Synthesis and characterization of novel guar gum hydrogels and their use as Cu sorbents

To prepare novel hydrogels for use in water technologies, guar gum was subjected to acid hydrolysis. The depolymerized guar gum obtained there from and the native guar gum were oxidized to their respective polycarboxylic forms using NO_x as oxidant. All these polymers were crosslinked with N,N-methylenebisacrylamide, and were used as Cu²⁺ sorbents. The candidate hydrogel exhibiting the highest uptake was used further to investigate the effect of external stimuli on sorption. The sorption on hydrogels was fast as the highest sorption was observed after 2 h at 40 °C and 20 ppm of Cu²⁺ ions. The hydrogel prepared from the oxidized guar gum afforded the maximum sorption capacity of 125.893 mg g⁻¹. Langmuir and Freundlich isotherms, and pseudo second order kinetics matches the experimental data. The evidence of sorption was obtained by characterizing Cu²⁺-loaded hydrogels by FTIR spectroscopy.     

Removal of chromium (VI) using poly(methylacrylate) functionalized guar gum

Using persulfate/ascorbic acid redox pair, poly(methylacrylate) was grafted on to guar gum and the conditions for the grafting were optimized. The copolymer sample having maximum %G was evaluated for the removal of Cr(VI) and the sorption conditions were optimized. The sorption was found pH dependent, pH 1.0 being the optimum value. Sorption data at pH 1.0 were modeled using both the Langmuir and Freundlich isotherms where the data fitted better to Freundlich isotherm. The equilibrium sorption capacity of 29.67 mg/g was determined from the Langmuir isotherm. The sorption followed a pseudo-second-order kinetics with a rate constant 2.5 × 10^?4 g mg^?1 min^?1. The grafted product was also evaluated for Cr(VI) removal from local electroplating industrial waste water. The regeneration experiments revealed that the guar-graft-poly(methylacrylate) could be successfully reused for five cycles. In the present study conductivity measurements were used instead of conventional photometric method for determining Cr(VI) concentration in the equilibrium solutions and the results obtained have been compared with photometric method. Optimum Cr(VI) binding under highly acidic conditions indicated significant contribution of non electrostatic forces in the adsorption process.     

Sorptive removal of Methylene blue from aqueous solution using palm kernel fibre: Effect of fibre dose

The use of palm kernel fibre, a readily available agricultural waste product for the sorption of Methylene blue from aqueous solution and the possible mechanism of sorption has been investigated at various fibre doses. The extent of dye removal and the rate of sorption were analyzed using two kinetic rate models (pseudo-first and pseudo-second-order kinetic models) and two diffusion models (intraparticle and external mass transfer models).

Analysis of the kinetic data at different sorbent dose revealed that the pseudo-first order kinetics fitted to the kinetic data only in the first 5 min of sorption and then deviated from the experimental data. The pseudo-second-order kinetic model was found to better fit the experimental data with high correlation coefficients at the various fibre dose used. The dye sorption was confirmed to follow the pseudo-second-order model by investigating the relationship between the amount of dye sorbed and the change in hydrogen ion concentration of the dye solution and also the dependence of dye uptake with solution temperature. It was found that the change in hydrogen ion concentration and increase in sorption temperature were directly related to the amount of dye sorbed, and activation energy was calculated to be −39.57 kJ/mol, indicating that the dye uptake is chemisorption, involving valence forces through sharing or exchange of electrons between sorbent and sorbate as covalent forces.

The intraparticle diffusion plots showed three sections indicating that intraparticle diffusion is not solely rate controlling. The intraparticle diffusion and mass transfer rate constants where observed to be well correlated with sorbent dose in the first 5 min of sorption, indicating sorption process is complex. It was found that at low sorbent dose the mass transfer is the main rate controlling parameter. However at high sorbent dose, intraparticle diffusion becomes rate controlling.     

The livelihood impacts of oil palm: smallholders in Indonesia

The biodiversity and climate consequences of oil palm (Elaeis guineensis) expansion across South East Asia have received considerable attention. The human side of the issue, highlighted with reports of negative livelihood outcomes and rights abuses by oil palm companies, has also led to controversy. Oil palm related conflicts have been widely documented in Indonesia yet uptake by farmers has also been extensive. An assessment of the livelihood impacts of oil palm development, including sources of conflict, is needed to shed light on the apparent contradiction between these reports and the evident enthusiasm of farmers to join the oil palm craze thereby informing future expansion. We assessed the impact of oil palm development on the economic wellbeing of rural farmers in Indonesia. We found that many smallholders have benefited substantially from the higher returns to land and labour afforded by oil palm but district authorities and smallholder cooperatives play key roles in the realisation of benefits. Conflicts between communities and companies have resulted almost entirely from lack of transparency, the absence of free, prior, and informed consent and unequal benefit sharing, and have been exacerbated by the absence of clear land rights. We make specific recommendations to improve the present situation and foster the establishment of smallholder friendly production regimes. Oil palm expansion in Indonesia is set to continue. If environmental standards can be raised and policy interventions targeted at the broader social impacts of land development this expansion may be achieved to the significant benefit of large numbers of rural smallholders.     

Removal of lead from aqueous solutions on palm shell activated carbon

The performance of a commercially available palm shell based activated carbon to remove lead ions from aqueous solutions by adsorption was evaluated. The adsorption experiments were carried out at pH 3.0 and 5.0. The effect of malonic and boric acid presence on the adsorption of lead ions was also studied. Palm shell activated carbon showed high adsorption capacity for lead ions, especially at pH 5 with an ultimate uptake of 95.2mg/g. This high uptake showed palm shell activated carbon as amongst the best adsorbents for lead ions. Boric acid presence did not affect significantly lead uptake, whereas malonic acid decreased it. The diffuse layer surface complexation model was applied to predict the extent of adsorption. The model prediction was found to be in concordance with the experimental values.     

Switching from monoculture to polyculture farming benefits birds in oil palm production landscapes: Evidence from mist netting data

Monoculture farming is pervasive in industrial oil palm agriculture, including those RSPO plantations certified as sustainably managed. This farming practice does not promote the maintenance of farmland biodiversity. However, little scientific attention has been given to polyculture farming in oil palm production landscapes. Polyculture farming is likely to increase the floristic diversity and stand structural complexity that underpins biodiversity. Mist nets were used to sample birds at 120 smallholdings in Peninsular Malaysia. At each site, 12 vegetation structure characteristics were measured. We compared bird species richness, abundance, and composition between monoculture and polyculture smallholdings and used predictive models to examine the effects of habitat quality on avian biodiversity. Bird species richness was significantly greater in polyculture than that of monoculture smallholdings. The number of fallen and standing, dead oil palms were also important positive predictors of species richness. Bird abundance was also strongly increased by standing and dead oil palms and decreased with oil palm stand height. Our results indicate that polyculture farming can improve bird species richness in oil palm production landscapes. In addition, key habitat variables that are closely associated with farming practices, such as the removal of dead trees, should and can be managed by oil palm growers in order to promote biodiversity. To increase the sustainability of oil palm agriculture, it is imperative that stakeholders modify the way oil palms are currently planted and managed. Our findings can guide policy makers and certification bodies to promote oil palm production landscapes that will function more sustainably and increase existing biodiversity of oil palm landscapes.     

Removal of oil by walnut shell media

Studies were conducted to evaluate the oil sorption capacities of walnut shell media. Sorption capacity is the weight of oil picked up by unit weight of a sorbent. Initial oil pick-up by walnut shell media on pure oil and oil on aqueous medium was evaluated. Batch kinetic studies were conducted to evaluate the equilibrium time required by walnut shell media for sorbing oil. For pure oil medium, sorption capacities of 0.30g/g, 0.51g/g and 0.58g/g were obtained for standard mineral oil, vegetable oil and DoALL Bright-Edge oil, respectively. The results showed sorption capacities of 0.56g/g, 0.58g/g and 0.74g/g for standard mineral oil, vegetable oil and DoALL Bright-Edge oil, respectively, for oil on aqueous medium. It was found that sorbed oil could be recovered from walnut shell media by applying pressure. The study showed that walnut shell media can be used as a sorbent for oil removal.     

Lipase-catalyzed methanolysis of palm oil in presence and absence of organic solvent for production of biodiesel

Enzymatic production of methyl esters (biodiesel) by methanolysis of palm oil in presence and absence of organic solvent was investigated using Candida antarctica lipase immobilized on acrylic resin as a biocatalyst. Although, at least molar equivalent of methanol (methanol-palm oil ratio 3:1) is required for the complete conversion of palm oil to methyl esters, lipase catalyzed methanolysis of palm oil in absence of organic solvent was poisoned by adding more than 1/3 molar equivalent of methanol. The use of polar organic solvents prevented the lipase to be poisoned in methanolysis with a molar equivalent of methanol, and tetrahydrofuran (THF) was found to be the most effective. The presence of water in methanolysis of palm oil both in presence and absence of THF inhibited the reaction rate but this inhibition was considerably low in THF containing system. The palm oil-lipase (w/w) ratio significantly influenced the activity of lipase and the optimal ratio in presence and absence of THF was 100 and 50, respectively.     

Pathogenicity of Fusarium oxysporum Isolates from Malaysia and F. oxysporuin f. sp. elaeidis from Africa to Seedlings of Oil Palms (Elaeis guineensis)

Pathogenicity tests with Fusarium oxysporum isolated form Malaysian oil palm were made with oil palms seedlings raised form Malaysian seed as well s with wilt-susceptible seedlings gown from African seed. Oil palm seedlings grown form Malaysian seed were also inoculated with African isolates of F. oxysporum f. sp. elaeidis and F. oxysporum var. redolens. The experiments were made under normal soil moisture conditions and under water stress. F. oxysporum f. sp. elaeidis isolates form Africa were pathogenic to oil palm seedlings from Malaysian seeds but the Malaysian F oxysporum isolates were non-pathogenic to plams grown from Malaysian seed or the wilt-susceptible palms from African seed. Seedlings from Malaysian seed proved to be highly susceptible to the vascular wilt disease caused by F. oxysporum f. sp. elaeidis as 75–90% of the palms were infected. The susceptibility of the palms from Malaysian seed varied with different African isolates tested. The Yaligimba isolate from Zaire which was found to be F. oxysporum var. redolens was the most virulent. Disease was more severe when oil palm seedlings were subjected to a period of water stress. The incidence of death in the seedlings under stress conditions was 45% as compared with only 15% for palms grown under normal conditions.     

Growth of oil palm (Elaeis guineensis) seedlings on acid sulfate soils as affected by water regime and aluminium

In Malaysia, acid sulfate soils contain high amounts of aluminium and are usually utilized for oil palm cultivation. As these soils are frequently flooded during rainy periods, it is thought that this may affect the growth performance of the oil palm. A glasshouse experiment was, therefore, conducted to study the effects of water regime and aluminium on the growth of oil palm seedlings. Soils used in the experiment were Typic Sulfaquepts and Sulfic Tropaquepts from Pulau Lumut Island, Malaysia. Best growth was observed on a non-jarositic freely drained topsoil. Oil palm seedlings were found the be moderately tolerant to soil acidity. Growth was only affected if Al³⁺ and Al_sum activities in the soil solutions were above 100 and 700 M, respectively. Root length was found to be one of the better parameters to predict crop growth, while others included plant height, fron length and LAI. Soil solution attributes which could be used as indices of soil acidity for oil palm growth were pH and activities of Al³⁺, AlSO₄ ⁺ and Al_sum.     

Biochemical characterisation during seed development of oil palm (Elaeis guineensis)

Developmental biochemical information is a vital base for the elucidation of seed physiology and metabolism. However, no data regarding the biochemical profile of oil palm (Elaeis guineensis Jacq.) seed development has been reported thus far. In this study, the biochemical changes in the developing oil palm seed were investigated to study their developmental pattern. The biochemical composition found in the seed differed significantly among the developmental stages. During early seed development, the water, hexose (glucose and fructose), calcium and manganese contents were present in significantly high levels compared to the late developmental stage. Remarkable changes in the biochemical composition were observed at 10 weeks after anthesis (WAA): the dry weight and sucrose content increased significantly, whereas the water content and hexose content declined. The switch from a high to low hexose/sucrose ratio could be used to identify the onset of the maturation phase. At the late stage, dramatic water loss occurred, whereas the content of storage reserves increased progressively. Lauric acid was the most abundant fatty acid found in oil palm seed starting from 10 WAA.     

Changes in photosynthetic activity in five common hybrids of oil palm (Elaeis guineensis Jacq.) seedlings under water deficit

The leaf water potential, gas-exchange parameters and chlorophyll fluorescence were evaluated in five common oil palm (Elaeis guineensis Jacq.) tenera hybrids 913X1988, 1425X2277, 748X1988, 7418X1988, and 690X1988 under water deficit with an aim to identify hybrids which can cope up better under such conditions and understand possible differences among hybrids in relation to the physiological mechanisms triggered by water deficit. Our findings indicate oil palm hybrids 913X1988, 1425X2277, and 7418X1988 maintained higher leaf water potentials than the other hybrids. Hybrids 7418X1988 and 1425X2277 recorded lower stomatal conductance after water deficit, which resulted in higher intrinsic water-use efficiency. The excess light energy produced due to decreased photosynthesis in 7418X1988 and 690X1988 hybrids under water deficit was dissipated as heat by higher nonphotochemical quenching. The maximum efficiency of photosystem II was not affected, even after withholding water for 24 days, suggesting an increased efficiency of photoprotection mechanisms in all these oil palm hybrids.     

Using Soil Water Depletion to Measure Spatial Distribution of Root Activity in Oil Palm (Elaeis guineensis Jacq.) Plantations

Knowledge of where roots are active is crucial for efficient management of nutrients in tree crops but measurement of root activity is problematic. Measurement using soil water depletion is an approach that has not been tested in a humid climate. We hypothesised that the three dimensional distribution of root activity of a tree crop in the humid tropics (a) can be determined by measuring soil water depletion during rain-free periods, and (b) is influenced by environment (soil type and climate) and surface management. A field study was carried out in which soil water content was measured and water uptake calculated (by difference between soil water content at beginning and end of rain-free periods) for different surface management zones and depths (0.1 m intervals to 1.6 m depth) under oil palm (Elaeis guineensis Jacq.) at a loam–clay site and a sandy site. Significant differences were measured between sites and between surface management zones at each site. At both sites water uptake was highest under the weeded zone close to the palm stem, slightly lower under the zone where pruned fronds are placed, and lowest under the path used for removing harvested fruit. Vertical distribution of root activity differed between the sites, with higher activity near the surface at the finer textured site. Total water uptake values were lower than estimates of evapotranspiration made using climate data. The difference was probably largely due to water uptake from deeper than 1.6 m. This study showed that the spatial distribution of tree root activity in a humid climate could be quantified using a relatively simple method.     

Comprehensive Analysis of Lipid Composition in Crude Palm Oil Using Multiple Lipidomic Approaches

Palm oil is currently the leading edible oil consumed worldwide. Triacylglycerol （TAG） and diacylglycerol （DAG） are the dominant lipid classes in palm oil. Other lipid classes present in crude palm oil, such as phospholipids and galactolipids, are very low in abundance. These low-abundance lipids constitute key intermediates in lipid biosynthesis. In this study, we applied multiple lipidomic approaches, including high-sensitivity and high-specificity multiple reaction monitoring, to comprehensively quantify individual lipid species in crude palm oil. We also established a new liquid chromatography-coupled mass spectrometry method that allows direct quantification of low-abundance galactolipids in palm oil without the need for sample pretreatrnent. As crude palm oil contains large amounts of neutral lipids, our direct-detection method circumvents many of the challenges encountered with conventional lipid quantification methods. This approach allows direct measurement of lipids with no hassle during sample preparation and is more accurate and precise compared with other methods.     

Synthesis and characterization of gum acacia inspired silica hybrid xerogels for mercury(II) adsorption

In a sol-gel process, gum acacia inspired silica xerogels have been synthesized from tetraethylorthosilicate. Besides showing photoluminescence under ultraviolet excitation, the hybrid xerogels were very efficient in capturing mercury(II) from synthetic solution. To synthesize the optimum sample (in terms of Hg(II) uptake), different ratios of H(2)O:TEOS:EtOH were taken at fixed GA and catalyst concentrations where 4:1:1 ratio was found to be most favorable. Calcination in air further enhanced the mercury binding capacity of this sample. Optimum sample (H4) was obtained on calcination of the gel at 600°C. The hybrids have been structurally characterized using Infrared spectroscopy, X-ray diffraction, scanning electron microscopy, thermo gravimetric analysis, photoluminescence spectroscopy and Brunauer-Emmett-Teller analysis. In a preliminary batch adsorption experiment, H4 was evaluated to be highly efficient in the removal Hg(II) from synthetic aqueous solution.     

Irradiation depolymerized guar gum as partial replacement of gum Arabic for microencapsulation of mint oil

Spray dried microcapsules of mint oil were prepared using gum Arabic alone and its blends with radiation or enzymatically depolymerized guar gum as wall materials. Microcapsules were evaluated for retention of mint oil during 8-week storage during which qualitative changes in encapsulated mint oil was monitored using principal component analysis. The microcapsules with radiation depolymerized guar gum as wall material component could better retain major mint oil compounds such as menthol and isomenthol. The t(1/2) calculated for mint oil in microcapsules of gum Arabic, gum Arabic:radiation depolymerized guar gum (90:10), gum Arabic:enzyme depolymerized guar gum (90:10) was 25.66, 38.50, and 17.11 weeks, respectively. The results suggested a combination of radiation depolymerized guar gum and gum Arabic to show better retention of encapsulated flavour than gum Arabic alone as wall material.     

Effects of dietary palm oil on serum lipid peroxidation, antithrombin III, plasma cyclic AMP, and platelet aggregation.

Intravascular thrombus formation in association with lipid depositions in the arterial wall is thought to be involved in the process of atheroma formation. We have previously shown the beneficial effect of palm oil on the serum lipid profile resulting in a lowering of serum triacylglycerol and an elevation of the HDL/LDL ratio. The present study investigates the effect of dietary palm oil on the biochemical parameters associated with clotting and platelet aggregation in young rats (70 g body wt) fed a palm oil diet over a period of 10 weeks. Palm oil-fed rats showed significantly lower levels of fibrinogen and serum lipid peroxide and elevated AtIII levels resulting in a prolongation of clotting time. Reduced platelet aggregation and ATP release associated with a prolongation of bleeding time were also found. These findings, together with our earlier findings on the effect of palm oil on the serum lipid profile, suggest that dietary palm oil may be antithrombotic as well as beneficial in preventing the deposition of lipids on the vessel wall and may, therefore, be protective against the development of atherosclerosis.     

Properties and Antioxidant Action of Actives Cassava Starch Films Incorporated with Green Tea and Palm Oil Extracts

There is an interest in the development of an antioxidant packaging fully biodegradable to increase the shelf life of food products. An active film from cassava starch bio-based, incorporated with aqueous green tea extract and oil palm colorant was developed packaging. The effects of additives on the film properties were determined by measuring mechanical, barrier and thermal properties using a response surface methodology design experiment. The bio-based films were used to pack butter (maintained for 45 days) under accelerated oxidation conditions. The antioxidant action of the active films was evaluated by analyzing the peroxide index, total carotenoids, and total polyphenol. The same analysis also evaluated unpacked butter, packed in films without additives and butter packed in LDPE films, as controls. The results suggested that incorporation of the antioxidants extracts tensile strength and water vapor barrier properties (15 times lower) compared to control without additives. A lower peroxide index (231.57%), which was significantly different from that of the control (p<0.05), was detected in products packed in film formulations containing average concentration of green tea extracts and high concentration of colorant. However, it was found that the high content of polyphenols in green tea extract can be acted as a pro-oxidant agent, which suggests that the use of high concentration should be avoided as additives for films. These results support the applicability of a green tea extract and oil palm carotenoics colorant in starch films totally biodegradable and the use of these materials in active packaging of the fatty products.     

Energy and nutrient use of palm kernels, palm kernel meal and palm kernel oil in diets for growing pigs

A metabolism experiment was conducted with 13 gilts over four periods to investigate the effects of age or weight of pigs, level of inclusion and methods of estimation of apparent digestible (DE) and metabolizable (ME) energy and nutrient digestibility of full-fat palm kernels (FFPK), recombined palm kernel oil and meal (OPKM) and palm kernel oil (PKO). Each palm kernel product was evaluated at levels equivalent to added oil of 40, 80 and 120 g kg⁻¹ in a basal diet. Extracted palm kernel meal (PKM) was also evaluated in the basal diet at the same level as in OPKM. Thus, 13 treatments arranged in four blocks (time periods) constituted the experimental data analysed using a randomised complete block design. Digestible energy and ME contents and apparent digestibility of nitrogen (ADN), dry matter (ADD) and oil (AOD - employing two oil analytical methods) of palm kernel products were estimated by single level assay and by regression with the latter yielding DE values of 40.2, 19.5, 22.1 and 13.1 MJ/kg DM for PKO, FFPK, OPKM and PKM, respectively. The corresponding values for AOD were 1.08, 0.93, 1.03 and 0.88. While the level of inclusion and pig weight (over the range 40–76 kg) did not significantly affect dietary energy and nutrient digestibility of palm kernel products, the form of oil inclusion had considerable effect with OPKM being better utilized than FFPK. Digestibility of oil in the palm kernel products measured by the ether extract (EE) method was, in general, significantly higher than that estimated by the acid ether extract (AEE) procedure. The results suggest the necessity for digestibility coefficients of oils and fats in oil bearing ingredients to be re-evaluated in the light of the currently applied analytical method as figures obtained using the traditional ether extract method may not be applicable to the true nutritional value of feed ingredients and consequently may lead to imprecise diet formulation.     

Kinetics and mechanism of methylene blue sorption onto palm kernel fibre

The kinetics and mechanism of the sorptive removal of methylene blue dye from aqueous solution using palm kernel fibre as adsorbent have been investigated. Batch kinetic experiments were performed and system variables investigated includes pH and initial dye concentration. The kinetic data were fitted to the pseudo-first, pseudo-second, intraparticle diffusion and mass transfer models. The pseudo-first order reaction kinetics fitted to the experimental data only in the first 5 min of sorption and then deviated, while the pseudo-second order kinetic model was found to fit the experimental data for the entire sorption period with high coefficient of determination. Equations were developed using the pseudo-second order model, which predicts the amounts of methylene blue at any contact time and initial concentration within the given range. This suggests that the sorption of methylene blue onto palm kernel fibre follows a chemical activation mechanism. A mathematical relationship was also drawn between the equilibrium sorption capacity and the change in pH (ΔH⁺) at the end of the kinetic experiments with varying initial dye concentration, supporting the fact that chemical reaction (ion exchange) occurred and is important in the rate determining step. Mass transfer was found to be favoured at high concentrations while intraparticle diffusion was favoured at low concentrations.