Survey of Vietnamese coffee beans for the presence of ochratoxigenic Aspergilli

Vietnamese coffee beans were investigated for the presence of ochratoxigenic Aspergilli. Ninety-three percent of the coffee samples studied were positive for A. niger. No other ochratoxigenic species were present. HPLC analysis determined that 8.7% of the A. niger strains were positive for ochratoxin A (OA) production. There was no significant difference in the level of contamination or incidence of toxigenic strains in samples that had been rejected by manual sorting and those that were destined for human consumption. No OA-producing fungi were uncovered in a fresh coffee bean sample analysed, suggesting that the OA problem most likely occurs post-harvest.     

Isolation and identification of ochratoxin A-producing Aspergillus section Nigri strains from California raisins

Aims: To determine incidence and levels of ochratoxin A (OTA) in California raisins and to isolate and characterize OTA‐producing fungi from California raisin vineyard populations. Methods and Results: Forty raisin clusters sampled from four California vineyards in the San Joaquin Valley were analysed for OTA content using immunoaffinity and HPLC methods. OTA was detected in 93% of the samples, at levels from 0·06 to 11·4 ng g^?1. From these raisin samples, a total of 400 strains of Aspergillus were isolated and analysed for OTA production. Twelve isolates (3%), from five raisin samples, produced OTA. These isolates were identified as Aspergillus carbonarius, based on morphological characteristics and multilocus sequence analysis. Levels of OTA produced by these isolates on raisin agar ranged from 0·9 to 15 μg g^?1. Conclusions: OTA is a common contaminant of raisin vineyards, but average levels are much lower than EU regulatory limits for dried fruit. The primary species responsible for OTA contamination in California raisins is A. carbonarius. Significance and Impact of the Study: This study illustrates that low‐level OTA contamination of raisins occurs in California and that ecological studies of A. carbonarius within the Aspergillus section Nigri population on raisins are warranted to monitor ochratoxigenic potential of the crop.     

Aspergillus niger and Aspergillus carbonarius in Corinth Raisin and Wine-Producing Vineyards in Greece: Population Composition, Ochratoxin A Production and Chemical Control

Vineyard surveys of Corinth raisin cultivar carried out in the Peloponnese region of Greece during 2002 and of wine‐producing grape cultivars (Cabernet Sauvignon and Grenache Rouge) on the island of Rhodes, Greece, during 2003, demonstrated the occurrence of various Aspergillus spp. in berries of bunches at harvest. Aspergillus niger and A. carbonarius were predominantly isolated from sampled berries. Although the prevailing Aspergillus spp. isolates belonged mainly to A. niger aggregate, isolates of A. carbonarius were by far the most efficient Ochratoxin A (OTA) producers as revealed by the enzyme‐linked immunosorbent assay test. This study provides the first evidence concerning the composition of Aspergillus populations in raisin and wine‐producing vineyards and offers convincing data for their ability to produce various levels of OTA in Corinth raisins and wine‐producing grapes in Greece. Furthermore, it demonstrates that chemical applications with the fungicide Switch, especially under low to intermediate Aspergillus infection of vineyards, could both significantly reduce the occurrence of OTA‐producing Aspergillus spp. and restrict sour rot severity. In contrast, vineyard applications with the fungicides Carbendazim or Chorus were ineffective in controlling the fungus in Corinth raisin cultivar.     

Method validation for the determination of ochratoxin A in green and soluble coffee by immunoaffinity column cleanup and liquid chromatography

A method was validated for the determination of ochratoxin A (OTA) in soluble and green coffee. Performance parameters evaluated included selectivity, accuracy, intermediate precision, linearity, limit of detection, limit of quantitation, and ruggedness. The method was found to be selective for OTA in both matrices tested. Recovery rates from soluble coffee samples ranged from 73.5 to 91.2%, and from green coffee samples from 68.7 to 84.5%. The intermediate precision (RSDr) was between 9.1 and 9.4% for soluble coffee and between 14.3 and 15.5% for green coffee analysis. The linearity of the standard calibration curve (r²) was <0.999 for OTA levels of 1.0–20.0 μg/kg in coffee samples. The limit of detection was determined to be 0.01 ng of OTA on column, while the limit of quantitation was found to be 0.03 ng on column. The limit of quantitation is equivalent to 0.6 μg/kg in soluble coffee samples and 0.3 μg/kg in green coffee samples. The results of the ruggedness trial showed two factors are critical for soluble coffee analysis: the extraction method, and the flow rate of the mobile phase. For green coffee analysis two critical factors detected were the extraction method and the storage temperature of the immunoaffinity column. Five samples of soluble coffee and 42 of green coffee were analysed using the validated method. All soluble coffee samples contained OTA at levels that ranged from 8.4 to 13.9 μg/kg. Six of the 42 green coffee samples analysed (14.3%) contained OTA at levels ranging from 0.9 to 19.4 μg/kg. The validated method can be used to monitor OTA levels in Colombian coffee for export or for local consumption.     

Mycelial growth and ochratoxin A production by Aspergillus section Nigri on simulated grape medium in modified atmospheres

Aims:  To evaluate the impact of modified atmosphere packaging on in vitro growth of Aspergillus carbonarius and Aspergillus niger , and possible effects on ochratoxin A (OTA) biosynthesis.
Methods and Results:  Ochratoxigenic isolates belonging to the species A. carbonarius and A. niger were grown on a synthetic grapejuice medium (SNM) and packaged in combinations of controlled O₂ (1% and 5%) and CO₂ levels (0% and 15%), and in air as a control. Colony diameters were recorded every 3 days up to 21 days, and OTA was analysed after 7, 14 and 21 days. The greatest reductions in mycelial growth rate were observed at 1% O₂ followed by 1% O₂/15% CO₂, whereas 5% O₂ stimulated the growth of all isolates. OTA production by A. carbonarius and A. niger isolates was minimized at 1% O₂/15% CO₂ and 1% O₂, respectively, after 7 days of incubation. Maximal OTA accumulation after 7 days was observed for all isolates in the control pack and at 5% O₂.
Conclusions:  Of the atmospheres tested, only 1% O₂ combined with 15% CO₂ consistently reduced fungal growth and OTA synthesis by A. carbonarius and A. niger .
Significance and Impact of the Study:  Storage under modified atmospheres is unlikely to be suitable as the sole method for OTA minimization and grape preservation; other inhibitory factors are necessary.     

Utilization of AFLP markers for PCR-based identification of Aspergillus carbonarius and indication of its presence in green coffee samples

AIMS: The objective of this work was to test whether ochratoxin A (OTA) production of Aspergillus niger and A. carbonarius is linked to a certain genotype and to identify marker sequences with diagnostic value aiding identification of A. carbonarius, a fungus of major concern regarding OTA production in food and food raw materials. METHODS AND RESULTS: Aspergillus niger and A. carbonarius were isolated mainly from Brazilian coffee sources. The ability of isolates to produce OTA was tested by thin layer chromatography (TLC). Strains were genetically characterized by AFLP fingerprinting and compared with each other and with reference strains. Cluster analysis of fingerprints showed clear separation of A. niger from A. carbonarius strains. To obtain marker sequences, AFLP fragments were isolated from silver stained polyacrylamide gels, cloned and sequenced. Sequences obtained were used to develop species- specific PCR primers for the identification of A. carbonarius in pure culture and in artificially and naturally infected samples of green coffee. CONCLUSIONS: No clear correlation between genetic similarity of the strains studied and their potential to produce OTA was found. The PCR assays designed are a useful and specific tool for identification and highly sensitive detection of A. carbonarius. SIGNIFICANCE AND IMPACT OF THE STUDY: The developed PCR assays allow specific and sensitive detection and identification of A. carbonarius, a fungus considered to be one of the major causative agents for OTA in coffee and grape-derived products. Assays may provide powerful tools to improve quality control and consumer safety in the food processing industry.     

Aspergillus species producing ochratoxin A: isolation from vineyard soils and infection of Semillon bunches in Australia

AIMS: The incidence of toxigenicity among Australian isolates of Aspergillus niger and Aspergillus carbonarius was assessed. Aspergillus rot and concomitant production of ochratoxin A (OA) in bunches inoculated with A. carbonarius were also investigated. METHODS AND RESULTS: Aspergillus niger and A. carbonarius were isolated from vineyard soils. Aspergillus niger was more widespread than A. carbonarius, and two restriction fragment length polymorphism types of A. niger, N and T, were present. Three of 113 A. niger isolates and all 33 A. carbonarius isolates produced OA. Aspergillus carbonarius was inoculated onto Semillon bunches with and without damage in the month before harvest. Damaged berries at greater than 12.3 (o) Bx were particularly susceptible to Aspergillus rot and production of OA, which was concentrated in severely mouldy berries. CONCLUSIONS: OA in Australian grapes results mainly from infection of berries by A. carbonarius. It is concentrated in discoloured, shrivelled berries. The potential for Aspergillus rot and OA production appears to commence after veraison and increase with berry damage and ripeness. SIGNIFICANCE AND IMPACT OF THE STUDY: Minimizing damage to grapes between veraison and harvest significantly reduces Aspergillus rot and OA formation. Monitoring the extent of Aspergillus rot in bunches infected with toxigenic Aspergillus spp. may give some indication of OA contamination.     

Effect of roasting on ochratoxin A level in green coffee beans inoculated with Aspergillus ochraceus

The heat stability of ochratoxin A in green coffee beans inoculated with Aspergillus ochraceus was studied. Heat treatment (roasting) at 200 °C for 10 or 20 min reduced the levels of ochratoxin A by only 0–12% in the dried whole beans. Almost all of the ochratoxin A was infused into the coffee decoction when the roasted samples were ground and extracted with boiling water. Therefore, the reduction of ochratoxin A concentration of contaminated coffee beans by roasting under these conditions is ineffective.     

Isolation and characterization of six polymorphic microsatellite loci in Aspergillus niger

Certain strains of Aspergillus niger produce ochratoxin A in food and in animal feeds. Six polymorphic microsatellite markers suitable for population analysis were developed for A. niger through screening published sequences for microsatellite repeats. Polymorphism was evaluated for 28 isolates of A. niger, including toxigenic strains. Loci displayed six to 13 alleles. Investigation of cross‐species amplifications with Aspergillus carbonarius and Aspergillus japonicus showed limited success.     

Ochratoxin A-producing species in grapes and sun-dried grapes and their relation to ecophysiological factors

AIMS: To explain the dominance of OTA-producing fungal species in sun-dried grapes for special wine production through an ecophysiological approach. METHODS AND RESULTS: Grapes at different ripening stages, sun-dried grapes and raisins were analysed for fungal presence, and isolates identified. Aspergillus section Nigri incidence in grapes increased with grape maturation. In the ecophysiological study five isolates (Alternaria alternata, Cladosporium herbarum, Penicillium decumbens, Aspergillus carbonarius, A. niger aggregate and A. section Nigri uniseriate) were inoculated in SNM medium at four a(w) (0.82-0.97) and incubated at 20, 30 and 40 degrees C for 18 d. Isolates were also inoculated in pairs to evaluate fungal interactions recording their growth rates and indexes of dominance. Aspergillus section Nigri grew in a wider range of temperature and a(w), had higher growth rates than the others under most of the conditions tested and showed behaviour usually dominant. CONCLUSIONS: The presence of A. section Nigri is predominant in grapes during harvesting and sun-drying period likely because of a better adaptation to hot and humid environment. SIGNIFICANCE AND IMPACT OF THE STUDY: The duration of the drying period should be reduced as much as possible without compromising the quality of the final product, or drying the grapes in controlled chambers with dry hot air flow.     

Brief in vitro study on Botrytis cinerea and Aspergillus carbonarius regarding growth and ochratoxin A

Aims: To evaluate the effect of Botrytis cinerea growth on ochratoxin A (OTA) production by Aspergillus carbonarius and degradation. Methods and Results: OTA‐producing A. carbonarius and B. cinerea were grown on grape‐like medium at 20°C for 7 days. Radii of colonies were daily recorded and OTA was analysed. In addition, each B. cinerea isolate was inoculated on grape‐like synthetic nutrient medium (SNM) paired with each A. carbonarius isolate at a distance of 45 mm. Botrytis cinerea isolates were also grown in OTA‐spiked SNM. Growth rates of B. cinerea and A. carbonarius were 20 and 7·5 mm day^?1, respectively. The growth of the colonies of each species stopped when they contacted each other in paired cultures. OTA production by A. carbonarius in the contact area was affected by B. cinerea, but no clear trend was observed. All B. cinerea isolates showed to degrade between 24·2% and 26·7% of OTA from spiked SNM. Conclusions: The ecological advantage of B. cinerea, in terms of growth rate, vs. OTA‐producing Aspergillus in some wine‐growing regions and its ability to degrade OTA may explain the low levels of this toxin in noble wines. Significance and Impact of the Study: At determinate conditions, the presence of B. cinerea in grapes with A. carbonarius may help in reducing OTA accumulation.     

Antifungal and physicochemical properties of Ocimum essential oil loaded in poly(lactic acid) nanofibers

Poly(lactic acid) (PLA) nanofibres containing different proportions of the essential oils from Ocimum basilicum L. and Ocimum gratissimum L. were prepared by solution blow spinning method. The essential oils were extracted by hydrodistillation and characterized by gas chromatography. MEV, contact angle, DSC and FTIR were used to characterize the nanofibres. The effect of bioative nanofibres on the growth of the fungus and on the production of ochratoxin A were evaluated using the fumigation test. Linalool, 1·8-cineole and camphor were the principal components of the essential oil from O. basilicum, and eugenol was the principal constituent in the oil from O. gratissimum. An increase in the average diameter of the nanofibres was observed with the addition of the essential oils. The essential oils acted as a plasticizer, resulting in a reduction in the crystallinity of the PLA. The encapsulation of essential oils in PLA nanofibres was verified by FTIR. An effective antifungal and antimicotoxygenic activity against Aspergillus ochraceus and Aspergillus westerdjikiae was observed for the bioative nanofibres. These results confirm the potential of PLA nanofibres containing the essential oils for the control of toxigenic fungi that cause the deterioration of food and are harmful to human health.     

Specific detection of Aspergillus carbonarius by SYBR® Green and TaqMan® quantitative PCR assays based on the multicopy ITS2 region of the rRNA gene

Agroproducts contaminated by ochratoxin A (OTA) represent a risk for human and animal health and, therefore, maximum limits have been established by Food Safety Authorities. Reduction of OTA contamination may be accomplished by early detection of OTA-producing fungal species using rapid, specific and sensitive detection and quantification by PCR-based methods. Aspergillus carbonarius is one of the most important OTA-producing species, in particular in grapes and derivatives from Mediterranean regions. In this work, highly efficient quantitative PCR assays using SYBR Green I and TaqMan methods were developed for specific detection of A. carbonarius to be used in grapes. The primers and the TaqMan probe were based on the internal transcribed region 2 multicopy region (internal 2 sequence of the rRNA gene). The specificity and sensitivity of both assays were tested on genomic DNA mixtures of several A. carbonarius strains and other fungal species frequently present in grapes. Both methods were also compared using grapes inoculated with different spore concentrations of A. carbonarius , detecting up to 0.4 pg DNA g⁻¹ grape berries. The efficiency and sensitivity of both methods were comparable and only the lower cost of SYBR Green might favour its use in routine screenings.     

Partitioning of ochratoxin A in mycelium and conidia of Aspergillus carbonarius and the impact on toxin contamination of grapes and wine

AIMS: Aspergillus carbonarius is an important ochratoxin A (OTA)-producing fungus which is responsible for toxin contamination of grapes and wine. The objectives of this study were to examine the partitioning of OTA in mycelium and conidia of a range of A. carbonarius strains on artificial grape juice and defined media, to determine the excretion patterns of OTA from these spores, and the effect of organic acids used in wine production on OTA excretion from conidia. METHODS AND RESULTS: The results showed that 60-70% of the OTA was accumulated in the conidia of a number of different isolates of A. carbonarius. Calculations showed that on different defined media, an amount of 0.011- to 0.1-pg OTA was present per conidium. The OTA in spores was found to be rapidly excreted into the medium during the initial few hours after conidial germination leading to an increase of OTA in must during maceration for wine production. The presence of tartaric acid inhibited OTA production, but malic acid enhanced this production during mycelial growth. These acids were also shown to affect the time course of germination and the rate of OTA excretion from conidia during germination. CONCLUSIONS: This study is the first to examine and show the partitioning of OTA into spores of strains of A. carbonarius and that rapid excretion of OTA from spores could be a reason for OTA accumulation in musts during wine production. SIGNIFICANCE AND IMPACT OF THE STUDY: Conidia of A. carbonarius could be a major source of OTA contamination of grapes used in wine production. This information could help in the development of effective prevention strategies to minimize wine contamination with this important mycotoxin.     

Coffee polyphenols extracted from green coffee beans improve skin properties and microcirculatory function

Coffee polyphenols (CPPs), including chlorogenic acid, exert various physiological activities. The purpose of this study was to investigate the effects of CPPs on skin properties and microcirculatory function in humans. In this double-blind, placebo-controlled study, 49 female subjects with mildly xerotic skin received either a test beverage containing CPPs (270 mg/100 mL/day) or a placebo beverage for 8 weeks. The ingestion of CPPs significantly lowered the clinical scores for skin dryness, decreased transepidermal water loss, skin surface pH, and increased stratum corneum hydration and the responsiveness of skin blood flow during local warming. Moreover, the amounts of free fatty acids and lactic acid in the stratum corneum significantly increased after the ingestion of CPPs. These results suggest that an 8-week intake of CPPs improve skin permeability barrier function and hydration, with a concomitant improvement in microcirculatory function, leading to efficacy in the alleviation of mildly xerotic skin.     

一株产赭曲霉毒素A黑曲霉的筛选与鉴定

【目的】筛选出可产生赭曲霉毒素A (OTA)的霉菌菌株。【方法】利用CYA和YES培养基从实验室32个霉菌样品中筛选目的菌株。利用高效液相色谱-荧光检测法对OTA产生菌进行初筛,利用高效液相色谱-质谱联用对OTA初筛菌株进行复筛。通过菌落形态、菌丝及分生孢子形态、ITS DNA序列、β-Tubulin基因序列及Calmodulin基因序列分析等鉴定目的菌株。【结果】得到一株OTA产生菌株1062,该菌株能在25 °C条件下,在CYA、YES和CA培养基中很好生长。结合形态学、对培养基的要求以及上述3个基因序列的进化树分析,该菌株属于黑曲霉(Aspergillus niger)。【结论】菌株1062具有OTA产生能力,是一株黑曲霉。     

Effects of water activity and temperature on the survival of Aspergillus carbonarius spores in vitro

AIMS: To determine the effect of water activity (a(w)) and temperature on the survival of Aspergillus carbonarius spores. METHODS AND RESULTS: Spores of A. carbonarius were dried onto filter membranes. These filters were held at 1.0, 0.9, 0.8, 0.6 and 0.4 a(w) and at 1, 15, 25 and 37 degrees C for up to 618 d. At intervals, spores were recovered from filters and assessed for viability by enumeration on dichloran rose bengal chloramphenicol agar. Survival and subsequent growth of spores was prolonged at low temperatures and at a(w) below 0.6. Above 15 degrees C, 0.6-0.9 a(w) were often more deleterious than 1.0. However, at 1 degrees C and 1.0 a(w), spores lost viability more rapidly than at lower a(w). CONCLUSIONS: Increased incidence of black Aspergillus spp. in dry soils and from grapes in dry conditions may result partly from prolonged survival of spores. SIGNIFICANCE AND IMPACT OF THE STUDY: Delineating the direct effect of a(w) and temperature on survival of A. carbonarius spores may aid in understanding the incidence of this ochratoxin A-producing species in vineyard soils and on grapes.     

Fungi and ochratoxin A detected in healthy grapes for wine production

AIMS: The mycoflora of healthy grapes (i.e. without visible symptoms of rot) for wine production in Portuguese wine-making regions was assessed and its potential for ochratoxin A (OTA) production evaluated. The OTA content of grapes was also determined. METHODS AND RESULTS: A total of 386 fungal strains were isolated by plating methods. The most frequent genera found in grapes were non-ochratoxigenic species: Cladosporium (28%), Penicillium (24%), Botrytis (13%) and Aspergillus (9%). Two OTA-producing strains were isolated, belonging to the species Aspergillus carbonarius and Aspergillus ochraceus. OTA was detected in three of four grape samples, up to 116 ng l(-1). CONCLUSIONS: OTA is being produced in healthy berries by Aspergillus species, namely A. carbonarius, at levels below the maximum recommended limit of 2,000 ng l(-1) in wine. SIGNIFICANCE AND IMPACT OF THE STUDY: The OTA concentration detected in healthy Portuguese grapes does not represent a risk to wine regarding the legal limit established.