万古霉素产生菌发酵培养基及发酵条件的优化

通过单因素分析和正交试验,对万古霉素产生菌的发酵培养基和发酵条件进行了研究,确定最佳的发酵培养基配方为葡萄糖2.0%,淀粉3.0%,豆粕1.8%,大豆粉2.2%,氯化钠0.2%,碳酸钙0.2%,与原培养基配方相比,优化后万古霉素的摇瓶发酵效价提高了11.2%。同时优化了部分发酵条件,即二级种接种量为10%,溶氧为摇床转速220 r/min时250 mL摇瓶装液量为25 mL。将优化后的发酵工艺进罐验证,其保持了较高的适应性和连续性。     

吸水链霉菌NND-52-C菌株产阿扎霉素B 发酵条件的优化

通过碳源、氮源的单因子实验和正交实验,确定了吸水链霉菌NND-52-C菌株产阿扎霉素B最佳的液体发酵培养基组分(%,质量分数)甘油4.5,玉米粉3,黄豆粉1,蛋白胨1,NaNO30.5,NaCl 0.2,CaCO3 0.3,MgSO4·7H2 O0.05,FeSO4 0.05,PH 7.5;阿扎霉素B最佳的发酵条件发酵前期温度30℃,起始pH 7.5;发酵后期温度28℃,pH6.8;接种量10%,装液量30 mL/250mL摇瓶,发酵时间5 d,最终阿扎霉素B的产量达到l 434 mg/L,比原配方以及原发酵条件提高了76%.     

纳他霉素发酵培养基及发酵条件的优化

采用Plackett-Burman法、最陡爬坡实验和响应面实验(Box-Behnken设计法)相结合的方法对褐黄孢链霉菌合成纳他霉素的发酵培养基及发酵条件进行优化。结果表明,培养基中的蛋白胨、pH和摇瓶装液量是影响纳他霉素产量的主要因素。优化后的培养基组成为葡萄糖50 g/L、蛋白胨19.5 g/L、酵母粉7 g/L、pH 7.4~7.5;发酵条件为装液量60 mL/500 mL、接种量15%、发酵温度29℃、摇床转速200 r/min、发酵周期96 h。此条件下,纳他霉素的产量较优化前提高了94%,达到2.19 g/L。     

赭曲霉的高密度培养对坎利酮转化的影响

目的:研究赭曲霉高密度培养的发酵培养基及条件,实现坎利酮的高转化.方法:选取廉价易得的培养基成分并进行优化,同时对发酵条件进行优化,得到了最优发酵培养基配方及培养条件.结果:发酵培养基最优配方为:葡萄糖20g/L,玉米浆20g/L,酵母膏20g/L,K2HPO4 2.5g/L.种子液最佳培养时间为24h,发酵培养基初始pH 5.8,接种量为8%,装液量200mL/1000mL,摇床转速为180 r/min,28℃,底物投料时间24h,发酵结束时间72 h.结论:将该工艺在7L发酵罐中放大,菌体密度达到25.36g/L,11α羟基坎利酮的转化率为86.1%.     

桔青霉生产核酸酶的发酵条件研究

对通过紫外线和60Co两次育种得到的桔青霉W48高产菌株培养基的单组分和发酵条件进行了优化,最后又用正交实验对培养基的各组分的浓度进行了优化。得到了产酶量最高的培养基组分(质量分数)是:KH2PO40.05%,K2HPO40.03%,酵母膏+蛋白胨0.7%,CaCl20.02%,MgSO40.04%,ZnSO40.03%,葡萄糖5%,pH5.5。最佳发酵条件是:接种量10%,装液量50 mL,摇床转速180 r/min,温度30℃,发酵时间66 h。用最佳培养基和最佳发酵条件发酵生产核酸酶的酶活力为758.10 U/mL,原始菌种产核酸酶的酶活力为272.26 U/mL,提高了2.78倍。     

解淀粉芽胞杆菌PC2产抑菌物质培养基及发酵条件优化

【目的】优化解淀粉芽胞杆菌PC2产抑菌活性物质发酵培养基及发酵条件。【方法】以马铃薯葡萄糖液体培养基为基础,依据发酵液对金黄色葡萄球菌抑菌圈的单因素试验结果,采用Box-Behnken响应面法优化发酵培养基,二次通用旋转组合设计,频率分析法优化发酵条件。【结果】影响发酵液抑菌活性的培养基主要组分为马铃薯、蔗糖和L-谷氨酸钠,最优发酵培养基配方为:马铃薯188.0 g/L,蔗糖22.0 g/L,L-谷氨酸钠1.80 g/L,培养基成本为0.81元/L;最佳发酵条件为:接种量6%、发酵温度30°C、装液量40 mL/250 mL、摇床转速185 r/min、发酵时间24 h、初始pH 7.0。优化后发酵液对金黄色葡萄球菌抑菌圈直径为30.82 mm,较优化前的18.22 mm增加了12.60 mm。【结论】优化后的培养基和发酵条件提高了解淀粉芽胞杆菌PC2发酵液的抑菌活性,为该菌株的工业化生产应用提供了依据。     

毛头鬼伞富铬深层发酵条件的优化

在筛选出最佳发酵培养基的基础上,对毛头鬼伞富铬深层发酵培养条件进行了优化。以有机铬产量为主要指标,筛选出的最佳发酵培养条件为:CrCl3·6H2O的添加量为200mg/L,培养基初始为自然pH,接种量为8%~10%,装液量为80mL/250mL三角瓶,转速100r/min,26℃恒温培养5d,有机铬的产量达1597·88μg/100mL发酵液,铬富集率达9·09%。     

粘质沙雷氏菌产几丁质酶发酵条件的研究

目的：通过对粘质沙雷氏菌发酵条件的优化,提高其产几丁质酶的能力。方法：以实验室保存菌种粘质沙雷氏菌S418为对象,通过单因素试验和三因素三水平正交试验筛选出了菌株S418产几丁质酶的最佳培养基配方及培养条件。结果：该菌种产酶的最佳发酵条件：0.2%（w/v）胶体几丁质,1%蛋白胨,0.05%KH2PO4,在28℃、pH7.0、接种量6%,培养72h,酶活达到5.49U/mL。结论：优化后菌株S418产几丁质酶的条件。     

毛头鬼伞富铬深层发酵条件的优化*

在筛选出最佳发酵培养基的基础上,对毛头鬼伞富铬深层发酵培养条件进行了优化。以有机铬产量为主要指标,筛选出的最佳发酵培养条件为:CrCl₃·6H₂O的添加量为200mg/L,培养基初始为自然pH,接种量为8%~10%,装液量为80mL/250mL三角瓶,转速100r/min,26℃恒温培养5d,有机铬的产量达1597.88μg/100mL发酵液,铬富集率达9.09%。     

海洋Cellulophaga sp.QY201产生L-卡拉胶酶的发酵条件优化

目的:通过发酵条件优化,提高海洋Cellulophaga sp.QY201的L-卡拉胶酶产量.方法:采用正交试验分别时发酵条件、培养基配方进行优化.结果:该茵株最适培养基配方为(w/v):3%NaCl、0.5%MgSO4·7H2O、0.02%CaCl2、0.01%KCl、0.002%FeSO4、0.25%CaSein、0.15%Na2HPO4,0.2%NaNO3、0.25%L-卡拉胶.最佳培养条件为:培养基体积为70ml/250ml三角瓶,接种量为1%,25℃,90 r/min培养36 h.优化后酶活最高可迭2.64 U/ml,较优化前提高了22倍.结论:QY201最佳发酵条件的建立,为L-卡拉胶酶的大规模生产创造了条件.     

Streptomyces sp.FIM-16-06产他克莫司摇瓶发酵条件的优化

采用单因素试验和正交试验研究发酵培养基组成,优化Streptomyces sp. FIM-16-06产他克莫司的发酵条件,探讨摇瓶发酵的主要影响因子初始p H、装液量、转速等发酵参数的影响。确定了适宜的发酵培养基和发酵参数:6. 0%玉米淀粉、2. 0%黄豆粉、2. 0%葡萄糖和0. 5%玉米浆,初始pH 7. 5,装液量50 m L/500 m L三角瓶,种子菌龄48 h,接种量10%,摇床转速250 r/min,发酵温度27℃,发酵周期7 d。优化后的发酵水平较原生产工艺提高60%以上。他克莫司的优化发酵工艺为其工业化生产奠定了基础。     

Optimization of fermentation medium and conditions for mycelial growth and water-soluble exo-polysaccharides production by Isaria farinosa B05

The optimal fermentation medium and conditions for mycelial growth and water-soluble exo-polysaccharides production by Isaria farinosa B05 were investigated. The medium components and fermentation conditions were optimized according to the one at a time method, while the concentration of medium components was determined by the orthogonal matrix method. The results showed that the optimal fermentation medium was as follows: sucrose 3.5% (w/v), peptone 0.5%, yeast extract 0.2%, K(2)HPO(4) 0.1%, and MgSO(4) 0.05%. The suitable fermentation conditions were as follows: initial pH 7.0, temperature 25 degrees C, medium volume 75 mL/250 mL, inoculum volume 5% (v/v), time 5d. In such optimal nutrition and environmental conditions, the maximal mycelial yield was 2.124 g/100 mL after 4 day's fermentation, while maximal water-soluble exo-polysaccharides production reached 2.144 g/L after 5 day's fermentation.     

Optimization of Fermentation Medium and Conditions for Mycelial Growth and Water-soluble Exo-polysaccharides Production by Isaria farinosa B05

Abstract

The optimal fermentation medium and conditions for mycelial growth and water-soluble exo-polysaccharides production by Isaria farinosa B05 were investigated. The medium components and fermentation conditions were optimized according to the one at a time method, while the concentration of medium components was determined by the orthogonal matrix method. The results showed that the optimal fermentation medium was as follows: sucrose 3.5% (w/v), peptone 0.5%, yeast extract 0.2%, K₂HPO₄ 0.1%, and MgSO₄ 0.05%. The suitable fermentation conditions were as follows: initial pH 7.0, temperature 25°C, medium volume 75 mL/250 mL, inoculum volume 5% (v/v), time 5d. In such optimal nutrition and environmental conditions, the maximal mycelial yield was 2.124 g/100 mL after 4 day's fermentation, while maximal water-soluble exo-polysaccharides production reached 2.144 g/L after 5 day's fermentation.     

响应面法优化荷叶离褶伞菌丝体产漆酶条件

为了对荷叶离褶伞产漆酶条件进行优化,在单因素实验基础上,通过最陡爬坡实验(PB)对培养基8因素进行筛选,获得影响产漆酶的3个显著性因素:葡萄糖,pH和KH₂PO₄;通过中心组合(CCD)设计及响应面分析确定了最优发酵条件:葡萄糖20.09g/L,酪蛋白1.5g/L,酵母提取物1.5g/L,MgSO₄ 3g/L,CuSO₄ 3.75mg/L,KH₂PO₄ 3.97g/L,pH 4.98,VB₁ 0.1g/L,愈创木酚12mg/L,该条件下,漆酶酶活为829.83U/mL,较未优化对照提高46.6%.     

枯草芽孢杆菌B47菌株高产抗菌物质的培养基及发酵条件优化

枯草芽孢杆菌Bacillus subtilis B47菌株为番茄内生细菌, 也是玉米小斑病拮抗菌, 能产生对玉米小斑病菌有强烈抑制作用的抗菌物质。以B47菌株发酵液的无菌滤液对玉米小斑病菌的抗菌活性为检测指标, 测定B47菌株产抗菌物质培养所需的最佳碳、氮源和无机盐, 并通过正交试验法对该菌株产抗菌物质的培养基配方和摇瓶发酵条件进行优化。研究结果表明, B47菌株产抗菌物质最佳碳、氮源和无机盐分别为蔗糖、酵母浸膏和MgSO4·7H2O, 最优培养基是YSB (Yeast extract-sucrose-beef extract)培养基, 其配方为: 蔗糖2%, 酵母浸膏2%, 牛肉浸膏1.5%, MgSO4?7H2O 0.06%, FeSO4·7H2O 0.000 9%, 最优发酵条件组合为: 30 °C, pH 7.0, 170 r/min摇床培养6 d, 接种量为1%, 装液量为40 mL/200 mL。     

海洋枯草芽孢杆菌产纤溶酶的诱变育种与发酵工艺优化*

目的:对海洋来源的具有产纤溶酶能力的枯草芽孢杆菌(Bacillus subtilis)LC6-1进行紫外诱变,得到高产且稳定的突变株PW6-3,对该突变株发酵产酶的条件进行优化。方法:采用单因素和正交试验进行发酵培养基组分和培养条件的优化。结果:突变株PW6-3的酶活力为(6 960.21 ± 85.51)U/mL,较原始菌株提高了30.48%。以PW6-3为出发菌株,采用单因素及正交试验的方法对菌株进行发酵培养基组分与培养条件优化,最终得到的最佳培养基组分是:玉米淀粉30 g/L,玉米浆干粉40 g/L,CaCl₂ 3 g/L;最佳发酵培养条件是:32℃,转速200 r/min,接种量3%,pH 6.5,种龄18 h,发酵培养时间66 h,最终菌株的酶活力稳定在(9 203.63 ± 67.85)U/mL。结论:发酵工艺优化后,菌株PW6-3纤溶酶产量较诱变之前的菌株LC6-1提高72.53%,且发酵工艺成本较低,具有较好的经济效益。     

高效杀蚊苏云金芽孢杆菌BRC-LLP29的发酵优化

苏云金芽孢杆菌BRC-LLP29为新型高效杀蚊菌株,应用快速有效的数学统计方法对其杀蚊毒力的发酵培养进行优化.通过单因素筛选确定最佳碳源为葡萄糖、麦芽糖、可溶性淀粉,氮源为typetone、大豆蛋白胨、干酪素;最佳金属离子为Mg²⁺、Al³⁺.采用二水平Placlkett-Burman设计对影响毒力的8因素进行显著性筛选,获得培养基成分中3个重要影响因子:葡萄糖、干酪素和Al₂（SO₄）₃;运用爬坡路径法对这3种因子进行试验,获得3种重要因子的最适浓度范围;通过响应面分析法得到3个重要因子的交互作用和最佳条件,确定BRC-LLP29菌株最佳毒力水平的发酵培养基为:葡萄糖19.8g/L、干酪素28.4g/L、Al₂（SO₄）₃1.2g/L、MgSO₄ 2g/L、K₂HPO₄ 3g/L、CaCO₃ 0.5g/L,优化后毒力水平达到致死率61.11%,与响应面数学模型的预测值只有5.91%的误差.发酵条件优化结果表明:发酵温度为31°,发酵初始pH为7.0,摇瓶装量为40mL/250mL三角瓶,每瓶的接种量为3.5%,发酵72h,对致倦库蚊最终致死率达到最高为83.33%.     

固定化植物乳杆菌的制备及其发酵条件优化

采用海藻酸钠包埋植物乳杆菌并通过测定固定化细胞发酵清液的抑菌效果,优化得到的固定化最佳工艺条件为:海藻酸钠浓度为3%,CaCl2浓度为1.5%,菌悬液体积为3.5 mL(4.0×108 cfu/mL).固定化细胞重复发酵多批次效果良好.固定化细胞发酵条件优化结果表明:最适pH为7.0,最适温度为36℃,培养基中添加0....     

Optimization of submerged culture conditions for mycelial polysaccharide production in Cordyceps pruinosa

Cordyceps pruinosa is an entomogenous fungus noteworthy for its various bioactivities. The influence of synthetic medium and cultural conditions on polysaccharides production was investigated in shake flask culture. In the present study, optimal medium and submerged culture conditions were investigated using an orthogonal layout. Media and cultural conditions including potato starch 2% (w/v), sucrose 2.5%, soybean 0.5%, beef extract 0.5%, yeast extract 0.1%, KCl 0.02%, K₂HPO₄ 0.1%, MgSO₄·7H₂O 0.05%, pH 7.0, inoculum size 5%, medium capacity 50 ml/250 ml flask, dispersant 15 beads, culture time 7 days were employed. In fermentation medium, sucrose, beef extract and yeast extract were replaced with molasses of sucrose, groundnut and Vitamin B complex, respectively. Under optimal culture conditions, the yield of polysaccharides production was 9.51 g l⁻¹ after 54 h of fermentation in a 25 l fermenter, which was approximately twice as high as that in shake flask cultures. In addition the entire period of fermentation was shorted to around 1/4 of flask culture time (9 days). Thus, it will meet closely the requirements of industrial fermentation scale of polysaccharides production in C. pruinosa.     

蜡质芽孢杆菌AR156发酵培养基及发酵条件的优化

对前期筛选得到的在田间试验中防治根结线虫效果较好的蜡质芽孢杆菌(Bacillus cereus)AR156,通过单因素筛选及正交试验的方法进行了发酵培养基优化,得到的最佳配比为:麦芽糖0.25%,玉米粉0.5%,黄豆粉0.5%,胰蛋白胨0.5%,CaCl2·2H2O0.05%,MnSO4·H2O0.05%,K2HPO40.1%。同时对实验室摇瓶条件下液体发酵的主要影响因子温度、转速、初始pH值等进行实验探讨,确定了最佳培养条件:初始pH值7.0,装液量200mL/L,接种量5%,发酵温度28℃,转速200r/min,发酵时间48h。优化后芽孢产量为1.03×109CFU/mL,芽孢生成率在97%以上,明显高于初始发酵培养基发酵结果。