Long-term outdoor growth and lipid productivity of Tetraselmis suecica, Dunaliella tertiolecta and Chlorella sp (Chlorophyta) in bag photobioreactors

There has been considerable interest on cultivation of green microalgae (Chlorophyta) as a source of lipid that can alternatively be converted to biodiesel. The ideal microalga characteristics are that it must grow well even under high cell density and under varying outdoor environmental conditions and be able to have a high biomass productivity and contain a high oil content (~25–30 %). The main advantage of Chlorophyta is that their fatty acid profile is suitable for biodiesel conversion. Tetraselmis suecica CS-187 and Chlorella sp. were grown semi-continuously in bag photobioreactors (120 L, W?×?L?=?40?×?380 cm) over a period of 11 months in Melbourne, Victoria, Australia. Monthly biomass productivity of T. suecica CS-187 and Chlorella sp. was strongly correlated to available solar irradiance. The total dry weight productivity of T. suecica and Chlorella sp. was 110 and 140 mg L^?1 d^?1, respectively, with minimum 25 % lipid content for both strains. Both strains were able to tolerate a wide range of shear produced by mixing. Operating cultures at lower cell density resulted in increasing specific growth rates of T. suecica and Chlorella sp. but did not affect their overall biomass productivity. On the other hand, self shading sets the upper limit of operational maximum cell density. Several attempts in cultivating Dunaliella tertiolecta CS-175 under the same climatic conditions were unsuccessful.     

Lipid accumulation and growth of Chlorella zofingiensis in flat plate photobioreactors outdoors

Culturing microalgae using natural sunlight is an effective way to reduce the cost of microalgae-based biodiesel production. In order to evaluate the feasibility of culturing Chlorella zofingiensis outdoors for biodiesel production, effects of nitrogen limitation and initial cell concentration on growth and lipid accumulation of this alga were investigated in 60 L flat plate photobioreactors outdoors. The highest μmax and biomass productivity obtained was 0.994 day(-1) and 58.4 mg L(-1)day(-1), respectively. The lipid content was much higher (54.5% of dry weight) under nitrogen limiting condition than under nitrogen sufficient condition (27.3%). With the increasing initial cell concentrations, the lipid contents declined, while lipid concentrations and productivities increased. The highest lipid content, lipid concentration, and lipid productivity obtained was 54.5%, 536 mg L(-1) and 22.3 mg L(-1)day(-1), respectively. This study demonstrated that it was possible to culture C. zofingiensis under outdoor conditions for producing biodiesel feedstock.     

Effect of temperature on yield and night biomass loss in Spirulina platensis grown outdoors in tubular photobioreactors

Outdoor experiments carried out in Florence, Italy (latitude 43.8° N, longitude 11.3° E), using tubular photobioreactors have shown that in summer the average net productivity of a Spirulina platensis culture grown at the optimal temperature of 35 °C was superior by 23% to that observed in a culture grown at 25 °C. The rates of night biomass loss were higher in the culture grown at 25 °C (average 7.6% of total dry weight) than in the one grown at 35 °C (average 5%). Night biomass loss depended on the temperature and light irradiance at which the cultures were grown, since these factors influenced the biomass composition. A net increase in carbohydrate synthesis occurred when the culture was grown at a low biomass concentration under high light irradiance or at the suboptimal temperature of 25 °C. Excess carbohydrate synthesized during the day was only partially utilized for night protein synthesis.     

The effect of nitrogen limitation on lipid productivity and cell composition in Chlorella vulgaris

Chlorella vulgaris accumulates lipid under nitrogen limitation, but at the expense of biomass productivity. Due to this tradeoff, improved lipid productivity may be compromised, despite higher lipid content. To determine the optimal degree of nitrogen limitation for lipid productivity, batch cultures of C. vulgaris were grown at different nitrate concentrations. The growth rate, lipid content, lipid productivity and biochemical and elemental composition of the cultures were monitored for 20 days. A starting nitrate concentration of 170 mg L^?1 provided the optimal tradeoff between biomass and lipid production under the experimental conditions. Volumetric lipid yield (in milligram lipid per liter algal culture) was more than double that under nitrogen-replete conditions. Interpolation of the data indicated that the highest volumetric lipid concentration and lipid productivity would occur at nitrate concentrations of 305 and 241 mg L^?1, respectively. There was a strong correlation between the nitrogen content of the cells and the pigment, protein and lipid content, as well as biomass and lipid productivity. Knowledge of the relationships between cell nitrogen content, growth, and cell composition assists in the prediction of the nitrogen regime required for optimal productivity in batch or continuous culture. In addition to enhancing lipid productivity, nitrogen limitation improves the lipid profile for biodiesel production and reduces the requirement for nitrogen fertilizers, resulting in cost and energy savings and a reduction in the environmental burden of the process.     

Effect of oil and dispersant on growth and chlorophyll a content of the marine microalga Tetraselmis suecica

Low hydrocarbon concentrations stimulated the growth of Tetraselmis suecica, whereas higher concentrations (200 ppm) inhibited growth. The content of chlorophyll a in this microalga was affected in a similar way. Crude oil had the most marked effects. Dispersant SEAKLIN-101-NT and mixtures of oil and SEAKLIN-101-NT did not show selective toxicity for the microalga, although inhibitory effects could be observed at high concentrations.     

The effect of degree and timing of nitrogen limitation on lipid productivity in Chlorella vulgaris

Improvements in lipid productivity would enhance the economic feasibility of microalgal biodiesel. In order to optimise lipid productivity, both the growth rate and lipid content of algal cells must be maximised. The lipid content of many microalgae can be enhanced through nitrogen limitation, but at the expense of biomass productivity. This suggests that a two-stage nitrogen supply strategy might improve lipid productivity. Two different nitrogen supply strategies were investigated for their effect on lipid productivity in Chlorella vulgaris. The first was an initial nitrogen-replete stage, designed to optimise biomass productivity, followed by nitrogen limitation to enhance lipid content (two-stage batch) and the second was an initial nitrogen-limited stage, designed to maximise lipid content, followed by addition of nitrogen to enhance biomass concentration (fed-batch). Volumetric lipid yield in nitrogen-limited two-stage batch and fed-batch was compared with that achieved in nitrogen-replete and nitrogen-limited batch culture. In a previous work, maximum lipid productivity in batch culture was found at an intermediate level of nitrogen limitation (starting nitrate concentration of 170 mg L^?1). Overall lipid productivity was not improved by using fed-batch or two-stage culture strategies, although these strategies showed higher volumetric lipid concentrations than nitrogen-replete batch culture. The dilution of cultures prior to nitrogen deprivation led to increased lipid accumulation, indicating that the availability of light influenced the rate of lipid accumulation. However, dilution did not lead to increased lipid productivity due to the resulting lower biomass concentration.     

pH值对沼液培养的普通小球藻生长及油含量积累的影响

以50％的沼液为普通小球藻的全营养培养基,考察培养基的起始pH值对小球藻生长及油脂含量的影响,普通小球藻对不同初始pH的沼液中氮、磷的去除情况。设定了2组实验,一组只调节初始接种培养液的pH,分别为6.0、6.5、7.0、7.5、8.0、8.5;另一组将培养液pH分别固定在6.0、6.5、7.0、7.5、8.0、8.5,pH用稀HCl和NaOH进行调节。研究发现在pH 6.5和pH 7.0的偏酸环境有利于小球藻生长,而pH在7.0~8.5的偏碱性条件下有利于小球藻油脂的积累,因此综合小球藻生长和油脂积累2个因素,得到最适合小球藻生长和油脂积累的pH为7.0。培养结束后沼液中氮磷的去除率分别达到了95％和97％,沼液中的总氮由原来的134.91 mg/L降至4.86 mg/L,总磷由10.19 mg/L降到0.32 mg/L。     

Cultivation of Tetraselmis suecica using a fishmeal factory effluent: effect on the growth,biochemical composition,and nutrient removal

One of the main effluents from fishmeal plants is stickwater (STW) that causes a considerable number of environmental hazards. This study aimed to replace standard growth medium (F/2; as an enriched solution for growing most of the marine microalgae) of Tetraselmis suecica with different ratios of STW from a kilka fishmeal plant including 0% (control), 10%, 25%, 50%, 75%, and 100%. Results showed that the highest nutrient removal efficacy was obtained in 75% STW treatment, followed by the highest algal cell density (1.23 × 10⁷ cells mL^?1) (P <0.05). A significant increase in the concentrations of photosynthetic pigments (chlorophyll a, b) and lipid productivity was recorded in 75% STW treatment compared to others (P <0.05). The maximum contents of carotenoids and crude protein were obtained in 100% and 50% STW groups, respectively. The levels of saturated and monosaturated fatty acids were significantly increased by increasing the inclusion ratio of STW from 50 to 100% (P <0.05). However, the lowest level of polyunsaturated fatty acids was measured in 100% STW treatment. Overall, replacing F/2 with STW up to 75% is feasible to culture T. suecica with the highest biomass and lipid productivity.

     

Growth-associated biosynthesis of astaxanthin in heterotrophic Chlorella zofingiensis (Chlorophyta)

The green microalga Chlorella zofingiensis can produce the ketocarotenoid astaxanthin under heterotrophic culture conditions. Here we report the growth-associated biosynthesis of astaxanthin in this biotechnologically important alga. With glucose as sole carbon and energy source, C. zofinginesis grew fast in the dark with rapid exhaustion of nitrogen and carbon sources from media, leading to a high specific growth rate (0.034 h⁻¹). Cultures started at a cell concentration of about 3.4 × 10⁹ cells l⁻¹ reached, after 6 days, standing biomass values of 1.6 × 10¹¹ cells or 8.5 g dry weight l⁻¹. Surprisingly, the biosynthesis of astaxanthin was found to start at early exponential phase, independent of cessation of cell division. A general trend was observed that the culture conditions benefiting cell growth also benefited astaxanthin accumulation, indicating that astaxanthin was a growth-associated product in this alga. The maximum cell dry biomass and astaxanthin yield were 11.75 g l⁻¹ and 11.14 mg l⁻¹ (about 1 mg g⁻¹), simultaneously obtained in the fed-batch culture with a combined glucose–nitrate mixture addition, which were the highest ever reported in dark-heterotrophic algal cultures. The possible reasons why dark-heterotrophic C. zofingiensis could produce astaxanthin during the course of cell growth were discussed.     

Comparison of suitable protein measurement for Thalassiosira weissflogii (Bacillariophyta) and Tetraselmis chuii (Chlorophyta)

To perform effective measurement of the protein contents, it is necessary to apply the most suitable extraction technique. We compared protein extraction techniques for two microalgal species with entirely different cell wall structures, such as diatom Thalassiosira weissflogii and green flagellate Tetraselmis chuii, using mechanical, physical, and chemical extraction methods. Our results showed that in Th. weissflogii, the control treatment without extraction and mechanical disruption using ultrasonication was sufficient to disrupt its brittle cell wall, resulting in the protein yield of 19.03 and 19.46% of dry weight (DW), respectively. In case of Te. chuii, the chemical extraction using 6% trichloroacetic acid at 95°C was the most suitable extraction method, resulting in the protein yield of 23.78% of DW. Therefore, the most suitable extraction technique must be individually selected for each species depending on their cell wall properties.     

Effect of oil and dispersant on growth and chlorophyll a content of the marine microalga Tetraselmis suecica.

Low hydrocarbon concentrations stimulated the growth of Tetraselmis suecica, whereas higher concentrations (200 ppm) inhibited growth. The content of chlorophyll a in this microalga was affected in a similar way. Crude oil had the most marked effects. Dispersant SEAKLIN-101-NT and mixtures of oil and SEAKLIN-101-NT did not show selective toxicity for the microalga, although inhibitory effects could be observed at high concentrations.     

Effect of Mg, Si, and Sr on growth and antioxidant activity of the marine microalga Tetraselmis suecica

Efforts to increase the productivity of microalgal cultures have been focused on the improvement of photobioreactors, but little attention has been paid to the nutritional requirements of microalgae in order to improve culture media formulation. In this study, the main goal was obtaining a high productivity for Tetraselmis suecica (Chlorophyta) in semicontinuous culture by adding magnesium (Mg), silicon (Si), and strontium (Sr) at concentrations from 0.01 to 10 mM; at the time, the effect on steady-state cell density, biochemical composition, and antioxidant activity of T. suecica was evaluated. Because productivity is higher in high-density cultures, the work was focused many times to cell density. Mg (3 mM) and Sr (0.1 mM) added separately reached the highest steady-state cell density (7.0?×?10⁶?±?0.4 cells mL^?1) in comparison to control (4.2?±?0.1 cells mL^?1), but simultaneous addition had a synergic effect, achieving 8.7?×?10⁶?±?0.6 cells mL^?1. Silicon (3 mM) significantly affected the steady-state cell density, reaching 6.0?±?0.3 cells mL^?1 and increased the cell ash-free dry weight, reaching 127?±?7.9 pg cell^?1 in comparison to control (102.7?±?5.0 pg cell^?1), resulting in an ash-free dry weight productivity of 0.75?±?0.07 g?L^?1 day^?1. The highest fatty acids content and antioxidant activity, measured by 2, 2-diphenyl-1-picrylhydrazyl (DPPH) method were obtained with Sr 10 mM. Sr treatments showed a high correlation (R ²?=?0.98) between DPPH inhibition and polyphenolic content, explaining its high antioxidant activity. Therefore, the addition of Mg, Si, and Sr to culture medium of T. suecica is recommended to achieve high steady-state cell density in semicontinuous cultures.     

Vitamin E (alpha-tocopherol) production by the marine microalgae Dunaliella tertiolecta and Tetraselmis suecica in batch cultivation

Batch experiments with Dunaliella tertiolecta and Tetraselmis suecica were performed to investigate alpha-tocopherol (alpha-T) production in time, in order to assess the effect of light availability per cell on the production of this antioxidant. In D. tertiolecta alpha-T content increased during growth, in other words, as the cell density increased and the light availability per cell decreased. In T. suecica the pattern was different: alpha-T content was highest during the exponential phase, decreased significantly during the linear phase and increased again towards the end of the cultivation. Chlorophyll (chl-a) content of T. suecica cells decreased after the exponential phase, instead of the expected increase typically observed in shade-adapted cells, suggesting that the culture was nutrient limited. An experiment with extra nutrients showed that chl-a and alpha-T content increased significantly during both the linear and the stationary phase when compared with values in nutrient-deficient conditions. No correlation between alpha-T and chl-a was observed. Our results indicate that diminished light availability does not limit alpha-T production in D. tertiolecta and T. suecica, opening up the possibility of using high cell density, light-limited cultures for the production of this commercially interesting compound.     

In situ monitoring of chlorophyll fluorescence to assess the synergistic effect of low temperature and high irradiance stresses inSpirulina cultures grown outdoors in photobioreactors

A chlorophyll fluorescence technique was applied to anin situ study on the effects of low temperature and high light stresses onSpirulina cultures grown outdoors in controlled tubular photobioreactors at high (1.1 g L^–1) and low (0.44 g L^–1) biomass concentrations. Diurnal changes in PSII photochemistry (F _v/F _m) after 15 min of darkness, or in the light (dF/F _m), and non-photochemical (qN) quenching were measured using a portable, pulse-amplitude-modulated fluorometer. The depression of theF _v/F _m ratio ofSpirulina cultures grown outdoors at 25°C (i.e. 10°C below optimum for growth) and 0.44 g L^–1, reached 30% at the middle of the day. At the same time of the day thedF/F _m ratio showed a reduction of up to 52%. The depression of bothF _v/F _m anddF/F _m was lower in the cultures grown at 1.1 g L^–1. Photoinhibition reduced the daily productivity of the culture grown at 0.44 g L^–1 and 25°C by 33% with respect to that grown at 35°C. Changes in the growth yields of the cultures grown under different temperatures and growth rates correlate well with analogous changes in photon yield (dF/F _m). Simple measurements of photochemical yield (F _v/F _m) can be used to test the physiological status ofSpirulina cultures. The results indicate that the saturating pulse fluorescence technique, when usedin situ, is a powerful tool for assessment of the photosynthetic characteristics of outdoor cultures ofSpirulina.     

Influence of stress factors on growth and pigment production in three Dunaliella species cultivated outdoors in flat-plate photobioreactors

Abstract

Growth and production of carotenoid in three Dunaliella species (Dunaliella salina (Dunal) Teodoresco, Dunaliella bardawil Ben-Amotz & Avron and Dunaliella sp.) were investigated using flat-plate photobioreactors in outdoor conditions with two optical paths (3?cm and 5?cm). The experiment was conducted in duplicate and lasted four weeks during which light intensity, temperature, pH and optical density were checked daily. The pigment production (total carotenoid and chlorophyll a) was monitored every two days. To induce an additional stress besides temperature and light intensity, two different salt concentrations were used, i.e. 6% and 8% NaCl. The highest growth in all treatment groups was noticed for Dunaliella sp. followed by D. bardawil and D. salina. D. salina produced a higher content of carotenoid concentrations corresponding to 5?cm/8% and 5?cm/6% groups; 779.102?±?0.434?μg.mL^?1 and 694.326?±?0.098?μg.mL^?1 were registered at the end of the experiment. The same species had also greater content of β-carotene.     

Genotype versus phenotype variability in Chlorella and Micractinium (Chlorophyta, Trebouxiophyceae)

The most recent revision of the genus Chlorella, based on biochemical and SSU rDNA analyses, suggested a reduction to a set of four "true" spherical Chlorella species, while a growing number of morphologically different species such as Micractinium (formerly Micractiniaceae) were found to cluster within the clade of "true"Chlorella. In this study, the generic concept in Chlorellaceae to Chlorella and Micractinium was evaluated by means of combined SSU and ITS-2 rDNA sequence analyses and biotests to induce development of bristles on the cell wall. Molecular phylogenetic analyses of Chlorella and Micractinium strains confirmed their separation into two different genera. In addition, non-homoplasious synapomorphies (NHS) and compensatory base changes (CBC) in the secondary structures of SSU and ITS-2 rDNA sequences were found for both genera using this approach. The Micractinium clade can be differentiated into three different genotypes. Using culture medium of the rotifer Brachionus calyciflorus, phenotypic plasticity in Chlorella and Micractinium was studied. Non-bristled Micractinium cells developed bristles during incubation with Brachionus culture medium, whereas Chlorella did not produce bristles. Grazing experiments with Brachionus showed the rotifer preferred to feed on non-bristled cells. The dominance of colonies versus solitary cells in the Micractinium culture was not correlated with the "Brachionus factor". These results suggest that morphological characteristics like formation of bristles represent phenotypic adaptations to the conditions in the ecosystem.     

Systematic investigation of biomass and lipid productivity by microalgae in photobioreactors for biodiesel application

We describe a methodology to investigate the potential of given microalgae species for biodiesel production by characterizing their productivity in terms of both biomass and lipids. A multi-step approach was used: determination of biological needs for macronutrients (nitrate, phosphate and sulphate), determination of maximum biomass productivity (the “light-limited” regime), scaling-up of biomass production in photobioreactors, including a theoretical framework to predict corresponding productivities, and investigation of how nitrate starvation protocol affects cell biochemical composition and triggers triacylglycerol (TAG) accumulation. The methodology was applied to two freshwater strains, Chlorella vulgaris and Neochloris oleoabundans, and one seawater diatom strain, Cylindrotheca closterium. The highest total lipid content was achieved with N. oleoabundans (25-37% of DW), while the highest TAG content was found in C. vulgaris (11-14% of DW). These two species showed similar TAG productivities.     

Effects of methanol on cell growth and lipid production from mixotrophic cultivation of Chlorella sp.

The marine microalga Chlorella sp. was cultivated under mixotrophic conditions using methanol as an organic carbon source, which may also act to maintain the sterility of the medium for long-term outdoor cultivation. The optimal methanol concentration was determined to be 1% (v/v) for both cell growth and lipid production when supplying 5% CO₂ with 450 μE/m²/sec of continuous illumination. Under these conditions, the maximal cell biomass and total lipid production were 4.2 g dry wt/L and 17.5% (w/w), respectively, compared to 2.2 g dry wt/L and 12.5% (w/w) from autotrophic growth. Cell growth was inhibited at methanol concentrations above 1% (v/v) due to increased toxicity, whereas 1% methanol alone sustained 1.0 g dry wt/L and 4.8% total lipid production. We found that methanol was preferentially consumed during the initial period of cultivation, and carbon dioxide was consumed when the methanol was depleted. A 12:12 h (light:dark) cyclic illumination period produced favorable cell growth (3.6 g dry wt/L). Higher lipid production was observed with cyclic illumination than with continuous illumination (18.6% (w/w) vs 17.5% (w/w)), and better lipid production was also obtained under mixotrophic rather than autotrophic conditions. Interestingly, under mixotrophic conditions with 12:12 (h) cyclic illumination, high proportions of C_16:0, C_18:0, and C_18:1 were observed, which are beneficial for biodiesel production. These results strongly indicate that the carbon source is important for controlling both lipid composition and cell growth under mixotrophic conditions, and they suggest that methanol could be utilized to scale up production to an open pond type system for outdoor cultivation where light illumination changes periodically.     

Production of lipids in 10 strains of Chlorella and Parachlorella, and enhanced lipid productivity in Chlorella vulgaris

We tested 10 different Chlorella and Parachlorella strains under lipid induction growth conditions in autotrophic laboratory cultures. Between tested strains, substantial differences in both biomass and lipid productivity as well as in the final content of lipids were found. The most productive strain (Chlorella vulgaris CCALA 256) was subsequently studied in detail. The availability of nitrates and/or phosphates strongly influenced growth and accumulation of lipids in cells by affecting cell division. Nutrient limitation substantially enhanced lipid productivity up to a maximal value of 1.5 g l⁻¹ day⁻¹. We also demonstrated the production of lipids through large-scale cultivation of C. vulgaris in a thin layer photobioreactor, even under suboptimal conditions. After 8 days of cultivation, maximal lipid productivity was 0.33 g l⁻¹ day⁻¹, biomass density was 5.7 g l⁻¹ dry weight and total lipid content was more than 30% dry weight. C. vulgaris lipids comprise fatty acids with a relatively high degree of saturation compared with canola oil offering a possible alternative to the use of higher plant oils.