代谢工程大肠杆菌利用甘油高效合成L-乳酸

以甘油为碳源高效合成L-乳酸有助于推进油脂水解产业和生物可降解材料制造业的共同发展。为此,首先分别从凝结芽胞杆菌Bacillus coagulans CICIM B1821和大肠杆菌Escherichia coli CICIM B0013中克隆了L-乳酸脱氢酶基因BcoaLDH和D-乳酸脱氢酶 (LdhA) 的启动子片段PldhA。将两条DNA片段连接组成了表达盒PldhA-BcoaLDH。然后将上述表达盒通过同源重组删除FMN为辅酶的L-乳酸脱氢酶编码基因lldD的同时克隆入ldhA基因缺失菌株E. coli CICIM B0013-080C (ack-pta pps pflB dld poxB adhE frdA ldhA)的染色体上,获得了L-乳酸高产菌株E. coli CICIM B0013-090B (B0013-080C,lldD::PldhA-BcoaLDH)。考察了菌株CICIM B0013-090B不同培养温度下代谢利用甘油和合成L-乳酸的特征后,建立并优化了一种新型L-乳酸变温发酵工艺。在7 L发酵罐上,发酵27 h,积累L-乳酸132.4 g/L,产酸强度4.90 g/(L·h),甘油到L-乳酸的得率为93.7％,L-乳酸的光学纯度达到99.95％。     

产L-苹果酸重组大肠杆菌的构建

基于产琥珀酸重组大肠杆菌E.coli B0013-1050的琥珀酸合成途径,利用Red同源重组技术结合Xer/dif重组系统敲除富马酸酶基因fumB、fumC,苹果酸酶基因maeB,构建L-苹果酸合成途径,最终得到重组大肠杆菌E.coli2030,该菌株在15 L发酵罐中,产L-苹果酸12.5 g/L,葡萄糖-苹果酸转化率为52.1%,同时对发酵产物中主要杂酸丙酮酸和琥珀酸的生产原因进行了初步的探讨与分析。为进一步提高L-苹果酸的转化率,整合表达来源于黄曲霉的苹果酸脱氢酶基因,构建重组菌E.coli 2040,在15 L发酵罐中产L-苹果酸14 g/L,葡萄糖-苹果酸转化率提高到60.3%。     

温度调节基因开关调控大肠杆菌发酵合成L-丙氨

【目的】L-丙氨酸的存在导致Escherichia coli的生长速率显著降低,最终会降低发酵过程中L-丙氨酸的体积合成速率。用温度调节基因开关(λpR-pL)高效、动态调控重组E. coli菌株菌体生长与L-丙氨酸合成过程,使两者相协调。【方法】以野生型E. coli B0016为出发菌株,敲除乙酸、甲酸、乙醇、琥珀酸、乳酸代谢产物合成途径以及丙氨酸消旋酶编码基因(ackA-pta、pflB、adhE、frdA、ldhA、dadX),获得菌株B0016-060B。将嗜热脂肪地芽孢杆菌(Geobacillus stearothermophilus)来源的L-丙氨酸脱氢酶基因(alaD)克隆于pL启动子下游,并在B0016-060B菌株中表达,获得菌株B0016-060B/pPL-alaD,进行摇瓶和发酵罐发酵考察菌体生长和L-丙氨酸发酵性能。【结果】竞争代谢途径的敲除显著降低了副产物合成量,仅形成极少量的乙酸、琥珀酸和乙醇。28 °C下菌株B0016-060B/pPL-alaD几乎不合成L-丙氨酸,可保证菌体快速生长;而在42 °C下可高效合成L-丙氨酸。经发酵罐发酵,可合成67.2 g/L L-丙氨酸,体积生产强度达到2.06 g/(L·h)。【结论】通过发酵培养温度的简单切换,分阶段实现了细胞的快速增量和L-丙氨酸的高强度合成。     

大肠杆菌利用木糖发酵产琥珀酸的研究

目的:研究大肠杆菌以木糖为碳源发酵产琥珀酸。方法:首先比较了实验室保藏的7种野生型大肠杆菌利用木糖发酵产琥珀酸的产量和得率,结果:表明野生型菌株琥珀酸对木糖的得率集中在0.34g/g~0.53g/g之间,得率较低,副产物主要为乳酸、乙酸。然后选取其中2株菌(E.coli MG1655与E.coli C-1)进行基因敲除,构建了ldhA和pflB双基因缺失的MLB和CLB菌株,以减少副产物的积累。两阶段摇瓶发酵结果表明,琥珀酸得率从0.40g/g分别提高到了0.89g/g及0.90g/g,而产量分别从4.92g/L、5.58g/L提高到11.52g/L、11.81g/L。结论:通过基因敲除后,大肠杆菌能够利用木糖发酵产琥珀酸,琥珀酸得率可以达到0.90g/g。     

利用五碳糖产高纯度L-乳酸的大肠杆菌基因工程菌的构建

[目的]本研究以已敲除多个产杂酸酶基因的大肠杆菌(Escherichia coli)乙醇工程菌SZ470(△frdBC △ldhA △ackA △focA-pflB △pdhR::pflBp6-pflBrbs-aceEF-lpd)为起始菌株,进一步敲除其乙醇脱氢酶(alcohol dehydrogenase,ADH)基因,同时插入带有自身启动子的乳酸片球菌(Pediococcus acidilactici)的L-乳酸脱氢酶(L-lactate dehydrogenase,LLDH)基因,构建可利用五碳糖同型发酵L-乳酸重组大肠杆菌.[方法]利用λ噬菌体Red重组系统构建乙醇脱氢酶基因(adhE)缺失菌株Escherichia coli JH01,并克隆P.acidilactici的ldhL基因,利用染色体插入技术将其整合到JH01基因组,构建产L-乳酸大肠杆菌基因工程菌Escherichia coli JH12,利用无氧发酵15 L发酵罐测定重组菌株L-乳酸产量.[结果]工程菌JH12在15 L发酵罐中以6％的葡萄糖为碳源进行发酵,发酵到36 h的过程中葡萄糖的消耗速率为1.46 g/(L·h),乳酸生产强度为1.14 g/(L·h),乳酸的产量达到41.13 g/L.发酵产物中未检测到琥珀酸、甲酸的生成,仅有少量乙酸生成,L-乳酸纯度达95.69％(L-乳酸在总发酵产物的比率).工程菌JH12以6％的木糖为碳源进行发酵,发酵到36 h的过程中葡萄糖的消耗速率为0.88 g/(L·h),乳酸生产强度为0.60 g/(L·h),乳酸的产量达到34.73 g/L.发酵产物中杂酸少,乳酸的纯度高达98％.[结论]本研究通过基因敲除、染色体插入及无氧进化筛选获得一株产L-乳酸的大肠杆菌工程菌JH12,该菌株不需利用外源质粒,稳定性好,可利用五碳糖进行发酵,发酵产物中杂酸少,L-乳酸的纯度高.本研究为L-乳酸大肠杆菌工程菌的构建提供一定的技术支持,同时也为大肠杆菌L-乳酸的工业化生产提供了参考依据.     

过表达长链鞘氨醇激酶基因LCB4提高酿酒酵母抑制物耐受性

木质纤维素预处理过程中产生的有毒副产物严重影响了纤维素乙醇发酵,提高酿酒酵母抑制物耐受性是提高纤维素乙醇发酵效率的有效方法。文中通过过表达LCB4基因,研究了重组菌株S288C-LCB4在乙酸、糠醛和香草醛胁迫下的细胞生长和乙醇发酵性能。结果表明,LCB4过表达菌株在分别含有10 g/L乙酸、1.5 g/L糠醛和1 g/L香草醛的平板中生长均优于对照菌株;在分别含有10 g/L乙酸、3 g/L糠醛和2 g/L香草醛的液体乙醇发酵过程中,重组菌株S288C-LCB4乙醇发酵产率分别为0.85 g/(L·h)、0.76 g/(L·h)和1.12 g/(L·h),比对照菌株提高了34.9%、85.4%和330.8%;且糠醛和香草醛胁迫下发酵时间分别缩短了30 h和44 h。根据发酵终点发酵液代谢物分析发现重组菌株比对照菌株产生了更多甘油、海藻糖和琥珀酸,这些物质有利于增强菌株的抑制物耐受性。综上所述,LCB4基因过表达可显著提高酿酒酵母S288C在乙酸、糠醛和香草醛胁迫下的乙醇发酵性能。     

耐铵型产琥珀酸放线杆菌的选育

以Actinobacillus succinogenes NJ113为出发菌株,经硫酸二乙酯(DES)诱变,在含8～20 g/L硫酸铵平板中筛选到一株耐铵型突变株YZ25,该菌株在含8 g/L硫酸铵培养基中厌氧发酵,琥珀酸产量达32.68 g/L,比出发菌提高了180.5%,对葡萄糖收率达65.4%,副产物乙酸、甲酸产量分别下降3.5%、28.7%,琥珀酸/乙酸比值由0.63提高到2.5。在7.5 L发酵罐中,用氨水调节pH分批实验,发酵34 h琥珀酸产量达27.13 g/L,较出发菌株提高了85.3%。     

调控大肠杆菌胞内ATP和NADH水平促进琥珀酸生产

琥珀酸作为一种重要的C4平台化合物,广泛应用于食品、化学、医药等领域。利用大肠杆菌(Escherichia coli)发酵生产琥珀酸受胞内辅因子不平衡的影响,存在产率低、生产强度低、副产物多等问题。为此,对不同氧气条件下琥珀酸产量和化学计量学分析发现,微厌氧条件下E.coli FMME-N-26高效积累琥珀酸需要借助三羧酸循环(tricarboxylic acid cycle,TCA)为还原性三羧酸途径(reductive tricarboxylic acid pathway,r-TCA)提供足够的ATP和NADH。通过减少ATP消耗、强化ATP合成、阻断NADH竞争途径和构建NADH回补路径等代谢工程策略,组合调控胞内ATP与NADH含量,获得工程菌株E.coli FW-17。通过发酵条件优化,菌株E.coli FW-17在5 L发酵罐能积累139.52 g/L琥珀酸,比出发菌株提高了17.81%,乙酸浓度为1.40 g/L,降低了67.59%。进一步在1000 L发酵罐中进行放大实验,琥珀酸产量和乙酸浓度分别为140.2 g/L和1.38 g/L。     

利用温度调节实现新型重组菌高效转化甘油为D-乳酸

油脂水解来源的甘油将是未来发酵工业主要原料之一.文中探索D-乳酸高产大肠杆菌Escherichia coli CICIM B0013-070菌株不同培养温度下好氧与厌氧代谢甘油的特征后,建立并优化了一种新型D-乳酸变温发酵工艺,甘油到乳酸的得率由64％提高到82.6％.另外,在B0013-070中引入了温度诱导型乳酸脱氢酶的转录系统,甘油到乳酸的得率进一步提高到88.9％.     

代谢工程改造大肠杆菌合成丁二酸及发酵罐放大工艺

【背景】Escherichia coli AFP111发酵生产丁二酸时大量副产乙酸,丁二酸得率低。【目的】代谢工程改造EscherichiacoliAFP111,提高丁二酸得率,降低副产物乙酸的生成,建立100 L规模的丁二酸发酵工艺。【方法】一步同源重组敲除乙酸合成途径关键酶基因,改造丁二酸合成途径关键酶启动子实现过表达;单因素优化5L发酵罐培养条件。【结果】敲除乙酸产生途径编码乙酸激酶和磷酸转乙酰酶的基因ackA-pta、苏氨酸脱羧酶和2-酮丁酸甲酸裂解酶的基因tdcDE获得SX02菌株,摇瓶发酵条件下其乙酸产量下降了53.42%,丁二酸得率提高9.85%。在SX02菌株基础上,经启动子改造过表达编码葡萄糖激酶的基因glk后获得菌株SX03,其Glk酶活性提高3.66倍,乙酸产量下降了31.62%,丁二酸得率提高8.28%。SX03菌株发酵生产丁二酸在5 L发酵罐进行放大,其乙酸产量为3.97 g/L,丁二酸得率为1.62 mol/mol葡萄糖,相比出发菌株的乙酸产量下降了75.76%,丁二酸得率提高19.12%。在5L发酵罐上对比研究了中和剂Na2CO3和NaOH混合液替换碱式MgCO3的发酵效果,并优化了发酵pH、搅拌转速和葡萄糖浓度,获得如下最适发酵条件:pH6.8,搅拌转速250r/min,葡萄糖100g/L,发酵结束时乙酸产量为2.24 g/L,丁二酸得率为1.66 mol/mol葡萄糖。中和剂替换优化后乙酸产量下降了20.65%,丁二酸得率提高2.47%。菌株SX03发酵工艺进一步在100 L发酵罐上实现放大,其乙酸产量为1.91 g/L,丁二酸得率为1.30 mol/mol葡萄糖。【结论】通过代谢工程改造的大肠杆菌,其副产物乙酸含量显著下降,丁二酸得率提高,并在5 L和100 L发酵罐上实现了工艺放大,展现出较大的工业化利用潜力。     

Evaluation of Genetic Manipulation Strategies on d-Lactate Production by Escherichia coli

In order to rationally manipulate the cellular metabolism of Escherichia coli for D: -lactate production, single-gene and multiple-gene deletions with mutations in acetate kinase (ackA), phosphotransacetylase (pta), phosphoenolpyruvate synthase (pps), pyruvate formate lyase (pflB), FAD-binding D-lactate dehydrogenase (dld), pyruvate oxidase (poxB), alcohol dehydrogenase (adhE), and fumarate reductase (frdA) were tested for their effects in two-phase fermentations (aerobic growth and oxygen-limited production). Lactate yield and productivity could be improved by single-gene deletions of ackA, pta, pflB, dld, poxB, and frdA in the wild type E. coli strain but were unfavorably affected by deletions of pps and adhE. However, fermentation experiments with multiple-gene mutant strains showed that deletion of pps in addition to ackA-pta deletions had no effect on lactate production, whereas the additional deletion of adhE in E. coli B0013-050 (ackA-pta pps pflB dld poxB) increased lactate yield. Deletion of all eight genes in E. coli B0013 to produce B0013-070 (ackA-pta pps pflB dld poxB adhE frdA) increased lactate yield and productivity by twofold and reduced yields of acetate, succinate, formate, and ethanol by 95, 89, 100, and 93%, respectively. When tested in a bioreactor, E. coli B0013-070 produced 125 g/l D-lactate with an increased oxygen-limited lactate productivity of 0.61 g/g h (2.1-fold greater than E. coli B0013). These kinetic properties of D-lactate production are among the highest reported and the results have revealed which genetic manipulations improved D-lactate production by E. coli.     

Genetically switched d-lactate production in Escherichia coli

During a fermentation process, the formation of the desired product during the cell growth phase competes with the biomass for substrates or inhibits cell growth directly, which results in a decrease in production efficiency. A genetic switch is required to precisely separate growth from production and to simplify the fermentation process. The ldhA promoter, which encodes the fermentative d-lactate dehydrogenase (LDH) in the lactate producer Escherichia coli CICIM B0013-070 (ack-pta pps pflB dld poxB adhE frdA), was replaced with the λ p(R) and p(L) promoters (as a genetic switch) using genomic recombination and the thermo-controllable strain B0013-070B (B0013-070, ldhAp::kan-cI(ts)857-p(R)-p(L)), which could produce two-fold higher LDH activity at 42°C than the B0013-070 strain, was created. When the genetic switch was turned off at 33°C, strain B0013-070B produced 10% more biomass aerobically than strain B0013-070 and produced only trace levels of lactate which could reduce the growth inhibition caused by oxygen insufficiency in large scale fermentation. However, 42°C is the most efficient temperature for switching on lactate production. The volumetric productivity of B0013-070B improved by 9% compared to that of strain B0013-070 when it was grown aerobically at 33°C with a short thermo-induction at 42°C and then switched to the production phase at 42°C. In a bioreactor experiment using scaled-up conditions that were optimized in a shake flask experiment, strain B0013-070B produced 122.8g/l d-lactate with an increased oxygen-limited productivity of 0.89g/g·h. The results revealed the effectiveness of using a genetic switch to regulate cell growth and the production of a metabolic compound.     

好氧发酵生产琥珀酸工程菌株的构建

通过分析大肠杆菌的碳源代谢途径, 利用基因敲除手段, 以Escherichia coli MG1655为出发菌株, 成功构建了琥珀酸好氧发酵生产工程菌E. coli QZ1111 (MG1655?ptsG?poxB?pta?iclR?sdhA)。检测结果表明该菌株能以葡萄糖为碳源, 在好氧发酵且不表达任何异源基因的条件下大量积累琥珀酸。摇瓶试验证明, 琥珀酸发酵产量达到26.4 g/L, 乙酸盐作为唯一检测到的副产物产量为2.3 g/L。二者浓度比达到11.5:1。     

Production of carotenoids and lipids by <Emphasis Type="Italic">Rhodococcus opacus</Emphasis> PD630 in batch and fed-batch culture

Production of carotenoids by Rhodococcus opacus PD630 is reported. A modified mineral salt medium formulated with glycerol as an inexpensive carbon source was used for the fermentation. Ammonium acetate was the nitrogen source. A dry cell mass concentration of nearly 5.4 g/L could be produced in shake flasks with a carotenoid concentration of 0.54 mg/L. In batch culture in a 5 L bioreactor, without pH control, the maximum dry biomass concentration was ~30 % lower than in shake flasks and the carotenoids concentration was 0.09 mg/L. Both the biomass concentration and the carotenoids concentration could be raised using a fed-batch operation with a feed mixture of ammonium acetate and acetic acid. With this strategy, the final biomass concentration was 8.2 g/L and the carotenoids concentration was 0.20 mg/L in a 10-day fermentation. A control of pH proved to be unnecessary for maximizing the production of carotenoids in this fermentation.     

Fermentation of Detoxified Acid-Hydrolyzed Pyrolytic Anhydrosugars into Bioethanol with <Emphasis Type="Italic">Saccharomyces cerevisiae</Emphasis> 2.399

Pyrolysate obtained from the pyrolysis of waste cotton is a source of fermentable sugars that could be fermented into bioethanol fuel and other chemicals via microbial fermentation. However, pyrolysate is a complex mixture of fermentable and non-fermentable substrates causing inhibition of the microbial growth. The aim of this study was to detoxify the hydrolysate and then ferment it into bio-ethanol fuel in shake flasks and fermenter applying yeast strain Saccharomyces cerevisiae 2.399. Pyrolysate was hydrolyzed to glucose with 0.2 M sulfuric acid, neutralized with Ba(OH)₂ followed by treatment with ethyl acetate and activated carbon to remove fermentation inhibitors. The effect of various fermentation parameters such as inoculum concentration, pH and hydrolysate glucose was evaluated in shake flasks for optimum ethanol fermentation. With respect to inoculum concentration, 20% v/v inoculum i.e. 8.0 × 10⁸–1.2 × 10⁹ cells/mL was the optimum level for producing 8.62 ± 0.33 g/L ethanol at 9 h of fermentation with a maximum yield of 0.46 g ethanol/g glucose. The optimum pH for hydrolysate glucose fermentation was found to be 6.0 that produced 8.57 ± 0.66 g/L ethanol. Maximum ethanol concentration, 14.78 g/L was obtained for 4% hydrolysate glucose concentration after 16 h of fermentation. Scale-up studies in stirred fermenter produced much higher productivity (1.32 g/L/h^–1) compared to shake flask fermentation (0.92 g/L/h^–1). The yield of ethanol reached a maximum of 91% and 89% of the theoretical yield of ethanol in shake flasks and fermenter, respectively. The complex of integrated models of development was applied, that has been successfully tested previously for the mathematical analysis of the fermentation processes.     

Energy conservation by succinate decarboxylation in Veillonella parvula.

Veillonella parvula cannot grow with succinate as sole energy source. However, succinate decarboxylation simultaneous with malate or lactate fermentation increased growth yields by 2.4-3.5 g (mol succinate)-1. Malate was fermented stoichiometrically to acetate and propionate whereas lactate fermentation produced more acetate and considerable amounts of H2. Aspartate was utilized only in the presence of succinate as co-substrate. Methylmalonyl-CoA decarboxylase and ATP-dependent pyruvate carboxylase, but not methylmalonyl-CoA:pyruvate transcarboxylase, were detected in cell-free extracts of malate- or lactate-grown cells. The energetic aspects of these fermentation patterns are discussed.