Molecular Cloning,Structural Modeling and the Production of Soluble Triple-Mutated Diphtheria Toxoid (K51E/G52E/E148K) Co-expressed with Molecular Chaperones in Recombinant <Emphasis Type="Italic">Escherichia coli</Emphasis>

CRM197 is a diphtheria toxin (DT) mutant (G52E) which has been used as a carrier protein for conjugate vaccines. However, it still possesses cytotoxicity toward mammalian cells. The goal of this project was to produce a non-toxic and soluble CRM197EK through introduction of triple amino acid substitutions (K51E/G52E/E148K) in Escherichia coli. The expression of CRM197EKTrxHis was optimized and co-expressed with different molecular chaperones. The soluble CRM197EKTrxHis was produced at a high concentration (97.33 ± 17.47 μg/ml) under the optimal condition (induction with 0.1 mM IPTG at 20 °C for 24 h). Cells containing pG-Tf2, expressing trigger factor and GroEL-GroES, accumulated the highest amount of soluble CRM197EKTrxHis at 111.24 ± 10.40 μg/ml after induction for 24 h at 20 °C. The soluble CRM197EKTrxHis still possesses nuclease activity and completely digest λDNA at 25 and 37 °C with 8- and 4-h incubation, respectively. Molecular modeling of diphtheria toxin, CRM197 and CRM197EK indicated that substitutions of two amino acids (K51E/E148K) may cause poor NAD binding, consistent with the lack of toxicity. Therefore, CRM197EK might be used as a new potential carrier protein. However, further in vivo study is required to confirm its roles as functional carrier protein in conjugate vaccines.     

小鼠卵ZP3蛋白的可溶性表达、纯化及免疫活性鉴定

哺乳动物卵透明带3(Zona pellucida 3,ZP3)在诱导获能精子发生顶体反应中发挥着重要作用,其在大肠杆菌中主要以包涵体形式表达。本研究在大肠杆菌中诱导表达可溶性的mZP3融合蛋白,并鉴定该蛋白的免疫活性。将小鼠卵透明带3克隆至pMAL-p2x质粒,转化至大肠杆菌BL21表达菌中。用不同温度、不同IPTG浓度、不同诱导时间及不同浓度的添加剂诱导目的蛋白表达,以筛选出mZP3融合蛋白可溶性表达的最佳条件。大量表达纯化后以Western blotting和ELISA检测蛋白的免疫活性。酶切鉴定及DNA测序表明mZP3已克隆入pMAL-p2x质粒。经优化诱导表达条件,筛选出mZP3融合蛋白可溶性表达的最佳条件为:当A600为0.6时添加0.02 mol/L葡萄糖,以0.6 mmol/L IPTG于25oC条件下诱导表达4 h。ELISA及Western blotting检测结果表明诱导表达的蛋白具有免疫活性。在大肠杆菌中表达并纯化获得可溶性mZP3蛋白,为mZP3免疫不育疫苗研制及其免疫效果检测提供了可溶性抗原。     

Optimizing the expression of a monoclonal antibody fragment under the transcriptional control of the Escherichia coli lac promoter

The expression of a monoclonal antibody Fab fragment in Escherichia coli strain RB791/pComb3, induced with either lactose or isopropyl-beta-D-thiogalactoside (IPTG), was compared to determine if lactose might provide an inexpensive alternative to induction with IPTG. Induction of Fab expression imposed a metabolic load on the recombinant cells, resulting in lower final cell yields compared to the non-induced controls. An IPTG concentration of 0.05 mM was sufficient to achieve maximal expression of soluble Fab protein when inducing in the early-, mid-, or late-log phases of batch cultures grown using either glucose or glycerol as a carbon source. The largest overall yield of Fab fragments when using 0.05 mM IPTG was achieved by increasing the final yield of cells through glycerol feeding following induction in late-log phase. Lactose was as effective as IPTG for inducing Fab expression in E. coli RB791/pComb3. The greatest overall level of Fab expression was found when cells grown on glycerol were induced with 2 g/L lactose in late-log phase. Since the cost of 0.05 mM of IPTG is significantly greater than the cost of 2 g/L lactose, lactose provides an inexpensive alternative to IPTG for inducing the expression of Fab fragments, and possibly other recombinant proteins, from the E. coli lac promoter.     

Batch and Fed-Batch Cultivation for Excretive Production of Human Epidermal Growth Factor (hEGF) with Recombinant E. Coli K12 System

Abstract

Batch and fed-batch production of recombinant human epidermal growth factor (hEGF) was studied in an E. coli secretary expression system. By using MMBL medium containing 5 g/L glucose, controlling the temperature at 32°C and maintaining the dissolved oxgen level over 20% saturation, a high yield of hEGF (32 mg/L) was obtained after an 18 hr batch cultivation with 0.2 mM IPTG induction at mid-log phase. Three different glucose feeding strategies were employed to further improve hEGF productivity in a bench top fermentor. Compared with the batch results, hEGF yield was improved up to 25.5% or 28.1%, respectively by intermittent or pH-stat glucose feeding, and up to 150% improvement of hEGF production was achieved by constant feeding of 200 g/L glucose solution at a rate of 0.11 mL/min. The effects of further combined feeding with other medium components and inducer on hEGF yield were also examined in the benchtop fermentor. This work is very helpful to further improve the productivity of extracellular hEGF in the recombinant E. coli system.     

cDNA Cloning and Functional Expression of the α-<Emphasis Type="SmallCaps">d</Emphasis>-Galactose-Binding Lectin Frutalin in <Emphasis Type="Italic">Escherichia coli</Emphasis>

cDNA clones encoding frutalin, the α-d-galactose-binding lectin expressed in breadfruit seeds (Artocarpus incisa), were isolated and sequenced. The deduced amino acid sequences indicated that frutalin may be encoded by a family of genes. The NCBI database searches revealed that the frutalin sequence is highly homologous with jacalin and mornigaG sequences. Frutalin cDNA was re-amplified and cloned into the commercial expression vector pET-25b(+) for frutalin production in Escherichia coli. An experimental factorial design was employed to maximise the soluble expression of the recombinant lectin. The results indicated that temperature, time of induction, concentration of IPTG and the interaction between the concentration of IPTG and the time of induction had the most significant effects on the soluble expression level of recombinant frutalin. The optimal culture conditions were as follows: induction with 1 mM IPTG at 22°C for 20 h, yielding 16 mg/l of soluble recombinant frutalin. SDS-PAGE and Western blot analysis revealed that recombinant frutalin was successfully expressed by bacteria with the expected molecular weight (17 kDa). These analyses also showed that recombinant frutalin was mainly produced as insoluble protein. Recombinant frutalin produced by bacteria revealed agglutination properties and carbohydrate-binding specificity similar to the native breadfruit lectin.     

Functional expression of anti-hepatitis B virus (HBV) preS2 antigen scFv by <Emphasis Type="Italic">cspA</Emphasis> promoter system in <Emphasis Type="Italic">Escherichia coli</Emphasis> and application as a recognition molecule for single-walled carbon nanotube (SWNT) field effect transistor (FET)

The preS2 antigens of hepatitis B virus (HBV), which causes a serious health problem in the world, have been implicated in hepatocyte cell binding and viral penetration. Therefore, the importance of antibody production against preS2 antigen for early diagnosis of HBV has been well established. In this study, the recombinant HBV preS2 single chain variable fragment (scFv) antibody was successfully expressed in E. coli with the novel cold shock vector (pCold) under the cspA promoter, and its expression level was compared with the pET vector under the T7 promoter. Additionally, a host with an oxidizing cytoplasm, E. coli trxB/gor double mutant, was used to improve the soluble expression. The anti-HBV preS2 scFv using pCold vector was successfully expressed in a soluble and functional form in both wild type and double mutant E. coli, while the scFv using the pET vector was expressed in an insoluble form in spite of using a double mutant providing an oxidizing environment. The induction with 0.05 mM IPTG showed a 2-fold higher functional expression compared to induction with 1 mM IPTG, and the functional expression at the induction temperature (15°C), which is optimal temperature for pCold vector, was improved 2-fold and 3- fold at 4 and 25°C, respectively. The efficacy of anti-HBV preS2 scFv for detecting HBV preS2 antigen was tested and verified by using Ni-decorated single-walled carbon nanotube (SWNT) field effect transistors.     

Cloning and optimization of induction conditions for mature PsaA (pneumococcal surface adhesin A) expression in Escherichia coli and recombinant protein stability during long-term storage

The gene corresponding to mature PsaA from Streptococcus pneumoniae serotype 14 was cloned into a plasmid with kanamycin resistance and without a purification tag in Escherichia coli to express high levels of the recombinant protein for large-scale production as a potential vaccine candidate or as a carrier for polysaccharide conjugation at Bio-Manguinhos/Fiocruz. The evaluation of induction conditions (IPTG concentration, temperature and time) in E. coli was accomplished by experimental design techniques to enhance the expression level of mature recombinant PsaA (rPsaA). The optimization of induction process conditions led us to perform the recombinant protein induction at 25°C for 16 h, with 0.1mM IPTG in Terrific Broth medium. At these conditions, the level of mature rPsaA expression obtained in E. coli BL21 (DE3) Star by pET28a induction with IPTG was in the range of 0.8 g/L of culture medium, with a 10-fold lower concentration of inducer than usually employed, which contributes to a less expensive process. Mature rPsaA expressed in E. coli BL21 (DE3) Star accounted for approximately 30-35% of the total protein. rPsaA purification by ion exchange allowed the production of high-purity recombinant protein without fusion tags. The results presented in this work confirm that the purified recombinant protein maintains its stability and integrity for long periods of time in various storage conditions (temperatures of 4 or -70°C using different cryoprotectors) and for at least 3 years at 4 or -70°C in PBS. The conformation of the stored protein was confirmed using circular dichroism. Mature rPsaA antigenicity was proven by anti-rPsaA mouse serum recognition through western blot analysis, and no protein degradation was detected after long periods of storage.     

桑氏链霉菌几丁质酶ChiKJ40基因的克隆表达及其抑菌作用

【背景】目前关于桑氏链霉菌(Streptomyces sampsonii)生防基因的研究不多,仅从其基因组中克隆了2个几丁质酶基因片段,其单个几丁质酶的完整基因序列相关研究未见报道。【目的】克隆S.sampsonii KJ40的几丁质酶基因Chi KJ40并进行原核表达,纯化重组蛋白并研究其抑菌作用。【方法】采用PCR扩增法从S.sampsonii KJ40中克隆几丁质酶基因Chi KJ40,连接到表达载体p ET-32a,导入Escherichia coli BL21(DE3)进行诱导表达。使用His标记蛋白质微量纯化试剂盒对重组几丁质酶进行纯化,Bradford蛋白浓度测定试剂盒测定粗酶液和纯化酶液的浓度,几丁质酶试剂盒测定粗酶液和纯化酶液的几丁质酶活性。观察重组几丁质酶对桉树焦枯病菌(Cylindrocladium scoparium)、栗疫病菌(Cryphonectria parasitica)、链格孢菌(Alternaria alternate)、紫丝核菌(Rhizoctonia violacea)几种致病真菌的抑菌作用。【结果】Chi KJ40基因(登录号为MF434484)在E.coli中经IPTG诱导表达,获得42 k D的重组几丁质酶,不同浓度IPTG在37°C诱导3 h,蛋白产量无明显变化。0.2 mmol/L IPTG 16°C诱导过夜,重组几丁质酶主要以可溶性形式存在于上清,小部分以包涵体存在于沉淀中。粗酶液几丁质酶活性为0.080 U/m L,酶比活力为0.041 U/mg,纯化酶液几丁质酶活性为0.046 U/m L,酶比活力为0.115 U/mg,纯化倍数为2.8,酶活回收率为57.5%。重组几丁质酶处理后,C.scoparium、C.parasitica和A.alternata菌丝细胞出现分节、膨胀,R.violacea菌丝溶解且部分被破坏成碎片。【结论】Chi KJ40基因的研究补充了S.sampsonii的生防背景,为几丁质酶基因找到了新的来源,并为其应用奠定了理论基础。     

结核分枝杆菌H37Rv新基因Rv2742克隆表达及纯化

Rv2742是本课题组前期基于蛋白质基因组学策略从结核分枝杆菌Mycobacteriumtuberculosis H37Rv中发现、鉴定的遗漏注释基因。文中旨在建立结核分枝杆菌H37Rv漏注释蛋白Rv2742的可溶性诱导表达、纯化体系,为进一步探索Rv2742基因参与的生物学功能奠定基础。前期实验发现构建的pGEX-4T-2-Rv2742、pET-28a-Rv2742、pET-32a-Rv2742及pMAL-c2X-Rv2742原核表达载体均无法实现目的蛋白的诱导表达。但经密码子优化后,仅有pMAL-c2X-Rv2742载体能够实现目的蛋白的可溶性诱导表达。此外,通过比较不同宿主菌、温度及IPTG浓度对目的蛋白表达量的影响,发现目的蛋白在Rosetta (DE3)中,16℃及0.5mmol/LIPTG诱导条件下表达量最高。直链淀粉树脂(Amyloseresin)亲和层析柱纯化获得较纯的产物,经LC-MS/MS验证确认是Rv2742融合蛋白肽段序列。成功获得结核分枝杆菌H37Rv新基因Rv2742的重组蛋白,可进一步开展其潜在相互作用及免疫原性研究工作。     

Recombinant Hemoglobin II From Lucina pectinata: A Large-Scale Method For Hemeprotein Expression in E. coli

Hemoglobin II from the clam L. pectinata is an O₂ reactive protein that remains oxygenated in the presence of other molecules. To determine the mechanism of ligand selection in this hemoglobin, rHbII was expressed in large quantities using an improved fermentation process. The highest protein yield was obtained by: transforming HbII into the BLi5 cells, inducing and supplementing the culture during the mid-log phase with 1 mM IPTG, 30 μg/mL hemin chloride and 1% glucose, and decreasing the temperature to 30 °C after induction. In addition, cell culture density was greatly enhanced by using glycerol, adding MgSO₄, supplementing the media with glucose after the glycerol was consumed and maintaining the dissolved oxygen at 35%. Under these conditions the maximum protein yield obtained was ~2,300 mg/L. The results indicate that rHbII is similar to the native protein. The protocol was validated with other hemoglobins, indicating that it can be extended to other hemeproteins.     

Purification and characterization of novel antifungal peptide,mouse beta defensin-1, in Escherichia coli

Mouse beta defensin-1 (mBD-1) is a cationic peptide with broad antimicrobial activity. The mBD-1 gene was cloned and fused with TrxA to construct pET32-mBD1, which was transformed into E. coli BL21 (DE3). The optimal expression conditions of fusion protein TrxA–mBD1 were: cultivation at 32°C in 2 × YT medium, induction with 0.2 mM isopropylthio-d-galactoside (IPTG), and post-induction expression for 8 h. The fusion protein was highly soluble (90.0%) and accounted for 65% of the total soluble protein; and its volumetric productivity reached 0.67 g/l, i.e., 0.14 g/l of recombinant mBD-1. At 5 μM, purified recombinant mBD-1 killed 50% of Candida albicans. Electronic supplementary material  The online version of this article (doi:) contains supplementary material, which is available to authorized users.     

Identification of quinone-binding and heme-ligating residues of the smallest membrane-anchoring subunit (QPs3) of bovine heart mitochondrial succinate:ubiquinone reductase

The smallest membrane-anchoring subunit (QPs3) of bovine heart succinate:ubiquinone reductase was overexpressed in Escherichia coli JM109 as a glutathione S-transferase fusion protein using the expression vector pGEX2T/QPs3. The yield of soluble active recombinant glutathione S-transferase-QPs3 fusion protein was isopropyl-1-thio-beta-D-galactopyranoside concentration-, induction growth time-, temperature-, and medium-dependent. Maximum yield of soluble recombinant fusion protein was obtained from cells harvested 3.5 h post-isopropyl-1-thio-beta-D-galactopyranoside (0.4 mM)-induction growth at 25 degrees C in 2.0% tryptone, 0.5% yeast extract, 10 mM NaCl, 2.5 mM KCl, 10 mM MgCl2, 20 mM glucose (SOC medium) containing 440 mM sorbitol and 2.5 mM betaine. QPs3 was released from the fusion protein by proteolytic cleavage with thrombin. Isolated recombinant QPs3 shows one protein band in sodium dodecyl sulfate-polyacrylamide gel electrophoresis that corresponds to subunit V of mitochondrial succinate:ubiquinone reductase. Although purified recombinant QPs3 is dispersed in 0.01% dodecylmaltoside, it is in a highly aggregated form, with an apparent molecular mass of more than 1 million. The recombinant QPs3 binds ubiquinone, causing a spectral blue shift. Upon titration of the recombinant protein with ubiquinone, a saturation behavior is observed, suggesting that the binding is specific and that recombinant QPs3 may be in the functionally active state. Two amino acid residues, serine 33 and tyrosine 37, in the putative ubiquinone binding domain of QPs3 are involved in ubiquinone binding because the S33A- or Y37A-substituted recombinant QPs3s do not cause the spectral blue shift of ubiquinone. Although recombinant QPs3 contains little cytochrome b560 heme, the spectral characteristics of cytochrome b560 are reconstituted upon addition of hemin chloride. Reconstituted cytochrome b560 in recombinant QPs3 shows a EPR signal at g = 2.92. Histidine residues at positions 46 and 60 are responsible for heme ligation because the H46N- or H60N-substituted QPs3 fail to restore cytochrome b560 upon addition of hemin chloride.     

人乳头瘤病毒16型E7蛋白的原核表达与鉴定

本研究在大肠杆菌BL21中融合表达人乳头瘤病毒16型E7蛋白,并初步评价其应用价值。采用PCR技术扩增出HPV16E7基因,将其克隆进原核表达载体pGEX6p-1,转化至大肠杆菌BL21,利用IPTG进行诱导表达。以纯化的融合蛋白作为检测抗原建立间接ELISA方法,用于检测重组李斯特菌(Lm1-2-E7)免疫小鼠后的E7血清抗体水平。在25℃,0.5mM IPTG诱导下,HPV16E7蛋白在大肠杆菌BL21中获得表达,融合蛋白以可溶性形式存在,Western blot结果显示其与HPV16E7单克隆抗体发生特异性反应。二次免疫后小鼠血清经间接ELISA结果表明E7特异性抗体滴度为1∶200。结果表明GST-E7融合蛋白具有较强的免疫活性。     

Expression and Activity Analysis of Fructosyltransferase from <Emphasis Type="Italic">Aspergillus oryzae</Emphasis>

The fructosyltransferase gene was isolated and cloned from Aspergillus oryzae. The gene was 1368 bp, which encoded a protein of 455 amino acids. To analyze the activity of the expressed fructosyltransferase, the pET32a-fructosyltransferase recombined plasmid was transformed into Escherichia coli BL21. The fructosyltransferase gene was successfully expressed by Isopropyl-β-d-thiogalactoside (IPTG) induction. The molecular weight of the expression protein was about 45 kDa. The optimal conditions of protein expression were 25?°C, 0.1 mM IPTG, and 8 h of inducing time. The optimal concentration of urea dealing with inclusion body was 2.5 M. The expressed protein exhibited a strong fructosyl transfer activity. These results showed that the expressed fructosyltransferas owned transferase activity, and could catalyze the synthesis of sucrose-6-acetate.     

Production and purification of the phosphoprotein of Nipah virus in <Emphasis Type="Italic">Escherichia coli</Emphasis> for use in diagnostic assays

Nipah Virus (NiV) is an emerging zoonotic paramyxovirus that can be fatal in humans and various types of animals. The phospho (P) protein of NiV plays an important role in RNA synthesis, replication, and genome synthesis. In this study, the NiV P gene was cloned into a pTrcHis2-TOPO vector and the recombinant protein containing a His-tag was produced in Escherichia coli. SDS-PAGE and Western blot analysis using the anti-His antibody confirmed the protein expression. An optimization study of E. coli fermentation showed that the optimal cultivation temperature was 37°C, while the optimal induction time for P protein expression was at 9 h with 1 mM IPTG. Solubility analysis showed that E. coli cultivated at 37°C produced the highest fraction (70%) of soluble P protein. The recombinant P protein was purified from clarified E. coli lysate using an immobilized metal affinity chromatography (IMAC) technique to a purity of 92.67%, with a purification factor of 11.58. The purified P protein strongly reacted with the anti-NiV swine sera collected during a NiV outbreak, suggesting its potential as a diagnostic reagent.     

A recombinant vaccine against hydatidosis: production of the antigen in Escherichia coli

A commercial process was developed for producing a recombinant vaccine against hydatidosis in farm animals. The vaccine antigen consisting of a surface protein of the oncospheres of the hydatid worm (Echinococcus granulosus), was produced as inclusion bodies in Escherichia coli. Fed-batch cultures of E. coli using Terrific broth in stirred bioreactors at 37°C, pH 7.0, and a dissolved oxygen level of 30% of air saturation produced the highest volumetric concentrations of the final solubilized antigen. An exponential feeding strategy proved distinctly superior to feeding based on pH-stat and DO-stat methods. The plasmid coding for the antigen was induced with isopropyl-β-D-thiogalactopyranoside (IPTG) at 4 h after initiation of the culture. The minimum IPTG concentration for full induction was 0.1 mM.     

Overexpression and purification of PreS region of hepatitis B virus antigenic surface protein adr subtype in Escherichia coli

PreS domain of Hepatitis B virus (HBV) surface antigen is a good candidate for an effective vaccine as it activates both B and T cells besides binding to hepatocytes. This report deals with overexpression and purification of adr subtype of surface antigen that is more prevalent in Pakistan. PreS region, comprising 119 aa preS1 region plus a 55 aa preS2 region plus 11 aa from the N-terminal S region, was inserted in pET21a+ vector, cloned in E. coli DH5alpha cells and expressed in E. coli BL21 codon+ cells. The conditions for over expression were optimized using different concentrations of IPTG (0.01-5 mM), and incubating the cells at different temperatures (23-41 degrees C) for different durations (0-6 h). The cells were grown under the given optimized conditions (0.5 mM IPTG concentration at 37 degrees C for 4 h), lysed by sonication and the protein was purified by ion exchange chromatography. On the average, 24.5 mg of recombinant protein was purified per liter of culture. The purified protein was later lyophilized and stored at -80 degrees.     

重组阳离子抗肿瘤肽AIK的原核表达、纯化及活性测定

利用Gateway克隆技术构建重组抗瘤肽AIK的原核表达体系,建立表达及纯化重组AIK的最优条件,为深入研究和利用AIK奠定基础。首先,设计含AttB重组位点的引物,通过重叠PCR技术扩增出Att B-TEV-FLAG-AIK序列,利用BP重组反应将目的序列TEV-FLAG-AIK克隆到供体载体pDONR223中,构建入门载体,再通过LR重组反应,将目的序列转移到目的载体pDEST15中,构建GST-AIK融合蛋白原核表达质粒。随后,在BL21(DE3)工程菌中优化诱导融合蛋白表达的条件。以谷胱甘肽磁珠纯化GST-AIK融合蛋白,再以rTEV酶切除GST,获得FLAG-AIK重组蛋白。最后以MTS法检测FLAG-AIK对白血病细胞HL-60的细胞毒性。菌液PCR验证和测序分析表明成功构建了重组抗瘤肽AIK的入门质粒和原核表达质粒。在BL21(DE3)工程菌中实现了GST-AIK融合蛋白的高效可溶性表达。并测得在37℃下以0.1 mmol/L IPTG诱导工程菌(OD600=1.0)4 h,重组蛋白表达量占菌体总蛋白的30%以上。经GST亲和层析、rTEV酶切除GST标签及二次GST亲和层析获得纯度高于95%的FLAG-AIK蛋白。MTS法测得所制备的FLAG-AIK蛋白抑瘤活性与化学合成的AIK相当。总之,本课题应用Gateway克隆系统成功构建了抗瘤肽AIK的原核表达质粒,实现了GST-AIK融合蛋白的高效可溶性表达,经亲和层析获得了有生物活性的重组AIK多肽,为后续深入研究和大规模制备奠定了基础。