Simultaneous occurrence of mycotoxins in human food commodities from Cameroon

Eighty-two samples of dried food commodities from Cameroon were screened and quantified for different mycotoxins, including fumonisin B₁ (FB₁), zearalenone (ZEA), deoxynivalenol (DON), aflatoxin (AF) and ochratoxin A (OTA), by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC), respectively. The percentage of positive samples was as follows: FB₁ 41%, AF 51%, ZEA 57%, DON 65% and OTA 3%. High FB₁ contents were found in maize, averaging 3,684 μg/kg (range: 37-24,225 μg/kg), whereas the highest average ZEA level was found in peanuts (70 μg/kg), followed by maize (69 μg/kg), rice (67 μg/kg) and beans (48 μg/kg) with no ZEA was detected in soybeans. DON contents were low, ranging from 13 to 273 μg/kg, and for AF the average content was 2.6 μg/kg with peanuts and maize as principal substrates. The incidence of OTA was low, with a mean level of 6.4 μg/kg recorded. The majority (79%) of samples contained more than one mycotoxin and the most frequent co-occurrence found was FB₁ + ZEA + DON, detected in 21% of samples (mainly maize) analysed. Co-contamination with FB₁ + ZEA + DON + AF was found in 11% of the samples. Although a large proportion of samples had fairly low levels of individual mycotoxins, this should be of concern as the co-occurrence of mycotoxins may generate additive or synergistic effect in humans, especially if the respective commodities are consumed almost on a daily basis.     

Survey and risk assessment of the mycotoxins deoxynivalenol,zearalenone, fumonisins,ochratoxin A,and aflatoxins in commercial dry dog food

The aim of the present study was to investigate the occurrence of mycotoxins in commercial dog food, as a basis to estimate the risk of adverse effects. Seventy-six dry dog food samples from 27 producers were purchased from retail shops, supermarkets, and specialized pet food shops in Vienna, Austria. The frequency and levels of deoxynivalenol (DON), zearalenone (ZEA), fumonisins (FUM), ochratoxin A (OTA). and aflatoxins (AF) in dry dog food were determined. Mycotoxin analysis were performed by commercial enzyme-linked immunosorbent assay (ELISA) test kits. Confirmatory analyses were done for DON, ZEA, and FUM by high performance liquid chromatography (HPLC) after extract clean-up with immunoaffinity columns. The correlations between ELISA and HPLC results for DON and ZEA were acceptable and indicated that ELISA could be a simple, low cost, and sensitive screening tool for mycotoxins detection, contributing to quality and safety of pet food. DON was the mycotoxin most frequently found (83% positives; median 308 μg/kg, maximum 1,390 μg/kg). ZEA (47% positives, median 51 μg/kg and maximum 298 μg/kg) and FUM (42% positives, median 122 μg/kg and maximum 568 μg/kg) were also frequently detected in dog food. OTA was less frequently found (5%, median 3.6 μg/kg, maximum 4.7 μg/kg. AF were not detected (<0.5 μg/kg) in any sample. The results show that dry dog food marketed in Vienna are frequently contaminated with mycotoxins (DON > ZEA > FUM > OTA) in low concentrations, but do not contain AF. The high frequency of Fusarium toxins DON, ZEA, and FUM indicates the need for intensive control measures to prevent mycotoxins in dog foods. The mycotoxin levels found in dry dog food are considered as safe in aspects of acute mycotoxicoses. However, repeated and long-time exposure of dogs to low levels of mycotoxins may pose a health risk.     

Fusarium spp. and Fusarium mycotoxins in maize: a problem for Flanders?

Fusarium species cause not only root, stem and ear rot with severe reductions in crop yield, they produce also toxic secondary metabolites (mycotoxins) such as deoxynivalenol (DON) and zearalenone (ZEA). During several growing seasons the presence of Fusarium spp was followed up. DON and ZEA were determined and related to infection levels. The distribution of DON and ZEA in the different plant parts was studied as well as the influence of the ensiling process on the mycotoxin content. More or less important varietal differences in susceptibility for Fusarium spp. could be detected. DON and ZEA were clearly present in most of the analysed samples. No clear relationship could be detected between visual disease symptoms and mycotoxin content. The accumulation of DON and ZEA was different for the analysed aerial plant parts. The ensiling process gave no reduction of the mycotoxin content.     

Trichothecene Content of Rye and Wheat Genotypes Inoculated with a Deoxynivalenol- and a Nivalenol-producing Isolate of Fusarium culmorum

Head blight caused by Fusarium culmorum may lead to yield reduction and the contamination of cereal grain with the mycotoxins deoxynivalenol (DON), 3-acetyl deoxynivalenol (3-ADON), nivalenol (NIV), fusarenone-X (FUS), and others. In this study, the covariation between DON and NIV accumulation of 12 rye and eight wheat genotypes that differed in resistance were analysed by inoculating them with a DON-and a NIV-producing isolate, respectively, in three locations. The resistance traits head blight rating and plot yield relative to the uninoculated plots of the same genotype were assessed and the contents of DON, 3-ADON, NIV, and FUS in the grain were analysed by gas chromatography with mass spectrometry. The NIV-producing isolate was significantly (P=0.05) less aggressive and led to a considerably lower mean NIV content in the grain compared with the aggressiveness and mean DON content of the DON-producing isolate (19.5 mg NIV/kg grain versus 48.4 mg DON/kg). Wheat and rye genotypes significantly differed in their DON and NIV accumulation. All genotypes reacted in a similar manner to both chemotypes of F. culmorum for the resistance traits and the respective mycotoxin contents with the exception of one wheat variety, that caused a change in rank order for mycotoxin content. In conclusion, resistance to head blight and tolerance to mycotoxin accumulation seems to be most likely the same for DON- and NIV-producing isolates of F. culmorum .     

Mykotoxine in futtergetreideproben aus landwirtschaftlichen Betrieben in Bayern (Ernte 1991-2000)

Feed grain production for on-farm use is widespread in Bavarian agriculture and garants a reliable production of healthy foodstuff. Therefore the quality of feed grain is very important for farmers. In an orientating investigation of the on-farm stored feed grain quality from the harvest years 1991 to 2000 1757 samples were analysed. Based on values for guidance by the German government for DON and ZEA and Commission Regulation EC No 472/2002 for OTA the results show that only 2% of the positive samples have amounts higher then 0,05 mg ZEA/kg grain, 4% of the positive samples contain more then 1 mg DON/kg grain and 2% of the positive samples have amounts higher then 0,003 mg OTA/kg feed grain. These illustrate the good conservation and storage quality on Bavarian farms.     

Airborne mycotoxins in dust from grain elevators

Workers in grain elevators are exposed to grain dust and may therefore have an increased risk of inhalatory contact with mycotoxins. To study the mycotoxin burden of such environments, settled grain dust samples (n=35) were collected from several locations of a total of 13 grain elevators in Germany, and analysed for ochratoxin A (OTA, detection limit 0.01 ng/g), deoxynivalenol (DON, detection limit 15 ng/g), and zearalenone (ZEA, detection limit 6 ng/g), respectively. Cytotoxicity of these samples was assessed by a MTT bioassay with a swine kidney target cell line. Additionally, the airborne dust concentration of these locations was determined. Nearly all settled dust samples contained OTA (96%), DON (100%), and ZEA (100%) with median concentrations of 0.4 ng/g, 416 ng/g, and 126 ng/g, respectively. Cytotoxic effects in varying degrees from weakly to highly toxic were caused by crude extracts of 86% of the dust samples. However, cytotoxicity did not correlate with mycotoxin levels in these samples and thus indicated the presence of cytotoxic compounds of unknown origin. Based on the mycotoxin findings in settled dust samples and the airborne dust concentrations, the average airborne mycotoxin concentrations were estimated to be 0.002 ng/m³ (OTA), 2 ng/m³ (DON), and 1 ng/m³ (ZEA), respectively. The relevance of these findings for occupational health was assessed by comparison with WHO recommendations for the maximum tolerable daily (oral) intake (TDI). Even in a worst case scenario, the calculated inhalatory intake was far below the TDI values. However, considering the uncertainties resulting from different exposure pathways, namely oral ingestion versus inhalation, further research should primarily address the problem of how adequate assessment criteria for airborne exposure to mycotoxins could be established. Presented at the 28^th Mykotoxin-Workshop, Bydgoszcz, Poland, May 29–31, 2006     

Nachweis von Fusarien und deren Mykotoxinen in Futterkonservaten aus Grünlandbeständen mit differenzierter Bewirtschaftungsintensität

Conservation forage (17 hay and 18 grass silage samples) from 15 farms with different intensities of grassland management in the Federal State of Brandenburg were examined for contamination with fusaria and their mycotoxins. The numbers of culturable filamentous fungi in hay were determined by plate counting andFusarium isolates were classified taxonomically. The mycotoxins Zearalenone (ZEA) and Deoxynivalenol (DON) were extracted from hay as well as silage by different procedures and detected chromatographically (HPLC). The numbers of filamentous fungi in the hay samples were 10² and 10⁶ CFU/g FM independently of intensive or extensive management. Only fourFusarium species were identified.Fusarium culmorum, a potential toxin producing species, was most frequently detected (52% of all isolates). ZEA was found in two hay and four silage samples (6-66 μg/kg), DON in three hay and seven silage samples (63–1290 μg/kg). There were no differences between forage samples of extensive and intensive cultivated grassland of the year 2003 regarding numbers of fusaria and the content of their mycotoxins.

Presented at the 26^th Mykotoxin-Workshop in Herrsching, Germany, May 17–19, 2004.     

Determination of trichothecenes, zearalenone and zearalenols in commercially available corn-based foods in Spain

Among the main Spanish commercially available trademarks, we have selected a total of 25 samples of corn-based foods, which have the highest consume rate, to carry out the analysis of deoxynivalenol (DON), T-2 toxin, zearalenone (ZEA) and zearalenols (ZOL). The contents of mycotoxins were determined by gas chromatography with flame ionization detection, and those of ZEA were confirmed by HPLC with fluorescence detection. Of the 25 analyzed samples, the incidence of DON, ZEA and alfa-ZOL was 68, 44 and 24%, respectively; levels detected ranged from 29-195, 34-216, and 36-71 microg/kg, respectively. T-2 toxin was only detected in one sample (<50 microg/kg). Beta-ZOL was not present in excess of the detection limit in the investigated samples. The results suggest a risk for consumers of corn products and the need to monitor the final products before consumption. This is the first report in Spain on natural contamination with these mycotoxins in corn-based foods.     

Mycotoxins in several Polish food products in 2004–2005

In 2004–2005, samples of several selected Polish foods such as cereal products, nuts, dried fruits, coffee and culinary spices collected from Warsaw market and taken from food producers were analyzed on presence of aflatoxin B₁, B₂, G₁, G₂ (AF), ochratoxin A (OTA), zearalenone (ZEA) and deoxynivalenol (DON). After extraction and clean-up of extracts on immunoaffinity columns (IAC), mycotoxin analyses were carried out by HPLC using fluorescence and UV detectors. The concentrations of aflatoxins and ochratoxin A depending on the kind of sample ranged from 0.02 to 7.8 (one sample, of peanuts) and 0.02–11.9 μg/kg (one coffee sample), respectively. The levels of ZEA and DON were found to be below 50 °g/kg.     

Cumulation of mycotoxins in maize cobs infected with<Emphasis Type="Italic">Fusarium gramihearum</Emphasis>

Maize cobs withFusarium ear rot were collected at 1986 season and five infected byFusarium graminearum were analyzed for presence of triohothecenes and zearalenone. Collected material was subsampled forFusarium damaged kernels and corresponding axial stems and healthy looking kernels. All investigated cobs contained deoxynivalenol (DON) (range 18.0–131.5 mg/kg) and zearalenone (ZEA) (range 0.38–2.17 mg/kg), in four cobs 15-acetyl-deoxynivalenol (15-AcDON) (range 5.2–6.2 mg/kg) was present and two cobs besides three all metabolites contained 3-acetyl-deoxynivalenol (3-AcD0N) (range 0.5–0.8 mg/kg).The average of individual toxins amount in axial stems: in mg/kg was equal to: DON — 110.36, ZEA — 4.57, 15-AcD0N — 16.66, and 3-AcD0N — 1.32.Fusarium damaged kernels contained in average the following amount (mg/kg) of: DON 77.00, ZEA 0.98, 15-AcD0N 3.78 and 3-AcD0N 0.06. Healthy looking kernels contained DON 1.96 mg/kg and ZEA 0.07 mg/kg only. Cooccurrence of 3-AcDON and 15-AcDON in two samples was an interesting finding. The amount of DON in total cob was highly correlated (r = 0.94) with percentage ofFusarium damaged kernels in given ear.     

Grundfutterqualität in Sachsen: Ergebnisse der mykotoxikologischen Untersuchungen an Silomais der Jahre 1997–2003

Maize for silage purposes is investigated on Zeralenone (ZEA) and Deoxynivalenol (DON) in Saxony since 1997. About 45 samples from various regions of Saxony are analyzed every year. The occurrence of DON and ZEA was proved for 20 to 90% of all samples. Most of the samples showed both of these toxins. The quantity of the detected toxins was generally very low, even in so called “Fusarium years” only 20% of samples exceeded the lowest border of orientation values for critical dietary concentrations in cattle feed. We observed a higher contamination with DON in samples from the region “Erzgebirge” and clear higher contents of ZEA in the region “Sächsisches Heideland”. Correlation between toxin content and other parameters like cultivation, pre-fruit etc. were not observed, probably because of masking these effects by variety and location.     

Occurrence of<Emphasis Type="Italic">Fusarium</Emphasis> toxins in the 1999’s harvest

Continuing the monitoring ofFusarium toxins in cereals, we investigated 245 samples of wheat, barley, triticale and oats in 1999. 84 samples out of 100 analysed forFusarium could be found to be infected. The most prominentFusarium species detected whereF. avenaceum, F. poae, F. detected whereF. avenaceum, F. poae, F. graminearum, andF. sporotrichoides. The level of mycotoxin contamination of the samples varied depending on their origins and was in general very low in comparison with the result obtained in samples of the previous year. There where only some wheat samples with deoxynivalenol (DON) concentrations beyond existing advisory levels. The average DON concentration of all samples was 0.35 mg/kg with a median of 0.007 mg/kg. 3-Acetyldeoxynivalenol and zearalenone (ZEA) could only be detected at minor concentrations (below 0.1 and 0.05 mg/kg, respectively) in less than 10% of the samples. The analysis of commercial cereal flour reflects this situation. Flour bought in the first quarter of 1999, which was suspected to contain a high portion of the 1998 harvest, was contaminated by DON to a higher extent than those purchased in 2000. The average DON concentration in the flour samples of 1999 and 2000 was 0.35 mg/kg and 0.23 mg/kg, respectively. Although the general mycotoxin level in the 1999 harvest was lower as in 1998 there were some highly contaminated samples that had mainly been grown in fields with either maize or other cereals as previous crop and reduced tillage. The combination of maize as previous crop and non-tillage could be stated as most unsuitable, which promotes enhanced mycotoxin contamination, and should therefore be avoided.     

Deoxynivalenol in Mehlproben des Jahres 1999 aus dem Einzelhandel

To study the levels of deoxynivalenol (DON) in retail cereal products, wheat and rye samples were purchased in 1999 from supermarkets and “organic food” shops in Munich, Germany. DON was analysed by an enzyme immunoassay (EIA), 78 of these samples were additionally analysed by HPLC. The following contamination rates (%) and mean DON levels were found: wheat flour type 405 (n=42): 71%, 200 µg/kg; flour type 550 (n=9): 33%, 410 µg/kg; flour type 1050 (n=11): 91%, 370 µg/kg; bread-baking wheat premixes (n=14): 79%, 210 µg/kg; whole grain flour (n=20): 65%, 300 µg/kg; whole grain wheat (n=8): 75%, 280 µg/kg, wheat bran (n=20): 85%, 830 µg/kg; rye flour and grits (n=7): 29%, 120 µg/kg. HPLC confirmed the results obtained by EIA. Further analysis of 16 wheat flour (405) samples in May 2000 showed a similar frequency (69%) and mean DON level (270 µg/kg) as for samples from 1999. It is concluded that with DON levels in wheat for human consumption ranging from 200–400 µg/kg, the intake of DON has to be taken seriously in the light of the temporary tolerable daily intake of 1 µg DON per kg body weight as proposed within the European Union.     

Co-occurrence of mycotoxins in swine feed produced in Portugal

A total of 404 samples of commercial swine feed from Portugal feed mills were analysed by HPLC methods for the presence of mycotoxins: 277 samples of feed for fattening pigs were analysed for ochratoxin A (OTA), zearalenone (ZEA), and deoxynivalenol (DON), and 127 samples of feed for sows were analysed for ZEA and fumonisins (FB₁ + FB₂). Concerning feed for fattening pigs, 21 (7.6%) samples were positive for OTA, (2–6.8 μg/kg), 69 (24.9%) were positive for ZEA (5–73 μg/kg), and 47 (16.9%) were positive for DON (100–864 μg/kg). In feed for sows, the results showed 29.9% of positive samples for ZEA (5–57.7 μg/kg) and 8.7% positive samples for FB₁ and FB₂ (50–391.4 μg/kg). Co-occurrence of DON/ZEA was found most frequently, but simultaneous contamination with OTA/ZEA and OTA/DON was also found.     

Chemotaxonomic diagnostics: combining sucrose-water agar with TLC to discriminate <Emphasis Type="Italic">Fusarium graminearum</Emphasis> 3-acetyl-DON and 15-acetyl-DON chemotypes

Twelve randomly-selected isolates of Fusarium graminearum that produce 3-acetyl-deoxynivalenol (3-ADON) or 15-acetyl-deoxynivalenol (15-ADON) were screened by thin-layer chromatography (TLC) for their ability to produce ADON and zearalenone (ZEA) mycotoxins when grown on water agar containing different concentrations of sucrose. The results showed the ability of the F. graminearum 3-ADON chemotype population to produce DON and ZEA at a lower concentration range of sucrose (5-7%) compared with the 15-ADON chemotype (30-40%). The former distinction allows for sucrose-water agar to be employed as a rapid and simple differential medium, where two separate sucrose-gradient concentrations discriminate 3-ADON from 15-ADON populations. In the light of the shift in sugar concentrations occurring during the process of grain formation and maturation, the difference in mycotoxin production between the two populations is discussed with respect to predicting Fusarium head blight (FHB) epidemiology and accumulation of DON and ZEA.     

Hydrothermal treatment of naturally contaminated maize in the presence of sodium metabisulfite, methylamine and calcium hydroxide; effects on the concentration of zearalenone and deoxynivalenol

Fusarium toxin-contaminated ground maize was hydrothermally treated in the presence of different combinations of chemicals in order to simultaneously reduce zearalenone (ZEA) and deoxynivalenol (DON) concentrations. Treatments were carried out in a laboratory conditioner at 80 °C and 17 % moisture. Six different treatments were performed, consisting of 3 doses of methylamine (MMA; 2.5, 5 and 10 g/kg maize) at a constant dose of 5 g sodium metabisulfite (SBS)/kg, either with or without the addition of 20 g calcium hydroxide (Ca(OH)₂)/kg. The used maize was contaminated with approximately 45.99 mg DON/kg and 3.46 mg ZEA/kg. Without the addition of Ca(OH)₂, DON reductions reached approximately 82 % after 1-min treatment and the toxin disappeared nearly completely after 10 min when 2.5 or 5 g MMA were applied. ZEA concentrations were only marginally affected. In the presence of Ca(OH)₂, reductions in DON concentrations were lower, but were enhanced by increasing doses of MMA. ZEA concentrations were reduced by 72, 85 and 95 % within the first 5 min of the treatment at MMA dosages of 2.5, 5 and 10 g/kg maize, respectively. The application of SBS in combination with a strong alkaline during hydrothermal treatment seems to be a promising approach to simultaneously decontaminate even high amounts of DON and ZEA in ground maize and may contribute to reduce the toxin load of diets     

Exposure of oocytes to the Fusarium toxins zearalenone and deoxynivalenol causes aneuploidy and abnormal embryo development in pigs

Fungi of the Fusarium species can infect food and feed commodities and produce the mycotoxins zearalenone (ZEA) and deoxynivalenol (DON). Since both toxins have been reported to reduce fertility, the mechanisms of ZEA and DON on inhibition of oocyte maturation were examined. Pig oocytes were matured in the presence of ZEA (a mycotoxin with estrogenlike activity), 17beta-estradiol, and DON (all 3.12 micromol/L). Zearalenone, 17beta-estradiol, and DON inhibited oocyte maturation and caused approximately 34% of the oocytes to form an aberrant spindle. Different ratios of ZEA:DON did not lead to a more severe inhibition of oocyte maturation. Both mycotoxins caused abnormal formation of the meiotic spindle. The developmental competence of oocytes matured in the presence of mycotoxins was further investigated after in vitro fertilization. Presence of ZEA (3.12 micromol/L) during maturation reduced the percentages of oocytes that cleaved and formed a blastocyst to about 12%, compared with 25% of control oocytes. Maturation in the presence of equimolar concentrations of DON was not compatible with development. The ploidy of blastomeres from blastocysts derived from mycotoxin-exposed oocytes was analyzed with fluorescent in situ hybridization. All blastocysts, even those from the control group, contained at least one blastomere with abnormal ploidy, but the variation in the percentages of aneuploid blastomeres was significantly larger in embryos from oocytes exposed to mycotoxins. It is concluded that ZEA and DON can lead to abnormal spindle formation, leading to less fertile oocytes and embryos with abnormal ploidy, and that the effects of ZEA and DON are not synergistic.     

Differences in susceptibility of winter wheat varieties for Fusarium species under Belgian growing conditions

Fusarium head blight is an important disease of cereal crops caused by Fusarium species. It causes not only a reduction in yield, but most Fusarium species (F. graminearum. F. culmorum, F. avenaceum. F. poae) produce also a range of toxic metabolites such as deoxynivalenol (DON) and zearalenone (ZEA). The evaluation of Fusarium species was followed up under natural infection conditions during the growing seasons 2001--2002 and 2002--2003 in two varietal winter wheat experiments on the experimental farm of the Hogeschool Gent at Bottelare. Disease pressure, DON and ZEA content, different Fusarium species as well as growth and yield parameters were determined. In both years there were significant differences between the varieties concerning the susceptibility to Fusarium and the DON content. ZEA was not found in the kernels. The mean deoxynivalenol (DON) content was in 2002 (1,126 mg/kg) higher than in 2003 (0.879 mg/kg) although the mean disease severity was bigger in 2003 than in 2002 what means that the DON content was not always correlated with the disease severity. The Fusarium species most frequently identified in our two field trials (Bottelare) were F. graminearum and F. culmorum Varietal differences in susceptibility to Fusarium species and DON contamination could be detected.     

Histopathological and cytolosical abnormalities induced by fusarial toxins in mice (Mus musculus)

Three fusarial toxins vi z., zearal enone (ZEA), deoxynivalenol (DON) and T-2 were administered orally to mice (Mus musculus) under two different treatments. In the -first treatment, the toxins were -fed at the rate o-f 0.5 mg/kg body weight (ZEA), 3mg/kg body weight (DON), and 0.5mg/kg body weight (T-2) -for eight weeks (twice a week) . In another set o-f experiments the toxins were .given daily by mixing with the -feed at a concentration commonly -found in -food and -feed items as natural contaminants. The a-f-fected animals showed significant changes in body weight. T-2 toxins caused swelling o-f stomach in most o-f the treated animals. Portal and periportal fibrosis in liver was also very common. Enlargement o-f urinary bladder was observed in ZEA fed animals. Cytological studies in bonemarrow cells showed fragmentation, chromosome breaks, stickiness and clumping of chromosome.