Sodium nitrite and sorbic acid effects on Clostridium botulinum spore germination and total microbial growth in chicken frankfurter emulsions during temperature abuse.

Samples of (i) a control or of (ii) sodium nitrite-containing or (iii) sorbic acid-containing, mechanically deboned chicken meat frankfurter-type emulsions inoculated with Clostridium botulinum spores, or a combination of ii and iii, were temperature abuse at 27 degrees C. Spore germination and total microbial growth were followed and examined at specified times and until toxic samples were detected. The spores germinated within 3 days in both control and nitrite (20, 40 and 156 micrograms/g) treatments. Sorbic acid (0.2%) alone or in combination with nitrite (20, 40, and 156 micrograms/g) significantly (P less than 0.05) inhibited spore germinations. No significant germination was recorded until toxic samples were detected. A much longer incubation period was necessary for toxin to be formed in nitrite-sorbic acid combination treatments as contrasted with controls or nitrite and sorbic acid used individually. Total growth was not affected by the presence of nitrite, whereas sorbic acid appeared to depress it. Possible mechanisms explaining the effects of nitrite and sorbic acid on spore germination and growth are postulated.     

Effect of temperature on spore germination and vegetative cell growth of Clostridium botulinum.

Spore germination and vegetative growth of Clostridium botulinum type E strain VH at 2 to 50 degrees C were studied. At all of these temperatures, germination began immediately after the addition of the spores to the germination medium. Microscopic observations during germination revealed three types of spores: phase bright (ungerminated), phase variable (partially germinated), and phase dark (fully germinated). At all temperatures except 50 degrees C, there was a pronounced lag between the initial appearance of phase-variable spores and their eventual conversion to phase-dark spores. The number of partially germinated spores increased steadily, reaching 40 to 60% by 18 to 21 h of incubation. During this time, phase-dark, fully germinated spores developed slowly and did not exceed 28% in any of the samples. At 18 to 26 h of incubation, the rate of full germination increased abruptly four-fold. There was extensive and relatively rapid germination at 2 degrees C, the lowest temperature tested, yielding about 60% phase-variable spores by 18 h, which became phase-dark by 26 h of incubation. The optimum temperature for partial and full germination was consistently 9 degrees C. Germination at 50 degrees C was exceptionally rapid and was completed within 1 to 2 h, although 40% remained phase bright. Vegetative cells showed detectable growth at 6 to 41 degrees C, with a distinct optimum at 32.5 degrees C. No growth occurred at 50 degrees C, and only marginal growth was observed at 6 to 14 degrees C. The psychrophilic nature of the germination process coupled with the cold tolerance of vegetative growth appears to give C. botulinum type E an advantage in cold climates as well as in cold-stored foods.     

Factors influencing Clostridium botulinum spore germination, outgrowth, and toxin formation in acidified media.

Clostridium botulinum type A spores were inoculated at a level of 10(7) spores per ml into sterile beef media with protein concentrations of 1, 2, 3, 4, or 6% and acidified to pH values of 2.01 to 4.75 with hydrochloric acid or 4.19 to 4.60 with citric acid. All experimental manipulations, including blending, acidification, inoculation, incubation (30 degrees C), and analyses, were conducted in an anaerobic chamber-incubator in which atmospheric oxygen levels were maintained below 2 ppm (2 microliters/liter). Under these strict anaerobic conditions (oxidation-reduction values in media ranging from -370 to -391 mV), C. botulinum spores were consistently found to germinate, grow, and produce toxin below pH 4.6. The boundary between toxic and atoxic samples in HC1-acidified beef media was mediated by titratable acidity, pH, and protein concentration. A limiting acidity was not established for the citrate-acidified samples; all blends tested (1, 2, 3, and 4% protein and titratable acidities of 0.091 to 0.453%) became toxic within 5 weeks. At the same pH and protein concentration, citric acid was less effective than HC1 in preventing the germination of C. botulinum spores. Higher levels of cell proliferation in the beef protein, as well as enhanced gas production and putrefactive degradation, indicated that beef was a better substrate than soy for C. botulinum spores under these conditions. Reducing the inoculum to 10(4) delayed but did not prevent spore outgrowth and toxin release at pH levels below 4.6.     

The combined effect of incubation temperature, pH and sorbic acid on the probability of growth of non-proteolytic, type B Clostridium botulinum

L und , B.M., G raham , A.F., G eorge , S.M. & B rown , D. 1990. The combined effect of incubation temperature, pH and sorbic acid on the probability of growth of non-proteolytic, type B Clostridium botulinum. Journal of Applied Bacteriology 69 , 481–492.
It has been reported that non-proteolytic strains of Clostridium botulinum will grow at 3.3°C, and they are therefore of concern in relation to certain chilled foods. The effects of combinations of inhibitory factors may be used to reduce the risk of growth of these bacteria in foods. The combined effect of pH values between 4.8 and 7.0, temperatures between 6° and 30°C, and sorbic acid concentrations up to 2270 mg/1 on the probability of growth from a single spore of non-proteolytic, type B strains in a culture medium has been determined. A mathematical model has been developed that enables the effect of varying combinations of these factors on the probability of growth of non-proteolytic, type B Cl. botulinum to be predicted.     

The combined effect of incubation temperature, pH and sorbic acid on the probability of growth of non-proteolytic, type B Clostridium botulinum

It has been reported that non-proteolytic strains of Clostridium botulinum will grow at 3.3 degrees C, and they are therefore of concern in relation to certain chilled foods. The effects of combinations of inhibitory factors may be used to reduce the risk of growth of these bacteria in foods. The combined effect of pH values between 4.8 and 7.0, temperatures between 6 degrees and 30 degrees C, and sorbic acid concentrations up to 2270 mg/l on the probability of growth from a single spore of non-proteolytic, type B strains in a culture medium has been determined. A mathematical model has been developed that enables the effect of varying combinations of these factors on the probability of growth of non-proteolytic, type B Cl. botulinum to be predicted.     

Mechanisms of sorbate inhibition of Bacillus cereus T and Clostridium botulinum 62A spore germination.

The mechanism by which potassium sorbate inhibits Bacillus cereus T and Clostridium botulinum 62A spore germination was investigated. Spores of B. cereus T were germinated at 35 degrees C in 0.08 M sodium-potassium phosphate buffers (pH 5.7 and 6.7) containing various germinants (L-alanine, L-alpha-NH2-n-butyric acid, and inosine) and potassium sorbate. Spores of C. botulinum 62A were germinated in the same buffers but with 10 mM L-lactic acid, 20 mM sodium bicarbonate, L-alanine or L-cysteine, and potassium sorbate. Spore germination was monitored by optical density measurements at 600 nm and phase-contrast microscopy. Inhibition of B. cereus T spore germination was observed when 3,900 micrograms of potassium sorbate per ml was added at various time intervals during the first 2 min of spore exposure to the pH 5.7 germination medium. C. botulinum 62A spore germination was inhibited when 5,200 micrograms of potassium sorbate per ml was added during the first 30 min of spore exposure to the pH 5.7 medium. Potassium sorbate inhibition of germination was reversible for both B. cereus T and C. botulinum 62A spores. Potassium sorbate inhibition of B. cereus T spore germination induced by L-alanine and L-alpha-NH2-n-butyric acid was shown to be competitive in nature. Potassium sorbate was also a competitive inhibitor of L-alanine- and L-cysteine-induced germination of C. botulinum 62A spores.     

Factors influencing Clostridium botulinum spore germination, outgrowth, and toxin formation in acidified media

Clostridium botulinum type A spores were inoculated at a level of 10(7) spores per ml into sterile beef media with protein concentrations of 1, 2, 3, 4, or 6% and acidified to pH values of 2.01 to 4.75 with hydrochloric acid or 4.19 to 4.60 with citric acid. All experimental manipulations, including blending, acidification, inoculation, incubation (30 degrees C), and analyses, were conducted in an anaerobic chamber-incubator in which atmospheric oxygen levels were maintained below 2 ppm (2 microliters/liter). Under these strict anaerobic conditions (oxidation-reduction values in media ranging from -370 to -391 mV), C. botulinum spores were consistently found to germinate, grow, and produce toxin below pH 4.6. The boundary between toxic and atoxic samples in HC1-acidified beef media was mediated by titratable acidity, pH, and protein concentration. A limiting acidity was not established for the citrate-acidified samples; all blends tested (1, 2, 3, and 4% protein and titratable acidities of 0.091 to 0.453%) became toxic within 5 weeks. At the same pH and protein concentration, citric acid was less effective than HC1 in preventing the germination of C. botulinum spores. Higher levels of cell proliferation in the beef protein, as well as enhanced gas production and putrefactive degradation, indicated that beef was a better substrate than soy for C. botulinum spores under these conditions. Reducing the inoculum to 10(4) delayed but did not prevent spore outgrowth and toxin release at pH levels below 4.6.     

Inhibition of type A and type B (proteolytic) Clostridium botulinum by sorbic acid.

The effect of sorbic acid in the pH range 4.9 to 7.0 on the probability P of growth of a single vegetative bacterium of proteolytic strains of Clostridium botulinum has been determined by comparison of the most probable number count of the bacteria in media at pH 4.9 to 7.0 containing a series of concentrations of potassium sorbate and in a nutrient medium at pH 6.8 to 7.0. The media were maintained under strictly anaerobic conditions at a redox potential equivalent to lower than -350 mV at pH 7. In medium adjusted to the required pH with HCl, P for strain ZK3 (type A) at pH 5.1 or 5.5 after 2 days at 30 degrees C was similar to that at pH 6.8 to 7.0 but was slightly lower at pH 4.9. Potassium sorbate inhibited growth, the inhibition being a function of the concentration of undissociated sorbic acid. A calculated undissociated sorbic acid concentration of 156 mg/liter delayed growth of strain ZK3 (type A) but did not result in a significant decrease in P after an incubation time of 14 days. Higher concentrations of undissociated sorbic acid caused longer delays before maximum most probable number counts developed, and a calculated undissociated sorbic acid concentration of 282 mg/liter decreased log P for strain ZK3 after an incubation time of 14 days by a factor of 5.5 to 7.5. Four additional type A strains and five type B strains were inhibited to an extent comparable to inhibition of strain ZK3.(ABSTRACT TRUNCATED AT 250 WORDS)     

Variability in spore germination response by strains of proteolytic Clostridium botulinum types A,B and F

AIMS: The objective of the study was to evaluate the variability of germination response of 10 strains of proteolytic Clostridium botulinum. METHODS AND RESULTS: An automated turbidometric method was used to follow the fall in optical density. Spores of proteolytic Cl. botulinum germinated in response to l-alanine alone, with rate and extent of germination increased by addition of l-lactate or bicarbonate ions. Other hydrophobic amino acids also triggered germination of spores of proteolytic Cl. botulinum but not AGFK and inosine, germinants for Bacillus subtilis or B. cereus. CONCLUSIONS: Unlike spores of nonproteolytic Cl. botulinum, all proteolytic Cl. botulinum germinate in hydrophobic l-amino acids without l-lactate. However, a great variability of response to germinant is evidenced between the species. SIGNIFICANCE AND IMPACT OF THE STUDY: The selection of a model strain to study germination of Cl. botulinum spores should consider the variability in sensitivity to germinants shown in this work. In particular, the sequenced strain ATCC 3502 may not be the most appropriate model for germination studies.     

Deoxyribonucleic acid metabolism and nuclear division during spore germination in Fusarium oxysporum.

Ungerminated microconidia of Fusarium oxysporum have a mean cell DNA content of 0-134 times 10--12 g/cell with a guanine-plus-cytosine composition (%GC) of 50-75%. During germination, the first dry weight increase of the spore population was defected after 3 h incubation and the first germ tube appeared after 4 h. The total DNA of the culture sharply increased after 5 h, followed by a pause at 6 h. At this time the DNA content per nucleus was maximal and the first nuclear divisions were detected. auses in the rise of total DNA of the culture and in the [14C]adenine incorporation pattern suggest that there is partial synchrony in DNA synthesis at the beginning of incubation. This is also supported by the fact that until 8 h, only hyphae with 1, 2 and 4 nucleic were observed. [14C]adenine incorporation into DNA averaged 2-68% of the total taken up in 10 h incubation.     

Bacteriocin-mediated inhibition of Clostridium botulinum spores by lactic acid bacteria at refrigeration and abuse temperatures.

The bacteriocinogenicity of Lactococcus lactis ATCC 11454, Pediococcus pentosaceus ATCC 43200, P. pentosaceus ATCC 43201, Lactobacillus plantarum BN, L. plantarum LB592, L. plantarum LB75, and Lactobacillus acidophilus N2 against Clostridium botulinum spores at 4, 10, 15, and 35 degrees C was investigated by modified deferred and simultaneous antagonism methods. All the strains, except L. acidophilus N2, produced inhibition zones on lawns of C. botulinum spores at 30 degrees C. L. plantarum BN, L. lactis ATCC 11454, and P. pentosaceus ATCC 43200 and 43201 were bacteriocinogenic at 4, 10, and 15 degrees C. Supplementation of brain heart infusion agar with 0 to 5% NaCl increased the radii of inhibition zones during simultaneous antagonism assays. Detectable bacteriocin activities were extracted from freeze-thawed agar cultures of L. plantarum BN and L. lactis ATCC 11454 which had been grown at 4 and 10 degrees C. These results suggest that low levels of L. plantarum BN or L. lactis ATCC 11454, in the presence of 3 or 4% NaCl, could be formulated into minimally processed refrigerated food products for protection against possible botulism hazards.     

Bacteriocin-mediated inhibition of Clostridium botulinum spores by lactic acid bacteria at refrigeration and abuse temperatures.

The bacteriocinogenicity of Lactococcus lactis ATCC 11454, Pediococcus pentosaceus ATCC 43200, P. pentosaceus ATCC 43201, Lactobacillus plantarum BN, L. plantarum LB592, L. plantarum LB75, and Lactobacillus acidophilus N2 against Clostridium botulinum spores at 4, 10, 15, and 35 degrees C was investigated by modified deferred and simultaneous antagonism methods. All the strains, except L. acidophilus N2, produced inhibition zones on lawns of C. botulinum spores at 30 degrees C. L. plantarum BN, L. lactis ATCC 11454, and P. pentosaceus ATCC 43200 and 43201 were bacteriocinogenic at 4, 10, and 15 degrees C. Supplementation of brain heart infusion agar with 0 to 5% NaCl increased the radii of inhibition zones during simultaneous antagonism assays. Detectable bacteriocin activities were extracted from freeze-thawed agar cultures of L. plantarum BN and L. lactis ATCC 11454 which had been grown at 4 and 10 degrees C. These results suggest that low levels of L. plantarum BN or L. lactis ATCC 11454, in the presence of 3 or 4% NaCl, could be formulated into minimally processed refrigerated food products for protection against possible botulism hazards.     

Effect of storage time and temperature on the survival of Clostridium botulinum spores in acid media.

Clostridium-botulinum type A and type B spores were stored in tomato juice (pH 4.2) and citric acid-phosphate buffer (pH 4.2) at 4, 22, and 32 degrees C for 180 days. The spore count was determined at different intervals over the 180-day storage period. There was no significant decrease in the number of type A spores in either the tomato juice or citric acid-phosphate buffer stored for 180 days at 4, 22, and 32 degrees C. The number of type B spores did not decrease when storage was at 4 degrees C, but there was an approximately 30% decrease in the number of spores after 180 days of storage at 22 and 32 degrees C.     

Effect of storage time and temperature on the survival of Clostridium botulinum spores in acid media.

Clostridium-botulinum type A and type B spores were stored in tomato juice (pH 4.2) and citric acid-phosphate buffer (pH 4.2) at 4, 22, and 32 degrees C for 180 days. The spore count was determined at different intervals over the 180-day storage period. There was no significant decrease in the number of type A spores in either the tomato juice or citric acid-phosphate buffer stored for 180 days at 4, 22, and 32 degrees C. The number of type B spores did not decrease when storage was at 4 degrees C, but there was an approximately 30% decrease in the number of spores after 180 days of storage at 22 and 32 degrees C.     

Lipid metabolism during bacterial growth, sporulation, and germination: kinetics of fatty acid and macromolecular synthesis during spore germination and outgrowth of Bacillus thuringiensis.

The timing and kinetics of fatty acid synthesis are delineated for Bacillus thuringiensis spore germination and outgrowth by analyzing [U-14C]acetate and [2-3H]glycerol incorporation into chloroform-methanol-extractable and trichloroacetic acid-precipitable lipids. In addition to measurement of pulsed and continuous labeling of fatty acids, monitoring the incorporation of radioactive phenylalanine, thymidine, and uridine from the onset of germination through first cell division provides a profile of biochemical activities related to membrane differentiation and cellular development. Upon germination, ribonucleic acid synthesis is initiated, immediately followed by rapid and extensive fatty acid synthesis that in turn precedes protein, deoxyribonucleic acid and triglyceride synthesis. Significantly, formation of fatty acids from acetate exhibits further developmental periodicity in which a large transient increase in fatty acid synthetic activity coincides with the approach of cell division. Radiorespirometric analyses indicates only slight oxidative decarboxylation of acetate and corroborates the extreme involvement of acetate in specific fatty acid biosynthetic reactions throughout cellular modification. These findings graphically demonstrate an intimate association of fatty acid metabolism with commitment to spore outgrowth and subsequent cell division.