Xylanase production by Trichoderma reesei Rut C-30 grown on L-arabinose-rich plant hydrolysates

The suitability of L-arabinose-rich plant hydrolysates as carbon sources and inducers of xylanase production in Trichoderma reesei Rut C-30 was tested. Significantly higher xylanase activities were obtained in cultures on oat husk and sugar beet pulp hydrolysates than on lactose. In batch culture with oat husk hydrolysate and lactose, the xylanase activity was about 9 times higher ( approximately 510 IU/ml) than in lactose ( approximately 60 IU/ml). Even higher xylanase activity ( approximately 630 IU/ml) was obtained when the batch cultivations were done on sugar beet pulp hydrolysate and lactose. In a fed-batch culture using oat husk hydrolysate-lactose the xylanase activity was as high as 1350 IU/ml in 4 days. The cellulase production clearly decreased when T. reesei was cultured on both hydrolysates compared to the cultivation on lactose. Moreover, the relative amounts of the xylanases I-III were similar regardless the used carbon source.     

Optimization of xylanase production using inexpensive agro-residues by alkalophilic Bacillus subtilis ASH in solid-state fermentation

Alkalophilic Bacillus subtilis ASH produced high levels of xylanase using easily available inexpensive agricultural waste residues such as wheat bran, wheat straw, rice husk, sawdust, gram bran, groundnut and maize bran in solid-state fermentation (SSF). Among these, wheat bran was found to be best substrate. Xylanase production was highest after 72 h of incubation at 37 °C and at a substrate to moisture ratio of 1:2 (w/v). The inoculum level of 15% resulted in maximum production of xylanase. The enzyme production was stimulated by the addition of nutrients such as yeast extract, peptone and beef extract. In contrast, addition of glucose and xylose repressed the production of xylanase. The extent of repression by glucose (10%, w/v) was 81% and it was concentration-dependent. Supplementation of the medium with 4% xylose caused 59% repression. Under optimized conditions, xylanase production in SSF (8,964 U of xylanase/g dry wheat bran) was about twofold greater than in submerged fermentation. Thus, B. subtilis produced a very high level of xylanase in SSF using inexpensive agro-residues, a level which is much higher than that reported by any other bacterial isolate. Furthermore, the enzyme was produced at room temperature and with tap water without the addition of any mineral salt in SSF, leading to a marked decrease in the cost of xylanase production, which enhances its industrial potential.     

Amino acid supplementation improves heterologous protein production by Saccharomyces cerevisiae in defined medium

Supplementation of a chemically defined medium with amino acids or succinate to improve heterologous xylanase production by a prototrophic Saccharomyces cerevisiae transformant was investigated. The corresponding xylanase production during growth on ethanol in batch culture and in glucose-limited chemostat culture were quantified, as the native ADH2 promoter regulating xylanase expression was derepressed under these conditions. The addition of a balanced mixture of the preferred amino acids, Ala, Arg, Asn, Glu, Gln and Gly, improved both biomass and xylanase production, whereas several other individual amino acids inhibited biomass and/or xylanase production. Heterologous protein production by the recombinant yeast was also improved by supplementing the medium with succinate. The production of heterologous xylanase during growth on ethanol or glucose could thus be improved by supplementing metabolic precursors in the carbon- or nitrogen-metabolism.     

Alkali-thermostable and cellulase-free xylanase production by an extreme thermophile <Emphasis Type="Italic">Geobacillus thermoleovorans</Emphasis>

The optimization of cultural variables resulted in a marked enhancement in the secretion of cellulase-free and alkali-thermostable xylanase (EC 3.2.1.8) by an extreme thermophile Geobacillus thermoleovorans. The enzyme secretion was enhanced when the medium was supplemented with xylan (0.15%) and Tween-80 (0.1% v/v). In wheat bran-tryptone medium, the peak in enzyme production was attained within 42 h in a fermenter as compared to 72 h in shake flasks. Optimization of the culture conditions resulted in a 7.72-fold enhancement in enzyme production. The cellulase-free xylanase was optimally active at pH 8.5 and 80°C, and it was found to be useful in the pre-bleaching process of paper pulps.     

Use of xylan-rich cost effective agro-residues in the production of xylanase by Streptomyces cyaneus SN32

AIM: The present study aimed at optimization of cultural and nutritional parameters for enhanced production of xylanase from Streptomyces cyaneus SN32. METHODS AND RESULTS: The xylanase production by S. cyaneus SN32 on most of the agro-residues tested in this study was more, as compared with the xylanase yield in the medium supplemented with commercial xylan. The presence of wheat bran as carbon source in the medium induced the highest production of xylanase followed by corn cob. Utilization of maize stalk, gram husk and black gram husk for microbial xylanase production has been reported first time in the present study. Among all the organic and inorganic sources of nitrogen tested in the study, peptone was found to be the best in stimulating xylanase production by S. cyaneus SN32. CONCLUSION: The production of xylanase from this thermoalkalophilic actinomycete has been enhanced 1.44-fold. To the best of our knowledge, the magnitude of enzyme yield i.e. 720 IU ml(-1) by S. cyaneus SN32 has not been reported for any other actinomycete so far. SIGNIFICANCE AND IMPACT OF STUDY: Present studies revealed that thermoalkalophilic S. cyaneus SN32, because of its simple nutritional requirements and its ability to exhibit considerably good enzyme yield, is a potent xylanase producer for its economical application in various industries.     

Production and characterization of a xylanase from Cyathus stercoreus

Cyathus stercoreus grown on wheat straw had a higher xylanase activity than when it was grown on rice husk or extracted hemicellulose. Inclusion of casein hydrolysate, Tween 80 and Mn²⁺ (at 0.02%, 0.2% and 0.075%, respectively) increased the production of extracellular xylanase. Optimal yield of xylanase (0.73 U/ml) was at pH 5.6 after 9 to 12 days at 30°C. The xylanase was stable at pH 4.5 to 7.5 for 2h but above 50°C its stability fell sharply.The authors are with the Department of Microbiology, University of Delhi South Campus, Benito Juarez Road, New Delhi-110021, India;     

Production of Xylanase by Thermophilic Melanocarpus albomyces IIS-68

Melanocarpus albomyces IIS-68, a thermophilic fungus was used for the production of extracellular xylanase on various agroresidues in solid-state fermentation (SSF). Growth on untreated wheat straw and sugar cane bagasse supported xylanase production, while rice straw and rice husk did not. Alkali treatment and acid chlorite treatment of these latter substrates, which lead to extensive delignification, enhanced xylanase production. In contrast, these treatments caused a decline in xylanase activity on wheat straw and bagasse. Acetyl esterase was produced concurrently with xylanase, maximal activity being produced on bagasse. Enzyme production was higher in SSF than in submerged fermentation (SmF). Studies with electron micrographs indicated that culture filtrate proteins were able to degrade wall polymers.     

Production of alkali-tolerant cellulase-free xylanase by <Emphasis Type="Italic">Pseudomonas</Emphasis> sp. WLUN024 with wheat bran as the main substrate

An alkali-tolerant cellulase-free xylanase producer, WLI-11, was screened from soil samples collected from a pulp and paper mill in China. It was subsequently identified as a Pseudomonas sp. A mutant, WLUN024, was selected by consecutive mutagenesis by u.v. irradiation and NTG treatment using Pseudomonas sp. WLI-11 as parent strain. Pseudomonas sp. WLUN024 produced xylanase when grown on xylosidic materials, such as hemicellulose, xylan, xylose, and wheat bran. Effects of various nutritional factors on xylanase production by Pseudomonas sp. WLUN024 with wheat bran as the main substrate were investigated. A batch culture of Pseudomonas sp. WLUN024 was conducted under suitable fermentation conditions, where the maximum activity of xylanase reached 1245 U ml⁻¹ after incubating at 37 °C for 24 h. Xylanase produced by Pseudomonas sp. WLUN024 was purified and the molecular weight was estimated as 25.4 kDa. Primary studies on the characteristics of the purified xylanase revealed that this xylanase was alkali-tolerant (optimum pH 7.2–8.0) and cellulase-free. In addition, the xylanase was also capable of producing high quality xylo-oligosaccharides, which indicated its application potential in not only pulp bio-bleaching processes but also in the nutraceutical industry.     

Effect of nitrogen source on lignocellulolytic enzyme production by white-rot basidiomycetes under solid-state cultivation

Summary The effect of additional nitrogen sources on lignocellulolytic enzyme production by four species of white-rot fungi (Funalia trogii IBB 146, Lentinus edodes IBB 363, Pleurotus dryinus IBB 903, and P. tuberregium IBB 624) in solid-state fermentation (SSF) of wheat straw and beech tree leaves was strain- and substrate-dependent. In general, the yields of hydrolytic enzymes and laccase increased by supplementation of medium with an additional nitrogen source. This stimulating effect of additional nitrogen on enzyme accumulation was due to higher biomass production. Only xylanase specific activity of P. dryinus IBB 903 and laccase specific activity of L. edodes IBB 363 increased significantly (by 66% and 73%, respectively) in SSF of wheat straw by addition of nitrogen source to the control medium. Additional nitrogen (20 mM) repressed manganese peroxidase (MnP) production by all fungi tested. The study of the nitrogen concentration effect revealed that 10 mM peptone concentration was optimal for cellulase and xylanase accumulation by P. dryinus IBB 903. While variation of the peptone concentration did not cause the change in MnP yield, elevated concentrations of this nutrient (20–40 mM) led to a 2–3-fold increase of P. dryinus IBB 903 laccase activity. About 10–20 mM concentration of NH₄NO₃ was optimal for cellulase and xylanase production by F. trogii IBB 146. However, neither the laccase nor the MnP yield was significantly changed by the additional nitrogen source.     

Production of cell wall-degrading enzymes by a pH tolerant estuarine fungal isolate <Emphasis Type="Italic">Fusarium moniliforme</Emphasis> NCIM1276 in different culture conditions

A pH tolerant strain of Fusarium moniliforme NCIM1276 with a saprophytic mode of nutrition was isolated from a coastal estuarine environment. Under laboratory conditions, the fungus produced significant biomass between pH 3 and 9, and produced cell wall degrading enzymes such as pectinases (polygalacturonase and pectate lyase), carboxymethylcellulase, xylanase and amylase. The production of these enzymes by the isolate in liquid medium, semi-solid medium and in infected tomato and cauliflower plants tissue was investigated. In liquid medium, the production of cell wall-degrading enzymes was induced by appropriate substrates, whereas the organism secreted all enzymes constitutively on wheat bran. The production of polygalacturonase, pectate lyase, carboxymethylcellulase, xylanase and amylase was increased by 3, 2, 11, 10 and 4-fold respectively on semi-solid medium containing wheat bran and orange pulp. Moreover when the fungus was allowed to infect tomato and cauliflower plants, the fungus was localized in the cortical tissues of the plants and secreted pectinases, carboxymethylcellulase and xylanase enzymes in the infected host tissue.     

Optimization of extracellular xylanase production by Dictyoglomus sp. B1 in continuous culture

The thermophilic, xylanolytic, anaerobic organism, Dictyoglomus sp. B1, was cultivated in batch and continuous cultures in media containing insoluble beech-wood xylan. The extracellular xylanase activity levels obtained for the two cultivation methods were compared. Experiments were performed separately to determine the optimum substrate concentration, dilution rate, pH and temperature for xylanase production. Maximum xylanase activity was found at a substrate concentration of 1.5 g xylan/l, a dilution rate of 0.112 h^–1, pH 8.0 and at 7°C. Different combinations of these optimum values were used in a 2³ factorial experiment to investigate whether an increase in the xylanase production/activity could be achieved. A maximum xylanase activity of 2312 U/l was found when fermentors were operated at 73°C with a substrate concentration of 1.5 g xylan/l, pH 8.0, and a dilution rate of 0.112 h^–1. Thus, the optimum xylanase activity in the factorial experiment was obtained when the conditions that gave the maximum xylanase activities in the individual experiments were combined. Optimum xylanase activity obtained in the 2³ factorial experiment was 6.2 times higher than the activity found in the initial batch culture (373 U/l) and 3.0 times higher than the activity of a batch culture (783 U/l) grown at the same optimum conditions as the factorial experiment. The higher specific xylanase activity (217 U/mg protein) found in the 2³ factorial experiment was 4.1 times higher than the specific activity in the initial batch culture (53 U/mg protein).     

Improved xylanase production from a haloalkalophilic Staphylococcus sp. SG-13 using inexpensive agricultural residues

The production of an alkali-stable xylanase, with dual pH optima, from haloalkalophilic Staphylococcus sp. SG-13 has been enhanced using agro-residues in submerged fermentation and a biphasic growth system. The agro-residues such as wheat bran, sugarcane bagasse, corncobs and poplar wood when used as sole carbon source, improved the xylanase yield by five-fold as compared to xylose and xylan. Staphylococcus sp. SG-13 also produced equally good amounts of xylanase when grown simply in deionized water (pH 8.0) supplemented with agro-residues as sole carbon source. In the biphasic growth system (lower layer containing agricultural residue set in agar medium with liquid medium above it), the prime substrate, wheat bran (1% w/v), resulted in maximum xylanase production of 4525 U l^–1 (pH 7.5) and 4540 U l^–1 (pH 9.2) at an agar: broth ratio of 4.0 after 48 h of incubation at 37 °C under static conditions. In general, the cost-effective agro-residues were found to be more suitable inducers for xylanase production over expensive substrates like xylan.     

Mixture design as first step for improved glutaminase production in solid-state fermentation by isolated Bacillus

Aim: Investigation of mixture‐design impact on glutaminase production by isolated Bacillus sp. Methods and Results: An augmented simplex centroid design was used to optimize a three (wheat bran, Bengal gram husk and palm seed fibre) component mixture for glutaminase production. Selected substrate materials showed impact on glutaminase production values at individual level by Bengal gram husk [2789 U gds^?1 (gram dry substrate] and in two‐level combination with wheat bran and Bengal gram husk (maximum of 3300 U gds^?1). Conclusion: Bengal gram husk is the most suitable substrate medium for glutaminase production by Bacillus sp. Maximum glutaminase production is achieved using solid‐substrate mixture at two‐level combinations in the ratio of 66 : 34 for Bengal gram husk and wheat bran, respectively. Significance and Impact of the Study: The present study has significance in large‐scale production of glutaminase at commercial level with the use of multi‐substrate rather than single‐substrate/support material.     

Production of xylanase by Emericella nidulans NK-62 on low-value lignocellulosic substrates

Thermotolerant Emericella nidulans NK-62 was isolated from bird nesting material and was tested for its ability to produce xylanase. The fungus when grown on a medium containing wheat bran (2% w/v) supplemented with Czapek's mineral salt solution at 45 °C for 7 days produced 362 IU/ml of xylanase (EC 3.2.1.8). The specific activity of E. nidulans NK-62 xylanase was found to be 275 IU/mg of total protein. The enzyme was found to be active over a broad temperature and pH range with 60 °C as optimum temperature for enzyme activity. The enzyme was stable at 50 °C and its half-life at 55 °C was 45 min. -xylosidase (EC 3.2.1.37) and carboxymethylcellulase (EC 3.2.1.4) activities, 0.018 and 0.21 IU/ml respectively, were also noticed. The fungus was screened for its ability to produce xylanase on four different lignocellulosic substrates. It produced 318.9 IU/ml of cellulase-free xylanase on corn cobs. The fungus could also utilize lentil bran (seed husk of Lens esculentus) and meal of groundnut shells to produce 84.8 and 17.3 IU/ml xylanase respectively.     

Production of cellulase-free thermostable xylanases by an isolated strain of Aspergillus niger PPI, utilizing various lignocellulosic wastes

A strain of Aspergillus niger PPI having prolific xylanolytic potential was isolated and the optimum conditions for maximum xylanase production was studied, resulting in the following: 4% substrate concentration, 10% v/v inoculum size, 72 h of incubation and pH 3.5–4.5 at 28 °C. The production profile of xylanase was examined with various lignocellulosics and maximum yield was achieved with oat. The hemicellulose content of wastes was also determined and oatmeal was found to have maximum hemicellulose content followed by wheat straw, sugarcane bagasse, rice husk and gram residue respectively. The enzyme showed maximum activity at pH 4 and temperature 60 °C. However, maximum stability was achieved at pH 3.5 and temperature 55 °C. Cellulase activity was found altogether absent in the enzyme broth.     

Xylanase production using inexpensive agricultural wastes and its partial characterization from a halophilic <Emphasis Type="Italic">Chromohalobacter</Emphasis> sp. TPSV 101

A halophilic and alkali-tolerant Chromohalobacter sp. TPSV 101 with an ability to produce extracellular halophilic, alkali-tolerant and moderately thermostable xylanase was isolated from solar salterns. Identification of the bacterium was done based upon biochemical tests and 16S rRNA sequence. The culture conditions for higher xylanase production were optimized with respect to NaCl, pH, temperature, substrates and metal ions and additives. Maximum xylanase production was achieved in the medium with 20% NaCl, pH-9.0 at 40°C supplemented with 1% (w/v) sugarcane bagasse and 0.5% feather hydrolysate as carbon and nitrogen sources. Sugarcane bagasse (250 U/ml) and wheat bran (190 U/ml) were the best inducer of xylanase when used as carbon source as compared to xylan (61 U/ml). The xylanase that was partially purified by protein concentrator had a molecular mass of 15 kDa approximately. The xylanase from Chromohalobacter sp. TPSV 101 was active at pH 9.0 and required 20% NaCl for optimal xylanolytic activity and was active over a broad range of temperature 40–80°C with 65°C as optimum. The early stage hydrolysis products of sugarcane bagasse were xylose and xylobiose, after longer periods of incubation only xylose was detected.     

Influence of cultivation conditions on production of lignocellulolytic enzymes by Ceriporiopsis subvermispora

The aim of this work was to make a survey describing factors that influence the production of extracellular enzymes by white-rot fungus Ceriporiopsis subvermispora responsible for the degradation of lignocellulolytic materials. These factors were: carbon sources (glucose, cellulose, hemicellulose, lignin, maltose and starch), nitrogen sources (ammonium sulphate, potassium nitrate, urea, albumin and peptone), pH, temperature and addition of three different concentrations of Cu²⁺ and Mn²⁺. The cellulase and xylanase activities were similar in medium with different carbon sources and the highest cellulase and xylanase activities were measured in medium with urea and potassium nitrate as nitrogen sources, respectively. The highest laccase activity was observed in medium with lignin and peptone as carbon and nitrogen sources. In other experiments, time course of production of lignocellulolytic enzymes by white-rot fungus C. subvermispora in medium with lignin or glucose as carbon sources was observed.     

Thermolabile xylanase of the Antarctic yeast Cryptococcus adeliae: production and properties

Xylanase production by the Antarctic psychrophilic yeast Cryptococcus adeliae was increased 4.3 fold by optimizing the culture medium composition using statistical designs. The optimized medium containing 24.2 g l⁻¹ xylan and 10.2 g l⁻¹ yeast extract and having an initial pH of 7.5 yielded xylanase activity at 400 nkat (nanokatal) ml⁻¹ after 168-h shake culture at 4°C. In addition, very little endoglucanase, β-mannanase, β-xylosidase, β-glucosidase, α-l-arabinofuranosidase, and no filter paper cellulase activities were detected. Among 12 carbon sources tested, maximum xylanase activity was induced by xylan, followed by lignocelluloses such as steamed wheat straw and alkali-treated bagasse. The level of enzyme activity produced on other carbon sources appeared to be constitutive. Among the complex organic nitrogen sources tested, the xylanase activity was most enhanced by yeast extract, followed by soymeal, Pharmamedia (cotton seed protein), and Alburex (potato protein). A batch culture at 10°C in a 5-l fermenter (3.5-1 working volume) using the optimized medium gave 385 nkat at 111 h of cultivation. The crude xylanase showed optimal activity at pH 5.0–5.5 and good stability at pH 4–9 (21 h at 4°C). Although the enzyme was maximally active at 45°–50°C, it appeared very thermolabile, showing a half-life of 78 min at 35°C. At 40°–50°C, it lost 71%–95% activity within 5 min. This is the first report on the production as well as on the properties of thermolabile xylanase produced by an Antarctic yeast. Received: December 10, 1999 / Accepted: March 23, 2000     

Optimization of nutrient medium containing agricultural waste for xylanase production by Bacillus pumilus B20

We aimed to optimize a nutrient medium containing agricultural waste for xylanase production by Bacillus pumilus B20. Xylanase production with lignocellulosic material was optimized in two steps using DeMeo’s fractional factorial design. A 3.4-fold increase in xylanase production (313.3 U/mL) was achieved using the optimized culture medium consisting of (g/L): K₂HPO₄, 2; MgSO₄·7H₂O, 0.3; CaCl₂·2H₂O, 0.01; NaCl, 2; peptone, 5 yeast extract, 4; and wheat bran, 50. _{B. pumilus} B20 produced a high level of xylanase, which may have potential industrial application.     

里氏木霉GXC木聚糖酶的研究

研究了里氏木霉GXC产木聚糖酶的条件和酶学性质。结果表明,适宜产酶碳源为乳糖、甘露糖、棉子糖、木聚糖和麸皮,氮源为牛肉膏和酵母膏;产酶的最适初始pH为4.0,30℃培养60h。对以麸皮为碳源的培养液进行纯化的酶特性研究表明,木聚糖酶的最适反应温度为50℃,pH为5.5,该酶在pH5.0(7.0和40℃以下相对稳定。Fe3+和Mn2+对木聚糖酶有较大的促进作用,Cu～2+、Fe～2+和Ca～2+ 具有抑制作用。