NMR studies on heavy metal immobilization in biosorbents and mineral matrices

Magnetic resonance imaging and otherNMR methods have a potential for thenon-destructive observation of environmentallyrelevant processes with both spatial andtemporal resolution. Among other applications,such methods can be used to study transport andimmobilization of paramagnetic heavy metal ionsin biosorbents and other matrices. Thisoverview covers various NMR approaches to studysuch processes and illustrates them withexamples of imaging on alginate-basedbiosorbents and on heavy-metal doped gypsumpastes. Experimental challenges in studies ofother matrices are shortly addressed as well.     

Water relations of immobilized giant algal cells

Cells of Halicystis parvula, Acetabularia mediterranea, and Valonia utricularis were immobilized in a cross-linked alginate matrix (4–6% w/w) in order to simulate water-relation experiments in individual cells of higher plant tissues. The immobilization of these cells did not lead to an increase in the mechanical stability of the cell walls. This was demonstrated by measuring the volumetric elastic modulus of the cell wall and its dependence on turgor pressure with the aid of the non-miniaturized pressure probe. In immobilized cells, no changes in the absolute value of the elastic modulus of the cell wall could be detected for any given pressure. At the maximum turgor pressure at which non-immobilized cells normally burst (about 3–7 bar for V. utricularis; depending on cell size, 3 bar for A. mediterranea and 0.9 bar for H. parvula) reversible decreases in the pressure are observed which are succeeded by corresponding pressure increases. This obvervation indicates that coating the cells with the cross-linked matrix protects them from rapid water and turgor pressure loss. Turgor pressure relaxation processes in immobilized cells, which could be induced hydrostatically by means of the pressure probe, yielded accurate values for the half-times of water exchange and for the hydraulic conductivity of the cell membrane. The results demonstrate that the water transport equations derived for single cells in a large surrouding medium are valid for immobilized cells, so that any influence exerted by the unstirred layer which is caused by the presence of the cross-linked matrix can be ignored in the calculations. On the other hand, the evaluation of the half-times of water exchange and the hydraulic conductivity from turgor pressure relaxation processes, which have been induced osmotically, only yields correct values under certain circumstances. The model experiments presented here show, therefore, that the correct Lp-value for an individual cell in a higher plant tissue can probably only be obtained presently by using the pressure probe technique rather than the osmotic method. The results are also discussed in relation to the possible applications of immobilized cells and particularly of immobilized micro-organisms in catalytic reaction runs on an industrial scale.     

Pectin-rich fruit wastes as biosorbents for heavy metal removal: equilibrium and kinetics

Biosorption can be used as a cost effective and efficient technique for the removal of toxic heavy metals from wastewater. Waste materials from industries such as food processing and agriculture may act as biosorbents. This study investigates the removal of cadmium by fruit wastes (derived from several citrus fruits, apples and grapes). Citrus peels were identified as the most promising biosorbent due to high metal uptake in conjunction with physical stability. Uptake was rapid with equilibrium reached after 30-80 min depending on the particle size (0.18-0.9 mm). Sorption kinetics followed a second-order model. Sorption equilibrium isotherms could be described by the Langmuir model in some cases, whereas in others an S-shaped isotherm was observed, that did not follow the Langmuir isotherm model. The metal uptake increased with pH, with uptake capacities ranging between 0.5 and 0.9 meq/g of dry peel. Due to their low cost, good uptake capacity, and rapid kinetics, citrus peels are a promising biosorbent material warranting further study.     

Steroid transformation by living cells immobilized in calcium alginate

Summary Whole cells of Arthrobacter simplex were immobilized in a living state in calcium alginate gel. The bacteria showed steroid-¹-dehydrogenase activity and the production of prednisolone from cortisol was investigated. The ¹-dehydrogenase activity of the immobilized cells could be increased about ten-fold by incubation in nutrient media (e.g., containing 0.5% peptone abd 0.2% glucose). The reason for this activation was examined and it was found that the immobilized cells were capable of multiplying when supplied with nutrients. Furthermore, provided that an inducer, cortisol, was present, the steroid-¹-dehydrogenase activity increased in proportion to the increase in the number of cells and it was thus concluded that microbial growth was the cause of activation.Experiments on repeated, batch-wise pseudocrystallofermentation with immobilized A. simplex cells also showed that immobilized cells could be advantageously used for pseudocrystallofermentation of steroids.     

Fluorometric estimation of viable animal cells immobilized in alginate gel

Fluorescein diacetate (FDA) is hydrolyzed to a fluorescent compound, fluorescein (FRC) which is retained in viable animal cells having an intact plasma membrane. The FDA-FRC system was applied to analysis of viable cells for a mouse hybridoma 16-3F cell entrapped in alginate gel. As a result, visualization of the viable cell distribution in the gel matrix became possible. Moreover, a linear relationship was confirmed between the viable cell concentration determined by microscopic counting and the fluorescence intensity derived from FRC in the viable cells. Thus, cell growth could be quantitatively estimated on the basis of the fluorometry for the immobilized-cell culture.     

Cellobiose hydrolysis using Pichia etchellsii cells immobilized in calcium alginate

The rate of celluose degradation, limited due to the inhibition by cellobiose, can be increased by the hydrolysis of cellobiose to glucose using immobilized beta-glucosidase. Production of beta-glucosidase in four yeasts was studied and a maximum activity of 1.22 IU/mg cells was obtained in cells of Pichia etchellsii when grown on 3% cellobiose as the sole carbon source. A study of the immobilization of beta-glucosidase containing cells of Pichia etchellsii on various solid supports was conducted and immobilization by entrapment in calcium alginate gel beads was found to be the most simple and efficient method. A retention of 96.5% of initial activity after ten sequential batch uses of the immobilized preparation was observed. The pH and temperature optima for free and immobilized cells were the same, i.e., 6.5 (0.05M Maleate buffer) and 50 degrees C, respectively. Even though the temperature optimum was found to be 50 degrees C, the enzyme exhibits a better thermal stability at 45 degrees C. Beads stored at 4 degrees C for six months retain 80% of their activity. Kinetic studies performed on free and immobilized cells shown that glucose is a noncompetitive product inhibitor.The immobilized preparation was found to be limited by pore diffusion but exhibited no film-diffusion resistance during packed bed column indicated by a low dispersion number of 0.1348. A model for reaction with pore diffusion for a noncompetitive type of inhibited system was developed and applied to the cellobiose hydrolysis system. The rate of reaction with diffusional limitations was determined by using the model and effectiveness factors were calculated for different particle sizes. An effectiveness factor of 0.49 was obtained for a particle diameter of 2.5 mm. The modified rate expression using the effectiveness factor represented batch and packed bed reactor operation satisfactorily. The productivity in the packed bed column was found to fall rapidly with increase in conversion rate indicating that the operating conditions of the column would have to be a compromise between high conversion rates and reasonable productivity. A half-life of over seven days was obtained at the operating temperature of 45 degrees C in continuous operation of the packed bed reactor. However, the half-life in the column was found to be greatly affected by temperature, increasing to over seventeen days at a temperature of 40 degrees C and decreasing to less than two days at 50 degrees C.     

Nitrite uptake by Chlamydomonas reinhardtii cells immobilized in calcium alginate

When an initial cell loading of about 30–40 µg chlorophyll (Chl)·g^–1 gel and alginate suspension of 3% (w/v) were used for immobilization of Chlamydomonas reinhardtii, the resulting cell beads showed optimum nitrite uptake rate, at 30° C and pH 7.5, of 14 µmol NO _inf2 ^sup– ·mg^–1 Chl·h^–1, the photosynthetic and respiratory activities being about 120 µmol O₂ produced·mg^–1 Chl·h^–1, and 40 µmol O₂ consumed ·mg^–1 Chl·h^–1, respectively. The nitrite uptake activity required CO₂ in the culture and persisted after 8 days of cells immobilization, or in the presence of 0.2 mm ammonium in the medium. Our data indicate that alginate-entrapped C, reinhardtii cells may provide a stable and functional system for removing nitrogenous contaminants from waste-waters.Correspondence to: C. Vílchez     

A morphometric analysis of algal response to low dose,short-term heavy metal exposure

Summary Three algae,Melosira granulata, Fragilaria capucina, andAnacystis cyanea, collected as part of a natural phytoplankton assemblage were found to differ in their cytological responses to low dose short-term exposure to copper and lead. In general, all were more sensitive to copper than to lead.Fragilaria was more sensitive to both metals than the other species examined. Most immediate changes in relative volume categories can be ascribed to changes in vacuole volume that are most likely the result of changes in membrane permeability. There was some degree of accommodation in all three species at 24 hours. These results are discussed in view of the natural environment of the algae, as well as in relationship to previous studies.     

Improvement of biodesulfurization activity of alginate immobilized cells in biphasic systems

The immobilization of Pseudomonas delafieldii R-8 in calcium alginate beads has been studied in order to improve biodesulfurization activity in oil/water (O/W) biphasic systems. A gas jet extrusion technique was performed to produce immobilized beads. The specific desulfurization rate of 1.5 mm diameter beads was 1.4-fold higher than that of 4.0 mm. Some nonionic surfactants can significantly increase the activity of immobilized cells. The desulfurization rate with the addition of 0.5% Span 80 increased 1.8-fold compared with that of the untreated beads. The rate of biodesulfurization was markedly enhanced by decreasing the size of alginate beads and adding the surfactant Span 80, most likely resulting from the increasing mass transfer of substrate to gel matrix.     

Calcium alginate immobilized cells of clostridium acetobutylicum for solvent production

Conclusions Immobilized vegetative cells ofC. acetobutylicum has a similar product formation pattern when incubated in a simple glucose-salts solution as ordinary growing cells. If vegetative cells of the organism are immobilized in the solvent production phase, solvents are continuously produced on extended incubation.By immobi1izing spores of the organism the disturbance of the cells metabolic activity during the immobilization procedure was avoided. After the outgrowth of viable cells within the gel, the washed gel preparation retained at a high production capacity in the non-growth stage and the results indicate that continuous production might be fully possible. The butanol productivity was also found to be higher with immobilized cells than in a normal batch process.     

Continuous production of lacticin 3147 and nisin using cells immobilized in calcium alginate

Bacteriocinogenic strains, Lactococcus lactis subsp. lactis DPC 3147 and L. lactis DPC 496, producing lacticin 3147 and nisin, respectively, were immobilized in double-layered calcium alginate beads. These beads were inoculated into MRS broth at a ratio of 1:4 and continuously fermented for 180 h. Free cells were used to compare the effect of immobilization on bacteriocin production. After equilibrium was reached, a flow rate of 580 ml h(-1) was used in the immobilized cell (IC), and 240 ml h(-1) in free-cell (FC) bioreactors. Outgrowth from beads was observed after 18 h. Bacteriocin production peaked at 5120 AU ml(-1) in both IC and FC bioreactors. However, FC production declined after 80 h to 160 AU ml(-1) at the end of the fermentation. Results of this study indicate that immobilization offers the possibility of a more stable and long-term means of producing lacticin 3147 in laboratory media than with free cells.     

Production of oxytetracycline by immobilized Streptomyces rimosus cells in calcium alginate gels

Streptomyces rimosus Pfizer 18234–2 cells were immobilized in calcium alginate and used for the production of oxytetracycline. The influence of the incubation period, alginate concentration and storage in CaCl₂ were investigated. From the results of the repeated batch fermentations of the shake flasks, a good level of antibiotic was maintained for a period of about 28 days using 4% calcium alginate. The cell leakage and cell concentration inside the beads were affected by the alginate concentration and storage in CaCl₂ solution.     

Yeast protoplasts immobilized in alginate: Cell wall regeneration and reversion to cells

Yeast protoplasts may regenerate the cell wall and revert to cells if immobilized in a 2%–5% Ca-alginate gel and cultured in an osmotically stabilized medium. The method of protoplast immobilization and subsequent isolation from the gel is described in detail. The reversion yield is dependent of the actual gel concentration, gel shape (beads vs. sheets) and of a medium molarity, and it may be up to 90%. The morphology of the cell wall regeneration and morphology of reversion to the cell forms correspond to protoplast development in gelatin or agar gels.     

Bioconversion of nitriles by Candida guilliermondii CCT 7207 cells immobilized in barium alginate

Nitrile degradation by Candida guilliermondii CCT 7207 using free and immobilized cell systems was compared. Different specific growth rates were observed for immobilized (mumax=0.021 h(-1)) and the free cells (mumax=0.029 h(-1)). The maximum specific rate of acetic acid formation was 0.387 h(-1) and 0.266 h(-1) for free and immobilized cells, respectively. Cell adhesion to the support materials was confirmed by scanning electron microscopy. When immobilized, the yeast was able to use high nitrile and amide concentrations (aliphatic and aromatic) as nitrogen sources. The results suggest that C. guilliermondii CCT 7207 presents a physiological pattern potentially useful for the bioremediation of polluted environments or for the bioproduction of amides and organic acid of high commercial value.     

Kinetic aspects of glucose oxidation by Gluconobacter oxydans cells immobilized in calcium alginate

Summary Gluconobacter oxydans subspecies suboxydans (ATCC 621 H), when growing at high glucose concentrations, oxidizes this substrate incompletely and gluconic acid accumulates in the medium in almost stoichiometric amounts. Such cells were harvested and entrapped in various alginate gels. The preparation with the highest retention of glucose oxidizing activity was used in further studies with the aim of developing an efficient process for continuous gluconic acid production.The retention of activity increases (up to 95%) as the alginate concentration in the gel decreases or the cell/alginate weight ratio is enhanced. In the latter case, however, transport of oxygen to and inside the biocatalyst beads rapidly becomes rate-limiting and thus lowers the efficiency of the biocatalyst. Similarly, the efficiency decreases as the size of the biocatalyst beads increases. In no case rate-limitation by transport of glucose was found. Thus, biocatalyst activity per unit volume of support, diameter of the biocatalyst beads, and aeration efficiency are important parameters for reactor design.     

Trichloroethylene degradation by cells of a methane-utilizing bacterium,Methylocystis sp. M,immobilized in calcium alginate

When Methylocystis sp. M cells were immobilized in calcium alginate, the resulting cell beads showed optimum trichloroethylene (TCE) degradation activity at pH 7.0 and 35°C. In comparison with free cells, the immobilized cells were more stable at low pH, and to some extent, at higher temperatures. Studies on the kinetics and the influence of cell density suggest that oxygen permeation was a rate-limiting step. Investigation of the storage stability and the optimum concentration of dissolved oxygen revealed that the TCE degradability was greater under anaerobic than aerobic conditions. Although a toxic effect caused by TCE was observed, methane seemed to restore activity, suggesting that the development of a two-step reactor system might be advantageous. The finding that the immobilized cells showed TCE degradation activity in actual groundwater suggests that TCE bioremediation could be achieved through the use of bioreactors with such cells.     

Hydrolysis of whey by kluyveromyces bulgaricus cells immobilized in stabilized alginate and in chitosan beads

Kluyveromyces bulgaricus cells were immobilized in matrices resisting to complexing anions. Yeast entrapped in alginate stabilized by polyethylenimine and glutaraldehyde were unable to hydrolyse whey owing to the inactivation of β-galactosidase by the stabilizing agents. Chitosan was resistant to whey medium but decreased the yeast hydrolyzing capacity by 15% with respect to alginate. The hydrolysis rate was found to be unchanged for 37 days at 21–25°C.     

超富集植物吸收富集重金属的生理和分子生物学机制

与普通植物相比,超富集植物在地上部富集大量重金属离子的情况下可以正常生长,其富集重金属的机理已经成为当前植物逆境生理研究的热点领域．尤其是近两年,随着分子生物学等现代技术手段的引人,关于重金属离子富集机理的研究取得了一定进展．通过与酵母突变株功能互补克隆到了多条编码微量元素转运蛋白的全长cDNA;也从分子水平上研究了谷胱甘肽、植物螯合素、金属硫蛋白、有机酸或氨基酸等含巯基物质与重金属富集之间的可能关系．本文从植物生理和分子生物学角度简要评述超富集植物对重金属元素的吸收、富集、整合及区室化的机制．