Effectiveness of phytase pre-treatment on growth performance,nutrient digestibility and mineral status of common carp (Cyprinus carpio) juveniles fed Moringa by-product based diet

Several anti-nutritional substances are found in plant derivatives for example phytate, that make the nutrients and minerals unavailable to fish, hence leading to poor growth performance. Presence of the anti-nutrient factor such as phytate is a chelated compound and need enzyme for its breakdown and availability of nutrients to improve fish growth. This research work was performed to check the improvement of overall performance of Cyprinus carpio fingerlings by the help of phytase addition in Moringa oleifera by- products based diet. Combination of Moringa seed meal and Moringa leaf meal was utilized as test ingredient to formulate seven test feeds, containing graded levels of phytase (0, 500, 650, 800, 950, 1100 and 1250 FTU kg⁻¹). In feeding trial of 70 days, fingerlings were given feed two times in a day at the rate of 4% of wet weight of their bodies and faeces were collected. According to current results, it was found that growth performance parameters i.e. weight gain; 25 g, specific growth rate; 1.67 and feed conversion ratio; 1.10 were improved to maximum at 950 FTU kg⁻¹. Digestibility of nutrients (crude protein; 73%, crude fat; 71% and gross energy; 67%) and minerals absorption was also maximum (Ca; 70%, Zn; 66%, K; 74%, Mn; 66% and P; 71%) at 950 FTU kg⁻¹. Lowest growth efficiency, nutrient digestibility and mineral absorption were observed in fingerlings fed at control diet (0 FTU kg⁻¹). Results of the current study, proved that 950 FTU kg⁻¹ is the most optimum level of phytase to formulate economical and ecofriendly feed for improved growth of C. carpio fingerlings as it decreases the discharge of minerals and nutrients in water bodies.     

Sparing effect of microbial phytase on zinc supplementation in maize-soya-bean meal diets for chickens

The experiment was conducted to evaluate the sparing effect of microbial phytase on the need for dietary zinc supplementation in chicks. A maize–soya-bean meal basal diet, containing 33 mg of zinc and 16 mg of copper per kg, supplemented with 0, 6, 12, 18, 24, 30 or 60 mg of zinc as sulphate per kg or with 250, 500, 750 or 1000 units (FTU) of microbial phytase (3-phytase from Aspergillus niger, Natuphos®) per kg was given to 1-day-old chicks for 20 days. Sixteen chicks placed in individual cages were assigned to each diet except the unsupplemented basal diet which was assigned to 32 cages. Actual range of phytase supplementation was 280 to 850 FTU per kg diet. Growth performance was not affected by microbial phytase. Chicks given the unsupplemented basal diet and the basal diet supplemented with 60 mg of zinc per kg displayed similar performance. Bone weight, bone ash, liver weight and liver dry matter were independent (P > 0.1) of zinc and phytase supplementations. Plasma, bone and liver zinc concentrations increased linearly (P < 0.001) and quadratically (P < 0.001; P < 0.001 and P < 0.05, respectively) with zinc added. Plasma zinc tended to increase linearly (P = 0.07) and bone zinc increased linearly (P < 0.01) with phytase added but no quadratic response was detected (P > 0.1). Liver zinc was unresponsive to phytase added (P > 0.1). Liver copper decreased linearly (P < 0.001) and quadratically (P < 0.01) with zinc supplementation. Mathematical functions were fitted to the responses of plasma and bone zinc to zinc and phytase added and used to calculate zinc equivalency values of phytase. The models included a linear plateau response to zinc added and a linear response to phytase added. In diets without phytase, plasma and bone zinc concentrations were maximised for a dietary zinc concentration of 55 and 51 mg/kg, respectively. Over the range of 280 to 850 FTU, 100 FTU was equivalent to 1 mg of zinc as sulphate. Consequently, in a maize–soya-bean meal chicken diet formulated to contain 60 mg zinc per kg, zinc ingested, and in turn, zinc excreted may be reduced by around 10% if the diet contains 500 FTU as Natuphos® per kg.     

Dietary effects on inositol phosphate breakdown in the crop of broilers

The effect of diets differing in enzyme supplements, mineral phosphorus (P) and microwave wheat treatment on phytate hydrolysis and lower inositol phosphate isomers (InsPs) appearance in broiler crops was studied. The broilers (16- and 15-day-old) were assigned to 48 pens of 15 or 20 birds each (n = 8 pens per treatment) in Experiments 1 and 2, respectively. In Experiment 1, birds received a low-P wheat-soybean meal diet where the wheat was either microwave treated or not. These diets were offered without further supplementation or with added phytase (500 FTU/kg diet), alone or in combination with a xylanase (16,000 BXU/kg diet). In Experiment 2, two maize-soybean meal-based diets were fed, without or with monocalcium phosphate supplementation. Furthermore, these diets were offered without further supplementation or with phytase at 500 or 12,500 FTU/kg diet. On day 23 or 24 (Experiments 1 and 2, respectively), crop digesta were pooled per pen, freeze-dried and analysed for InsPs and the marker TiO₂. Microwaving reduced the intrinsic phytase activity and InsP₆ hydrolysis, but increased the concentration of Ins(1,2,3,4,5)P₅ and Ins(1,2,4,5,6)P₅ in the digesta of crop (Experiment 1). Microwave treatment significantly interacted with enzyme supplementation for Ins(1,2,5,6)P₄ concentration, indicating a synergistic effect of intrinsic and supplied phytase in the crop. Xylanase tended to support phytase hydrolysis in diets with microwave-treated wheat. Phytase addition increased InsP₆ hydrolysis up to 79% (Experiment 2). Thus, wheat phytase activity can cause high InsP₆ hydrolysis in the crop. Treatment differences in lower InsPs indicated that hydrolysis of the first InsP₆ phosphate group is not the only step in the degradation cascade in the crop of broilers that is influenced by dietary factors.     

Thermoregulatory,behavioral and productive responses of laying hens supplemented with different types and dosages of phytases raised in a hot environment: An integrative approach

This study had the following objectives: (i) to evaluate the thermoregulatory and behavioral responses of light laying hens supplemented with different types and dosages of phytases in the two day shifts; and (ii) to integrate the thermoregulatory and behavioral responses with performance of these birds raised in a hot environment. 270 light laying hens of the Hy-Line White lineage, with a body weight of 1.60 ± 0.092 kg were distributed in a completely randomized design in a 2 × 2 + 1 factorial model with two types of phytases (bacterial and fungal) and two dosages (450 and 900 FTU), and a control diet. The day shift (morning and afternoon) was considered as a fixed effect in the factorial arrangement. Principal component analysis (P_CA), correspondence analysis (C_A) and canonical discriminant analysis (C_DA) were used. There was no interaction (P > 0.05) between phytases and dosages for thermoregulatory responses. Respiratory rate (R_R), cloacal temperature (C_T), and surface temperature with feathers (S_TWF) and featherless (S_TF) were higher (P < 0.001) in the afternoon. Birds show different thermoregulatory and behavioral responses in the two shifts of the day. We also observed that birds supplemented with bacterial and fungal phytase showed similar thermoregulatory and behavioral responses to the control group in both day shifts. Expression of the “eating” activity was greater in the morning, while the birds remained sitting longer in the afternoon. Egg production was higher (P < 0.001) in birds supplemented with bacterial phytase. The phytase dosages had no effect on thermoregulatory, behavioral or performance responses. Egg production, feed conversion per dozen eggs corresponded to 81.1% of the differences between bacterial and fungal phytase supplementation and group control. Thus, we conclude that: (i) phytase dietary supplementation has no effect on the thermoregulatory responses of laying hens reared in a hot environment; (ii) birds supplemented with bacterial phytase showed higher egg production; and (iii) phytases (450 and 900 FTU) do not interfere with productive, behavioral and thermoregulatory responses.     

Microbial phytase addition resulted in a greater increase in phosphorus digestibility in dry-fed compared with liquid-fed non-heat-treated wheat–barley–maize diets for pigs

The objective was to evaluate the effect of microbial phytase (1250 FTU/kg diet with 88% dry matter (DM)) on apparent total tract digestibility (ATTD) of phosphorus (P) in pigs fed a dry or soaked diet. Twenty-four pigs (65±3 kg) from six litters were used. Pigs were housed in metabolism crates and fed one of four diets for 12 days; 5 days for adaptation and 7 days for total, but separate collection of feces and urine. The basal diet was composed of wheat, barley, maize, soybean meal and no mineral phosphate. Dietary treatments were: basal dry-fed diet (BDD), BDD with microbial phytase (BDD+phy), BDD soaked for 24 h at 20°C before feeding (BDS) and BDS with microbial phytase (BDS+phy). Supplementation of microbial phytase increased ATTD of DM and crude protein (N×6.25) by 2 and 3 percentage units (P<0.0001; P<0.001), respectively. The ATTD of P was affected by the interaction between microbial phytase and soaking (P=0.02). This was due to a greater increase in ATTD of P by soaking of the diet containing solely plant phytase compared with the diet supplemented with microbial phytase: 35%, 65%, 44% and 68% for BDD, BDD+phy, BSD and BSD+phy, respectively. As such, supplementation of microbial phytase increased ATTD of P in the dry-fed diet, but not in the soaked diet. The higher ATTD of P for BDS compared with BDD resulted from the degradation of 54% of the phytate in BDS by wheat and barley phytases during soaking. On the other hand, soaking of BDS+phy did not increase ATTD of P significantly compared with BDD+phy despite that 76% of the phytate in BDS+phy was degraded before feeding. In conclusion, soaking of BDS containing solely plant phytase provided a great potential for increasing ATTD of P. However, this potential was not present when microbial phytase (1250 FTU/kg diet) was supplemented, most likely because soaking of BDS+phy for 24 h at 20°C did not result in a complete degradation of phytate before feeding.     

the effect of the combination of microbial phytase and amino acid supplementation of diets for finishing pigs on p and n excretion and carcass quality

The objective of this study was to evaluate the effect of a combined low-protein, low-phosphorus diet supplemented with limiting amino acids and microbial phytase on performance, nutrient utilization and carcass characteristics of late-finishing barrows. 4?×?8 crossbreed barrows were continuously housed in metabolism cages from 70?–?110?kg BW and were fed diets, either conventional (A) or protein reduced (B) or protein and phosphorus reduced diets (C) based on barley, maize and soybean meal. Diet A (positive control) contained in air dry matter 13% and 10% CP as well as 0.49% and 0.42% P at growth phases I (70?–?100?kg BW) or II (100?–?110?kg BW), respectively. Diet B was low in CP (11.3%, 8.4%), diet C low in CP and low in P (CP: as B, P: 0.36%, 0.30%). To diet B the limiting amino acids lysine, methionine, threonine and trypthophan were added to meet the levels in diet A. To diet C the limiting amino acids and 800 FTU/kg Aspergillus-phytase were supplemented. At the end of the balance periods the barrows were slaughtered, the carcasses scored and loin chops, ham and Phalanx prima IV were analysed for nutrients and minerals. The CP or P reduction in diets B and C did not generally negatively affect growth, feed efficiency, absolute nitrogen retention or overall carcass performances of the pigs. With the low CP diets B and C, N excretion per unit BWG was decreased by about 23%. The addition of microbial phytase (diet C) increased apparent total tract digestibility of P by about 20%. In spite of 30% reduction of P intake (diet C), the absolute P retention related to 1?kg BW did not differ between treatments. Thus, phytase supplementation in diet C reduced P excretion per unit BWG by about 33%. Phytase raised apparent digestibility of Zn by about 20% but not Ca digestibility. Generally the carcass traits and meat characteristics were not affected by any of the diet strategies. Mineralization of the Phalanx prima IV was also similar in all treatment groups. However, phytase supplementation led to significantly increased zinc concentration in bones (25%). In contrast, Fe incorporation into the Phalanx prima IV was not affected. In general, the feeding regimen introduced in this experiment offers substantial benefits in maintaining a sustainable environmental-friendly pork production even at the stage of late-finishing barrows.     

无鱼粉低磷饲料中添加中性蛋白酶和植酸酶对建鲤生长及营养物质利用的影响

在无鱼粉低磷饲料中添加中性蛋白酶、中性植酸酶, 考察对建鲤(Cyprinus carpio var. Jian)生长、营养物质消化率和沉积率、血浆生化指标及肠道组织学的影响。配制含鱼粉5%和磷酸二氢钙1.5%的正对照饲料、无鱼粉饲料、无鱼粉低磷饲料(磷酸二氢钙1.0%)和在无鱼粉饲料中添加175 mg/kg蛋白酶, 在无鱼粉低磷饲料中添加175 mg/kg蛋白酶+300 mg/kg植酸酶的5组等蛋白饲料, 饲喂初始体重为(52.5±2.0) g的建鲤10周。结果表明: 对照组具有最高增重率和最低饲料系数(P<0.05), 无鱼粉饲料和无鱼粉低磷饲料组的增重率、蛋白质和磷沉积率、蛋白质和钙消化率均显著下降(P<0.05); 在无鱼粉饲料中添加蛋白酶后, 提高了建鲤增重率13.1%(P<0.05), 达到和对照组基本一致的水平; 显著提高了蛋白质、钙消化率和肠绒毛高度, 降低了饲料系数(P<0.05); 在无鱼粉低磷饲料中添加蛋白酶和植酸酶后, 显著提高了脂肪、蛋白质、磷沉积率和蛋白质、钙、磷消化率(P<0.05), 增加了前肠绒毛长度和隐窝深度(P<0.05), 提高了血浆磷浓度(P<0.05)。以上结果表明, 在全植物性蛋白饲料中添加蛋白酶, 在全植物蛋白的低磷饲料中同时添加蛋白酶和植酸酶可以促进建鲤生长, 提高对营养物质的消化率和沉积率, 促进肠道生长发育。     

Nutritional evaluation of treated X’pelon seed (Vigna unguiculata (L.) Walp) in the feeding of Nile tilapia (Oreochromis niloticus)

Legume seed products are used extensively in human and animal nutrition, but high levels of inclusion are often avoided as their secondary compounds can interfere with digestion and absorption of nutrients in the digestive tract. Due to the well-known benefits of some physicochemical treatments on nutritional value, this experiment was completed to assess effects of soaking and heat treatment on the nutritional value of dehulled and hulled X’pelon seeds (Vigna unguiculata (L.) Walp) to Nile tilapia (Oreochromis niloticus) fingerlings. Seeds were soaked for 16 h in a 2 g/kg sodium bisulphate solution in water. Seeds were divided into two lots, being hulled and dehulled. Three heat treatments were used to convert the seeds to meal, being 5 h of hot air flow (70 °C); autoclaving at 119 °C for 30 min to 1.05 kg/cm², and 7 h in a forced air oven at 48 °C. The resultant crude protein (CP) quality of each meal was evaluated by amino acid analysis and by a tilapia feeding study in which fingerlings were fed one of eight diets, each containing 350 g CP/kg of DM, of which seven diets were formulated with 0.80 of CP provided by fish meal and 0.20 by the X’pelon meals and one control diet was formulated with fish meal as the sole CP source. The study encompassed 9 weeks during which fingerlings were fed ad libitum. Chemical and secondary compound analysis of treated seeds showed that heat flow reduced phytic acid by 34.9% and trypsin inhibitors and hemaglutinin decreased by 94.5%, while complete elimination was obtained with autoclaving. Soaking and heat treatment are suitable for partial or complete elimination of the secondary compounds of X’pelon seeds without affecting the content and bioavailability of amino acids, with heat treatment by hot air flow the best. Partial replacement of fish meal with X’pelon meal improved growth and feed efficiency of Nile tilapia, whether the meal was treated or raw.     

Effect of microbial phytase on apparent ileal amino acid digestibility of phosphorus-adequate diets in growing pigs

Six ileally cannulated pigs (mean initial body weight 34.8 kg) were used to study the effect of microbial phytase on apparent ileal digestibility of P, total N and amino acids. Three P-adequate diets (digestible P concentration 2.3 g kg(- )l) containing barley (B), soyabean meal (S) or a mixture of the two (BS) with or without phytase supplement (1000 FTU x kg(-1)) were fed to pigs using a 6 x 6 Latin square design. The addition of phytase increased (p < 0.05) apparent ileal P digestibility of diets B, S and BS by 16.5, 19.2 and 19.2%, respectively. There was no effect of phytase on the ileal digestibility of total N. Apparent ileal digestibility of amino acids tended to increase in the BS diet supplemented with phytase (mean improvement of 2.2%); but no significant difference was found for any amino acid as compared with the unsupplemented diet. To asses the additivity of apparent amino acid digestibility, the determined values for the BS diet were compared to those calculated from digestibilities found in diets B and S. There were no significant differences between the determined and calculated values. It is concluded that the addition of microbial phytase to P-adequate diets does not affect ileal amino acid digestibility in growing pigs and that the apparent amino acid digestibility values determined in single ingredients may be additive when included into a complex diet.     

Effect of Dietary Supplementation with Copper Sulfate or Tribasic Copper Chloride on the Growth Performance, Liver Copper Concentrations of Broilers Fed in Floor Pens, and Stabilities of Vitamin E and Phytase in Feeds

An experiment was conducted using a total of 840, 1-day-old, Arbor Acres commercial male broilers to compare copper (Cu) sulfate and tribasic Cu chloride (TBCC, Cu₂(OH)₃Cl) as sources of supplemental Cu for broilers fed in floor pens. Chicks were randomly allotted to one of seven treatments for six replicate pens of 20 birds each, and were fed a basal corn–soybean meal diet (10.20 mg/kg Cu) supplemented with 0, 100, 150, or 200 mg/kg Cu from either Cu sulfate or TBCC for 21 days. Chicks fed 200 mg/kg Cu as TBCC had a higher (P?<?0.05) average daily gain (ADG) than those consuming other diets. Liver Cu contents of broilers fed diets supplemented with TBCC were numerically lower (P?>?0.05) than those of broilers fed diets supplemented with Cu sulfate. The vitamin E contents and the phytase activities in the feed fortified with TBCC were higher (P?<?0.01) and numerically higher (P?>?0.05) compared with those in the feeds fortified with Cu sulfate stored at room temperature, respectively. The vitamin E contents in liver and plasma of broilers fed diets supplemented with TBCC were higher (P?<?0.05) than those of birds fed diets supplemented with Cu sulfate. This result indicates that TBCC is more effective than Cu sulfate in improving the growth of broilers fed in floor pens, and it is chemically less active than Cu sulfate in promoting the undesirable oxidation of vitamin E in feeds.     

P and Ca digestibility is increased in broiler diets supplemented with the high-phytase HIGHPHY wheat

Around 70% of total seed phosphorus is represented by phytate which must be hydrolysed to be bioavailable in non-ruminant diets. The limited endogenous phytase activity in non-ruminant animals make it common practice to add an exogenous phytase source to most poultry and pig feeds. The mature grain phytase activity (MGPA) of cereal seeds provides a route for the seeds themselves to contribute to phytate digestion, but MGPA varies considerably between species and most varieties in current use make negligible contributions. Currently, all phytases used for feed supplementation and transgenic improvement of MGPA are derived from microbial enzymes belonging to the group of histidine acid phosphatases (HAP). Cereals contain HAP phytases, but the bulk of MGPA can be attributed to phytases belonging to a completely different group of phosphatases, the purple acid phosphatases (PAPhy). In recent years, increased MGPAs were achieved in cisgenic barley holding extra copies of barley PAPhy and in the wheat HIGHPHY mutant, where MGPA was increased to ~6200 FTU/kg. In the present study, the effect of replacing 33%, 66% and 100% of a standard wheat with HIGHPHY wheat was compared with a control diet with and without 500 FTU of supplemental phytase. Diets were compared by evaluating broiler performance, ileal Ca and P digestibility and tibia development, using nine replicate pens of four birds per diet over 3 weeks from hatch. There were no differences between treatments in any tibia or bird performance parameters, indicating the control diet did not contain sufficiently low levels of phosphorus to distinguish effect of phytase addition. However, in a comparison of the two wheats, the ileal Ca and P digestibility coefficients for the 100% HIGHPHY wheat diets are 22.9% and 35.6% higher, respectively, than for the control diet, indicating the wheat PAPhy is functional in the broiler digestive tract. Furthermore, 33% HIGHPHY replacement of conventional wheat, significantly improved Ca and P digestibility over the diet-supplemented exogenous phytase, probably due to the higher phytase activity in the HIGHPHY diet (1804 v. 1150 FTU). Full replacement by HIGHPHY gave 14.6% and 22.8% higher ileal digestibility coefficients for Ca and P, respectively, than for feed supplemented with exogenous HAP phytase at 500 FTU. This indicates that in planta wheat PAPhys has promising potential for improving P and mineral digestibility in animal feed.     

Barley HvPAPhy_a as transgene provides high and stable phytase activities in mature barley straw and in grains

The phytase purple acid phosphatase (HvPAPhy_a) expressed during barley seed development was evaluated as transgene for overexpression in barley. The phytase was expressed constitutively driven by the cauliflower mosaic virus 35S‐promoter, and the phytase activity was measured in the mature grains, the green leaves and in the dry mature vegetative plant parts left after harvest of the grains. The T₂‐generation of HvPAPhy_a transformed barley showed phytase activity increases up to 19‐fold (29 000 phytase units (FTU) per kg in mature grains). Moreover, also in green leaves and mature dry straw, phytase activities were increased significantly by 110‐fold (52 000 FTU/kg) and 57‐fold (51 000 FTU/kg), respectively. The HvPAPhy_a‐transformed barley plants with high phytase activities possess triple potential utilities for the improvement of phosphate bioavailability. First of all, the utilization of the mature grains as feed to increase the release of bio‐available phosphate and minerals bound to the phytate of the grains; secondly, the utilization of the powdered straw either directly or phytase extracted hereof as a supplement to high phytate feed or food; and finally, the use of the stubble to be ploughed into the soil for mobilizing phytate‐bound phosphate for plant growth.     

Partial replacement of monocalcium phosphate with neutral phytase in diets for grass carp,Ctenopharyngodon idellus

A 9‐week experiment was designed to study the effects of partial replacement of monocalcium phosphate (MCP) with neutral phytase on growth, body compositions, serum biochemical statuses and intestinal digestive enzyme activities of grass carp, Ctenopharyngodon idellus. The control diet (designated as P2.0) was prepared with 2.0% MCP but without phytase. The three other diets (designated as PP1.5, PP1.0 and PP0.5, respectively) were supplemented with 1.5, 1.0 and 0.5% MCP, respectively, along with 500 FTU of neutral phytase kg^?1 diet in each. After a 9‐week feeding trial, fish (initial body weight: 43.44 ± 2.37 g) fed with PP1.5 and PP1.0 had no significant change in weight gain (WG), specific growth rate (SGR), protein efficiency rate (PER) or feed conversion ratio (FCR) compared with the control (P > 0.05) whereas fish fed with PP0.5 showed significantly lower growth performance in the above parameters. The crude lipid content in whole body or muscle of the fish fed with PP1.5 was significantly lower than the control while significantly higher in fish fed with PP0.5 (P < 0.05), whereas no obvious change was observed in the fish fed with PP1.0. For serum indices, higher serum alkaline phosphatase (Alkp), phosphorus (P) and calcium (Ca) contents were observed in fish fed with phytase‐supplemented diets in comparison with the control. In addition, dietary phytase supplementation increased amylase activity and decreased lipase activity in both foregut and hindgut. The present study suggests that dietary MCP can be reduced when neutral phytase is added to the grass carp diet, and that the maximum MCP reduction level can be up to 1% when neutral phytase is supplemented at 500 FTU kg^?1 diet.     

植酸酶对草鱼和新吉富罗非鱼消化酶活性的影响

植酸酶能水解植酸络合物,释放被植酸束缚的各种营养因子,因此能有效解除植酸与内源性消化酶的结合,促进消化酶的作用。本实验在全植物性饲料中添加植酸酶,研究其对草鱼(Ctenopharyngodon idellus)和新吉富罗非鱼(Oreochromis niloticus)淀粉酶及蛋白酶比活力的影响。以全植物性饲料为阴性对照组,添加磷酸氢钙(dibasic calcium phosphate,DCP)实验组为阳性对照组,另设4个不同梯度的植酸酶实验组(250 U/kg、500 U/kg、1 000 U/kg和2 000 U/kg)。实验选取健壮、规格齐整平均体质量为(12.59±0.09)g的草鱼和平均体质量为(9.59±0.12)g的新吉富罗非鱼,分别随机分为6个组,每组5个平行,每个平行20尾鱼。养殖8周后,草鱼平均体质量(18.29±0.63)g,新吉富罗非鱼平均体质量为(24.68±1.34)g,抽样取出胃、肠和肝胰脏用来分析淀粉酶和蛋白酶比活力。结果表明,植酸酶对无胃鱼草鱼和有胃鱼罗非鱼淀粉酶及蛋白酶比活力都有显著的促进作用。相比较而言,植酸酶对罗非鱼的应用效果较明显,低剂量就能显著提高其淀粉酶及蛋白酶比活力(P<0.05)。当植酸酶添加量达到1 000 U/kg时,草鱼和罗非鱼淀粉酶及蛋白酶比活力均达到峰值,此时,罗非鱼淀粉酶和蛋白酶比活力与阳性对照组无显著差异(P>0.05),而草鱼肝胰脏蛋白酶比活力显著高于阳性对照组(P<0.05)。植酸酶2 000 U/kg实验组,罗非鱼淀粉酶和蛋白酶比活力与1 000 U/kg植酸酶实验组无显著差异(P>0.05),但草鱼肝胰脏蛋白酶比活力显著低于1 000 U/kg植酸酶实验组(P<0.05)。因此,本实验条件下,植酸酶在草鱼和新吉富罗非鱼全植物性蛋白质配合饲料中的适宜添加量均为1 000 U/kg,生产实践中可通过添加植酸酶部分替代无机磷源。     

Effects of dietary phytase on body weight gain, body composition and bone strength in growing rats fed a low-zinc diet

Phytic acid, a major phosphorous storage compound found in foodstuffs, is known to form insoluble complexes with nutritionally essential minerals, including zinc (Zn). Phytases are enzymes that catalyze the removal of these minerals from phytic acid, improving their bioavailability. The objective of the present study was to determine the ability of dietary phytase to affect body weight, body composition, and bone strength in growing rats fed a high phytic acid, low Zn diet. Rats (n = 20) were fed either a control (AIN-93) or phytase supplemented (Natuphos, BASF, 1,500 phytase units (FTU)/kg) diet for a period of 8 weeks. Phytase supplementation resulted in increased (P<.05) bone and plasma Zn, but no change in plasma inorganic phosphorous or bone levels of Ca, Fe, or Mg. The addition of phytase to the diets resulted in a 22.4% increase (P<.05) in body weight at the end of the study as compared with rats fed a control diet. Dual x-ray absorptiometry (DXA) revealed that phytase supplementation resulted in increase lean body mass (LBM, P<.001) and increased bone mineral content (BMC, P<.001) as compared with feeding the control diet. Bone studies indicated that femurs and tibias from phytase supplemented rats had greater mass (P<.05) and were stronger (P<.05) than rats fed the control diet. This data suggest that the addition of phytase to low Zn diets results in improved Zn status, which may be responsible for beneficial effects on growth, body composition, and bone strength.     

Effects of phytase supplementation on production performance,egg and bone quality,plasma biochemistry and mineral excretion of layers fed varying levels of phosphorus

Excessive fecal excretion of phosphorus (P) has increasingly become an environmental issue due to oversupply of P in layer rations, and thus it is imperative to minimize safety margins for P to ensure the sustainability of the egg industry. In this study, a 12-week feeding trial (22 to 34 weeks of age) was conducted to evaluate the effects of phytase supplementation on production performance, plasma biochemistry, egg and bone quality and P excretion of laying hens fed various levels of non-phytate P (NPP). Forty-eight Lohmann white laying hens were randomly allocated to one of six corn–soybean meal–oat-based diets: diets containing 2.0, 2.5 or 3.0 g/kg NPP without phytase, and diets containing 1.0, 1.5 or 2.0 g/kg NPP with phytase (1 000 U/kg diet) where phytase inclusion was expected to provide 1.0 g/kg NPP to laying hens, thus making the phytase-unsupplemented treatment served as a control for the phytase-supplemented treatment accordingly. Productive performance was recorded during the experimental period. Blood and egg samples were collected, and digestibility studies were conducted at weeks 6 and 12 of the experiment. Bone mineralization was evaluated at the end of the experiment. Egg weight and egg production, feed consumption, BW and feed conversion ratio of laying hens fed lower NPP diets supplemented with phytase were comparable to those of hens fed high NPP phytase-unsupplemented controls. Eggshell thickness, specific gravity, Haugh units, tibia bone mineral density, tibia ash percent, plasma P and other biochemical parameters were not significantly different among dietary treatments. Total P intake, excretion and retention were affected by diet (P < 0.001), but its deposition in eggs was not significantly different. Contrast analysis further showed that total P excretion of phytase present vs phytase absent was averagely reduced by 40.4 mg/hen per day (P < 0.01). Moreover, total P excretion was linearly (P < 0.01) reduced with lowering dietary NPP, and this relationship was similar regardless of whether phytase was supplemented or not. The results from this study indicated that NPP levels in laying hen diets could be reduced to 1.0 g/kg (excluding the portion of NPP released by phytase) with the inclusion of phytase, without negative effects on production performance and health of the hens, thereby diminishing P excretion into environment.     

Effects of amino acid supplementation on the nutritive quality of fermented linseed meal protein in the diets for rohu, Labeo rohita, fingerlings

A feeding trial was conducted for 8 weeks to examine the effects of partial substitution of fish meal (FM) protein (crude protein content: 58.5%) with linseed meal protein with and without supplemental amino acids in diets for rohu Labeo rohita (Hamilton), fingerlings (mean weight: 1.50 ± 0.3 g). Prior to incorporation into the diets, linseed meal was fermented with lactic acid bacteria ( Lactobacillus acidophilus ) to reduce/eliminate the antinutritional tannin and phytic acid factors. Twelve experimental diets (diets D1–D12) were formulated to replace the FM protein from a reference diet (RD) with linseed meal protein at different levels (four sets of diets, of which each set of three diets contained 25%, 50% and 75% replacement of FM protein by linseed meal protein, respectively). Diets D1–D3 were not supplemented with any amino acid. Lysine was supplemented in diets D4–D6. Diets D7–D9 were supplemented with methionine + cystine (together), and diets D10–D12 contained lysine and methionine + cystine (together). Lysine and methionine + cystine (together) were added to the diets at 5.7% and 3.1% of dietary protein, respectively. The groups of fish fed diets without amino acid supplementation had significantly lower percentages of weight gain, specific growth rate and high feed : gain ratio than the fish groups fed other experimental diets. The addition of lysine and methionine + cystine to the diet in which 50% of the FM protein was replaced by linseed meal protein (diet D11) significantly improved fish performance. The results of the present study suggest that rohu fingerlings can effectively utilize the supplemented amino acids and that linseed meal protein can replace up to 50% of the FM protein in rohu diets if the linseed meal is properly processed (fermented) and supplemented with the lacking amino acids.     

Growth performance, haematology and serum biochemistry of African catfish (Clarias gariepinus) fingerlings fed graded levels of dietary fumonisin B1

Fingerlings of Clarias gariepinus were used to evaluate the effect of dietary fumonisin B₁ (FB₁), a mycotoxin produced by Fusarium verticillioides, on growth, haematological and serum biochemical parameters. The fingerlings were sorted, weighed and randomly stocked in 16 plastic tanks at the rate of 20 fingerlings per tank. Fusarium-cultured maize grains containing FB₁ were used to formulate three diets containing approximately 5.0, 10.0 and 15.0 mg FB₁/kg, constituting diets 2, 3, and 4 respectively. These three diets, plus diet 1, which contained non-Fusarium cultured maize grains that served as the control, were used in a 6-week feeding trial. The final weight gains by the fingerlings were significantly (P?<?0.05) influenced by FB₁. The final weights of the fingerlings fed diets 2, 3 and 4 ranged from 70.07 to 87.10% of the controls. The haematocrit, erythrocytes, haemoglobin, mean corpuscular volume (MCV), mean corpuscular haemoglobin (MCH) and the serum protein constituents (total protein, albumin and globulin) values significantly (P?<?0.05) decreased, while the leucocytes, MCV and MCH increased significantly (P?<?0.05) with increase in the dietary FB₁. The total serum protein values of the fingerlings fed diets 2, 3 and 4 were 34.53, 39.42 and 50.17% lower than the total serum protein values of those fed the control diet. These results indicate that Fusarium-contaminated diets containing about 5.0 mg or more FB₁/kg reduced weight gain and significantly altered haematological parameters and serum protein constituents in the fingerlings. These may have a significant impact on physiological activities and may be vital in immunosuppression in the fingerlings with a strong negative impact on subsequent performance of the fish.     

Effect of inorganic phosphate supplementation on egg production in Hy-Line Brown layers fed 2000 FTU/kg phytase

Phytase has long been used to decrease the inorganic phosphorus (Pi) input in poultry diet. The current study was conducted to investigate the effects of Pi supplementation on laying performance, egg quality and phosphate–calcium metabolism in Hy-Line Brown laying hens fed phytase. Layers (n = 504, 29 weeks old) were randomly assigned to seven treatments with six replicates of 12 birds. The corn–soybean meal-based diet contained 0.12% non-phytate phosphorus (nPP), 3.8% calcium, 2415 IU/kg vitamin D₃ and 2000 FTU/kg phytase. Inorganic phosphorus (in the form of mono-dicalcium phosphate) was added into the basal diet to construct seven experimental diets; the final dietary nPP levels were 0.12%, 0.17%, 0.22%, 0.27%, 0.32%, 0.37% and 0.42%. The feeding trial lasted 12 weeks (hens from 29 to 40 weeks of age). Laying performance (housed laying rate, egg weight, egg mass, daily feed intake and feed conversion ratio) was weekly calculated. Egg quality (egg shape index, shell strength, shell thickness, albumen height, yolk colour and Haugh units), serum parameters (calcium, phosphorus, parathyroid hormone, calcitonin and 1,25-dihydroxyvitamin D), tibia quality (breaking strength, and calcium, phosphorus and ash contents), intestinal gene expression (type IIb sodium-dependent phosphate cotransporter, NaPi-IIb) and phosphorus excretion were determined at the end of the trial. No differences were observed on laying performance, egg quality, serum parameters and tibia quality. Hens fed 0.17% nPP had increased (P < 0.01) duodenum NaPi-IIb expression compared to all other treatments. Phosphorus excretion linearly increased with an increase in dietary nPP (phosphorus excretion = 1.7916 × nPP + 0.2157; R² = 0.9609, P = 0.001). In conclusion, corn–soybean meal-based diets containing 0.12% nPP, 3.8% calcium, 2415 IU/kg vitamin D₃ and 2000 FTU/kg phytase would meet the requirements for egg production in Hy-Line Brown laying hens (29 to 40 weeks of age).     

不同添加方式植酸酶处理豆粕对牙鲆生长和饲料利用率的影响

以初始平均体重(2.02±0.02)g的牙鲆(Paralichthys olivaceus)为实验对象,进行为期70d的摄食生长实验,研究不同添加方式的植酸酶对牙鲆生长和饲料利用的影响。在5000.0g豆粕中添加2.5g植酸酶,然后用产朊假丝酵母(Candidautilis)进行发酵预处理,得到植酸酶预处理豆粕。共制作4种等氮等能(粗蛋白49.7%、总能20.9kJ/g)饲料,对照饲料主要以鱼粉为蛋白源;在对照饲料的基础上,用豆粕蛋白替代45%的鱼粉蛋白配制成豆粕组饲料;在每千克豆粕组饲料中添加1000IU植酸酶,配制成植酸酶组饲料;用植酸酶预处理豆粕蛋白替代45%的鱼粉蛋白配制成植酸酶预处理豆粕组饲料。结果表明,与对照组相比较,用豆粕蛋白替代饲料中45%的鱼粉蛋白,若不添加植酸酶则显著降低牙鲆的特定生长率(P0.01)、饲料效率、蛋白质效率和氮贮积率(P0.05);直接添加植酸酶组、植酸酶预处理豆粕组牙鲆的特定生长率、饲料效率、蛋白质效率和氮贮积率与鱼粉对照组相比较没有出现显著差异(P0.05);与不添加植酸酶的豆粕组相比较,在含豆粕饲料中添加1000IU/kg饲料的植酸酶显著提高牙鲆的特定生长率(P0.01)、氮贮积率(P0.05)和磷贮积率(P0.01),显著降低氮排放率(P0.05)和磷排放率(P0.01),但饲料效率和蛋白质效率没有显著变化(P0.05);在豆粕中添加植酸酶进行发酵预处理,降低了豆粕中植酸含量,在饲料中添加植酸酶预处理豆粕显著提高牙鲆的特定生长率(P0.01)、饲料效率、蛋白质效率和氮贮积率(P0.05),显著降低氮(P0.05)、磷和钙的排放率(P0.01)。