Purification and characterization of a high-thermostable β-xylanase from newly isolated Thermomyces lanuginosus THKU-49

Highly thermostable β-xylanase produced by newly isolated Thermomyces lanuginosus THKU-49 strain was purified in a four-step procedure involving ammonium sulfate precipitation and subsequent separation on a DEAE-Sepharose fast flow column, hydroxylapatite column, and Sephadex G-100 column, respectively. The enzyme purified to homogeneity had a specific activity of 552 U/mg protein and a molecular weight of 24.9 kDa. The optimal temperature of the purified xylanase was 70°C, and it was stable at temperatures up to 60°C at pH 6.0; the optimal pH was 5.0–7.0, and it was stable in the pH range 3.5–8.0 at 4°C. Xylanase activity was inhibited by Mn²⁺, Sn²⁺, and ethylenediaminetetraacetic acid. The xylanase showed a high activity towards soluble oat spelt xylan, but it exhibited low activity towards insoluble oat spelt xylan; no activity was found to carboxymethylcellulose, avicel, filter paper, locust bean gum, cassava starch, and p-nitrophenyl β-d-xylopyranoside. The apparent K _m value of the xylanase on soluble oat spelt xylan and insoluble oat spelt xylan was 7.3 ± 0.236 and 60.2 ± 6.788 mg/ml, respectively. Thin-layer chromatography analysis showed that the xylanase hydrolyzed oat spelt xylan to yield mainly xylobiose and xylose as end products, but that it could not release xylose from the substrate xylobiose, suggesting that it is an endo-xylanase.     

Characterization of a thermostable and alkaline xylanase from Bacillus sp. and its bleaching impact on wheat straw pulp

Delignification efficacy of xylanases to facilitate the consequent chemical bleaching of Kraft pulps has been studied widely. In this work, an alkaline and thermally stable cellulase-less xylanase, derived from a xylanolytic Bacillus subtilis, has been purified by a combination of gel filtration and Q-Sepharose chromatography to its homogeneity. Molecular weight of the purified xylanase was 61 kDa by SDS–PAGE. The purified enzyme revealed an optimum assay temperature and pH of 60°C and 8.0, respectively. Xylanase was active in the pH range of 6.0–9.0 and stable up to 70°C. Divalent ions like Ca²⁺, Mg²⁺ and Zn²⁺ enhanced xylanase activity, whereas Hg²⁺, Fe²⁺, and Cu²⁺ were inhibitory to xylanase at 2 mM concentration. It showed K _m and V _max values of 9.5 mg/ml and 53.6 μmol/ml/min, respectively, using birchwood xylan as a substrate. Xylanase exhibited higher values of turn over number (K _cat) and catalytic efficiency (K _cat/K _m) with birchwood xylan than oat spelt xylan. Bleach-boosting enzyme activity at 30 U/g dry pulp displayed the optimum bio-delignification of Kraft pulp resulting in 26.5% reduction in kappa number and 18.5% ISO induction in brightness at 55°C after 3 h treatment. The same treatment improved the pulp properties including tensile strength and burst index, demonstrating its potential application in pre-bleaching of Kraft pulp.     

Purification and Characterization of Thermophilic Xylanase Isolated from the Xerophytic-<Emphasis Type="Italic">Cereus pterogonus</Emphasis> sp.

A thermo stable xylanase was purified and characterized from the cladodes of Cereus pterogonus plant species. The enzyme was purified to homogeneity by ammonium sulfate (80%) fractionation, ion exchange and size exclusion chromatography. The enzyme showed a final specific activity of 216.2 U/mg and the molecular mass of the protein was 80 KDa. The optimum pH and temperature for xylanase activity were 5.0 and 80 °C, respectively,. With oat spelt xylan as a substrate the enzyme yielded a Km value of 2.24 mg/mL and a Vmax of 5.8 μmol min⁻¹ mg⁻¹. In the presence of metal ions (1 mM) such as Co²⁺,Mn²⁺, Ni²⁺, Ca²⁺ and Fe³⁺ the activity of the enzyme increased, where as strong inhibition of the enzyme activity was observed with the use of Hg²⁺, Cd²⁺, Cu²⁺, while partial inhibition was noted with Zn²⁺ and Mg²⁺. The substrate specificity of the xylanase yielded maximum activity with oat spelt xylan.     

Molecular cloning and characterization of a novel thermostable xylanase from Paenibacillus campinasensis BL11

An open reading frame (XylX) with 1131 nucleotides from Paenibacillus campinasensis BL11 was cloned and expressed in E. coli. It encodes a family 11 endoxylanase, designated as XylX, of 41 kDa. The homology of the amino acid sequence deduced from XylX is only 73% identical to the next closest sequence. XylX contains a family 11 catalytic domain of the glycoside hydrolase and a family 6 cellulose-binding module. The recombinant xylanase was fused to a His-tag for affinity purification. The XylX activity was 2392 IU/mg, with a K_m of 6.78 mg/ml and a V_max of 4953 mol/min/mg under optimal conditions (pH 7, 60 °C). At pH 11, 60 °C, the activity was still as high as 517 IU/mg. Xylanase activities at 60 °C under pH 5 to pH 9 remained at more than 69.4% of the initial activity level for 8 h. The addition of Hg²⁺ at 5 mM almost completely inhibited xylanase activity, whereas the addition of tris-(2-carboxyethyl)-phosphine (TCEP) and 2-mercaptoethanol stimulated xylanase activity. No relative activities for Avicel, CMC and d-(+)-cellobiose were found. Xylotriose constitutes the majority of the hydrolyzed products from oat spelt and birchwood xylan. Broad pH and temperature stability shows its application potentials for biomass conversion, food and pulp/paper industries.     

Purification and characterization of an endoxylanase from the culture broth of <Emphasis Type="Italic">Bacillus cereus</Emphasis> BSA1

An extracellular xylanase from the fermented broth of Bacillus cereus BSA1 was purified and characterized. The enzyme was purified to 3.43 fold through ammonium sulphate precipitation, DEAE cellulose chromatography and followed by gel filtration through Sephadex-G-100 column. The molecular mass of the purified xylanse was about 33 kDa. The enzyme was an endoxylanase as it initially degraded xylan to xylooligomers. The purified enzyme showed optimum activity at 55°C and at pH 7.0 and remained reasonably stable in a wide range of pH (5.0–8.0) and temperature (40–65°C). The K _m and V _max values were found to be 8.2 mg/ml and 181.8 μmol/(min mg), respectively. The enzyme had no apparent requirement of cofactors, and its activity was strongly inhibited by Cu²⁺, Hg²⁺. It was also a salt tolerant enzyme and stable upto 2.5 M of NaCl and retained its 85% activity at 3.0 M. For stability and substrate binding, the enzyme needed hydrophobic interaction that revealed when most surfactants inhibited xylanase activity. Since the enzyme was active over wide range of pH, temperature and remained active in higher salt concentration, it could find potential uses in biobleaching process in paper industries.     

Purification, characterization and mass spectroscopic analysis of thermo-alkalotolerant ��-1, 4 endoxylanase from Bacillus sp. and its potential for dye decolorization

A Bacillus sp., isolated from sludge and sediments of pulp and paper mill, was found to produce xylanase in a synthetic culture media containing oat spelt xylan (1% w/v) and 10% black liquor as inducers along with 2.5% (w/v) sucrose as additional carbon source. The purified enzyme was highly thermostable with half-life of 10 min at 90 °C and pH 8. The enzyme was stable over a broad range of pH (pH 6-10) and showed good thermal stability when incubated at 70 °C. Chemicals like EDTA, Hg²⁺, Cu²⁺ and solvents like glycerol and acetonitrile completely inhibited enzyme activity at high concentration. The molecular weights of the purified enzyme, determined by matrix-assisted laser desorption/ionization coupled with time-of-flight mass spectrometry (MALDI-TOF/MS) analysis was analogous to the results obtained from SDS-PAGE, i.e. 55 kDa. Kinetic parameters were determined by using oat spelt xylan as substrate. The K_M and V_max values of the enzyme were 4.4 mg/ml and 287 U/mg respectively. At high xylan concentrations (>70 mg/ml) a substrate inhibition phenomenon of the enzyme was observed. In addition, crude xylanase showed enormous potential for decolorization of various recalcitrant dyes.     

Biochemical and Biophysical Characterization of Purified Thermophilic Xylanase Isoforms in Cereus pterogonus Plant Spp

Two thermostable xylanase isoforms T₆₀ and T₈₀ were purified to homogeneity from the cladodes of the xerophytic Cereus pterogonus plant species. After three consecutive purification steps, the specific activity of T₆₀ and T₈₀ isoforms were found to be 178.6 and 216.2 U mg⁻¹ respectively. The molecular mass of both isoforms was determined to be 80 kDa. The optimum temperature for T₆₀ and T₈₀ xylanase isoforms were 60 and 80 °C respectively. The pH was 5.0 for both isoforms. The presence of divalent metal ions (10 mM Co²⁺) showed stimulatory effects of both catalytic activities, where as in the presence of Hg²⁺, Cd²⁺, Cu²⁺ showed inhibitory effect on these activities at all concentrations studied. The thermodynamic analysis of xylanase activity using denaturation kinetics and the presence divalent cations at 30–100 °C, showed lower ΔH, ΔS, and ΔG values at all the temperatures investigated. The melting temperature of purified T₈₀ xylanase isoform as determined by TG/DTA analysis and it showed the unfolding temperature was 80 °C. The g value and hyperfine (A) value purified xylanase T₈₀ isoform was 2.017 and 10.80 respectively. Immunoblot analysis with antiserum raised against the purified T₈₀ xylanase isoforms revealed single immunolgically related polypeptides of 80 kDa, identical with the polypeptide band produced on SDS-PAGE. The results of double immunodiffusion against the T₈₀ isoforms showed a single precipitin line indicating that the serum used was specific to these xylanase isoforms. The kinetic and thermodynamic properties suggested that xylanase from C. pterogonus may have a potential usage in various industries.     

High expression of recombinant <Emphasis Type="Italic">Streptomyces</Emphasis> sp. S38 xylanase in <Emphasis Type="Italic">Pichia pastoris</Emphasis> by codon optimization and analysis of its biochemical properties

In recent years, the biotechnological use of xylanases has grown remarkably. To efficiently produce xylanase for food processing and other industry, a codon-optimized recombinant xylanase gene from Streptomyces sp. S38 was synthesized and extracellularly expressed in Pichia pastoris under the control of AOX1 promoter. SDS-PAGE and activity assay demonstrated that the molecular mass of the recombinant xylanase was estimated to be 25 kDa, the optimum pH and optimum temperature were 5.5 and 50°C, respectively. In shake flask culture, the specific activity of the xylanase activity was 5098.28 U/mg. The K _m and V _max values of recombinant xylanase were 11.0 mg/ml and 10000 μmol min⁻¹ mg⁻¹, respectively. In the presence of metal ions such as Ca²⁺, Cu²⁺, Cr³⁺ and K⁺, the activity of the enzyme increased. However, strong inhibition of the enzyme activity was observed in the presence of Hg²⁺. This is the first report on the expression properties of a recombinant xylanase gene from the Streptomyces sp. S38 using Pichia pastoris. The attractive biochemical properties of the recombinant xylanase suggest that it may be a useful candidate for variety of commercial applications.     

Cloning,purification and characterization of an alkali-stable endoxylanase from thermophilic <Emphasis Type="Italic">Geobacillus</Emphasis> sp. 71

The gene encoding a xylanase from Geobacillus sp. 71 was isolated, cloned, and sequenced. Purification of the Geobacillus sp 7.1 xylanase, XyzGeo71, following overexpression in E. coli produced an enzyme of 47 kDa with an optimum temperature of 75°C. The optimum pH of the enzyme is 8.0, but it is active over a broad pH range. This protein showed the highest sequence identity (93%) with the xylanase from Geobacillus thermodenitrificans NG80-2. XyzGeo71 contains a catalytic domain that belongs to the glycoside hydrolase family 10 (GH10). XyzGeo71 exhibited good pH stability, remaining stable after treatment with buffers ranging from pH 7.0 to 11.0 for 6 h. Its activity was partially inhibited by Al³⁺ and Cu²⁺ but strongly inhibited by Hg²⁺. The enzyme follows Michaelis–Menten kinetics, with K_m and V_max values of 0.425 mg xylan/ml and 500 μmol/min.mg, respectively. The enzyme was free from cellulase activity and degraded xylan in an endo fashion. The action of the enzyme on oat spelt xylan produced xylobiose and xylotetrose.     

A halotolerant type A feruloyl esterase from Pleurotus eryngii

An extracellular feruloyl esterase (PeFaeA) from the culture supernatant of Pleurotus eryngii was purified to homogeneity using cation exchange, hydrophobic interaction, and size exclusion chromatography. The length of the complete coding sequence of PeFaeA was determined to 1668 bp corresponding to a protein of 555 amino acids. The catalytic triad of Ser-Glu-His demonstrated the uniqueness of the enzyme compared to previously published FAEs. The purified PeFaeA was a monomer with an estimated molecular mass of 67 kDa. Maximum feruloyl esterase (FAE) activity was observed at pH 5.0 and 50 °C, respectively. Metal ions (5 mM), except Hg²⁺, had no significant influence on the enzyme activity. Substrate specificity profiling characterized the enzyme as a type A FAE preferring bulky natural substrates, such as feruloylated saccharides, rather than small synthetic ones. K_m and k_cat of the purified enzyme for methyl ferulate were 0.15 mM and 0.85 s⁻¹. In the presence of 3 M NaCl activity of the enzyme increased by 28 %. PeFaeA alone released only little ferulic acid from destarched wheat bran (DSWB), whereas after addition of Trichoderma viride xylanase the concentration increased more than 20 fold.     

Isolation,purification, and characterization of haloalkaline xylanase from a marine <Emphasis Type="Italic">Bacillus pumilus</Emphasis> strain,GESF-1

A haloalkalitolerant xylanase-producing Bacillus pumilus strain, GESF1 was isolated from an experimental salt farm of CSMCRI. Birch wood xylan and xylose induced maximum xylanase production with considerable activity seen in wheat straw and no activity at all with caboxymethyl cellulose (CMC). A three step purification yielded 21.21-fold purification with a specific activity of 112.42 U/mg protein (unit expressed as μmole of xylose released per min). Xylanase produced showed an optimum activity at pH 8.0, with approximately 50 and 30% relative activity at a pH 6.0 and 10.0, respectively. The temperature optimum was 40°C and kinetic properties such as K_m and V_max were 5.3 mg/mL and 0.42 μmol/min/mL (6593.4 μmol/min/mg protein). Xylanase activity (160∼ 120%) was considerably enhanced in 2.5 to 7.5% NaCl with 87 and 73% retention of activity in 10 and 15% of NaCl. Enzyme activity was enhanced by Ca²⁺, Mn²⁺, Mg²⁺, and Na⁺ but strongly inhibited by heavy metals such as Hg²⁺, Fe³⁺, Cu²⁺, Cd²⁺, and Zn²⁺. Organic reagents such as β-Mercaptoethanol enhanced xylanase activity whereas EDTA strongly inhibited its activity. Xylanase, purified from the Bacillus pumilus strain, GESF1 could have potential biotechnological applications.     

Purification and characterization of a thermoalkalophilic xylanase from <Emphasis Type="Italic">Bacillus</Emphasis> sp.

Summary An extracellular xylanase was purified to homogeneity from the culture filtrate of a thermophilic Bacillus sp. The molecular weight of the purified xylanase was 44 kDa, as analysed by SDS/PAGE. The enzyme reaction followed Michaelis–Menten kinetics with K_m^app and V_max values of 0.025 mg/ml and 450 U/mg protein, respectively, as obtained from a Lineweaver–Burk plot. The xylanase contained no other enzyme activity except for the hydrolysis of xylan substrate. The optimal temperature of the enzyme assay was 50 °C. The optimum pH for the xylanase activity was at three peaks 6.5, 8.5 and 10.5, respectively and the enzyme was stable over a broad range of pH from pH 6 to 10.5. Metal ions tested with demetalized enzyme had no effect, with the exception of Hg²⁺ and Pb²⁺ (both strong inhibitors). Inhibition of the enzyme activity by N-bromosuccinimide (amino acid modifier) indicated the role of tryptophan residues in the catalytic function of the enzyme. Due to these outstanding properties, the xylanase of Bacillussp. finds potential applications in biopulping, biobleaching and de-inking of recycled paper and other industrial processes.     

Biochemical characterization of an endoxylanase from Pseudozyma brasiliensis sp. nov. strain GHG001 isolated from the intestinal tract of Chrysomelidae larvae associated to sugarcane roots

Endo-xylanases play a key role in the hydrolysis of xylan and recently they have attracted much attention due to their potential applications on the biofuel and paper industries. We isolated a Pseudozyma brasiliensis sp. nov. strain from the intestinal tract of Chrysomelidae larvae that parasitize sugarcane roots. This basidiomycetous yeast produces a xylanase designated PbXynA which was purified and characterized. The molecular weight of PbXynA is 24 kDa, it belongs to the GH11 family and its optimum pH and optimum temperature are 4.0 and 55 °C, respectively. PbXynA has as secondary structure predominantly β-sheets and sigmoidal kinetic behavior with elevated speed conversion from substrate-to-products (V_max = 2792.0 μmol product/min/mg protein). It is highly activated by bivalent cations such as Ca²⁺, however in the presence of Cu²⁺ xylanase activity was inhibited. It has a high specific activity and produces xylooligosaccharides that have a variety of industrial applications, indicating PbXynA has a great biotechnological potential.     

Purification and partial characterisation of a thermostable xylanase from salt-tolerant Thermobifida halotolerans YIM 90462T

ThxynA, an extracellular xylanase of T. halotolerans YIM 90462^T, was purified to homogeneity from a fermentation broth by ultra-filtration, ammonium sulphate precipitation, hydrophobic chromatography and ion exchange chromatography. The purified xylanase has a molecular mass of 24 kDa and is optimally active at 80 °C and pH 6.0. The enzyme is stable over a broad pH range (pH 6.0–10.0) and shows good thermal stability when incubated at 70 °C for 1 h. The K_m and V_max values of the enzyme are 11.6 mg/mL and 434 μmol mg^?1 min^?1, respectively, using oat spelt xylan as a substrate. Moreover, the enzyme seemingly has both xylanase activity and cellulase activity. These unique properties suggest that it may be useful for industrial applications.     

Characterization of a recombinant thermostable xylanase from deep-sea thermophilic Geobacillus sp. MT-1 in East Pacific

A novel xylanase-producing thermophilic strain MT-1 was isolated from a deep-sea hydrothermal field in east Pacific. A xylanase gene encoding 331 amino-acid peptide from this isolate was cloned and expressed in Escherichia coli. The recombinant xylanase exhibited maximum activity at 70°C and had an optimum pH of 7.0. It was active up to 90°C and showed activity over a wide pH ranging from 5.5 to 10.0. The crude xylanase presented similar properties in temperature and pH to those of the recombinant xylanase. The recombinant xylanase was stable in 1 mM of enzyme inhibitors (PMSF, EDTA, 2-ME or DTT) and in 0.1% detergents (Tween 20, Chaps or Triton X-100), whereas, it was strongly inhibited by sodium dodecyl sulfate (SDS) (1 mM). In addition, its catalytic function was stable in the presence of Li⁺, Na⁺ or K⁺. However, it was strongly inhibited by Ni²⁺, Mn²⁺, Co²⁺, Cu²⁺, Zn²⁺, Cd²⁺, Hg²⁺ and Al³⁺ (1 or 0.1 mM). The K _m and V _max of the recombinant xylanase for oat spelt xylan were calculated to be 1.579 mg/ml and 289 μmol/(min • mg), respectively. Our study, therefore, presented a rapid overexpression and purification of xylanase from deep-sea thermophile aimed at improving the enzyme yield for industrial applications and scientific research.     

A new acidophilic endo-β-1,4-xylanase from Penicillium oxalicum: cloning,purification, and insights into the influence of metal ions on xylanase activity

A new acidophilic xylanase (XYN11A) from Penicillium oxalicum GZ-2 has been purified, identified and characterized. Synchronized fluorescence spectroscopy was used for the first time to evaluate the influence of metal ions on xylanase activity. The purified enzyme was identified by MALDI TOF/TOF mass spectrometry, and its gene (xyn11A) was identified as an open reading frame of 706 bp with a 68 bp intron. This gene encodes a mature protein of 196 residues with a predicted molecular weight of 21.3 kDa that has the 100 % identity with the putative xylanase from the P. oxalicum 114-2. The enzyme shows a structure comprising a catalytic module family 10 (GH10) and no carbohydrate-binding module family. The specific activities were 150.2, 60.2, and 72.6 U/mg for beechwood xylan, birchwood xylan, and oat spelt xylan, respectively. XYN11A exhibited optimal activity at pH 4.0 and remarkable pH stability under extremely acidic condition (pH 3). The specific activity, K _m and V _max values were 150.2 U/mg, 30.7 mg/mL, and 403.9 μmol/min/mg for beechwood xylan, respectively. XYN11A is a endo-β-1,4-xylanase since it release xylobiose and xylotriose as the main products by hydrolyzing xylans. The activity of XYN11A was enhanced 155 % by 1 mM Fe²⁺ ions, but was inhibited strongly by Fe³⁺. The reason of enhancing the xylanase activity of XYN11A with 1 mM Fe²⁺ treatment may be responsible for the change of microenvironment of tryptophan residues studied by synchronous fluorescence spectrophotometry. Inhibition of the xylanase activity by Fe³⁺ was first time demonstrated to associate tryptophan fluorescence quenching.     

Biochemical characterization,cloning and molecular modeling of a detergent and organic solvent-stable family 11 xylanase from the newly isolated Aspergillus niger US368 strain

New β-1,4-d-xylan xylanohydrolase (XAn11) belonging to the xylanase 11 family was purified to homogeneity from a newly soil-isolated Aspergillus niger US368 strain. The pure xylanase is a glycosylated monomer having a molecular mass of about 26 kDa. The N-terminal sequence of the purified enzyme was determined and compared to some Aspergillus xylanases N-terminal ones. The gene encoding the XAn11 was cloned and sequenced.The maximal xylanase activity was obtained at pH 5.0 and 55 °C. The XAn11 was found to be stable in a wide range of pH (3–9) and in presence of some detergents and organic solvents. A specific activity of about 805.6 U/mg or 334 U/mg was measured using birchwood xylan or oatspelt xylan as substrate, respectively. A structural explanation of the difference between experimental and theoretical molecular mass as well as the stability of the enzyme against acidic pH was proposed by molecular modeling.     

Study of the intracellular xylanolytic activity of the phytopathogenic fungus Sporisorium reilianum

The present study demonstrates that Sporisorium reilianum, a phytopathogenic fungus of corn, produces intracellular xylanolytic activity during submerged fermentation. Production reached its highest levels in a medium containing glucose, corn hemicellulose and yeast extract. An intracellular xylanase was purified by a process that included precipitation with ammonium sulfate, ion exchange chromatography and gel filtration. Optimal pH and temperature values were 5.0 and 60 °C, respectively. The enzyme showed activity through a broad pH range. The molecular weights of pure xylanase were 36 and 37 kDa, determined by SDS PAGE and gel filtration, respectively. K_m and V_max were 0.160 mg/mL and 1.564 μmol/min/mg, respectively, on a substrate of birchwood xylan. SDS, EDTA, β-Mercaptoethanol, Tween 80, Triton and Mn²⁺ and Ca²⁺ strongly inhibited activity. The purified enzyme hydrolyzed xylan, releasing xylotriose and xylobiose. Sequence protein analysis showed 95% similarity with the theoretical protein encoded by the sr14403 gene of S. reilianum, which encodes a putative endo-β-1,4-xylanase. The enzyme is an isoform of the extracellular xylanase SRXL1 of this basidiomycete.     

Identification of Paenibacillus sp. 2S-6 and application of its xylanase on biobleaching

A Paenibacillus sp. strain 2S-6 was isolated from the black liquor of the first brownstock washing stage of kraft pulping process and identified by its 16S rDNA sequence. This bacterial strain utilized a variety of saccharides and polysaccharides as carbon source, but neither lignin nor lipids. Crude xylanase from Paenibacillus sp. 2S-6 was produced in a 5 L laboratory fermenter at 37 °C, pH 7. After 24 h, up to 10.5 IU xylanase per mg of protein in the crude extract of fermentation broth was obtained. After two-stage ultrafiltration, the optimal activity of partially purified xylanase reached 60.51 IU/mg at 50 °C, pH 6. A major band indicating molecular weight of 33 kDa was shown on SDS-PAGE for the partially purified xylanase. After 4 h at 60 °C, 48.99% and 31.25% residual xylanase activities were demonstrated at pH 7 and 9, respectively. Efficacy of its xylanase on the bleaching agent saving was demonstrated by using 5 IU xylanase per gram oven-dried pulp prior to bleaching, referred as biobleaching. Identical levels of brightness and higher levels of viscosity were obtained for the xylanase pretreated eucalypt kraft pulps followed by a 20% reduction of the bleaching agent dosage in the first step of a commercial C₇₀/D₃₀-E_o-D bleaching sequence.     

Production, Purification, and Characterization of β-(1-4)-Endoxylanase of Streptomyces roseiscleroticus

Twelve species of Streptomyces that formerly belonged to the genus Chainia were screened for the production of xylanase and cellulase. One species, Streptomyces roseiscleroticus (Chainia rosea) NRRL B-11019, produced up to 16.2 IU of xylanase per ml in 48 h. A xylanase from S. roseiscleroticus was purified and characterized. The enzyme was a debranching β-(1-4)-endoxylanase showing high activity on xylan but essentially no activity against acid-swollen (Walseth) cellulose. It had a very low apparent molecular weight of 5,500 by native gel filtration, but its denatured molecular weight was 22,600 by sodium dodecyl sulfate-polyacrylamide gel electrophoresis. It had an isoelectric point of 9.5. The pH and temperature optima for hydrolysis of arabinoxylan were 6.5 to 7.0 and 60°C, respectively, and more than 75% of the optimum enzyme activity was retained at pH 8.0. The xylanase had a K_m of 7.9 mg/ml and an apparent V_max of 305 μmol · min^-1 · mg of protein^-1. The hydrolysis rate was linear for xylan concentrations of less than 4 mg/ml, but significant inhibition was observed at xylan concentrations of more than 10 mg/ml. The predominant products of arabinoxylan hydrolysis included arabinose, xylobiose, and xylotriose.