Thermal inactivation of Listeria monocytogenes and Yersinia enterocolitica in minced beef under laboratory conditions and in sous-vide prepared minced and solid beef cooked in a commercial retort

D-values were obtained for Listeria monocytogenes and Yersinia enterocolitica at 50, 55 and 60 degrees C in vacuum-packed minced beef samples heated in a laboratory water-bath. The experiment was repeated using vacutainers, which allowed heating of the beef to the desired temperature before inoculation. D-values of between 0.15 and 36.1 min were obtained for L. monocytogenes. Pre-heating the beef samples significantly affected (P < 0.05) the D60 value only. D-values for Y. enterocolitica ranged from 0.55 to 21.2 min and all the D-values were significantly different (P < 0.05) after pre-heating. In general, the D-values obtained for core inoculated solid beef samples were significantly higher (P < 0.05) than those generated in minced beef when heated in a Barriquand Steriflow commercial retort.     

Comparison of selective and non-selective enrichment media in the detection of Listeria monocytogenes from meat containing Listeria innocua

AIMS: This study investigated whether the higher incidence of recovery from meat of Listeria innocua compared with L. monocytogenes could be due to the laboratory media used, leading to an artificially lower detection of the pathogenic species, L. monocytogenes. METHODS AND RESULTS: Minced beef was inoculated with L. monocytogenes, L. innocua, or a mixture of these species, and stored at 0 or 10 degrees C under vacuum or aerobic conditions for up to 28 days. Listeria were recovered from the minced beef using selective (University of Vermont Medium, UVM) and non-selective (Buffered Peptone Water, BPW) enrichment broths after 0, 14, and 28 days of storage. In general, there were no significant differences (P < 0.05) between the numbers of L. monocytogenes recovered from minced beef samples after 24 h enrichment in BPW and the numbers recovered using UVM. In addition, the presence of L. innocua in meat samples containing L. monocytogenes did not significantly (P < 0.05) affect the numbers of L. monocytogenes recovered using either enrichment broth. In most cases there were no significant differences (P < 0.05) between the numbers of L. innocua recovered from minced beef samples after 24 h enrichment in BPW compared with numbers recovered using UVM. CONCLUSION: Listeria innocua was found to have no significant competitive advantage over L. monocytogenes in selective or non-selective enrichment media. SIGNIFICANCE AND IMPACT OF THE STUDY: The results suggest that, in some instances, the use of a selective enrichment broth offers no advantage over a non-selective enrichment broth for the recovery of Listeria species from minced beef.     

Sensitivity of nisin-resistant Listeria monocytogenes to heat and the synergistic action of heat and nisin

Nisin, a bacteriocin produced by some strains of Lactococcus lactis, acts against foodborne pathogen Listeria monocytogenes. A single exposure of cells to nisin can generate nisin-resistant (Nisr) mutants, which may compromise the use of nisin in the food industry. The objective of this research was to compare the heat resistance of Nisr and wild type (WT) Listeria monocytogenes. The synergistic effect of heat-treatment (55 degrees C) and nisin (500 IU ml-1) on the Nisr cells and the WT L. monocytogenes Scott A was also studied. When the cells were grown in the absence of nisin, there was no significant (alpha = 0.05) difference in heat resistance between WT and Nisr cells of L. monocytogenes at 55, 60 and 65 degrees C. However, when the Nisr cells were grown in the presence of nisin, they were more sensitive to heat at 55 degrees C than the WT cells. The D-values at 55 degrees C were 2.88 and 2.77 min for Nisr ATCC 700301 and ATCC 700302, respectively, which was significantly (alpha = 0.05) lower than the D-value for WT, 3.72 min. When Nisr cells were subjected to a combined treatment of heat and nisin, there was approximately a four log reduction during the first 7 min of treatment.     

A comparative heat inactivation study of indigenous microflora in beef with that of Listeria monocytogenes,Salmonella serotypes and Escherichia coli O157:H7

AIMS: Thermal inactivation of a mixture of five strains of Listeria monocytogenes, four strains of Escherichia coli O157:H7 and eight serotypes of Salmonella were compared with that of indigenous microflora in 75% lean ground beef. METHODS AND RESULTS: Inoculated meat was packaged in bags that were completely immersed in a circulating water bath and held at 55, 57.5 and 60 degrees C for predetermined lengths of time. The surviving cell population was enumerated by spiral plating heat-treated samples onto tryptic soya agar supplemented with 0.6% yeast extract and 1% sodium pyruvate. D-values, determined by linear regression, in beef were 77.49, 21.9, and 10.66 min at 55, 57.5, and 60 degrees C, respectively, for indigenous microflora (z = 5.81 degrees C). When either of the three pathogens were heated in beef, their D-values calculated were significantly lower (P < 0.05) than those of indigenous microflora at all temperatures. The slope of the thermal death time curve for L. monocytogenes, E. coli O157:H7 and indigenous microflora were similar. Using a survival model for nonlinear survival curves, the D1-values at all temperatures for L. monocytogenes were significantly higher (P < 0.05) compared with those for Salmonella serotypes, E. coli O157:H7 or indigenous microflora. However, higher recovery of a subpopulation of the indigenous microflora in beef exposed to heating at 55, 57.5 or 60 degrees C resulted in significantly higher (P < 0.05) D2-values at all three temperatures, compared with those of the three pathogens at the same test temperatures. CONCLUSIONS: If the thermal process is designed to ensure destruction of indigenous microbial flora, it should also provide an adequate degree of protection against L. monocytogenes, Salmonella serotypes or E. coli O157:H7. SIGNIFICANCE AND IMPACT OF THE STUDY: The results of this study will assist the retail food industry in designing acceptance limits on critical control points that ensure safety, without introducing pathogens in a retail food environment, against L. monocytogenes, E. coli O157:H7 and Salmonella in cooked ground beef.     

The effect of culture growth phase on induction of the heat shock response in Yersinia enterocolitica and Listeria monocytogenes

The effect of culture growth phase on induction of the heat shock response in Yersinia enterocolitica and Listeria monocytogenes, was examined. Exponential or stationary preconditioned cultures were heat shocked and survivor numbers estimated using selective and overlay/resuscitation recovery techniques. The results indicate that prior heat shock induced increased heat resistance in both micro-organisms to higher heat treatments. Heat-shocked cells of each micro-organism were able to survive much longer than non-heat-shocked cells when heated at 55 degrees C. The size of the change in heat resistance between heat-shocked and non-heat-shocked cells was greatest for exponential cultures (X:X). Results indicate that the overall relative thermal resistance of each pathogen was dependent on cell growth phase. Stationary cultures (S:S) were significantly (P < 0.01) more thermotolerant than exponential cultures (X:X) under identical processing conditions. Under most conditions, the use of an overlay/resuscitation recovery medium resulted in higher D-values (P < 0.05) compared with a selective recovery medium.     

The glutamate decarboxylase acid resistance mechanism affects survival of Listeria monocytogenes LO28 in modified atmosphere-packaged foods

AIMS: The contribution of the glutamate decarboxylase (GAD) acid resistance system to survival and growth of Listeria monocytogenes LO28 in modified atmosphere-packaged foods was examined. METHODS AND RESULTS: The survival and growth of the wild-type LO28 and four GAD deletion mutants (DeltagadA, DeltagadB, DeltagadC, DeltagadAB) in packaged foods (minced beef, lettuce, dry coleslaw mix) during storage at 4, 8 and 15 degrees C were studied. Survival and growth patterns varied with strain, product type, gas atmosphere and storage temperature. In minced beef, the wild-type LO28 survived better (P < 0.05) than the GAD mutant strains at 8 and 15 degrees C. In both packaged vegetables at all storage temperatures, the wild-type strain survived better (P < 0.05) than the double mutant DeltagadAB. The requirement for the individual gad genes varied depending on the packaged food. In the case of lettuce, gadA played the most important role, while the gadB and gadC genes played the greatest role in packaged coleslaw (at 15 degrees C). CONCLUSIONS: This work demonstrates that elements of the GAD system play significant roles in survival of L. monocytogenes LO28 during storage in modified atmosphere-packaged foods. SIGNIFICANCE AND IMPACT OF THE STUDY: A better understanding of how L. monocytogenes behaves in modified atmosphere-packaged foods, and how it responds to elevated carbon dioxide atmospheres.     

Synergistic effect of heat and sodium lactate on the thermal resistance of Yersinia enterocolitica and Listeria monocytogenes in minced beef

The effect of sodium lactate (NaL) (0, 2.4 or 4.8%), in heating and recovery media, on Yersinia enterocolitica and Listeria monocytogenes numbers recovered from minced beef heated at 55 degrees C, was examined. Survivors were enumerated on selective media at pH 5.7/7.4 (Y. enterocolitica) or pH 5.7/7.2 (L. monocytogenes). Recovery of the organisms depended on the pH and NaL levels in the recovery medium. The heat resistance of Y. enterocolitica (P < 0.001) and L. monocytogenes (P < 0.01) decreased as the concentration of NaL in the minced beef increased from 0 to 2.4% or 4.8%. The thermal destruction of pathogens in foods processed using mild temperatures may be enhanced by the addition of 2.4% NaL.     

Evaluation of the pH-dependent,stationary-phase acid tolerance in Listeria monocytogenes and Salmonella Typhimurium DT104 induced by culturing in media with 1% glucose: a comparative study with Escherichia coli O157:H7

AIMS: To comparatively evaluate the adaptive stationary-phase acid tolerance response (ATR) in food-borne pathogens induced by culturing in glucose-containing media, as affected by strain variability and antibiotic resistance, growth temperature, challenge pH and type of acidulant. METHODS AND RESULTS: Antibiotic resistant or sensitive strains of Listeria monocytogenes, Salmonella including S. Typhimurium DT104, and Escherichia coli O157:H7 were cultured (30 degrees C for 24 h; 10 degrees C for up to 14 days) in trypticase soya broth with yeast extract (TSBYE) with 1% or without glucose to induce or prevent acid adaptation, respectively. Cultures were subsequently exposed to pH 3.5 or 3.7 with lactic or acetic acid at 25 degrees C for 120 min. Acid-adapted cultures were more acid tolerant than nonadapted cultures, particularly those of L. monocytogenes and Salmonella. No consistent, positive or negative, influence of antibiotic resistance on the pH-inducible ATR or acid resistance (AR) was observed. Compared with 30 degrees C cultures, growth and acid adaptation of L. monocytogenes and S. Typhimurium DT104 at 10 degrees C markedly reduced their ATR and AR in stationary phase. E. coli O157:H7 had the greatest AR, relying less on acid adaptation. A 0.2 unit difference in challenge pH (3.5-3.7) caused great variations in survival of acid-adapted and nonadapted cells. CONCLUSIONS: Culturing L. monocytogenes and Salmonella to stationary phase in media with 1% glucose induces a pH-dependent ATR and enhances their survival to organic acids; thus, this method is suitable for producing acid-adapted cultures for use in food challenge studies. SIGNIFICANCE AND IMPACT OF THE STUDY: Bacterial pathogens may become acid-adapted in foods containing glucose or other fermentable carbohydrates. Low storage temperatures may substantially decrease the stationary-phase ATR of L. monocytogenes and S. Typhimurium DT104, but their effect on ATR of E. coli O157:H7 appears to be far less dramatic.     

An investigation of the thermal inactivation of Staphylococcus aureus and the potential for increased thermotolerance as a result of chilled storage

AIMS: The aims of this study were; (i) to provide thermal inactivation data for Staphylococcus aureus; (ii) to examine the kinetics, including decimal reduction times (D-value) and rate constants (k), that describe the thermal inactivation of Staph. aureus and to compare two different methods of calculating D-values and (iii) to determine whether or not chilled storage would toughen these microorganisms resulting in increased thermotolerance. METHODS AND RESULTS: Isolates of Staph. aureus recovered from domestic refrigerators were grown in shaken culture for 8 h at 37 degrees C, recovered and washed by centrifugation and combined to form a cocktail of five strains. Samples from this cocktail were (a) heat treated at 50, 55 and 60 degrees C or (b) held under simulated domestic refrigeration conditions for 72 h and then heat treated as above. The numbers of Staph. aureus in heat treated and chill held, heat treated samples were enumerated by direct selective plating onto Baird Parker Agar (BPA) and recovery plating on Tryptone Soya Agar (TSA) subsequently overlaid with BPA. D-values were obtained using two different methods both of which may be used when the thermal inactivation follows first order kinetics. In the first method D-values are obtained by plotting the Log(10) of the surviving cells against time and using the equation D = -1/slope. The second method uses the rate constant (k) which is obtained from the slope of a plot of ln N/N(0)vs time and D is obtained using the equation D = 2.303 k(-1). D(50), D(55) and D(60) values ranged from 94.3 to 127.9 min, 13 to 21.7 min and 4.8 to 6.5 min. Prechilling did not enhance thermal resistance. The method of calculation did not affect the D-values obtained because the thermal inactivation of Staph. aureus in this study followed first order kinetics with r(2) values of 0.91-0.99. CONCLUSIONS: The thermal inactivation of Staph. aureus in tryptone soya broth (TSB) follows first order kinetics and in general chilling of these bacteria does not increase the resistance to thermal destruction during subsequent thermal processes such as cooking. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides much needed data on the thermal resistance of Staph. aureus and validates chilling as a food storage activity which does not cause toughening of the microorganisms to subsequent cooking. However, the data generated strongly suggests that Staph. aureus is more thermotolerant than Listeria monocytogenes and should be used as the target microorganism in designing mild thermal treatments for food, in which case the current recommendations for pasteurization (70 degrees C for 2 min, minimum) should be revised.     

The effect of prior heat shock on the thermoresistance of Salmonella thompson in foods

The resistance of Salmonella thompson to heating at 54° or 60°C in tryptone soya broth, liquid whole egg, 10% or 40% reconstituted dried milk or minced beef was increased if cells were held at 48°C for 30 min before heating at the higher temperatures. Induction of thermotolerance by mild heat shock is thus not confined to cells grown and heated in broth systems. The heat shock phenomenon may therefore have implications for the safety of foods given marginal heat treatment.     

Heat shock and thermotolerance of Escherichia coli O157:H7 in a model beef gravy system and ground beef

Duplicate beef gravy or ground beef samples inoculated with a suspension of a four-strain cocktail of Escherichia coli O157:H7 were subjected to sublethal heating at 46 °C for 15–30 min, and then heated to a final internal temperature of 60 °C. Survivor curves were fitted using a linear model that incorporated a lag period (T_L), and D-values and 'time to a 4D inactivation' (T_4D) were calculated. Heat-shocking allowed the organism to survive longer than non-heat-shocked cells; the T_4D values at 60 °C increased 1·56- and 1·50-fold in beef gravy and ground beef, respectively. In ground beef stored at 4 °C, thermotolerance was lost after storage for 14 h. However, heat-shocked cells appeared to maintain their thermotolerance for at least 24 h in ground beef held at 15 or 28 °C. A 25 min heat shock at 46 °C in beef gravy resulted in an increase in the levels of two proteins with apparent molecular masses of 60 and 69 kDa. These two proteins were shown to be immunologically related to GroEL and DnaK, respectively. Increased heat resistance due to heat shock must be considered while designing thermal processes to assure the microbiological safety of thermally processed foods.     

Does single-dose cell resistance to the radio-mimetic zeocin correlate with a zeocin-induced adaptive response in <Emphasis Type="Italic">Chlamydomonas reinhardtii</Emphasis> strains?

This study aimed to test whether a correlation exists between single-dose resistance to zeocin and the ability to develop a zeocin-induced adaptive response (AR) in Chlamydomonas reinhardtii strains. Three genotypes were used: wild type (WT) strain 137C and two strains (H-3 and AK-9-9), which are highly resistant to radiation based on survival studies. Based on a micro-colony assay, the strains could be arranged according to their single-dose resistance to zeocin as follows: AK-9-9 > H-3 > 137C. However, zeocin induced a similar level of DSB in strains AK-9-9, H-3 and 137C. The radio- and zeocin-resistant strains AK-9-9 and H-3 showed higher DSB rejoining capacity than the WT strain 137C, suggesting that DSB rejoining can at least partly account for different cell survival. Both WT and radio-resistant strains develop zeocin-induced AR involving increased DSB rejoining. The radio- and zeocin-resistant strains AK-9-9 and H-3 again showed higher DSB rejoining capacity than the WT strain 137C. The higher resistance of strains H-3 and AK-9-9 did not abrogate their ability to adapt, albeit with a smaller magnitude as compared to the WT strain. The obtained results characterize new radio-resistant C. reinhardtii strains, which enrich the collection of resistant C. reinhardtii strains.     

Heat resistance of Listeria: strain differences and effects of meat type and curing salts

The heat resistances of 27 strains of Listeria monocytogenes and two strains of L. innocua were compared in broth heated at 57°C. No strain was exceptionally resistant. The heat resistance of a representative isolate of L. monocytogenes was compared in fresh and cured beef and chicken, and an equation was derived to predict the time necessary to achieve a '7D' inactivation at temperatures between 50 and 70°C.     

Some Properties of Heat-Resistant and Heat-Sensitive Strains of Clostridium perfringens I. Heat Resistance and Toxigenicity

Heat resistance at 100 C (D-values), sporulating ratios, toxigenicity for mice, and lecithinase activity (as micrograms per milliliter of enzyme, ascertained by the lecithovitellin reaction) were determined for four strains of Clostridium perfringens. A definite inverse relationship between thermal resistance and toxigenicity was found. The D-values ranged from 17.6 for the most heat-resistant strain to 0.3 for the strain possessing the least heat resistance, with corresponding lecithinase activities from 25 to 133 mug/ml of enzyme. The sporulating ratios did not differ greatly between the strains. The heat stability of the toxin was greater at 100 C than at 75 C. There was a noticeable difference between the heat stabilities of the toxin in the culture fluids of the heat-sensitive and heat-resistant strains at pH 7.0 when the toxic filtrates were held at 100 C. At a holding temperature of 75 C, a similar but lesser difference was observed at pH 5.5. Heat resistance and lecithinase activity did not change when a substrain of the least heat-resistant parent strain was obtained through heat selection by a single transfer, or when the most heat-resistant strain was transferred serially 12 times.     

Inhibition of Listeria monocytogenes by Lactobacillus bavaricus MN in beef systems at refrigeration temperatures.

The ability of Lactobacillus bavaricus, a meat isolate, to inhibit the growth of three Listeria monocytogenes strains was examined in three beef systems: beef cubes, beef cubes in gravy, and beef cubes in gravy containing glucose. The beef was minimally heat treated, inoculated with L. bavaricus at 10(5) or 10(3) CFU/g and L. monocytogenes at 10(2) CFU/g, vacuum sealed, and stored at 4 or 10 degrees C. The meat samples were monitored for microbial growth, pH, and bacteriocin production. The pathogen was inhibited by L. bavaricus MN. At 4 degrees C, L. monocytogenes was inhibited or killed depending on the initial inoculum level of L. bavaricus. At 10 degrees C, at least a 10-fold reduction of the pathogen occurred, except in the beef without gravy. This system showed a transient inhibition of the pathogen during the first week of storage followed by growth to control levels by the end of the incubation period. Bacteriocin was detected in the samples, and inhibition could not be attributed to acidification. Low refrigeration temperatures significantly (P < or = 0.05) enhanced L. monocytogenes inhibition. Moreover, the addition of glucose-containing gravy and the higher inoculum level of L. bavaricus were significantly (P < or = 0.05) more effective in reducing L. monocytogenes populations in most of the systems studied.     

Prevalence and distribution of Arcobacter species in various sources in Turkey and molecular analysis of isolated strains by ERIC-PCR

AIMS: To determine the prevalence of Arcobacter in various food, animal and water sources in Turkey and to subtype the isolated strains using enterobacterial repetitive intergenic consensus (ERIC)-PCR. METHODS AND RESULTS: A total of 806 samples consisting of chicken (100) and turkey meat (100); minced beef (27); rectal swabs from cattle (173), sheep (68) and dogs (62); cloacal swabs of broilers (100) and layers (100); gall bladders of cattle (50) and drinking water samples (26) were examined. A previously described membrane filtration method was used for the isolation. Isolates were identified at species level using multiplex-PCR and discriminated by ERIC-PCR for subtyping. Ninety-eight (12.1%) of the samples examined were found positive for arcobacters. Arcobacter spp. were isolated from 68%, 4%, 6.9%, 8% and 37% of chicken and turkey meats, rectal swabs and gall bladders of cattle and minced beef, respectively. No arcobacters were obtained from the rectal swabs of sheep and dogs, cloacal swabs of broilers and layers, and water samples examined. In total, 99 Arcobacter isolates were obtained. Of these isolates, 92 were identified as Arcobacter butzleri, five were Arcobacter skirrowii and two were Arcobacter cryaerophilus. Thirteen distinct DNA profiles among A. butzleri isolates were obtained by the ERIC-PCR. Of these profiles, eight were from chicken carcass, three from cattle rectal swab and two from minced beef meat isolates. Some of the isolates originated from different sources gave the same DNA profiles. All isolates of A. skirrowii and A. cryaerophilus gave different DNA profiles. CONCLUSIONS: Poultry carcasses, minced beef meat, rectal swabs and gall bladders of cattle were found to be positive for Arcobacter spp. A. butzleri was the predominant species isolated. In addition, large heterogeneity among the Arcobacter isolates was determined. SIGNIFICANCE AND IMPACT OF THE STUDY: Contamination of the poultry carcasses and minced beef meat, rectal and gall bladder samples of cattle with arcobacters poses a risk for both human and animal infections. Detection of several different Arcobacter strains may suggest multiple sources for contamination and infection.     

Antibiotic resistance among Listeria, including Listeria monocytogenes, in retail foods

AIMS: In the past eight to 10 years, reports of antibiotic resistance in food-borne isolates in many countries have increased, and this work examined the susceptibility of 1001 food isolates of Listeria species. METHODS AND RESULTS: Susceptibility/resistance to eight antibiotics was determined using the Bauer-Kirby disc diffusion assay, and 10.9% of the isolates examined displayed resistance to one or more antibiotics. Resistance to one or more antibiotics was exhibited in 0.6% of Listeria monocytogenes isolates compared with 19.5% of Listeria innocua isolates. Resistance was not observed in Listeria seeligeri or Listeria welshimeri. Resistance to tetracycline (6.7%) and penicillin (3.7%) was the most frequently observed, and while resistance to one antibiotic was most common (9.1%), isolates resistant to two or more antibiotics (1.8%) were also observed. CONCLUSION: While resistance to the antibiotics most commonly used to treat human listeriosis was not observed in L. monocytogenes, the presence of such resistance in other Listeria species raises the possibility of future acquisition of resistance by L. monocytogenes. SIGNIFICANCE AND IMPACT OF THE STUDY: The higher level of resistance in L. innocua compared with L. monocytogenes suggests that a species-related ability to acquire resistance to antibiotics exists.     

Optimization of enrichment and plating procedures for the recovery of Escherichia coli O111 and O26 from minced beef

AIM: Optimization of enrichment media and selective agars for the detection of Escherichia coli O26 and O111 from minced beef. METHODS AND RESULTS: This study compared a number of different enrichment conditions and plating media for the recovery of E. coli O26 and E. coli O111 from minced beef. The optimum enrichment conditions for E. coli O26 was observed in beef samples enriched at 41.5 degrees C in tryptone soya broth supplemented with cefixime (50 microg l(-1)), vancomycin (40 mg l(-1)) and potassium tellurite (2.5 mg l(-1)). Similar enrichment conditions were optimal for E. coli O111 with the omission of potassium tellurite. The optimum agar for recovery of E. coli O26 and giving the most effective suppression of contaminants was MacConkey agar [lactose replaced by rhamnose (20 g l(-1))] and supplemented with cefixime (50 microg ml(-1)) and potassium tellurite (2.5 mg l(-1)). Optimum recovery of E. coli O111 was on chromocult agar, supplemented with cefixime (50 microg ml(-1)), cefsulodin (5 mg l(-1)) and vancomycin (8 mg l(-1)). Minced beef samples were inoculated with a number of strains of E. coli O26 (n=9) and O111 (n=8), and the developed enrichment and plating methods, used in combination with immunomagnetic separation, were shown to be an effective method for the recovery of all strains. CONCLUSIONS: Routine cultural methods for the recovery of E. coli O26 and O111 from minced beef are described. SIGNIFICANCE AND IMPACT OF THE STUDY: The optimized enrichment and plating procedure described for the recovery of E. coli O111 and O26 from meat can be used to extend research on these emerging pathogens in beef.     

The incidence and level of Listeria monocytogenes contamination of food sources at primary production and initial processing

Listeria monocytogenes was isolated in low numbers from a variety of environmental samples associated with the primary production of food, including vegetation, faeces and meat. The organism was rarely detected on growing grass and vegetables prior to processing. The excretion of L. monocytogenes by farm animals was linked to their diet, with animals fed entirely on hay or manufactured diets not excreting detectable levels of Listeria (i.e. absence in 25 g). However, animals fed on silage, which is frequently contaminated with L. monocytogenes , commonly excreted the organism. Transport of live animals over long distances (> 100 km) significantly increased the level of excretion of Listeria , but the contamination of carcasses of sheep and cattle was not high. Pigs and poultry faeces were free of Listeria prior to slaughter and pig carcasses were not found to have Listeria present. Frozen and chilled chicken did show detectable levels reflecting the greater potential for contamination during poultry processing. Samples of minced beef were tested and 21 of 23 samples were positive for L. monocytogenes , demonstrating that processing significantly increases the level of contamination compared to whole carcasses. Multilocus enzyme electrophoresis of a representative selection of the isolates showed that there was a wide range of electrophoretic types present in the primary production environment, relatively few of which have been linked to cases of human listeriosis. However, these types do arise on farms and occasional contamination of food raw material by potentially virulent strains may be sufficient to allow adaptable strains to become established in the processing environment and thus be responsible for more widespread contamination of the food available to the consumer.     

Detection and recovery rates achieved using direct plate and enrichment/immunomagnetic separation methods for Escherichia coli O157:H7 in minced beef and on bovine hide

AIMS: To assess the detection and recovery rates achieved with commonly used cultural methods for the enumeration and recovery of Escherichia coli O157:H7 from minced beef and bovine hide. METHODS AND RESULTS: Minced beef and bovine hide were inoculated with varying concentrations (log(10) 1.58-2.58 CFU g(-1) and log(10) 2.42-4.49 CFU 100 cm(2) respectively) of E. coli O157:H7 and recovered using a direct plate method or an enrichment/immunomagnetic separation (IMS) method and then plated onto SMAC or SMAC-CT in both cases. The direct plate method detected the pathogen consistently from minced beef samples with an average recovery of 69.2-91.2%. From faecal material on the bovine hide the recovery of the pathogen ranged from 1.80 to 64.5% with fresh faeces depending on the inocula while from dried faeces on hide the results ranged from no recovery at all to 25.1%. Enrichment/IMS recovered E. coli O157:H7 at all inocula levels tested in minced beef while the pathogen was only detected consistently at an average inocula level of log(10) 2.73 CFU 100 cm(2) from fresh faeces and log(10) 4.49 CFU 100 cm(2) from dried faeces on bovine hide. CONCLUSIONS: The direct count enumeration method for E. coli O157:H7 underestimated the numbers of pathogens present. The enrichment/IMS procedure consistently detected the pathogen from minced beef but did not always detect E. coli O157:H7 from faeces on bovine hide. SIGNIFICANCE AND IMPACT OF THE STUDY: Overall this study highlights that any microbial data, used in either predictive microbiology or risk assessment, must take account of the sensitivity and associated performance of the methods employed, in order to make an accurate reflection of the true microbiology of the examined sample.