不同pH调节剂对产琥珀酸放线杆菌NJ113发酵产丁二酸的影响

在3L发酵罐中分别采用不同的碱性物质作为pH调节剂,考察其对产琥珀酸放线杆菌Actinobacillus succinogenes NJ113厌氧发酵制备丁二酸的影响。结果表明:Ca2+、NH4+调节剂对菌体生长代谢有较大阻碍作用,丁二酸产量较低;采用含Na+调节剂,在发酵中后期菌体出现絮凝现象严重,且产丁二酸能力骤降;采用含Mg2+调节剂,整个发酵过程菌体代谢旺盛,发酵效果较佳。根据各碱性物质的调节能力以及对菌体生长代谢的影响,选择NaOH、Mg(OH)2和Na2CO3、Mg(OH)2分别作为混合碱组分调节pH,并对两组混合碱中各物质的质量比例进行优化。结果表明,以NaOH、Mg(OH)2混合,两者质量比为1:1时,发酵效果最好,丁二酸质量浓度高达到69.8g/L,质量收率74.5%。该种混合碱配比可有效替代碱式MgCO3调节pH,既达到高产丁二酸的目的,又可降低生物制备丁二酸的成本。     

Production of succinate by a <Emphasis Type="Italic">pfl</Emphasis>B <Emphasis Type="Italic">ldh</Emphasis>A double mutant of <Emphasis Type="Italic">Escherichia coli</Emphasis> overexpressing malate dehydrogenase

The gene encoding malate dehydrogenase (MDH) was overexpressed in a pflB ldhA double mutant of Escherichia coli, NZN111, for succinic acid production. With MDH overexpression, NZN111/pTrc99A-mdh restored the ability to metabolize glucose anaerobically and 0.55 g/L of succinic acid was produced from 3 g/L of glucose in shake flask culture. When supplied with 10 g/L of sodium bicarbonate (NaHCO₃), the succinic acid yield of NZN111/pTrc99A-mdh reached 1.14 mol/mol glucose. Supply of NaHCO₃ also improved succinic acid production by the control strain, NZN111/pTrc99A. Measurement of key enzymes activities revealed that phosphoenolpyruvate (PEP) carboxykinase and PEP carboxylase in addition to MDH played important roles. Two-stage culture of NZN111/pTrc99A-mdh was carried out in a 5-L bioreactor and 12.2 g/L of succinic acid were produced from 15.6 g/L of glucose. Fed-batch culture was also performed, and the succinic acid concentration reached 31.9 g/L with a yield of 1.19 mol/mol glucose.     

A complete industrial system for economical succinic acid production by Actinobacillus succinogenes

An industrial fermentation system using lignocellulosic hydrolysate, waste yeast hydrolysate, and mixed alkali to achieve high-yield, economical succinic acid production by Actinobacillus succinogenes was developed. Lignocellulosic hydrolysate and waste yeast hydrolysate were used efficiently as carbon sources and nitrogen source instead of the expensive glucose and yeast extract. Moreover, as a novel method for regulating pH mixed alkalis (Mg(OH)₂ and NaOH) were first used to replace the expensive MgCO₃ for succinic acid production. Using the three aforementioned substitutions, the total fermentation cost decreased by 55.9%, and 56.4 g/L succinic acid with yield of 0.73 g/g was obtained, which are almost the same production level as fermentation with glucose, yeast extract and MgCO₃. Therefore, the cheap carbon and nitrogen sources, as well as the mixed alkaline neutralize could be efficiently used instead of expensive composition for industrial succinic acid production.     

Engineering of unconventional yeast Yarrowia lipolytica for efficient succinic acid production from glycerol at low pH

Yarrowia lipolytica is considered as a potential candidate for succinic acid production because of its innate ability to accumulate citric acid cycle intermediates and its tolerance to acidic pH. Previously, a succinate-production strain was obtained through the deletion of succinate dehydrogenase subunit encoding gene Ylsdh5. However, the accumulation of by-product acetate limited further improvement of succinate production. Meanwhile, additional pH adjustment procedure increased the downstream cost in industrial application. In this study, we identified for the first time that acetic acid overflow is caused by CoA-transfer reaction from acetyl-CoA to succinate in mitochondria rather than pyruvate decarboxylation reaction in SDH negative Y. lipolytica. The deletion of CoA-transferase gene Ylach eliminated acetic acid formation and improved succinic acid production and the cell growth. We then analyzed the effect of overexpressing the key enzymes of oxidative TCA, reductive carboxylation and glyoxylate bypass on succinic acid yield and by-products formation. The best strain with phosphoenolpyruvate carboxykinase (ScPCK) from Saccharomyces cerevisiae and endogenous succinyl-CoA synthase beta subunit (YlSCS2) overexpression improved succinic acid titer by 4.3-fold. In fed-batch fermentation, this strain produced 110.7 g/L succinic acid with a yield of 0.53 g/g glycerol without pH control. This is the highest succinic acid titer achieved at low pH by yeast reported worldwide, to date, using defined media. This study not only revealed the mechanism of acetic acid overflow in SDH negative Y. lipolytica, but it also reported the development of an efficient succinic acid production strain with great industrial prospects.     

Inhibition of succinic acid production in metabolically engineered Escherichia coli by neutralizing agent,organic acids,and osmolarity

The economical viability of biochemical succinic acid production is a result of many processing parameters including final succinic acid concentration, recovery of succinate, and the volumetric productivity. Maintaining volumetric productivities >2.5 g L^?1 h^?1 is important if production of succinic acid from renewable resources should be competitive. In this work, the effects of organic acids, osmolarity, and neutralizing agent (NH₄OH, KOH, NaOH, K₂CO₃, and Na₂CO₃) on the fermentative succinic acid production by Escherichia coli AFP184 were investigated. The highest concentration of succinic acid, 77 g L^?1, was obtained with Na₂CO₃. In general, irrespective of the base used, succinic acid productivity per viable cell was significantly reduced as the concentration of the produced acid increased. Increased osmolarity resulting from base addition during succinate production only marginally affected the productivity per viable cell. Addition of the osmoprotectant glycine betaine to cultures resulted in an increased aerobic growth rate and anaerobic glucose consumption rate, but decreased succinic acid yield. When using NH₄OH productivity completely ceased at a succinic acid concentration of ～40 g L^?1. Volumetric productivities remained at 2.5 g L^?1 h^?1 for up to 10 h longer when K‐ or Na‐bases where used instead of NH₄OH. The decrease in cellular succinic acid productivity observed during the anaerobic phase was found to be due to increased organic acid concentrations rather than medium osmolarity. © 2009 American Institute of Chemical Engineers Biotechnol. Prog., 2009     

Effects of neutralizing agents on lactic acid production by Rhizopus oryzae using sweet potato starch

A neutralizing agent is usually employed to counteract the pH reduction during lactic acid fermentation by Rhizopus oryzae. Calcium carbonate (CaCO₃) is used as such a pH controlling agent. The low solubility of CaCO₃ in the fermentation broth could however lead to low efficiency in pH control and cause problems in the subsequent purification process. Therefore, an alternative agent in place of CaCO₃ was examined in this study. The effect of four different neutralizing agents, including CaCO₃, sodium hydroxide (NaOH), ammoniacal solution and sodium bicarbonate (NaHCO₃) on lactic acid production and the morphology of the pellets were investigated. Results indicated that CaCO₃ was still the preferred choice, because of the pellet morphology and the highest lactic acid concentration (43.3 g/L) obtained in the batch using 60 g/L of sweet potato starch as feedstock. It is noteworthy that the lactic acid purification is relatively easier when using NaHCO₃ instead of CaCO₃, due to the higher solubility of sodium lactate than calcium lactate. Therefore, even the batch with CaCO₃ had a slightly higher productivity (1.23 g/L/h) than the batch with NaHCO₃ (1.14 g/L/h), NaHCO₃ might be the first choice for process designers whenever recovery is vital.     

Development of succinic acid production from corncob hydrolysate by <Emphasis Type="Italic">Actinobacillus succinogenes</Emphasis>

Succinic acid is one of the most important platform chemicals since it has great potential in industrial applications. In this study, corncob hydrolysate was used for succinic acid production. After diluted acid treatment, xylose was released from hemicellulose as the predominant monosaccharide in the hydrolysate, whereas glucose was released very little and most was retained as cellulose in the raw material. Without any detoxification, corncob hydrolysate was used directly as the carbon source in the fermentation. Actinobacillus succinogenes could utilize the sugars in the hydrolysate to produce succinic acid efficiently. Through medium optimization, yeast extract was selected as the nitrogen source and MgCO₃ was used to control pH. A total of 23.64 g/l of succinic acid was produced with a yield of 0.58 g/g based on consumed sugar, indicating that the waste corncob residue can be used to produce value-added chemicals practically.     

Succinic acid production with metabolically engineered <Emphasis Type="Italic">E. coli</Emphasis> recovered from two-stage fermentation

Escherichia coli AFP111 cells recovered from spent two-stage fermentation broth were investigated for additional production of succinic acid under anaerobic conditions. Recovered cells produced succinic acid in an aqueous environment with no nutrient supplementation except for glucose and MgCO₃. In addition, initial glucose concentration and cell density had a significant influence on succinic acid mass yield and productivity. Although the final concentration of succinic acid from recovered cells was lower than from two-stage fermentation, an average succinic acid mass yield of 0.85 g/g was achieved with an average productivity of 1.81 g/l h after three rounds of recycling, which was comparable to two-stage fermentation. These results suggested that recovered cells might be reused for the efficient production of succinic acid.     

Effects of culture redox potential on succinic acid production by Corynebacterium crenatum under anaerobic conditions

During mixed-acid fermentation by Corynebacterium crenatum under anaerobic conditions, two moles of NADH are required to synthesize 1 mol of succinic acid. In this work, four controlled culture redox potentials and different carbon sources with different oxidation states were used to investigate the possibility of enhancing the succinic acid production by increasing the availability of NADH. When the culture redox potential was ?300 mV, the yield of succinic acid was 0.31 g/g, representing a 72% increase compared with the yield when the culture redox potential was ?40 mV. Meanwhile, the molar ratio of succinic acid/lactic acid increased from 0.27 to 0.48. When 0.1% neutral red was added to the acid production medium, the yield of succinic acid was 0.25 g/g, and the molar ratio of succinic acid/lactic acid was 0.38. Both values were higher than those obtained from glucose only (0.19 g/g, 0.26) or gluconate (0.05 g/g, 0.18). A higher NADH/NAD⁺ ratio and increased enzymatic activity could be achieved to enhance the succinic acid production by manipulating the culture to a more reductive environment.     

An efficient succinic acid production process in a metabolically engineered <Emphasis Type="Italic">Corynebacterium glutamicum</Emphasis> strain

A Corynebacterium glutamicum strain (ΔldhA-pCRA717) that overexpresses the pyc gene encoding pyruvate carboxylase while simultaneously exhibiting a disrupted ldhA gene encoding l-lactate dehydrogenase was investigated in detail for succinic acid production. Succinic acid was shown to be efficiently produced at high-cell density under oxygen deprivation with intermittent addition of sodium bicarbonate and glucose. Succinic acid concentration reached 1.24 M (146 g l⁻¹) within 46 h. The yields of succinic acid and acetic acid from glucose were 1.40 mol mol⁻¹ (0.92 g g⁻¹) and 0.29 mol mol⁻¹ (0.10 g g⁻¹), respectively. The succinic acid production rate and yield depended on medium bicarbonate concentration rather than glucose concentration. Consumption of bicarbonate accompanied with succinic acid production implied that added bicarbonate was used for succinic acid synthesis.     

Succinic Acid Production with Actinobacillus succinogenes ZT-130 in the Presence of Succinic Acid

Glucose fermentation with Actinobacillus succinogenes was carried out at different initial concentrations of succinic acid (SA₀) to determine its effect on growth and on the production of succinic acid itself. The specific rates of biomass production, succinic, formic and acetic acids decreased with SA₀ (0–40 g/l). The partially dissociated form of succinic acid had a higher effect on cell growth and production of succinic acid as compared to the non-dissociated forms of the acids, a fact that has not been reported until now. Cell growth fitted the Jerusalimski model, and the Aiba–Shoda model was suitable for quantification of the inhibition for the production of succinic acid. The growth inhibition constants K _is and K _ip and their summatory were consistent with the experimental values obtained, i.e., 22 g/l for the produced acids and 38 g/l for total acids that were the limits at which the biomass formation ceased.     

Effects of redox potential control on succinic acid production by engineered Escherichia coli under anaerobic conditions

The effects of oxido-reduction potential (ORP) control on succinic acid production have been investigated in Escherichia coli LL016. In LL016, two CO₂ fixation pathways were achieved and NAD⁺ supply was enhanced by co-expression of heterologous pyruvate carboxylase (PYC) and nicotinic acid phosphoribosyltransferase (NAPRTase). During anaerobic fermentation, cell growth and metabolite distribution were changed with redox potential levels in the range of −200 to −400 mV. From the results, the ORP level of −400 mV was preferable, which resulted in the high succinic acid concentration (28.6 g/L) and high succinic acid productivity (0.33 g/L/h). Meanwhile, the yield of succinic acid at the ORP level of −400 mV was 39% higher than that at the ORP level of −200 mV. In addition, a higher NADH/NAD⁺ ratio and increased enzyme activities were also achieved by regulating the culture to a more reductive environment, which further enhanced the succinic acid production.     

Adaptive evolution improves acid tolerance and succinic acid production in Actinobacillus succinogenes

Fermentation at low pH is an efficient way to improve the competitiveness of biological succinic acid-producing process. Actinobacillus succinogenes shows good performance of succinic acid production under anaerobic conditions, but its succinic acid production capability at the low-pH is inefficient due to the poor acid resistance. Herein, a mutant A. succinogenes BC-4 with improved cell growth and succinic acid production under weak acid conditions was obtained by adaptive evolution. The specific growth rate and succinic acid production of BC-4 reached 0.13 g/L/h and 20.77 g/L, which were increased by 3.25- and 2.95- fold, respectively compared with the parent strain under anaerobic condition at pH 5.8. The activities of specific enzymes with ATP generation were significantly enhanced under weak acidic conditions, resulting in 1.28-fold increase in the maximum ATP level. Membrane fatty acid composition analysis demonstrated that the ratio of saturated to unsaturated fatty acids was decreased from 1.62 to 1.44 in mutant BC-4, leading to improved intracellular pH homeostasis. Furthermore, the change from long-chain to median-chain fatty acid might lower the permeability of H⁺ into cytoplasm for survival under acid stress. These results indicated that A. succinogenes BC-4 is a promising candidate for succinic acid production under weak acid condition.     

Continuous <Emphasis Type="SmallCaps">d</Emphasis>-lactic acid production by a novelthermotolerant <Emphasis Type="Italic">Lactobacillus delbrueckii</Emphasis> subsp. <Emphasis Type="Italic">lactis</Emphasis> QU 41

We isolated and characterized a d-lactic acid-producing lactic acid bacterium (d-LAB), identified as Lactobacillus delbrueckii subsp. lactis QU 41. When compared to Lactobacillus coryniformis subsp. torquens JCM 1166 ^T and L. delbrueckii subsp. lactis JCM 1248 ^T, which are also known as d-LAB, the QU 41 strain exhibited a high thermotolerance and produced d-lactic acid at temperatures of 50 °C and higher. In order to optimize the culture conditions of the QU 41 strain, we examined the effects of pH control, temperature, neutralizing reagent, and initial glucose concentration on d-lactic acid production in batch cultures. It was found that the optimal production of 20.1 g/l d-lactic acid was acquired with high optical purity (>99.9% of d-lactic acid) in a pH 6.0-controlled batch culture, by adding ammonium hydroxide as a neutralizing reagent, at 43 °C in MRS medium containing 20 g/l glucose. As a result of product inhibition and low cell density, continuous cultures were investigated using a microfiltration membrane module to recycle flow-through cells in order to improve d-lactic acid productivity. At a dilution rate of 0.87 h⁻¹, the high cell density continuous culture exhibited the highest d-lactic acid productivity of 18.0 g/l/h with a high yield (ca. 1.0 g/g consumed glucose) and a low residual glucose (<0.1 g/l) in comparison with systems published to date.     

Homogeneous solid dispersion (HSD) system for rapid and stable production of succinic acid from lignocellulosic hydrolysate

Continuous bio-production of succinic acid was reported in homogeneous solid dispersion (HSD) system utilizing porous coconut shell activated carbon (CSAC) as immobilization carrier. The aim of the present work was to implement the HSD system to increase the area of cell immobilization and the rate of succinic-acid production from the lignocellulosic medium. The ratio of the two enzymes (cellulase-to-hemicellulase) was initially optimized to break down the lignocellulose into its free monomers, wherein the best ratio was determined as 4:1. Succinic-acid production was evaluated in the HSD system by varying the substrate loading and dilution rate. The results showed that high productivities of succinic acid were obtained when 60 g/L glucose was fed over a dilution rates ranging from 0.03 to 0.4/h. The titer of succinic acid decreased gradually with higher dilution rate, whereas the residual substrate concentration increased with it. Critical dilution rate was determined to be 0.4/h at which the best productivity of succinic acid of 6.58 g/L h and its yield of 0.66 g/g were achieved using oil palm fronds (OPF) hydrolysate. This work lends evidence to the use of CSAC and lignocellulosic hydrolysate to further exploit the potential economies of scale.

     

Enhancement of succinic acid production by osmotic-tolerant mutant strain of Actinobacillus succinogenes

Fermentation and succinic acid production by Actinobacillus succinogenes YZ0819 was inhibited by high NaCl. To enhance the resistance of this strain to osmotic stress, an NaCl-tolerant mutant strain of A. succinogenes (CH050) was screened and selected through a continuous culture using survival in 0.7 M NaCl as the selection criterion. Using Na₂CO₃ as the pH regulator and glucose as the carbon source in batch fermentation, the isolated osmo-resistant stain, A. succinogenes CH050, produced up to 66 g/l succinic acid with a yield of 73.37% (w/w). The concentration of succinic acid and mass yield were increased by 37.5 and 4.37%, respectively, compared to the parent strain. The dry cell weight reached 10.1 g/l, which is 37% higher than that of the parent strain. The high tolerance of A. succinogenes CH050 to osmotic stress increased improved the succinic acid production from batch fermentation.     

Substrate and product inhibition kinetics in succinic acid production by Actinobacillus succinogenes

The inhibition of substrate and products on the growth of Actinobacillus succinogenes in fermentation using glucose as the major carbon source was studied. A. succinogenes tolerated up to 143 g/L glucose and cell growth was completely inhibited with glucose concentration over 158 g/L. Significant decrease in succinic acid yield and prolonged lag phase were observed with glucose concentration above 100 g/L. Among the end-products investigated, formate was found to have the most inhibitory effect on succinic acid fermentation. The critical concentrations of acetate, ethanol, formate, pyruvate and succinate were 46, 42, 16, 74, 104 g/L, respectively. A growth kinetic model considering both substrate and product inhibition is proposed, which adequately simulates batch fermentation kinetics using both semi-defined and wheat-derived media. The model accurately describes the inhibitory kinetics caused by both externally added chemicals and the same chemicals produced during fermentation. This paper provides key insights into the improvement of succinic acid production and the modelling of inhibition kinetics.     

An engineering Escherichia coli mutant with high succinic acid production in the defined medium obtained by the atmospheric and room temperature plasma

Escherichia coli BA002, the ldhA and pflB deletion strain, cannot utilize glucose in nutrient-rich or minimal media anaerobically. Co-expression of heterologous pyruvate carboxylase and nicotinic acid phosphoribosyltransferase in BA002 resulted in a significant increase in cell mass and succinic acid production. Nevertheless, the resultant strain, BA016, still could not grow in a defined medium without tryptone and yeast extract. To solve the problem, a novel atmospheric and room temperature plasma mutation method was employed to generate mutants which can grow in the defined medium. A mutant designated as LL016 was observed to be the best strain that regained the capacity of cell growth and glucose utilization in a defined medium anaerobically. After 120 h of fermentation in the defined medium, 35.0 g/L of glucose was consumed to generate 25.2 g/L of succinic acid. Furthermore, with the highest glucose consumption rate in the dual-phase fermentation, the yield of succinic acid in LL016 reached 0.87 g/g, which was higher than that observed in other strains. From an industrial standpoint, the defined medium is much cheaper than LB medium, which shows a great potential usage for the economical production of succinic acid by LL016.     

Production of xylanase under solid-state fermentation by <Emphasis Type="Italic">Aspergillus tubingensis</Emphasis> JP-1 and its application

The production of extracellular xylanase by a locally isolated strain of Aspergillus tubingensis JP-1 was studied under solid-state fermentation. Among the various agro residues used wheat straw was found to be the best for high yield of xylanase with poor cellulase production. The influence of various parameters such as initial pH, moisture, moistening agents, nitrogen sources, additives, surfactants and pretreatment of substrates were investigated. The production of the xylanase reached a peak in 8 days using untreated wheat straw with modified MS medium, pH 6.0 at 1:5 moisture level at 30 °C. Under optimized conditions yield as high as 6,887 ± 16 U/g of untreated wheat straw was achieved. Crude xylanase was used for enzymatic saccharification of agro-residues like wheat straw, rice bran, wheat bran, sugarcane bagasse and industrial paper pulp. Dilute alkali (1 N NaOH) and acid (1 N H₂SO₄) pretreatment were found to be beneficial for the efficient enzymatic hydrolysis of wheat straw. Dilute alkali and acid-pretreated wheat straw yielded 688 and 543 mg/g reducing sugar, respectively. Yield of 726 mg/g reducing sugar was obtained from paper pulp after 48 h of incubation.     

利用嗜盐菌Salinivibrio YS生产2,3-丁二醇和琥珀酸

以从新疆艾丁湖采集的土样中分离出的中度嗜盐菌Salinivibrio YS为研究对象,利用该菌在厌氧条件下生产2,3-丁二醇和琥珀酸,在单因素摇瓶实验基础上,确定影响产物积累的各因素及其相应条件,再利用正交试验确定这些参数的最佳水平,即温度33℃,起始pH为8.0,发酵过程pH为7.0,乙酸添加量为3 g/L,NaCl浓度为l0 g/L.利用优化条件进行3L体系的发酵放大实验,经过108 h的无氧发酵,2,3-丁二醇的产量可达35.05 g/L,而琥珀酸的含量则高达22.46 g/L,且其糖的总转化率高达约50％.首次利用嗜盐菌在厌氧条件下生产2,3-丁二醇和琥珀酸,拓展了嗜盐菌的应用,同时也为生产2,3-丁二醇和琥珀酸提供了新的思路.