Production of SCP and cellulase by Aspergillus terreus from bagasse substrate

The fermentation of 1.0% untreated bagasse under optimum cultural and nutritional conditions with Aspergillus terreus GN1 indicated that the maximum rate of protein and cellulase production could be obtained during three days of submerged fermentation. Even though 16.4% protein recovery, 0.55 units CMCase/mL, and 0.027 FPase units/mL were obtained on the seventh day, the rates of increase in protein recovery and cellulase production were slower than those obtained up to these days, which were 14.3% protein recovery, 0.45 units CMCase/mL, and 0.019 units FPase/mL. There was an initial lag in the utilization of cellulose up to two days due to the utilization of the water-soluble carbohydrate present in untreated bagasse. Cellulose utilization and water-soluble carbohydrate content during fermentation were correlated with protein recovery and enzyme production. The protein and cellulase production during three days fermentation with 1.0% untreated and treated bagasse were compared and the protein content of the total biomass was calculated and treated bagasse were compared and the protein content of the biomass was calculated into constituent protein contributed by the fungal mycelium and the under graded bagasse. The total biomass recovered with untreated and treated bagasse was 1020 and 820 mg/g bagasse substrate, respectively, and contained 14.3 and 20.6% crude protein, respectively. The contribution of fungal biomass and under graded bagasse was 309 and 711, and 373 and 447 mg/g untreated and treated bagasse substrates, respectively. In an 8-L-flask trial during three days of fermentation, the recovery of SCP and cellulase were 66 g and 32,400 units (Sigma) for treated bagasse and 82 g and 8200 units (Sigma) for untreated bagasse, respectively.     

Effect of cultural factors on cellulase activity and protein production by Aspergillus terreus

Protein production by Aspergillus terreus GN1 grown on 1.0% alkali-treated bagasse was studied under various cultural conditions. The maximum biomass protein content of 20.1% and protein recovery of 11.2% was obtained with an initial pH of 4.0, with 1/5 (v/v) inoculum in continuously shaken cultures grown for seven days. Protein content of the alkali-treated bagasse was 3.0%. Highest crude protein percent also corresponded with highest carboxymethyl cellulase and filter paper enzyme activities.     

Alkali treatment and fermentation of straw for animal feed

The feed value of annual ryegrass straw was improved by treatment with various concentrations of NaOH or NH₃ followed by fermentation of the treated straw with a mixed culture of Cellulomonas sp. and Alcaligenes faecalis. Laboratory feeding trials with voles showed that NaOH or NH₃ treatment considerably increased the feed efficiency of straw, but apparently gave a poorly palatable product. Fermentation tended to decrease the in vitro rumen digestibility (IVRD) of alkali-treated straw. The fermentations were carried out aerobically on a semisolid straw matrix having 11–86% moisture. Treatment by both NaOH and NH₃ increased the IVRD of straw. NH₃ also increased the nitrogen content in straw. The optimum condition for alkaline treatment of the straw was 4–6% NaOH for 1 hr or with 3% NH₃ for four weeks at room temperature. A minimum of 63% moisture was needed for significant fermentation of the straw. The combined effects of NaOH treatment and fermentation more than doubled crude protein, doubled crude fat, and increased IVRD by 75%. The NH₃ plus fermentation treatment tripled crude protein, doubled crude fat, and increased IVRD by 60%. Acetic acid was the main volatile fatty acid in the fermented straw.     

Production of lovastatin by a wild strain of Aspergillus terreus

Of 68 Aspergillus terreus, three produced lovastatin with equivalent or better yield than strain ATCC 20542 originally described for lovastatin production. Medium optimization experiments with the best isolate (TUB F-514) indicated that lactose, rapeseed meal and KNO3 were the best carbon, organic nitrogen and inorganic nitrogen sources, respectively. In shake-flasks with optimized medium containing 4 % (w/v) lactose, 400 g lovastatin/ml was produced, with a yield of 10 mg/g lactose. In solid substrate fermentation on extracted sweet sorghum pulp supplemented with cheese whey 1500 g lovastatin/g dry weight was produced with a yield of 37.5 mg/g lactose. © Rapid Science Ltd. 1998     

氮源对L-苏氨酸发酵的影响

以L-苏氨酸生产菌TRFC为供试菌株,研究了氮源对L-苏氨酸发酵的产量和糖酸转化率的影响。首先通过摇瓶实验确定发酵的最佳无机氮源和有机氮源分别为硫酸铵和酵母粉,进一步利用10L罐补料分批发酵确定硫酸铵和酵母粉的最佳用量,继续优化培养条件,采用发酵中后期流加硫酸铵和糖氨混合补料等措施,L-苏氨酸产量得到进一步的提高。在最优发酵条件下,通过10L罐补料分批发酵36h,产酸可达118.9g/L,糖酸转化率为47.6%。     

Joint effect of nitrogen sources and B vitamin supplementation of date juice on lactic acid production by Lactobacillus casei subsp. rhamnosus

The use of date juice as a substrate for lactic acid production was investigated. Various nitrogen sources were compared with yeast extract for efficient lactic acid production by Lactobacillus casei subsp. rhamnosus. Among different nitrogen sources added to date juice (yeast extract, ammonium sulfate, tryptic soy, urea, peptone, and casein hydrolysate), yeast extract was the most efficient. The effect of yeast extract could have been due to its B vitamin content. The addition of five B vitamins at less than 25 mg/l to date juice with any nitrogen source enhanced lactic acid production to some extent, except for date juice with yeast extract or urea or peptone. The most significant increase was obtained with ammonium sulfate. Half of the yeast extract content (10 g/l) in a supplemented date juice could be replaced by a mixture of B vitamins at less than 25 mg/l, and ammonium sulfate at 2.6 g/l with no significant decrease in lactic acid production.     

Batch Production of Protein from Ethane and Ethane-Methane Mixtures

A culture of Graphium grows upon natural gas and a mineral salt solution. Ethane is the preferred substrate but methane is co-utilized. A stirred-tank type fermentor was used to study batch growth. Maximum production rate of biomass was 80 mg/liter.hr, at pH 4, using simple synthetic supporting medium with ammonium sulfate as a nitrogen source. This rate was observed after 40 hr of fermentation. A doubling time of 3.7 hr was observed. The corresponding specific growth rate was 0.187 per hr. A magnetic drive fermentor was used to study the effect of continuous recycle of gases in a gas-tight system. The rate of oxygen utilization is approximately 2.1 times higher than for ethane. Oxygen must not be allowed to become limiting in recycle gases. The calculated efficiency of overall biomass synthesis averages 30%. Hyphal and unicellular tissue of Graphium contains 52% protein. It compares favorably with standard FAO protein in its content of amino acids.     

Enhanced cellulase production through random mutagenesis of Talaromyces pinophilus OPC4-1 and fermentation optimization

Reducing cellulase cost remains a major challenge for lignocellulose to fuel and chemical industries. In this study, mutants of a novel wild-type cellulolytic fungal strain Talaromyces pinophilus OPC4-1 were developed by consecutive UV irradiation, N-methyl-N`-nitro-N-nitrosoguanidine (NTG) and ethylmethane sulfonate (EMS) treatment. A potential mutant EMM was obtained and displayed enhanced cellulase production. Using Solka Floc cellulose as the substrate, through fed-batch fermentation, mutant strain T. pinophilus EMM generated crude enzymes with an FPase activity of 27.0 IU/mL and yield of 900 IU/g substrate. When corncob powder was used, strain EMM produced crude enzymes with an FPase activity of 7.3 IU/mL and yield of 243.3 IU/g substrate. In addition, EMM crude enzymes contained 29.2 and 16.3 IU/mL β-glucosidase on Solka Floc cellulose and corncob power, respectively. The crude enzymes consequently displayed strong biomass hydrolysis performance. For corncob hydrolysis, without supplement of any commercial enzymes, glucose yields of 591.7 and 548.6 mg/g biomass were obtained using enzymes produced from Solka Floc cellulose and corncob powder, respectively. It was 553.9 mg/g biomass using the commercial enzyme mixture of Celluclast 1.5 L and Novozyme 188. Strain T. pinophilus EMM was therefore a potential fungus for on-site enzyme production in biorefinery processes.     

Solid state fermentation of dried citrus peel byAspergillus niger

Summary Solid state fermentation of dried citrus peel was studied in a packed bed reactor withAspergillus niger QH-2. When no nitrogen source was added the growth was limited. When urea and/or ammonium sulphate were added in the proportion of 0.63 g N/100 g solid dry substrate a diauxie was observed and the final content of crude protein was higher than 10%. The results of a factorial design show that ammonium sulphate has a significant effect on the specific growth rate.     

Use of response surface methodology for selection of nutrient levels for culturing Paecilomyces variotii in eucalyptus hemicellulosic hydrolyzate

Eucalyptus hemicellulose was hydrolyzed by treating eucalyptus wood chips with sulfuric acid. The hydrolyzate was used as the substrate to produce single-cell protein by growing Paecilomyces variotii IOC-3764 for 72 or 96 h. The influences of rice bran, ammonium sulfate and fermentation time were verified by a 23 full-factorial central composite design. At the optimum process conditions, the cell concentration was 12.06 g/l, which was obtained when the microorganisms were cultivated for 89 h in a medium composed of 10 g/l rice bran, 2.0 g/l nitrogen and 1.1 g/l sodium phosphate. The mathematical model Y = 10.65 + 2.40X2 + 2.36X3 + 1.16X2X3 - 2.10X2(2) - 1.06X3(2) describes biomass production by P. variotii in eucalyptus hemicellulosic hydrolyzate with a determination coefficient of R2 = 0.9561, where X2 and X3 are ammonium sulfate and fermentation time, respectively.     

Growth of Chaetomium cellulolyticum in solid-state fermentation of sugar cane bagasse treated with water and alkali at several liquid/solid ratios

Sugar cane bagasse was water- or alkali-treated at three liquid/solid (L/S) ratios and its digestibility was measured as microbial protein production of Chaetomium cellulolyticum grown on solid-state fermentation columns. The treatments significantly enhanced fungus growth compared to non-treated bagasse, which was used as a control, although the composition of bagasse did not change greatly. Alkali-treated bagasse reached an average protein content of about 7.6% and the lower the L/S ratio, the higher the protein content. L/S ratio did not have an effect in water-treated bagasse. Protein content of water-treated bagasse was also high, approximately 80% of that one of alkali-treated bagasse. Both treatments look promising to enhance sugar cane bagasse potential as an animal feed.Currently at Universidad Francisco de Miranda. Coro, Venezuela.Currently at Ciclo Básico, Facultad de Ingeniería, Universidad del Zulia. Maracaibo, Venezuela.     

氮源对灵芝菌丝体液态深层发酵合成灵芝三萜的影响

以沪农灵芝1号为供试菌株,葡萄糖作为碳源,用硫酸铵、氯化铵、鱼粉蛋白胨、胰蛋白胨和酵母粉作为氮源,研究不同种类氮源对灵芝菌丝体液态深层发酵过程的影响。首先,确定了N-10酵母自溶粉作为发酵的氮源,降低了发酵的复杂性和不确定性;其次,考察N-10酵母自溶粉不同浓度对灵芝菌丝体发酵合成灵芝三萜过程中菌丝体的生物量、葡萄糖消耗、灵芝三萜产量等方面的影响,确定了N-10酵母自溶粉的适宜添加浓度。在此基础上,采用响应面中心组合设计,对4因素最佳水平范围进行研究,结果表明,葡萄糖、N-10酵母自溶粉、磷酸二氢钾和七水硫酸镁的含量分别为31.06g/L、2.76g/L、1.77g/L和1.99g/L时,灵芝三萜的理论产量为21.166g/kg干菌丝体,实际发酵产量提高到21.153g/kg干菌丝体。与原工艺相比,新工艺的灵芝三萜产量提高了6.22%。     

Ethanol from lignocellulosic materials by a simultaneous saccharification and fermentation process (SFS) with Kluyveromyces marxianus CECT 10875

Simultaneous saccharification and fermentation (SSF) process for ethanol production from various lignocellulosic woody (poplar and eucalyptus) and herbaceous (Sorghum sp. bagasse, wheat straw and Brassica carinata residue) materials has been assayed using the thermotolerant yeast strain Kluyveromyces marxianus CECT 10875. Biomass samples were previously treated in a steam explosion pilot plant to provide pretreated biomass with increased cellulose content relative to untreated materials and to enhance cellulase accessibility. SSF experiments were performed in laboratory conditions at 42 °C, 10% (w/v) substrate concentration and 15 FPU/g substrate of commercial cellulase. The results indicate that it is possible to reach SSF yields in the range of 50–72% of the maximum theoretical SSF yield, based on the glucose available in pretreated materials, in 72–82 h. Maximum ethanol contents from 16 to 19 g/l were obtained in fermentation media, depending on the material tested.     

Producton of single-cell protein from cellulose by Aspergillus terreus

Cellulose fermentation studies were conducted with a thermotolerant strain of Aspergillus terreus. Batch cultivation of A. terreus using purified or complex cellulose showed that 80-88% of the available cellulose was utilized in 30-36 h with an average doubling time of 7.5-8.3 h. The protein content in the biomass ranged from 23 to 38%. Semicontinuous cultivation studies, in which 90% of the biomass was withdrawn at the end of growth cycle, indicated that 84% of added cellulose was utilized with the biomass containing 32% crude protein. No loss in cellulose consumption, growth rate, or protein production occurred through two growth cycles. Continuous cultivation of A. terreus showed that 78-84% cellulose consumption occurred over growth temperatures ranging from 35 to 45 degrees C. Maximum specific growth rates (0.14 h(-1)) occurred at 40 and 45 degrees C with a minimum doubling time of 4.9 h.     

铁尾矿区油松根际溶磷泛菌D2的筛选鉴定及溶磷特性

从河北省迁安市马兰庄镇铁尾矿植被恢复区油松根际分离出2株溶磷细菌,经过平板初筛和摇瓶复筛得到1株溶磷能力较强的菌株D2.通过菌落形态、生理生化特性及16S rDNA序列分析,确定此菌株D2属于泛菌属.利用液体发酵试验测定不同碳源、氮源对菌株D2溶磷能力的影响,通过高效液相色谱测定D2在不同氮源条件下产生有机酸的种类和浓度.结果表明:菌株D2对磷酸三钙有较强的溶磷能力,培养液有效磷含量最高为392.13 mg·L^-1,菌株D2的溶磷能力在碳源为葡萄糖、氮源为硫酸铵时效果最好;高效液相色谱测定发现,不同氮源条件下,D2分泌有机酸的种类和浓度存在差异,以硫酸铵、氯化铵、硝酸钾、硝酸钠、硝酸铵为氮源,均产生草酸、甲酸、乙酸和柠檬酸,以硫酸铵、氯化铵、硝酸铵为氮源还产生苹果酸.相关性分析表明,乙酸含量与有效磷含量间呈显著正相关(r=0.886,P<0.05),表明溶磷泛菌D2分泌的乙酸对无机磷的溶解有明显的促进作用,这也很可能是该菌株的重要溶磷机制之一.     

氮源种类及溶氧水平对锁掷酵母产类胡萝卜素组分的影响

在锁掷酵母（Sporidioboluspararoseus）发酵产类胡萝卜紊的过程中,发酵产物中类胡萝卜紊种类繁多,而且性质相似,加大了不同色素分离纯化的难度。为定向积累不同种类的类胡萝卜素,以本实验室保藏锁挪酵母JD-2为出发菌,研究了氮源种类和浓度及溶氧对锁掷酵母产类胡萝卜素的影响,并在7L发酵罐中进行了补料分批发酵试验。发现培养基中同时添加有机氮源和无机氮源且溶氧控制较低（5％）时有利于β-胡萝卜素的大量积累,最佳有机氮源和无机氮源分别为玉米浆（20g／L）、硫酸铵（5g／L）。补料分批发酵时β-胡萝卜素产量达到31．28mg／L,红酵母烯12．38mg／L。培养基中只添加有机氮源且相对溶氧控制相对较高（30％）时有利于红酵母烯的大量积累,最佳有机氮源为酵母膏（20g／L）。补料分批发酵时红酵母烯产量达到38．96mg／L,8．胡萝卜素12．36mg／L。     

Solid state fermentation for L-glutamic acid production using Brevibacterium sp.

Summary Solid state fermentation system was used to cultivate Brevibacterium sp. on sugar cane bagasse impregnated with a medium containing glucose, urea, mineral salts and vitamins for producing L-glutamic acid. Maximum yields (80 mg glutamic acid per g dry bagasse with biomass and substrate - mg/gds) were obtained when bagasse of mixed particle size was moistened at 85–90 % mositure level with the medium containing 10 % glucose. This is the first report on the cultivation of Brevibacterium sp. in solid cultures for production of glutamic acid.     

双水相系统纯化山楂叶中黄酮类物质的研究

应用水、乙醇和硫酸铵三者形成双水相系统,并利用黄酮在乙醇中的溶解度要大于水中的溶解度,以脱除其中一些易溶于水和在高浓度乙醇中溶解度低的物质。尝试了不同盐、不同体积比的乙醇和水、以及盐加入量对分相的影响并测定了其在不同情况下的纯化效果。发现在硫酸铵中的分相情况最好,在加入量到2．5g时既可以达到分相完全。并测定：（1）在5mL乙醇＋5mL水＋5g硫酸铵＋0．15g粗体物（粗体物中黄酮的百分含量为25％）的双水相中,黄酮类物质的回收率为89．2％,而黄酮百分含量提升为47．6％;（2）在4mL乙醇＋5mL水＋5g硫酸铵＋0．15g粗体物（粗体物中黄酮的百分含量为25％）的双水相中,黄酮类物质的回收率为81．9％,而黄酮含量提升为50．9％。水、乙醇和硫酸铵三者形成双水相系统应用于山楂叶中黄酮类物质的纯化在文献中少有报道,而本文应用此法可以将黄酮含量从25％提升到将近47．6％,并且回收率为89％。     

Biotechnological production of lactic acid integrated with fishmeal wastewater treatment by <Emphasis Type="Italic">Rhizopus oryzae</Emphasis>

Fishmeal wastewater, a seafood processing waste, was utilized for production of lactic acid and fungal biomass by Rhizopus oryzae AS 3.254 with the addition of sugars. The 30 g/l exogenous glucose in fishmeal wastewater was superior to starch in view of productivities of lactic acid and fungal biomass, and COD reduction. Fishmeal wastewater can be a replacement for peptone which was the most suitable nitrogen source for lactic acid production among the tested organic or inorganic nitrogen sources. Exogenous NaCl (12 g/l) completely inhibited the production of lactic acid and fungal growth. In the medium of COD 5,000 mg/l fishmeal wastewater with the addition of 30 g/l glucose, the maximum productivity of lactic acid was 0.723 g/l h corresponding to productivity of fungal biomass 0.0925 g/l h, COD reduction 84.9% and total nitrogen removal 50.3% at a fermentation time of 30 h.     

Partial purification and characterization of extracellular cellulase from a strain ofTrichoderma viride isolated from forest soil

Partial purification of extracellular cellulase ofTrichoderma viride isolated from forest soil was done by ammonium sulfate precipitation of culture supernatant, centrifugation at higher speed, solubilization of protein in sodium acetate buffer and dialysis. The specific activity of cellulase in the culture supernatant, was 136 nkat/mg which was increased by 172% after the completion of final step (234 nkat/mg). The recovery of enzyme was 70%. The enzyme was characterized by demonstration of optimum activity at 55°C and pH 5.0 with 1% carboxymethyl cellulose as substrate.