益生菌Lactobacillus casei Zhang固态发酵条件的优化

利用一株分离自传统发酵酸马奶中的益生干酪乳杆菌（Lactobacillus casei Zhang）进行固态发酵（Solid State Fermentation,SSF）。以发酵物中的活菌数为主要指标,采用九因素四水平（L32（4^9））的正交试验优化固态发酵培养基,并在优化的培养基基础上研究不同的初始含水量及培养时间对Lactobacillus casei Zhang活菌数的影响。实验结果表明,在固态发酵培养基组成为4g豆粕、5g麸皮、0．6g乳清粉、0．3g葡萄糖、0．3g碳酸钙、0．02g硫酸铵、0．01g硫酸镁,初始含水量为55％的优化条件下,37℃发酵60h,发酵物中Lactobacillus casei Zhang活菌数可达到4．08×10^10CFU／g。     

Optimization of Exopolysaccharide Overproduction by Lactobacillus confusus in Solid State Fermentation under High Salinity Stress

It is believed that high concentrations of sodium chloride (NaCl) suppress the biosynthesis of exopolysaccharide (EPS) in lactic acid bacteria (LAB). Nevertheless, overproduction of EPSs due to high salinity stress in solid state fermentation performed on an agar surface was demonstrated in this study using a response surface methodology via a central composite design (CCD). Under optimized conditions with NaCl 4.97% and sucrose 136.5 g/L at 40.79 h of incubation, the EPS yield was 259% (86.36 g/L of EPS), higher than the maximum yield produced with the modified MRS medium containing only 120 g/L of sucrose without NaCl (33.4 g/L of EPS). Biosynthesis of EPS by Lactobacillus confusus TISTR 1498 was independent of biomass production. Our results indicated that high salinity stress can enhance EPS production in solid state fermentation.     

黑曲霉固态发酵生产单宁酶的条件优化

研究采用响应面法优化黑曲霉固态发酵生产单宁酶的培养条件。应用Plackett—Burman试验筛选出重要影响因子：五倍子粉含量、（NH4）2SO4浓度以及接种孢子量,最陡爬坡试验逼近最大响应区域。应用Box．Behnken响应面试验对重要影响因子进一步优化。得到最佳培养条件：每250mL三角瓶中装入1．0g五倍子粉、4．4g稻壳和0．5g麸皮、液固比（mL／g）2：1且营养盐溶液组成为（NH4）2s0421g/L、MgSO4·7H2O1g／L、NaCl1g／L,培养基pH自然,接种5．7×10^7个孢子后在30℃温度下培养4d。在此条件下,单宁酶产量从40U／g提高到114U／g,3次重复验证性试验平均值为115U／g,验证了模型的可靠性。     

樟绒枝霉(Malbranchea cinnamomea)固体发酵产木聚糖酶的发酵条件优化

[目的] 研究樟绒枝霉(Malbranchea cinnamomea) CAU521利用农业废弃物固体发酵产木聚糖酶的发酵条件.[方法]采用单因素试验法优化影响菌株产酶的各个条件,包括碳源种类、氮源种类、初始pH、初始水分含量、培养温度及发酵时间共6个因素.[结果]获得的最佳产酶条件为:稻草为发酵碳源、2％(W/W)的酵母提取物为氮源、初始pH 7.0、初始水分含量80％和发酵温度45℃.在此条件下发酵6d后木聚糖酶的酶活力达到13 120 U/g干基碳源.[结论]樟绒枝霉固体发酵产木聚糖酶的产酶水平高,生产成本低,具有潜在的工业化应用前景.     

Optimization of protease production from Bacillus halodurans under solid state fermentation using agrowastes

Marine microbes are potential source for novel metabolites. They are efficient in producing these metabolites utilizing agrowastes. Protease is one of the enzymes which find wide industrial applications. In the present study, protease producing bacteria was isolated from marine sediments and the organism was identified as Bacillus halodurans. The organism was subjected to protease production under solid state fermentation (SSF) using different agrowastes as substrates. Among the substrates used, wheat bran yielded maximum quantity of protease. The fermentation process was carried out under different cultural conditions to optimize the parameters influencing the enzyme production. The results of the stain removal studies by the enzyme revealed the increased efficiency of the microbial enzyme than the commercial detergent.     

Optimization studies on the production of cyclosporin A by solid state fermentation

Several parameters including (a) tray fermentation with and without perforation (b) thickness of solid substrate bed (c) type of inoculum (d) size of inoculum (e)?effect of relative humidity were studied for the optimum production of Cyclosporin A by solid state fermentation using Tolypocladium sp. The results indicate that while perforations in the trays had no significance on the yield of Cyc A, the other parameters had an influence on the production of Cyc A. The results indicate that under the optimized conditions, Cyc A can be produced in bulk quantities economically.     

Penicillin production by solid state fermentation

Summary Penicillin was produced by a non-sterile solid state fermentation (SSF) on bagasse impregnated with culture medium. The use of concentrated media greatly enhanced the antibiotic production in this system. It was observed that adequate initial moisture content (70%) of the impregnated solid medium results in higher production. A comparison between solid and liquid fermentation showed superior yield and productivity.     

高产纤维素酶的拟康宁木霉菌株8985固态发酵条件优化

木霉是重要的产纤维素酶真菌,在其可利用性评价筛选过程中,获得了一株在实验室条件下高产纤维素酶的拟康宁木霉菌株8985.采用响应面法对8985产纤维素酶的固态发酵条件进行了研究,以滤纸酶活为响应值,通过Plackett-Burman设计对11个因素进行了筛选,包括温度、湿度、发酵时间、K2HPO4、(NH4)2SO4、T...     

Economic production of Lysinibacillus sphaericus under solid state fermentation

A highly active mosquitocidal Lysinibacillus sphaericus namely Ls 9B24 was isolated from soil of Alexandria governorate in Egypt. It was more active than the standard strain, L. sphaericus 2362. The sporulation and toxin formation of both cultures grown on different leguminous seeds and by-products under solid state fermentation (SSF) were studied. Among the tested substrates, 6% cotton seed meal enhanced sporulation and the mosquitocidal activity of L. sphaericus 2362, while 6% fodder yeast enhanced sporulation and the mosquitocidal activity of Ls 9B24. The optimum SSF growth conditions for maximum mosquitocidal activity by both cultures were using coarse wheat bran as a carrier material, 50% initial moisture content, 4–64 × 10⁶ colony forming units (CFU)/g solid medium inoculum and 6 days’ incubation period at 30°C. Addition of 0.5% yeast extract enhanced toxicity about 2.2 and 1.8 fold for L. sphaericus 2362 and Ls 9B24, respectively.     

Optimization of cellulase production by a brown rot fungus Fomitopsis sp. RCK2010 under solid state fermentation

Culture conditions for enhanced cellulase production from a newly isolated brown rot fungus, Fomitopsis sp. RCK2010 were optimized under solid state fermentation. An initial pH of 5.5 and moisture ratio of 1:3.5 (solid:liquid) were found to be optimal for maximum enzyme production. Of the different carbon sources tested wheat bran gave the maximum production of CMCase (71.526 IU/g), FPase (3.268 IU/g), and β-glucosidase (50.696 IU/g). Among the nitrogen sources, urea caused maximum production of CMCase (81.832 IU/g), where as casein and soyabean meal gave the highest FPase (4.682 IU/g) and β-glucosidase (69.083 IU/g) production, respectively. Among amino acids tested glutamic acid gave the highest production for CMCase (84.127 IU/g); however 4-hydroxy-l-proline stimulated maximum FPase production (6.762 IU/g). Saccharification of pretreated rice straw and wheat straw by crude enzyme extract from Fomitopsis sp. RCK2010 resulted in release of 157.160 and 214.044 mg/g of reducing sugar, respectively.     

Optimization of fermentation conditions for production of exopolysaccharide by Bacillus polymyxa

Production of exopolysaccharide (EPS) from a strain of Bacillus polymyxa was studied. Sucrose and potassium nitrate were found to be efficient carbon and nitrogen sources, respectively, for the production of the EPS. EPS production increased with the increase of sucrose concentration, probably due to the facilitated carbon uptake. Optimal pH was 7–8, and a sufficient supply of oxygen was needed for the EPS production. It was noted that the EPS synthesis by this B. polymyxa was growth-associated, indicating that a sufficient supply of nutrients was required for a high production of the EPS. As high as 54?g/l of EPS with a yield of 63% (g EPS/g sucrose) was obtained in 48?h of fed-batch cultivation with intermittent feeding of sucrose and potassium nitrate.     

Development of high penicillin producing strains for solid state fermentation

Penicillin production with an industrial strain and 4 strains of P. chrysogenum, in solid state fermentation (SSF) and liquid submerged fermentation (LSF), was determined. Their ability to produce the antibiotic in SSF in relation to their capacity to do so in LSF was evaluated. this was done by calculating the ratio PS/PL (production in SSF/production in LSF), which was called relative production. Clones were isolated from each strain and evaluated in a similar way. The strains presented different relative productions (from 1.4 to 2.5). Within the clones, a much wider range of relative productions was observed (0.6 to 16.7). On the other hand, the highest-producing strains in LSF were also the highest producers in SSF. This indicates that the production potential of a strain is an important factor in its production level in SSF. Moreover, the highest penicillin producing ciones (9,500 to 10,500 microg of penicillin/g were generated from high-yielding strains (P2 and ASP-78). However, the higher-producing strains (in LSF) showed lower relative performance, suggesting that higher producing strains tend to express less efficiently their potential in SSF. In this study, several overproducing clones, particularly suited for SSF, were obtained by the procedures followed. Production increases of 500 to 600 %, in this culture system, were achieved.     

Optimization of the fermentation of whey by Lactobacillus casei

Optimization studies have been carried out for the production of L-lactic acid from the fermentation of whey by Lactobacillus casei. Two Statistical Designs, a full 2⁴ Factorial Design and a full 3² Factorial Design, have been used to determine the most suitable values of the operational variables for obtaining the maximum lactic acid production rate. The variables selected for study were temperature, pH, lactose concentration, and inoculum concentration. Among them only temperature and pH were found to affect the response significantly. A second-order polynomial empirical model relating both the response (lactic acid production rate) and the variables was formulated. The maximum acid production rate was found when the values of pH and temperature were 5.4 and 38°C, respectively. All conclusions are restricted to the experimental range studied.     

Production of Cyclosporin A by solid state fermentation

The production of Cyclosporin A using wheat bran as the solid substrate was attempted using Tolypocladium sp. and it was found that the yield was 10 times more than the yield obtained by submerged fermentation. Hydrolysing the wheat bran using dilute HCl was found to increase the yield. Different solvents were used for the optimization of extraction of Cyc A from the fermented bran.     

樟芝固态发酵产物抗氧化性分析

本文对樟芝谷物固态发酵产物抗氧化性能及活性成分进行了研究.在所选谷物中,樟芝青稞固态发酵产物的乙醇提取物总抗氧化性最好,较未发酵青稞提高了4.02倍.通过无水乙醇50℃水浴振荡提取80 min,其总抗氧化性达到了769.60 U/g.对其抗氧化性能分析发现,樟芝青稞固态发酵乙醇提取物为6 mg/L时,对DP P H自由基、羟基自由基以及超氧阴离子的去除率分别为91.9%、51.2%、61.3%,对铁离子的螯合能力为79.5%.相对于未发酵谷物,大米、小米、玉米以及青稞的樟芝发酵产物中总酚含量均有显著的提升,其中青稞乙醇提取和水提取物中总酚含量分别提高了2.36倍和4.23倍.通过HP LC分析可知,樟芝固态发酵产物含有丰富的活性化合物,包括马来酸衍生物(Antrodin)以及泛醌类衍生物(Antroquinonol),且各组分含量较为均衡;而樟芝液态发酵菌丝体乙醇提取物中主要活性成分为马来酸衍生物,不含有泛醌类化合物.     

Production of pectinases by Aspergillus niger in solid state fermentation at high initial glucose concentrations

Exopectinase (exo-p) and endopectinase (endo-p) production by Aspergillus niger CH4 in solid state culture was studied at initial glucose concentrations of 100, 250, 350 and 450 g/l. The highest activity of exo-p (35 U/g) was produced at 72 and 120 h in the medium containing 100 and 250 g glucose/l, respectively. The maximum endo-p activity (9 U/g) was produced at 72 h in the medium with 250 g glucose/l. The reduction in pectinase production at 350 and 450 g/l initial glucose concentration was due neither to repression of the synthesis of the enzyme nor to the glucose consumption rate of the strain but due to a drastic drop in pH of the medium.S. Solis-Pereyra, E. Favela-Torres, M. Gutiérrez-Rojas, G. Saucedo-Castañeda and G. Viniegra-González are with the Departamento de Biotecnologia, Universidad Autónoma Metropolitana, A.P. 55-535, C.P. 09340, México D.F., México; S. Roussos is with the Laboratoire de Biotechnologie, ORSTOM, B.P. 5045, 34032, Montpellier Cedex, France, and P. Gunasekaran is with the Department of Microbial Technology, School of Biological Sciences, Madurai Kamaraj University, Madurai, 625-021, India.     

Optimizing some factors affecting protease production under solid state fermentation

Production of extracellular alkaline protease by a locally isolated fungal species, Rhizopus oryzae, under solid state fermentation was optimized. The maximum enzyme activity under the optimum conditions of temperature (32?°C), relative humidity (90%–95%), spore count (～2?×?10⁵/g wheat bran), moisture content of solid substrate (140%) adjusted suitably with salt solution (M-9) of pH?5.5 was 341 unit/g wheat bran.     

Optimization of anticancer exopolysaccharide production from probiotic Lactobacillus acidophilus by response surface methodology

Colorectal cancer (CRC) is one of the leading causes of cancer-related deaths in the Western world. Recently, much attention has been focused on decreasing the risk of CRC by consuming probiotics. In the present study, exopolysaccharide (EPS) extracted from Lactobacillus acidophilus was found to inhibit the growth of CaCo2 colon cancer cell line in a dose-dependent manner. The experiment was performed in both normoxic and hypoxic conditions, and EPS was found to reduce the survival of CaCo2 cell line in both the conditions. Quantitative polymerase chain reaction (qPCR) studies demonstrated that EPS treatment upregulated the expression of peroxisome proliferator activator receptor-γ (PPAR-γ) in both normoxia and hypoxia conditions, whereas it upregulated the expression of erythropoietin (EPO) in the normoxic condition, but there was no significant expression under hypoxic conditions. Hence, the EPS production was optimized by Plackett–Burman design followed by central composite rotatory design. The optimized production of EPS at 24 hr was found to be 400 mg/L. During batch cultivation the production peaked at 21 hr, resulting in an EPS concentration of 597 mg/L.     

Optimization of solid state fermentation of sugar cane by aspergillus niger considering particles size effect

The protein enrichment of sugar cane by solid state fermentation employing Aspergillus niger was optimized in a packed bed column using a two Factor Central Composit Design α = 2, considering as independent factors the particles diameter corresponding to different times of grinding for a sample and the air flow rate. It was significative for the air flow rate (optimum 4.34 VKgM) and the particle diameter (optimum 0.136 cm). The average particle size distribution, shape factor, specific surface, volume-surface mean diameter, number of particles, real and apparent density and hollowness for the different times of grinding were determined, in order to characterize the samples.     

Optimization of mycophenolic acid production in solid state fermentation using response surface methodology

Mycophenolic acid (MPA) can be produced in solid state fermentation. An isolate of Penicillium brevi-compactum ATCC 16024 grown on moist wheat bran produced a titre of 425 mg per kg of wheat bran. Central composite rotatable design and response surface methodology were employed to derive a statistical model for media optimization towards production of mycophenolic acid. Five levels with a five factorial design were adopted. The correlation coefficient was 0.82, ensuring a satisfactory adjustment of the model to the experimental values. This statistical design was very effective in improving the titre of mycophenolic acid up to 3286 mg per kg of wheat bran. Received 24 July 1998/ Accepted in revised form 4 December 1998