丙酮酸高产菌株的选育及中试研究

对T.glabrata WSH-IP12进行EMS诱变,挑选以NH4Cl为唯一氮源的平板上透明圈较大的菌株,经初筛和复筛后,发现T.glabrata WSH-IP303生产丙酮酸的能力强且稳定。以NH4Cl为唯一氮源摇瓶培养48h,其丙酮酸产量（35．1g/L）比出发菌株（21．4g/L)提高了64％。采用该菌株在300L罐上进行了4批发酵试验,丙酮酸产量最高可达58．4g/L,对葡萄糖产率0．562g/g。     

添加TCA循环中间产物加速光滑球拟酵母积累丙酮酸

在维生素限制的条件下,研究了添加TCA循环中间产物对光滑球拟酵母多重维生素营养缺陷型菌株CCTCC M202019生长和积累丙酮酸的影响。该菌株能以TCA循环中间产物为唯一碳源进行生长,且在以葡萄糖、乙酸和TCA循环中间产物为复合碳源的平板上菌落数高于分别以葡萄糖和乙酸或TCA循环中间产物为唯一碳源时的菌落数。与其它TCA循环中间产物相比,草酰乙酸更能促进细胞的生长、提高丙酮酸产量和对葡萄糖的得率。草酰乙酸能够促进细胞生长,是因为T. glabrata CCTCC M202019菌株能够利用乙酸作为乙酰辅酶A供体。在含有100 g/L葡萄糖和6 g/L乙酸钠的培养基中再添加10 g/L草酰乙酸进行分批发酵实验,可使菌体浓度从11.8 g/L提高到 13.6 g/L,增长幅度为15%;丙酮酸对葡萄糖的得率(0.66 g/g)以及生产强度(1.19 g·L^{-1<、sup>·h-1<、sup>)分别高出6%和24%,使发酵结束时间提前8～12h。}     

琥珀酸发酵高产菌株的选育

以富马酸钠为唯一碳源的选择性平板,从牛的瘤胃中筛选出一株产琥珀酸的菌株Actinobacillus succinogenes CGMCC1593。以该菌株为出发菌株进行NTG诱变,挑选在含有50~100 mmol/L氟乙酸平板生长较快的菌落,经过初筛和复筛,发现SF-9菌株产琥珀酸能力强且积累的乙酸较少。以50 g/L的葡萄糖为碳源,在培养瓶厌氧发酵条件下其琥珀酸产量(35.09 g/L)比出发菌株(28.91 g/L)提高了21.4%,琥珀酸/乙酸比率(w/w)从3.3∶1提高到7.5∶1。用SF-9菌株在5 L发酵罐上进行分批发酵,发酵36 h时琥珀酸积累量达到40.51 g/L,对葡萄糖的转化率为0.81(w/w),琥珀酸/乙酸比率为9∶1,副产物乙酸量比出发菌株降低了约50%。     

维生素在丙酮酸过量合成中的重要作用

研究了烟酸、硫胺素、吡哆醇、生物素和核黄素对一株光滑球拟酵母(\%Torulopsis glabrata\%) WSH\|IP303以葡萄糖为碳源、以氯化铵为唯一氮源生产丙酮酸的影响。利用正交试验方法,确证了硫胺素是影响WSH\|IP303生产丙酮酸的最重要因素。在硫胺素浓度一定(0.01～0.015mg/L)的前提下,提高烟酸浓度有助于加快耗糖速度。当烟酸、硫胺素、吡哆醇、生物素和核黄素的浓度分别为8、0.015、0.4、0.04和01mg/L时,摇瓶发酵48h,丙酮酸产量和产率可分别达到52.4g/L和0525g/g。采用优化的维生素组合方式,进行2.5L罐分批发酵,在初糖浓度120g/L的条件下发酵57.5h,丙酮酸产量和产率分别达到69.4g/L和0593g/g,分别比摇瓶培养的最好结果提高了32.%和13%。     

一种基于途径分析提高丙酮酸产量的育种策略

为进一步提高光滑球拟酵母发酵生产丙酮酸的水平 ,在途径分析的基础上提出了一种组成型降低丙酮酸脱酸酶、但增强乙酰辅酶A合成酶活性的育种策略。通过亚硝基胍诱变 ,获得 1株乙酸需求型突变株CCTCCM2 0 2 0 19,在外加乙酸的培养基中表现出高于出发株 2 1%的丙酮酸生产能力和良好的遗传稳定性。检测突变株CCTCCM2 0 2 0 19中丙酮酸代谢相关酶的活性发现 :(1)丙酮酸脱羧酶活性降低了 4 0 % ;(2 )外加乙酸与否的条件下 ,乙酰辅酶A合成酶的活性分别提高了 10 3 5 %和 5 7 4 % ;(3)添加乙酸和突变对丙酮酸羧化酶、丙酮酸脱氢酶系、乙醇脱氢酶和乙醛脱氢酶的活性没有显著影响。在含有乙酸的培养基中突变株细胞干重比出发株高 2 1 7% ,可能是因为乙酰辅酶A合成酶活性的提高 ,补充了因丙酮酸脱羧酶活性降低而引起的胞质乙酰辅酶A短缺。在 7L罐中含有 6g L乙酸钠的培养基中发酵 6 2h ,丙酮酸产量达到 6 8 7g L ,对葡萄糖的产率为 0 6 5 1g g。     

敲除aceE基因对大肠杆菌生长和丙酮酸代谢的影响

大肠杆菌aceE基因是编码丙酮酸脱氢酶多酶复合体PdhR的关键酶之一。利用Red重组系统敲除大肠杆菌MG1655的aceE基因后,阻断了丙酮酸流向TCA循环,导致丙酮酸的累积,也使菌体生长受到影响,在培养基中补加5 g/L KAc后可以在一定程度上弥补菌株在生长上的缺陷。摇瓶发酵36 h,MG1655没有积累丙酮酸,MG1655ΔaceE∷cat菌株可以积累26.77 g/L丙酮酸,为利用大肠杆菌发酵生产丙酮酸奠定了基础。     

钝齿棒杆菌丙酮酸激酶的克隆表达及其对精氨酸合成的扰动影响

钝齿棒杆菌(Corynebacterium crenatum)SYPA 5-5是诱变选育的一株高产精氨酸菌株。丙酮酸激酶(pyruvate kinase)是EMP途径的限速酶,对胞内能量产生和代谢流调节方面都有重要作用。为提高葡萄糖消耗速率以缩短发酵周期,以钝齿棒杆菌基因组为模板,克隆得到pyk基因并将其在C.crenatum SYPA 5-5中成功表达,葡萄糖平均消耗速率为1.71 g/L/h较C.crenatum SYPA 5-5提高33.5%,精氨酸产量和最大产率分别为43.32 g/L和0.55 g/L/h较C.crenatum SYPA 5-5分别提高20%和19.5%。结果表明,加强表达丙酮酸激酶能增强EMP途径,提高精氨酸产量。     

营养条件对光滑球拟酵母积累α-酮戊二酸的影响

以光滑拟球酵母为研究模型,研究α-酮戊二酸的浓度情况。通过单因素实验得到α-酮戊二酸积累最佳浓度的各单因素条件为：葡萄糖浓度140g／L,NH4Cl浓度5g／L。在碳源（30g/L葡萄糖初始浓度）匮乏条件下加入丙酮酸30g／L,在此条件下丙酮酸转化为α－酮戊二酸的转化率最高达53．7％。以30g／L丙酮酸为唯一碳源时在7L发酵罐中光滑拟球酵母可生成浓度为10．7g/Lα-酮戊二酸,外源丙酮酸的转化率可达66．9％。这一结果表明,T．glabrata具有将丙酮酸转化为α-KG的能力。     

过程优化提高解脂亚洛酵母积累α-酮戊二酸

目前,应用解脂亚洛酵母发酵生产α-酮戊二酸由于产量和底物转化率低、生产周期长等问题,仍未大规模工业化生产。为了解决这些问题,以研究室诱变选育获得的1株高产α-酮戊二酸的解脂亚洛酵母Yarrowia lipolytica WSH-Z06 C3为出发菌株,考察了该菌株在50 L发酵罐中转速、碳酸钙浓度、溶氧以及补料方式(多节点补料、恒速补料)等因素对α-酮戊二酸积累的影响。结果表明,当转速为300 r/min时,α-酮戊二酸和丙酮酸的产量分别为32.4 g/L和19.66 g/L;碳酸钙质量浓度为20 g/L时,α-酮戊二酸的产量提高至38.55 g/L,丙酮酸降低至8.28 g/L;控制溶氧水平在50%时,α-酮戊二酸产量为42.39 g/L,此时丙酮酸为6.22 g/L。比较高初始甘油浓度和不同的补料发酵策略,发现恒速补料效果最好,发酵144 hα-酮戊二酸产量达到66.27 g/L,丙酮酸产量为20.82 g/L。通过上述发酵过程参数的优化,α-酮戊二酸的产量和底物的转化率比未优化前分别提高了67.3%和4.56%,为解脂亚洛酵母工业化生产α-酮戊二酸提供一定参考。     

乳糖诱导丙酮酸羧化酶基因在大肠杆菌中的表达及对丁二酸产量的影响

大肠杆菌DC1515是敲除葡萄糖磷酸转移酶(ptsG)、乳酸脱氢酶(ldhA)、丙酮酸甲酸裂解酶(pflA)基因的菌株,具有发酵生产丁二酸的潜力。为进一步提高菌株DC1515的丁二酸生产能力,将枯草芽孢杆菌丙酮酸羧化酶(pyc)基因转入其中。用乳糖代替IPTG诱导pyc表达,确定了最佳乳糖加入时间、乳糖浓度及诱导温度。在此基础上,考察了补加乳糖对丁二酸产量的影响。结果表明:由于ptsG基因缺失,当培养基中葡萄糖浓度达到15g/L时,乳糖诱导作用并不受葡萄糖抑制。优化诱导条件后,pyc过表达菌株的丁二酸产量达15.17g/L,为对照菌株的1.78倍。间歇补加乳糖2次至浓度为1g/L,丁二酸产量可进一步增至17.54g/L。研究结果为以葡萄糖为底物生产丁二酸的过程中乳糖诱导外源基因在大肠杆菌中的表达奠定了基础。乳糖诱导降低了成本,有利于实现丁二酸发酵生产的工业化。     

嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

嗜热子囊菌利用短链有机酸生产角质酶

以嗜热子囊菌(Thermobifida fusca WSH03-11)发酵生产角质酶为模型,研究微生物利用市政污泥厌氧酸化所产短链有机酸为碳源发酵生产高附加值产品的可能。发现：(1)以丁酸、丙酸和乙酸为碳源时,有机酸和氮元素浓度分别为8.0 g/L和1.5 g/L有利于角质酶的生产;而以乳酸为碳源时,最适有机酸和氮源浓度分别为3.0 g/L和1.0 g/L;(2)改变诱导物角质的浓度,以丁酸、丙酸、乙酸和乳酸为碳源,分别比优化前提高了31.0%、13.3%、43.8%和73.2%;(3)在四种有机酸中,T. fusca WSH03-11利用乙酸的速率最快,平均比消耗速率是丙酸的1.3倍,丁酸的2.0倍及乳酸的2.2倍;以丁酸为碳源时的酶活(52.4 U/mL)是乳酸的1.7倍、乙酸的2.5倍和丙酸的3.2倍;角质酶对乳酸的得率(12.70 u/mg)分别是丁酸的1.4倍、丙酸的3.0倍和乙酸的3.8倍;(4)以混合酸为碳源生产角质酶,T. fusca WSH03-11优先利用乙酸,而对丁酸的利用受到抑制。进一步研究发现,混合酸中0.5 g/L的乙酸将导致丁酸的消耗量降低66.7%。这是首次利用混合酸作碳源发酵生产角质酶的研究报道。这一研究结果进一步确证了利用市政污泥厌氧酸化所产有机酸为碳源发酵生产高附加值产品的可行性,为以廉价碳源生产角质酶奠定了良好的基础。     

Enhancement of pyruvate production by osmotic-tolerant mutant of Torulopsis glabrata

Pyruvate production by Torulopsis glabrata was used as a model to study the mechanism of product inhibition and the strategy for enhancing pyruvate production. It was found that the concentration of cell growth and pyruvate deceased with the increase of NaCl and sorbitol concentrations. To enhance the osmotic stress resistance of the strain, an NaCl-tolerant mutant RS23 was screened and selected through a pH-controlled continuous culture with 70 g/L NaCl as the selective criterion. Compared with the parent strain, mutant RS23 could grow well on the medium containing 70 g/L NaCl or 0.6 mol/L sorbitol. Pyruvate concentration by the mutant strain RS23 reached 94.3 g/L at 82 h (yield on glucose 0.635 g/g) in a 7-l fermentor with 150 g/L glucose as carbon source. Pyruvate concentration and yield of mutant RS23 were 41.1% and 11.1% higher than those of the parent strain, respectively. The strategy for enhancing pyruvate production by increasing osmotic stress resistance may provide an alternative approach to enhance organic acids production with yeast.     

Manipulating the pyruvate dehydrogenase bypass of a multi-vitamin auxotrophic yeast Torulopsis glabrata enhanced pyruvate production

AIMS: To investigate the relationship between the activity of pyruvate dehydrogenase (PDH) bypass and the production of pyruvate of a multi-vitamin auxotrophic yeast Torulopsis glabrata. METHODS AND RESULTS: Torulopsis glabrata CCTCC M202019, a multi-vitamin auxotrophic yeast that requires acetate for complete growth on glucose minimum medium, was selected after nitrosoguanidine mutagenesis of the parent strain T. glabrata WSH-IP303 screened in previous study [Li et al. (2001) Appl. Microbiol. Biotechnol. 55, 680-685]. Strain CCTCC M202019 produced 21% higher pyruvate than the parent strain and was genetically stable in flask cultures. The activities of the pyruvate metabolism-related enzymes in parent and mutant strains were measured. Compared with the parent strain, the activity of pyruvate decarboxylase (PDC) of the mutant strain CCTCC M202019 decreased by roughly 40%, while the activity of acetyl-CoA synthetase (ACS) of the mutant increased by 103.5 or 57.4%, respectively, in the presence or absence of acetate. Pyruvate production by the mutant strain CCTCC M202019 reached 68.7 g l(-1) at 62 h (yield on glucose of 0.651 g g(-1)) in a 7-l jar fermentor. CONCLUSIONS: The increased pyruvate yield in T. glabrata CCTCC M202019 was due to a balanced manipulation of the PDH bypass, where the shortage of cytoplasmic acetyl-CoA caused by the decreased activity of PDC was properly compensated by the increased activity of ACS. SIGNIFICANCE AND IMPACT OF THE STUDY: Manipulating the PDH bypass may provide an alternative approach to enhance the production of glycolysis-related metabolites.     

丙酮酸钠对E．coli CCTCCM208088发酵生产聚唾液酸的影响

研究了丙酮酸钠对E．coliCCTCCM208088发酵生产聚唾液酸的影响。首先在摇瓶水平上优化了丙酮酸钠的添加策略：发酵初始培养基中添加6g／L丙酮酸钠,聚唾液酸的产量达到最高水平3．47g／L,相比空白相比提高了73％,聚唾液酸产率（YP／（x．s））提高了125％。在30L发酵罐中,添加丙酮酸钠使聚唾液酸产量达到了6．6g／L,相对照提高了53．5％。通过有机酸分析,添加丙酮酸钠增强了菌体内三羧酸循环．可能导致胞内能荷水平的提高．从而促进了聚唾液酸的合成。     

丙酮酸发酵过程中光滑球拟酵母过程功能的强化

对不同葡萄糖浓度下光滑球拟酵母分批发酵生产丙酮酸的动力学模型分析发现, 葡萄糖浓度是影响光滑球拟酵母发酵生产丙酮酸过程功能的关键因素。在发酵初始阶段, 低浓度葡萄糖可维持较高的菌体比生长速率; 对数生长中前期, 葡萄糖快速进料使菌体浓度接近最大值, 并实现碳流从菌体生长转向丙酮酸积累; 对数生长后期葡萄糖浓度控制在33.4 g/L以维持高丙酮酸对葡萄糖产率系数 (0.71 g/g)。采用奇异控制的葡萄糖流加方式, 在7 L发酵罐上控制不同发酵阶段葡萄糖浓度处于最佳水平以强化光滑球拟酵母过程功能, 丙酮酸产量 (83.1 g/L)、产率 (0.621 g/g)、生产强度[1.00 g/(L·h)]与分批发酵对比, 分别提高了21.3%、21.6%和29.9%。     

Efficient pyruvate production by a multi-vitamin auxotroph of Torulopsis glabrata: key role and optimization of vitamin levels

A multi-vitamin auxotroph, Torulopsis glabrata strain WSH-IP303, which can use ammonium chloride as a sole nitrogen source for pyruvate production, was selected. To optimize pyruvate yield and productivity, a simple but useful, orthogonal design method, was used to investigate the relationship between thiamine, nicotinic acid, pyridoxine, biotin, and riboflavin. Thiamine was confirmed to be the most important factor affecting pyruvate production. When the concentration of thiamine was 0.01 mg/l or 0.015 mg/l, glucose consumption was improved by increasing the nicotinic acid concentration. When the concentrations of nicotinic acid, thiamine, pyridoxine, biotin, and riboflavin were 8.0, 0.015, 0.4, 0.04, and 0.1 mg/l, respectively, pyruvate concentration and yield reached 52 g/l and 0.52 g/g, respectively, in a 48-h flask culture. By employing a combination of the optimum vitamin concentrations, a batch culture was conducted in a 2.5-l fermentor with an initial glucose concentration of 112 g/l; and the pyruvate concentration reached 69 g/l after 56 h (yielding 0.62 g/g).