A CASE STUDY: OLIGONUCLEOTIDE PURIFICATION FROM GRAM TO HUNDRED GRAM SCALE

This article describes the purification and scale-up of ISIS 2302, a 20-mer phosphorothioate oligonucleotide by anion-exchange (AX) chromatography. The key operating parameters were optimized at gram scale and further scaled up to hundred gram. SOURCE 30Q, a high efficiency polymeric chromatographic media was used for both the small and large-scale work. High length-based purity and yield were maintained at scale-up. This purification is one of the largest demonstrations of AX purification of phosphorothioate oligonucleotide.     

Purification of a synthetic oligonucleotide by anion exchange chromatography: method optimisation and scale-up

A single-step chromatographic method for purification of a synthetic 20-mer oligonucleotide is described. Method optimisation was conducted at laboratory scale where 30 mg crude sample was purified per run with a yield of 17 mg pure oligonucleotide. The protocol was scaled-up in steps to achieve 5-, 58- and a final 230-fold scale-up. At the final scale, 7.0 g of crude material was purified with a yield of 4.1 g product. The purity of the oligonucleotide was in all scales higher than 97%. The cycle time was 110 min, which corresponds to a purification capacity of about 90 g crude oligonucleotide material per 24 h.     

Large-scale purification of oligonucleotides by extraction and precipitation with butanole

Today the synthesis of oligonucleotides is a well-established process. Using automatic synthesizers even kilogram quantities can be produced in a few hours. However, the purification of the final product is still time-consuming and needs a complex apparatus. In this article, a simple and fast purification method for the large-scale syntheses of oligonucleotides is described. According to the method of Sawadago and van Dyke ([1991] Nucleic Acids Res 19:674-675) for small-scale oligonucleotide purification, oligonucleotides in mumol to mmol amounts were purified by liquid-liquid extraction using butanole as the extraction liquid. Choosing appropriate ratios of extraction liquid to oligonucleotide solution, simultaneous purification and precipitation could be achieved. It was found that the yield of the purified oligonucleotide was mainly affected by the temperature. Yield decreased with increasing temperature. The use of this improved extraction procedure allows the purification of gram to kilogram quantities of oligonucleotides in less than a day with simple equipment and high yield.     

Sequence characterization of 5S ribosomal RNA from eight gram positive procaryotes

Summary The available comparative data on procaryotic 5S rRNA was extended through sequencing studies of eight gram positive procaryotes. Complete nucleotide sequences were presented for 5S rRNA fromBacillus subtilis, B. firmus, B.pasteurii, B.brevis, Lactobacillus brevis andStreptococcus faecalis. In addition, 5S rRNA oligonucleotide catalogs and partial sequence data were provided forB.cereus andSporosarcina ureae. These sequences and catalogs were discussed in terms of known features of procaryotic 5S rRNA architecture.     

Mechanism of gram variability in select bacteria.

Gram stains were performed on strains of Actinomyces bovis, Actinomyces viscosus, Arthrobacter globiformis, Bacillus brevis, Butyrivibrio fibrisolvens, Clostridium tetani, Clostridium thermosaccharolyticum, Corynebacterium parvum, Mycobacterium phlei, and Propionibacterium acnes, using a modified Gram regimen that allowed the staining process to be observed by electron microscopy (J. A. Davies, G. K. Anderson, T. J. Beveridge, and H. C. Clark, J. Bacteriol. 156:837-845, 1983). Furthermore, since a platinum salt replaced the iodine mordant of the Gram stain, energy-dispersive X-ray spectroscopy could evaluate the stain intensity and location by monitoring the platinum signal. These gram-variable bacteria could be split into two groups on the basis of their staining responses. In the Actinomyces-Arthrobacter-Corynebacterium-Mycobacterium-Propionibacterium group, few cells became gram negative until the exponential growth phase; by mid-exponential phase, 10 to 30% of the cells were gram negative. The cells that became gram negative were a select population of the culture, had initiated septum formation, and were more fragile to the stress of the Gram stain at the division site. As cultures aged to stationary phase, there was a relatively slight increase toward gram negativity (now 15 to 40%) due to the increased lysis of nondividing cells by means of lesions in the side walls; these cells maintained their rod shape but stained gram negative. Those in the Bacillus-Butyrivibrio-Clostridium group also became gram negative as cultures aged but by a separate set of events. These bacteria possessed more complex walls, since they were covered by an S layer. They stained gram positive during lag and the initial exponential growth phases, but as doubling times increased, the wall fabric underlying the S layer became noticeably thinner and diffuse, and the cells became more fragile to the Gram stain. By stationary phase, these cultures were virtually gram negative.     

High yielding one-pot enzyme-catalyzed synthesis of UDP-glucose in gram scales.

Uridine diphosphoglucose is an important cofactor of glucosylating enzymes. A simple and high yielding one-pot enzymatic synthesis of UDPG on a gram scale from glucose via hexokinase, phosphoglucomutase and UDPG pyrophosphorylase (UGPase) is described. Repetitive addition of substrate was used to avoid inhibition of UGPase. The approach allows recovery of active enzymes and their re-use. The synthesis of UDP-[4-(13)C]-glucose on a 0.5 g scale resulted in a final yield of 70% and a purity of >95% after chromatographic purification.     

Isolation of gram quantities of isoleucyl-tRNA synthetase from an overproducing strain of Escherichia coli and its use for purification of cognate tRNA

The ileS gene coding for isoleucyl-tRNA synthetase was cloned on a runaway-replication plasmid. From the cells harboring the plasmid, gram quantities of the synthetase were isolated using two column procedures. The synthetase was used for the purification of cognate tRNA. Isoleucine tRNAGAU of greater than 90% purity was easily isolated by taking advantage of a specific complex formation of the synthetase with cognate tRNA.     

Characterization of guanylate kinase from gram positive and gram negative microorganisms; preliminary results

Guanylate kinase is a member of the nucleoside monophosphate (NMP) kinase family, a family of enzymes that despite having a low primary structure identity share a similar fold, which consists of three structurally distinct regions termed the CORE, LID, and NMP-binding regions. Guanylate kinase (GMPK) is an essential enzyme for the biosynthesis of GTP and dGTP by catalyzing the phosphoryl transfer from ATP to (d)GMP resulting in ADP and (d)GDP. Despite the similar fold of the monomer there is an important difference between GMPKs from prokaryotes and eukaryotes: eukaryotes GMPK are monomers while prokaryotes GMPK are dimmers, tetramers or hexamers. For this reason bacterial GMPKs are possible targets for new antibacterial drugs. Finding new targets for antibacterial therapies is a prior subject in today's medical research. The purpose of this work was to characterize guanylate kinases from both gram positive and gram negative pathogenic bacteria. We started with GMPK from Enterococcus faecalis as gram positive microorganism and Pseudomonas aeruginosa as gram negative representative.     

Some properties and applications of Superose 6B

Applications of a new agarose-based medium for high-performance preparative gel filtration is described. The 30-micron bead size, high pore volume, and simple experimental technique to prepare highly efficient columns make Superose 6B very suitable for preparative purifications of protein mixtures in the molar mass range of 10(3) to 4 X 10(6). Sample load exceeds 100 mg/cm2, which indicates that gram quantities may be purified on K 50/60 columns. The scale-up procedure from analytical to preparative columns is demonstrated by the separation of serum samples and the industrial purification of an enzyme-antibody conjugate.     

Simultaneous fluorescent gram staining and activity assessment of activated sludge bacteria

Wastewater treatment is one of the most important commercial biotechnological processes, and yet the component bacterial populations and their associated metabolic activities are poorly understood. The novel fluorescent dye hexidium iodide allows assessment of Gram status by differential absorption through bacterial cell walls. Differentiation between gram-positive and gram-negative wastewater bacteria was achieved after flow cytometric analysis. This study shows that the relative proportions of gram-positive and gram-negative bacterial cells identified by traditional microscopy and hexidium iodide staining were not significantly different. Dual staining of cells for Gram status and activity proved effective in analyzing mixtures of cultured bacteria and wastewater populations. Levels of highly active organisms at two wastewater treatment plants, both gram positive and gram negative, ranged from 1.5% in activated sludge flocs to 16% in the activated sludge fluid. Gram-positive organisms comprised <5% of the total bacterial numbers but accounted for 19 and 55% of the highly active organisms within flocs at the two plants. Assessment of Gram status and activity within activated sludge samples over a 4-day period showed significant differences over time. This method provides a rapid, quantitative measure of Gram status linked with in situ activity within wastewater systems.     

中试规模纯化海洋芽孢杆菌源脂肽类化合物

本次研究旨在建立经济可行的海洋芽孢杆菌源脂肽类化合物的中试规模纯化工艺。对包括酸化沉淀、甲醇浸提、溶剂沉淀、盐析、萃取、硅胶柱层析和HZ806大孔树脂吸附工艺在内的可放大的成熟单元工艺进行反复试验,考察脂肽类化合物表面活性对单元工艺的影响。严格遵循以高收率为前提循序渐进逐步减少杂质的原则,组合上述单元工艺对目标产物进行提取和纯化,并最终获得高纯度脂肽样品。新工艺可从1 t海洋芽孢杆菌Bacillus marinus B-9987的发酵液中,以百克量级的规模制备87.51%–100%纯度的脂肽类化合物样品,收率81.73%。本研究首次实现了高纯度的海洋芽孢杆菌源脂肽类化合物的百克量级制备;允许发酵生产阶段使用天然培养基,缓解了脂肽中游发酵生产和下游大规模纯化之间的矛盾;且各单元工艺规避了脂肽类化合物水溶液的乳化起泡和不经济的大体积水溶液蒸发浓缩。新工艺实用可行,经济合理。     

Solid-phase synthesis of somatostatin and glucagon-selective analogs in gram quantities

Somatostatin (SS) and two glucagon selective analogs [D -Cys^l4]-SS and [D -Trp⁸, D -Cys¹⁴]-SS have been synthesized in gram quantities by the solid-phase procedure. A general modification of Monahan and Gilon's procedure for esterification of the first protected amino acid onto the chloromethylated resin as well as a general protocol for solid-phase peptide synthesis on Beckman 990 automatic synthesizer are described. A new general procedure for disulfide formation, which involves the adaptation of the “high-dilution” principle to the ferricyanide oxidation and the optimization of the sequence of purification steps as applied to somatostatin and its analogs, yields highly purified peptides (≥ 199% pure) as checked by reverse-phase high-pressure liquid chromatography—which is shown to be a highly sensitive, resolutive, and quantitative analytical tool for evaluation of the homogeneity of peptides.     

Synthesis, 3D-structure and stability analyses of NRPa-308, a new promising anti-cancer agent

We report herein the synthesis of a newly described anti-cancer agent, NRPa-308. This compound antagonizes Neuropilin-1, a multi-partners transmembrane receptor overexpressed in numerous tumors, and thereby validated as promising target in oncology. The preparation of NRPa-308 proved challenging because of the orthogonality of the amide and sulphonamide bonds formation. Nevertheless, we succeeded a gram scale synthesis, according to an expeditious three steps route, without intermediate purification. This latter point is of utmost interest in reducing the ecologic impact and production costs in the perspective of further scale-up processes. The purity of NRPa-308 has been attested by means of conventional structural analyses and its crystallisation allowed a structural assessment by X-Ray diffraction. We also reported the remarkable chemical stability of this molecule in acidic, neutral and basic aqueous media. Eventually, we observed for the first time the accumulation of NRPa-308 in two types of human breast cancer cells MDA-MB231 and BT549.     

Escherichia coli exhibiting gram positivity after cetyl pyridinium chloride treatment

Summary Treatment with a solution of the detergent cetyl pyridinium chloride develops gram positivity in E. coli as is evident from the increased retention of crystal violet by the bacteria. Since cetyl pyridinium chloride has been found to remove larger quantity of lipid from E. coli than from the normal gram positive bacteria S. aureus, it is reasonable to think that lipid content in a bacteria may have an important role in determining the gram character of it. Gram negative bacteria generally contain more lipid than the gram positive ones.     

Enzymatic synthesis of UDP-galactose on a gram scale

Uridine 5′-diphospho-- -galactose (UDP-Gal) was synthesized on a gram scale from uridine 5′-diphospho-- -glucose and - -galactose 1-phosphate using the enzymes galactose-1-phosphate uridyltransferase (EC 2.7.7.12), phosphoglucomutase (EC 2.7.5.1) and glucose-6-phosphate dehydrogenase (EC 1.1.1.27). The synthesis was performed in a repetitive batch mode in which the enzymes, some of which are expensive, were used in 16 subsequent batches without any loss of enzyme activity. The space time yield of the synthesis was 7.1 g/l d. The overall yield of the synthesis amounted to 40% and 1.1 gram of pure UDP-Gal was obtained.     

Milligram to gram scale purification and characterization of dextransucrase from Leuconostoc mesenteroides NRRL B-512F

A sequence of dextranase treatment, DEAE-cellulose chromatography, affinity chromatography on Sephadex G-200, and chromatography on DEAE-Trisacryl M has been optimized to give a dextransucrase preparation with low carbohydrate content (1-100 micrograms/mg protein) and high specific activity (90-170 U/mg protein) relative to previous procedures, in 30-50% yield. Levansucrase was absent after DEAE-cellulose chromatography, and dextranase was undetectable after Sephadex G-200 chromatography. The method could be scaled up to produce gram quantities of purified enzyme. The purified dextransucrase had a pH optimum of 5.0-5.5, a Km of 12-16 mM, and produced the same lightly branched dextran as before purification. The purified enzyme was not activated by added dextran, but the rate of dextran synthesis increased abruptly during dextran synthesis at a dextran concentration of approximately 0.1 mg/mL. The enzyme had two major forms, of molecular weight 177,000 and 158,000. The 177,000 form predominated in fresh preparations of culture supernatant or purified enzyme, whereas the amount of the 158,000 form increased at the expense of the 177,000 form during storage of either preparation.     

Resolution of protected silaproline for a gram scale preparation

Silaproline is an analogue of proline, which exhibits similar conformational properties. Moreover, the presence of dimethylsilyl group confers to silaproline a higher lipophilicity as well as an improved resistance to biodegradation. This report describes the comparison of two routes to obtain Fmoc-(L) Sip-OH on the gram scale using chiral HPLC resolution.     

Selection of endosulfan-tolerant gram cell line

Three alternate exposures of Cicer arietinum (gram) root callus to lethal (1 ppm) endosulfan-containing selective medium (SM) and non-selective medium (NSM) yielded a tolerant cell line (1 ESR). Such an induced resistance was retained during subculture on NSM for 15 generations tested so far. Higher soluble proteins and peroxidase activity were found in 1 ESR compared to mother tissue.     

The impact of foliar boron sprays on reproductive biology and seed quality of black gram

An experiment was conducted under glass house condition to study the effect of foliar application of boron (B) on reproductive biology and seed quality of black gram (Vigna mungo). Black gram (V. mungo L. var. DPU-88-31) was grown under controlled sand culture condition at deficient and sufficient B levels. After 32 days of sowing B deficient plants were sprayed with three concentrations of B (0.05%, 0.1% and 0.2% borax) at three different stages of reproductive development, i.e. prior to flowering, initiation of bud formation and after bud formation. Deficient B supply decreased the anther and pollen size, pollen tube growth, pollen viability as well as stigmatic receptivity which were increased by foliar B application. Foliar spray at all the three concentrations and at all stages increased the yield parameters like number of pods, pod size and number of seeds formed per plant. Foliar B application also improved the seed yield and seed quality in terms of storage seed proteins (albumin, globulin, glutenin and prolamin) and carbohydrates (sugars and starch) in black gram. The foliar application of B in appropriate doses (particularly 0.1%) after bud formation made quantitative and qualitative improvement in seed yield of black gram by supplementing additional/critical B requirements for reproductive development.     

An improved method for tissue long-chain acyl-CoA extraction and analysis

We report an extensively modified method for the extraction, solid-phase purification, and HPLC analysis of long-chain acyl-CoAs from tissues. Tissue samples were homogenized in a glass homogenizer in KH2PO4 buffer (100 mM, pH 4.9) and again after the addition of 2-propanol. Acyl-CoAs were then extracted from the homogenate with acetonitrile (ACN). The acyl-CoAs in the extract were bound to an oligonucleotide purification column and eluted using 2-propanol. This eluent was concentrated and then loaded onto a C-18 column and eluted using a binary gradient system in which solvent A was KH2PO4 (75 mM, pH 4.9) and solvent B was ACN containing 600 mM glacial acetic acid. Initial flow rate was 0.5 or 0.25 ml/min depending upon the tissue used. The HPLC eluent was monitoring at 260 nm. Our modifications increased the recovery of the extraction procedure to 70-80%, depending upon tissue, with high reproducibility and significantly improved separation of the most common unsaturated and saturated acyl-CoAs. We also report, for the first time, the mass (nanomoles per gram wet weight) of the most common polyunsaturated acyl-CoAs in rat heart, kidney, and muscle tissues. The modifications and high recovery permit the use of tissue samples of less than 100 mg, making this method useful for the analysis of small tissue amounts associated with mice.