Versatile signal peptide of Flavobacterium‐originated organophosphorus hydrolase for efficient periplasmic translocation of heterologous proteins in Escherichia coli

Organophosphorus hydrolase (OPH) from Flavobacterium species is a membrane‐associated homodimeric metalloenzyme and has its own signal peptide in its N‐terminus. We found that OPH was translocated into the periplasmic space when the original signal peptide‐containing OPH was expressed in recombinant Escherichia coli even though its translocation efficiency was relatively low. To investigate the usability of this OPH signal peptide for periplasmic expression of heterologous proteins in an E. coli system, we employed green fluorescent protein (GFP) as a cytoplasmic folding reporter and alkaline phosphatase (ALP) as a periplasmic folding reporter. We found that the OPH signal peptide was able to use both twin‐arginine translocation (Tat) and general secretory (Sec) machineries by switching translocation pathways according to the nature of target proteins in E. coli. These results might be due to the lack of Sec‐avoidance sequence in the c‐region and a moderate hydrophobicity of the OPH signal peptide. Interestingly, the OPH signal peptide considerably enhanced the translocation efficiencies for both GFP and ALP compared with commonly used TorA and PelB signal peptides that have Tat and Sec pathway dependences, respectively. Therefore, this OPH signal peptide could be successfully used in recombinant E. coli system for efficient periplasmic production of target protein regardless of the subcellular localization where functional folding of the protein occurs. © 2016 American Institute of Chemical Engineers Biotechnol. Prog., 32:848–854, 2016     

Specific inhibition of the translocation of a subset of Escherichia coli TAT substrates by the TorA signal peptide

The SufI protein and the trimethylamine N-oxide reductase (TorA) are the two best-characterized prototype proteins exported by the Escherichia coli TAT system. Whereas SufI does not contain cofactors, TorA is a molybdo-enzyme and the acquisition of the molybdo-cofactor is a prerequisite for its translocation. The overproduction of each protein leads to the saturation of its translocation, but it was unknown if the overproduction of one substrate could saturate the TAT apparatus and block thus the translocation of other TAT substrates. Here, we showed that the overproduction of SufI saturated only its own translocation, but had no effect of the translocation of TorA and other TAT substrate analyzed. To dissect the saturation mechanism of TorA translocation, we shortened by about one-third of the TorA protein and removed nine consensus molybdo-cofactor-binding ligands. Like SufI, the truncated TorA (TorA502) did not contain cofactor and would not compete with the full length TorA for molybdo-cofactor acquisition. The overproduction of TorA502 completely inhibited the export of the full length TorA and dimethyl sulfoxide (DMSO) reductase, but had no effect on the translocation of SufI, nitrate-induced formate dehydrogenase and hydrogenase-2. Importantly, deletion of the twin-arginine signal peptide of TorA502 abolished the inhibitory effect. Moreover, the overproduction of the TorA signal peptide fused to the green fluorescence protein (GFP) was sufficient to block the TorA translocation. These results demonstrated that the twin-arginine signal peptide of the TorA protein specifically inhibits the translocation of a subset of TAT substrates, probably at the step of their targeting to the TAT apparatus.     

信号肽对浸麻类芽孢杆菌α-环糊精葡萄糖基转移酶在大肠杆菌中胞外表达的影响

为了筛选得到利于浸麻类芽孢杆菌Paenibacillus macerans α-环糊精葡萄糖基转移酶(α-CGT酶)分泌表达的信号肽,提高α-CGT酶的分泌表达量,本研究考察了大肠杆菌中外源蛋白分泌表达常用的OmpA、PelB、OmpT和Endoxylanase四个信号肽对重组α-CGT酶在大肠杆菌中胞外表达的影响.在...     

Functional analysis of the twin-arginine translocation pathway in Sodalis glossinidius, a bacterial symbiont of the tsetse fly

This study demonstrates a functional twin-arginine (Tat) translocation pathway present in the tsetse fly symbiont Sodalis glossinidius and its potential to export active heterologous proteins to the periplasm. Functionality was demonstrated using green fluorescent protein (GFP) fused to the Tat signal peptide of Escherichia coli trimethylamine N-oxide reductase (TorA).     

Competition between Sec- and TAT-dependent protein translocation in Escherichia coli.

Recently, a new protein translocation pathway, the twin-arginine translocation (TAT) pathway, has been identified in both bacteria and chloroplasts. To study the possible competition between the TAT- and the well-characterized Sec translocon-dependent pathways in Escherichia coli, we have fused the TorA TAT-targeting signal peptide to the Sec-dependent inner membrane protein leader peptidase (Lep). We find that the soluble, periplasmic P2 domain from Lep is re-routed by the TorA signal peptide into the TAT pathway. In contrast, the full-length TorA-Lep fusion protein is not re-routed into the TAT pathway, suggesting that Sec-targeting signals in Lep can override TAT-targeting information in the TorA signal peptide. We also show that the TorA signal peptide can be converted into a Sec-targeting signal peptide by increasing the hydrophobicity of its h-region. Thus, beyond the twin-arginine motif, the overall hydrophobicity of the signal peptide plays an important role in TAT versus Sec targeting. This is consistent with statistical data showing that TAT-targeting signal peptides in general have less hydrophobic h-regions than Sec-targeting signal peptides.     

Coexpression of TorD enhances the transport of GFP via the TAT pathway

Twin-arginine translocation (Tat) pathway is capable of secreting fully folded proteins into the periplasm of Gram-negative bacteria and may thus be an ideal system for the expression of active cofactor-containing proteins. However, the applications of Tat system for such purpose have been plagued by low translocation efficiencies. In this study, we demonstrate that the coexpression of a soluble chaperone, TorD, in conjunction with the TorA signal peptide, the translocation efficiency of GFP can be enhanced by more than three-fold. The enhancement in translocation efficiency is believed to be a result of reduced proteolysis mediated by the binding of TorD toward the TorA signal peptide. We believe this approach can be further exploited for the expression and secretion of other heterologous proteins as well as traditional Tat substrate proteins.     

Genetic analysis of pathway specificity during posttranslational protein translocation across the Escherichia coli plasma membrane

In Escherichia coli, the SecB/SecA branch of the Sec pathway and the twin-arginine translocation (Tat) pathway represent two alternative possibilities for posttranslational translocation of proteins across the cytoplasmic membrane. Maintenance of pathway specificity was analyzed using a model precursor consisting of the mature part of the SecB-dependent maltose-binding protein (MalE) fused to the signal peptide of the Tat-dependent TorA protein. The TorA signal peptide selectively and specifically directed MalE into the Tat pathway. The characterization of a spontaneous TorA signal peptide mutant (TorA*), in which the two arginine residues in the c-region had been replaced by one leucine residue, showed that the TorA*-MalE mutant precursor had acquired the ability for efficiently using the SecB/SecA pathway. Despite the lack of the "Sec avoidance signal," the mutant precursor was still capable of using the Tat pathway, provided that the kinetically favored Sec pathway was blocked. These results show that the h-region of the TorA signal peptide is, in principle, sufficiently hydrophobic for Sec-dependent protein translocation, and therefore, the positively charged amino acid residues in the c-region represent a major determinant for Tat pathway specificity. Tat-dependent export of TorA-MalE was significantly slower in the presence of SecB than in its absence, showing that SecB can bind to this precursor despite the presence of the Sec avoidance signal in the c-region of the TorA signal peptide, strongly suggesting that the function of the Sec avoidance signal is not the prevention of SecB binding; rather, it must be exerted at a later step in the Sec pathway.     

Novel GFP expression using a short N-terminal polypeptide through the defined twin-arginine translocation (Tat) pathway

Escherichia coli is frequently used as a convenient host organism for soluble recombinant protein expression. However, additional strategies are needed for proteins with complex folding characteristics. Here, we suggested that the acidic, neutral, and alkaline isoelectric point (pI) range curves correspond to the channels of the E. coli type-II cytoplasmic membrane translocation (periplasmic translocation) pathways of twin-arginine translocation (Tat), Yid, and general secretory pathway (Sec), respectively, for unfolded and folded target proteins by examining the characteristic pI values of the N-termini of the signal sequences or the leader sequences, matching with the known diameter of the translocation channels, and analyzing the N-terminal pI value of the signal sequences of the Tat substrates. To confirm these proposed translocation pathways, we investigated the soluble expression of the folded green fluorescent protein (GFP) with short N-terminal polypeptides exhibiting pI and hydrophilicity separately or collectively. This, in turn, revealed the existence of an anchor function with a specific directionality based on the N-terminal pI value (termed as N-terminal pI-specific directionality) and distinguished the presence of the E. coli type-II cytoplasmic membrane translocation pathways of Tat, Yid, and Sec for the unfolded and folded target proteins. We concluded that the pI value and hydrophilicity of the short N-terminal polypeptide, and the total translational efficiency of the target proteins based on the ΔGRNA value of the N-terminal coding regions are important factors for promoting more efficient translocation (secretion) through the largest diameter of the Tat channel. These results show that the short N-terminal polypeptide could substitute for the Tat signal sequence with improved efficiency.     

An essential role for the DnaK molecular chaperone in stabilizing over-expressed substrate proteins of the bacterial twin-arginine translocation pathway

All secreted proteins in Escherichia coli must be maintained in an export-competent state before translocation across the inner membrane. In the case of the Sec pathway, this function is carried out by the dedicated SecB chaperone and the general chaperones DnaK-DnaJ-GrpE and GroEL-GroES, whose job collectively is to render substrate proteins partially or entirely unfolded before engagement of the translocon. To determine whether these or other general molecular chaperones are similarly involved in the translocation of folded proteins through the twin-arginine translocation (Tat) system, we screened a collection of E. coli mutant strains for their ability to transport a green fluorescent protein (GFP) reporter through the Tat pathway. We found that the molecular chaperone DnaK was essential for cytoplasmic stability of GFP bearing an N-terminal Tat signal peptide, as well as for numerous other recombinantly expressed endogenous and heterologous Tat substrates. Interestingly, the stability conferred by DnaK did not require a fully functional Tat signal as substrates bearing translocation defective twin lysine substitutions in the consensus Tat motif were equally unstable in the absence of DnaK. These findings were corroborated by crosslinking experiments that revealed an in vivo association between DnaK and a truncated version of the Tat substrate trimethylamine N-oxide reductase (TorA502) bearing an RR or a KK signal peptide. Since TorA502 lacks nine molybdo-cofactor ligands essential for cofactor attachment, the involvement of DnaK is apparently independent of cofactor acquisition. Finally, we show that the stabilizing effects of DnaK can be exploited to increase the expression and translocation of Tat substrates under conditions where the substrate production level exceeds the capacity of the Tat translocase. This latter observation is expected to have important consequences for the use of the Tat system in biotechnology applications where high levels of periplasmic expression are desirable.     

Export of active green fluorescent protein to the periplasm by the twin-arginine translocase (Tat) pathway in Escherichia coli

The twin-arginine translocation (Tat) system targets cofactor-containing proteins across the Escherichia coli cytoplasmic membrane via distinct signal peptides bearing a twin-arginine motif. In this study, we have analysed the mechanism and capabilities of the E. coli Tat system using green fluorescent protein (GFP) fused to the twin-arginine signal peptide of TMAO reductase (TorA). Fractionation studies and fluorescence measurements demonstrate that GFP is exported to the periplasm where it is fully active. Export is almost totally blocked in tat deletion mutants, indicating that the observed export in wild-type cells occurs predominantly, if not exclusively, by the Tat pathway. Imaging studies reveal a halo of fluorescence in wild-type cells corresponding to the exported periplasmic form; the GFP is distributed uniformly throughout the cytoplasm in a tat mutant. Because previous work has shown GFP to be incapable of folding in the periplasm, we propose that GFP is exported in a fully folded, active state. These data also show for the first time that heterologous proteins can be exported in an active form by the Tat pathway.     

Protein secretion in bacteria.

Most secretory proteins are synthesized as precursors with an amino-terminal signal peptide. Genetic identification of proteins essential for signal peptide dependent translocation to the Escherichia coli periplasm has led to the biochemical dissection of the secretion pathway. Additional mechanisms exist in Gram-negative bacteria for protein secretion to the extracellular environment.     

The hydrophobic core of twin-arginine signal sequences orchestrates specific binding to Tat-pathway related chaperones

Redox enzyme maturation proteins (REMPs) bind pre-proteins destined for translocation across the bacterial cytoplasmic membrane via the twin-arginine translocation system and enable the enzymatic incorporation of complex cofactors. Most REMPs recognize one specific pre-protein. The recognition site usually resides in the N-terminal signal sequence. REMP binding protects signal peptides against degradation by proteases. REMPs are also believed to prevent binding of immature pre-proteins to the translocon. The main aim of this work was to better understand the interaction between REMPs and substrate signal sequences. Two REMPs were investigated: DmsD (specific for dimethylsulfoxide reductase, DmsA) and TorD (specific for trimethylamine N-oxide reductase, TorA). Green fluorescent protein (GFP) was genetically fused behind the signal sequences of TorA and DmsA. This ensures native behavior of the respective signal sequence and excludes any effects mediated by the mature domain of the pre-protein. Surface plasmon resonance analysis revealed that these chimeric pre-proteins specifically bind to the cognate REMP. Furthermore, the region of the signal sequence that is responsible for specific binding to the corresponding REMP was identified by creating region-swapped chimeric signal sequences, containing parts of both the TorA and DmsA signal sequences. Surprisingly, specificity is not encoded in the highly variable positively charged N-terminal region of the signal sequence, but in the more similar hydrophobic C-terminal parts. Interestingly, binding of DmsD to its model substrate reduced membrane binding of the pre-protein. This property could link REMP-signal peptide binding to its reported proofreading function.     

Twin-Arginine Translocation Pathway in Streptomyces lividans

The recently discovered bacterial twin-arginine translocation (Tat) pathway was investigated in Streptomyces lividans, a gram-positive organism with a high secretion capacity. The presence of one tatC and two hcf106 homologs in the S. lividans genome together with the several precursor proteins with a twin-arginine motif in their signal peptide suggested the presence of the twin-arginine translocation pathway in the S. lividans secretome. To demonstrate its functionality, a tatC deletion mutant was constructed. This mutation impaired the translocation of the Streptomyces antibioticus tyrosinase, a protein that forms a complex with its transactivator protein before export. Also the chimeric construct pre-TorA-23K, known to be exclusively secreted via the Tat pathway in Escherichia coli, could be translocated in wild-type S. lividans but not in the tatC mutant. In contrast, the secretion of the Sec-dependent S. lividans subtilisin inhibitor was not affected. This study therefore demonstrates that also in general in Streptomyces spp. the Tat pathway is functional. Moreover, this Tat pathway can translocate folded proteins, and the E. coli TorA signal peptide can direct Tat-dependent transport in S. lividans.     

Effect of codon-optimized E. coli signal peptides on recombinant Bacillus stearothermophilus maltogenic amylase periplasmic localization,yield and activity

Recombinant proteins can be targeted to the Escherichia coli periplasm by fusing them to signal peptides. The popular pET vectors facilitate fusion of target proteins to the PelB signal. A systematic comparison of the PelB signal with native E. coli signal peptides for recombinant protein expression and periplasmic localization is not reported. We chose the Bacillus stearothermophilus maltogenic amylase (MA), an industrial enzyme widely used in the baking and brewing industry, as a model protein and analyzed the competence of seven, codon-optimized, E. coli signal sequences to translocate MA to the E. coli periplasm compared to PelB. MA fusions to three of the signals facilitated enhanced periplasmic localization of MA compared to the PelB fusion. Interestingly, these three fusions showed greatly improved MA yields and between 18- and 50-fold improved amylase activities compared to the PelB fusion. Previously, non-optimal codon usage in native E. coli signal peptide sequences has been reported to be important for protein stability and activity. Our results suggest that E. coli signal peptides with optimal codon usage could also be beneficial for heterologous protein secretion to the periplasm. Moreover, such fusions could even enhance activity rather than diminish it. This effect, to our knowledge has not been previously documented. In addition, the seven vector platform reported here could also be used as a screen to identify the best signal peptide partner for other recombinant targets of interest.     

Membrane-specific targeting of green fluorescent protein by the Tat pathway in the cyanobacterium Synechocystis PCC6803

The transport and sorting of extracytoplasmic proteins in cyanobacteria is made complex by the presence of a highly differentiated membrane system. Proteins destined for the periplasm and thylakoid lumen are initially transported by Sec- and Tat-type pathways but little is known of the mechanisms that ultimately direct them to the correct destinations. We have generated a Synechocystis PCC6803 transformant that expresses a fusion protein comprising the Tat-specific targeting signal of Escherichia coli TorA linked to green fluorescent protein (GFP). Immunoblotting indicates the presence of mature-size GFP but no precursor form, demonstrating that efficient translocation has taken place. Confocal microscopy and immunogold electron microscopy reveal GFP to be almost exclusively located in the periplasm, with almost no protein evident in the thylakoid network. These data point to the operation of highly effective sorting pathways for soluble proteins in this cyanobacterium. The observed sorting of the GFP suggests that either (a) the Tat apparatus is located only in the plasma membrane or (b) the TorA-GFP is targeted across either membrane but the GFP is subsequently directed to the periplasm, perhaps by a default sorting pathway to this compartment.     

信号肽及化学通透剂对环糊精葡萄糖基转移酶胞外分泌的影响

【目的】研究不同的信号肽和化学通透剂对重组环糊精葡萄糖基转移酶(CGTase)胞外分泌的影响,提高CGTase的胞外分泌量。【方法】扩增地芽孢杆菌CHB1(Geobacillus sp.CHB1)的CGTase基因,构建带有地芽孢杆菌CHB1自身信号肽、Omp A、Pel B信号肽和不带信号肽的4种重组质粒;比较4种重组质粒对重组CGTase胞外分泌的影响,筛选最优的信号肽;考察甘氨酸、Triton X-100、SDS和Tween 80四种化学通透剂对重组CGTase胞外分泌的影响,确定最佳的化学通透剂及其浓度。【结果】Omp A信号肽介导的分泌效果最好,胞外酶活达到7.44 U/m L,分别是Pel B、CHB1信号肽的2.04倍和11.27倍,不带信号肽的重组质粒菌胞外检测不到酶活;携带Omp A信号肽的重组质粒菌发酵48 h,同时添加浓度为0.6%的甘氨酸和0.3%的Triton X-100,胞外酶活达最大到14.27 U/m L;SDS和Tween 80对该酶的胞外分泌具有明显的抑制作用。【结论】Omp A信号肽的介导效果最佳,同时添加浓度为0.6%和0.3%的甘氨酸和Triton X-100可以有效促进胞外分泌,为该重组酶的高效胞外分泌提供了一种有效的方法。     

Signal peptide protection by specific chaperone

TorD is the private chaperone of TorA, a periplasmic respiratory molybdoenzyme of Escherichia coli. In this study, it is demonstrated that TorD is required to maintain the integrity of the twin-arginine signal sequence of the cytoplasmic TorA precursors. In the absence of TorD, 35 out of the 39 amino acid residues of the signal peptide were lost and the proteolysis of the N-terminal extremity of TorA precursors was not prevented by the molybdenum cofactor insertion. We thus propose that one of the main roles of TorD is to protect the TorA signal peptide to allow translocation of the enzyme by the TAT system.     

Comparison of signal peptides for efficient protein secretion in the baculovirus-silkworm system

The baculovirus-silkworm expression system is widely used as a mass production system for recombinant secretory proteins. However, the final yields of some recombinant proteins are not sufficient for industrial use. In this study, we focused on the signal peptide as a key factor for improving the efficiency of protein production. Endoplasmic reticulum (ER) translocation of newly synthesized proteins is the first stage of the secretion pathway; therefore, the selection of an efficient signal peptide would lead to the efficient secretion of recombinant proteins. The Drosophila Bip and honeybee melittin signal peptides have often been used in this system, but to the best of our knowledge, there has been no study comparing secretion efficiency between exogenous and endogenous signal peptides. In this study we employed signal peptides from 30K Da and SP2 proteins as endogenous signals, and compared secretion efficiency with those of exogenous or synthetic origins. We have found that the endogenous secretory signal from the 30K Da protein is the most efficient for recombinant secretory protein production in the baculovirus-silkworm expression system.     

Novel synthetic signal peptides for the periplasmic secretion of green fluorescent protein in Escherichia coli

New secretion vectors containing synthetic signal peptides were constructed to study the periplasmic translocation of green fluorescent protein (GFP) in Escherichia coli. These constructs encode synthetic signal peptides spA and spD fused to the amino terminal end of GFP, and expressed from T7/lac promoter in the BL21DE3 strain by induction with IPTG. The recombinant protein was detected in both the cytoplasmic and periplasmic fractions. Fluorescence analysis revealed that recombinant proteins with signal peptides were not fluorescent, indicating translocation to periplasmic space. In contrast, recombinant proteins without signal peptide were fluorescent. These results indicate that the expressed recombinant proteins were translocated into the periplasm. Therefore, the synthetic signal peptides derived from signal peptides of Bacillus sp. could efficiently secrete the heterologous proteins to the periplasmic space of E. coli.     

Functional analysis of the twin-arginine translocation pathway in Corynebacterium glutamicum ATCC 13869

Compared to those of other gram-positive bacteria, the genetic structure of the Corynebacterium glutamicum Tat system is unique in that it contains the tatE gene in addition to tatA, tatB, and tatC. The tatE homologue has been detected only in the genomes of gram-negative enterobacteria. To assess the function of the C. glutamicum Tat pathway, we cloned the tatA, tatB, tatC, and tatE genes from C. glutamicum ATCC 13869 and constructed mutants carrying deletions of each tat gene or of both the tatA and tatE genes. Using green fluorescent protein (GFP) fused with the twin-arginine signal peptide of the Escherichia coli TorA protein, we demonstrated that the minimal functional Tat system required TatA and TatC. TatA and TatE provide overlapping function. Unlike the TatB proteins from gram-negative bacteria, C. glutamicum TatB was dispensable for Tat function, although it was required for maximal efficiency of secretion. The signal peptide sequence of the isomaltodextranase (IMD) of Arthrobacter globiformis contains a twin-arginine motif. We showed that both IMD and GFP fused with the signal peptide of IMD were secreted via the C. glutamicum Tat pathway. These observations indicate that IMD is a bona fide Tat substrate and imply great potential of the C. glutamicum Tat system for industrial production of heterologous folded proteins.