昆虫中肠液性质对苏云金芽孢杆菌伴孢晶体毒力的影响

综述了昆虫中肠液性质对苏云金芽孢杆菌Bacillus thuringiensis伴孢晶体毒力的影响。中肠液的酸碱度和蛋白酶是影响伴孢晶体溶解与原毒素活化的两大因素。中肠液的酸碱度不仅影响到伴孢晶体的溶解速度,还影响到各种蛋白酶的活性表现;而蛋白酶则直接参与了原毒素的活化,其组成与活性影响着原毒素的活化速度和杀虫专一性。因中肠液蛋白水解能力过高而导致原毒素的过度降解是某些昆虫对苏云金芽孢杆菌低度敏感的主要原因,而中肠液对原毒素活化能力的降低则与昆虫抗性的形成有关。此外,中肠液的沉淀作用及其它生理生化特性也影响着原毒素毒力的正常发挥。     

pH-Controlled Bacillus thuringiensis Cry1Ac Protoxin Loading and Release from Polyelectrolyte Microcapsules

Crystal proteins synthesized by Bacillus thuringiensis (Bt) have been used as biopesticides because of their toxicity to the insect larval hosts. To protect the proteins from environmental stress to extend their activity, we have developed a new microcapsule formulation. Poly (acrylic acid) (PAH) and poly (styrene sulfonate) (PSS) were fabricated through layer-by-layer self-assembly based on a CaCO₃ core. Cry1Ac protoxins were loaded into microcapsules through layer-by-layer self-assembly at low pH, and the encapsulated product was stored in water at 4°C. Scanning electron microscopy (SEM) was used to observe the morphology of the capsules. To confirm the successful encapsulation, the loading results were observed with a confocal laser scattering microscope (CLSM), using fluorescein-labeled Cry1Ac protoxin (FITC-Cry1Ac). The protoxins were released from the capsule under the alkaline condition corresponding to the midgut of certain insects, a condition which seldom exists elsewhere in the environment. The following bioassay experiment demonstrated that the microcapsules with Cry1Ac protoxins displayed approximately equivalent insecticidal activity to the Asian corn borer compared with free Cry1Ac protoxins, and empty capsules proved to have no effect on insects. Further result also indicated that the formulation could keep stable under the condition of heat and desiccation. These results suggest that this formulation provides a promising methodology that protects protoxins from the environment and releases them specifically in the target insects’ midgut, which has shown potential as biopesticide in the field.     

Inhibition of gut proteases and development of dengue vector, Aedes aegypti by Allium sativum protease inhibitor

The paper describes the bio efficacy of a protease inhibitor; isolated from Allium sativum ‘garlic’ (ASPI); against Aedes aegypti mosquito, a well-known transmitter of dengue and Chikungunya. The purification of protease inhibitor from Allium sativum ‘garlic’ (ASPI) was carried out by ammonium sulfate precipitation followed by Fast Protein Liquid Chromatography using akta DEAE-Cellulose column. The protein fraction demonstrating trypsin inhibitory activity was further evaluated for its insecticidal activity using gut protease inhibition assay and larvicidal assay. ASPI is an inhibitor of porcine trypsin (IC₅₀ of 650.726?μg/mL) and has molecular weight of ~15?kDa determined by SDS PAGE similar to other inhibitors of the Kunitz-type family (14–26?kDa). ASPI demonstrated 50% reduced activity of Ae. aegypti midgut proteases and showed a dose-dependent acute toxicity on Ae. aegypti 3rd instars exhibiting LC₅₀ value of ~50.827?μg/mL. After ten days of larval exposure ASPI resulted in a 24-h delay of larval development and ~72% mortality at 61.5?μg/mL. These results suggest that ASPI may serve as potent insecticidal agent and hence opens a new gateway in the field of phyto-remediation.     

Influence of pH Control Agents on Entomotoxicity Potency of Bacillus thuringiensis using Different Raw Materials

Summary In this investigation, ammonium hydroxide and acetic acid were used as pH control agents during Bacillus thuringiensis (Bt) fermentation in a pilot scale fermentor (150-l) employing two secondary wastewater sludges from two different wastewater treatment plants (CUQS and JQS) and semi-synthetic soybean meal medium as raw materials. Regardless of the cultivation medium, a substantial increase in total cell count, spore count, protease activity and entomotoxicity was achieved when the pH of the culture was controlled using NH₄OH/CH₃COOH. At harvest, total cell count increased by almost 17%, 33% and 25%; protease activity was enhanced by 12%, 33% and 53% and maximal spore count augmented by almost 28%, 48% and 33% in CUQS, JQS and soybean medium, respectively. Entomotoxicity potency was improved by 22%, 21% and 14% in CUQS, JQS and soybean medium, respectively compared to results obtained with NaOH/H₂SO₄ as pH control agents. A higher entomotoxicity was also observed using sludge compared to the soybean medium. This improvement of the Bt process performance was a consequence of the addition of rapidly utilizable carbon and nitrogen source through pH control, which stimulated endotoxin production in the crystal and enhanced sporulation.     

Intracellular proteases during sporulation and enterotoxin formation byClostridium perfringens type A

Intracellular proteolytic activity was detected in cell-free extracts ofClostridium perfringens NCTC 10239 and NCTC 8798. The kinetics of protease, enterotoxin, and spore formation as well as growth of the wild type at elevated temperature and the use of sporulation mutants indicated that most protease activity was related to sporulation. Intracellular protease activity was inhibited by a mixture of tetrasodium ethylenediaminetetraacetic acid and phenylmethylsulfonyl fluoride; this indicated the presence of an alkaline serine protease and a neutral metallo-protease. Stage 0 sporulation mutants produced only metallo-sensitive proteases; this indicated that only the serine protease was sporulation-specific.     

The interactions between soybean trypsin inhibitor and delta-endotoxin of Bacillus thuringiensis in Helicoverpa armigera larva

No significant difference in larval mortality was observed when a sublethal dose of Bacillus thuringiensis (Bt) var. kurstaki HD-1 crystal was supplemented with soybean trypsin inhibitor (STI) in the artificial diet fed to Helicoverpa armigera in the laboratory, but supplementing a nonlethal dose of crystal with STI in the diet led to a pronounced reduction of larval growth. This concentration of crystal and two lower concentrations of STI alone had no significant effects on larval growth. The results of substrate-gel electrophoresis demonstrated that the proteases in the H. armigera midgut fluid responsible for the degradation of protoxin consisted of at least four proteases with molecular weights of 71, 49, 36, and 30 kDa. All four proteases could utilize casein also as the substrate. When larvae were fed with STI or Bt + STI, the proteolytic activities of the 49-kDa enzyme disappeared, and the activities of the other three enzymes were reduced. Enzyme assays also indicated that feeding larvae with diets containing Bt, STI, or Bt + STI significantly decreased the specific activities of larval general proteases and the trypsin-like enzyme. The protein concentration of midgut fluid was elevated, especially in the larvae fed on the diets containing STI and Bt + STI. Both in vitro and in vivo studies showed that the degradation of protoxin and toxin could be inhibited by soybean trypsin inhibitors, but when the incubation time was prolonged, the protoxin could be degraded completely, while the degradation of toxin was inhibited further. This suggested that the retention time of toxins in the larval midgut was extended and synergism between insecticidal crystal protein and soybean trypsin inhibitor occurred, which showed as the inhibition of H. armigera larval growth.     

Role of Tryptophan Residues in Toxicity of Cry1Ab Toxin from Bacillus thuringiensis

Bacillus thuringiensis produces insecticidal proteins (Cry protoxins) during the sporulation phase as parasporal crystals. During intoxication, the Cry protoxins must change from insoluble crystals into membrane-inserted toxins which form ionic pores. The structural changes of Cry toxins during oligomerization and insertion into the membrane are still unknown. The Cry1Ab toxin has nine tryptophan residues; seven are located in domain I, the pore-forming domain, and two are located in domain II, which is involved in receptor recognition. Eight Trp residues are highly conserved within the whole family of three-domain Cry proteins, suggesting an essential role for these residues in the structural folding and function of the toxin. In this work, we analyzed the role of Trp residues in the structure and function of Cry1Ab toxin. We replaced the Trp residues with phenylalanine or cysteine using site-directed mutagenesis. Our results show that W65 and W316 are important for insecticidal activity of the toxin since their replacement by Phe reduced the toxicity against Manduca sexta. The presence of hydrophobic residue is important at positions 117, 219, 226, and 455 since replacement by Cys affected either the crystal formation or the insecticidal activity of the toxin in contrast to replacement by Phe in these positions. Additionally, some mutants in positions 219, 316, and 455 were also affected in binding to brush border membrane vesicles (BBMV). This is the first report that studies the role of Trp residues in the activity of Cry toxins.     

Intramolecular proteolytic nicking and binding of Bacillus thuringiensis Cry8Da toxin in BBMVs of Japanese beetle

Bacillus thuringiensis (Bt) Cry8D insecticidal proteins are unique among Cry8 family proteins in terms of its insecticidal activity against adult Scarab beetles, such as Japanese beetle (Popillia japonica Newman). From the sequence homology with other Bt Cry proteins especially those active against beetles, such as Cry3Aa whose 3D structure is available, the structure of the Cry8D protein has been predicted to be a typical three-domain Cry protein type. In addition, the activation process of Cry8D in gut juice of susceptible insects is presumed to be similar to that of Cry3A (Yamaguchi et al., 2008). In this study, the activation process of Cry8Da in insect gut juice was closely examined. Japanese beetle gut juice proteases digested the 130 kDa Cry8Da protein to produce a 64 kDa protein. This 64 kDa protein was active against both adult and larval Japanese beetle and considered to be an activated toxin. N-terminal sequencing of this 64 kDa protein revealed that the Cry8Da leader sequence consisting of 63 amino acid residues from M¹ to F⁶³ was removed. As in the case of Cry3Aa, the proteases further digested the 64 kDa protein to two 8 kDa and 54 kDa fragments. N-terminal amino acid analysis of these smaller fragments indicated that the proteases digested the loop between Alpha Helix (Alpha for short) 3 and Alpha 4. This means that the 8 kDa fragment consists of Alpha 1-3 of Domain I and that the 54 kDa fragment contains the remaining Domain I and full Domain II and Domain III. Size exclusion chromatography and anion exchange chromatography could not separate these 64, 54 and 8 kDa proteins suggesting that the 54 kDa and 8 kDa fragments are still forming the toxin complex equivalent to the 64 kDa protein by size and ionic charge. The sequencing and chromatography results suggest that the gut juice proteases merely nicked the loop between Alpha 3 and Alpha 4. This nicking process appeared to be essential for receptor binding of the Cry8Da toxin. BBMV binding assay revealed that the Cry8Da toxin bound to BBMV preparations from both adult and larval Japanese beetle only after the loop was nicked. Only the 54 kDa fragment bound to the BBMV preparations but not the 64 kDa protein. Ligand blot showed that the protease activated Cry8Da toxin, presumably the 54 kDa fragment, bound to specific BBMV proteins, one or more of those would be receptor(s). The sizes and binding affinities of these Cry8Da-bound proteins of Japanese beetle BBMV differed between larvae and adults.     

Tritrophic interactions among Bt maize,an insect pest and entomopathogens: effects on development and survival of western corn rootworm

Agricultural systems often provide a model for testing ecological hypotheses, while ecological theory can enable more effective pest management. One of the best examples of this is the interaction between host‐plant resistance and natural enemies. With the advent of crops that are genetically modified to produce insecticidal toxins from the bacterium Bacillus thuringiensis (Bt), a new form of host‐plant resistance has been introduced to agroecosystems. How Bt crops interact with natural enemies, especially insect pathogens in below‐ground systems, is not well understood, but provides a unique opportunity to study below‐ground tritrophic interactions. In this study, we used two species of entomopathogenic fungi and three species of entomopathogenic nematodes to determine how this community of soil‐borne natural enemies might interact with Bt maize (event 59122, expressing the insecticidal protein Cry34/35Ab1) to affect survival and development of western corn rootworm (Diabrotica virgifera virgifera), which is an obligate root feeder and a serious pest of maize. We ran two experiments, one in a greenhouse and one in a growth chamber. Both experiments consisted of a fully crossed design with two maize treatments (Bt maize and non‐Bt maize) and two entomopathogen treatments (present or absent). The community of entomopathogens significantly increased mortality of western corn rootworm, and Bt maize increased larval developmental time and mortality. Entomopathogens and Bt maize acted in an independent and additive manner, with both factors increasing the mortality of western corn rootworm. Results from this study suggest that entomopathogens may complement host‐plant resistance from Bt crops.     

Characterization and comparison of midgut proteases of Bacillus thuringiensis susceptible and resistant diamondback moth (Plutellidae: Lepidoptera)

The midgut proteases of the Bacillus thuringiensis resistant and susceptible populations of the diamondback moth, Plutella xylostella L. were characterized by using protease specific substrates and inhibitors. The midgut contained trypsin-like proteases of molecular weights of 97, 32, 29.5, 27.5, and 25 kDa. Of these five proteases, 29.5 kDa trypsin-like protease was the most predominant in activation of protoxins of Cry1Aa and Cry1Ab. The activation of Cry1Ab protoxin by midgut protease was fast (T(1/2) of 23-24 min) even at a protoxin:protease ratio of 250:1. The protoxin activation appeared to be multi-step process, and at least seven intermediates were observed before formation of a stable toxin of about 57.4 kDa from protoxin of about 133 kDa. Activation of Cry1Aa was faster than that of Cry1Ab on incubation of protoxins with midgut proteases and bovine trypsin. The protoxin and toxin forms of Cry proteins did not differ in toxicity towards larvae of P. xylostella. The differences in susceptibility of two populations to B. thuringiensis Cry1Ab were not due to midgut proteolytic activity. Further, the proteolytic patterns of Cry1A protoxins were similar in the resistant as well as susceptible populations of P. xylostella.     

Protease activation of the entomocidal protoxin of Bacillus thuringiensis subsp. kurstaki.

Two isolates of Bacillus thuringiensis subsp. kurstaki were examined which produced different levels of intracellular proteases. Although the crystals from both strains had comparable toxicity, one of the strains, LB1, had a strong polypeptide band at 68,000 molecular weight in the protein from the crystal; in the other, HD251, no such band was evident. When the intracellular proteases in both strains were measured, strain HD251 produced less than 10% of the proteolytic activity found in LB1. These proteases were primarily neutral metalloproteases, although low levels of other proteases were detected. In LB1, the synthesis of protease increased as the cells began to sporulate; however, in HD251, protease activity appeared much later in the sporulation cycle. The protease activity in strain LB1 was very high when the cells were making crystal toxin, whereas in HD251 reduced proteolytic activity was present during crystal toxin synthesis. The insecticidal toxin (molecular weight, 68,000) from both strains could be prepared by cleaving the protoxin (molecular weight, 135,000) with trypsin, followed by ion-exchange chromatography. The procedure described gave quantitative recovery of toxic activity, and approximately half of the total protein was recovered. Calculations show that these results correspond to stoichiometric conversion of protoxin to insecticidal toxin. The toxicities of whole crystals, soluble crystal protein, and purified toxin from both strains were comparable.     

Protease activation of the entomocidal protoxin of Bacillus thuringiensis subsp. kurstaki

Two isolates of Bacillus thuringiensis subsp. kurstaki were examined which produced different levels of intracellular proteases. Although the crystals from both strains had comparable toxicity, one of the strains, LB1, had a strong polypeptide band at 68,000 molecular weight in the protein from the crystal; in the other, HD251, no such band was evident. When the intracellular proteases in both strains were measured, strain HD251 produced less than 10% of the proteolytic activity found in LB1. These proteases were primarily neutral metalloproteases, although low levels of other proteases were detected. In LB1, the synthesis of protease increased as the cells began to sporulate; however, in HD251, protease activity appeared much later in the sporulation cycle. The protease activity in strain LB1 was very high when the cells were making crystal toxin, whereas in HD251 reduced proteolytic activity was present during crystal toxin synthesis. The insecticidal toxin (molecular weight, 68,000) from both strains could be prepared by cleaving the protoxin (molecular weight, 135,000) with trypsin, followed by ion-exchange chromatography. The procedure described gave quantitative recovery of toxic activity, and approximately half of the total protein was recovered. Calculations show that these results correspond to stoichiometric conversion of protoxin to insecticidal toxin. The toxicities of whole crystals, soluble crystal protein, and purified toxin from both strains were comparable.     

Effects of stilbene optical brighteners on the insecticidal activity of Bacillus thuringiensis and a single nucleopolyhedrovirus on Helicoverpa armigera

The incorporation of certain stilbene optical brighteners into virus-based formulations has been demonstrated to increase viral pathogenicity (as indicated by reduced LD/LC₅₀ values) but their effect on Bacillus thuringiensis activity has been scarcely investigated. We determined the effect of nine optical brighteners on the insecticidal activity of B. thuringiensis ser. kurstaki HD-1 strain (Bt HD-1) on Helicoverpa armigera and also compared the effect of two optical brighteners on the insecticidal activity of Bt HD-1 and occlusion bodies (OBs) of a Spanish isolate of H. armigera single nucleocapsid nucleopolyhedrovirus (HearNPV-SP1). Blankophor CLE, Blankophor DRS, Blankophor ER, and Leucophor SAC significantly increased the pathogenicity of Bt HD-1. In contrast, Tinopal UNPA-GX, Tinopal CBS, Blankophor BA, Leucophor AP, and Leucophor UO had an adverse or no effect on its insecticidal activity. Mixtures of HearNPV-SP1 OBs with Tinopal UNPA-GX or Leucophor UO resulted in 31.4- and 11.4-fold increases in pathogenicity, respectively, at 1%, and 11.4- and 6.3-fold increases in pathogenicity, respectively, at 0.1%, compared to the OBs alone. However, none of these brighteners increased Bt HD-1 activity. These results appear consistent with the hypothesis that the enhancement of HearNPV-SP1 pathogenicity and the null or antagonistic effects observed in Bt HD-1 against H. armigera were due to optical brightener-mediated degradation of the peritrophic membrane, but additional systematic studies involving a broad range of brighteners and electron microscope observations are required to confirm this premise.     

Induced production of chitinase to enhance entomotoxicity of Bacillus thuringiensis employing starch industry wastewater as a substrate

Induced production of chitinase during bioconversion of starch industry wastewater (SIW) to Bacillus thuringiensis var. kurstaki HD-1 (Btk) based biopesticides was studied in shake flask as well as in computer-controlled fermentors. SIW was fortified with different concentrations (0%; 0.05%; 0.1%; 0.2%; 0.3% w/v) of colloidal chitin and its consequences were ascertained in terms of Btk growth (total cell count and viable spore count), chitinase, protease and amylase activities and entomotoxicity. At optimum concentration of 0.2% w/v colloidal chitin, the entomotoxicity of fermented broth and suspended pellet was enhanced from 12.4 × 10⁹ (without chitin) to 14.4 × 10⁹ SBU/L and from 18.2 × 10⁹ (without chitin) to 25.1 × 10⁹ SBU/L, respectively. Further, experiments were conducted for Btk growth in a computer-controlled 15 L bioreactor using SIW as a raw material with (0.2% w/v chitin, to induce chitinase) and without fortification of colloidal chitin. It was found that the total cell count, spore count, delta-endotoxin concentration (alkaline solubilised insecticidal crystal proteins), amylase and protease activities were reduced whereas the entomotoxicity and chitinase activity was increased with chitin fortification. The chitinase activity attained a maximum value at 24 h (15 mU/ml) and entomotoxicity of suspended pellet reached highest (26.7 × 10⁹ SBU/L) at 36 h of fermentation with chitin supplementation of SIW. In control (without chitin), the highest value of entomotoxicity of suspended pellet (20.5 × 10⁹ SBU/L) reached at 48 h of fermentation. A quantitative synergistic action of delta-endotoxin concentration, spore concentration and chitinase activity on the entomotoxicity against spruce budworm larvae was observed.     

Differences in susceptibility and physiological fitness of Mexican field Trichoplusia ni strains exposed to Bacillus thuringiensis

The use of different commercial Bacillus thuringiensis (Bt) products in the Bajio guanajuatense area in Mexico began 12 yr ago, and resistance to Bt in this area has been reported for Plutella xylostella (L.) The current study provides a baseline response and resistance potential to Bt in field and laboratory strains of Bajio Trichoplusia ni (Hübner). Differences in susceptibility to Bt among T. ni populations were observed. T. ni neonates collected in Romita, Guanajuato, were more susceptible to Bt than those collected in Salvatierra or San Luis de la Paz, Guanajuato. After five generations of exposure to XenTari in the laboratory, decreased susceptibility was found only in the Salvatierra insects, with an LC50 that was 2.1-fold greater than that of a Mexican laboratory strain. The XenTari-selected San Luis de la Paz strain was from 16- to 87-fold more resistant to CrylA protoxins than U.S. (US) and Mexican laboratory strains. Although CrylAb is not a component of XenTari, this strain also was significantly less susceptible to CrylAb toxin compared with a US strain, with a resistance ratio of 40.4. The larval weights and lengths, pupal lengths, and percentage of pupation were significantly lower for the Salvatierra strain than for all other strains. The relationship of T. ni susceptibilities to Bt Cry toxins and protoxins after several generations of exposure to XenTari and its similarity to P. xylostella behavior.     

Entomotoxicity,protease and chitinase activity of Bacillus thuringiensis fermented wastewater sludge with a high solids content

This study investigated the production of biopesticides, protease and chitinase activity by Bacillus thuringiensis grown in raw wastewater sludge at high solids concentration (30 g/L). The rheology of wastewater sludge was modified with addition of Tween-80 (0.2% v/v). This addition resulted in 1.6 and 1.3-fold increase in cell and spore count, respectively. The maximum specific growth rate (μ_max) augmented from 0.17 to 0.22 h⁻¹ and entomotoxicity (Tx) increased by 29.7%. Meanwhile, volumetric mass transfer coefficient (k_La) showed marked variations during fermentation, and oxygen uptake rate (OUR) increased 2-fold. The proteolytic activity increased while chitinase decreased for Tween amended wastewater sludge, but the entomotoxicity increased. The specific entomotoxicity followed power law when plotted against spore concentration and the relation between Tx and protease activity was linear. The viscosity varied and volume percent of particles increased in Tween-80 amended wastewater sludge and particle size (D₅₀) decreased at the end of fermentation. Thus, there was an increase in entomotoxicity at higher suspended solids (30 g/L) as Tween addition improved rheology (viscosity, particle size, surface tension); enhanced maximum growth rate and OUR.     

Mechanism of entomotoxicity of the plant lectin from Hippeastrum hybrid (Amaryllis) in Spodoptera littoralis larvae

Plant lectins have received a lot of attention because of their insecticidal properties. When orally administered in artificial diet or in transgenic plants, lectins provoke a wide range of detrimental effects, including alteration of the digestive enzyme machinery, fecundity drop, reduced feeding, changes in oviposition behavior, growth and development inhibition and mortality. Although many studies reported the entomotoxicity of lectins, only a few of them investigated the mode of action by which lectins exert toxicity. In the present paper we have studied for the first time the insecticidal potential of the plant lectin from Hippeastrum hybrid (Amaryllis) (HHA) bulbs against the larvae of the cotton leafworm (Spodoptera littoralis). Bioassays on neonate larvae showed that this mannose-specific lectin affected larval growth, causing a development retardation and larval weight decrease. Using primary cell cultures from S. littoralis midguts and confocal microscopy we have elucidated FITC-HHA binding and internalization mechanisms. We found that HHA did not exert a toxic effect on S. littoralis midgut cells, but HHA interaction with the brush border of midgut cells interfered with normal nutrient absorption in the S. littoralis midgut, thereby affecting normal larval growth in vivo. This study thus confirms the potential of mannose-specific lectins as pest control agents and sheds light on the mechanism underlying lectin entomotoxicity.     

Cloning of the nprA gene for neutral protease A of Bacillus thuringiensis and effect of in vivo deletion of nprA on insecticidal crystal protein.

The nprA gene, encoding Bacillus thuringiensis neutral protease A, was cloned by the use of gene-specific oligonucleotides. The size of neutral protease A deduced from the nprA sequence was 566 amino acids (60,982 Da). The cloned nprA gene was partially deleted in vitro, and the deleted allele, designated nprA3, was used to construct an nprA3 strain (neutral protease A-deficient strain) of B. thuringiensis. Growth and sporulation of the nprA3 strain were similar to those of an isogenic nprA+ strain, although the extracellular proteolytic activity of the nprA3 strain was significantly less than that of the nprA+ strain. The nprA3 strain produced insecticidal crystal proteins that were more stable than those of the isogenic nprA+ strain after solubilization in vitro, and sporulated cultures of the nprA3 strain contained higher concentrations of full-length insecticidal crystal proteins than did those of its isogenic counterpart. The absence of neutral protease A did not affect the insecticidal activity of a lepidopteran-specific crystal protein of B. thuringiensis. These results indicate that crystal protein stability and yield may be improved by deletion of specific proteases from B. thuringiensis.     

Molecular approaches towards development of novel Bacillus thuringiensis biopesticides

Bacillus thuringiensis (Bt) has been used for control of lepidopteran, dipteran and coleopteran insects for over three decades. Novel Bt strains harbouring new types of insecticidal genes are being discovered worldwide. Recombinant strains with enhanced toxicity and broadened insecticidal spectrum have been constructed. To increase the field persistence of insecticidal crystal proteins (ICPs), alternative modes of their delivery in Pseudomonas sp. and endophytes have been developed. ICPs have been modified by site-directed mutagenesis to improve their insecticidal efficacy. Higher yields of ICPs have been achieved by use of strong expression promoters and other regulatory elements. Gene-disabling of the sporulation-specific protease has led to yield enhancement of ICPs. Interestingly, Bt toxins have been found to act synergistically with some other pesticidal agents. Optimization of fermentation conditions is an essential requirement for cost-effective commercial production of Bt biopesticides. The environmental impact of deployment of genetically engineered biopesticides has been assessed. Recombinant Bt strains that do not carry any non-Bt DNA, endophytes, encapsulation in killed bacteria (such as Pseudomonas) and asporogenous Bt strains are ecologically safe approaches. Efficient resistance management strategies require judicious use of Bt transgenic plants in conjunction with refugia and Bt biopesticides in an Integrated Pest Management (IPM) program. This revised version was published online in November 2006 with corrections to the Cover Date.     

Role of tryptophan residues in toxicity of Cry1Ab toxin from Bacillus thuringiensis

Bacillus thuringiensis produces insecticidal proteins (Cry protoxins) during the sporulation phase as parasporal crystals. During intoxication, the Cry protoxins must change from insoluble crystals into membrane-inserted toxins which form ionic pores. The structural changes of Cry toxins during oligomerization and insertion into the membrane are still unknown. The Cry1Ab toxin has nine tryptophan residues; seven are located in domain I, the pore-forming domain, and two are located in domain II, which is involved in receptor recognition. Eight Trp residues are highly conserved within the whole family of three-domain Cry proteins, suggesting an essential role for these residues in the structural folding and function of the toxin. In this work, we analyzed the role of Trp residues in the structure and function of Cry1Ab toxin. We replaced the Trp residues with phenylalanine or cysteine using site-directed mutagenesis. Our results show that W65 and W316 are important for insecticidal activity of the toxin since their replacement by Phe reduced the toxicity against Manduca sexta. The presence of hydrophobic residue is important at positions 117, 219, 226, and 455 since replacement by Cys affected either the crystal formation or the insecticidal activity of the toxin in contrast to replacement by Phe in these positions. Additionally, some mutants in positions 219, 316, and 455 were also affected in binding to brush border membrane vesicles (BBMV). This is the first report that studies the role of Trp residues in the activity of Cry toxins.