短乳杆菌与植物乳杆菌的发酵特性

【背景】目前对于酸菜发酵的研究主要关注点是植物乳杆菌(Lactobacillus plantarum),有关短乳杆菌(Lactobacillus brevis)在酸菜方面的研究报道很少。【目的】为了挖掘短乳杆菌的发酵性能并开发酸菜发酵剂,将2株短乳杆菌分别与1株植物乳杆菌进行组合并发酵酸菜,分析短乳杆菌对酸菜发酵品质的影响。【方法】分别测定短乳杆菌与植物乳杆菌的单菌株生长产酸性能、耐酸性及亚硝酸盐降解力,并将两菌种组合后发酵酸菜,分析1-7d内酸度、乳酸菌活菌数、亚硝酸盐含量及酸菜质构特性的变化趋势。【结果】相较于短乳杆菌Lb-9-2,短乳杆菌Lb-5-3的生长和产酸速率较慢、酸耐受力较弱,但其亚硝酸盐降解力较强。两株短乳杆菌分别与植物乳杆菌Lp-9-1组合后产酸力显著增强,并在3 d时达到最低pH值(约3.10);植物乳杆菌Lp-9-1的添加使酸菜中总体乳酸菌生长延迟,在5 d时达到最高活菌数;组合菌种的样品中亚硝酸盐含量在1-7 d内变化较为平缓,前5天内两个组合之间差异不显著;接种乳酸菌会降低酸菜硬度和弹性,发酵3d时Lb-5-3/Lp-9-1组合的硬度最大,感官评价得分最高。【...     

Bacterial diversity and community structure during fermentation of Chinese sauerkraut with Lactobacillus casei 11MZ‐5‐1 by Illumina Miseq sequencing

The bacterial diversity and community structure involved in Chinese sauerkraut is one of the most important factors shaping the final characteristics of traditional foods. In this research, Lactobacillus casei 11MZ‐5‐1 was applied in Chinese sauerkraut fermentation as a starter culture. Illumina Miseq sequencing analysis was used to reveal the bacterial diversity and community structure during Chinese sauerkraut fermentation. A total of 177 283 high‐quality reads of 16S rRNA V4 regions were obtained. The inoculation of L. casei 11MZ‐5‐1 decreased considerably the bacterial richness and bacterial diversity. This inoculum led to the replacement of Lactococcus by Lactobacillus. The levels of Pseudomonas and Enterobacter bacteria decreased. These findings reveal the evolution of important bacterial groups that are involved in fermentation and will facilitate improvements in the Chinese sauerkraut fermentation process.

Significance and Impact of the Study

This research thoroughly revealed the effects of Lactobacillus casei 11MZ‐5‐1 starter cultures on bacterial communities during Chinese sauerkraut fermentation. Illumina Miseq sequencing was effective technique to monitor the bacterial diversity and community structure. The inoculation of L. casei 11MZ‐5‐1 led to the decline of bacterial richness and diversity together with a consistent predominance of Lactobacillus during spontaneous fermentation. The result collectively suggested L. casei 11MZ‐5‐1 is a promising starter in Chinese sauerkraut manufacturing.     

Starter Culture Selection for Making Chinese Sesame-Flavored Liquor Based on Microbial Metabolic Activity in Mixed-Culture Fermentation

Selection of a starter culture with excellent viability and metabolic activity is important for inoculated fermentation of traditional food. To obtain a suitable starter culture for making Chinese sesame-flavored liquor, the yeast and bacterium community structures were investigated during spontaneous and solid-state fermentations of this type of liquor. Five dominant species in spontaneous fermentation were identified: Saccharomyces cerevisiae, Pichia membranaefaciens, Issatchenkia orientalis, Bacillus licheniformis, and Bacillus amyloliquefaciens. The metabolic activity of each species in mixed and inoculated fermentations of liquor was investigated in 14 different cocultures that used different combinations of these species. The relationships between the microbial species and volatile metabolites were analyzed by partial least-squares (PLS) regression analysis. We found that S. cerevisiae was positively correlated to nonanal, and B. licheniformis was positively associated with 2,3-butanediol, isobutyric acid, guaiacol, and 4-vinyl guaiacol, while I. orientalis was positively correlated to butyric acid, isovaleric acid, hexanoic acid, and 2,3-butanediol. These three species are excellent flavor producers for Chinese liquor. Although P. membranaefaciens and B. amyloliquefaciens were not efficient flavor producers, the addition of them alleviated competition among the other three species and altered their growth rates and flavor production. As a result, the coculture of all five dominant species produced the largest amount of flavor compounds. The result indicates that flavor producers and microbial interaction regulators are important for inoculated fermentation of Chinese sesame-flavored liquor.     

Isolation and Characterization of Bacteriophages from Fermenting Sauerkraut

This paper presents the first report of bacteriophage isolated from commercial vegetable fermentations. Nine phages were isolated from two 90-ton commercial sauerkraut fermentations. These phages were active against fermentation isolates and selected Leuconostoc mesenteroides and Lactobacillus plantarum strains, including a starter culture. Phages were characterized as members of the Siphoviridae and Myoviridae families. All Leuconostoc phages reported previously, primarily of dairy origin, belonged to the Siphoviridae family.     

Comparative Volatile Profiles in Soy Sauce According to Inoculated Microorganisms

We compared the volatile profiles in soy sauce according to inoculation with Tetragenococcus halophilus and/or Zygosaccharomyces rouxii. Totals of 107 and 81 volatiles were respectively identified by using solid-phase microextraction and solvent extraction. The various volatile compounds identified included acids, aldehydes, esters, ketones, furans and furan derivatives, and phenols. The major volatiles in the samples treated with T. halophilus were acetic acid, formic acid, benzaldehyde, methyl acetate, ethyl 2-hydroxypropanoate, 2-hydroxy-3-methyl-2-cyclopenten-1-one, and 4-hydroxy-3-methoxybenzaldehyde, while those in the samples inoculated with Z. rouxii were mainly ethanol, acetaldehyde, ethyl propanoate, 2/3-methylbutanol, 1-butanol, 2-phenylethanol, ethyl 2-methylpropanoate, and 4-hydroxy-2-ethyl-5-methyl-3(2H)-furanone. The results indicate that T. halophilus produced significant acid compounds and could affect the Z. rouxii activity, supporting the notion that yeasts and lactic acid bacteria respectively have different metabolic pathways of alcoholic fermentation and lactic acid fermentation, and produce different dominant volatile compounds in soy sauce.     

Microbiological and chemical-sensory characteristics of three coffee varieties processed by wet fermentation

This work evaluated the bacterial diversity during coffee wet fermentation of the three coffee varieties—Mundo Novo (MN), Ouro Amarelo (OA), and Catuaí Vermelho (CV). Isolates were identified by polyphasic techniques: biochemical tests, matrix-assisted laser desorption/ionization-time of flight (MALDI-TOF) and DNA sequencing. Chemical compositions were determined by high (HPLC) and gas chromatography-mass spectrometry (GC-MS) and the roasted beans were sensorial evaluated using the cupping test. Thirty-six mesophilic bacteria and six lactic acid bacteria were identified. Lactobacillus plantarum and Leuconostoc mesenteroides were often found in all varieties. Citric acid was the acid detected in higher concentrations. The volatile profile of the green coffee beans changed during the fermentation in the tank, but more significantly, during the roasting process. These volatiles belonged to the classes of acids, alcohols, aldehydes, and hydrocarbons. Temporal dominance of sensations analysis showed sensorial sensations of acidity (OA and CV), bitterness, chocolate, nuts (MN), and sweetness (CV). The characteristics of each coffee variety were distinct, mainly in relation to total bacteria population, volatile compounds, and sensorial profile. In conclusion polyphasic methodology was efficiently done for bacteria identification; the dominant bacteria might be used for starter cultures and the chemical and sensory analyses helped to understand the changes in coffee fermentation. Our findings are relevant to future select starter bacteria for coffee processing to improve quality and standardization of quality.     

Quantifying the Significance of Phage Attack on Starter Cultures: a Mechanistic Model for Population Dynamics of Phage and Their Hosts Isolated from Fermenting Sauerkraut

We investigated the possibility of using starter cultures in sauerkraut fermentation and thereby reducing the quantity of salt used in the process. This, in turn, would reduce the amount of waste salt that would enter in our water resources. Phage, naturally present in sauerkraut fermentation, could potentially affect the starter cultures introduced. Thus, a mechanistic mathematical model was developed to quantify the growth kinetics of the phage and starter cultures. The model was validated by independent experiments with two Leuconostoc mesenteroides strains isolated from sauerkraut and their corresponding phage. Model simulations and experimental evidence showed the presence of phage-resistant cell populations in starter cultures which replaced phage-sensitive cells, even when the initial phage density (P₀) and multiplicity of infection (MOI) were low (P₀ < 1 × 10³ PFU/ml; MOI < 10⁻⁴) in the MRS media. Based on the results of model simulation and parameter optimization, it was suggested that the kinetic parameters of phage-host interaction, especially the adsorption rate, vary with the initial phage and host densities and with time. The model was validated in MRS broth. Therefore, the effects of heterogeneity and other environmental factors, such as temperature and pH, should be considered to make the model applicable to commercial fermentations.     

Fermentation of philippine vegetable blends

Seven blends of Philipphine vegetables, two of which contained soybeans and one mongo bean sprouts, were prepared for fermentation and study of microbiological and chemical changes. The fermentations were typical lactic acid bacterial fermentations, initiated by Leuconostoc mesenteroides and continued by Lactobacillus brevis, Pediococcus cerevisiae, and L. plantarum. The combination of high acidity and low pH resembled other vegetable fermentations, such as sauerkraut. The procedure offers a method of preserving surplus vegetables, and, in addition, a method for incorporating and preserving the high-protein-containing soybeans.     

Enhancement of exopolysaccharide production from Ganoderma lucidum using a novel submerged volatile co-culture system

Based on the impact of volatile organic compounds (VOCs) on secondary metabolite pathways, a novel submerged volatile co-culture system was constructed, and the effects of thirteen fungal and bacterial VOCs were investigated on Ganoderma lucidum exopolysaccharides production. The results demonstrated at least a 2.2-fold increase in exopolysaccharide (EPS) specific production yield in 6 days submerged volatile co-culture of G. lucidum with Pleurotus ostreatus. Therefore, P. ostreatus was selected as a variable culture, and the effects of agitation speed, inoculum size, initial pH, and co-culture volume on EPSs production were investigated using a Taguchi L₉ orthogonal array. Finally, the highest concentration of EPSs (3.35 ± 0.22 g L^?1) was obtained under optimized conditions; initial pH 5.0, inoculum size 10%, 150 rpm, and 3:1 volume ratio of variable culture to main culture.     

Bioconversion of isoflavones during the fermentation of Samso-Eum with Lactobacillus strains

In this study, the possible application of Lactobacillus strains as a functional starter culture to ferment Samso-Eum (SE), an oriental herbal medicine formula, and the production of bioactive isoflavones (daidzein, genistein) were investigated. Four strains of Lactobacillus (Lactobacillus plantarum KFRI 144, L. amylophilus KFRI 161, L. curvatus KFRI 166, and L. bulgaricus KFRI 344) were used for SE fermentation. Declines in pH and in viable cell counts during fermentation were investigated and the quantification of isoflavones using HPLC were performed after fermentation at 37°C for 48 h. All the tested Lactobacillus strains lowered the pH level to approximately 3.6 after 48 h and showed the highest level of growth at 24 h during SE fermentation. During the SE fermentation of the four Lactobacillus strains, the conversion of isoflavone glycosides (daidzin, genistin) into bioactive aglycones (daidzein, genistein) was observed in all of the fermentations, but with different rates depending on the strains. L. plantarum KFRI 144 and L. amylophilus KFRI 161 exhibited the highest bioconversion rate of isoflavone glycosides into their bioactive aglycones. These results demonstrate that L. plantarum KFRI 144 and L. amylophilus KFRI 161 have potentials as functional starter cultures for manufacturing fermented SE with higher isoflavone bioavailability.     

Use of Lactobacillus plantarum LPCO10, a Bacteriocin Producer, as a Starter Culture in Spanish-Style Green Olive Fermentations

Bacteriocin-producing Lactobacillus plantarum LPCO10 and its non-bacteriocin-producing, bacteriocinimmune derivative, L. plantarum 55-1, were evaluated separately for growth and persistence in natural Spanish-style green olive fermentations. Both strains were genetically marked and selectively enumerated using antibiotic-containing media. Plasmid profile and bacteriocin production (bac⁺) were used as additional markers. When olive brines were inoculated at 10⁵ CFU/ml, the parent strain, LPCO10, proliferated to dominate the epiphytic microflora, sharing high population levels with other spontaneously occurring lactobacilli and persisting throughout the fermentation (12 weeks). In contrast, the derivative strain could not be isolated after 7 weeks. Stability of both plasmid profile and bac⁺ (LPCO10 strain) or bac^- (55-1 strain) phenotype was shown by L. plantarum LPCO10 and L. plantarum 55-1 isolated throughout the fermentation. Bacteriocin activity could be found in the L. plantarum LPCO10-inoculated brines only after ammonium sulfate precipitation and concentration (20 times) of the final brine. Spontaneously occurring lactobacilli and lactic coccus populations, which were isolated from each of the fermenting brines studied during this investigation, were shown to be sensitive to the bacteriocins produced by L. plantarum LPCO10 when tested by the drop diffusion test. The declines in both pH and glucose levels throughout the fermentative process were similar in L. plantarum LPCO10- and in L. plantarum 55-1-inoculated brines and were comparable to the declines in the uninoculated brines. However, the final concentration of lactic acid in L. plantarum LPCO10-inoculated brines was higher than in the L. plantarum 55-1-inoculated brines and uninoculated brines. These results indicated that L. plantarum LPCO10 may be useful as a starter culture to control the lactic acid fermentation of Spanish-style green olives.     

<Emphasis Type="Italic">In situ</Emphasis> fermentation dynamics during production of <Emphasis Type="Italic">gundruk</Emphasis> and <Emphasis Type="Italic">khalpi</Emphasis>, ethnic fermented vegetable products of the Himalayas

Gundruk is a fermented leafy vegetable and khalpi is a fermented cucumber product, prepared and consumed in the Himalayas. In situ fermentation dynamics during production of gundruk and khalpi was studied. Significant increase in population of lactic acid bacteria (LAB) was found during first few days of gundruk and khlapi fermentation, respectively. Gundruk fermentation was initiated by Lactobacillus brevis, Pediococcus pentosaceus and finally dominated by Lb. plantarum. Similarly in khalpi fermentation, heterofermentative LAB such as Leuconostoc fallax, Lb. brevis and P. pentosaceus initiated the fermentation and finally completed by Lb. plantarum. Attempts were made to produce gundruk and khalpi using mixed starter culture of LAB previously isolated from respective products. Both the products prepared under lab condition had scored higher sensory-rankings comparable to market products.     

Overexpression and optimization of glutamate decarboxylase in Lactobacillus plantarum Taj‐Apis362 for high gamma‐aminobutyric acid production

Gamma‐aminobutyric acid (GABA) is an important bioactive compound biosynthesized by microorganisms through decarboxylation of glutamate by glutamate decarboxylase (GAD). In this study, a full‐length GAD gene was obtained by cloning the template deoxyribonucleic acid to pTZ57R/T vector. The open reading frame of the GAD gene showed the cloned gene was composed of 1410 nucleotides and encoded a 469 amino acids protein. To improve the GABA‐production, the GAD gene was cloned into pMG36e‐LbGAD, and then expressed in Lactobacillus plantarum Taj‐Apis362 cells. The overexpression was confirmed by SDS‐PAGE and GAD activity, showing a 53 KDa protein with the enzyme activity increased by sevenfold compared with the original GAD activity. The optimal fermentation conditions for GABA production established using response surface methodology were at glutamic acid concentration of 497.973 mM, temperature 36°C, pH 5.31 and time 60 h. Under the conditions, maximum GABA concentration obtained (11.09 mM) was comparable with the predicted value by the model at 11.23 mM. To our knowledge, this is the first report of successful cloning (clone‐back) and overexpression of the LbGAD gene from L. plantarum to L. plantarum cells. The recombinant Lactobacillus could be used as a starter culture for direct incorporation into a food system during fermentation for production of GABA‐rich products.     

<Emphasis Type="Italic">Lactobacillus plantarum</Emphasis> as a Probiotic Potential from Kouzeh Cheese (Traditional Iranian Cheese) and Its Antimicrobial Activity

The aim of this study is to isolate and identify Lactobacillus plantarum isolates from traditional cheese, Kouzeh, and evaluate their antimicrobial activity against some food pathogens. In total, 56 lactic acid bacteria were isolated by morphological and biochemical methods, 12 of which were identified as Lactobacillus plantarum by biochemical method and 11 were confirmed by molecular method. For analyzing the antimicrobial activity of these isolates properly, diffusion method was performed. The isolates were identified by 318 bp band dedicated for L. plantarum. The isolated L. plantarum represented an inhibitory activity against four of the pathogenic bacteria and showed different inhibition halos against each other. The larger halos were observed against Staphylococcus aureus and Staphylococcus epidermidis (15 ± 0.3 and 14.8 ± 0.7 mm, respectively). The inhibition halo of Escherichia coli was smaller than that of other pathogen and some L. plantarum did not show any inhibitory activity against E. coli, which were resistant to antimicrobial compounds produced by L. plantarum. The isolated L. plantarum isolates with the antimicrobial activity in this study had strong probiotic properties. These results indicated the nutritional value of Kouzeh cheese and usage of the isolated isolates as probiotic strains.     

Identification and Characterization of Leuconostoc fallax Strains Isolated from an Industrial Sauerkraut Fermentation

Lactic acid bacterial strains were isolated from brines sampled after 7 days of an industrial sauerkraut fermentation, and six strains were selected on the basis of susceptibility to bacteriophages. Bacterial growth in cabbage juice was monitored, and the fermentation end products were identified, quantified, and compared to those of Leuconostoc mesenteroides. Identification by biochemical fingerprinting, endonuclease digestion of the 16S-23S intergenic transcribed spacer region, and sequencing of variable regions V1 and V2 of the 16S rRNA gene indicated that the six selected sauerkraut isolates were Leuconostoc fallax strains. Random amplification of polymorphic DNA fingerprints indicated that the strains were distinct from one another. The growth and fermentation patterns of the L. fallax isolates were highly similar to those of L. mesenteroides. The final pH of cabbage juice fermentation was 3.6, and the main fermentation end products were lactic acid, acetic acid, and mannitol for both species. However, none of the L. fallax strains exhibited the malolactic reaction, which is characteristic of most L. mesenteroides strains. These results indicated that in addition to L. mesenteroides, a variety of L. fallax strains may be present in the heterofermentative stage of sauerkraut fermentation. The microbial ecology of sauerkraut fermentation appears to be more complex than previously indicated, and the prevalence and roles of L. fallax require further investigation.     

Characterization of Six Leuconostoc fallax Bacteriophages Isolated from an Industrial Sauerkraut Fermentation

Six bacteriophages active against Leuconostoc fallax strains were isolated from industrial sauerkraut fermentation brines. These phages were characterized as to host range, morphology, structural proteins, and genome fingerprint. They were exclusively lytic against the species L. fallax and had different host ranges among the strains of this species tested. Morphologically, three of the phages were assigned to the family Siphoviridae, and the three others were assigned to the family Myoviridae. Major capsid proteins detected by electrophoresis were distinct for each of the two morphotypes. Restriction fragment length polymorphism analysis and randomly amplified polymorphic DNA fingerprinting showed that all six phages were genetically distinct. These results revealed for the first time the existence of bacteriophages that are active against L. fallax and confirmed the presence and diversity of bacteriophages in a sauerkraut fermentation. Since a variety of L. fallax strains have been shown to be present in sauerkraut fermentation, bacteriophages active against L. fallax are likely to contribute to the microbial ecology of sauerkraut fermentation and could be responsible for some of the variability observed in this type of fermentation.     

Biodiversity of Lactobacillus plantarum from traditional Italian wines

In this study, 23 samples of traditional wines produced in Southern Italy were subjected to microbiological analyses with the aim to identify and biotype the predominant species of lactic acid bacilli. For this purpose, a multiple approach, consisting in the application of both phenotypic (API 50CHL test) and biomolecular methods (polymerase chain reaction-denaturing gradient gel electrophoresis and 16S rRNA gene sequencing) was used. The results showed that Lactobacillus plantarum was the predominant species, whereas Lb. brevis was detected in lower amount. In detail, out of 80 isolates 58 were ascribable to Lb. plantarum and 22 to Lb. brevis. Randomly amplified polymorphic DNA-polymerase chain reaction was used to highlight intraspecific variability among Lb. plantarum strains. Interestingly, the cluster analysis evidenced a relationship between different biotypes of Lb. plantarum and their origin, in terms of wine variety. Data acquired in this work show the possibility to obtain several malolactic fermentation starter cultures, composed by different Lb. plantarum biotypes, for their proper use in winemaking processes which are distinctive for each wine.     

Rapid identification of Lactobacillus plantarum group using the SNaPshot minisequencing assay

This study used SNaPshot minisequencing for species identification within the Lactobacillus plantarum group. A SNaPshot minisequencing assay using dnaK as a target gene was developed, and five SNP primers were designed by analysing the conserved regions of the dnaK sequences. The specificity of the minisequencing assay was evaluated using 35 strains of L. plantarum group species. The results showed that the SNaPshot minisequencing assay was able to unambiguously and simultaneously discriminate strains belonging to the species L. plantarum subsp. plantarum, L. plantarum subsp. argentoratensis, Lactobacillus paraplantarum, Lactobacillus pentosus and Lactobacillus fabifermentans. In conclusion, a rapid, accurate and cost-effective assay was successfully developed for species identification of the members of the L. plantarum group.     

Regulation of Lactobacillus plantarum contamination on the carbohydrate and energy related metabolisms of Saccharomyces cerevisiae during bioethanol fermentation

During the industrial bioethanol fermentation, Saccharomyces cerevisiae cells are often stressed by bacterial contaminants, especially lactic acid bacteria. Generally, lactic acid bacteria contamination can inhibit S. cerevisiae cell growth through secreting lactic acid and competing with yeast cells for micronutrients and living space. However, whether are there still any other influences of lactic acid bacteria on yeast or not? In this study, Lactobacillus plantarum ATCC 8014 was co-cultivated with S. cerevisiae S288c to mimic the L. plantarum contamination in industrial bioethanol fermentation. The contaminative L. plantarum-associated expression changes of genes involved in carbohydrate and energy related metabolisms in S. cerevisiae cells were determined by quantitative real-time polymerase chain reaction to evaluate the influence of L. plantarum on carbon source utilization and energy related metabolism in yeast cells during bioethanol fermentation. Contaminative L. plantarum influenced the expression of most of genes which are responsible for encoding key enzymes involved in glucose related metabolisms in S. cerevisiae. Specific for, contaminated L. plantarum inhibited EMP pathway but promoted TCA cycle, glyoxylate cycle, HMP, glycerol synthesis pathway, and redox pathway in S. cerevisiae cells. In the presence of L. plantarum, the carbon flux in S. cerevisiae cells was redistributed from fermentation to respiratory and more reducing power was produced to deal with the excess NADH. Moreover, L. plantarum contamination might confer higher ethanol tolerance to yeast cells through promoting accumulation of glycerol. These results also highlighted our knowledge about relationship between contaminative lactic acid bacteria and S. cerevisiae during bioethanol fermentation.