Cold Shock Induction of Thermal Sensitivity in Listeria monocytogenes

Cold shock at 0 to 15°C for 1 to 3 h increased the thermal sensitivity of Listeria monocytogenes. In a model broth system, thermal death time at 60°C was reduced by up to 45% after L. monocytogenes Scott A was cold shocked for 3 h. The duration of the cold shock affected thermal tolerance more than did the magnitude of the temperature downshift. The Z values were 8.8°C for controls and 7.7°C for cold-shocked cells. The D values of cold-shocked cells did not return to control levels after incubation for 3 h at 28°C followed by heating at 60°C. Nine L. monocytogenes strains that were cold shocked for 3 h exhibited D₆₀ values that were reduced by 13 to 37%. The D-value reduction was greatest in cold-shocked stationary-phase cells compared to cells from cultures in either the lag or exponential phases of growth. In addition, cold-shocked cells were more likely to be inactivated by a given heat treatment than nonshocked cells, which were more likely to experience sublethal injury. The D values of chloramphenicol-treated control cells and chloramphenicol-treated cold-shocked cells were no different from those of untreated cold-shocked cells, suggesting that cold shock suppresses synthesis of proteins responsible for heat protection. In related experiments, the D values of L. monocytogenes Scott A were decreased 25% on frankfurter skins and 15% in ultra-high temperature milk if the inoculated products were first cold shocked. Induction of increased thermal sensitivity in L. monocytogenes by thermal flux shows potential to become a practical and efficacious preventative control method.     

Effect of prior heat shock on heat resistance of Listeria monocytogenes in meat.

The effect of prior heat shock on the thermal resistance of Listeria monocytogenes in meat was investigated. A sausage mix inoculated with approximately 10(7) L. monocytogenes per g was initially subjected to a heat shock temperature of 48 degrees C before being heated at a final test temperature of 62 or 64 degrees C. Although cells heat shocked at 48 degrees C for 30 or 60 min did not show a significant increase in thermotolerance as compared with control cells (non-heat shocked), bacteria heat shocked for 120 min did, showing an average 2.4-fold increase in the D64 degrees C value. Heat-shocked cells shifted to 4 degrees C appeared to maintain their thermotolerance for at least 24 h after heat shock.     

Effect of prior heat shock on heat resistance of Listeria monocytogenes in meat

The effect of prior heat shock on the thermal resistance of Listeria monocytogenes in meat was investigated. A sausage mix inoculated with approximately 10(7) L. monocytogenes per g was initially subjected to a heat shock temperature of 48 degrees C before being heated at a final test temperature of 62 or 64 degrees C. Although cells heat shocked at 48 degrees C for 30 or 60 min did not show a significant increase in thermotolerance as compared with control cells (non-heat shocked), bacteria heat shocked for 120 min did, showing an average 2.4-fold increase in the D64 degrees C value. Heat-shocked cells shifted to 4 degrees C appeared to maintain their thermotolerance for at least 24 h after heat shock.     

Enhanced levels of cold shock proteins in Listeria monocytogenes LO28 upon exposure to low temperature and high hydrostatic pressure

Listeria monocytogenes is a psychrotrophic food-borne pathogen that is problematic for the food industry because of its ubiquitous distribution in nature and its ability to grow at low temperatures and in the presence of high salt concentrations. Here we demonstrate that the process of adaptation to low temperature after cold shock includes elevated levels of cold shock proteins (CSPs) and that the levels of CSPs are also elevated after treatment with high hydrostatic pressure (HHP). Two-dimensional gel electrophoresis combined with Western blotting performed with anti-CspB of Bacillus subtilis was used to identify four 7-kDa proteins, designated Csp1, Csp2, Csp3, and Csp4. In addition, Southern blotting revealed four chromosomal DNA fragments that reacted with a csp probe, which also indicated that a CSP family is present in L. monocytogenes LO28. After a cold shock in which the temperature was decreased from 37 degrees C to 10 degrees C the levels of Csp1 and Csp3 increased 10- and 3.5-fold, respectively, but the levels of Csp2 and Csp4 were not elevated. Pressurization of L. monocytogenes LO28 cells resulted in 3.5- and 2-fold increases in the levels of Csp1 and Csp2, respectively. Strikingly, the level of survival after pressurization of cold-shocked cells was 100-fold higher than that of cells growing exponentially at 37 degrees C. These findings imply that cold-shocked cells are protected from HHP treatment, which may affect the efficiency of combined preservation techniques.     

Cold shock and its effect on ribosomes and thermal tolerance in Listeria monocytogenes

Differential scanning calorimetry (DSC) and fatty acid analysis were used to determine how cold shocking reduces the thermal stability of Listeria monocytogenes. Additionally, antibiotics that can elicit production of cold or heat shock proteins were used to determine the effect of translation blockage on ribosome thermal stability. Fatty acid profiles showed no significant variations as a result of cold shock, indicating that changes in membrane fatty acids were not responsible for the cold shock-induced reduction in thermal tolerance. Following a 3-h cold shock from 37 to 0 degrees C, the maximum denaturation temperature of the 50S ribosomal subunit and 70S ribosomal particle peak was reduced from 73.4 +/- 0.1 degrees C (mean +/- standard deviation) to 72.1 +/- 0.5 degrees C (P < or = 0.05), indicating that cold shock induced instability in the associated ribosome structure. The maximum denaturation temperature of the 30S ribosomal subunit peak did not show a significant shift in temperature (from 67.5 +/- 0.4 degrees C to 66.8 +/- 0.5 degrees C) as a result of cold shock, suggesting that either 50S subunit or 70S particle sensitivity was responsible for the intact ribosome fragility. Antibiotics that elicited changes in maximum denaturation temperature in ribosomal components also elicited reductions in thermotolerance. Together, these data suggest that ribosomal changes resulting from cold shock may be responsible for the decrease in D value observed when L. monocytogenes is cold shocked.     

Survival of Listeria monocytogenes in sea water and effect of exposure on thermal resistance

Survival, recoverability and sublethal injury of two strains of Listeria monocytogenes , Scott A and an environmental strain KM, on exposure to sea water at 12·8 or 20·8 °C was determined using in situ diffusion chambers. Plate counts were used to assess recoverability and injury while 5-cyano-2,3-ditolyl tetrazolium chloride (CTC) reduction was used to determine respiratory activity. T₉₀ values (times for 10-fold decreases in numbers of recoverable cells) on non-selective medium (trypticase soya agar with 0·6% yeast extract) at 12·8 and 20·8 °C were 61·7 and 69·2 h for L. monocytogenes Scott A, and 103·0 and 67·0 h for L. monocytogenes KM, respectively. On selective medium (Oxford agar), T₉₀ values at 12·8 and 20·8 °C were 60·6 and 56·9 h for L. monocytogenes Scott A, and 83·0 and 65·9 h for L. monocytogenes KM, respectively. With Scott A, the percentage of sublethally injured cells at 12·8 and 20·8 °C was 1·7 and 17·7%, respectively, while for KM the values were 19·0 and 1·6%, respectively. The fraction of cells reducing CTC but which were not recoverable on plating progressively increased on exposure to sea water. Listeria monocytogenes KM challenged at 58 °C showed an apparent increase in heat resistance after exposure to sea water at 20·8 °C for 7 d ( D ₅₈= 2·64 min) compared with before exposure ( D ₅₈= 1·24). This increase in thermal resistance was not apparent at temperatures greater than 63 °C, and analysis of the best-fit regression lines fitted to the thermal data obtained from the two cell populations indicated that their thermal resistance was not significantly different ( P > 0·05) over the temperature range tested (58–62 °C).     

Expression of heat shock and cold shock proteins in the gorgonian Leptogorgia virgulata

In this study, we analyzed the response of the temperate, shallow-water gorgonian, Leptogorgia virgulata, to temperature stress. Proteins were pulse labeled with (35)S-methionine/cysteine for 1 h to 2 h at 22 degrees C (control), or 38 degrees C, or for 4 h at 12.5 degrees C. Heat shock induced synthesis of unique proteins of 112, 89, and 74 kDa, with 102, 98 and 56 kDa proteins present in the control as well. Cold shock from 22 degrees C-12.5 degrees C induced the synthesis of a 25 kDa protein, with a 44 kDa protein present in the control as well. Control samples expressed unique proteins of 38, and 33 kDa. Non-radioactive proteins expressed under the same conditions as above, as well as natural field conditions, were tested for reactivity with antibodies to heat shock proteins (HSPs). HSP60 was the major protein found in L. virgulata. Although HSP47, HSP60, and HSP104 were present in all samples, the expression of HSP60 was enhanced in heat stressed colonies, while HSP47 and HSP104 expression were greatest in cold shocked samples. Inducible HSP70 was expressed in cold-shocked, heat-shocked, and field samples. Constitutively expressed HSP70 was absent from all samples. The expression of HSP90 was limited to heat shocked colonies. The expression of both HSP70 and HSP104 suggests that the organism may also develop a stress tolerance response.     

Effects of growth temperature and strictly anaerobic recovery on the survival of Listeria monocytogenes during pasteurization.

Listeria monocytogenes F5069 was suspended in either Trypticase soy broth-0.6% yeast extract (TSBYE) or sterile, whole milk and heated at 62.8 degrees C in sealed thermal death time tubes. Severely heat-injured cells were recovered in TSBYE within sealed thermal death time tubes because of the formation of reduced conditions in the depths of the TSBYE. Also, the use of strictly anaerobic Hungate techniques significantly increased recovery in TSBYE containing 1.5% agar compared with aerobically incubated controls. The exogenous addition of catalase, but not superoxide dismutase, slightly increased the recovery of heat-injured cells in TSBYE containing 1.5% agar incubated aerobically. Growth of cells at 43 degrees C caused a greater increase in heat resistance as compared with cells heat shocked at 43 degrees C or cells grown at lower temperatures. Growth of L. monocytogenes at 43 degrees C and enumeration by the use of strictly anaerobic Hungate techniques resulted in D62.8 degrees C values that were at least sixfold greater than those previously obtained by using cells grown at 37 degrees C and aerobic plating. Results indicate that, under the conditions of the present study, high levels of L. monocytogenes would survive the minimum low-temperature, long-time treatment required by the U.S. Food and Drug Administration for pasteurizing milk. The possible survival of low levels of L. monocytogenes during high-temperature, short-time pasteurization and enumeration of injured cells by recovery on selective media under strictly anaerobic conditions are discussed.     

Effects of growth temperature and strictly anaerobic recovery on the survival of Listeria monocytogenes during pasteurization

Listeria monocytogenes F5069 was suspended in either Trypticase soy broth-0.6% yeast extract (TSBYE) or sterile, whole milk and heated at 62.8 degrees C in sealed thermal death time tubes. Severely heat-injured cells were recovered in TSBYE within sealed thermal death time tubes because of the formation of reduced conditions in the depths of the TSBYE. Also, the use of strictly anaerobic Hungate techniques significantly increased recovery in TSBYE containing 1.5% agar compared with aerobically incubated controls. The exogenous addition of catalase, but not superoxide dismutase, slightly increased the recovery of heat-injured cells in TSBYE containing 1.5% agar incubated aerobically. Growth of cells at 43 degrees C caused a greater increase in heat resistance as compared with cells heat shocked at 43 degrees C or cells grown at lower temperatures. Growth of L. monocytogenes at 43 degrees C and enumeration by the use of strictly anaerobic Hungate techniques resulted in D62.8 degrees C values that were at least sixfold greater than those previously obtained by using cells grown at 37 degrees C and aerobic plating. Results indicate that, under the conditions of the present study, high levels of L. monocytogenes would survive the minimum low-temperature, long-time treatment required by the U.S. Food and Drug Administration for pasteurizing milk. The possible survival of low levels of L. monocytogenes during high-temperature, short-time pasteurization and enumeration of injured cells by recovery on selective media under strictly anaerobic conditions are discussed.     

Effects of several factors on the heat-shock-induced thermotolerance of Listeria monocytogenes.

The influence of the temperature at which Listeria monocytogenes had been grown (4 or 37 degrees C) on the response to heat shocks of different durations at different temperatures was investigated. For cells grown at 4 degrees C, the effect of storage, prior to and after heat shock, on the induced thermotolerance was also studied. Death kinetics of heat-shocked cells is also discussed. For L. monocytogenes grown at 37 degrees C, the greatest response to heat shock was a fourfold increase in thermotolerance. For L. monocytogenes grown at 4 degrees C, the greatest response to heat shock was a sevenfold increase in thermotolerance. The only survival curves of cells to have shoulders were those for cells that had been heat shocked. A 3% concentration of sodium chloride added to the recovery medium made these shoulders disappear and decreased decimal reduction times. The percentage of cells for which thermotolerance increased after a heat shock was smaller the milder the heat shock and the longer the prior storage.     

Enhanced thermal destruction of Listeria monocytogenes and Staphylococcus aureus by the lactoperoxidase system

The lactoperoxidase system (LPS) enhanced thermal destruction of Listeria monocytogenes and Staphylococcus aureus. After LPS activation, biphasic survival curves were observed for L. monocytogenes at 57.8 degrees C and for S. aureus at 55.2 degrees C. The data were consistent with a model that assumed two bacterial populations differing in heat sensitivity. The more heat-sensitive fractions (93% of the L. monocytogenes, 92% of the S. aureus) were killed almost instantly. For these biphasic survival curves, D values were based on the much smaller, less-heat-sensitive fractions. For L. monocytogenes, the D52.2 degrees C values were 30.2 min (untreated milk) and 10.7 min (LPS activated); corresponding D55.2 degrees C values were 8.2 and 1.6 min; corresponding D57.8 degrees C values were 2.3 and 0.5 min. For S. aureus, the D52.2 degrees C values were 33.3 min (untreated milk) and 2.2 min (LPS activated), and the corresponding D55.2 degrees C values were 7.6 and 1.1 min, respectively. The most rapid killing of L. monocytogenes occurred when samples were heated soon after activation of the LPS. Activation of the LPS followed by heating can increase the margin of safety with respect to milkborne pathogens.     

Enhanced thermal destruction of Listeria monocytogenes and Staphylococcus aureus by the lactoperoxidase system.

The lactoperoxidase system (LPS) enhanced thermal destruction of Listeria monocytogenes and Staphylococcus aureus. After LPS activation, biphasic survival curves were observed for L. monocytogenes at 57.8 degrees C and for S. aureus at 55.2 degrees C. The data were consistent with a model that assumed two bacterial populations differing in heat sensitivity. The more heat-sensitive fractions (93% of the L. monocytogenes, 92% of the S. aureus) were killed almost instantly. For these biphasic survival curves, D values were based on the much smaller, less-heat-sensitive fractions. For L. monocytogenes, the D52.2 degrees C values were 30.2 min (untreated milk) and 10.7 min (LPS activated); corresponding D55.2 degrees C values were 8.2 and 1.6 min; corresponding D57.8 degrees C values were 2.3 and 0.5 min. For S. aureus, the D52.2 degrees C values were 33.3 min (untreated milk) and 2.2 min (LPS activated), and the corresponding D55.2 degrees C values were 7.6 and 1.1 min, respectively. The most rapid killing of L. monocytogenes occurred when samples were heated soon after activation of the LPS. Activation of the LPS followed by heating can increase the margin of safety with respect to milkborne pathogens.     

Catalase and superoxide dismutase activities after heat injury of Listeria monocytogenes

Four strains of Listeria monocytogenes were examined for catalase (CA) and superoxide dismutase (SOD) activities. The two strains having the highest CA activities (LCDC and Scott A) also possessed the highest SOD activities. The CA activity of heated cell extracts of all four strains examined decreased sharply between 55 and 60 degrees C. SOD was more heat labile than CA. Two L. monocytogenes strains demonstrated a decline in SOD activity after heat treatment at 45 degrees C, whereas the other two strains demonstrated a decline at 50 degrees C. Sublethal heating of the cells at 55 degrees C resulted in increased sensitivity to 5.5% NaCl. Exogenous hydrogen peroxide was added to suspensions of L. monocytogenes; strains producing the highest CA levels showed the greatest H2O2 resistance.     

Catalase and superoxide dismutase activities after heat injury of Listeria monocytogenes.

Four strains of Listeria monocytogenes were examined for catalase (CA) and superoxide dismutase (SOD) activities. The two strains having the highest CA activities (LCDC and Scott A) also possessed the highest SOD activities. The CA activity of heated cell extracts of all four strains examined decreased sharply between 55 and 60 degrees C. SOD was more heat labile than CA. Two L. monocytogenes strains demonstrated a decline in SOD activity after heat treatment at 45 degrees C, whereas the other two strains demonstrated a decline at 50 degrees C. Sublethal heating of the cells at 55 degrees C resulted in increased sensitivity to 5.5% NaCl. Exogenous hydrogen peroxide was added to suspensions of L. monocytogenes; strains producing the highest CA levels showed the greatest H2O2 resistance.     

Expression of cellular antigens of Listeria monocytogenes that react with monoclonal antibodies C11E9 and EM-7G1 under acid-, salt- or temperature-induced stress environments

AIMS: To study the expression of cellular antigens of Listeria monocytogenes that react with monoclonal antibodies (MAbs) C11E9 and EM-7G1 under acid-, salt- or temperature-induced stress environments. METHODS AND RESULTS: The reaction patterns of antibodies to L. monocytogenes held in stressful environments for a short duration (3 h) or grown for extended periods (16-72 h) were investigated. During both short or prolonged exposure to stress environments of high temperature (45 degrees C) and NaCl (>1.5%, w/v), reactions of whole cells of L. monocytogenes to antibodies were severely affected as determined by ELISA and by the reduced expression of the antibody-reactive 66 kDa antigen in the Western blot assay. Conversely, cold (4-15 degrees C) or acid (pH 2-3) stress environments had very little effect on antigen expression or antibody reaction. Additionally, heat-killed cells showed reduced reactions to these antibodies when compared with unheated cells. Artificially created stress environments in hotdog slurry also affected the antigen expression in L. monocytogenes. Immunoelectron microscopy revealed that the antibody-reactive antigens were uniformly present on the surface of the cells. Morphological characteristics following growth in stressed environments revealed that heat stress at 45 degrees C caused L. monocytogenes cells to be elongated and to form clumps; whereas, osmotic stress (5.5% NaCl, w/v) caused filamentous appearance with multiple septa along the length of the cell. CONCLUSIONS: These results indicated that MAb C11E9 or EM-7G1 could detect L. monocytogenes from cold or acid-stress environments; however, they may show weaker reactions with heat or osmotically stressed cells or cells grown at 4 degrees C. SIGNIFICANCE AND IMPACT OF THE STUDY: Bacteria in food are routinely subjected to various stresses, induced by cold, heat, salt or acid during processing and storage. Whether stresses would modify the expression of cellular antigens of L. monocytogenes is of a great concern for immunodetections in food products.     

Growth of Listeria monocytogenes at different pH values in uncultured whey or whey cultured with Penicillium camemberti

Wheys from making Camembert cheese were either uncultured or cultured with Penicillium camemberti, adjusted to pH 5.0, 5.2, 5.4, 5.6, 6.2, and 6.8, and filter sterilized. Whey samples were inoculated to contain 100 to 500 Listeria monocytogenes (strains Scott A, V7, CA, or OH) cfu/mL and incubated at 6 degrees C. Counts of L. monocytogenes were obtained by surface plating appropriate dilutions on Tryptose Agar. Listeria monocytogenes failed to grow at or below pH 5.4; except for strains Scott A and OH which grew in cultured whey at pH 5.4 and attained populations of 7.8 x 10(3) and 5.4 x 10(4) cfu/mL, respectively, after 35 d of storage. In uncultured whey at pH 5.6, 6.2, and 6.8, populations of L. monocytogenes increased from 7.20 to 7.81, 7.51 to 8.23, and 7.48 to 8.08 log10 cfu/mL, respectively, after 35 d of storage at 6 degrees C. In cultured whey at pH 5.6, 6.2, and 6.8, numbers of L. monocytogenes increased from 7.53 to 8.13, 7.82 to 8.55, and 7.95 to 8.80 log10 cfu/mL, respectively, after 35 d of storage. Generation times for L. monocytogenes at 6 degrees C in uncultured whey at pH 5.6, 6.2, and 6.8 ranged between 25.3 and 31.6 h, 14.8 and 21.1 h, and 14.0 and 19.4 h, respectively, depending on the Listeria strain. In contrast, generation times were significantly (p less than 0.05) shorter in cultured whey and ranged between 16.6 and 27.4 h, 10.3 and 16.6 h, and 17.4 and 16.3 h at pH values of 5.6, 6.2, and 6.8, respectively.     

Different cellular fatty acid pattern behaviours of two strains of Listeria monocytogenes Scott A and CNL 895807 under different temperature and salinity conditions

Cells of two strains of Listeria monocytogenes CNL 895807 and Scott A were grown to late exponential phase at different growth temperatures (37, 20 and 4 degrees C) with or without NaCl (7%), and their fatty acid compositions were analysed. The results showed that low thermal adaptation response of L. monocytogenes CNL was different than that of the Scott A strain, and it was based on both an increase of anteiso-branched-chain fatty acids and a significant decrease of straight-chain fatty acids. However, the main modifications observed in the Scott A strain when grown at a low temperature were a decrease of the proportion of ai17:0 and an increase of ai15:0. In hyperosmotic medium and over the entire temperature range (4 degrees C, 20 degrees C and 37 degrees C) the two L. monocytogenes strains showed a cellular fatty acid profile dominated by ai15:0. In addition, a decrease of the two major straight-chain fatty acids (14:0 and 16:0) was observed in the CNL strain. These results demonstrated that the CNL strain showed different behaviours of low thermal and salt adaptation to maintain membrane fluidity, which are based both on an increase of anteiso-branched-chain fatty acids, and a significant decrease of straight-chain fatty acids.     

A proposed nonpathogenic biological indicator for thermal inactivation of Listeria monocytogenes.

Listeria innocua M1 was developed as a thermal processing indicator organism for L. monocytogenes by selection of a rifampin- and streptomycin-resistant mutant. zetaD values were 5.6 and 5.8 degrees C, and D (68 degrees C) values were 3.8 and 4.9 s for L. monocytogenes and L. innocua, respectively, in skim milk. The advantages of easy selection, similar heat resistance, and nonpathogenicity make L. innocua M1 appropriate for challenge studies designed to evaluate process lethality with respect to L. monocytogenes.