Effect of fatty acid substrate chain length on Pseudomonas aeruginosa ATCC 9027 monorhamnolipid yield and congener distribution

Rhamnolipids are surface-active molecules produced by Pseudomonas aeruginosa as congener mixtures. They are considered “green” alternatives to synthetic surfactants used in industrial, remediation and pharmaceutical applications. Optimizing yield as well as controlling congener distribution are necessary steps for successful commercialization of rhamnolipids. This study used a mixture of glucose and fatty acids of different chain length (C₁₂–C₂₂) and saturation (C_18:1 and C_18:2) to produce monorhamnolipids and determine the effect of fatty acid substrates on rhamnolipid yield, percent carbon conversion and congener distribution. Results show that 1% glucose + 0.25% stearic acid (C₁₈) produced the greatest yield (2.1 g L⁻¹) compared to other glucose–fatty acid combinations (0.8–1.8 g L⁻¹). Various glucose + C₁₈ ratios were then tested to optimize yield and percent substrate carbon conversion to monorhamnolipid. Results revealed a positive linear correlation between the mass percent of C₁₈ used and the percent carbon conversion. A mass percent of 67% C₁₈ was optimal resulting in a 44% carbon conversion and a yield of 13.7 g L⁻¹ monorhamnolipid. For all fatty acid substrates tested, the RhaC₁₀C₁₀ was the most abundant and RhaC₁₀C_12:1 was the least abundant of the four major congeners produced. However, the relative amount of RhaC₁₀C₈ and RhaC₁₀C₁₂ congeners was dependent on several factors: in general, fatty acid substrates with relatively short chain length (C₁₂ and C₁₄), unsaturated fatty acid substrate (_C18:2), and longer cultivation time resulted in a higher RhaC₁₀C₈/RhaC₁₀C₁₂ ratio. These findings will assist in mass production of monorhamnolipids and controlling the specific congeners produced.     

Characterization of the lipA gene encoding the major lipase from Pseudomonas aeruginosa strain IGB83

The lipases produced by Pseudomonas have a wide range of potential biotechnological applications. Pseudomonas aeruginosa IGB83 was isolated as a highly lipolytic strain which produced a thermotolerant and alkaline lipase. In the present work, we have characterized the P. aeruginosa IGB83 gene (lipA) encoding this enzyme. We describe the construction of a lipA mutant and report on the effect of two carbon sources on lipase expression.     

Cloning of Escherichia coli and Pseudomonas aeruginosa phosphomannose isomerase genes and their expression in alginate-negative mutants of Pseudomonas aeruginosa.

The phosphomannose isomerase (pmi) gene of Escherichia coli was cloned on a broad-host-range cosmid vector and expressed in Pseudomonas aeruginosa at a low level. Plasmid pAD3, which harbors the E. coli pmi gene, contains a 6.2-kilobase-pair HindIII fragment derived from the chromosome of E. coli. Subcloning produced plasmids carrying the 1.5-kilobase-pair HindIII-HpaI subfragment of pAD3 that restored alginic acid production in a nonmucoid, alginate-negative mutant of P. aeruginosa. This fragment also complemented mannose-negative, phosphomannose isomerase-negative mutants of E. coli and showed no homology by DNA-DNA hybridization to P. aeruginosa chromosomal DNA. By using a BamHI constructed cosmid clone bank of the stable alginate producing strain 8830, we have been able to isolate a recombinant plasmid of P. aeruginosa origin that also restores alginate production in the alginate-negative mutant. This new recombinant plasmid, designated pAD4, contained a 9.9-kilobase-pair EcoRI-BamHI fragment with the ability to restore alginate synthesis in the alginate-negative P. aeruginosa. This fragment showed no homology to E. coli chromosomal DNA or to plasmid pAD3. Both mucoid and nonmucoid strains of P. aeruginosa had no detectable levels of phosphomannose isomerase activity as measured by mannose 6-phosphate-to-fructose 6-phosphate conversion. However, P. aeruginosa strains harboring the cloned pmi gene of E. coli contained measurable levels of phosphomannose isomerase activity as evidenced by examining the conversion of mannose 6-phosphate to fructose 6-phosphate.     

Isolation, organization and expression of the Pseudomonas aeruginosa threonine genes

Three genes from Pseudomonas aeruginosa involved in threonine biosynthesis, hom, thrB and thrC, encoding homoserine dehydrogenase (HDH), homoserine kinase (HK) and threonine synthase (TS), respectively, have been cloned and sequenced. The hom and thrc genes lie at the thr locus of the P. aeruginosa chromosome map (31 min) and are likely to be organized in a bicistronic operon. The encoded proteins are quite similar to the Hom and TS proteins from other bacterial species. The thrB gene was located by pulsed-field gel electrophoresis experiments at 10 min on the chromosome map. The product of this gene does not share any similarity with other known ThrB proteins. No phenotype could be detected when the chromosomal thrB gene was inactivated by an insertion. Therefore the existence of isozymes for this activity is postulated. HDH activity was feedback inhibited by threonine; the expression of all three genes was constitutive. The overall organization of these three genes appears to differ from that in other bacterial species.     

Quorum-sensing genes in Pseudomonas aeruginosa biofilms: their role and expression patterns

Acylated homoserine lactone molecules are used by a number of gram-negative bacteria to regulate cell density-dependent gene expression by a mechanism known as quorum sensing (QS). In Pseudomonas aeruginosa, QS or cell-to-cell signaling controls expression of a number of virulence factors, as well as biofilm differentiation. In this study, we investigated the role played by the las and rhl QS systems during the early stages of static biofilm formation when cells are adhering to a surface and forming microcolonies. These studies revealed a marked difference in biofilm formation between the PAO1 parent and the QS mutants when glucose, but not citrate, was used as the sole carbon source. To further elucidate the contribution of lasI and rhlI to biofilm maturation, we utilized fusions to unstable green fluorescent protein in concert with confocal microscopy to perform real-time temporal and spatial studies of these genes in a flowing environment. During the course of 8-day biofilm development, lasI expression was found to progressively decrease over time. Conversely, rhlI expression remained steady throughout biofilm development but occurred in a lower percentage of cells. Spatial analysis revealed that lasI and rhlI were maximally expressed in cells located at the substratum and that expression decreased with increasing biofilm height. Because QS was shown previously to be involved in biofilm differentiation, these findings have important implications for the design of biofilm prevention and eradication strategies.     

Adsorption of monorhamnolipid and dirhamnolipid on two <Emphasis Type="Italic">Pseudomonas aeruginosa</Emphasis> strains and the effect on cell surface hydrophobicity

Previously, adsorption feature of a dirhamnolipid biosurfactant on diverse microbial cells was studied and the effect of the adsorption on cell surface hydrophobicity was compared. In this paper, the adsorption behavior of a monorhamnolipid and a dirhamnolipid on cells of two Pseudomonas aeruginosa strains was investigated in order to further reveal the influence of biosurfactant structure and cell property on the adsorption and the relation between the adsorption and cell surface hydrophobicity. Experimental results showed that the adsorption capacity of all the cells to monorhamnolipid was much stronger than to dirhamnolipid, and the rhamnolipid-sourced P. aeruginosa cells, no matter grown on glucose or hexadecane, released extra dirhamnolipid when aqueous concentration of dirhamnolipid was too high. Length of surfactant alkyl chain as well as the type of carbon source used to cultivate the cell adsorbents had only minor influence on the adsorption. The adsorption was assumed to be driven by polar interaction between the rhamnolipid molecules and the cell surface chemical groups. The directional orientation of the rhamnolipid molecules with hydrophobic moiety extending to the environment may account for the rapid increase of cell surface hydrophobicity at low aqueous concentrations of the surfactant, while the stable or decreased cell hydrophobicity was probably the consequence of multiple surfactant layer formation or hemimicelle accumulation.     

铜绿假单胞菌必需基因的研究进展

铜绿假单胞菌为专性需氧非发酵革兰氏阴性杆菌,是医院感染的常见条件致病菌之一,可引起呼吸道、泌尿道、烧伤创面和菌血症等严重感染.铜绿假单胞菌耐药形势日益严峻,给临床治疗带来困难.必需基因是生长过程中必不可少的看家基因,对铜绿假单胞菌必需基因进行深入研究,不仅有助于了解细菌的生长、毒力等基本特性,也有助于筛选新的抗菌药物靶...     

Modulation of the physical properties of dielaidoylphosphatidylethanolamine membranes by a dirhamnolipid biosurfactant produced by Pseudomonas aeruginosa

Rhamnolipids are bacterial biosurfactants produced by Pseudomonas spp. These compounds have been shown to present several interesting biological activities, restricting the growth of Bacillus subtilis and showing zoosporicidal activity on zoosporic phytopathogens. It has been suggested that the interaction with the membrane could be the ultimate responsible for these actions. Therefore, it is of great interest to get insight into the molecular mechanism of the interaction of purified rhamnolipids with the various phospholipid components of biological membranes. In this paper we report on the phase behaviour of mixtures of dielaidoylphosphatidylethanolamine (DEPE) with a purified dirhamnolipid (DiRL) fraction from Pseudomonas aeruginosa, as studied by a number of physical techniques such as differential scanning calorimetry, FTIR, small angle X-ray (SAX) diffraction and dynamic light scattering. Our data indicate that the presence of DiRL counteracts the tendency of DEPE to form vesicular aggregates of large size, forming vesicles of smaller diameter which most probably have a lower lamellarity index. The partial phase diagram obtained from calorimetric data shows a complex behaviour with a solid-phase immiscibility. X-ray diffraction shows that DiRL has a bilayer stabilizing effect, impeding formation of the inverted hexagonal-HII phase of DEPE. The presented data are discussed focussing into how DiRL/DEPE interactions could help to explain the membrane perturbing activities of this biosurfactant.     

Heterologous expression and regulation of the lysA genes of Pseudomonas aeruginosa and Escherichia coli

Summary Chlorsulfuron-resistant mutants of Arabidopsis thaliana were isolated by screening for growth of seedlings in the presence of the herbicide. Both whole plants and derived tissue cultures were resistant to concentrations of the herbicide approximately 300-fold higher than that required to prevent growth of the wild-type. The resistance is due to a single dominant nuclear mutation at a locus designated csr which has been genetically mapped to chromosome-3. Acetohydroxy acid synthase activity in extracts from chlorsulfuron-resistant plants was much less-susceptible to inhibition by chlorsulfuron and a structurally related inhibitor than the activity in wild-type extracts. This suggests that the csr locus is the structural gene for acetohydroxy acid synthase.     

Cloning and characterization of chemotaxis genes in Pseudomonas aeruginosa

Two chemotaxis-defective mutants of Pseudomonas aeruginosa, designated PC3 and PC4, were selected by the swarm plate method after N-methyl-N'-nitro-N-nitrosoguanidine mutagenesis. These mutants were not complemented by the P. aeruginosa cheY and cheZ genes, which had been previously cloned (Masduki et al., J. Bacteriol., 177, 948-952, 1995). DNA sequences downstream of the cheY and cheZ genes were able to complement PC3 but not PC4. Sequence analysis of a 9.7-kb region directly downstream of the cheZ gene found three chemotaxis genes, cheA, cheB, and cheW, and seven unknown open reading frames (ORFs). The predicted translation products of the cheA, cheB, and cheW genes showed 33, 36, and 31% amino acid identity with Escherichia coli CheA, CheB, and CheW, respectively. Two of the unknown ORFs, ORF1 and ORF2, encoded putative polypeptides that resembled Bacillus subtilis MotA (40% amino acid identity) and MotB (34% amino acid identity) proteins, respectively. Although P. aeruginosa was found to have proteins similar to the enteric chemotaxis proteins CheA, CheB, CheW, CheY, and CheZ, the gene encoding a CheR homologue did not reside in the chemotaxis gene cluster. The P. aeruginosa cheR gene could be cloned by phenotypic complementation of the PC4 mutant. This gene was located at least 1,800 kb away from the chemotaxis gene cluster and encoded a putative polypeptide that had 32% amino acid identity with E. coli CheR.