Sorbitol co-feeding reduces metabolic burden caused by the overexpression of a Rhizopus oryzae lipase in Pichia pastoris

To improve the specific production rate of Rhizopus oryzae lipase (ROL) in Pichia pastoris, a protein that triggers the unfolded protein response in P. pastoris, the effect of sorbitol/methanol mixed substrates was tested in batch and fed-batch cultures. Remarkably, a different substrate consumption behaviour was observed depending on the host's phenotype (Mut(+) or Mut(s)) in batch cultures: when the methanol assimilation capacity is genetically reduced (Mut(s) phenotype), both substrates were consumed simultaneously, allowing not only a higher specific growth rate but also higher lipase levels (8.7-fold) compared to those obtained by cells growing on methanol as a sole carbon source in batch culture. This effect was not observed in Mut(+) phenotype, where the two substrates were consumed sequentially and the levels of heterologous product were only slightly higher (1.7-fold). A mixed substrate strategy was also applied to a Mut(s) fed-batch culture at a low methanol concentration set-point (0.5 gl(-1)). This resulted in a 2.2-fold increase in the heterologous protein level achieved, compared with the methanol-only feeding strategy. In addition, sorbitol co-feeding permitted the achievement of higher specific growth rates, and avoided the drastic decrease of the specific production rate observed after the start of the induction phase when methanol was used as sole carbon source This resulted in a significant increase in the overall bioprocess volumetric productivity (2.2-fold) and specific productivity (1.7-fold). Moreover, whereas increased ROL gene dosage in Mut(s) strains have been previously reported to be deleterious for P. pastoris cells growing on methanol, sorbitol co-feeding allowed for sustained cell growth and lipase production.     

Expression of a Rhizopus oryzae lipase in Pichia pastoris under control of the nitrogen source-regulated formaldehyde dehydrogenase promoter

A Rhizopus oryzae lipase gene has been expressed in Pichia pastoris as a reporter using the formaldehyde dehydrogenase 1 promoter (PFLD1) of this organism, which has been reported to be strongly and independently induced by either methanol as sole carbon source or methylamine as sole nitrogen source. Levels of lipase expressed and secreted under the control of the PFLD1 at different induction conditions have been compared to those obtained with the commonly used alcohol oxidase 1 promoter (PAOX1) in small (shake flask) and 1l bioreactor batch cultures. PFLD1-controlled heterologous gene expression was strongly repressed by excess of either glycerol or glucose-but not sorbitol-during growth using methylamine both as sole nitrogen source and inducing substrate. Co-induction of PFLD1 with methanol and methylamine resulted in a synergistic effect on extracellular lipase expression levels. In all tested conditions, the substitution of ammonium for methylamine as carbon source provoked a clear decrease in the specific growth rate and yield of biomass per gram of carbon source. Overall, this study demonstrates that the PFLD1 promoter is at least as efficient as the PAOX1 for extracellular expression of heterologous proteins in P. pastoris bioreactor cultures and provides a first basis for the further design of methanol-free high cell density fed-batch cultivation strategies for controlled overproduction of foreign proteins in P. pastoris.     

Influence of specific growth rate on specific productivity and glycosylation of a recombinant avidin produced by a Pichia pastoris Mut+ strain

A recombinant avidin-producing Mut+ Pichia pastoris strain was used as a model organism to study the influence of the methanol feeding strategy on the specific product productivity (q(p)) and protein glycosylation. Fed-batch cultivations performed at various specific growth rates (micro) and residual methanol concentrations showed that the specific avidin productivity is growth-dependent. The specific productivity increases strongly with the specific growth rate for micro ranging from 0 to 0.02 h(-1), and increases only slightly with the specific growth rate above this limit. N-terminal glycosylation was also found to be influenced by the specific growth rate, since 9-mannose glycans were the most abundant form at low growth rates, whereas 10-mannose carbohydrate chains were favored at higher micro. These results show that culture parameters, such as the specific growth rate, may significantly affect the activity of glycoproteins produced in Pichia pastoris. In terms of process optimization, this suggests that a compromise on the specific growth rate may have to be found, in certain cases, to work with an acceptable productivity while avoiding the addition of many mannoses.     

Cell bank characterization and fermentation optimization for production of recombinant heavy chain C-terminal fragment of botulinum neurotoxin serotype E (rBoNTE(H(c)): antigen E) by Pichia pastoris

A process was developed for production of a candidate vaccine antigen, recombinant C-terminal heavy chain fragment of the botulinum neurotoxin serotype E, rBoNTE(H(c)) in Pichia pastoris. P. pastoris strain GS115 was transformed with the rBoNTE(H(c)) gene inserted into pHILD4 Escherichia coli-P. pastoris shuttle plasmid. The clone was characterized for genetic stability, copy number, and BoNTE(H(c)) sequence. Expression of rBoNTE(H(c)) from the Mut(+) HIS4 clone was confirmed in the shake-flask, prior to developing a fed-batch fermentation process at 5 and 19 L scale. The fermentation process consists of a glycerol growth phase in batch and fed-batch mode using a defined medium followed by a glycerol/methanol transition phase for adaptation to growth on methanol and a methanol induction phase resulting in the production of rBoNTE(H(c)). Specific growth rate, ratio of growth to induction phase, and time of induction were critical for optimal rBoNTE(H(c)) production and minimal proteolytic degradation. A computer-controlled exponential growth model was used for process automation and off-gas analysis was used for process monitoring. The optimized process had an induction time of 9 h on methanol and produced up to 3 mg of rBoNTE(H(c)) per gram wet cell mass as determined by HPLC and Western blot analysis.     

Modeling Pichia pastoris growth on methanol and optimizing the production of a recombinant protein, the heavy-chain fragment C of botulinum neurotoxin, serotype A

An unstructured growth model for the recombinant methylotrophic yeast P. pastoris Mut(+) expressing the heavy-chain fragment C of botulinum neurotoxin serotype A [BoNT/A(H(c))], was successfully established in quasi-steady state fed-batch fermentations with varying cell densities. The model describes the relationships between specific growth rate and methanol concentration, and the relationships between specific methanol and ammonium consumption rates and specific growth rate under methanol-limited growth conditions. The maximum specific growth rate (mu) determined from the model was 0.08 h(-1) at a methanol concentration of 3.65 g/L, while the actual maximum mu was 0.0709 h(-1). The maximum specific methanol consumption rate was 0.0682 g/g WCW/h. From the model, growth can be defined as either methanol-limited or methanol-inhibited and is delineated at a methanol concentration of 3.65 g/L. Under inhibited conditions, the observed biomass yield (Y(X/MeOH)) was lower and the maintenance coefficient (m(MeOH)) was higher than compared to limited methanol conditions. The Y(X/MeOH) decreased and m(MeOH) increased with increasing methanol concentration under methanol-inhibited conditions. BoNT/A(H(c)) content in cells (alpha) under inhibited growth was lower than that under limited growth, and decreased with increasing methanol concentration. A maximum alpha of 1.72 mg/g WCW was achieved at a mu of 0.0267 h(-1) and induction time of 12 h.     

混合碳源流加对重组毕赤酵母生产碱性果胶酶的影响

为提高重组毕赤酵母生产碱性果胶酶(PGL)的产量和生产强度,在诱导期采用多种碳源与甲醇混合添加的模式。实验结果发现:甘油、山梨醇、乳酸与甲醇的混合添加均可以提高PGL的产量,其中山梨醇与甲醇的混合流加效果最为显著。研究表明,通过双碳源混合流加可以提高细胞活力,增强醇氧化酶活力,提高毕赤酵母表达外源蛋白效率。当山梨醇的流速为3.6g/(h·L)时,PGL酶活可达1593U/mL,生产强度为16.7U/(mL·h),比对照分别提高了84.6%和45.2%,实现了碱性果胶酶的高效生产。     

Fed-batch sorbose fermentation using pulse and multiple feeding strategies for productivity improvement

Microbial oxidation of D-sorbitol tol-sorbose byAcetobacter suboxydans is of commercial importance since it is the only biochemical process in vitamin C synthesis. The main bottleneck in the batch oxidation of sorbitol to sorbose is that the process is severely inhibited by sorbitol. Suitable fed-batch fermentation designs can eliminate the inherent substrate inhibition and improve sorbose productivity. Fed-batch sorbose fermentations were conducted by using two nutrient feeding strategies. For fed-batch fermentation with pulse feeding highly concentrated sorbitol (600 g/L) along with other nutrients were fed intermittently in four pulses of 0.5 liter in response to the increased DO signal. The fed-batch fermentation was over in 24 h with a sorbose productivity of 13.40 g/L/h and a final sorbose concentration of 320.48 g/L. On the other hand, in fed-batch fermentation with multiple feeds, two pulse feeds of 0.5 liter nutrient medium containing 600 g/L sorbitol was followed by the addition of 1.5 liter nutrient medium containing 600 g/L sorbitol at a constant feed rate of 0.36 L/h till the full working capacity of the reactor. The fermentation was completed in 24 h with an enhanced sorbose productivity of 15.09 g/L/h and a sorbose concentration of 332.60 g/L. The sorbose concentration and productivity obtained by multiple feeding of nutrients was found to be higher than that obtained by pulse feeding and was therefore a better strategy for fed-batch sorbose fermentation.     

Use of dynamic step response for control of fed-batch conversion of lignocellulosic hydrolyzates to ethanol

Optimization of fed-batch conversion of lignocellulosic hydrolyzates by the yeast Saccharomyces cerevisiae was studied. The feed rate was controlled using a step response strategy, in which the carbon dioxide evolution rate was used as input variable. The performance of the control strategy was examined using both an untreated and a detoxified dilute acid hydrolyzate, and the performance was compared to that obtained with a synthetic medium. In batch cultivation of the untreated hydrolyzate, only 23% of the hexose sugars were assimilated. However, by using the feed-back controlled fed-batch technique, it was possible to obtain complete conversion of the hexose sugars. Furthermore, the maximal specific ethanol productivity (q(E,max)) increased more than 10-fold, from 0.06 to 0.70 g g(-1) h(-1). In addition, the viability of the yeast cells decreased by more than 99% in batch cultivation, whereas a viability of more than 40% could be maintained during fed-batch cultivation. In contrast to untreated hydrolyzate, it was possible to convert the sugars in the detoxified hydrolyzate also in batch cultivation. However, a 50% higher specific ethanol productivity was obtained using fed-batch cultivation. During batch cultivation of both untreated and detoxified hydrolyzate a gradual decrease in specific ethanol productivity was observed. This decrease could largely be avoided in fed-batch cultivations.     

Fed-batch sorbitol to sorbose fermentation by A. suboxydans

Batch kinetics for sorbitol to sorbose bioconversion was studied at 20% sorbitol concentration. The culture featured 90% conversion of sorbitol to sorbose in 20 hours. Increasing the initial substrate concentration in the bioreactor decreased the culture specific growth rate. At 40% initial sorbitol concentration no culture growth was observed. The batch kinetics and substrate inhibition studies were used to develop the Mathematical Model of the system. The model parameters were identified using the original batch kinetic data (S _o =20%). The developed mathematical model was adopted to fed-batch cultivation with the exponential nutrient feeding. The fed-batch model was simulated and implemented experimentally. No substrate inhibition was observed in the fed-batch mode and it provided an overall productivity of 12.6?g/l-h. The fed-batch model suitably described the experimentally observed results. The model is ready for further optimization studies.     

Zymomonas mobilis CP4 fed-batch fermentations of glucose-fructose mixtures to ethanol and sorbitol

Zymomonas mobilis CP4 fed-batch fermentations of glucose-fructose mixtures were carried out at different operational conditions (aeration, feed rate and substrate concentration) to test their effects on the system productivity. In these fermentations, the main products were ethanol and sorbitol. Kinetic parameters were calculated using the experimental data. However, parameters in the sorbitol synthesis rate were estimated from data recorded in different experiments in order to avoid the effect of the simultaneous cell growth and ethanol synthesis. In this case, the crude cell extract was used as source of the enzyme responsible for the sorbitol synthesis. The highest degree of conversion of fructose into sorbitol obtained with the extract was equal to 71% in a sugar mixture with an initial concentration of 200 g/l. Results obtained in the fed-batch fermentations showed that aeration of the culture has a positive effect on the final biomass concentration. However, final ethanol concentration is lower under aerated conditions. The best sugar yields to biomass and ethanol were 0.032 and 0.411 g/g, respectively. On the other hand, the highest sorbitol yield in the fed-batch fermentations was 0.148 g/g.     

A rational approach to improving productivity in recombinant Pichia pastoris fermentation

A Mut(S) Pichia pastoris strain that had been genetically modified to produce and secrete sea raven antifreeze protein was used as a model system to demonstrate the implementation of a rational, model-based approach to improve process productivity. A set of glycerol/methanol mixed-feed continuous stirred-tank reactor (CSTR) experiments was performed at the 5-L scale to characterize the relationship between the specific growth rate and the cell yield on methanol, the specific methanol consumption rate, the specific recombinant protein formation rate, and the productivity based on secreted protein levels. The range of dilution rates studied was 0. 01 to 0.10 h(-1), and the residual methanol concentration was kept constant at approximately 2 g/L (below the inhibitory level). With the assumption that the cell yield on glycerol was constant, the cell yield on methanol increased from approximately 0.5 to 1.5 over the range studied. A maximum specific methanol consumption rate of 20 mg/g. h was achieved at a dilution rate of 0.06 h(-1). The specific product formation rate and the volumetric productivity based on product continued to increase over the range of dilution rates studied, and the maximum values were 0.06 mg/g. h and 1.7 mg/L. h, respectively. Therefore, no evidence of repression by glycerol was observed over this range, and operating at the highest dilution rate studied maximized productivity. Fed-batch mass balance equations, based on Monod-type kinetics and parameters derived from data collected during the CSTR work, were then used to predict cell growth and recombinant protein production and to develop an exponential feeding strategy using two carbon sources. Two exponential fed-batch fermentations were conducted according to the predicted feeding strategy at specific growth rates of 0.03 h(-1) and 0.07 h(-1) to verify the accuracy of the model. Cell growth was accurately predicted in both fed-batch runs; however, the model underestimated recombinant product concentration. The overall volumetric productivity of both runs was approximately 2.2 mg/L. h, representing a tenfold increase in the productivity compared with a heuristic feeding strategy.     

Over-expression of recombinant human interferon-gamma in high cell density fermentation of Escherichia coli

Human interferon-gamma (hIFN-gamma) was expressed in Escherichia coli BL21(DE3) under the control of the T7 promoter. Glucose was used as the sole source of carbon and energy with simple exponential feeding rate in fed-batch process. Cell density of recombinant E. coli was reached to 100 g dry wt l(-1) under both constant (0.12 h(-1)) and variable (0.12-0.52 h(-1)) specific growth rates. In the variable specific growth rate fed-batch process, plasmid stability and specific yield of rhIFN-gamma were greater than constant specific growth rate fed-batch process. The final specific yield and overall productivity of rhIFN-gamma were 0.35 +/- 0.02 g rhIFN-gamma g(-1) dry cell wt and 0.9 +/- 0.05 g rhIFN-gamma l(-1) h(-1) in the variable specific growth rate fed-batch process, respectively.     

Hypoxic fed-batch cultivation of Pichia pastoris increases specific and volumetric productivity of recombinant proteins

High cell density cultivation of Pichia pastoris has to cope with several technical limitations, most importantly the transfer of oxygen. By applying hypoxic conditions to chemostat cultivations of P. pastoris expressing an antibody Fab fragment under the GAP promoter, a 2.5-fold increase of the specific productivity q(P) at low oxygen supply was observed. At the same time the biomass decreased and ethanol was produced, indicating a shift from oxidative to oxidofermentative conditions. Based on these results we designed a feedback control for enhanced productivity in fed batch processes, where the concentration of ethanol in the culture was kept constant at approximately 1.0% (vv(-1)) by a regulated addition of feed medium. This strategy was tested successfully with three different protein producing strains, leading to a three- to sixfold increase of the q(P) and threefold reduced fed batch times. Taken together the volumetric productivity Q(P) increased 2.3-fold.     

Influence of methanol/sorbitol co-feeding rate on pAOX1 induction in a <Emphasis Type="Italic">Pichia pastoris</Emphasis> Mut+ strain in bioreactor with limited oxygen transfer rate

High Pichia pastoris biomass density could be obtained using high co-feeding rate of methanol and sorbitol in a fed-batch or continuous culture, while further higher feeding rate finally leads to oxygen limitation in bioreactor. In the literature, there is lack of report about AOX1 promoter regulation with regard to dissolved oxygen level (DO). Therefore, in this work, chemostat cultures were performed to investigate the cell growth, metabolism and regulation of the AOX1 promoter (pAOX1) regarding co-feeding rate of optimized methanol/sorbitol mixture (methanol fraction 0.60 C-mol/C-mol) using a P. pastoris Mut+/pAOX1-lacZ strain. The oxygen transfer rates (OTR) in bioreactor were kept in the range of typical values of large bioreactor, i.e., 4–8 g/(L h) if DO equals 30 % saturation or 5–10 g/(L h) if DO nears zero. For DO >0, an increase of the carbon fed led to an increase of pAOX1 induction. By contrast, when dissolved oxygen was completely depleted, methanol accumulated, causing a 30 % decrease of pAOX1 induction. However, this decrease is more likely to be lined to methanol accumulation than to low level of dissolved oxygen (<4 % DO). Methanol/sorbitol co-feeding allowed cells to adapt to oxygen transient limitations that often occur at industrial scale with reduced effect on pAOX1 induction. The optimal feeding rate tested here was 6.6 mmol C (DCW h)^?1 at an OTR of 8.28 g O₂(L h)^?1 with over fivefold pAOX1 induction (probably directly associated with target protein productivity) compared with previous work.     

双碳源流加对重组毕赤酵母高效表达葡萄糖氧化酶的影响

葡萄糖氧化酶(GOD)是一种具有广泛应用前景的工业酶.为了实现葡萄糖氧化酶的高效生产,提高重组毕赤酵母生产GOD的产量和增强生产强度,对重组毕赤酵母诱导阶段的初始菌体浓度和甲醇浓度进行了优化.在此基础上,诱导期采用了双碳源(甘油、山梨醇和甘露醇)与甲醇混合流加的模式.研究发现,最佳诱导前初始菌体浓度和甲醇浓度分别为100 g/L和18 g/L,此时GOD产量为427.6 U/mL.在诱导阶段采用甘油、山梨醇和甘露醇与甲醇的混合添加均可以提高GOD产量,其中甘露醇与甲醇的混合流加效果最为显著.当甲醇与甘露醇混合流加的比例为20∶1(W/W)时,诱导156h GOD产量和生产强度分别可达711.3 U/mL和4.60 U/(mL·h),比甲醇单一流加策略结果分别提高了66.3％和67.9％.此外采用合适的甘露醇混合流加策略不但不会抑制AOX1启动子的表达,甚至有一定促进作用,AOX酶活性为8.8 U/g(对照为5.2 U/g).双碳源流加方式还能推广到毕赤酵母其他表型中,为该系统高效表达外源蛋白提供一种新策略.     

Mixed feeds of glycerol and methanol can improve the performance of Pichia pastoris cultures: A quantitative study based on concentration gradients in transient continuous cultures

Transient continuous cultures constitute a means to speed up strain characterization, by avoiding the need for many time-consuming steady-state experiments. In this study, mixed substrate growth on glycerol and methanol of a Pichia pastoris strain expressing and secreting recombinant avidin was characterized quantitatively by performing a nutrient gradient with linear increase of the methanol fraction in the feed medium from 0.5 to 0.93 C-mol C-mol(-1) at a dilution rate of 0.06 h(-1). The influence of the methanol fraction in the feed medium on recombinant avidin productivity and on specific alcohol oxidase activity were also examined. Results showed that, compared with cultures on methanol as sole carbon source, the specific recombinant avidin production rate was the same provided the methanol fraction in the feed medium was higher than 0.6 C-mol C-mol(-1). The volumetric avidin production rate was even 1.1-fold higher with a methanol fraction in the feed medium of 0.62 C-mol C-mol(-1) as a result of the higher biomass yield on mixed substrate growth compared with methanol alone. Moreover, since heat production and oxygen uptake rates are lower during mixed substrate growth on glycerol and methanol, mixed substrate cultures present technical advantages for the performance of high cell density P. pastoris cultures. Results obtained in a high cell density fed-batch culture with a mixed feed of 0.65 C-mol C-mol(-1) methanol and 0.35 C-mol C-mol(-1) glycerol were in agreement with results obtained during the transient nutrient gradient.     

Optimisation of culture conditions with respect to biotin requirement for the production of recombinant avidin in Pichia pastoris

Due to its very high affinity to biotin, avidin is one of the most widely exploited proteins in modern biotechnological and biomedical applications. Since biotin is an essential vitamin for the growth of many microorganisms, we examined the effect of biotin deficiency on growth for a recombinant Pichia pastoris strain expressing and secreting a recombinant glycosylated avidin. The results showed that biotin deficiency lowers growth rate and biomass yield for P. pastoris. Substitution of biotin in the medium by the two structurally unrelated compounds, aspartic acid and oleic acid, which do not bind to recombinant avidin was analyzed quantitatively. These two compounds had a growth promoting effect in biotin-deficient medium, but did not replace biotin completely. Indeed, in chemostat culture, wash-out occurred after about six liquid residence times and recombinant avidin productivity was lowered. However, addition of low amounts of biotin (20 microg L(-1) of biotin for a cell density of 8 g L(-1)) resulted in stable chemostat cultures on methanol with the production of recombinant biotin-free avidin. The specific avidin production rate was 22 microg g(-1) h(-1) at a dilution rate of 0.06 h(-1).     

恒细胞密度发酵策略提高重组毕赤酵母生产碱性果胶酶的表达效率

为了提高重组毕赤酵母生产碱性果胶酶(Alkaline polygalacturonate lyase,PGL)的比速率,开发了一种新的恒细胞密度发酵策略。通过不同的甲醇流加方式,实现发酵过程细胞密度的合理控制。实验结果表明:控制细胞密度为75 g/L的策略为最优,最终单位发酵液体积生产强度和单位菌体生产强度为6.11 U/(mL.h)和81.5 U/(g.h),分别比传统高密度发酵提高了42.1%和191.2%,最终PGL酶活为441.9 U/mL。此外,该策略还具有提高细胞活性和降低蛋白酶降解作用等优势。