Roles of extracellular lactose hydrolysis in cellulase production by Trichoderma reesei Rut C30 using lactose as inducing substrate

Lactose, an inexpensive, soluble substrate, offers reasonably good induction for cellulase production by Trichoderma reesei. The fungus does not uptake lactose directly. Lactose is hydrolyzed to extracellular glucose and galactose for subsequent ingestion. The roles of this extracellular hydrolysis step were investigated in this study. Batch and continuous cultures were grown on the following substrates: lactose, lactose–glycerol mixtures, glucose, galactose, and glucose–galactose mixtures. Cell growth, substrate consumption, lactose hydrolysis, and lactase and cellulase production were followed and modeled. Cells grew much faster on glucose than on galactose, but with comparable cell yields. Glucose (at >0.3 g/L) repressed the galactose consumption. Cellulase synthesis was growth-independent while lactase synthesis was growth-dependent, except at D < ∼0.065 h⁻¹ where a basal level lactase production was observed. For cellulase production the optimal D was 0.055–0.065 h⁻¹ where the enzyme activity and productivity were both near maxima. The model suggested that lactase synthesis was subject to weak galactose repression. As the galactose concentration increased at high D (>0.1 h⁻¹), lactase synthesis became repressed. The insufficient lactase synthesis limited the lactose hydrolysis rate. Extracellular lactose hydrolysis was concluded to be the rate-limiting step for growth of T. reesei Rut C30 on lactose.     

Galactose metabolism by Streptococcus mutans

The galK gene, encoding galactokinase of the Leloir pathway, was insertionally inactivated in Streptococcus mutans UA159. The galK knockout strain displayed only marginal growth on galactose, but growth on glucose or lactose was not affected. In strain UA159, the sugar phosphotransferase system (PTS) for lactose and the PTS for galactose were induced by growth in lactose and galactose, although galactose PTS activity was very low, suggesting that S. mutans does not have a galactose-specific PTS and that the lactose PTS may transport galactose, albeit poorly. To determine if the galactose growth defect of the galK mutant could be overcome by enhancing lactose PTS activity, the gene encoding a putative repressor of the operon for lactose PTS and phospho-beta-galactosidase, lacR, was insertionally inactivated. A galK and lacR mutant still could not grow on galactose, although the strain had constitutively elevated lactose PTS activity. The glucose PTS activity of lacR mutants grown in glucose was lower than in the wild-type strain, revealing an influence of LacR or the lactose PTS on the regulation of the glucose PTS. Mutation of the lacA gene of the tagatose pathway caused impaired growth in lactose and galactose, suggesting that galactose can only be efficiently utilized when both the Leloir and tagatose pathways are functional. A mutation of the permease in the multiple sugar metabolism operon did not affect growth on galactose. Thus, the galactose permease of S. mutans is not present in the gal, lac, or msm operons.     

Coregulation of beta-galactoside uptake and hydrolysis by the hyperthermophilic bacterium Thermotoga neapolitana

Regulation of the beta-galactoside transport system in response to growth substrates in the extremely thermophilic anaerobic bacterium Thermotoga neapolitana was studied with the nonmetabolizable analog methyl-beta-D-thiogalactopyranoside (TMG) as the transport substrate. T. neapolitana cells grown on galactose or lactose accumulated TMG against a concentration gradient in an intracellular free sugar pool that was exchangeable with external galactose or lactose and showed induced levels of beta-galactosidase. Cells grown on glucose, maltose, or galactose plus glucose showed no capacity to accumulate TMG, though these cells carried out active transport of the nonmetabolizable glucose analog 2-deoxy-D-glucose. Glucose neither inhibited TMG uptake nor caused efflux of preaccumulated TMG; rather, glucose promoted TMG uptake by supplying metabolic energy. These data show that beta-D-galactosides are taken up by T. neapolitana via an active transport system that can be induced by galactose or lactose and repressed by glucose but which is not inhibited by glucose. Thus, the phenomenon of catabolite repression is present in T. neapolitana with respect to systems catalyzing both the transport and hydrolysis of beta-D-galactosides, but inducer exclusion and inducer expulsion, mechanisms that regulate permease activity, are not present. Regulation is manifest at the level of synthesis of the beta-galactoside transport system but not in the activity of the system.     

Effect of modulation of enzyme inactivation on temperature optimization for reactor operation with chitin-immobilized lactase

Temperature is a critical variable to be optimized in any enzymatic process, producing opposite effects on enzyme activity and inactivation rate. Temperature functions for all kinetic and inactivation parameters were validated for chitin-immobilized yeast lactase (CIL). Enzyme inactivation was described by a two-stage series mechanism. The effect of galactose and lactose on inactivation was determined in terms of modulation factors that were positive for galactose and negative for lactose. Modulation factors were mild functions of temperature in the first stage and strong functions in the second stage of enzyme inactivation, where galactose positive modulation factors increase while lactose negative modulation factors decrease with temperature. Temperature-explicit functions for kinetic and inactivation parameters were incorporated into a scheme to optimize temperature in the simulation of a continuous packed-bed reactor operation with chitin-immobilized lactase, based on an annual cost objective function. Optimum temperature was 20°C at enzyme replacement of 25% residual activity, and increased only slightly at higher replacement frequencies. The effect of modulation factors on reactor design and temperature optimization is presented and discussed. Software for temperature optimization that allows the introduction of variations in all parameters and operational criteria to perform sensitivity analysis was developed.     

Galactose Metabolism by Streptococcus mutans

The galK gene, encoding galactokinase of the Leloir pathway, was insertionally inactivated in Streptococcus mutans UA159. The galK knockout strain displayed only marginal growth on galactose, but growth on glucose or lactose was not affected. In strain UA159, the sugar phosphotransferase system (PTS) for lactose and the PTS for galactose were induced by growth in lactose and galactose, although galactose PTS activity was very low, suggesting that S. mutans does not have a galactose-specific PTS and that the lactose PTS may transport galactose, albeit poorly. To determine if the galactose growth defect of the galK mutant could be overcome by enhancing lactose PTS activity, the gene encoding a putative repressor of the operon for lactose PTS and phospho-β-galactosidase, lacR, was insertionally inactivated. A galK and lacR mutant still could not grow on galactose, although the strain had constitutively elevated lactose PTS activity. The glucose PTS activity of lacR mutants grown in glucose was lower than in the wild-type strain, revealing an influence of LacR or the lactose PTS on the regulation of the glucose PTS. Mutation of the lacA gene of the tagatose pathway caused impaired growth in lactose and galactose, suggesting that galactose can only be efficiently utilized when both the Leloir and tagatose pathways are functional. A mutation of the permease in the multiple sugar metabolism operon did not affect growth on galactose. Thus, the galactose permease of S. mutans is not present in the gal, lac, or msm operons.     

Utilization of Lactose, Glucose, and Galactose by a Mixed Culture of Streptococcus thermophilus and Lactobacillus bulgaricus in Milk Treated with Lactase Enzyme

The mechanism responsible for an increased rate of acid production when yogurt starter cultures are grown in milk treated with lactase enzyme was investigated by studying carbohydrate utilization and acid development by a pure culture of Streptococcus thermophilus and a mixed yogurt starter culture consisting of S. thermophilus and Lactobacillus bulgaricus. In milk containing glucose, galactose, and lactose, glucose and lactose (but not free galactose) were fermented. Fermentation of lactose in control milk was accompanied by the release of free galactose, with the result that carbohydrate utilization was less efficient than in treated milk. This phenomenon also occurred when lactose was fermented by S. thermophilus in broth culture. Carbohydrate utilization by the mixed yogurt culture was more rapid when the lactose in milk was partially prehydrolyzed. Our results suggest that the more rapid acid development that took place when a mixed yogurt starter culture was grown in milk containing prehydrolyzed lactose was the result of a more rapid and efficient utilization of carbohydrate by S. thermophilus when free glucose in addition to lactose was available for fermentation. The evidence presented also suggests that uptake and utilization of glucose and lactose by S. thermophilus are different in broth and milk cultures.     

Induction of intracellular and extracellular beta-galactosidase activity in Phycomyces blakesleeanus

The inductive effect of different sugars on beta-galactosidase synthesis in Phycomyces blakesleeanus has been studied. The enzyme was inducible by galactose and fructose. When grown on these sugars the enzyme level was 10-20 times greater than when grown on glucose. We have detected both intra- and extracellular beta-galactosidase activity when Phycomyces blakesleeanus was grown on galactose, but only extracellular beta-galactosidase activity when grown on fructose plus lactose.     

Catabolite inhibition and sequential metabolism of sugars by Streptococcus lactis.

Growth of galactose-adapted cells of Streptococcus lactis ML(3) in a medium containing a mixture of glucose, galactose, and lactose was characterized initially by the simultaneous metabolism of glucose and lactose. Galactose was not significantly utilized until the latter sugars had been exhausted from the medium. The addition of glucose or lactose to a culture of S. lactis ML(3) growing exponentially on galactose caused immediate inhibition of galactose utilization and an increase in growth rate, concomitant with the preferential metabolism of the added sugar. Under nongrowing conditions, cells of S. lactis ML(3) grown previously on galactose metabolized the three separate sugars equally rapidly. However, cells suspended in buffer containing a mixture of glucose plus galactose or lactose plus galactose again consumed glucose or lactose preferentially. The rate of galactose metabolism was reduced by approximately 95% in the presence of the inhibitory sugar, but the maximum rate of metabolism was resumed upon exhaustion of glucose or lactose from the system. When presented with a mixture of glucose and lactose, the resting cells metabolized both sugars simultaneously. Lactose, glucose, and a non-metabolizable glucose analog (2-deoxy-d-glucose) prevented the phosphoenolpyruvate-dependent uptake of thiomethyl-beta-d-galactopyranoside (TMG), but the accumulation of TMG, like galactose metabolism, commenced immediately upon exhaustion of the metabolizable sugars from the medium. Growth of galactose-adapted cells of the lactose-defective variant S. lactis 7962 in the triple-sugar medium was characterized by the sequential metabolism of glucose, galactose, and lactose. Growth of S. lactis ML(3) and 7962 in the triple-sugar medium occurred without apparent diauxie, and for each strain the patterns of sequential sugar metabolism under growing and nongrowing conditions were identical. Fine control of the activities of preexisting enzyme systems by catabolite inhibition may afford a satisfactory explanation for the observed sequential utilization of sugars by these two organisms.     

Influence of dilution rate and induction of cloned gene expression in continuous fermentations of recombinant yeast

The effects of growth rate on cloned gene product synthesis in recombinant Saccharomyces cerevisiae have been studied in continuous culture. The plasmid employed contains a yeast GAL10-CYC1 hybrid promoter directing expression of the E. coli lacZ gene. beta-Galactosidase production was therefore controlled by the yeast galactose regulatory circuit, and the induction process and its effects were studied at the various dilution rates. At all dilution rates plasmid stability decreased with induction of lacZ gene expression. In some instances, two induced "steady states" were observed, the first 10-15 residence times after induction and the second after 40-50 residence times. The second induced steady state was characterized by greater biomass concentration and lower beta-galactosidase specific activity relative to the first induced "steady-state." beta-Galactosidase specific activity and biomass concentration increased as dilution rate was reduced, and despite lower flow rate and plasmid stability, overall productivity (activity/L/hr) was substantially higher at low dilution rate. Important factors influencing all of the trends were the glucose and galactose (inducer) concentrations in the vessel and inducer metabolism.     

Co-induction of beta-galactosidase and the lactose-P-enolpyruvate phosphotransferase system in Streptococcus salivarius and Streptococcus mutans.

The addition of lactose, galactose, or isopropyl-beta-D-thiogalactoside (IPTG) to glucose-grown cells of Streptococcus salivarius 25975 resulted in the co-induction of both the lactose-P-enolpyruvate phosphotransferase system (lactose-PTS) and beta-galactosidase, with the latter the predominant metabolic system. With various strains of Streptococcus mutans and Streptococcus sanguis 10556, on the other hand, the lactose-PTS was the major metabolic pathway with beta-galactosidase induced either to low or negligible levels. In all cases, induction of the lactose-PTS resulted in the concomitant induction of 6-P-beta-galactosidase. The induction by lactose of both the lactose-PTS and beta-galactosidase in all strains was repressed by glucose and other catabolites, notably, fructose. Induction of beta-galactosidase in S. salivarius 25975 by IPTG was, however, relatively resistant to glucose repression. Induction experiments with IPTG and lactose suggested that a cellular metabolite of lactose metabolism was a repressor of enzyme activity. Exogenous cAMP was shown to reverse the transient repression by glucose of beta-galactosidase induction in cells of S. salivarius 25975 receiving lactose, provided the cells were grown with small amounts of toluene to overcome the permeability barrier to this nucleotide, cAMP, was however, unable to overcome the permanent repression of beta-galactosidase activity to a significant extent under these conditions.     

Melibiose transport system in Lactobacillus plantarum.

Lactobacillus plantarum ATCC 8014 grew on melibiose at 30 C, but not at 37 C, although it grew on galactose or lactose at either temperature. ATCC 8014 grown on lactose at 30 or 37 C accumulated melibiose slowly, suggesting that melibiose may partly be transported by a lactose transport system. A lactose-negative mutant, NTG 21, derived from ATCC 8014 was isolated. The mutant was totally deficient in lactose transport, but retained normal melibiose transport activity. In NTG 21, the melibiose transport activity was induced by melibiose at 30 C, but not at 37 C. The transport activity itself was found to be stable for at least 3 hr at 37 C, suggesting that the induction process in the cytoplasm rather than the inducer entrance is temperature-sensitive in the organism. The organism also failed to form alpha-galactosidase at 37 C when grown on melibiose. The enzyme synthesis, however, was induced by galactose in NTG 21 (and also by lactose in ATCC 8014) even at 37 C, indicating that the induction of the enzyme is essentially not temperature-sensitive. In NTG 21, melibiose transport system and alpha-galactosidase were induced by galactose, melibiose and o-nitrophenyl-alpha-D-galactopyranoside when the strain was grown at 30 C. Raffinose induced melibiose transport system only a little, while it was a good inducer for alpha-galactosidase. Inhibition studies revealed that galactose may be a weak substrate of the melibiose transport system; no inhibition was demonstrated with lactose and raffinose.     

Changes in the activities of respiratory enzymes during the aerobic growth of yeast on different carbon sources

1. Unlike yeast cells grown on glucose (0.9%), cells grown on galactose aerobically or anaerobically as well as cells grown on very low glucose concentrations (0.09%) have been found to possess mitochondria. 2. Synthesis of respiratory enzymes was less in the presence of glucose than galactose. When either sugar was consumed, synthesis of these enzymes increased. 3. A possible mechanism is suggested for the repression of mitochondrial formation by glucose by means of a ;high-energy' substance easily derived from glucose.     

The utilization of mixed sugars in continuous fermentation. I.

A strain of Klebsiella aerogenes was selected which gave marked diauxic growth in a batch system on a mixture of glucose and lactose in a simple salts medium; the diauxic lag was 15–20 hr. at 30°C. The growth of this organism on glucose and lactose was studied in a single-stream two-stage continuous-stirred fermentor system over a wide range of flow rates. Glucose was metabolized instantaneously to give very low reactor concentrations at all flow rates, but the time lag before lactose was attacked, when present for the first time, was never less than 40 hr. at low feed rates, rising to 60 hr. at higher rates. The adaptation to lactose of cells in the first vessel lagged behind that in the second vessel but eventually both sugars were completely utilized in the first vessel except at very high dilution rates. At these feed rates, lactose utilization was not only prevented completely in the first vessel but also could be delayed almost indefinitely in the second vessel at the highest dilution rates; thus the lactose passed unchanged through both vessels. Once the enzymes required for lactose utilization had been induced, this ability to use lactose was retained, even in the absence of lactose, for very long periods of time under continuous conditions. Thus on presenting lactose for the second and subsequent occasions it was immediately metabolized. The significance of these results is discussed.     

Effects of pH and type of sugar in the medium on tyrosinase activity in cultured melanoma cells.

The tyrosinase (EC 1.14.18.1) activity of cultured mouse melanoma cells B16 in the stationary phase of growth, depends greatly on the pH of the medium and the kind of sugar present. The enzyme activity of a homogenate of cells grown at pH 7.2 in Eagles's MEM supplemented with 10% new born calf serum and con taining galactose in place of glucose, was about ten times that of a homogenate of cells cultured at pH 6.3 in the same medium. The tyrosinase activity changed reversibly on changing the pH of the culture medium. When cultured at a constant pH of 7.2, cells grown with 1 mM galactose had about five times higher tyrosinase activity than cells grown with 1 mM glucose. Only a small amount of lactate accumulated in cultures with glucose and it had little effect on the enzyme activity. These two findings explain the very low tyrosinase activity of cells cultured in medium with 5 mM glucose: the low activity is due to the presence of glucose and to the low pH resulting from conversion of glucose to lactic acid.     

Regulation and characterization of the galactose-phosphoenolpyruvate-dependent phosphotransferase system in Lactobacillus casei.

Cells of Lactobacillus casei grown in media containing galactose or a metabolizable beta-galactoside (lactose, lactulose, or arabinosyl-beta-D-galactoside) were induced for a galactose-phosphoenolpyruvate-dependent phosphotransferase system (gal-PTS). This high-affinity system (Km for galactose, 11 microM) was inducible in eight strains examined, which were representative of all five subspecies of L. casei. The gal-PTS was also induced in strains defective in glucose- and lactose-phosphoenolpyruvate-dependent phosphotransferase systems during growth on galactose. Galactose 6-phosphate appeared to be the intracellular inducer of the gal-PTS. The gal-PTS was quite specific for D-galactose, and neither glucose, lactose, nor a variety of structural analogs of galactose caused significant inhibition of phosphotransferase system-mediated galactose transport in intact cells. The phosphoenolpyruvate-dependent phosphorylation of galactose in vitro required specific membrane and cytoplasmic components (including enzyme IIIgal), which were induced only by growth of the cells on galactose or beta-galactosides. Extracts prepared from such cells also contained an ATP-dependent galactokinase which converted galactose to galactose 1-phosphate. Our results demonstrate the separate identities of the gal-PTS and the lactose-phosphoenol-pyruvate-dependent phosphotransferase system in L. casei.     

Selection of lactose-adapted cells in vinca minor and Dantura innoxia cultures; location and characterization of β-galactosidase and lactase activities

Lactose-adapted cells were obtained from Datura innoxia sucrose growing calli cultures and from Vinca minor glucose growing calli cultures. Lactose adaptation process points out the homogeneity of the cell population towards lactose uptake in V. minor cultures while it reveals the presence of heterogeneous population in D. innoxia cultures.In both species, lactose hydrolysis was only occurring in the cells; no lactase activity was detected in the culture medium. An intermittent lactase activity was determined in a cell-free extract during the culture period. Lactase activity was detected in Vinca glucose grown cells as well in Datura lactose-adapted cells cultured in absence of lactose; so lactase is a constitutive enzyme. Galactose liberated during lactose hydrolysis was not toxic for thecells; it was released into the culture medium and not metabolized in Vinca cultures while it was metabolized in Datura cultures at the end of the culture period.     

Regulation of beta-glucosidase in Bacteroides ruminicola by a different mechanism: growth rate-dependent derepression

Bacteroides ruminicola B(1)4, a predominant ruminal and cecal bacterium, was grown in batch and continuous cultures, and beta-glucosidase activity was measured by following the hydrolysis of p-nitrophenyl-beta-glucopyranoside. Specific activity was high when the bacterium was grown in batch cultures containing cellobiose, mannose, or lactose (greater than 286 U/g of protein). Activity was reduced approximately 90% when the organism was grown on glucose, sucrose, fructose, maltose, or arabinose. The specific activity of cells fermenting glucose was initially low but increased as glucose was depleted. When glucose was added to cultures growing on cellobiose, beta-glucosidase synthesis ceased immediately. Catabolite repression by glucose was not accompanied by diauxic growth and was not relieved by cyclic AMP. Since glucose-grown cultures eventually exhibited high beta-glucosidase activity, cellobiose was not needed as an inducer. Catabolite repression explained beta-glucosidase activity of batch cultures and high-dilution-rate chemostats where glucose accumulated, but it could not account for activity at slow dilution rates. Maximal beta-glucosidase activity was observed at a dilution rate of approximately 0.35 h-1, and cellobiose-limited chemostats showed a 15-fold decrease in activity as the dilution rate declined. An eightfold decline was observed in glucose-limited chemostats. Since inducer availability was not a confounding factor in glucose-limited chemostats, the growth rate-dependent derepression could not be explained by other mechanisms.     

Regulation of beta-glucosidase in Bacteroides ruminicola by a different mechanism: growth rate-dependent derepression.

Bacteroides ruminicola B(1)4, a predominant ruminal and cecal bacterium, was grown in batch and continuous cultures, and beta-glucosidase activity was measured by following the hydrolysis of p-nitrophenyl-beta-glucopyranoside. Specific activity was high when the bacterium was grown in batch cultures containing cellobiose, mannose, or lactose (greater than 286 U/g of protein). Activity was reduced approximately 90% when the organism was grown on glucose, sucrose, fructose, maltose, or arabinose. The specific activity of cells fermenting glucose was initially low but increased as glucose was depleted. When glucose was added to cultures growing on cellobiose, beta-glucosidase synthesis ceased immediately. Catabolite repression by glucose was not accompanied by diauxic growth and was not relieved by cyclic AMP. Since glucose-grown cultures eventually exhibited high beta-glucosidase activity, cellobiose was not needed as an inducer. Catabolite repression explained beta-glucosidase activity of batch cultures and high-dilution-rate chemostats where glucose accumulated, but it could not account for activity at slow dilution rates. Maximal beta-glucosidase activity was observed at a dilution rate of approximately 0.35 h-1, and cellobiose-limited chemostats showed a 15-fold decrease in activity as the dilution rate declined. An eightfold decline was observed in glucose-limited chemostats. Since inducer availability was not a confounding factor in glucose-limited chemostats, the growth rate-dependent derepression could not be explained by other mechanisms.     

Purification and properties of two lactose hydrolases from Trichosporon cutaneum

Two enzymes that hydrolysed lactose were purified essentially to homogeneity from cell extracts of the oleaginous yeast Trichosporon cutaneum. One enzyme of Mr 120,000 had properties typical of a beta-galactosidase (EC 3.2.1.23). It hydrolysed lactose, lactulose and nitrophenyl-beta-D-galactosides. The enzyme required K+ or Rb+ for activity, and other monovalent cations tested were not effective. Enzyme activity was abolished by EDTA and stimulated by Mg2+, Mn2+ and Ca2+. The beta-galactosidase was induced by lactose, galactose, lactulose and lactobionic acid. The other enzyme, a beta-glycosidase (EC 3.2.1.21) of Mr 52,000 showed no ionic requirements and it hydrolysed lactose, nitrophenyl-beta-D-galactosides, 4-nitrophenyl-beta-D-glucoside, cellobiose, laminaribiose, laminaritriose and sophorose, but not gentiobiose, 4-nitrophenyl-beta-D-mannoside or sucrose. This enzyme was induced by lactose, galactose and lactulose, and also by cellobiose.     

Characterization of lactose-fermenting revertants from lactose-negative Streptococcus lactis C2 mutants

Partial lactose-fermenting revertants from lactose-negative (lac(-)) mutants of Streptococcus lactis C2 appeared on a lawn of lac(-) cells after 3 to 5 days of incubation at 25 C. The revertants grew slowly on lactose with a growth response similar to that for cryptic cells. In contrast to lac(+)S. lactis C2, the revertants were defective in the accumulation of [(14)C]thiomethyl-beta-d-galactoside, indicating that they were devoid of a transport system. Hydrolysis of o-nitrophenyl-beta-d-galactoside-6-phosphate by toluene-treated cells confirmed the presence of phospho-beta-d-galactosidase (P-beta-gal) in the revertant. However, this enzyme was induced only when the cells were grown in the presence of lactose; galactose was not an inducer. In lac(+)S. lactis C2, enzyme induction occurred in lactose- or galactose-grown cells. The revertants were defective in EII-lactose and FIII-lactose of the phosphoenolpyruvate-dependent phosphotransferase system. Galactokinase activity was detected in cell extracts of lac(+)S. lactis C2, but the activity was 9 to 13 times higher in extracts from the revertant and lac(-), respectively. This suggested that the lac(-) and the revertants use the Leloir pathway for galactose metabolism and that galactose-1-phosphate rather than galactose-6-phosphate was being formed. This may explain why lactose, but not galactose, induced P-beta-gal in the revertants. Because the revertant was unable to form galactose-6-phosphate, induction could not occur. This compound would be formed on hydrolysis of lactose phosphate. The data also indicate that galactose-6-phosphate may serve not only as an inducer of the lactose genes in S. lactis C2, but also as a repressor of the Leloir pathway for galactose metabolism.