A novel nonwoven hybrid bioreactor (NWHBR) for enhancing simultaneous nitrification and denitrification

This study proposed a nonwoven hybrid bioreactor (NWHBR) in which the nonwoven fabric played dual roles as a biofilm carrier and membrane‐like separation of the flocculent sludge in the reactor. The results of long‐term monitoring demonstrated that the NWHBR could achieve simultaneous nitrification and denitrification (SND), with nearly complete ammonium removal and 80% removal of total nitrogen. The biofilm attached to the nonwoven fabric removed 27% of the chemical oxygen demand (COD) and 36% of the nitrate in the reactor, an enhanced elimination of nutrients that was attributed to the increased mass transfer within the biofilm due to permeate drag. The results of batch experiments showed that the flocculent sludge played a more dominant role in nitrification and denitrification (79% and 61%, respectively) than the biofilm (21% and 36%, respectively). The batch experiments also revealed that the enforced mass transfer, with an effluent recirculation rate of 4.3 L/m²h (which was the same as the flux during the reactor's long‐term operation), improved the denitrification rate by 58% (i.e., from 9.0 to 14.2 mg‐NO‐N/h). Pyrosequencing of the 16S rRNA gene amplification revealed a high microbial diversity in both the flocculent sludge and biofilm, with Proteobacteria, Bacteroidetes and Chloroflexi as the dominant groups. A phylogenetic (P) test indicated that the NWHBR contained phylogenetically distinct microbial communities: those in the biofilm differed from those in the flocculent sludge. However, the communities on the exterior and interior of the biofilm were more similar to each other. Due to its good SND performance, low physical back‐washing frequency and low air‐to‐water ratio, the NWHBR represents an attractive alternative for the wider application of either low‐cost membrane bioreactors or biofilm reactors. Biotechnol. Bioeng. 2013; 110: 1903–1912. © 2013 Wiley Periodicals, Inc.     

Novel approach for the ammonium removal by simultaneous heterotrophic nitrification and denitrification using a novel bacterial species co-culture

Agricultural activities lead excessive emission of ammonia nitrogen in the environment and can profoundly interfere the equilibrium of the natural ecosystems leading to their contamination. Actually, the biological purification of wastewaters is the most adopted technique thanks to its several advantages such as high performance and low energy consumption. For this reason, two novel strains of Alcaligenes sp. S84S3 and Proteus sp. S19 genus were isolated from an activated sludge and applied in the treatment of ammonium and nitrite in aqueous solution. Under the optimum operating conditions of temperature (30 °C), pH (7), carbon substrate (2 g/L of glucose) and duration of incubation time (69 h), the strain Alcaligenes sp. S84S3 could oxidize 65 % of the ammonium as high as 272.72 mg-NH₄ ⁺/L. Moreover, during 48 h, the nitrate reduction rate performed by the strain Proteus S19 was about 99 % without production of nitrite intermediate (negligible concentration). Moreover, the coculture of the strains Alcaligenes sp. S84S3 and Proteus sp. S19 could eliminate 65.83 % of the ammonium ions without production of toxic forms of nitrogen oxides during a short time of incubation (118 h) at the same operational conditions with providing the aeration in the first treatment phase. The coculture of our isolated strains is assumed to have a good potential for nitrification and denitrification reactions applied in the treatment of wastewater containing ammonium, nitrite and nitrate. As a result, we can consider that the mixed culture is a practical method in the treatment of high-strength ammonium wastewater with reducing of sludge production.     

Air-lift internal loop biofilm reactor for realized simultaneous nitrification and denitrification

Simultaneous nitrification and denitrification (SND) was realized by means of a novel air-lift internal loop biofilm reactor, in which aeration was set in middle of the reactor. During operation, the aeration was adjusted to get appropriate dissolve oxygen (DO) in bulk solution and let aerobic and anoxic zone coexist in one reactor. When aeration was at 0.6 and 0.2 L/min, corresponding to DO of 5.8 and 2.5 mg/L in bulk solution, ammonia nitrogen removal percentage reached about 80 and 90 %, but total nitrogen removal percentage was lower than 25 %. While the aeration was reduced to 0.1 L/min, aerobic and anoxic zones existed simultaneously in one reactor to get 75 % of ammonia nitrogen and 50 % of total nitrogen removal percentage. Biofilms were, respectively, taken from aerobic and anoxic zone to verify their function of nitrification and denitrification in two flasks, in which ammonia nitrogen was transferred into nitrate completely by aerobic biofilm, and nitrate was removed more than 80 % by anoxic biofilm. Microelectrode was used to measure the DO distribution inside biofilms in anoxic zone corresponding to different aerations. When aeration was at 0.6 and 0.2 L/min, DO inside biofilm was more than 1.5 mg/L, but the DO inside biofilm decreased to anoxic status with depth of biofilm increasing corresponding to aeration of 0.1 L/min. The experimental results indicated that SND could be realized because of simultaneous existence of aerobic and anoxic biofilms in one reactor.     

The development of simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process in a single reactor for nitrogen removal

The simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process was validated to potentially remove ammonium and COD from wastewater in a single, oxygen-limited, non-woven rotating biological contactor (NRBC) reactor. An ammonium conversion efficiency of 79%, TN removal efficiency of 70% and COD removal efficiency of 94% were obtained with the nitrogen and COD loading rate of 0.69 kgN/m(3)d and 0.34 kg/m(3)d, respectively. Scanning electron microscopy (SEM) observation and fluorescence in situ hybridizations (FISH) analysis revealed the existence of the dominant groups of bacteria. As a result, the aerobic ammonia-oxidizing bacteria (AOB), with a spot of aerobic heterotrophic bacteria were mainly distributed in the aerobic outer part of the biofilm. However, ANAMMOX bacteria with denitrifying bacteria were present and active in the anaerobic inner part of the SNAD biofilm. These bacteria were found to exist in a dynamic equilibrium to achieve simultaneous nitrogen and COD removal in NRBC system.     

Heterotrophic nitrification and aerobic denitrification by a novel Halomonas campisalis

A novel halophilic strain that could carry out heterotrophic nitrification and aerobic denitrification was isolated and named as Halomonas campisalis ha3. It removed inorganic nitrogen compounds (e.g. NO₃ ^?, NO₂ ^? and NH₄ ⁺) simultaneously, and grew well in the medium containing up to 20 % (w/v) NaCl. PCR revealed four genes in the genome of ha3 related to aerobic denitrification: napA, nirS, norB and nosZ. The optimal conditions for aerobic denitrification were pH 9.0, at 37 °C, with 4 % (w/v) NaCl and sodium succinate as carbon source. The nitrogen removal rate was 87.5 mg NO₃ ^?–N l^?1 h^?1. Therefore, this strain is a potential aerobic denitrifier for the treatment of saline wastewater.     

Control of carbon and ammonium ratio for simultaneous nitrification and denitrification in a sequencing batch bioreactor

This study shows how the carbon and nitrogen (C/N) ratio controls the simultaneous occurrence of nitrification and denitrification in a sequencing batch reactor (SBR). Data demonstrated that a low C/N ratio resulted in a rapid carbon deficit, causing an unbalanced simultaneous nitrification–denitrification (SND) process in SBR. When the initial COD/NH₄⁺-N ratio was adjusted to 11.1, the SND-based SBR achieved complete removal of NH₄-N and COD without leaving any NO₂⁻-N in the effluent. The nitrogen removal efficiency decreases gradually with increasing ammonium-loading rate to the SND–SBR system. Altogether, data showed that appropriate controls of carbon and nitrogen input are required to achieve an efficient SND–SBR. An established SND technology can save operation time and energy, and might replace the traditional two-stage biological nitrification and denitrification process.     

Improved simultaneous nitrification and denitrification in a single reactor by using two different immobilization carriers with specific oxygen transfer characteristics

To maximize nitrogen utilization rates during nitrification and denitrification in a simultaneous reaction for direct nitrogen removal from ammonia–nitrogen in a single reactor, two different carriers were applied that immobilized nitrifiers and denitrifiers separately. With the optimized DO concentration and mixing ratio of immobilization carriers, ammonium–nitrogen was successfully removed as designed until the middle phase of treatment where nitrogen removal rate was higher than 83% of the theoretical value, although an imbalance between nitrification and denitrification occurred at a later phase of treatment where residual nitrate–nitrogen concentration was less than 2 mg/l. The new approach using two different carriers to immobilize nitrifiers and denitrifiers separately was proved useful for controlling both nitrification and denitrification rates, enabling the utilization of maximum treatment ability of both nitrifiers and denitrifiers in a single reactor for direct nitrogen removal from ammonium–nitrogen.     

Closed water recirculating system for fish rearing equipped with bioreactor capable of simultaneous nitrification and denitrification.

Five crucian carp, Carassius auratus langsdorfiicarps had been reared in a closed water recirculating system. The system was equipped with the compact bioreactor using the plate gels capable of both nitrification and denitrification in a single unit. Ammonia and nitrite concentrations in the rearing water had been maintained below 0.05 mg-N/L, and nitrate concentration also controlled between 2 and 8 mg-N/L with the bioreactor. As concerns nitrogen budget in the closed system, 95.0% of nitrogen income from feed was lost as nitrogen gas from the closed system. All fish was alive for 91 days without any unusual behavior. Thus, the bioreactor performed both nitrification and denitrification abilities enough to rear the five fish for 91 days. The bioreactor using the plate gels would be effective to simplify the closed system both physically and operationally, since it can remove the ammonia excreted from fish as nitrogen gas by a single step.     

Biofilm stratification during simultaneous nitrification and denitrification (SND) at a biocathode

The aeration of the cathode compartment of bioelectrochemical systems (BESs) was recently shown to promote simultaneous nitrification and denitrification (SND). This study investigates the cathodic metabolism under different operating conditions as well as the structural organization of the cathodic biofilm during SND. Results show that a maximal nitrogen removal efficiency of 86.9 ± 0.5%, and a removal rate of 3.39 ± 0.08 mg N L⁻¹ h⁻¹ could be achieved at a dissolved oxygen (DO) level of 5.73 ± 0.03 mg L⁻¹ in the catholyte. The DO levels used in this study are higher than the thresholds previously reported as detrimental for denitrification. Analysis of the cathodic half-cell potential during batch tests suggested the existence of an oxygen gradient within the biofilm while performing SND. FISH analysis corroborated this finding revealing that the structure of the biofilm included an outer layer occupied by putative nitrifying organisms, and an inner layer where putative denitrifying organisms were most dominant. To our best knowledge this is the first time that nitrifying and denitrifying microorganisms are simultaneously observed in a cathodic biofilm.     

Mixed culture of nitrifying bacteria and denitrifying bacteria for simultaneous nitrification and denitrification

A mixed culture containing nitrifying bacteria and denitrifying bacteria was investigated for aerobic simultaneous nitrification and denitrification. A mixture of NaHCO₃ and CH₃COONa was selected as the appropriate carbon source for cell growth and nitrogen removal, the concentrations of carbon and nitrogen sources were also examined. Ammonia could be oxidized aerobically to nitrite by the mixed culture, and the intermediate nitrite was then reduced to dinitrogen gas. No nitrite was detected during the process. 0.212 g of ammonia/l could be removed in 30 h and nitrate could not be utilized aerobically by the mixed culture. Nitrite could be degraded aerobically as well as anaerobically. Very little ammonia was degraded anaerobically, but the ability to degrade ammonia could be recovered even after oxygen had been supplied for 42 h.     

Effect of sludge age on simultaneous nitrification and denitrification in membrane bioreactor

This study evaluated the effect of sludge age on simultaneous nitrification and denitrification in a membrane bioreactor treating black water. A membrane bioreactor with no separate anoxic volume was operated at a sludge age of 20 days under low dissolved oxygen concentration of 0.1-0.2 mg/L. Its performance was compared with the period when the sludge age was adjusted to 60 days. Floc size distribution, apparent viscosity, and nitrogen removal differed significantly, together with different biomass concentrations: nitrification was reduced to 40% while denitrification was almost complete. Modelling indicated that both nitrification and denitrification kinetics varied as a function of the sludge age. Calibrated values of half saturation coefficients were reduced when the sludge age was lowered to 20 days. Model simulation confirmed the validity of variable process kinetics for nitrogen removal, specifically set by the selected sludge age.     

Loss of nitrogen in compacted grassland soil by simultaneous nitrification and denitrification

The soils of mid-Wales in grazed permanent pasture usually exhibit stagnogley features in the top 4–10 cm even though on sloping sites, they are freely drained. Nitrogen is often poorly recovered under these conditions. Our previous studies suggest that continuing loss of available N through concurrent nitrification and denitrification might provide an explanation for poor response to fertilizer N. The work described was designated to further test this proposition. When NH ₄ ⁺ –N was applied to the surface of intact cores, equilibrated at –5kPa matric potential, about 70% of NH ₄ ⁺ –N initially present was lost within 56 days of incubation. Study of different sections of the cores showed a rise in NO ₃ ^- level in the surface 0–2.5 cm soil layer but no significant changes below this depth. The imbalance between NO ₃ ^- accumulation and NH ₄ ⁺ disappearance during the study indicated a simultaneous nitrification and denitrification in the system. Furthermore, the denitrification potential of the soil was 3–4 times greater than nitrification potential so no major build-up of NO ₃ ^- would be expected when two processes occur simultaneously in micro-scale. When nitrification was inhibited by nitrapyrin, a substantial amount of NH ₄ ⁺ –N remained in the soil and persisted till the end of the incubation. The apparent recovery of applied N increased and of the total amount of N applied, 50% more was recovered relative to without nitrapyrin. It appears that addition of nitrapyrin inhibited nitrification, and consequently denitrification, by limiting the supply of NO ₃ ^- for denitrifying organisms. Emission of N₂O from the NH ₄ ⁺ amended soil cores further confirmed that loss of applied N was the result of both nitrification and denitrification, which occurred simultaneously in adjacent sites at shallow depths. This N loss could account for the poor response to fertilizer N often observed in pastoral agriculture in western areas of the UK.     

Characteristics of extracellular polymeric substances from sludge and biofilm in a simultaneous nitrification and denitrification system under high salinity stress

The composition and distribution of extracellular polymeric substance (EPS) both from suspended sludge and attached biofilm were investigated in a simultaneous nitrification and denitrification (SND) system with the increase of the salinity from 1.0 to 3.0 %. Fourier-transform infrared (FTIR) spectroscopy and three-dimensional excitation-emission matrix (3D-EEM) fluorescence spectroscopy were used to examine proteins (PN), polysaccharides (PS) and humic substances (HS) present in EPS. High total nitrogen removal (above 83.9 %) via SND was obtained in the salinity range of 1.0–2.5 %. Total EPS in the sludge increased from 150.2 to 200.6 mg/gVSS with the increase of salinity from 1.0 to 3.0 %, whereas the corresponding values in the biofilm achieved the maximum of 288.6 mg/g VSS at 2.0 % salinity. Dominant composition of EPS was detected as HS in both sludge and biofilm, having the percentages of 50.6–68.6 and 41.1–69.9 % in total EPS, respectively. Both PN and PS contents in soluble EPS (S-EPS), loosely bound EPS (LB-EPS) and tightly bound EPS (TB-EPS) of sludge and biofilm increased with the increased salinity. The FTIR spectrum and 3D-EEM fluorescence spectroscopy of S-EPS, LB-EPS and TB-EPS in the sludge and biofilm showed the changes of functional groups and conformations of the compositions in EPS with the increase of salinity. The results demonstrated that the characteristics of EPS varied from sludge to biofilm. The obtained results could provide a better understanding of the salinity effect on the EPS characteristics in a SND system.     

Nitrogen-removal bioreactor capable of simultaneous nitrification and denitrification for application to industrial wastewater treatment

A bioreactor system with 30 packed gel envelopes was installed in a thermal power plant for the removal of nitrogen from ammonia-containing desulfurization wastewater. Each envelope consisted of double-sided plate gels containing Nitrosomonas europaea and Paracoccus denitrificans cells with an internal space in between for injecting an electron donor. The envelope can remove ammonia from wastewater in a single step. When the wastewater was continuously treated with the bioreactor system, it removed 95.0% of the total nitrogen in the inlet, and the total nitrogen concentration in the outlet was below 9.0 mg L⁻¹. The maximum nitrogen removal rate was 6.0 g day⁻¹ per square meter of the gel area. The maximum utilization efficiency of the injected ethanol for denitrification was 98.4%, and the total organic carbon concentration in the outflow was maintained at a low level. Since the bioreactor system could use the electron donor effectively, it was not necessary to use an additional aerobic tank to remove the electron donor and a settling tank to segregate the surplus sludge containing bacteria from wastewater. Our concept of using packed gel envelopes would be highly effective for constructing a simple and efficient nitrogen removal system capable of simultaneous nitrification and denitrification.     

Study of operational conditions of simultaneous nitrification and denitrification in a Carrousel oxidation ditch for domestic wastewater treatment

The study on the operational conditions of simultaneous nitrification and denitrification (SND) in the channel of oxidation ditch (OD) without the need for a special anoxic tank was carried out based on lab-scale and pilot-scale experiments using real domestic wastewater. The influence of sludge loading and component proportion in influent, temperature, hydraulic retention time (HRT), dissolved oxygen (DO) and operational mode on SND was investigated. The result indicated that the optimal DO (ODO) of SND occurrence was confirmed majorly by the sludge loading of influent and temperature, the high TCOD/NH₃–N and short HRT can enhance the occurrence of SND. A new operational mode was proposed that achieved a higher removal efficiency of 60–70% for total nitrogen by SND with HRT of 4–6 h, and the concentrations of NH₃–N and TN in effluent are less than 5 and 15 mg/L, respectively.     

Effects of temperature on simultaneous nitrification and denitrification via nitrite in a sequencing batch biofilm reactor

A laboratory scale experiment was described in this paper to enhance biological nitrogen removal by simultaneous nitrification and denitrification (SND) via nitrite with a sequencing batch biofilm reactor (SBBR). Under conditions of total nitrogen (TN) about 30 mg/L and pH ranged 7.15–7.62, synthetic wastewater was cyclically operated within the reactor for 110 days. Optimal operation conditions were established to obtain consistently high TN removal rate and nitrite accumulation ratio, which included an optimal temperature of 31 °C and an aeration time of 5 h under the air flow of 50 L/h. Stable nitrite accumulation could be realized under different temperatures and the nitrite accumulation ratio increased with an increase of temperature from 15 to 35 °C. The highest TN removal rate (91.9%) was at 31 °C with DO ranged 3–4 mg/L. Process control could be achieved by observing changes in DO and pH to judge the end-point of oxidation of ammonia and SND.     

An investigation of a process for partial nitrification and autotrophic denitrification combined desulfurization in a single biofilm reactor

In this study, a vertical submerged biofilm reactor was applied to investigate autotrophic partial nitrification/denitrification and simultaneous sulfide removal by using synthetic wastewater. The appropriate influent ratios of ammonia and sulfide needed to achieve partial autotrophic nitrification and denitrification were evaluated with influent ammonium nitrogen ranging from 54.6 to 129.8 mg L^?1 and sulfide concentrations ranging from 52.7 to 412.4 mg S L^?1. The results demonstrated that the working parameter was more stable when the sulfur/nitrogen ratio was set at 3:2, which yielded the maximum sulfur conversion. Batch experiments with different phosphate concentrations proved that a suitable phosphate buffer solution to control pH values could improve synchronous desulfurization denitrification process performance.     

Rate constants for nitrification and denitrification in soils

Summary Rate constants for reactions in flowing solutions in soil can be calculated from extents of reactions as functions of depth, rates of flow, effective biomass of microbes and independent measurements of hydrodynamic dispersion. Constants have been calculated from data in the literature and are shown to be arbitrary unless all of these quantities have been evaluated. Good agreement of constants obtained in laboratory columns and in the field have been obtained for nitrification and denitrification in a few cases.Supported in part by a grant from The National Science Foundation-RANN.     

Salinity effect on simultaneous nitrification and denitrification,microbial characteristics in a hybrid sequencing batch biofilm reactor

Bioprocess and Biosystems Engineering - The effect of increasing salinity on nitrogen removal via simultaneous nitrification and denitrification, microbial activities and extracellular polymeric...