Apparent digestion coefficients for dry matter, protein and essential amino acids in terrestrial ingredients for Pacific shrimp Litopenaeus vannamei (Decapoda: Penaeidae)

Protein quality mainly depends on the essential amino acid (EAA) profile, but also on its bioavailability, because EAA digestibility is generally lower than the analyzed amounts. This information is needed in the aquaculture industry for aquafeed formulation. For this purpose, the apparent digestibility coefficients of dry matter, protein, and essential amino acids of eight feedstuffs of terrestrial origin were determined for the juvenile whiteleg shrimp Litopenaeus vannamei (15-19 g), using 1% chromic oxide as an inert marker. A reference diet was formulated and produced in the laboratory. Eight experimental diets were prepared each with 30% of one of the experimental ingredients added to the reference diet: casein, porcine byproduct meal poultry byproduct meal, corn meal, wheat gluten meal, soybean paste, sorghum meal, and wheat meal. The experiment consisted of a single-factor, completely randomized design with three replicates per treatment. Samples of ingredients, diets and feces were analyzed for nitrogen and amino acids. For amino acid assay, we used reverse-phase high performance liquid chromatography. To avoid partial loss of methionine and cystine, samples of ingredients, diets, and feces were oxidized with performic acid to methionine sulfone and cysteic acid prior to acid hydrolysis. The apparent dry matter and protein digestive utilization coefficients varied from 68% to 109% and from 70% to 103%, respectively. Apparent digestibility of protein for casein, soy paste, wheat meal and wheat gluten were very high (over 90%), corn gluten and poultry byproducts meal showed high protein digestibility (over 80%), but porcine byproducts meal and sorghum meal had low digestibility (76% and 70%, respectively). There was a reasonable, but not total, correspondence between apparent protein digestibility and average essential amino acid digestibility coefficients, except for arginine in corn gluten, phenylalanine and leucine in sorghum meal, phenylalanine in soy paste and lysine in wheat meal and poultry by-product meal. The most digestible feed ingredients for whiteleg shrimp were: wheat gluten, wheat meal and soy paste; poultry byproduct meal and corn gluten were less digestible and the lowest digestibility occurred in porcine byproduct meal and sorghum meal. Feedstuffs exhibited great variability in dry matter, protein and amino acid digestive utilization coefficients, which should be considered when formulating shrimp feeds.     

Response of 40-70 kg barrows and gilts to increasing ideal protein concentrations in the diet

In Belgium, crossing a hybrid dam with a Piétrain sire leads to a rather lean and meaty fattening pig type. A digestibility trial and a performance trial were carried out to determine protein needs of this pig type. Six experimental diets with increasing protein content were formulated with 0.65-1.25% apparent ileal digestible lysine. The feeds were formulated to the ideal protein composition, with lysine as the reference amino acid. Standardised and apparent digestible amino acid values of the extreme diets were measured in a digestibility trial with four gilts cannulated at the end of the ileum, with an average initial and final BW of 39.1 kg and 55.3 kg, respectively, using a protein-free feed to estimate the basal endogenous N-losses. A performance trial at 13-18 weeks of age (40-70 kg BW) was performed with barrows and gilts separately at six protein levels, balanced in lysine, threonine, methionine and tryptophan. The experiment consisted of 11 pens (of 5 animals) per treatment and per sex. Average daily gain (ADG) and feed conversion ratio (FCR) reached maximal performance within the experimental lysine range for both sexes. Based on the ADG-data for barrows and on the ADG- and FCR-data for gilts, a protein level for optimal performance corresponded with a standardised ileal digestible lysine concentration of 0.89% for barrows and of 1.07-1.09% for gilts.     

The nutritive value of concentrate feedstuffs for ruminant animals: Part I: In situ ruminal degradability of dry matter and organic matter

The aim of the study was to generate a database of ruminal degradability of dry matter (DM), and organic matter (OM) of different sources of concentrate ingredients (classified as protein, energy or protein+energy feeds) commonly offered to ruminants in European countries. The ruminal disappearance of DM and OM was measured using the in situ nylon bag technique, where the test feedstuffs were subject to ruminal incubation in four Friesian steers offered grass silage and concentrate. Disappearance of DM and OM from the test feeds from the rumen was measured at 0, 2, 4, 8, 14, 24 and 48 h. The exponential model of Ørskov and McDonald (1979) was used to calculate degradation kinetics. Test protein feeds were sunflower meal (SUN), rapeseed meal (RAP), soyabean meal (SBM) and cottonseed meal (CSM). Test energy feeds were palm kernel meal (PK), pollard (PO), barley (BA) and beet pulp (BP). Test protein+energy feeds were maize distillers grains (MDG), maize gluten feed (MGF), copra meal (CO) and malt combings (MC).

The effective degradability (degradability of feed, whilst considering rate of flow of feed from rumen to small intestine) of DM (EDDM) and OM (EDOM) in the protein feed SBM, where outflow rate k=0.02, was not influenced (P>0.05) by the sample of feed used. For the feeds classified as protein+energy feeds, the EDDM in MGF and MC were not affected (P>0.05) by the sample of feed for k=0.02. For the remainder of the concentrate feedstuffs used in this study, the sample of feed used had a pronounced effect on in situ degradability values. These data have shown that for the majority of feeds examined in this study, the different sources of any one feed are not equal in nutritive value and it is necessary to screen feeds for nutritive value before using them in ration formulation systems.     

The nutritive value of concentrate feedstuffs for ruminant animals: Part II: In situ ruminal degradability of crude protein

The objective of the study was to generate a database of in situ ruminal degradability of crude protein (CP) from different samples of a range of concentrate feedstuffs comprising protein, energy or protein+energy feeds commonly offered to ruminant animals in European countries. The in situ disappearance of CP was calculated using the in situ nylon bag technique where the test feedstuffs were subject to ruminal incubation in four Friesian steers offered grass silage and concentrate. Disappearance of CP from the test feeds from the rumen was measured at 0, 2, 4, 8, 14, 24 and 48 h. The exponential model of Ørskov and McDonald (1979) was used to measure degradation kinetics of CP. Test protein feeds were sunflower meal (SUN), rapeseed meal (RAP), soyabean meal (SBM) and cottonseed meal (CSM). Test energy feeds were palm kernel meal (PK), pollard (PO), barley (BA) and beet pulp (BP). Test protein+energy feeds were maize distillers grains (MDG), maize gluten feed (MGF), copra meal (CO) and malt combings (MC). The effective degradability of CP (EDP) in the protein feed SBM, where outflow rate (k)=0.02 was not influenced (P>0.05) by the sample of feed used. For the energy feeds, the EDP in PO for k=0.05 h⁻¹, 0.06 h⁻¹ and 0.08 h⁻¹ and EDP in BA for k=0.08 h⁻¹ were not significantly affected (P>0.05) by the sample of feed used. The data has shown that for the majority of feeds examined in this study, the different samples of any one feed are not equal in nutritive value and it is necessary to screen feeds for nutritive value before using them in ration formulation systems.     

Use of soybean flour (dehulled, solvent-extracted soybean) as a fish meal substitute in practical diets for African catfish, Clarias gariepinus (Burchell 1822): growth, feed utilization and digestibility

Growth and digestibility trials were conducted using African catfish, Clarias gariepinus (Burchell 1822): (1) to obtain apparent digestibility coefficient (ADC) values for capelin fish meal, soybean flour and corn meal; (2) to formulate diets based on ADC values of the protein feedstuffs; and (3) to evaluate the effects of replacing 25%, 50% and 75% of fish meal in control diets with soybean flour on growth, feed utilization efficiency and carcass composition. Supplemental methionine was added to the diet formulation in which soybean flour replaced 75% of the diet. Diets were formulated (400 g digestible protein kg⁻¹ and 15 kJ digestible energy g⁻¹ dry diet) and fed to catfish fingerlings (13.1 ± 0.5 g) to apparent satiation twice daily for 70 days. The protein and energy digestibilities of fish meal and soybean flour were high (>90% and >80%, respectively; P < 0.05). At 75% fish meal replacement with soybean flour (without methionine supplementation), growth and feed utilization efficiency indicators were depressed compared with other diet treatments which had a similar (P > 0.05) growth and feed utilization efficiency to those fed the control diet. The carcass compositions of catfish in all diets were similar (P > 0.05) and the liver histology of catfish fed any of the diets showed no alterations. The results obtained indicate that 50% of fish meal protein in practical catfish diets can be replaced with soybean flour and that catfish can effectively utilize supplemental methionine, thereby allowing up to 75% of the dietary fish meal protein to be replaced by soybean flour.     

Nutritional evaluation of wheat and barley cultivars by growth rate and body composition of larvae of Tenebrio molitor.

Larvae of the yellow mealworm, Tenebrio molitor L., Gembloux strain, race F, were reared on diets of 17 cultivars of wheat and 29 cultivars of barley, prepared for determination of digestible energy with mice, for 4 weeks at 27 +/- 0.25 degrees C and 65 +/- 5% relative humidity. Values for percentage crude protein of tissues of larvae fed wheat cultivars were significantly and positively correlated with values for digestible energy as determined with mice. These values were not correlated for larvae fed barley cultivars; however, values for per cent dry matter content of larvae were significantly and positively correlated with values for digestible energy determined with mice. This apparent discrepancy is explained on the basis of the chemical constitution of barley and the availability of amino acids of barley to the larvae. Use of larvae of Tenebrio molitor to indicate the digestible energy of cereal grains is feasible, provided that the proper parameter is chosen. Nevertheless, use of this biological method seems more suitable for evaluation of protein quality and of amino acid availability than for a measure of digestible energy of feeds.     

Optimum Ratio of Histidine in the Piglet Ideal Protein Model and Its Effects on Body Metabolism

A 4 ‐ 4 Latin square design was used to determine ileal apparent digestibility of amino acids (AAs) in corn, soybean meal, feather meal and dried whey in young pigs. The data were then to be used in formulating a basal diet for studies on AA metabolism in young pigs. Eight castrates T-cannulated at terminal ileum (average initial body weight 12.5 ± 0.62kg) were divided into 4 groups on the basis of body weight and transferred to individual metabolism crates. They were then fed four experimental diets containing the four feedstuffs to be tested (corn, soybean meal, feather meal and dried whey). The trial lasted 20 days, which included 4 five-day periods for ileal digesta collection. It was found that the digestibility of the AAs was similar to that reported in literature. Based on the findings a basal diet for this research was formulated according to an ideal protein model for the 10 to 20kg piglet, on the basis of digestible AAs and containing 14.13MJ/kg digestible energy, 18.22% crude protein, 1.04% digestible lysine and 0.23% digestible histidine.     

Influence of dietary fibre level and pelleting on the digestibility of energy and nutrients in growing pigs and adult sows

Two experiments were carried out to investigate the effect of pelleting on the apparent total tract digestibility (ATTD) of energy and nutrients according to the dietary fibre (DF) level in growing pigs (experiment 1) and in adult sows (experiment 2). Four diets based on wheat, barley, maize and soybean meal and supplemented with increased contents of a mixture of wheat bran, maize bran, soybean hulls and sugar beet pulp (116, 192, 268 and 344 g NDF/kg dry matter (DM) in diets 1 to 4) were tested. In experiment 1, 32 growing pigs (62 kg average BW), in two replicates and according to a factorial design, were fed one of the four diets, either as mash or as pellets. The digestibility of energy, organic matter (OM) and all nutrients decreased with DF increasing for both feed forms; the reduction was about 1% for each 1% NDF increase in the diet (P < 0.001). Pelleting improved moderately the digestibility of energy and OM (+1.5% and +1.0%, respectively; P < 0.05) in connection with greater DF (+5%; P < 0.05) and fat digestibility (+25%). Thus, pelleting improved the digestible energy content of diets on average by 0.3 MJ/kg of feed DM (P < 0.01). In experiment 2, four adult dry sows (235 kg average BW) were used in a 4 × 4 Latin square design and fed the four diets used in experiment 1 as pellets. The digestibility of energy, OM and macronutrients also decreased with DF increase (P < 0.001; -0.4% per 1% increase of dietary NDF for energy) while the digestibility of DF (i.e. crude fibre (CF) or ADF) increased (P < 0.001) or remained at a high level. In conclusion, increasing DF in diets decreases the digestibility of nutrients and energy in pigs and in sows. Although positive, the pelleting impact is minor on the energy and nutrients digestibility of fibre-rich diets in growing pigs, even in high-DF diets.     

Ruminal phosphorus availability from several feedstuffs measured by the nylon bag technique

The present study was aimed at determining rumen phosphorus availability of some feedstuffs assessed with the nylon bag technique: forage (alfalfa), cereals (control-C wheat, formaldehyde treated-FT wheat, barley, corn), cereal by-products (wheat bran, wheat distillers, corn distillers) and meals (C and FT soya bean meals, rapeseed meals and sunflower meals). Rumen phosphorus availability was not uniform amongst the feedstuffs, varying from 33.1% (FT rapeseed meal) to 84.7% (C wheat). Alfalfa phosphorus release kinetics showed high bacterial phosphorus contamination. Technological treatments affected phosphorus content of by-products by either increasing (wheat bran and distillers) or decreasing (corn distillers) after germ extraction from the seed. Formaldehyde treatment decreasing rumen phosphorus availability (from 77.2% vs. 89.4% for wheat to 33.1% vs. 64.4% for the rapeseed meal) may depreciate the phosphorus nutritional value of FT meals.     

Digestibility of phosphorous in cereals and co-products for animal feed

Feed ingredients used in swine diets contain various levels and availabilities of nutrients. Nutritional precision evaluation of each ingredient is necessary for formulating diets of pigs. Especially, phosphorous (P) is one of important nutrients for metabolism. However, current data of P digestibility were most apparent digestibility. Therefore, this study was aimed to estimate the coefficient of total tract standardized digestibility (CTTSD) of P in cereals and various co-products used in pig diet. Twelve barrows (initial BW?±?SD, 46.70?±?3.21?kg) were used in this experiment. The experimental design was a 12?×?8 incomplete Latin square with 12 diets and 8 periods. Experimental diets were consisted of barley, wheat, lupine kernel (LK), soybean meal (SBM), almond meal (AM), corn gluten meal (CGM), corn gluten feed from China (CGF-C), corn gluten feed from Korea (CGF-C), wheat bran (WB), rice bran (RB), lupine hull (LH) and P-free diet. The CTTAD of Ca was higher in AM than RB and CGF-K. The LK and CGM showed greater CTTSD of P than RB and LH. In conclusion, our results indicated that the cereals and co-products as P sources were the ideally used as an ingredient in mixed diets of the growing-finishing pigs.     

Determination of energy and amino acid digestibility in growing pigs fed corn distillers' dried grains with solubles containing different lipid levels

Two experiments were conducted to estimate the digestibility of energy, nitrogen and amino acids (AA) in growing pigs fed diets containing one of five corn distillers' dried grains with solubles (DDGS), including three normal oil DDGS (NO-DDGS) and two low oil DDGS (LO-DDGS) samples. Exp. 1 was conducted to determine the digestible energy (DE) and metabolisable energy (ME) content. Six growing barrows (initial body weight [BW]: 35.1 +/- 2.2 kg) were allotted to a 6 x 6 Latin square design, with six periods and six diets. One diet was a corn soybean meal basal diet and the other five diets were based on corn, soybean meal and 28.8% DDGS. The average DE and ME values for the three NO-DDGS samples were 16.0 and 14.9 MJ/kg dry matter (DM). These values were 9 and 13% greater than the LO-DDGS values of 14.7 and 13.2 MJ/kg DM respectively. Exp. 2 was conducted to determine and compare apparent (AID) and standardised (SID) ileal digestibility for crude protein and AA in the five DDGS samples. Six growing barrows (initial BW, 32.2 +/- 1.9 kg) fitted with a simple T-cannula were allotted to a 6 x 6 Latin square design with six periods and six diets. Five of the diets were based on the five DDGS samples, and the remaining one diet was nitrogen-free diet based on cornstarch and sucrose. Titanium dioxide (0.1%) was used as inert marker. The results of the experiment showed the largest variation among the different samples in AID and SID for lysine (from 41.8 to 65.8% and 53.8 to 73.9% respectively) and threonine (from 54.3 to 73.8% and 65.2 to 79.5% respectively). Also, among the indispensable AA, the SID values for arginine, histidine, threonine and tryptophan observed in LO-DDGS were not different from the values derived from NO-DDGS. In conclusion, LO-DDGS may have decreased energy compared with NO-DDGS because of its lower fat content. However, oil removal during the production of DDGS may not affect amino acid digestibility.     

Amino Acid Profile of Escaped Feed Protein After Rumen Incubation and Their Intestinal Digestibility

The crude protein content and amino acid profile of seven feedstuffs (linseed meal, maize gluten meal, rapeseed meal, rapeseed meal protected, soybean meal, fullfat soybean extruded and sunflower meal) were determined before and after ruminal incubation for 16h in three bulls with large rumen cannulas. The intestinal disappearance of amino acids was measured using mobile bag technique. Ruminal incubation affected amino acid profile of all experimental feedstuffs. Crude protein degradation varied from 29.3% for maize gluten meal to 86.4% for rapeseed meal. A tendency towards increased disappearance was observed for glutamic acid, histidine, lysine and proline and decreased disappearance for branched-chain amino acids. The intestinal crude protein digestibility was higher than >80%, except rapeseed meal (66.4%) and sunflower meal (77.8%). The least digestible individual amino acids were methionine and isoleucine in rapeseed meal, histidine and methionine in rapeseed meal protected and arginine in sunflower meal. In general, the lowest amino acid digestibilities were found in feedstuffs with the highest fibre content. The feedstuffs show that they have different potential for supplying of limiting amino acids. Of particular value are the feedstuffs with low crude protein degradability in the rumen and high intestinal digestibility of amino acids.     

The influence of feeding level and level of dietary inclusion on the digestibility of barley meal in the pig

Digestibility studies were undertaken with barley meal to examine the effect of levels of inclusion of 0.29 and 0.58 in a basal diet and feed levels of maintenance (560 g DM/d) and three times maintenance (1700 g DM/d).Apparent digestibility of gross energy and N did not vary with level of feeding but values calculated for barley by difference from a 0.58 inclusion in the basal diet were higher (P < 0.05) than those from a 0.29 inclusion. Coefficients obtained by regression were 0.783 for energy and 0.709 for N; the digestible energy value was 14.47 MJ/kg DM. The ratio of metabolisable to digestible energy was 0.968 and the content of digestible N was 12.3 g/kg DM.     

饲料营养成分对草鱼,团头鲂和青鱼鱼种阶段的饲料可消化能值的影响

为了探讨饲料可消化能值同饲料营养成分之间的关系,用Ｃｒ２Ｏ３作指示物,分别测定了鱼粉和大豆粕等饲料原料的草鱼（Ｃｔｅｎｏｐｈａｒｙｎｇｏｄｏｎ　ｉｄｅｌｌａ）团头鲂（Ｍｅｇａｌｏｂｒａｍａ ａｍｂｌｙｏｃｅｐｈａｌａ　Ｙｉｈ）青鱼（Ｍｙｌｏｐａｒｙｎｇｏｄｏｎ　ｐｉｃｅｕｓ）鱼种饲料的可消化能,用微机计算分析测试结果,发现饲料可消化能值随饲料蛋白质和／或脂肪食量增加而增加;随饲料无氮浸出物和／或纤维含量增加而降低。同时,“优选”出了有一定实用价值的估算草鱼、团头鲂和青鱼鱼种饲料可消化能值的回归方程。     

Protein value of cereals and cereal by-products for ruminants: a comparison between crude protein and protein-based estimates

In situ estimates of ruminal undegraded fraction (RU) and effective intestinal digestibility (EID, corrected for microbial colonisation) of dry matter (DM), crude protein (CP) and total analysed amino acids (TAA) of rye, wheat and corn grains, wheat bran, wheat and barley distillers’ dried grains with solubles (DDGS) and corn gluten feed were measured on three rumen and duodenum cannulated wethers using ¹⁵N labelling techniques and considering ruminal rates of particle comminution (k_c) and outflow. Results indicate that not considering k_c and microbial colonisation led to considerable overestimations of RU which increased with feed ruminal degradation. Microbial colonisation may be also associated with overestimations of EID, whose estimates for DM, CP and TAA were predicted from parameters related with the ruminal escape of intestinally indigestible materials. The RU estimates were higher for TAA than for CP in grains, but the opposite was observed in by-products, whereas EID estimates were higher for TAA in all feeds. To obtain accurate protein values in these feedstuffs, it is required to consider both k_c and ruminal microbial colonisation. The CP-based results underestimate the intestinally digested protein in grains and the opposite is evidenced in cereal by-products. Microbial protein synthesised in the rumen is largely the major fraction of the feedstuff protein value with the exception of DDGS.     

The energy systems used in the EEC countries: Their application to 24 commercial pig-feeds and relationships between them

In the EEC countries, eight different energy systems are used to evaluate pig feeds: Nettoenergie Fett (NEF_s); Net Energy Growth (NEG_s); Gesamtnährstoff (GN); Energiezahl Schwein (EZS) (original and modified forms); Total Digestible Nutrients (TDN); Digestible Energy (DE); and Metabolizable Energy (ME). In order to evaluate commercial mixed feeds according to these different energy systems, 24 feeds (300 kg in 50-kg bags) were bought on the Belgian market and analysed for crude protein, ether extract, crude fibre, nitrogen extractives (NFE), moisture, ash, starch and sugars. The digestibility of protein, ether extract, crude fibre and NFE fraction of each feed was determined with 4 barrows of 40–50 kg live weight. These figures were used to calculate the energy value of each mixed feed according to the eight different systems.Finally, the different energy systems were compared by linear regression calculation. It was found that the different energy systems (except for both forms of the Energiezahl Schwein system) correlate highly when applied to mixed pig-feeds, and that the residual standard deviations are small (between 0.09 and 1.83%).These findings are important in the context of the efforts of the EEC Commission to find a commonly acceptable energy index for mixed pig-feeds. Although the physiological bases are totally different, most energy systems classify the various mixed feeds in exactly the same order. This means that the energy value according to one system can easily be calculated, with reasonable accuracy (small r.s.d.), from figures calculated according to a second system.     

Natural occurrence of zeralenone in feeds and feedstuffs used in poultry and pig nutrition in colombia

A total of 200 samples of feedstuffs and mixed feeds used for poultry and pig nutrition in Colombia were analysed for zearalenone using a LC technique with a limit of detection of 20 μg/kg. Samples of grain sorghum, maize, processed soybean, rice meal, cottonseed meal, and poultry and pig feeds, representative of the Colombian production for the 1995–1996 harvest, were taken at feed manufacturing plants located in different cities of the country. Zearalenone was detected in 25 of 45 samples of sorghum, 2 of 33 samples of maize, 7 of 22 samples of rice meal, 9 of 17 samples of cottonseed meal, 11 of 30 samples of poultry feed and 6 of 16 samples of pig feed. Zearalenone was not detected in soybean or other feedstuff s analysed (wheat by- products, cassava meal, palm). Overall levels of zearalenone ranged from 29 to 3956 μg/kg, with a mean value of 436 μg/kg. Only one of the 6 positive samples of pig feed had a zearalenone concentration above 500 μg/kg, which is normally considered as the safe level for pigs.     

Nitrogen in vivo digestibility and in situ degradability data for estimation of lower tract N digestibility with or without correction for microbial contamination

In situ degradability and in vivo (by difference) digestibility trials were conducted to estimate lower tract residual N digestibility (LTRND) of five protein supplements. Efforts were also made to improve the in situ method of measuring protein degradability. For in situ degradability trials, soybean meal (SBM), corn gluten meal (CGM), cotton seed cake (CSC), wheat bran (WB) and corn gluten feed (CGF) were weighed into Dacron bags and incubated in the rumen of three cannulated Chios ewes. SBM, CGF and WB were degraded significantly, while CGM and CSC were least degraded. Microbial contamination (MC) resulted in a 5.3–28.3% artificially decrease in effective ruminal protein degradation of supplements. Total tract digestibility was measured using five rams in an in vivo, by difference, trial using a 5 × 5 Latin-square design. SBM had higher CP digestibility compared to WB, CGF and CSC, and higher N free extract (NFE) digestibility compared to the other feeds. CGM showed higher CP digestibility compared to WB, CGF or CSC, while CGF had higher organic matter (OM) and crude fibre (CF) digestibility compared to WB. CSC was the protein source with the lowest digestibility of OM, CP and NFE in comparison with the other feeds. LTRND was predicted as 0.928, 0.806, 0.227, 0.540, and 0.498 for SBM, CGM, CSC, WB, and CGF, respectively, or 0.931, 0.803, 0.147, 0.364, and 0.316 when the correction for MC was applied. Lower tract N digestibility could be predicted via a combination of in situ degradability and in vivo apparent digestibility data. This approach yields significant data regarding LTRND estimation of protein supplements, while diminishing animal suffering by avoiding small intestinal fistulation.     

Influence of incrementally substituting dietary soya bean meal for rapeseed meal on nutrient digestibility, nitrogen excretion, growth performance and ammonia emissions from growing-finishing pigs

A completely randomised design experiment was performed to examine the effects of replacing different levels of soya bean meal (SBM) with rapeseed meal (RSM) on the growth performance, carcass characteristics, apparent nutrient digestibility, nitrogen (N) balance and manure ammonia emissions of growing-finishing pigs. Pigs (n = 336; mean live weight 42.1 kg) were assigned to one of four dietary treatments containing per kg diet: 210 g SBM; 140 g SBM and 70 g RSM; 70 g SBM and 140 g RSM; and 210 g RSM. All diets were formulated on an ileal digestible amino acid, net energy and available phosphorus basis. There was no significant treatment effect on average daily gain, feed intake, feed conversion ratio and carcass characteristics. There was a linear decrease in gross energy digestibility (p < 0.01) as RSM increased at the expense of SBM in the diet. There was a linear decrease in urinary N excretion (p < 0.01), N digestibility (p < 0.05), total N excretion (p < 0.05) and N retention (p < 0.05) with increasing levels of RSM. There was no effect of dietary treatment on manure ammonia emissions. The results of this study indicate that RSM can be used as a direct replacement for SBM with no associated depression in performance, when formulated on an ileal digestible amino acid and net energy basis. Consumption of diets containing incremental levels of RSM linearly decreased urinary N and total N excretion, reflecting the associated decrease in crude protein concentrations.     

Predicting feed digestibility from NIRS analysis of pig faeces

Digestibility is a key parameter in the evaluation of feeds; however, the measurements on animals require heavy experimental trials, which are hardly feasible when large numbers of determinations are required – for example, in genetic studies. This experiment aimed at investigating the possibility to predict digestibility from NIRS spectra measured on faeces. A total of 196 samples were available from a digestibility experiment investigating the effects of age and genetic background of Large White pigs fed the same diet, rich in fibre (NDF=21.4% DM). Digestibility of dry matter (dDM), organic matter (dOM), nitrogen content (dN), energy (dE) and apparent digestible energy content (ADE) were calculated, as well as total N content of faeces (N). The faeces samples were submitted to reflectance NIRS analysis after freeze-drying and grinding. Calibration errors and validation errors were, respectively, 0.08 and 0.13% DM for total N in faeces, 0.97% and 1.08% for dDM, 0.79% and 1.04% for dOM, 1.04% and 1.47% for dN, 0.87% and 1.12% for dE and 167 and 213 kJ/kg DM for ADE. These results indicate that NIRS can account for digestibility differences due to animal factors, with an acceptable accuracy. NIRS appears to be a promising tool for large-scale evaluations of digestibility. It could also be used for the study of digestibility of different feeds, after appropriate calibration based on a wide range of feed types.