Microcalorimetric study of aerobic growth of Cellulomonas sp. 21399 on various carbohydrates

Summary Microcalorimetry was used to study the energetic aerobic growth of Cellulomonas sp. 21399 on glucose, cellobiose and amorphous and crystalline cellulose. The thermochemical aspect of growth on glucose was established with regard to the anabolic contribution. The results obtained allowed the use of glucose as a reference substrate for cellulose degradation. The experimental enthalpy change and the maximum catabolic activity, calculated from the maximum power evolved by the culture, were, respectively,-1079 kJ/mol and 0.85 mmol glucose per hour per dry weight of cells. The growth response on amorphous cellulose was equivalent to that demonstrated on glucose. However, on crystalline cellulose media, Cellulomonas sp. 21399 exhibited eight times less power and the quantity of heat evolved during growth showed that 50% of the cellulose was degraded. Quantitative results and the shape of power-time curves achieved indicate that the structural features of cellulose strongly influence its microbial degradability.     

Degradation of microcrystalline cellulose: synergism between different endoglucanases of Cellulomonas sp. ATCC 21399

Three immunologically and enzymatically distinct endoglucanases of Cellulomonas sp. ATCC 21399 were purified previously. Endoglucanase A and endoglucanase B acted synergistically on microcrystalline cellulose (Avicel), whereas no synergistic action was observed between endoglucanase B or endoglucanase C. Only endoglucanase A was capable of hydrolyzing Avicel when acting alone and this enzyme resulted in "short fiber formation" when acting on Avicel. The end product of hydrolysis of acid swollen Avicel produced by the three endoglucanases was in all cases dominated by cellobiose and showed lower content of glucose and cellotriose. Higher cellodextrins appeared as transient end products. The results indicate that the function of endoglucanase A in the cellulase system of Cellulomonas might be very similar to the function of the cellobiohydrolases of Trichoderma reesei.     

Purification of an extracellular cellulose-binding endoglucanase of Cellulomonas sp. ATCC 21399 by affinity chromatography on H3PO4-swollen cellulose

A cellulose-binding endoglucanase (endoglucanase A) of Cellulomonas sp. ATCC 21399 was purified to immunological homogeneity by affinity chromatography ob H(3)PO(4)-swollen cellulose. This method of purification turned out to be an easy and very gentle method for obtaining a high yield of cellulose-binding endoglucanase. The purified enzyme was immunologically homogeneous but appeared heterogeneous when analyzed by denaturing polyacrylamide gel electrophoresis. In addition to the cellulose-binding of endoglucanase A, the enzyme also had a strong affinity for Concanavaline A, indicating that the enzyme was glycosylated. Purified endoglucanase A showed an endo mode of action on carboxymethylcellulose. The enzyme could hydrolyze microcrystalline cellulose when acting alone, and the enzyme had a high specific activity on H(3)PO(4)-swollen cellulose.     

Crystalline index change in cellulose during aerobic and anaerobic Cellulomonas uda growth

Summary Cultures of Cellulomonas uda were monitored under both aerobic and anaerobic conditions using three commercially available celluloses with varying degrees of crystallinity. In all cases, a high level of cellulose was metabolized and the same maximum carboxymethylcellulase activity (2.6 IU/mg of cellular protein) was observed. Measurement of the crystalline index of celluloses during cellulose growth revealed that the amorphous and crystalline regions were solubilized simultaneously. Investigation of the solubilization rate showed that a decline occurred when a considerable amount of cellulose still remained in the medium. Hypotheses were suggested to explain the biphasic pattern of the kinetics obtained.     

Growth and enzyme production of Cellulomonas sp. ATCC 21399 on microcrystalline cellulose. Effects of increasing concentration of a mineral medium

Summary The kinetics and production of different extracellular enzyme activities were studied during growth of Cellulomonas sp. ATCC 21399 on 2% Avicel with different concentrations of M9 mineral medium. The lag phase and the doubling time increased with increasing ionic strength of the medium. The highest cell density was obtained during growth at 5 x M9 mineral medium and Cellulomonas grew well at this high salinity. The enzyme activities against carboxymethylcellulose and xylan increased with increasing concentration of M9 medium up to 5 x M9. By contrast, activities against microcrystalline cellulose (Avicel), galactomannan and amylose decreased with increasing concentration of M9 medium. The extracellular proteinase activity increased with increasing concentration of M9 medium, and it is possible that the lability of the cellulolytic and amylolytic enzymes may be due to their susceptibility to proteolytic inactivation by the extracellular proteinases.     

Growth of Cellulomonas sp. ATCC 21399 on different polysaccharides as sole carbon source Induction of extracellular enzymes

Summary Growth and extracellular enzyme production of Cellulomonas sp. ATCC 21399 on carboxymethylcellulose (CMC), microcrystalline cellulose (Avicel), xylan, galactomannan and starch were compared. The bacteria grew poorly on CMC, whereas high cell densities were obtained on the other substrates. Growth on Avicel resulted in extracellular enzyme activities against CMC, Avicel, xylan, galactomannan and amylose. By contrast, growth on xylan, galactomannan and starch induced only the enzymes neccessary for the degradation of the growth substrate. Extracellular proteinase activity could be measured during growth on all substrates but CMC, and the possibility of proteolytic inactivation of some of the unstable enzymes (i.e. Avicelase and amylase) in discussed.     

Cellulose degradation and monitoring of viscosity decrease in cultures of Cellulomonas uda grown on printed newspaper

The rheological behavior of cultures of Cellulomonas uda with shredded printed newspaper as the carbon source was studied. The initial substrate concentrations ranged from 23 to 60 g/L. The changes in apparent viscosity were followed on-line by applying a commercially available process viscometer and discretely using a rotational viscometer with an anchor impeller. During the time of highest cellulose degradation, the broths exhibited a pseudoplastic behavior which could be explained satisfactorily by the power-law model. At the end of cultivation when cellulose degradation slowed down, the broths became Newtonian in behavior. Endo-1,4-beta-glucanase, 1,4-beta-xylanase, beta-glucosidase, and beta-xylosidase activities were also determined during cultivation as well as cellulose degradation and cell mass production. The beginning of endoglucanase formation and the start of the final viscosity decrease of the bacterial paper pulp suspensions could be correlated.     

Electrophoretic and enzymatic studies on the crude extracellular enzyme system of the cellulolytic bacterium Cellulomonas sp. ATCC 21399

Cellulomonas sp. ATCC 21399 produced extracellular enzyme activities against Avicel, H(3)PO(4)-swollen Avicel, carboxymethylcellulose, (1-3, 1-4)-beta-D-heteroglucan, xylan, galactomannan, and amylose drying growth on microcrystalline cellulose. No extracellular cellobiase activity was produced. Crossed immunoelectrophoresis of the crude extracellular enzyme system revealed 15 immunologically distinct immunoprecipitates. The immunoprecipitates of endoglucanase A, endoglucanase B and the xylanase appeared heterogeneous with several optima, whereas the immunoprecipitates of endoglucanase C and the amylase appeared homogeneous. The heterogeneity of endoglucanase A, endoglucanase B and xylanase was also visualized using electrofocusing-immunoelectrophoresis. Electro-focusing could resolve the activity against carboxymethylcellulose into six peaks, whereas only one peak of activity against Avicel was observed. The later peak coincided with the major peak of activity against carboxymethylcellulose with isoelectric point between pH 4.0-5.0.     

Production and Properties of Xylan-Degrading Enzymes from Cellulomonas uda

Xylan degradation and production of β-xylanase and β-xylosidase activities were studied in cultures of Cellulomonas uda grown on purified xylan from birchwood. β-Xylanase activity was found to be associated with the cells, although in various degrees. The formation of β-xylanase activity was induced by xylotriose and repressed by xylose. β-Xylosidase activity was cell bound. Both constitutive and inducible β-xylosidase activities were suggested. β-Xylanase and β-xylosidase activities were inhibited competitively by xylose. β-Xylanase activity had a pronounced optimum pH of 5.8, whereas the optimum pH of β-xylosidase activity ranged from 5.4 to 6.1. The major products of xylan degradation by a crude preparation of β-xylanase activity, in decreasing order of amount, were xylobiose, xylotriose, xylose, and small amounts of xylotetraose. This pattern suggests that β-xylanase activity secreted by C. uda is of the endosplitting type. Supernatants of cultures grown on cellulose showed not only β-glucanase but also β-xylanase activity. The latter could be attributed to an endo-1,4-β-glucanase activity which had a low β-xylanase activity.     

Proteomic Analysis of the Secretome of Cellulomonas fimi ATCC 484 and Cellulomonas flavigena ATCC 482

The bacteria in the genus Cellulomonas are known for their ability to degrade plant cell wall biomass. Cellulomonas fimi ATCC 484 and C. flavigena ATCC 482 have been the subject of much research into secreted cellulases and hemicellulases. Recently the genome sequences of both C. fimi ATCC 484 and C. flavigena ATCC 482 were published, and a genome comparison has revealed their full spectrum of possible carbohydrate-active enzymes (CAZymes). Using mass spectrometry, we have compared the proteins secreted by C. fimi and C. flavigena during growth on the soluble cellulose substrate, carboxymethylcellulose (CMC), as well as a soluble xylan fraction. Many known C. fimi CAZymes were detected, which validated our analysis, as were a number of new CAZymes and other proteins that, though identified in the genome, have not previously been observed in the secretome of either organism. Our data also shows that many of these are co-expressed on growth of either CMC or xylan. This analysis provides a new perspective on Cellulomonas enzymes and provides many new CAZyme targets for characterization.     

Effects of end-product inhibition of Cellulomonas uda anaerobic growth on cellobiose chemostat culture

Cellulomonas uda was grown anaerobically in a chemostat with 3.33 and 11.41 mM cellobiose in the feed medium at dilution rates varying from 0.017 to 0.29/h. Unusual results obtained were analyzed by using curves simulating the steady-state biomass. This unusual behavior could be accounted for by a classical growth model taking end-product inhibition into account. Acetate has been identified to be the major inhibitor in the experimental conditions used. Parameters calculated from experimental observations gave theoretical curves of biomass production versus dilution rate which fitted the experimental points very well.     

Formation, Location, and Regulation of Endo-1,4-beta-Glucanases and beta-Glucosidases from Cellulomonas uda

The formation and location of endo-1,4-beta-glucanases and beta-glucosidases were studied in cultures of Cellulomonas uda grown on microcrystalline cellulose, carboxymethyl cellulose, printed newspaper, and some mono- or disaccharides. Endo-1,4-Glucanases were found to be extracellular, but a very small amount of cell-bound endo-1,4-beta-glucanase was considered to be the basal endoglucanase level of the cells. The formation of extracellular endo-1,4-beta-glucanases was induced by cellobiose and repressed by glucose. Extracellular endoglucanase activity was inhibited by cellobiose but not by glucose. beta-Glucosidases, on the other hand, were formed constitutively and found to be cell bound. beta-Glucosidase activity was inhibited noncompetitively by glucose. Some characteristics such as the optimal pH for and the thermostability of the endoglucanases and beta-glucosidases and the end products of cellulose degradation were determined.     

Identification of the major anaerobic end products ofCellulomonas sp. (ATCC 21399)

Summary A novel approach of aerobic growth followed by anaerobic growth was used to identify the anaerobic end products of the facultative organismCellulomonas sp. (ATCC 21399) utilizing cellulose as the substrate. The organism was found to produce an equimolar mixture of ethanol and acetic acid as the two carbon end products.     

酶法降解植物纤维素技术研究

用正交试验法探讨了以麦秸为原料进行纤维素酶降解的工艺条件。正交试验的结果表明,影响麦秸纤维素降解的因素的主次顺序为A（酶添加量）＞B（底物浓度）＞E（时间）＞C（温度）＞D（pH值）,纤维素酶解麦秸纤维素的最佳组合为A3B1E3C3D2,即纤维素酶的添加量为0．2％,底物浓度为5％,反应时间为2h,反应温度50℃,pH5.0时为最佳条件。在比常规酶解法时间缩短12－30倍的条件下,能使纤维素降解葡萄糖的转化率达22．3％。     

Mechanisms of wood degradation by brown-rot fungi: chelator-mediated cellulose degradation and binding of iron by cellulose

Iron, hydrogen peroxide, biochelators and oxalate are believed to play important roles in cellulose degradation by brown-rot fungi. The effect of these compounds in an 'enhanced' Fenton system on alpha-cellulose degradation was investigated specifically in regard to molecular weight distribution and cellulose-iron affinity. This study shows that the degradative ability of an ultrafiltered low molecular weight preparation of chelating compounds isolated from the brown-rot fungus Gloeophyllum trabeum (termed 'Gt chelator') increased with increasing Gt chelator concentration when the FeIII to Gt chelator ratio was greater than about 30:1. When this ratio was less than 30:1, increasing Gt chelator concentration did not accelerate cellulose degradation. In excess hydrogen peroxide, cellulose degradation increased and then decreased with increasing iron concentration when FeIII was present in excess of the Gt chelator. The critical ratio of FeIII to Gt chelator varied depending on the concentration of hydrogen peroxide in the system. Increasing iron concentration above a critical iron:chelator ratio inhibited cellulose degradation. The optimum pH for cellulose degradation mediated by Gt chelator was around 4.0. A comparison of the effects of 2,3-DHBA (a chelator that reduces iron similarly to Gt chelator) and Gt chelator with respect to cellulose degradation demonstrated the same pattern of cellulose degradation. Cellulose-iron affinity studies were conducted at three pH levels (3.6, 3.8, 4.1), and the binding constants for cellulose-FeIII, cellulose-FeII and cellulose-FeIII in the presence of Gt chelator were calculated. The binding constants for cellulose-FeIII at all three pH levels were much higher than those for cellulose-FeII, and the binding constants for cellulose-FeIII in the presence of Gt chelator were very close to those for cellulose-FeII. This is probably the result of FeIII reduction to FeII by Gt chelator and suggests that chelators from the fungus may be able to sequester iron from cellulose and reduce it in near proximity to the cellulose and thereby better promote depolymerization. The free radical generating system described has potential for use in a variety of industrial processing and pollution control applications.     

NMR study of cellulose and wheat straw degradation by Ruminococcus albus 20

Cellulose and wheat straw degradation by Ruminococcus albus was monitored using NMR spectroscopy. In situ solid-state (13)C-cross-polarization magic angle spinning NMR was used to monitor the modification of the composition and structure of cellulose and (13)C-enriched wheat straw during the growth of the bacterium on these substrates. In cellulose, amorphous regions were not preferentially degraded relative to crystalline areas by R. albus. Cellulose and hemicelluloses were also degraded at the same rate in wheat straw. Liquid state two-dimensional NMR experiments were used to analyse in detail the sugars released in the culture medium, and the integration of NMR signals enabled their quantification at various times of culture. The results showed glucose and cellodextrin accumulation in the medium of cellulose cultures; the cellodextrins were mainly cellotriose and accumulated to up to 2 mm after 4 days. In the wheat straw cultures, xylose was the main soluble sugar detected (1.4 mm); arabinose and glucose were also found, together with some oligosaccharides liberated from hemicellulose hydrolysis, but to a much lesser extent. No cellodextrins were detected. The results indicate that this strain of R. albus is unable to use glucose, xylose and arabinose for growth, but utilizes efficiently xylooligosaccharides. R. albus 20 appears to be less efficient than Fibrobacter succinogenes S85 for the degradation of wheat straw.     

Anaerobic degradation of cellulose by mixed culture

A mixed culture in which cellulose is capable of being converted to methane and carbon dioxide was obtained from an inoculum procured from a sewage-treatment plant and maintained in a synthetic medium containing tissue paper and an inorganic salt and vitamin mixture. The culture was tested for its ability to degrade 12 different paper and cotton products under batch conditions in 3-l anaerobic fermenters. This culture degraded 6-8 mmol/l per week of cellulose, expressed as glucose equivalents, with total gas yields of 0.3 m3/kg of cellulose degraded. The gas produced contained between 56 and 59% of methane. Maximum cellulose degradation occurred at chemical oxygen demand:nitrogen:phosphorus level of 80:5:1 and was adversely affected by high stirring rate. Also the presence of higher proportions of lignin in cellulose products adversely affected the ability of this culture to degrade cellulose.     

Factors affecting accumulation and degradation of curdlan, trehalose and glycogen in cultures of Cellulomonas flavigena strain KU (ATCC 53703)

Cellulomonas flavigena strain KU (ATCC 53703) is a cellulolytic, Gram-positive bacterium which produces large quantities of an insoluble exopolysaccharide (EPS) when grown in minimal media with a high carbon-to-nitrogen (C/N) ratio. Earlier studies proved the EPS is structurally identical to the linear β-1,3-glucan known as curdlan and provided evidence that the EPS functions as a carbon and energy reserve compound. We now report that C. flavigena KU also accumulates two intracellular, glucose-storage carbohydrates under conditions of carbon and energy excess. These carbohydrates were partially purified and identified as the disaccharide trehalose and a glycogen/amylopectin-type polysaccharide. A novel method is described for the sequential fractionation and quantitative determination of all three carbohydrates from culture samples. This fractionation protocol was used to examine the effects of C/N ratio and osmolarity on the accumulation of cellular carbohydrates in batch culture. Increasing the C/N of the growth medium caused a significant accumulation of curdlan and glycogen but had a relatively minor effect on accumulation of trehalose. In contrast, trehalose levels increased in response to increasing osmolarity, while curdlan levels declined and glycogen levels were generally unaffected. During starvation for an exogenous source of carbon and energy, only curdlan and glycogen showed substantial degradation within the first 24 h. These results support the conclusion that extracellular curdlan and intracellular glycogen can both serve as short-term reserve compounds for C. flavigena KU and that trehalose appears to accumulate as a compatible solute in response to osmotic stress.