微孔草籽油的超临界CO2流体萃取及HPLC—MS分析

利用超临界CO2萃取微孔草籽油,并对籽油进行了HPLC／MS分析。实验确定的最佳超临界CO2流体萃取条件是：萃取温度45℃,萃取压力20MPa,CO2流量为35-40kg／h,萃取时间120min,在此条件下白刺籽油的萃取率为16．12％。利用HPLC／MS对微孔草籽油分析,发现其不饱和脂肪酸的相对含量高达73．19％。比较了超临界CO2萃取微孔草籽油油样和石油醚萃取微孔草籽油油样的理化性质,发现超临界CO2流体萃取的籽油质量优于传统溶剂萃取的籽油。     

省沽油种子超临界CO2 萃取物中角鲨烯和维生素E的GC-MS分析

用气相色谱-质谱联用(GC-MS)方法对超临界CO2萃取出的省沽油种子油中角鲨烯和维生素E进行分析。省沽油种子油的萃取采用超临界CO2萃取技术,压力25MPa,温度50℃,时间2h;种子油用GC-MS方法分析,以正三十二烷为内标,用内标标准曲线法同时测定省沽油种子油中角鲨烯和维生素E的含量。结果表明:超临界CO2萃取种子油的收率为28.83%;所建立的定量分析方法平均回收率在96.0%~99.0%之间,相对标准偏差小于2.8%,线性相关系数大于0.999,方法检测限在2.0~2.5mg/L之间;省沽油种子油中含角鲨烯4.65%,维生素E1.58%。     

干姜超临界CO2萃取与水蒸气蒸馏工艺比较研究

目的：比较干姜的超临界CO2萃取与水蒸气蒸馏两种工艺的差别,为其在复方制剂中的应用提供工艺设计参考。方法：分别用超临界CO2萃取和水蒸气蒸馏处理干姜药材,采用GC、TLC对产物进行分析比较。结果：超临界CO2萃取产物得率为8．0％,水蒸气蒸馏得率为0．2％,GC、TLC显示超临界CO2萃取物比水蒸气蒸馏样品有较多的成分。结论：干姜的超临界CO2萃取工艺较水蒸汽蒸馏工艺的产物量高,成分较多。     

白果油的提取工艺及其化学成分研究

采用正交实验对超临界CO2萃取白果油的工艺条件进行优化,比较超声波提取、索氏提取、超临界CO2萃取3种方式对白果油提取率的大小,用最佳提取方式分析不同品种白果中油脂的含量,并用GC-MS分析其成分.结果表明: (1)3种提取方式对白果油提取率的大小顺序为:超临界CO2萃取(添加夹带剂)＞索氏提取＞超声波提取.(2)超临界CO2萃取白果油的最佳工艺条件为:温度40℃、压力20 MPa、流速15 L/h、时间3 h并添加石油醚夹带剂,不同品种白果干粉中油脂得率为3.6%～7.11%.(3)GC-MS分析表明:从超临界萃取白果油中鉴定出17种化学成分,其中不饱和脂肪酸占85.4%;超声波和索氏提取相似,分别从提取的白果油中鉴定出10种和9种化学成分,其中不饱和脂肪酸含量分别为90.3%和90.1%;不饱和脂肪酸以十六、十八碳的为主.     

超临界二氧化碳萃取鸢尾油的工艺条件研究

本文采用L9（3^4）正交实验考察了二氧化碳超临界萃取中萃取压力、萃取温度和萃取时间对鸢尾精油提取率的影响。结果表明各影响因子的影响顺序为：压力〉时间〉温度;当原料的颗粒度为60-80目、CO2流量为20．0m^3/h时,用超临界二氧化碳萃取鸢尾精油的最佳工艺条件为：萃取压力26．0MPa,萃取温度55．0℃,萃取完成时间为2．5h,此条件下鸢尾香根中鸢尾油的萃取率高达12．71％,得到的精油中鸢尾酮的含量为39．95％,与索氏法和微波提取法相比,超临界萃取具有提取率高和产品质量好的优点。     

薄荷油超临界CO2萃取条件的优化和筛选

以样品中的薄荷脑含量为指标,通过单因素和正交实验对影响薄荷(Mentha haplocalyx Briq.)油超临界CO2萃取的因素进行研究,筛选出薄荷油超临界CO2萃取的最佳条件.研究结果表明,影响样品中薄荷脑萃取率的因素从大到小依次为萃取压力、萃取温度、萃取时间、CO2流量.样品中薄荷脑含量最高的超临界CO2萃取条件为萃取压力10 MPa、萃取温度50℃、CO2流量30 L·h-1且萃取时间1.5 h.     

超临界二氧化碳萃取亚麻籽油工艺的可视化分析

对采用超临界二氧化碳技术萃取亚麻籽油进行较为系统的研究.选择萃取压力、萃取温度、萃取时间、分离压力4个主要影响因素,运用多因素多水平可视化设计法(m2VD)安排试验.选择分离釜1中产物的质量为试验指标,用自主提出的多因素多水平试验结果可视化分析方法(m2VA)对多维空间试验数据进行分析.得出最佳工艺范围为萃取压力20～ 30 MPa、萃取温度30～46℃、萃取时间77～90 min、分离压力4.0 ～4.7和5.7～5.9 MPa.根据优化工艺范围,在萃取压力为25 MPa、萃取温度40℃、萃取时间83 min、分离压力4.3 MPa下重新试验得到22.87％的得率,对应于质量为34.3 g.     

肾叶天胡荽精油的超临界CO2萃取、成分分析及杀虫活性初探

采用正交实验设计,对肾叶天胡荽（Hydrocotyle wigordi Maxim．）精油超临界CO2萃取条件进行了优化,并用GC—MS分析技术对精油的化学成分进行了鉴定,初步探讨了肾叶天胡荽精油对小菜蛾2龄幼虫的触杀活性。结果表明,肾叶天胡荽精油超临界CO2萃取的最佳条件为萃取压力35MPa、萃取温度50℃、解析压力5MPa、解析温度40℃、萃取时间75min、CO2流量34—36L·h^-1,精油得率最高可达5．32％。从精油中共鉴定出19种成分,总相对含量达到89．266％,主要成分为邻苯二甲酸二辛酯（64．302％）。用超临界CO2萃取技术提取的肾叶天胡荽精油对小菜蛾2龄幼虫有一定的触杀作用,20g·L^-1精油对小菜蛾2龄幼虫的24h校正死亡率高达90．00％。     

超临界CO2萃取百合花挥发油的工艺研究

本文介绍了超临界CO2萃取百合花中挥发油的提取分离工艺,重点研究了超临界CO2萃取压力、温度、时间对出油率的影响。正交试验结果表明：影响超临界CO2萃取的主要因素为C3〉A2〉B2（A为萃取压力,B为萃取温度,C为萃取时间）;最佳工艺参数：SC-CO2萃取压力为18MPa,温度为50℃,时间为90min,流量为25L／min,所得百合花挥发油的出油率高达2．92％。     

砂地柏种子油超临界CO2萃取技术研究

砂地柏(Sabina vulgaris Ant．)种子油是该植物主要的杀虫、杀菌活性组分。通过对砂地柏种子油的超临界CO2萃取工艺进行研究,得出较适宜的工艺条件为：采用先静态后动态的萃取方式,静态萃取时间10min;动态萃取条件为,萃取压力7000psi,萃取温度65℃,CO2流量为40mL／g;限流管温度80℃,用石油醚(沸程60-90℃)接受。初步认为SC-CO2萃取砂地柏种子油优于常规提取方法。同时对该技术工业化应用前景和可行性进行了分析探讨。     

Effects of whole linseed supplementation and treatment duration on fatty acid profile and endogenous bioactive compounds of beef muscle

Diet supplementation with oilseeds is known to improve the fatty acid profile of meat, but few studies have been carried out to determine the time required for the incorporation of a significant quantity of n-3 polyunsaturated fatty acids (PUFA) into meat from steers. Therefore, the present study aimed to assess the effects of linseed supplementation and feeding duration on the fatty acid profile, cholesterol and bioactive compounds of bovine meat. In total, 54 Friesian steers were randomly allocated during the finishing period into six experimental treatments following a 2×3 factorial design. The six treatments consisted of two diets, the control diet (CO) with no supplemental fat and the linseed diet (LS) containing 10% whole linseed, fed 40, 75 or 120 days before slaughter. At the end of each finishing period, steers from the CO and LS groups were slaughtered. After 8 days of ageing chemical analysis, the fatty acid profile, cholesterol content and bioactive compounds were determined from the longissimus thoracis muscle. Including linseed in the diet increased the content of monounsaturated fatty acids, CLA and n-3 PUFA, and reduced the proportion of saturated fatty acids and n-6 PUFA. The percentage of myristic fatty acid increased with the duration of feeding, regardless of diet and a decrease in PUFA and n-6 PUFA was observed in the CO and LS diets, respectively. Furthermore, meat from steers fed linseed showed an increased percentage of n-3 PUFA, linolenic acid, and EPA from 40 to 75 days of feeding, whereas vaccenic acid, CLA 9c,11t, and total CLA increased from 40 and 75 days but declined at 120 days. Beef from the linseed group had a higher content of bioactive substances such as creatine, carnosine and anserine than beef from the control group. The duration of feeding significantly affected the creatine concentrations, with an increase in the LS group from 40 to 75 days of feeding. Feeding linseed did not modify the cholesterol content, on average and the lowest cholesterol content was found in meat after 75 days of linseed administration. This study demonstrates that a short-term diet manipulation is sufficient to improve the nutritional properties of meat, including n-3 PUFA and bioactive compounds.     

The fatty acid profile of muscle and adipose tissue of lambs fed camelina or linseed as oil or seeds

The objective of this study was to evaluate the impact of diets enriched with plant oils or seeds, high in polyunsaturated fatty acids (PUFA), on the fatty acid profile of sheep intramuscular and subcutaneous adipose tissue (SAT). Sixty-six lambs were blocked according to initial body weight and randomly assigned to six concentrate-based rations containing 60 g fat/kg dry matter from different sources: (1) Megalac (MG; ruminally protected saturated fat), (2) camelina oil (CO), (3) linseed oil (LO), (4) NaOH-treated camelina seed (CS), (5) NaOH-treated linseed (LS) or (6) CO protected from ruminal saturation by reaction with ethanolamine; camelina oil amides (CA). The animals were offered the experimental diets for 100 days, after which samples of m. longissimus dorsi and SAT were collected and the fatty acid profile determined by GLC. The data were analyzed using ANOVA with 'a priori' contrasts including camelina v. linseed, oil v. NaOH-treated seeds and CS v. CA. Average daily gain and total fatty acids in intramuscular adipose tissue were similar across treatments. The NaOH-treatment of seeds was more effective in enhancing cis-9, trans-11 conjugated linoleic acid (CLA) incorporation than the corresponding oil, but the latter resulted in a higher content of trans-11 18:1 in both muscle neutral and polar lipids (P < 0.01, P < 0.001, respectively). Inclusion of LS resulted in the highest PUFA:saturated fatty acid (SFA) ratio in total intramuscular fat (0.22). The NaOH-treatment of seeds resulted in a higher PUFA/SFA ratio (0.21 v. 0.18, P < 0.001) than oils and on average, linseed resulted in a higher PUFA/SFA ratio than camelina (P < 0.01). Lambs offered LS had the highest concentration of n-3 PUFA in the muscle, while those offered MG had the lowest (P < 0.001). This was reflected in the lowest (P < 0.001) n-6: n-3 PUFA ratio for LS-fed lambs (1.15) than any other treatment, which ranged from 2.14 to 1.72, and the control (5.28). The trends found in intramuscular fat were confirmed by the data for SAT. This study demonstrated the potential advantage from a human nutrition perspective of feeding NaOH-treated seeds rich in PUFA when compared to the corresponding oil. The use of camelina amides achieved a greater degree of protection of dietary PUFA, but decreased the incorporation of biohydrogenation intermediates such as cis-9, trans-11 CLA and trans-11 18:1 compared to NaOH-treated seeds.     

不同脂肪源对异育银鲫的生长、体组成和肌肉脂肪酸的影响

配制了十种等氮等能的饲料饲喂3.53 g的异育银鲫幼鱼12周, 探讨异育银鲫对不同脂肪源的利用效果。十种饲料中分别添加8%的鱼油(FO)、椰子油(CNO)、玉米油(CO)、亚麻油(LO)、大豆油(SO)、菜籽油(RO)、1∶1鱼油-椰子油(FCNO)、1∶1鱼油-玉米油(FCO)、1∶1鱼油-亚麻油(FLO)和1∶1∶1∶1鱼油-椰子油-玉米油-亚麻油混合油(MIX)。每组饲料三个平行, 每个平行30尾。实验在循环水养殖系统中进行, 水温控制在(241)℃。结果表明, 在单一脂肪源中, 豆油组和椰子油组的增重率最高, 其次是菜籽油组, 鱼油、玉米油和亚麻油组的增重率最低。与相应的单一脂肪源相比, 饲料中鱼油与椰子油、玉米油或亚麻油1∶1混合后使用提高了异育银鲫的生长。摄食不同脂肪源饲料的异育银鲫血清生化指标、各组织的水分和脂肪含量差异不明显(P0.05)。肌肉脂肪酸与饲料脂肪源呈明显正相关。摄食豆油和菜籽油饲料的鱼体肌肉中20:4n-6较高, 而摄食亚麻油饲料的鱼则含有较高的20:5n-3和22:6n-3, 表明异育银鲫具有转化18:2n-6和 18:3n-3为高不饱和脂肪酸的能力。从实验可以看出, 豆油、椰子油和菜籽油是异育银鲫饲料中良好的脂肪源。       

Degradation of Linseed Oil Vapors by Soil Bacteria in Trickling Biofilters

Oxidation products of linseed oil were produced by impinging a stream of air onto the surface of pure linseed oil and injecting the vapor-laden air into soil percolation columns to enrich the population of bacteria capable of degrading linseed oil vapors. As the populations of bacteria increased, the linseed oil vapors were consumed by these organisms, and the air that emerged from the columns was free of linseed oil contaminants. Five different kinds of bacteria capable of growing on the linseed oil oxidation products as sole source of carbon and energy were found and isolated in pure culture. Chromatographic analyses showed that individual organisms removed specific components of the vapor at specific rates, but none was able to remove them all within a 30-day period of time. When the five were grown together and presented the linseed oil vapor, all vapor constituents were utilized, and the rate of utilization was greater than that seen when the isolates were tested in pure culture. This indicated that the five organisms operated as a bacterial consortium in the degradation of linseed oil vapors. Trickling biofilters prepared from pregrown populations of the five organisms challenged with linseed oil vapors were able to remove all volatile constituents found in linseed oil vapor. Bioremediation of the air was complete and it was accomplished in a single pass of the air through the filter.

This work shows that bacteria found in the soil are capable of degrading linseed oil vapors and that they can be grown in the laboratory and used successfully in bench scale trickling biofilters.     

Effect of oilseed cakes on alpha-amylase production by Bacillus licheniformis CUMC305.

The effects of oilseed cakes on extracellular thermostable alpha-amylase production by Bacillus licheniformis CUMC305 was investigated. Each oilseed cake was made of groundnut, mustard, sesame, linseed, coconut copra, madhuca, or cotton. alpha-Amylase production was considerably improved in all instances and varied with the oilseed cake concentration in basal medium containing peptone and beef extract. Maximum increases were effected by a low concentration (0.5 to 1.0%) of groundnut or coconut, a high concentration (3%) of linseed or mustard, and an Rintermediate concentration (2%) of cotton, madhuca, or sesame. The oilseed cakes made of groundnut or mustard could completely replace the conventional peptone-beef extract medium as the fermentation base for the production of alpha-amylase by B. licheniformis. The addition of corn steep liquor to cotton, linseed, sesame, or madhuca cake in the medium improved alpha-amylase production.     

The effect of dietary n-3 and n-6 fatty acids on tumor necrosis factor-alpha production and leucine aminopeptidase levels in rat peritoneal macrophages

The purpose of this study was to determine the effect of dietary n-3 and n-6 fatty acids on tumor necrosis factor-alpha (TNF-alpha) production and macrophage (MO) activation state. Rats were fed diets containing 12.5% linseed oil (LO) or corn oil (CO) that are high in n-3 and n-6 fatty acids respectively. The LO diet resulted in a significant increase in basal and endotoxin (LPS)-induced levels of TNF-alpha from resident MO cultured in vitro. There was no difference between the diets in LPS-induced TNF-alpha production by complete Freund's adjuvant (CFA) elicited macrophages. Variable responses were also observed between LO and CO MO in response to prostaglandin E2, indomethacin (INDO), and the prostaglandin E receptor antagonist SC-19220. This may indicate differences in signal transducing secondary messengers due to different activation states, receptor expression or ligand binding. Fluorescence due to leucine aminopeptidase (LAP) staining was determined by flow cytometry. Resident LO MO had a 15% increase in LAP fluorescence compared to CO MO. In CFA-elicited MO, the CO MO had a 43% increase in fluorescence compared to LO MO. Resident LO MO increased in LAP fluorescence by 35% to the activated state whereas resident CO MO increased in LAP fluorescence by 93%. The smaller window of activation for the LO MO may explain some of the antiinflammatory properties of dietary n-3 fatty acids.     

Effect of oilseed cakes on alpha-amylase production by Bacillus licheniformis CUMC305

The effects of oilseed cakes on extracellular thermostable alpha-amylase production by Bacillus licheniformis CUMC305 was investigated. Each oilseed cake was made of groundnut, mustard, sesame, linseed, coconut copra, madhuca, or cotton. alpha-Amylase production was considerably improved in all instances and varied with the oilseed cake concentration in basal medium containing peptone and beef extract. Maximum increases were effected by a low concentration (0.5 to 1.0%) of groundnut or coconut, a high concentration (3%) of linseed or mustard, and an Rintermediate concentration (2%) of cotton, madhuca, or sesame. The oilseed cakes made of groundnut or mustard could completely replace the conventional peptone-beef extract medium as the fermentation base for the production of alpha-amylase by B. licheniformis. The addition of corn steep liquor to cotton, linseed, sesame, or madhuca cake in the medium improved alpha-amylase production.     

Effects of whole linseed and rumen-protected conjugated linoleic acid enriched diets on beef quality

Instrumental assessments and sensory tests were performed to evaluate the effects of diet and postmortem ageing time (1, 7 and 21 days) on beef quality. A total of 48 Friesian calves were randomly allocated to four dietary treatments: control, whole linseed (10% linseed), conjugated linoleic acid (CLA) (2% protected CLA), and whole linseed+CLA (10% linseed and 2% protected CLA). Animals were slaughtered at 458±16.6 kg live weight and 11 months of age. Ageing was more significant than diet on most instrumental parameters. Meat from linseed enriched diets had greater drip loss (P⩽0.001) and intramuscular fat (P⩽0.01) than meat from animals fed CLA. Beef aged for 7 and 21 days had lower cooking losses (P⩽0.01) and shear force (P⩽0.001) than beef aged for 1 day. Lightness was affected only by display time. The addition of CLA in the diet increased hue and yellowness, whereas the inclusion of linseed decreased these values, as well as increased redness. Linseed in the diet decreased fat odour (P⩽0.05), but increased beef (P⩽0.01) and liver (P⩽0.05) flavours. Meat aged for 21 days was significantly more rancid (P⩽0.001), even under vacuum storage. Several organoleptic properties were improved with the inclusion of linseed in the diet, whereas they remained unaffected by the inclusion of CLA.     

Conjugated linolenic acid (CLnA), conjugated linoleic acid (CLA) and other biohydrogenation intermediates in plasma and milk fat of cows fed raw or extruded linseed

Thirty lactating dairy cows were used in a 3 × 3 Latin-square design to investigate the effects of a raw or extruded blend of linseed and wheat bran (70:30) on plasma and milk fatty-acids (FA). Linseed diets, containing 16.6% linseed blend on a dry-matter basis, decreased milk yield and protein percentage. They decreased the proportions of FA with less than 18 carbons in plasma and milk and resulted in cis-9, cis-12, cis-15 18:3 proportions that were more than three and four times higher in plasma and milk, respectively, whereas cis-9, cis-12 18:2 proportions were decreased by 10-15%. The cis-9, trans-11, cis-15 18:3 isomer of conjugated linolenic acid was not detected in the milk of control cows, but was over 0.15% of total FA in the milk fat of linseed-supplemented cows. Similarly, linseed increased plasma and milk proportions of all biohydrogenation (BH) intermediates in plasma and milk, including the main isomer of conjugated linoleic acid cis-9, trans-11 18:2, except trans-4 18:1 and cis-11, trans-15 18:2 in plasma lipids. In milk fat, compared with raw linseed, extruded linseed further reduced 6:0-16:0 even-chain FA, did not significantly affect the proportions of 18:0, cis-9 18:1 and cis-9, cis-12 18:2, tended to increase cis-9, cis-12, cis-15 18:3, and resulted in an additional increase in the proportions of most BH intermediates. It was concluded that linseed addition can improve the proportion of conjugated linoleic and linolenic acids, and that extrusion further increases the proportions of intermediates of ruminal BH in milk fat.     

Effects of two supplementation levels of linseed combined with CLA or tallow on meat quality traits and fatty acid profile of adipose and different muscle tissues in slaughter pigs

Dietary linseed supply efficiently elevates the linolenic acid concentration of pork. The main problem of increasing the n-3 fatty acid tissue levels arises from a higher susceptibility to lipid oxidation. Increasing the saturation level of tissue lipids by the dietary inclusion of conjugated linoleic acids (CLA) or tallow might prevent oxidation. Thus, the aim of the study was to evaluate the impact of dietary CLA or tallow supplementation combined with extruded linseed on the growth performance, carcass characteristics and fatty acid profile of muscles (longissimus, semimembranosus, biceps femoris) and subcutaneous fat (SF). The enzyme activity of the de novo lipogenesis and stearoyl-CoA desaturase in the SF was also assessed. From 18 to 104 kg BW, 32 Swiss Large White barrows were fed a diet supplemented with either: (1) 2% linseed (L2); (2) 3% linseed (L3); (3) 2% linseed + 1% CLA (L2-C) or (4) 2% linseed + 1% tallow (L2-T). The linolenic and eicosatrienoic acid concentrations were higher (P < 0.01) and the ∑n-6/∑n-3 ratio was lower (P < 0.01) in all tissues of L3 than L2 and L2-T barrows. Only in the SF the docosapentaenoic acid concentration was increased (P < 0.01) in L3 barrows. Compared with the other three diets, feeding the L2-C diets increased (P < 0.01) the amount of myristic, palmitic, stearic and palmitoleic acid at the expense of the oleic and eicosenoic acid content in the intramuscular and SF lipids. Except for the lower (P < 0.05) eicosadienoic acid concentration in the muscles, feeding the L2-C treatment resulted in similar polyunsaturated fatty acid concentrations and ∑n-6/∑n-3 ratio than feeding L2 or L2-T diets. Both the c9,t11- and t10,c12-CLA isomers found in the CLA-supplemented diet were also detected in the tissues, but the c9,t11-isomer was more abundant than the t10,c12-isomer. De novo lipogenesis was not (P > 0.05) affected by the dietary fats, whereas Δ9-desaturase activity was depressed (P < 0.05) by CLA inclusion (L2-C). Only when oxidation was challenged by cooking and subsequent storage for 4 days at 4°C values of thiobarbituric acid-reactive substances were lower (P < 0.05) in longissimus muscle chops of L2-C compared with L2, L3 and L2-T barrows. The present findings revealed that CLA, but not tallow, combined with extruded linseed enhanced the oxidative stability of pork probably by lowering the degree of unsaturation of the lipids without affecting the improved ∑n-6/∑n-3 ratio.