NeuroBactrus,a Novel,Highly Effective,and Environmentally Friendly Recombinant Baculovirus Insecticide

A novel recombinant baculovirus, NeuroBactrus, was constructed to develop an improved baculovirus insecticide with additional beneficial properties, such as a higher insecticidal activity and improved recovery, compared to wild-type baculovirus. For the construction of NeuroBactrus, the Bacillus thuringiensis crystal protein gene (here termed cry1-5) was introduced into the Autographa californica nucleopolyhedrovirus (AcMNPV) genome by fusion of the polyhedrin–cry1-5–polyhedrin genes under the control of the polyhedrin promoter. In the opposite direction, an insect-specific neurotoxin gene, AaIT, from Androctonus australis was introduced under the control of an early promoter from Cotesia plutellae bracovirus by fusion of a partial fragment of orf603. The polyhedrin–Cry1-5–polyhedrin fusion protein expressed by the NeuroBactrus was not only occluded into the polyhedra, but it was also activated by treatment with trypsin, resulting in an ∼65-kDa active toxin. In addition, quantitative PCR revealed that the neurotoxin was expressed from the early phase of infection. NeuroBactrus showed a high level of insecticidal activity against Plutella xylostella larvae and a significant reduction in the median lethal time against Spodoptera exigua larvae compared to those of wild-type AcMNPV. Rerecombinant mutants derived from NeuroBactrus in which AaIT and/or cry1-5 were deleted were generated by serial passages in vitro. Expression of the foreign proteins (B. thuringiensis toxin and AaIT) was continuously reduced during the serial passage of the NeuroBactrus. Moreover, polyhedra collected from S. exigua larvae infected with the serially passaged NeuroBactrus showed insecticidal activity similar to that of wild-type AcMNPV. These results suggested that NeuroBactrus could be recovered to wild-type AcMNPV through serial passaging.     

A novel recombinant baculovirus expressing insect neurotoxin and producing occlusion bodies that contain Bacillus thuringiensis Cry toxin

A novel recombinant baculovirus, designated AcB5A, was constructed to develop an improved baculovirus insecticide with additional beneficial properties. Bacillus thuringiensis crystal protein gene (cry1–5) and an insect-specific neurotoxin gene (AaIT) were introduced into the Autographa californica multicapsid nucleopolyhedrovirus (AcMNPV) genome by fusion of polyhedrin–cry1–5–polyhedrin under the control of polyhedrin gene promoter, and by insertion of AaIT under the control of early promoter of ORF3004 from Cotesia plutellae bracovirus. RT-PCR analysis with total RNA from AcB5A-infected cells indicated that cry1–5 and AaIT genes were normally transcribed. The 150 kDa of polyhedrin–Cry1–5–polyhedrin fusion protein was produced by AcB5A and occluded into polyhedra produced by the recombinant virus. This protein was activated when treated with trypsin to form a crystal protein of approximately 65 kDa. The AcB5A showed a high level of insecticidal activity against Plutella xylostella larvae and a significant reduction in the lethal time against Spodoptera exigua larvae compared to those infected with wild-type AcMNPV. The expression level of the fusion protein decreased after in vivo passage as a result of homologous recombination between the two polyhedrin genes.     

Removal of Adsorbed Toxin Fragments That Modify Bacillus thuringiensis CryIC δ-Endotoxin Iodination and Binding by Sodium Dodecyl Sulfate Treatment and Renaturation

We report that 10- and 25-kDa toxin fragments adhere to CryIC prepared from Bacillus thuringiensis insecticidal crystals, block iodination, and alter membrane binding. There is no apparent affect on CryIC toxicity against Spodoptera exigua. Associated peptides remained bound to CryIC in the presence of 50 mM dithiothreitol or 6 M urea. A novel detergent-renaturation procedure was developed for the purification of B. thuringiensis CryIC toxin. Sodium dodecyl sulfate (SDS) treatment followed by gel filtration chromatography yielded a homogeneous 62-kDa CryIC toxin. After removal of SDS and renaturation, the purified CryIC toxin was fully insecticidal to S. exigua larvae. ¹²⁵I-labeled CryIC bound with high affinity to brush border membrane vesicles from S. exigua larvae.     

Engineered Bacillus thuringiensis GO33A with broad insecticidal activity against lepidopteran and coleopteran pests

A recombinant plasmid pSTK-3A containing cry3Aa7 gene encoding a coleopteran-specific insecticidal protein was constructed and introduced into wild Bacillus thuringiensis subsp. aizawai G03, which contained cry1Aa, cry1Ac, cry1Ca, and cry2Ab genes and was highly toxic to lepidopteran insect pests. The genetically engineered strain were named G033A. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis and Western blot analysis demonstrated that the cry3Aa7 gene was expressed normally and produced a 67 kDa protein in G033A, and the flat rectangular crystals of Cry3Aa7 toxin protein was observed under scanning electron microscope. The recombinant plasmid was maintained in bacteria cultured for 180 generations in culture media containing no antibiotics. Synthesis of the Cry3Aa7 toxin conferred high and broad toxicity to the recombinant strain G033A against coleopteran order, elm leaf beetle (Pyrrhalta aenescens) (LC₅₀ 0.35 mg/ml), for which the parental strain G03 was not toxic. Both the parental strain G03 and recombinant strain G033A showed strong insecticidal activity to lepidopteran pests, beet armyworm (Spodoptera exigua), diamondback moth (Plutella xylostella), and cotton bollworm (Helicoverpa amigera), respectively. The lethal concentration 50% (LC₅₀) of G033A against S. exigua, P. xylostella, and H. amigera was 4.26, 0.86, and 1.76 μg/ml, respectively.     

Dual Insecticidal Activity of Spodoptera-Toxic Bacillus thuringiensis Strain Transformed with Lepidopteran-Specific Cry Toxin

The E. coli-B. thuringiensis shuttle vector for expression of cry1Ac, pHT1K-1Ac plasmid was introduced into acrystalliferous B. thuringiensis Cry⁻B and Spodoptera toxic STB-3 strain. The presence of a recombinant plasmid in transformants after electroporation was confirmed by PCR. The 1K-1Ac/Cry⁻B(Cry⁻B transformant) and 1K-1Ac/STB-3 (STB-3 transformant) produced bipyramidal-shaped parasporal inclusion that was 130 kDa in size as like B. thuringiensis subsp. kurstaki HD-73. In P. xylostella bioassay, these transformants showed significantly high toxicity than the wild-type recipients and further, in case of B. thuringiensis STB-3 transformant still had original Spodoptera toxicity. These results suggested that the pHT1K could be successfully applied for generating individual B. thuringiensis strains that produce various combinations of insecticidal proteins to expand their host spectrum and enhance insecticidal activity.     

Expression of Bacillus thuringiensis mosquitocidal toxin in an antimicrobial Bacillus brevis strain

Brown blotch is a common disease of many mushrooms, especially oyster mushrooms, in Korea. Recently, we isolated a promising Bacillus brevis strain which has antimicrobial activity against Pseudomonas tolaasii, a serious mushroom pathogen. In this study, in order to confer insecticidal activity, a recombinant B. brevis strain was constructed via the expression of Bacillus thuringiensis mosquitocidal crystal protein. A B. thuringiensis expression vector (pPro11A), which contained the cry11Aa gene under the control of cry1Ac promoter, was introduced into this B. brevis strain. The recombinant B. brevis strain successfully expressed and produced rhomboidal shaped Cry11A protein, although the initiation time of expression was slower than that of B. thuringiensis Cry^-B transformant. The insecticidal and antimicrobial activities of the transformant were verified using two dipteran larvae, Aedes aegypti and Culex pipiens, and four bacteria, including P. tolaasii, respectively. These results demonstrate that the introduction of B. thuringiensis insecticidal activity to antimicrobial Bacillus strains might be a useful tool to construct dual functional Bacillus strains.     

A Cry1Ac Toxin Variant Generated by Directed Evolution has Enhanced Toxicity against Lepidopteran Insects

Cry1Ac insecticidal crystal proteins produced by Bacillus thuringiensis (Bt) have become an important natural biological agent for the control of lepidopteran insects. In this study, a cry1Ac toxin gene from Bacillus thuringiensis 4.0718 was modified by using error-prone PCR, staggered extension process (StEP) shuffling combined with Red/ET homologous recombination to investigate the insecticidal activity of delta-endotoxin Cry1Ac. A Cry1Ac toxin variant (designated as T524N) screened by insect bioassay showed increased insecticidal activity against Spodoptera exigua larvae while its original insecticidal activity against Helicoverpa armigera larvae was still retained. The mutant toxin T524N had one amino acid substitution at position 524 relative to the original Cry1Ac toxin, and it can accumulate within the acrystalliferous strain Cry-B and form more but a little smaller bipyramidal crystals than the original Cry1Ac toxin. Analysis of theoretical molecular models of mutant and original Cry1Ac proteins indicated that the mutation T524N located in the loop linking β16–β17 of domain III in Cry1Ac toxin happens in the fourth conserved block which is an arginine-rich region to form a highly hydrophobic surface involving interaction with receptor molecules. This study showed for the first time that single mutation T524N played an essential role in the insecticidal activity. This finding provides the biological evidence of the structural function of domain III in insecticidal activity of the Cry1Ac toxin, which probably leads to a deep understanding between the interaction of toxic proteins and receptor macromolecules.     

A functional F analogue of Autographa californica nucleopolyhedrovirus GP64 from the Agrotis segetum granulovirus

The envelope fusion protein F of Plutella xylostella granulovirus is a computational analogue of the GP64 envelope fusion protein of Autographa californica nucleopolyhedrovirus (AcMNPV). Granulovirus (GV) F proteins were thought to be unable to functionally replace GP64 in the AcMNPV pseudotyping system. In the present study the F protein of Agrotis segetum GV (AgseGV) was identified experimentally as the first functional GP64 analogue from GVs. AgseF can rescue virion propagation and infectivity of gp64-null AcMNPV. The AgseF-pseudotyped AcMNPV also induced syncytium formation as a consequence of low-pH-induced membrane fusion.     

Phage Display of a Biologically Active Bacillus thuringiensis Toxin

Activated forms of Bacillus thuringiensis insecticidal toxins have consistently been found to form insoluble and inactive precipitates when they are expressed in Escherichia coli. Genetic engineering of these proteins to improve their effectiveness as biological pesticides would be greatly facilitated by the ability to express them in E. coli, since the molecular biology tools available for Bacillus are limited. To this end, we show that activated B. thuringiensis toxin (Cry1Ac) can be expressed in E. coli as a translational fusion with the minor phage coat protein of filamentous phage. Phage particles displaying this fusion protein were viable, infectious, and as lethal as pure toxin on a molar basis when the phage particles were fed to insects susceptible to native Cry1Ac. Enzyme-linked immunosorbent assay and Western blot analysis showed the fusion protein to be antigenically equivalent to native toxin, and micropanning with anti-Cry1Ac antibody was positive for the toxin-expressing phage. Phage display of B. thuringiensis toxins has many advantages over previous expression systems for these proteins and should make it possible to construct large libraries of toxin variants for screening or biopanning.     

Purification of Vip3Aa from Bacillus thuringiensis HD-1 and its contribution to toxicity of HD-1 to spruce budworm (Choristoneura fumiferana) and gypsy moth (Lymantria dispar) (Lepidoptera)

We developed a protocol for obtaining high yields (10-15 mg per 1100 ml of culture supernatant) of highly purified (up to 95%) Vip3Aa protein from HD-1 cultures. The protocol is based on acetone precipitation of supernatant protein, followed by HPLC fractionation (DEAE-5PW column) and several concentration steps. Our protocol resulted in higher yields and purity of Vip3Aa than a previously published method [Estruch, J.J., Warren, G.W., Mullins, M.A., Nye, G.J., Craig, J.A., Koziel, M.G., 1996. Vip3A, a 353 novel Bacillus thuringiensis vegetative insecticidal protein with a wide spectrum of 354 activities against lepidopteran insects. Proc. Nat. Acad. Sci. USA 93, 5389-5394.]. This was achieved by using acetone rather than ammonium sulfate for precipitation of proteins from culture supernatants, and a shallow rather than a steep NaCl gradient for elution of the toxin, and by conducting all the purification steps at low temperature to prevent toxin degradation. In bioassays of the purified protein, Choristoneura fumiferana and Lymantria dispar larvae were less susceptible than Spodopteraexigua (10- and ∼100-fold, respectively). A B. thuringiensis var. kurstaki strain HD-1 from which the vip3Aa gene had been deleted (EG12414) showed reduced toxicity to S. exigua relative to the unmodified parental strain (EG2001), but not to L. dispar or C. fumiferana. We interpret these results as indicating that the Vip3Aa toxin does not contribute measurably to pathogenicity of HD-1 in these species.     

Construction and characterisation of an antifungal recombinant Bacillus thuringiensis with an expanded host spectrum

A novel antifungal Bacillus thuringiensis strain 19–22, ssp. kurstaki (H3a3b3c), was characterised. This strain included cry1Aa, cry1Ab, cry1Ac, and cry1D, which have high insecticidal activities against lepidopteran larvae other than Spodoptera exigua. To expand the host spectrum, a cry1E gene whose product is active against S. exigua was introduced into the isolate. The transformant successfully expressed the Cry1E protein without any loss of its original antifungal activities. These results indicate that this recombinant strain exhibits dual activities and may be used as an integrated control agent to control plant diseases and insect pests.     

Increase in Insecticidal Toxicity by Fusion of the <Emphasis Type="Italic">cry1Ac</Emphasis> Gene from <Emphasis Type="Italic">Bacillus thuringiensis</Emphasis> with the Neurotoxin Gene <Emphasis Type="Italic">hwtx-I</Emphasis>

A fusion gene was constructed by combining the cry1Ac gene of Bacillus thuringiensis strain 4.0718 with a neurotoxin gene, hwtx-1, which was synthesized chemically. In this process, an enterokinase recognition site sequence was inserted in frame between two genes, and the fusion gene, including the promoter and the terminator of the cry1Ac gene, was cloned into the shuttle vector pHT304 to obtain a new expression vector, pXL43. A 138-kDa fusion protein was mass-expressed in the recombinant strain XL002, which was generated by transforming pXL43 into B. thuringiensis acrystalliferous strain XBU001. Quantitative analysis indicated that the expressed protein accounted for 61.38% of total cellular proteins. Under atomic force microscopy, there were some bipyramidal crystals with a size of 1.0 × 2.0 μm. Bioassay showed that the fusion crystals from recombinant strain XL002 had a higher toxicity than the original Cry1Ac crystal protein against third-instar larvae of Plutella xylostella, with an LC₅₀ (after 48 h) value of 5.12 μg/mL. The study will enhance the toxicity of B. thuringiensis Cry toxins and set the groundwork for constructing fusion genes of the B. thuringiensis cry gene and other foreign toxin genes and recombinant strains with high toxicity. LiQiu Xia and XiaoShan Long contributed equally to this work.     

Insecticidal effects of selected biological control agents on the larvae of Plutella xylostella (Lepidoptera: Plutellidae)

To identify a more effective and safe biological control agent against a common cabbage pest, Plutella xylostella (L.) (Lepidoptera: Plutellidae), the insecticidal effects of selected biological agents were evaluated. The highest insecticidal effects determined were 100, 73.5, 45.5, 47 and 55.3% using toxin HD‐1 (isolated from the Harry Dumagae strain of Bacillus thuringiensis), toxin BTS‐1 (isolated from the tenebrionis strain of B. thuringiensis), B. thuringiensis Berliner, B. thuringiensis israelensis and B. thuringiensis kurstaki, respectively.     

Functional expression of lepidopteran-selective neurotoxin in baculovirus: potential for effective pest management

Recombinant baculovirus expressing insect-selective neurotoxins derived from venomous animals are considered as an attractive alternative to chemical insecticides for efficient insect control agents. Recently we identified and characterized a novel lepidopteran-selective toxin, Buthus tamulus insect-selective toxin (ButaIT), having 37 amino acids and eight half cysteine residues from the venom of the South Indian red scorpion, Mesobuthus tamulus. The synthetic toxin gene containing the ButaIT sequence in frame to the bombyxin signal sequence was engineered into a polyhedrin positive Autographa californica nuclear polyhedrosis virus (AcMNPV) genome under the control of the p10 promoter. Toxin expression in the haemolymph of infected larvae of Heliothis virescens and also in an insect cell culture system was confirmed by western blot analysis using antibody raised against the GST-ButaIT fusion protein. The recombinant NPV (ButaIT-NPV) showed enhanced insecticidal activity on the larvae of Heliothis virescens as evidenced by a significant reduction in median survival time (ST50) and also a greater reduction in feeding damage as compared to the wild-type AcMNPV.     

Insecticidal activity of the chitinase from the Spodoptera litura nucleopolyhedrovirus

Baculovirus chitinase gene (chiA) is a late gene essential for liquefying the host insect at a late stage of infection for its hydrolyzing chitin function. In a previous report, baculovirus ChiA has been shown to offer many interesting new opportunities for pest control. Recently, a putative chiA gene was identified in the Korean isolate of the Spodoptera litura nucleopolyhedorvirus (SpliMNPV‐K1) genome. The open reading frame (ORF) contains 1692 nucelotides and encodes a protein of 563 amino acids with a predicted molecular weight of about 62.6 kDa. To study the insecticidal activity of ChiA from SpliMNPV‐K1, we constructed a recombinant AcMNPV, Ap‐SlChiA, which is designed to express the ChiA under the control of a polyhedrin promoter. Western blot analysis indicated that ChiA was successfully expressed by this recombinant virus. Chitinase assay revealed that the chitobiosidase and endochitinase activity of the recombinant virus was 2.5‐ and 3.9‐flods higher than those of wild‐type AcMNPV, respectively. In addition, the recombinant virus showed higher evident insecticidal activity against 3rd instar larvae of Spodotera exigua than that of the AcMNPV. These results suggest that the chiA gene from SpliMNPV‐K1 could be successfully applied to improve pathogenicity of baculoviruses.     

Characterization of an Insecticidal Toxin and Pathogenicity of Pseudomonas taiwanensis against Insects

Pseudomonas taiwanensis is a broad-host-range entomopathogenic bacterium that exhibits insecticidal activity toward agricultural pests Plutella xylostella, Spodoptera exigua, Spodoptera litura, Trichoplusia ni and Drosophila melanogaster. Oral infection with different concentrations (OD = 0.5 to 2) of wild-type P. taiwanensis resulted in insect mortality rates that were not significantly different (92.7%, 96.4% and 94.5%). The TccC protein, a component of the toxin complex (Tc), plays an essential role in the insecticidal activity of P. taiwanensis. The ΔtccC mutant strain of P. taiwanensis, which has a knockout mutation in the tccC gene, only induced 42.2% mortality in P. xylostella, even at a high bacterial dose (OD = 2.0). TccC protein was cleaved into two fragments, an N-terminal fragment containing an Rhs-like domain and a C-terminal fragment containing a Glt symporter domain and a TraT domain, which might contribute to antioxidative stress activity and defense against macrophagosis, respectively. Interestingly, the primary structure of the C-terminal region of TccC in P. taiwanensis is unique among pathogens. Membrane localization of the C-terminal fragment of TccC was proven by flow cytometry. Sonicated pellets of P. taiwanensis ΔtccC strain had lower toxicity against the Sf9 insect cell line and P. xylostella larvae than the wild type. We also found that infection of Sf9 and LD652Y-5d cell lines with P. taiwanensis induced apoptotic cell death. Further, natural oral infection by P. taiwanensis triggered expression of host programmed cell death-related genes JNK-2 and caspase-3.     

Characterization of Chimeric Bacillus thuringiensis Vip3 Toxins

Bacillus thuringiensis vegetative insecticidal proteins (Vip) are potential alternatives for B. thuringiensis endotoxins that are currently utilized in commercial transgenic insect-resistant crops. Screening a large number of B. thuringiensis isolates resulted in the cloning of vip3Ac1. Vip3Ac1 showed high insecticidal activity against the fall armyworm Spodoptera frugiperda and the cotton bollworm Helicoverpa zea but very low activity against the silkworm Bombyx mori. The host specificity of this Vip3 toxin was altered by sequence swapping with a previously identified toxin, Vip3Aa1. While both Vip3Aa1 and Vip3Ac1 showed no detectable toxicity against the European corn borer Ostrinia nubilalis, the chimeric protein Vip3AcAa, consisting of the N-terminal region of Vip3Ac1 and the C-terminal region of Vip3Aa1, became insecticidal to the European corn borer. In addition, the chimeric Vip3AcAa had increased toxicity to the fall armyworm. Furthermore, both Vip3Ac1 and Vip3AcAa are highly insecticidal to a strain of cabbage looper (Trichoplusia ni) that is highly resistant to the B. thuringiensis endotoxin Cry1Ac, thus experimentally showing for the first time the lack of cross-resistance between B. thuringiensis Cry1A proteins and Vip3A toxins. The results in this study demonstrated that vip3Ac1 and its chimeric vip3 genes can be excellent candidates for engineering a new generation of transgenic plants for insect pest control.     

Thermo-Inducible Expression of δ Endotoxin Gene of Bacillus thuringiensis HD1 Derived under Lambda PL Promoter in Escherichia coli

The insecticidal crystal protein gene cryIA(a) from Bacillus thuringiensis HD1 has been cloned as a single 3.765 kb Ndel fragment on the expression vector pRE1. The pBR322 based clone pES1 was digested with restriction endonuclease Ndel and the 3.765 kb fragment carrying the intact gene was eluted and cloned on pUC18 to confirm its functional integrity. This Ndel fragment was then cloned on the vector pRE1 carrying strong promoter PL of lambda upstream to the cloning site. The recombinant construct pUSR14.1 carried crystal protein (CP) gene under PL and was temperature inducible at 42°C in MZ1 host strain of Escherichia coli because of temperature sensitive CI857 gene carried by it as lysogen. Dilution based insect bioassays showed hyper-expression of toxin in these constructs. SDS-PAGE analysis indicated that polypeptides corresponding to 132 kD and 66 kD bands of HD1 endotoxin constituted 20.1% of the total soluble protein in this recombinant strain to be delta-endotoxin.