Effect of cyclic changes in culture conditions on the growth kinetics and physiological characteristics of yeasts

Candida utilis, Saccharomyces cerevisiae and Candida scottii were used to study the effect of cyclic changes in the pH and pO2 within a range of 1 to 60 min on their growth kinetics and physiological properties. These changes were shown to increase the specific growth rate from 0.33 to 0.5-0.6 h-1 without decreasing the economic coefficient and the quantity of budding cells during 2-3 generations of the exponentially growing batch culture of C. utilis. Optimal conditions of cyclic changes in the pO2 (minutes) were found to increase the specific growth rate of C. scottii and S. cerevisiae. The authors discuss a hypothesis for the formation of intermediate products in the substrate oxidation in the course of pulse aeration by the yeasts during the aerobic stage and the utilization of the products at the anaerobic stage of cyclic regimes. The paper describes a mathematical model for the yeast growth under the nonsteady-state conditions of pH and pO2, which accounts for the formation and utilization of possible intermediate biosynthetic products within the studied time intervals.     

Optimization of the production of virus-like particles in insect cells

In this work the maximal operational hydrodynamic conditions (agitation and aeration rate) that cause no adverse effect in Sf-9 cells growth in SF900II serum-free medium were determined. Shear stresses higher than 1 N m-2 and aeration rates higher than 0.04 vvm affect cell growth and when these conditions increase to 1.5 N m-2 and 0.11 vvm, cell growth is completely inhibited with significant cell morphology changes and a strong decrease in viability. Although the pO2 did not show a significant effect upon cell growth in the range from 10 to 50%, cell infection and specific productivity were dramatically affected. The production was optimal at a pO2 of 25% with decreases higher than 50% being observed when the pO2 decreased to 10 or increased to 50%. The maximum product quality, i.e., the percentage of product in the form of high molecular weight particles, is not coincident with maximum product titer. Although the highest Pr55gag particle titer was obtained at 96 hours post infection (hpi) and at pO2 of 25%, the best product quality (defined by gel filtration chromatography and Western immunoblot) was obtained at 48 hpi, independently of the pO2 used. The effect of overcritical conditions upon productivity was also studied. As obtained for cell growth, cell infection is affected by shear stresses above 1 N m-2 and by aeration rates higher than 0.04 vvm, with decreases in Pr55gag particle titer higher than 70%, even when the overcritical values are still far from the limit at which cell death occurs. The results obtained and the optimization strategy used allowed the maximization of the oxygen supply without damaging the cells, with important consequences on the scale-up of a production process involving this insect cell/baculovirus expression system.     

Effect of short-term hypoxia and re-oxygenation on mice peritoneal macrophages in vitro

Microfluorimetry of single cells could help to analyze their morphology and function state during changes of gas environment. It is very important to have a possibility of the cell visual control during hypoxia and collection of dynamic fluorimetric data in digital form. The effects of short-term pO2 decrease were studied. For estimating the effects of hypoxia and reoxygenation we used the mice peritoneal macrophages, which are very sensitive to physical, chemical and regulatory stimuli. A special small chamber for fluorimetric measurements during pO2 changes, was developed. The level of active oxygen forms, intracellular pH, and cell membrane instability were investigated during replacement of air by nitrogen or argon (of the basal level decreased to 20% of basic level) and in subsequent reoxygenation. The increase of active oxygen forms was shown during 30 min of hypoxia and their level continued to rise immediately after reoxygenation. A short-term decrease and subsequent increase of pO2 in the medium led to an increase of intracellular pH level. The shifts of measured cell indices were stabilized after 30-40 min of pO2 changes thus suggesting a fast comprehension of countermeasure cell mechanisms. No macrophages with membrane disorders were found despite the rise of the active oxygen forms level during hypoxia and reoxygenation in vitro. There were no significant differences between nitrogen and argon used for replacement of air in the medium. The data obtained suggest a high resistance of macrophages against pO2 changes and an involvement of the antioxidative mechanisms for cell protection especially during reoxygenation period.     

Factors affecting growth and nitrogen fixation of Spirillum lipoferum.

Spirillum lipoferum grows vigorously on malate, succinate, lactate, or pyruvate, moderately on galactose or acetate, and poorly on glucose or citrate. It reduces 15N2. Acetylene reduction rates decrease rapidly when the pH of the culture rises above 7.8. The organism is highly aerobic and had doubling times as low as 2 h when grown on NH4+. However, S. lipoferum reduces N2 well only under microaerophilic conditions. The optimal pO2 for acetylene reduction by stagnant cultures was 0.006 to 0.02 atm depending upon the cell density; aerated cultures grew well at dissolved O2 concentration corresponding to a pO2 of about 0.008 atm. Shaking S. lipoferum with air temporarily inactivates its nitrogenase; reactivation is inhibited by chloramphenicol. The organism assimilated 20 to 24 mg of N/g of organic acid oxidized during growth. The strains studied can be placed in two groups based upon their morphology and physiological characteristics.     

Filterability of sickle cells as a function of pO2: role of physico-chemical factors

A rigidity index (RI) related to red blood cell deformability was measured by using the hemorheometre. The RI for 13 patients homozygous for sickle cell disease was 109 +/- 44 at 37 degrees C and at atmospheric pO2. The filtration time curve as a function of pO2 is biphasic for sickle cell suspensions. The pO2 at which filtration time is maximum, pO2max., correlated with the rigidity index measured at atmospheric pO2. This pO2max. value was very sensitive to small changes in physico-chemical parameters such as osmolality, pH, temperature, hematocrit, and cell density. Conditions which reduced the Hb S polymerization induced a leftward shift of pO2max.. The experimental curves are in agreement with theoretical models based on the presence of two abnormal cell types: filtrable "slow cells" and infiltrable "sickled cells".     

Growth and Metabolism of L Cells in a Chemically Defined Medium in a Controlled Environment Culture System: I. Effects of O2 Tension on L-Cell Cultures

Six water-jacketed 500-ml Bellco spinner flasks were equipped to monitor and control environmental variables to study their effects on the growth and metabolism of mammalian cells. Studies with automated control of pO(2) levels of l-cell cultures, grown at pH 6.9 +/- 0.1, showed that dissolved O(2) tensions of ca. 9% were optimal for cell growth. At pO(2) values of 5 and 20%, maximum cell yields as well as growth rates were reduced by approximately 20%. Peak yields of L-cell cultures exceeded 5 x 10(6) cells/ml when grown for 4 days without medium renewal from inocula of ca. 10(6) cells/ml in a defined medium sparged with 5% CO(2) and maintained at 9% dissolved O(2) tension. The redox potentials of L-cell cultures reflected the pO(2) levels in the medium and ranged from -45 to +160 mv (versus calomel reference) for O(2) values ranging from 2 to 20% dissolved oxygen tension. Increased utilization of glucose per cell occurred in the presence of increased pO(2), whereas minimal accumulation of ammonia occurred with a pO(2) value maintained at 9%.     

Bicarbonate Requirement for Elimination of the Lag Period of Hydrogenomonas eutropha

Carbon dioxide and oxygen concentrations have a profound effect on the lag period of chemoautotrophically grown Hydrogenomonas eutropha. Minimum lag periods and high growth rates were obtained in shaken flask cultures with a prepared gas mixture containing 70% H(2), 20% O(2), and 10% CO(2). However, excessively long lag periods resulted when the same gas mixture was sparged through the culture. The lag period was shortened in sparged cultures by decreasing both the pO(2) and the pCO(2), indicating that gas medium equilibration had not occurred in shaken cultures. The lag period was completely eliminated at certain concentrations of O(2) and CO(2). The optimum pO(2) was 0.05 atm, but the optimum pCO(2) varied according to the pH of the medium and physiological age of the inoculum. At pH 6.4, the pCO(2) required to obtain immediate growth of exponential, postexponential, and stationary phase inocula at equal specific rates was 0.02, 0.05, and 0.16 atm, respectively. With each 0.3-unit increase in the pH of the medium, a 50% decrease in the CO(2) concentration was needed to permit growth to occur at the same rate. The pCO(2) changes required to compensate for the pH changes of the medium had the net effect of maintaining a constant bicarbonate ion concentration. Initial growth of H. eutropha was therefore indirectly related to pCO(2) and directly dependent upon a constant bicarbonate ion concentration.     

The cultivation of animal cells at controlled dissolved oxygen partial pressure. Reprinted from Biotechnology and Bioengineering Vol. X, Issue 6, Pages 801-814 (1968)

A 3-liter culture vessel has been developed for the growth of animal cells in suspension at controlled pH and dissolved oxygen partial pressure (pO(2)). The culture technique allows metabolically produced CO(2) to be measured; provision can be made to control the dissolved CO(2) partial pressure. In cultures containing a low serum concentration, gas sparging to control pO(2) was found to cause cell damage. This could be prevented by increasing the serum concentration to 10%, or by adding 0.02% of the surface-active polymer Pluronic F68. The growth of mouse LS cells in batch culture without pO(2) control was found to be limited by the availability of oxygen. Maximum viable cell populations were obtained when dissolved pO(2) was controlled at values within the range 40-100 mm Hg.     

Bioprocess development for the production of a recombinant MUC1 fusion protein expressed by CHO-K1 cells in protein-free medium

The mucin MUC1 is a candidate for use in specific immunotherapy against breast cancer, but this requires the large-scale production of a MUC1 antigen. In this study, a bioprocess for the expression of a recombinant MUC1 fusion protein with a cancer associated glycosylation in CHO-K1 cells has been developed. Cells permanently expressing parts of the extracellular portion of MUC1 fused to IgG Fc were directly transferred from adherent growth in serum-containing medium to suspension culture in the protein-free ProCHO4-CDM culture medium. Using the Cellferm-pro system, optimal culture parameter as pH and pO(2) were determined in parallel spinner flask batch cultures. A pH of 6.8-7.0 and a pO(2) of 40% of air saturation was found to give best cell growth and productivity of secreted recombinant protein. Specific productivity strongly depended the pO(2) and correlated with the online monitored oxygen uptake rate (OUR) of the cells, which indicates a positive influence of the rate of oxidative phosphorylation on productivity. The optimised conditions were applied to continuous perfusion culture which gave very high cell densities and space time yields of the recombinant MUC1 fusion protein, allowing production at gram scale. The product degradation was much lower in supernatants from continuous perfusion culture compared to batch mode. Antibodies reacting with cancer associated MUC1 glycoforms strongly bound to the fusion protein, indicating that the desired glycoforms were obtained and suggesting that the recombinant MUC1 protein could be tested for use in immunotherapy.     

Response of the endophytic diazotroph Gluconacetobacter diazotrophicus on solid media to changes in atmospheric partial O(2) pressure

Gluconacetobacter diazotrophicus is an N(2)-fixing endophyte isolated from sugarcane. G. diazotrophicus was grown on solid medium at atmospheric partial O(2) pressures (pO(2)) of 10, 20, and 30 kPa for 5 to 6 days. Using a flowthrough gas exchange system, nitrogenase activity and respiration rate were then measured at a range of atmospheric pO(2) (5 to 60 kPa). Nitrogenase activity was measured by H(2) evolution in N(2)-O(2) and in Ar-O(2), and respiration rate was measured by CO(2) evolution in N(2)-O(2). To validate the use of H(2) production as an assay for nitrogenase activity, a non-N(2)-fixing (Nif(-)) mutant of G. diazotrophicus was tested and found to have a low rate of uptake hydrogenase (Hup(+)) activity (0.016 +/- 0.009 micromol of H(2) 10(10) cells(-1) h(-1)) when incubated in an atmosphere enriched in H(2). However, Hup(+) activity was not detectable under the normal assay conditions used in our experiments. G. diazotrophicus fixed nitrogen at all atmospheric pO(2) tested. However, when the assay atmospheric pO(2) was below the level at which the colonies had been grown, nitrogenase activity was decreased. Optimal atmospheric pO(2) for nitrogenase activity was 0 to 20 kPa above the pO(2) at which the bacteria had been grown. As atmospheric pO(2) was increased in 10-kPa steps to the highest levels (40 to 60 kPa), nitrogenase activity decreased in a stepwise manner. Despite the decrease in nitrogenase activity as atmospheric pO(2) was increased, respiration rate increased marginally. A large single-step increase in atmospheric pO(2) from 20 to 60 kPa caused a rapid 84% decrease in nitrogenase activity. However, upon returning to 20 kPa of O(2), 80% of nitrogenase activity was recovered within 10 min, indicating a "switch-off/switch-on" O(2) protection mechanism of nitrogenase activity. Our study demonstrates that colonies of G. diazotrophicus can fix N(2) at a wide range of atmospheric pO(2) and can adapt to maintain nitrogenase activity in response to both long-term and short-term changes in atmospheric pO(2).     

In Vitro Effects of Film-Forming Polymers on the Growth and Morphology of Pyrenophora Avenae and Pyricularia Oryzae

Ethokem (Midkem Agrochemicals, Northampton, UK) and Bond (Newman Agrochemicals, Cambridge, UK) completely inhibited linear growth of Pyricularia oryzae at 1 and 2% concentrations of the compounds and strongly inhibited growth of Pyrenophora avenae in vitro . Vapor Gard (Miller Chemical & Fertilizer Corporation, Hannover, PA, USA) was less effective with relatively little inhibition of P. oryzae , but was a more effective inhibitor of P. avenae . All three compounds decreased cell lengths of both pathogens and increased cell diameters of P. avenae . Vapor Gard and Ethokem did not significantly alter cell diameters of P. oryzae , but a highly significant increase was observed with Bond. Gross changes in hyphal morphology were observed including swollen shortened cells, granulation of the cytoplasm, increased branching and collapsed empty cells. Ethokem and Bond decreased growth rate and inhibited biomass production of P. avenae .     

Effects of growth morphology and time of harvesting on the chitosan yield of Absidia repens

Summary Absidia repens (CBS 102.32) was grown in a fermentor and the effects of growth morphology (due to different agitation) and harvest timing on chitosan yield were evaluated. The use of the titration rate as an on-line measure of growth rate was studied. Small pellets, 0.5 mm o.d. allowed the most efficient growth (highest growth rate and highest biomass yields from carbon and nitrogen sources) whereas growth as large pellets, 2–3 mm o.d., or as a viscous pulp exhibited limited growth. The differences were most pronounced during the later part of the cultivations. The chitosan content of the biomass remained essentially constant during active growth, irrespective of morphology, but during the stationary phase, this content continued to increase from 18% to 23% of the biomass, reaching 2.8 g/l. The titration rate of NaOH, in order to maintain constant pH, exceeded the growth rate in all cultures, and this was pronounced when growth was limited. Correspondence to: A. Persson     

Heterogeneity of the changes in cytoplasmic pH upon serum stimulation of quiescent fibroblasts

Addition of mitogens to quiescent cells results in rapid ionic changes in the cytoplasm, including pH. We studied the changes in cytoplasmic pH in single Swiss 3T3 cells upon serum stimulation using fluorescence ratio imaging microscopy. Quiescence was attained using two approaches, serum deprivation of subconfluent cells and confluence. All measurements were made in the presence of bicarbonate and the absence of other organic buffers. We also used BCECF coupled to dextran to avoid several artifacts associated with using BCECF-AM, including leakage and phototoxicity. Analysis of the changes in cytoplasmic pH demonstrated a dramatic heterogeneity in the responses of single cells. There were six basic classes of responses, 1) a fast alkalinization, reaching a maximum pH in approximately 2-5 min; 2) a slow alkalinization, reaching a maximum pH in 10-20 min; 3) a very slow alkalinization, not reaching a plateau pH within the measurement time; 4) no apparent change in pH during the measurement time; 5) an early transient acidification, followed by either a fast or slow alkalinization; and 6) an acidification, followed by alkalinization and then by a decrease to some intermediate pH. Subconfluent cells exhibited greater heterogeneity in response than confluent cells, with no single dominant class of response. The dominant (55%) response for confluent cells was a gradual alkalinization of approximately 0.01 pH units/min. A larger proportion (52%) of subconfluent cells exhibited an early transient acidification compared to confluent cells (7%). A significant proportion of both types of cells (23% subconfluent, 36% confluent) exhibited no change in cytoplasmic pH upon stimulation. In general, the kinetics of changes in cytoplasmic pH were significantly different from the published results with population averaging methods.     

Low pO2 selectively inhibits K channel activity in chemoreceptor cells of the mammalian carotid body

The hypothesis that changes in environmental O2 tension (pO2) could affect the ionic conductances of dissociated type I cells of the carotid body was tested. Cells were subjected to whole-cell patch clamp and ionic currents were recorded in a control solution with normal pO2 (pO2 = 150 mmHg) and 3-5 min after exposure to the same solution with a lower pO2. Na and Ca currents were unaffected by lowering pO2 to 10 mmHg, however, in all cells studied (n = 42) exposure to hypoxia produced a reversible reduction of the K current. In 14 cells exposed to a pO2 of 10 mmHg peak K current amplitude decreased to 35 +/- 8% of the control value. The effect of low pO2 was independent of the internal Ca2+ concentration and was observed in the absence of internal exogenous nucleotides. Inhibition of K channel activity by hypoxia is a graded phenomenon and in the range between 70 and 120 mmHg, which includes normal pO2 values in arterial blood, it is directly correlated with pO2 levels. Low pO2 appeared to slow down the activation time course of the K current but deactivation kinetics seemed to be unaltered. Type I cells subjected to current clamp generate large Na- and Ca-dependent action potentials repetitively. Exposure to low pO2 produces a 4-10 mV increase in the action potential amplitude and a faster depolarization rate of pacemaker potentials, which leads to an increase in the firing frequency. Repolarization rate of individual action potentials is, however, unaffected, or slightly increased. The selective inhibition of K channel activity by low pO2 is a phenomenon without precedents in the literature that explains the chemoreceptive properties of type I cells. The nature of the interaction of molecular O2 with the K channel protein is unknown, however, it is argued that a hemoglobin-like O2 sensor, perhaps coupled to a G protein, could be involved.     

Influence of pregnancy and lactation on diurnal and seasonal changes in lactic acid and pyruvic acid levels and in values of pH, pCO2 and pO2 in the mare blood.

1. The diurnal changes in the levels of lactic (LA) and pyruvic (PA) acids and in values of pH, pO2 and pCO2 were studied in the blood of barren and later on in pregnant and lactating mares, throughout three subsequent years. 2. Blood samples were taken every 4 hr, for one day, each month, throughout 3 years. 3. The mares were kept and fed in the same conditions, lighting was natural. 4. In barren mares, diurnal rhythm in LA, PA, pO2 and pCO2 was found. 5. The pregnancy as well as lactation masked diurnal rhythms in parameters studied, except the LA level during lactation but then the acrophase was shifted by 3-4 hr. 6. Seasonal cyclicity was found in the values of LA, PA and pCO2 in barren mares. The pregnancy abolished cyclicity in LA level and modified the behaviour of PA and pCO2 values causing a shift of acrophases and lowering the amplitudes of the indices. 7. In the pO2 tensions no seasonal cycles were observed. 8. In the values of pH neither diurnal rhythms nor seasonal cycles throughout study years were observed.     

Seasonal changes in growth rate, morphology and alginate content in Undaria pinnatifida at the northern limit in the Sea of Japan (Russia)

The growth, morphology, alginate yield and composition of Undaria pinnatifidawas studied from March to August in 2000 and 2001 at the northern limit of distribution of the species in Peter the Great Bay, the Sea of Japan (Russia). The changes in morphology, alginate yield and composition were caused by sporophyte growth and sporulation. The average rate of biomass change was 2–5% d⁻¹. The highest alginate content (51% d.wt) was obtained from blades, with lower values for sporophylls and midribs. An increase in alginate content was detected before sporulation. The conditions seem favourable for farming the alga in this region, with June the optimum month for harvesting. This revised version was published online in August 2006 with corrections to the Cover Date.     

Correlations between 31P-NMR spectroscopy and tissue O2 tension measurements in a murine fibrosarcoma

Size-dependent changes in therapeutically relevant and interrelated metabolic parameters of a murine fibrosarcoma (FSaII) were investigated in vivo using conscious (unanesthetized) animals and tumor sizes less than or equal to 2% of body weight. Tumor pH and bioenergetics were evaluated by 31P nuclear magnetic resonance spectroscopy (31P-MRS), and tumor tissue oxygen tension (pO2) distribution was examined using O2-sensitive needle electrodes. During growth FSaII tumors showed a progressive loss of phosphocreatine (PCr) and nucleoside triphosphate (NTP) with increasing inorganic phosphate (Pi) and phosphomonoester (PME) signals. Ratios for PCr/Pi, PME/Pi, NTP/Pi, and phosphodiester/inorganic phosphate (PDE/Pi) as well as pH determined by 31P-NMR (pHNMR) and the mean tissue pO2 progressively declined as the tumors increased in size. The only relevant ratio increasing with tumor growth was PME/NTP. When the mean tissue pO2 value was plotted against pHNMR, NTP/Pi, PCr/Pi, PME/Pi, and PDE/Pi for tumor groups of similar mean volumes, a highly significant positive correlation was observed. There was a negative correlation between mean tumor tissue pO2 values and PME/NTP. From these results we concluded that 31P-MRS can detect changes in tumor bioenergetics brought about by changes in tumor oxygenation. Furthermore, the close correlation between oxygenation and energy status suggests that the microcirculation in FSaII tumors yields an O2-limited energy metabolism. Finally, a correlation between the proportion of pO2 readings between 0 and 2.5 mmHg and the radiobiologically hypoxic cell fraction in FSaII tumors was observed. The latter finding might be of particular importance for radiation therapy.     

荒漠草原区不同生活型植物生长对降水变化的响应

在全球气候变化背景下,降水变化对植物群落动态将产生深远的影响。以黄土高原西部荒漠草原为对象,通过野外降水控制试验,研究不同生活型植物丰富度、密度、盖度、高度和地上生物量对降水变化的响应。结果表明: 降水处理对一年生草本植物的丰富度、密度、盖度的影响在降水试验第3年(2015年)达到显著水平,以减水处理最低,植物高度对降水变化的响应更敏感,3年间,均以减水40%处理最低;植物生长和地上生物量对减水处理的负响应幅度大于对增水处理的响应。多年生草本植物的丰富度、密度和盖度在第3年以减水处理显著低于增水40%处理,但与对照无显著差异;植物高度3年间均以减水40%处理最低;丰富度、盖度、高度对减水处理的负响应幅度大于对增水处理的正响应,但地上生物量对增水40%处理的正响应较强。灌木的丰富度、密度、盖度和地上生物量对增减水20%处理的正响应最明显,可能与灌木在该处理分布相对集中有关。降水减少抑制了草本植物的生长,但对一年生草本植物的抑制作用更强,降水增加在一定程度上促进了多年生草本植物的生长和生物量积累。一年生草本植物的生长和生物量随降水年际变异波动明显,灌木受降水改变的影响相对较小,降水变化对黄土高原西部荒漠草原植物群落组成与功能将产生显著的影响。     

Kinetics of the processes of Streptococcus pneumoniae batch cultivation in relation to the physiological state of the inoculum

The present investigation, carried out with the use of S. pneumoniae as a model, has shown that the kinetics of cultivation processes depend on the preparation of the seed culture. The use of the seed culture, taken at the end of the exponential phase of growth, leads to high initial and maximum specific growth rates and a shorter lag phase, high productivity of the process and the economic coefficient of the yield of the biomass. If pH and pO2 are maintained at a set level, the most operative parameter of the process is the redox potential. A new informative characteristic of the cultivation process (T) is proposed. This characteristic permits the comparison of growth processes and indicates the time in which the fluctuations of Gibbs's free energy per 1000 million cells decrease to a definite level.