pH stability of penicillin acylase from <Emphasis Type="Italic">Escherichia coli</Emphasis>

The inactivation kinetics of penicillin acylase from Escherichia coli have been investigated over a wide pH range at 25 and 50 degrees C. The enzyme was very stable in neutral solutions and quickly lost its catalytic activity in acidic and alkaline solutions. In all cases, the inactivation proceeded according to first order reaction kinetics. Analysis of the pH dependence of enzyme stability provides evidence that stable penicillin acylase conformation is maintained by salt bridges. Destruction of the salt bridges due to protonation/deprotonation of the amino acid residues forming these ion pairs causes inactivation by formation of the unstable "acidic" EH(4)(3+), EH(3)(2+), EH(2)(+) and "alkaline" E(-) enzyme forms. At temperatures above 35 degrees C penicillin acylase apparently undergoes a conformational change that is accompanied by destruction of one of these salt bridges and change in the catalytic properties.     

Active site titration as a tool for the evaluation of immobilization procedures of penicillin acylase

Native and immobilized preparations of penicillin acylase from Escherichia coli and Alcaligenes faecalis were studied using an active site titration technique. Knowledge of the number of active sites allowed the calculation of the average turnover rate of the enzyme in the various preparations and allowed us to quantify the contribution of irreversible inactivation of the enzyme to the loss of catalytic activity during the immobilization procedure. In most cases a loss of active sites as well as a decrease of catalytic activity per active site (turnover rate) was observed upon immobilization. Immobilization techniques affected the enzymes differently. The effect of increased loading of penicillin acylase on the average turnover rate was determined by active site titration to assess diffusion limitations in the carrier.     

Reactivation of heterodimer and individual subunits of penicillin acylase from E. coli after inactivation in urea

Individual subunits of penicillin acylase from E. coli were isolated by gel-filtration under denaturing conditions (8 M urea). Recovery of the catalytic activity of the penicillin acylase heterodimer was studied after removal of urea. In the case of the heterodimer, 40-60% of the initial activity was recovered, whereas the activity of individual subunits was not recovered. Combination of native enzyme subunits with subunits isolated from the enzyme pre-inactivated with the irreversible inhibitor phenylmethylsulfonyl fluoride resulted in heterodimers which were active only in the case of involvement of the beta-subunit of the active enzyme.     

Stability and catalytic properties of penicillin acylase in systems with low water content

Stability and catalytic properties of native and immobilized penicillin acylase were studied in systems with low water content. Preparations of both native and immobilized penicillin acylase demonstrated the catalytic activity even in solid-phase systems which contained 3-5 wt. % of water. The stability and catalytic activity of penicillin acylase at low water content depended on the thermodynamic water activity (aw) in the system.     

Molecular cloning and analysis of the gene encoding the thermostable penicillin G acylase from Alcaligenes faecalis.

Alcaligenes faecalis penicillin G acylase is more stable than the Escherichia coli enzyme. The activity of the A. faecalis enzyme was not affected by incubation at 50 degrees C for 20 min, whereas more than 50% of the E. coli enzyme was irreversibly inactivated by the same treatment. To study the molecular basis of this higher stability, the A. faecalis enzyme was isolated and its gene was cloned and sequenced. The gene encodes a polypeptide that is characteristic of periplasmic penicillin G acylase (signal peptide-alpha subunit-spacer-beta subunit). Purification, N-terminal amino acid analysis, and molecular mass determination of the penicillin G acylase showed that the alpha and beta subunits have molecular masses of 23.0 and 62.7 kDa, respectively. The length of the spacer is 37 amino acids. Amino acid sequence alignment demonstrated significant homology with the penicillin G acylase from E. coli A unique feature of the A. faecalis enzyme is the presence of two cysteines that form a disulfide bridge. The stability of the A. faecalis penicillin G acylase, but not that of the E. coli enzyme, which has no cysteines, was decreased by a reductant. Thus, the improved thermostability is attributed to the presence of the disulfide bridge.     

Kinetic characteristics and enantioselective action of penicillinase in the hydrolysis reaction of N-phenylacetyl derivatives of 1-aminoethylphosphonic acid and its esters

Penicillin acylase from E. coli (EC 3.5.1.11) was found to hydrolyze N-phenylacetylated 1-aminoethylphosphonic acid and its esters. The enzyme preferentially converts the R-form of the substrates: the ratios of the bimolecular rate constants of penicillin acylasecatalyzed hydrolysis of R- and S-forms of 1-(N-phenylacetamino)-ethylphosphonic acid and its dimethyl- and diisopropyl-esters are 58000, 2300, 1800; these derivatives were shown to have the greatest values of the catalytic constants for enzymatic hydrolysis of all known substrates for penicillin acylase: 237, 148 and 134 s-1; the corresponding Km values are 3.7 10(-5), 6.8 10(-4) and 6.2 10(-4) M at pH 7.0. The kinetics of enzymatic hydrolysis of 1-(N-phenylacetamino)-ethylphosphonic acid was investigated up to high degrees of conversion. The inhibition of penicillin acylase by high concentrations of the R-form of the substrate (with substrate inhibition constant of 0.07 M) and competitive inhibition by the reaction product, phenylacetic acid (Ki = 3.5 10(-5) M), was observed.     

新的分离纯化青霉素酰化酶方法的研究

按0．6％(w／v)的比例将皂土加到青霉索酰化酶发酵上清液中,可将酶100％吸附,而吸附的蛋白质仅占发酵上清液中的10％左右。吸附时的pH和无机盐对酶的吸附影响不大。使用不同pH和种类的缓冲液洗涤皂土－酶复合物,不能将酶洗脱,但可洗脱15％左右吸附的杂蛋白。使用含10％以上的PEG和NaCl的磷酸缓冲液可将酶全部洗脱．酶纯化25倍,浓缩6倍左右。此法特点是简便,酶活力收率高,可在常温下操作,也可直接从未除菌体的发酵液中提取酶,具有工业应用价值。     

Crystallization and preliminary X-Ray diffraction analysis of glutaryl-7-aminocephalosporanic acid acylase from Pseudomonas sp. GK16

Glutaryl-7-aminocephalosporanicacid acylase from Pseudomonas sp. GK16 produces glutaryl-7-aminocephalosporanic acid, a key intermediate for the synthesis of cephem antibiotics. Sequence alignment suggests that the enzyme may belong to the N-terminal nucleophile hydrolase superfamily including penicillin G acylase. The enzyme is an (alphabeta)(2) heterotetramer of two nonidentical subunits. These subunits are derived from a nascent precursor polypeptide that is cleaved proteolytically through a two-step autocatalytic process upon folding. The enzyme has been crystallized using the vapor diffusion method. A bipyramidal crystal form was obtained from a solution containing polyethylene glycol (MW 3350) and calcium chloride. Complete diffraction data sets have been collected up to 2.8 A resolution. The crystal is tetragonal with the space group P4(1)2(1)2 or P4(3)2(1)2 and the unit cell parameters are a = b = 73.5 A, c = 380.3 A. Considerations of the possible values of V(m) account for the presence of a tetramer in the asymmetric unit.     

Improved activity and pH stability of E. coli ATCC 11105 penicillin acylase by error-prone PCR

Penicillin G acylase is the key enzyme used in the industrial production of β-lactam antibiotics. This enzyme hydrolyzes penicillin G and related β-lactam antibiotics releasing 6-aminopenicillanic acid, which is an intermediate in the production of semisynthetic penicillins. To improve the enzymatic activity of Escherichia coli penicillin acylase, sequential rounds of error-prone polymerase chain reaction were applied to the E. coli pac gene. After the second round of evolution, the best mutant M2234 with enhanced activity was selected and analyzed. DNA sequence analyses of M2234 revealed that one amino acid residue (K297I), located far from the center of the catalytic pocket, was changed. This mutant (M2234) has a specific activity 4.0 times higher than the parent enzyme and also displayed higher stability at pH 10.     

胞外青霉素酰化酶产生菌的选育

利用纸片显色方法,从土壤甲诀速筛选出98株产胞外青霉素酰化酶的菌种,经复筛其中10株酶活力较高,经鉴定均属于巨大芽孢杆菌。经单株分离得46号菌,用这株菌进行了产酶条件的研究,在最适产酶条件下,酶话力比开始提高了3．6倍。在此基础上又进行了物理化学因素处理,得突变株UL-81,酶活力达720u／1 Ooml发酵液。对原株和突变株进行比较,发现UL-81菌落、细胞形态、诱导剂苯乙酸用量及添加时间等明显不同于原株。在500L罐发酵酶活达8 20u／1OOml发酵液,为开始酶活的16倍。     

Expression of the Arthrobacter viscosus penicillin G acylase gene in Escherichia coli and Bacillus subtilis

The penicillin G acylase gene cloned from Arthrobacter viscosus 8895GU was subcloned into vectors, and the recombinant plasmids were transferred into Escherichia coli or Bacillus subtilis. Both E. coli and B. subtilis transformants expressed the A. viscosus penicillin G acylase. The enzyme activity was found in the intracellular portion of the E. coli transformants or in the cultured medium of the B. subtilis transformants. Penicillin G acylase production in the B. subtilis transformants was 7.2 times higher than that in the parent A. viscosus. The A. viscosus penicillin G acylase was induced by phenylacetic acid in A. viscosus, whereas the enzyme was produced constitutively in both the E. coli and B. subtilis transformants carrying the A. viscosus penicillin G acylase gene.     

Expression of the Arthrobacter viscosus penicillin G acylase gene in Escherichia coli and Bacillus subtilis.

The penicillin G acylase gene cloned from Arthrobacter viscosus 8895GU was subcloned into vectors, and the recombinant plasmids were transferred into Escherichia coli or Bacillus subtilis. Both E. coli and B. subtilis transformants expressed the A. viscosus penicillin G acylase. The enzyme activity was found in the intracellular portion of the E. coli transformants or in the cultured medium of the B. subtilis transformants. Penicillin G acylase production in the B. subtilis transformants was 7.2 times higher than that in the parent A. viscosus. The A. viscosus penicillin G acylase was induced by phenylacetic acid in A. viscosus, whereas the enzyme was produced constitutively in both the E. coli and B. subtilis transformants carrying the A. viscosus penicillin G acylase gene.     

Activation and stabilization of penicillin V acylase from streptomyces lavendulae in the presence of glycerol and glycols

Penicillin V acylase (EC 3.5.1.11) from Streptomyces lavendulae showed both enhanced activity and stability in mixed water/glycerol and water/glycols solvents. The catalytic activity was increased up to a critical concentration of these cosolvents, but further addition of the latter led to a gradual protein deactivation. The highest stabilizing effect was achieved in the presence of glycerol. Thermal stability was increased proportionally to the concentration of glycerol and glycols in the reaction mixture only if the amount added is below the threshold concentration. Reaction conditions that allow simultaneously enhanced activity and stability in the hydrolysis of penicillin V catalyzed by penicillin V acylase from S. lavendulae could be established.     

Cross-linked aggregates of penicillin acylase: robust catalysts for the synthesis of β-lactam antibiotics

A novel method for the immobilization of penicillin G acylase (penicillin amidohydrolase, E.C. 3.5.1.11) is reported. It involves the physical aggregation of the enzyme, followed by chemical cross-linking to form insoluble cross-linked enzyme aggregates (CLEAs). Compared with conventionally immobilized penicillin G acylases, these CLEAs possess a high specific activity as well as a high productivity and synthesis/hydrolysis (S/H) ratio in the synthesis of semi-synthetic antibiotics in aqueous media. Moreover, they are active in a broad range of polar and apolar organic solvents.     

Optimization of a pseudo-affinity process for penicillin acylase purification

A pseudo-affinity process for penicillin acylase (EC 3.5.1.11) purification using an affinity ligand (Ampicillin) attached on Sepharose 4B-CNBr was optimized. The enzyme adsorption on this affiant (Amp-Seph) is independent of pH between 5.5 and 8.8, in 100?mM phosphate containing 22% (w/v) ammonium sulphate. The desorption of the penicillin acylase from the affinity gels was carried out, the best desorption results being obtained through a non specific eluent, 100?mM phosphate pH 4.6 with 15% (w/v) ammonium sulphate. The best purification results were obtained with an enzymatic extract, produced through osmotic shock of Escherichia coli cells (3.7?IU/mg prot). With this extract and an affinity gel of Sepharose 4B-CNBr derivatized with ampicillin (3.8?μmol/cm³?gel), a maximum activity capacity adsorbed of 20?IU/cm³?gel was obtained for initial values of activity and protein concentration of 1.7?IU/cm³ and 0.4?mg prot/cm³, respectively. With the optimized eluent it was possible to obtain penicillin acylase in only one purification step with a desorption yield of enzyme activity higher than 90%. The penicillin acylase produced with this process was characterized by a maximum purity of 34?IU/mg prot, corresponding to a purification degree higher than 150 in relation to the lowest pure enzymatic extract. The enzyme purity of the eluted fractions was certified by SDS gel electrophoresis and liquid chromatography through a Mono Q column in a FPLC apparatus. The gel electrophoresis presented 4 main stained bands with 2 corresponding to α and β subunits of the penicillin acylase with equivalent molecular weights of 27 and 63?kDa. No external diffusion resistance on penicillin acylase and total protein adsorption on this affiant (Amp-Seph 3.8?μmol/cm³?gel) were observed for continuous adsorption processes performed at two different agitation speeds (120 and 400?rpm).     

重组青霉素G酰化酶拆分制备（S）-邻氯苯甘氨酸

对产青霉素G酰化酶的重组枯草芽胞杆菌发酵产酶条件进行优化,确定优化后的发酵条件：可溶性淀粉10g/L、蛋白胨12g/L、酵母粉3g/L、NaCl10g,／L;pH7．5、培养温度37℃、装液量80mL（500mL三角瓶）、培养28h,青霉素G酰化酶的表达水平由最初的7．34U／mL提高至18．23U／mL。以表达青霉素G酰化酶的枯草芽胞杆菌发酵液为酶源,在水相中对映选择性催化N-苯乙酰-（R,S）-邻氯苯甘氨酸制备（S）-邻氯苯甘氨酸,当底物浓度为100mol／L时转化4h,转化率达44．2％。对底物浓度为80mmoL／L反应液中的（S）-邻氯苯甘氨酸进行分离,达到理论收率的94．29％（以N-苯乙酰-（R,S）-邻氯苯甘氨酸的0．5倍摩尔量为理论产率）,e．e．值大于99．9％。170℃条件下,N-苯乙酰-（R）-邻氯苯甘氨酸与苯乙酸共熔消旋为N-苯乙酰-（R,S）-邻氯苯甘氨酸可用于循环拆分。     

Bacillus sphaericus Penicillin V Acylase: Purification,Substrate Specificity,and Active-Site Characterization

Penicillin V acylase from Bacillus sphaericus was purified to homogeneity with an overall yield of 15%. The enzyme exhibited comparatively high specificity for penicillin V, penicillin G, and other related compounds being hydrolyzed at less than 10% of the rate of penicillin V. Moreover, the high rate of hydrolysis was observed when the side chain of the substrate molecule was unsubstituted. Lysine-modifying reagents inactivated the enzyme rapidly. Kinetics and titration studies indicated the involvement of lysine in the catalytic activity of the enzyme. Received: 10 July 1996 / Accepted: 26 August 1996     

聚丙烯腈纤维固定化青霉素酰化酶性质的研究

将巨大芽孢杆菌（Bacillusmegaterium）青霉素酞化酶连接到聚丙烯腈纤维载体上,制成固定化青霉素酰化酶。其表现活力约为2000u／g。水解青霉素G的最适温度为50℃;最适PH为9．0;在PHS．5～10．3、温度50℃以下酶的活力稳定;表观米氏常数Ka为1．33×10-8mol／L;最大反应速度Vm为2．564mmol·min-1;苯乙酸为竞争性抑制剂,抑制常数为0．16mol／L。水解10％的青霉素G钾盐溶液,使用20批,保留酶活力80％。     

Separation and purification of penicillin acylase from Escherichia coli using AOT reverse micelles

Summary The extraction of penicillin acylase by reverse micellar solutions of a surfactant was studied. A 50 mM solution of dioctyl sodium sulphosuccinate in isooctane extracted 46% of the enzyme activity in a crude periplasmic extract of induced cells of E. coli ATCC 9637. The increase in the specific activity of the final enzyme preparation, after stripping of the organic phase at pH 7.5, in the presence of 1 M KCl, was 8 - fold.Abbreviations PA penicillin acylase (penicillin amidohydrolase EC 3.5.1.11) - AOT Aerosol OT (dioctyl sodium sulphosuccinate) - NIPAB 6-nitro-3-(phenylacetamido)-benzoic acid - NABA 6-nitro-3-aminobenzoic acid - BSA bovine serum albumin - SDS sodium dodecylsulphate