Potato peel as a solid state substrate for thermostable α-amylase production by thermophilic Bacillus isolates

Summary Potato peel was found to be a superior substrate for solid state fermentation, compared to wheat bran, for the production of α-amylase by two thermophilic isolates of Bacillus licheniformis and Bacillus subtilis. Under optimal conditions, B. licheniformis produced 270 units/ml and 175 units/ml of α-amylase on potato peel and wheat bran, respectively, while the corresponding values for B. subtilis were 600 units/ml and 265 units/ml. The enzyme from B.␣licheniformis was optimally active at 90 °C and pH 9.0, while that from B. subtilis at 60 °C and pH 7.0. The nature of the experimental data permitted excellent polynomial fits, on the basis of which, two master equations, corresponding to the isolated strains, were derived for estimation of enzyme activity for any set of values of temperature, particle size, moisture, and incubation time within the indicated ranges.     

荔枝果皮过氧化酶的纯化与性质研究(英)

荔枝果皮采后褐变是影响这一重要热带水果经济价值的主要问题,酚类物质的酶促氧化一直被认为是造成植物组织褐变的关键因素,其中多酚氧化酶被研究得最多.过氧化物酶在植物体中分布很广,能够氧化多种底物,在荔枝果皮中的含量也很高.非结合性过氧化物酶已经被证明在果实的采后成熟与老化过程中参与多种过程.在这项研究中,用磷酸缓冲液提取荔枝果皮的非结合性过氧化物酶,并通过硫酸铵沉淀,DEAE Sephadex A-50离子交换柱层析以及Sephadex G-100凝胶过滤进行纯化.对得到的酶溶液进行了酶学性质的研究,发现荔枝果皮过氧化物酶具有较高的热稳定性和高的最适反应pH值（6.8）,能够氧化许多底物尤其是单酚和各种多酚类物质,反应抑制剂专一性与其他植物来源的过氧化物酶略有不同.显示了过氧化物酶参与荔枝果皮褐变过程的可能性,并为提高荔枝采后贮藏性提供了新的思路.     

A thermostable,alkaline-active,keratinolytic proteinase from chrysosporium keratinophilum

Thermostable alkaline proteinase was produced by a strain of Chrysosporium keratinophilum when cultured in lactose/mineral salt medium incorporating keratin solubilized with DMSO. The proteinase, partially purified by cold-acetone precipitation followed by gel-filtration on Sephadex G-75, was optimally active at pH 9 and stable from pH 7 to 10 with over 90% relative residual activity after incubation at 25°C for 24 h. The optimum temperature for enzyme activity was 90°C at which the activity half-life was 30 min. Enzyme activity was stimulated by Fe²⁺ and inhibited by 1,10 o-phenanthroline. Gel-filtration indicated an M _r of 69 kDa.The authors are with the Department of Microbiology, Faculty of Biological Sciences, P.M. B.006, University of Nigeria, Nsukka, Enugu State, Nigeria     

Purification and enzymatic properties of α-galactosidase from Penicillium janthinellum

α-Galactosidase (E.C.3.2.1.22) from Penicillium janthinellum was purified by precipitation and fractionation with ammonium sulphate, cold acetone or ethanol, calcium phosphate gel, and column chromatographies on Sephadex G-100 and G-200. The enzyme was purified about 110.39-fold when Sephadex G-100 was used. α-Galactosidase exhibited the optimum pH and temperature at 4.5 and 60°C, respectively. The optimum enzyme stability was obtained at pH 3.5 for 24 h (at room temperature). The enzyme was found to be thermostable below 65°C up to 40 minutes and was gradually inactivated by increasing the temperature above this degree. The MICHAELIS constant was 0.55 mM for p-nitrophenyl-α-D-galactoside. The α-galactosidase activity was strongly inhibited by Hg⁺⁺ and slightly activated by Mn⁺⁺. The results show the possibility of producing a thermostable enzyme from a low-priced agricultural product, for instance, lupine.     

Purification and some properties of endopolygalacturonase from Rhizopus sp. LKN

An endopolygalacturonase of Rhizopus sp. strain LKN, one of several isolates from tempe starter (ragi), was purified 235-fold by CM-Sephadex C-50, DEAE-Sephadex A-50 ion exchange chromatographies and Sephadex G-75 gel filtration. The purified enzyme was homogeneous by SDS-PAGE with a M _r of 38.5 kDa. Its K _m value for pectic acid was 2 mg/ml. It was stable at pH 4.5 to 11 and up to 50°C, with optimum activity at pH 4.5 to 4.75 and 55 to 60°C. Some ionic compounds enhanced the enzyme activity, whereas tannic acid at 0.5 mm caused about 90% inhibition.The authors are with the Department of Food Science and Technology, Faculty of Agriculture, Kyushu University, Hakozaki, Fukuoka 812, Japan.     

Urease from Arthrobacter oxydans,a nickel-containing enzyme

In Arthrobacter oxydans, Klebsiella aerogenes and Sporosarcina ureae, growth with urea as a nitrogen source turned out to be more sensitive to inhibition by EDTA than that with ammonia. The inhibition was overcome by added nickel chloride, but not by other divalent metal ions tested. In A. oxydans the uptake of ⁶³Ni was paralleled by an increase in urease (urea amidohydrolase, EC 3.5.1.5) activity under certain conditions. Following growth with radioactive nickel, urease from this strain was enriched by heat treatment and acetone fractionation. Copurification of ⁶³Ni and urease was observed during subsequent Sephadex gel chromatography. Almost the entire labelling was detected together with the purified enzyme after focusing on polyacrylamide gel. The relative molecular mass of the purified urease was estimated to be 242,000. The pH optimum was 7.6, the K _m-value 12.5 mmol/l and the temperature optimum 40°C; heat stability was observed up to 65°C. In presence of 10 mmol/l EDTA the protein-nickel binding remained intact at pH 7; at pH 5 and below, nickel was irreversibly removed with concommitant loss of enzyme activity. The results demonstrated that nickel ions are required for active urease formation in the bacterial strains studied, and that urease from A. oxydans is a nickel-containing enzyme.Dedicated to Professor Dr. H.-G. Schlegel on the occasion of his 60th birthday     

Purification and characterization of pectin lyase secreted by <Emphasis Type="Italic">Penicillium citrinum</Emphasis>

The importance of various parameters such as sugarcane juice concentration, pH of the medium, and effects of different solid supports for maximum secretion of pectin lyase from Penicillium citrinum MTCC 8897 has been studied. The enzyme was purified to homogeneity by Sephadex G-100 and DEAE-cellulose chromatography. The molecular mass determined by SDS-PAGE was 31 kDa. The K _m and k _cat values were found to be 1 mg/ml and 76 sec⁻¹, respectively. The optimum pH of the purified pectin lyase was 9.0, though it retains activity in the pH 9.0–12.0 range when exposed for 24 h. The optimum temperature was 50°C, and the pectin lyase was found to be completely stable up to 40°C when exposed for 1 h. The purified pectin lyase was found efficient in retting of Linum usitatissimum, Cannabis sativa, and Crotalaria juncea. Published in Russian in Biokhimiya, 2009, Vol. 74, No. 7, pp. 985–992.     

Production and characterization of keratinase from<Emphasis Type="Italic">Paracoccus</Emphasis> sp. WJ-98

A bacterial strain WJ-98 found to produce active extracellular keratinase was isolated from the soil of a poultry factory. It was identified asParacoccus sp. based on its 16S rRNA sequence analysis, morphological and physiological characteristics. The optimal culture conditions for the production of keratinase byParacoccus sp. WJ-98 were investigated. The optimal medium composition for keratinase production was determined to be 1.0% keratin, 0.05% urea and NaCl, 0.03% K₂HPO₄, 0.04% KH₂PO₄, and 0.01% MgCl₂·6H₂O. Optimal initial pH and temperature for the production of keratinase were 7.5 and 37°C, respectively. The maximum keratinase production of 90 U/mL was reached after 84 h of cultivation under the optimal culturing conditions. The keratinase fromParacoccus sp. WJ-98 was partially purified from a culture broth by using ammonium sulfate precipitation, ion-exchange chromatography on DEAE-cellulose, followed by gel filtration chromatography on Sephadex G-75. Optimum pH and temperature for the enzyme reaction were pH 6.8 and 50°C, respectively and the enzymes were stable in the pH range from 6.0 to 8.0 and below 50°C. The enzyme activity was significantly inhibited by EDTA, Zn²⁺ and Hg²⁺. Inquiry into the characteristics of keratinase production from these bacteria may yield useful agricultural feed processing applications.     

Production,isolation and characterization of extracellular protease of an alkaliphilic strain of Arthrobacter ramosus,MCM B-351 isolated from the alkaline lake of Lonar,India

An extracellular protease was produced by Arthrobacter ramosus isolated from the alkaline lake of Lonar, Buldhana District of Maharashtra, India when grown on a synthetic medium of pH 10 containing casein. The optimum conditions for production were 3.0% initial casein concentration, 2% inoculum of 1 × 10⁸ cells/ml, pH 9.0, temperature 30 °C and shaken culture conditions. The protease was purified by ammonium sulphate precipitation followed by Sephadex G-100 chromatography. Two proteases viz. Arthro I and Arthro II, having molecular weights 21 and 11.4 kDa respectively were isolated. The Arthro II fraction had K _m 395 g/ml and V _max 10.55 g/min for azocasein. The maximum activity of enzyme was at 55 °C and pH 8. It was thermostable (up to 80 °C), alkali stable (pH 12) and stable in commercial detergent. The enzyme may contain a thiol group at the active site.     

Red cell hydrolases

Summary A 0.1% Triton X-100 extract of human erythrocyte plasma membranes contained high proteolytic activity as determined by a very sensitive assay utilizing³H-acetylated hemoglobin (162 cpm/pmole) as a substrate. Two proteolytic enzymes having optimum activity at pH 3.4 and pH 7.4 were isolated from Sephadex G-100. The protease active at pH 3.4 was 75 times as active as the pH 7.4 enzyme and it was purified 182-fold over the original homogenate and characterized. A linear relationship for activity versus time and activity versus concentration of enzyme was found. The optimum temperature was 37°C and theK _m was 1×10^–5 m hemoglobin. No enzyme activation was observed with any cation studied and EDTA had no inhibitory effect; (10mm Fe⁺³ and Hg⁺² were inhibitory). The pH 3.4 protease was stable indefinitely at –20°C in 0.1% Triton X-100. Gel electrophoresis was performed on a sodium dodecylsulfate-mercaptoethanol enzyme preparation and two protein bands (mol. wt. 33,000 and 54,000) were evident for the Sephadex G-200 eluate containing the pH 3.4 protease.     

Purification and characterization of lignin peroxidases from <Emphasis Type="Italic">Penicillium decumbens</Emphasis> P6

Summary Peroxidases are essential enzymes in biodegradation of lignin and lignite which have been investigated intensively in the white-rot fungi. This is the first report of purification and characterization of lignin peroxidase from Penicillium sp. P6 as lignite degradation fungus. The results indicated that the lignin peroxidase of Penicillium decumbens P6 had physical and chemical properties and a N-terminal amino acid sequence different from the lignin peroxidases of white-rot fungi. The lignin peroxidase was isolated from a liquid culture of P. decumbens P6. This enzyme had a molecular weight of 46.3 KDa in SDS-PAGE and exhibited greater activity, temperature stability and wider pH range than those previously reported. The isolation procedure involved (NH₄)₂SO₄ precipitation, ion-exchange chromatography on DEAE-cellulose and CM-cellulose, gel filtration on Sephadex G-100, and non-denaturing, discontinuous polyacrylamide gel electrophoresis. The K _m and V _max values of this enzyme using veratryl alcohol as substrate were 0.565 mmol L ⁻¹ and 0.088 mmol (mg protein) ⁻¹ min ⁻¹ respectively. The optimum pH of P6 lignin peroxidase was 4.0, and 70.6 of the relative activity was remained at pH 9.0. The optimum temperature of the enzyme was 45 °C.     

A Review of: “The Plasma Proteins,F. W. Putnam Volumes I and II, 2nd Edition, 481 and 436 pages respectively,hardbound; Academic Press, 1975; $37.50; $34.50”

A serine protease was purified 6.9-fold from the leaves of Thespesia populnea using ammonium sulfate fractionation followed by CM-cellulose and Sephadex G-100 chromatography. The purified enzyme was named populnein and was characterized. It was made up of a single polypeptide, and matrix-assisted laser desorption ionization–time of flight (MALDI-TOF) mass spectrometry (MS) analysis showed that the enzyme had a molecular mass of 14,518 Da. Inhibition of enzyme activity by phenyl methane sulfonyl fluoride indicates that populnein belongs to the class of serine proteases. The enzyme had appreciable pH and temperature stability. The activity of the enzyme was optimal at pH 8.0 and temperature 40°C. The enzyme was thermostable and retained 85% of its activity at 70°C after 1 hr. The enzyme was also resistant to autodigestion. The stabilization of the membrane of red blood cells exhibited by the protease populnein was found to be higher than for diclofenac. More studies are necessary to investigate the biological activity and applications of serine protease of T. populnea. Supplemental materials are available for this article. Go to the publisher's online edition of Preparative Biochemistry and Biotechnology to view the supplemental file.     

Catechol 1,2-dioxygenase from α-naphthol degrading thermophilic Geobacillus sp. strain: purification and properties

The purpose of this study was purification and characterization of catechol 1,2-dioxygenase from Geobacillus sp. G27 strain, which degrades α-naphthol by the β-ketoadipate pathway. The catechol 1,2-dioxygenase (C1,2O) was purified using four steps of ammonium sulfate precipitation, DEAE-celullose, Sephadex G-150 and hydroxylapatite chromatographies. The enzyme was purified about 18-fold with a specific activity of 7.42 U mg of protein⁻¹. The relative molecular mass of the native enzyme estimated on gel chromatography of Sephadex G-150 was 96 kDa. The pH and temperature optima for enzyme activity were 7 and 60°C, respectively. A half-life of the catechol 1,2-dioxygenase at the optimum temperature was 40 min. The kinetic parameters of the Geobacillus sp. G27 strain catechol 1,2-dioxygenase were determined. The enzyme had apparent K_m of 29 μM for catechol and the cleavage activities for methylcatechols were much less than for catechol and no activity with gentisate or protocatechuate was detected.     

Purification and characterization of trypsin inhibitor from seeds of faba bean (Vicia faba L.)

A trypsin inhibitor from seeds of faba bean (Vicia faba L.) was purified to near homogeneity as judged by native-PAGE with about 11 % recovery using ammonium sulphate fractionation, ion-exchange chromatography on DEAE-cellulose and gel filtration through Sephadex G-100. The inhibitor had a molecular weight of 18 kD as determined by SDS-PAGE and Sephadex G-100. The inhibitor inhibited trypsin and chymotrypsin to the extent of 48 and 12 %, respectively. The inhibtion was of non-competitive type with dissociation constant for the enzyme inhibitor complex in the region of 0.07 mg·ml⁻¹. The inhibtor was stable between pH 4 and 5. It completely lost its activity when heated at 125 °C for 1 h or at 100 °C for 2 h. The inhibitor also lost its activity on exposure to 2-mercaptoethanol. Based on these properties, it could be concluded that Vicia faba trypsin inhibitor belongs to Bowman-Birk type of inhibitors, as it has molecular weight lower than generally observed for Kunitz type inhibitors.     

L-asparaginase production by <Emphasis Type="Italic">Streptomyces albidoflavus</Emphasis>

Attempts were made to optimize the cultural conditions for the production of L-asparaginase by Streptomyces albidoflavus under submerged fermentations. Enhanced level of L-asparaginase was found in culture medium supplemented with maltose as carbon source. Yeast extract (2%) was served as good nitrogen source for the production of L-asparaginase. The optimum pH for enzyme production was 7.5 and temperature was 35°C. The release of L-asparaginase from the cells of S. albidoflavus was high when strain was treated with cell disrupting agents like EDTA and lysozyme. The enzyme produced by the strain was purifi ed by ammonium sulfate, Sephadex G-100 and CM-Sephadex C-50 gel fi ltration and the molecular weight was apparently determined as 112 kDa.     

Production of macerating enzymes of mandarin orange peel by fungal cultures

Summary Thirty-nine fungal cultures belonging to the genera of Aspergillus, Podospora, Sordaria, Cbaetomium, Iodophanus, Scleotinia, Coniella, Pellicularia and others, were examined for the production of enzymes which macerate the mandarin orange peel using a wheat bran as substrate. An isolated strain of Aspergillus niger was an excellent producer of macerating enzymes compared to other organisms tested. The peel of the mandarin orange could be macerated by the crude enzymes produced by isolated A. niger. The maceration of 1 g of peel/24 h yielded 0.57 g of reducing sugars. Expressed differently, 83% of solid peel materials were released from the peel into the water/24 h under the following conditions: a peel concentration of 8 g peel/l, a crude enzyme concentration of 1 g protein/l, a temperature of 40°C, a pH of 5, a 24 h incubation time and 120 rpm reciprocal shaking. The test of the macerating activity of commercially available hydrolases on the orange peel showed that the two samples of pectinase originating from A. niger had about the same activity as isolated A. niger whereas the two samples of cellulase originating from Trichoderma viride had remarkably lower activities than A. niger.     

Purification and characterization of a catechol 1,2-dioxygenase from a phenol degrading <Emphasis Type="Italic">Candida albicans</Emphasis> TL3

A eukaryotic catechol 1,2-dioxygenase (1,2-CTD) was produced from a Candida albicans TL3 that possesses high tolerance for phenol and strong phenol degrading activity. The 1,2-CTD was purified via ammonium sulfate precipitation, Sephadex G-75 gel filtration, and HiTrap Q Sepharose column chromatography. The enzyme was purified to homogeneity and found to be a homodimer with a subunit molecular weight of 32,000. Each subunit contained one iron. The optimal temperature and pH were 25°C and 8.0, respectively. Substrate analysis showed that the purified enzyme was a type I catechol 1,2-dioxygenase. This is the first time that a 1,2-CTD from a eukaryote (Candida albicans) has been characterized. Peptide sequencing on fragments of 1,2-CTD by Edman degradation and MALDI-TOF/TOF mass analyses provided information of amino acid sequences for BLAST analysis, the outcome of the BLAST revealed that this eukaryotic 1,2-CTD has high identity with a hypothetical protein, CaO19_12036, from Candida albicans SC5314. We conclude that the hypothetical protein is 1,2-CTD.     

Purification and characterization of a family 5 endoglucanase from a moderately thermophilic strain of Bacillus licheniformis

Strains of thermophilic bacilli were screened for cellulolytic activity by gel diffusion assay on selective medium at 55°C. Strain B-41361, identified as a strain of Bacillus licheniformis, displayed activity against carboxymethylcellulose. Zymogram analysis demonstrated several catalytically active polypeptides with the most prominent species having a mass of 37 kDa. The enzyme was purified 60-fold with a 17% yield and specific activity of 183 U/mg. The amino terminal sequence was homologous to members of glycoside hydrolase family 5. Optimal temperature was 65°C (measured over 30 min), but the enzyme was most stable at 60°C, retaining greater than 90% activity after one hour. The enzyme had a broad pH range, with maximal activity at pH 6.0, 75% maximal activity at pH 4.5, and 40% at pH 10. The enzyme hydrolyzed p-nitrophenylcellobioside, barley β-glucan, and lichenan, but no activity was detected against avicel or acid-swollen cellulose.Mention of a trade name or commercial products in this publication is solely for the purpose of providing specific information and does not imply recommendation or endorsement by the U.S. Department of Agriculture.     

Purification and Properties of Proteases from a Marine-psychrophilic Bacterium

Protease which was found in the culture fluid of Pseudomonas sp. No. 548 was fractionated into four components with protease activity by a two step chromatography using DEAE-cellulose. Each protease was further purified by gel filtration on Sephadex G-100 and/or G-75. The protease of Ia was obtained in crystalline form and was shown to be homogeneous by analysis with electrophoresis, while the other three enzymes were also highly purified. The enzymatic properties of the proteases were investigated. All of the four enzymes were inactivated by ethylene diamine tetraacetate. Proteases Ia, Ib, and IIb were inactivated by diisopropylfluorophosphate. The optimum activity of protease Ia was shown to be at pH 10.0, and that of the other enzymes were at pH 7.0 to 8.0. The proteases of Ia, Ib, and IIb were stabilized by calcium ion. The effect of temperature, pH, and metal ions on the activity of the enzyme were also investigated.     

Biochemical analysis of a fibrinolytic enzyme purified from <Emphasis Type="Italic">Bacillus subtilis</Emphasis> strain A1

A fibrinolytic enzyme from Bacillus subtilis strain Al was purified by chromatographic methods, including DEAE Sephadex A-50 column chromatography and Sephadex G-50 column gel filtration. The purified enzyme consisted of a monomeric subunit and was estimated to be approximately 28 kDa in size by SDS-PAGE. The specific activity of the fibrinolytic enzyme was 1632-fold higher than that of the crude enzyme extract. The fibrinolytic activity of the purified enzyme was approximately 0.62 and 1.33 U/ml in plasminogen-free and plasminogen-rich fibrin plates, respectively. Protease inhibitors PMSF, DIFP, chymostatin, and TPCK reduced the fibrinolytic activity of the enzyme to 13.7, 35.7, 15.7, and 23.3%, respectively. This result suggests that the enzyme purified from B. subtilis strain Al was a chymotrypsin-like serine protease. In addition, the optimum temperature and pH range of the fibrinolytic enzyme were 50°C and 6.0–10.0, respectively. The N-terminal amino acid sequence of the purified enzyme was identified as Q-T-G-G-S-I-I-D-P-I-N-G-Y-N, which was highly distinguished from other known fibrinolytic enzymes. Thus, these results suggest a fibrinolytic enzyme as a novel thrombolytic agent from B. subtilis strain Al.