Localization of the genes for silk fibroin in silk gland cells of Bombyx mori.

Radioactive iodinated silk fibroin messenger RNA and ribosomal RNA have been used as probes to localize their genes in tissue sections of Bombyx mori by in situ hybridization. From filter hybridization experiments it is inferred that the majority of the grains produced by in situ hybridization with fibroin mRNA represents specific hybridization to fibroin genes. Sections of the posterior silk gland where silk is synthesized have been compared with those of the middle gland which does not synthesize fibroin. Glands have been analyzed from the second through the fifth (last) larval instar during feeding and moulting periods. During later stages when the gland cells increase their DNA content by polyploidization, serial sections were required to follow the distribution of grains through entire nuclei. At all stages, both ribosomal DNA and fibroin genes are distributed randomly throughout the nuclei without a preferred relationship to any nuclear structure.     

NMR study of silk I structure of Bombyx mori silk fibroin with 15N- and 13C-NMR chemical shift contour plots

The metastable state silk I structures of Bombyx mori silk fibroin in the solid state were studied on the basis of ¹⁵N- and ¹³C-nmr chemical shifts of Ala, Ser, and Gly residues. The ¹⁵N cross-polarization magic angle spinning (CP/MAS) nmr spectra of the precipitated fraction after chymotrypsin hydrolysis of B. mori silk fibroin with the silk I and silk II forms were measured to determine the ¹⁵N chemical shifts of Gly, Ala, and Ser residues. For comparison, ¹⁵N CP/MAS nmr chemical shifts of Ala were measured for [¹⁵N] Ala Philosamia cynthia ricini silk fibroin with antiparallel β-sheet and α-helix forms. The ¹³C CP/MAS nmr chemical shifts of Ala, Ser, and Gly residues of B. mori silk fibroin with the silk I and silk II forms, as well as ¹³C CP/MAS nmr chemical shifts of Ala residue of P. c. ricini silk fibroin with β-sheet and α-helix forms, are used for the examination of the silk I structure. Both silk I and α-helix peaks are shifted to a lower field than silk II (β-sheet) for the Cα carbons of the Ala residues, while both Cβ carbon peaks are shifted to higher field. However, the silk I peak of the ¹⁵N nucleus of the Ala residue is shifted to lower field than the silk II peak, but the α-helix peak is shifted to high field. Thus, the difference in the structure between the silk I and α-helix is reflected in a different manner between the ¹³C and ¹⁵N chemical shifts. The Cα and Cβ chemical shift contour plots for Ala and Ser residues, and the Cα plot for the Gly residue, were prepared from the Protein Data Bank data obtained for 12 proteins and used for discussing the silk I structure quantitatively from the conformation-dependent chemical shifts. The plots reported by Le and Oldfield for ¹⁵N chemical shifts were also used for the purpose. All these chemical shift data support Fossey's model (Ala: ϕ = −80°, φ = 150°, Gly: ϕ = −150°, φ = 80°) and do not support Lotz and Keith's model (Ala: ϕ = −104.6°, φ = 112.2°, Gly: ϕ = 79.8°, φ = 49.7° or Ala: ϕ = −124.5°, φ = 88.2°, Gly: ϕ = −49.8°, φ = −76.1°) as the silk I structure. © 1997 John Wiley & Sons, Inc.     

Impact of pre-incubation time of silk fibroin scaffolds in culture medium on cell proliferation and attachment

Cell behaviours such as proliferation and attachment can be affected by the length of pre-incubation period of the scaffolds in the culture medium for long term. The aim of this study was to investigate the long term pre-incubation of 3D silk fibroin scaffolds in complete culture medium on cell attachment and proliferation. After the preparation of silk fibroin scaffolds by the technique of freeze drying, the scaffolds were pre-incubated in complete culture medium for 2 d, 6 d or 10 d before apical papilla stem cells (SCAP) seeding. Modifications of the scaffold surface and wettability were examined by FE-SEM and water contact angle, respectively. Results showed a decrease both in roughness and water contact angle as pre-incubation time increases. DNA measurement after 18 h and 10 d cell seeding showed a significant increase of DNA concentration which represents better attachment and proliferation with pre-incubation time increase. Qualitative examination, live&dead assay or H&E staining method after 30 h and 10 d cell seeding respectively, indicated that pre-incubation of scaffolds has time dependent effect on cell proliferation and attachment. This suggests that improvement of cell attachment and proliferation may be mediated by differences in the amount of wettability (decreased water contact angle) after exposure of scaffold to culture medium for long term which, in turn, causes more protein adsorption in the surface of silk fibroin scaffold (decreased roughness).     

Unusual protein behavior illustrated with silk fibroin

We investigated the interaction between phospholipid membranes and silk fibroin recovered from the posterior silk gland of the silkworm. Observations of the planar lipid bilayer membrane and electron microscopic observations of liposomes showed that newly constructed silk fibroin, existing in the form of filaments, quickly penetrates phospholipid membranes without bursting them.     

Isolation of giant silk fibroin polysomes and fibroin mRNP particles using a novel ribonuclease inhibitor, hydroxystilbamidine

Hydroxystilbamidine isethionate, a dye capable of binding to both DNA and RNA, has been found to be a powerful inhibitor of cellular ribonucleases. A procedure has been developed that, with the aid of this compound, permits the preparative isolation of giant silk fibroin polyribosomes from the posterior silk gland of Bombyx mori. The polyribosomes contain approximately 45-112 ribosomal particles, as judged by electron microscopy. Treatment of giant fibroin polyribosomes with EDTA releases a particle that sediments at 125S. This mRNP particle contains biologically active silk fibroin mRNA, as judged by cell-free translation in an mRNA-dependent reticulocyte cell-free system.     

Degradation mechanism and control of silk fibroin

Controlling the degradation process of silk is an important and interesting subject in the field of biomaterials. In the present study, silk fibroin films with different secondary conformations and nanostructures were used to study degradation behavior in buffered protease XIV solution. Different from previous studies, silk fibroin films with highest β-sheet content achieved the highest degradation rate in our research. A new degradation mechanism revealed that degradation behavior of silk fibroin was related to not only crystal content but also hydrophilic interaction and then crystal-noncrystal alternate nanostructures. First, hydrophilic blocks of silk fibroin were degraded. Then, hydrophobic crystal blocks that were formerly surrounded and immobilized by hydrophilic blocks became free particles and moved into solution. Therefore, on the basis of the mechanism, which enables the process to be more controllable and flexible, controlling the degradation behavior of silk fibroin without affecting other performances such as its mechanical or hydrophilic properties becomes feasible, and this would greatly expand the applications of silk as a biomedical material.     

Flexibility regeneration of silk fibroin in vitro

Although natural silk fibers have excellent strength and flexibility, the regenerated silk materials generally become brittle in the dry state. How to reconstruct the flexibility for silk fibroin has bewildered scientists for many years. In the present study, the flexible regenerated silk fibroin films were achieved by simulating the natural forming and spinning process. Silk fibroin films composed of silk I structure were first prepared by slow drying process. Then, the silk fibroin films were stretched in the wet state, following the structural transition from silk I to silk II. The difference between the flexible film and different brittle regenerated films was investigated to reveal the critical factors in regulating the flexibility of regenerated silk materials. Compared with the methanol-treated silk films, although having similar silk II structure and water content, the flexible silk films contained more bound water rather than free water, implying the great influence of bound water on the flexibility. Then, further studies revealed that the distribution of bound water was also a critical factor in improving silk flexibility in the dry state, which could be regulated by the nanoassembly of silk fibroin. Importantly, the results further elucidate the relation between mechanical properties and silk fibroin structures, pointing to a new mode of generating new types of silk materials with enhanced mechanical properties in the dry state, which would facilitate the fabrication and application of regenerated silk fibroin materials in different fields.     

Phosphorylation of silk fibroins improves the cytocompatibility of silk fibroin derived materials: A platform for the production of tuneable material

Silk fibroin demonstrates great biocompatibility and is suitable for many biomedical applications, including tissue engineering and regenerative medicine. Current research focuses on manipulating the physico‐chemical properties of fibroin, and examining the effect of this manipulation on firobin's biocompatibility. Regenerated silk fibroin was modified by in vitro enzymatic phosphorylation and cast into films. Films were produced by blending, at several ratios, the phosphorylated and un‐phosphorylated fibroin solutions. Fourier transform infra‐red spectroscopy was used to determine the specific P–OH vibration peak, confirming the phosphorylation of the regenerated silk fibroin solution. Differential scanning calorimetry showed that phosphorylation altered the intra‐ and inter‐molecular interactions. Further experiments demonstrated that phosphorylation can be used to tailor the hydrophylicity/hydrophobicity ratio as well as the crystalinity of silk fibroin films. Release profiling of a model drug was highly dependent on silk modification level. Cytotoxicity assays showed that exposure to lixiviates of phosphorylated films only slightly affected cellular metabolism and proliferation, although direct contact resulted in a strong direct correlation between phosphorylation level and cell proliferation. This new method for tuning silk biomaterials to obtain specific structural and biochemical features can be adapted for a wide range of applications. Phosphorylation of silk fibroins may be applied to improve the cytocompatibility of any silk‐based device that is considered to be in contact with live animals or human tissues.     

Comparative structure analysis of tyrosine and valine residues in unprocessed silk fibroin (silk I) and in the processed silk fiber (silk II) from Bombyx mori using solid-state (13)C,(15)N, and (2)H NMR

The solid-state (13)C CP-MAS NMR spectra of biosynthetically labeled [(13)C(alpha)]Tyr, [(13)C(beta)]Tyr, and [(13)C(alpha)]Val silk fibroin samples of Bombyx mori, in silk I (the solid-state structure before spinning) and silk II (the solid-state structure after spinning) forms, have been examined to gain insight into the conformational preferences of the semicrystalline regions. To establish the relationship between the primary structure of B. mori silk fibroin and the "local" structure, the conformation-dependent (13)C chemical shift contour plots for Tyr C(alpha), Tyr C(beta), and Val C(alpha) carbons were generated from the atomic coordinates of high-resolution crystal structures of 40 proteins and their characteristic (13)C isotropic NMR chemical shifts. From comparison of the observed Tyr C(alpha) and Tyr C(beta) chemical shifts with those predicted by the contour plots, there is strong evidence in favor of an antiparallel beta-sheet structure of the Tyr residues in the silk fibroin fibers. On the other hand, Tyr residues take a random coil conformation in the fibroin film with a silk I form. The Val residues are likely to assume a structure similar to those of Tyr residues in silk fiber and film. Solid-state (2)H NMR measurements of [3,3-(2)H(2)]Tyr-labeled B. mori silk fibroin indicate that the local mobility of the backbone and the C(alpha)-C(beta) bond is essentially "static" in both silk I and silk II forms. The orientation-dependent (i.e., parallel and perpendicular to the magnetic field) solid-state (15)N NMR spectra of biosynthetically labeled [(15)N]Tyr and [(15)N]Val silk fibers reveal the presence of highly oriented semicrystalline regions.     

Slit 2N与丝素蛋白混合物诱导大鼠海马神经元迁移的体外模型建立

目的：利用Slit排斥导向迁移和丝素蛋白,探索建立简便可行、经济实惠、作用持久的神经元导向迁移模型新方法。方法：提取SD新生鼠海马组织,以专用细胞培养片体外培养神经元,分为空白对照组、单纯丝素蛋白、单纯Slit 2N和Slit 2N与丝素蛋白混合物组（以下简称混合物组）,分别随机选择不同视野下50个神经元,用显微镜拍照记录胞体坐标及突起状态,除空白对照组外,其他3组均距每个神经元100 μm处添加相应诱导物,共观察30 min,再次记录后,用免疫荧光染色法鉴定细胞性质及其阳性率。结果：单纯Slit 2N组和混合物组均可见突起向浓度低处迁移或弯曲,且长度有所缩短,空白对照组和单纯丝素蛋白组未见明显变化。突起变化的平均持续时间及平均长度差从大到小依次为混合物组、单纯Slit 2N组、单纯丝素蛋白组（P<0.05）,单纯丝素蛋白组和空白对照组间无明显变化（P>0.05）。四组神经元MAP-2阳性率均达到90%以上。结论：丝素蛋白对Slit 2N诱导大鼠海马神经元迁移作用无明显影响,可有效减缓Slit 2N扩散速度,使作用时间延长,为治疗中枢神经系统疾病建立三维神经定向修复提供有利的体外实验构建基础。     

A new method for the modification of fibroin heavy chain protein in the transgenic silkworm

We constructed a new plasmid vector for the production of a modified silk fibroin heavy chain protein (H-chain) in the transgenic silkworm. The plasmid (pHC-null) contained the promoter and the 3' region of a gene encoding the H-chain and the coding regions for the N-terminal domain and the C-terminal domain of the H-chain. For the model protein, we cloned a foreign gene that encoded EGFP between the N-terminal domain and the C-terminal domain in pHC-null and generated transgenic silkworms that produced a modified H-chain, HC-EGFP. Transgenic silkworms produced HC-EGFP in the posterior part of silk gland cells, secreted it into the lumen of the gland, and produced a cocoon with HC-EGFP as part of the fibroin proteins. N-terminal sequencing of HC-EGFP localized the signal sequence cleavage site to between positions A((21)) and N((22)). These results indicate that our new plasmid successfully produced the modified H-chain in a transgenic silkworm.     

Production of an active feline interferon in the cocoon of transgenic silkworms using the fibroin H-chain expression system

We constructed the fibroin H-chain expression system to produce recombinant proteins in the cocoon of transgenic silkworms. Feline interferon (FeIFN) was used for production and to assess the quality of the product. Two types of FeIFN fusion protein, each with N- and C-terminal sequences of the fibroin H-chain, were designed to be secreted into the lumen of the posterior silk glands. The expression of the FeIFN/H-chain fusion gene was regulated by the fibroin H-chain promoter domain. The transgenic silkworms introduced these constructs with the piggyBac transposon-derived vector, which produced the normal sized cocoons containing each FeIFN/H-chain fusion protein. Although the native-protein produced by transgenic silkworms have almost no antiviral activity, the proteins after the treatment with PreScission protease to eliminate fibroin H-chain derived N- and C-terminal sequences from the products, had very high antiviral activity. This H-chain expression system, using transgenic silkworms, could be an alternative method to produce an active recombinant protein and silk-based biomaterials.     

New silk protein: modification of silk protein by gene engineering for production of biomaterials

The interest in silk fibroin morphology and structure have increased due to its attractiveness for bio-related applications. Silk fibers have been used as sutures for a long time in the surgical field, due to the biocompatibility of silk fibroin fibers with human living tissue. In addition, it has been demonstrated that silk can be used as a substrate for enzyme immobilization in biosensors. A more complete understanding of silk structure would provide the possibility to further exploit silk fibroin for a wide range of new uses, such as the production of oxygen-permeable membranes and biocompatible materials. Silk fibroin-based membranes could be utilized as soft tissue compatible polymers. Baculovirus-mediated transgenesis of the silkworm allows specific alterations in a target sequence. Homologous recombination of a foreign gene downstream from a powerful promoter, such as the fibroin promoter, would allow the constitutive production of a useful protein in the silkworm and the modification of the character of silk protein. A chimeric protein consisted of fibroin and green fluorescent protein was expressed under the control of fibroin in the posterior silk gland and the gene product was spun into the cocoon layer. This technique, gene targeting, will lead to the modification and enhancement of physicochemical properties of silk protein.     

Studies on silk fibroin of the silkworm Bombyx mori

A procedure has been developed to obtain native fibroin in a pure state from the reservoir part of the silk gland. The purified protein has a sedimentation coefficient of 10 S as determined on sucrose density gradients and the amino acid composition is similar to that reported for fibroin from the cocoons. The effects of various solvents has been studied; lithium thiocyanate was found to be the solvent of choice. By in vivo labeling of fibroin with [³H]glycine and [¹⁴C]alanine it was demonstrated that fibroin synthesized in the posterior part of the gland and that stored in the reservoir part are identical.     

New silk protein: modification of silk protein by gene engineering for production of biomaterials.

The interest in silk fibroin morphology and structure have increased due to its attractiveness for bio-related applications. Silk fibers have been used as sutures for a long time in the surgical field, due to the biocompatibility of silk fibroin fibers with human living tissue. In addition, it has been demonstrated that silk can be used as a substrate for enzyme immobilization in biosensors. A more complete understanding of silk structure would provide the possibility to further exploit silk fibroin for a wide range of new uses, such as the production of oxygen-permeable membranes and biocompatible materials. Silk fibroin-based membranes could be utilized as soft tissue compatible polymers. Baculovirus-mediated transgenesis of the silkworm allows specific alterations in a target sequence. Homologous recombination of a foreign gene downstream from a powerful promoter, such as the fibroin promoter, would allow the constitutive production of a useful protein in the silkworm and the modification of the character of silk protein. A chimeric protein consisted of fibroin and green fluorescent protein was expressed under the control of fibroin in the posterior silk gland and the gene product was spun into the cocoon layer. This technique, gene targeting, will lead to the modification and enhancement of physicochemical properties of silk protein.     

Dynamic light scattering of native silk fibroin solution extracted from different parts of the middle division of the silk gland of the Bombyx mori silkworm

Dynamic light scattering (DLS) measurements were performed on aqueous solutions of native silk fibroin extracted from three parts, the posterior (MP), the middle (MM), and the anterior parts (MA), of the middle division (M) of the silk gland of the Bombyx mori silkworm to study the dynamics and aggregation properties of silk fibroin. In the MP part, fibroin molecules are present as aggregates (or clusters) being composed of several large protein complexes or elementary unit (EU), which are further associated to make a large assembly connected via divalent metallic ions. In the MM part, such clusters of EU take more compact structure, and finally in the MA part, clusters disappear, but EUs are more or less aligned to keep the assembly, and the EU takes the conformation of wormlike cylinder capped with hemispheres at both ends. The overall conformational change in solution structure was interpreted as being due to the change in ionic environment in the solution. DLS study was also performed on regenerated silk fibroin solutions, which revealed that fibroin is present as a single molecule dominantly and their association behavior seems completely different from that of native samples and does not depend on types and concentration of added metallic ions.     

Phase behavior and hydration of silk fibroin

The osmotic stress method was applied to study the thermodynamics of supramolecular self-assembly phenomena in crystallizable segments of Bombyx mori silkworm silk fibroin. By controlling compositions and phases of silk fibroin solution, the method provided a means for the direct investigation of microscopic and thermodynamic details of these intermolecular interactions in aqueous media. It is apparent that as osmotic pressure increases, silk fibroin molecules are crowded together to form silk I structure and then with further increase in osmotic pressure become an antiparallel beta-sheet structure, silk II. A partial ternary phase diagram of water-silk fibroin-LiBr was constructed based on the results. The results provide quantitative evidence that the silk I structure must contain water of hydration. The enhanced control over structure and phase behavior using osmotic stress, as embodied in the phase diagram, could potentially be utilized to design a new route for water-based wet spinning of regenerated silk fibroin.     

Dissolution of Bombyx mori silk fibroin in the calcium nitrate tetrahydrate-methanol system and aspects of wet spinning of fibroin solution

There are still several problems associated with the spinning of dialyzed silk fibroin solutions. In this work some of these problems have been examined. The calcium nitrate tetrahydrate-methanol system was used to dissolve the silk fibroin. A compositional phase diagram was constructed at various concentrations of the solvent system. Regenerated fibroin powders from undialyzed fibroin solution in several coagulants showed different conformations. Regenerated powders from several coagulants except methanol and ethanol were resoluble in water. Atomic absorption analysis revealed that the calcium cations strongly interact with fibroin molecules in dialyzed fibroin solution, which may interfere with the regeneration of a strong fiber. Kinetic studies to determine the diffusion coefficient of methanol into dialyzed and concentrated fibroin solution were reported. The properties of both original and regenerated fibroin such as solubility in water and thermal behaviors using DSC were compared. Regenerated fibroin fiber was spun by the wet spinning method. An X-ray diffractogram showed that the regeneration process decreased the crystallinity of regenerated fibroin fiber. SEM images of the surface and cross section of the regenerated fibroin fibers were discussed.     

The fine structure of silk fibroin

The fine structure of Bombyx mori silk fibroin was investigated by electron microscopy and X-ray diffraction techniques. Examination of silk fibers fragmented with ultrasonic radiation and negatively stained revealed the presence of ribbon-like filaments of well-defined lateral dimensions. Analysis of the breadths of the equatorial reflections in the X-ray diffraction pattern of fibroin yielded similar dimensions for the lateral extent of the crystallites. It is concluded that the crystalline material in B. mori silk fibroin is in the form of ribbon-like filaments of considerable length parallel to the fiber axis and of lateral dimensions approximately 20 x 60 A.