Amino acid digestibility in corn distillers’ dried grains with solubles in pigs at different dietary levels of casein and test ingredient

Digestibility of amino acids (AA) in feed ingredients for pigs has been generally determined by feeding experimental diets containing test feedstuffs as a sole source of N, which may lead to the deficiency or imbalance of AA and hinder an accurate determination of digestibility values. Therefore, the addition of casein in experimental diets may ameliorate the potential negative effects of deficiency or imbalance of AA. In addition, the concentration of test feedstuffs in experimental diets may affect the digestibility of AA in test feedstuffs. Two experiments were conducted with corn distillers’ dried grains with solubles (DDGS) as the test feedstuff to determine the effects of increasing concentrations of casein in experimental diets on standardized ileal digestibility (SID) of AA in DDGS (experiment 1) and to investigate the effects of two concentrations of DDGS in experimental diets with or without the addition of casein on SID of AA in DDGS (experiment 2). In experiment 1, 20 barrows (initial BW = 45.3 ± 1.80 kg) surgically fitted with T-cannulas at the distal ileum were allocated to a quadruplicate 5 × 2 incomplete Latin square design with five diets and two periods. Four isonitrogenous diets containing increasing concentrations of casein from 0 to 165 g/kg with decreasing concentrations of DDGS from 466.8 to 0 g/kg and a N-free diet were prepared. The SID of AA, except for arginine, cysteine, and glycine, in DDGS linearly decreased (P < 0.05) with increasing concentrations of casein in experimental diets. Quadratic response (P = 0.023) was observed in the SID of lysine in DDGS when the concentration of casein in experimental diets increased. In experiment 2, the same 20 barrows (initial BW = 52.8 ± 2.99 kg) and experimental design as experiment 1 were used with different diets, which were prepared as a 2 × 2 factorial arrangement with the concentration of DDGS at 466.8 or 155.6 g/kg and that of casein at 0 or 110 g/kg. Regardless of the addition of casein, pigs fed experimental diets containing 466.8 g/kg DDGS had greater (P < 0.01) SID of indispensable AA, except for tryptophan, in DDGS than those fed diets containing 155.6 g/kg DDGS. In conclusion, the addition of casein in experimental diets did not affect the SID of AA in DDGS, whereas the SID of AA in DDGS decreased as the concentration of DDGS in diets decreased.     

Evaluation of the prebiotic potential of arabinoxylans extracted from wheat distillers’ dried grains with solubles (DDGS) and in-process samples

Applied Microbiology and Biotechnology - Distillers’ dried grains with solubles (DDGS) is a low-value agro-industrial by-product, rich in arabinoxylans (AX), which is produced by commercial...     

Estimation of utilisable crude protein at the duodenum of dried distillers’ grains with solubles using a modified gas test

The objective of this study was to characterise the variation of utilisable crude protein at the duodenum (uCP) of dried distillers’ grains with solubles (DDGS) for ruminants using a modified gas test and to predict the uCP in DDGS based on chemical composition. Thirteen samples originating from wheat, maize, barley or blends of different substrates were studied. The in vitro uCP was estimated using the modified Hohenheim gas test (moHGT). Samples were incubated in rumen fluid for 8 h, 24 h and 48 h followed by ammonia distillation. The obtained values were compared to reference values of uCP (based on the contents of crude protein (CP), in situ undegraded CP and metabolisable energy). The reference and in vitro values of uCP were calculated according to passage rates of 2, 5 and 8%/h (i.e., uCP₂, uCP₅ and uCP₈, respectively). The in vitro uCP₈ ranged from 214 to 320 g/kg DM and reference values from 158 to 302 g/kg DM. The in vitro uCP₂ was on average lower (by 7 g/kg DM) and in vitro uCP₈ was higher (by 56 g/kg DM) than their respective reference values. The in vitro uCP₅ and uCP₈ were correlated with reference values and the correlations were improved with increasing passage rates. When the differences of uCP content between in vitro and reference values were related to CP fractions, they increased with increasing content of CP fraction A and decreasing content of CP fraction B3 for uCP₈. The prediction of uCP values from chemical composition was not reliable. It was concluded that uCP can be predicted on the basis of the moHGT method and CP fractions. The accuracy of prediction improved upon the inclusion of CP fractions and neutral-detergent insoluble nitrogen. The present study revealed a significant variation in the uCP content of DDGS, which should be considered when formulating rations for dairy cows.     

Inclusion of sunflower seed and wheat dried distillers’ grains with solubles in a red clover silage-based diet enhances steers performance,meat quality and fatty acid profiles

The current study compared beef production, quality and fatty acid (FA) profiles of yearling steers fed a control diet containing 70 : 30 red clover silage (RCS) : barley-based concentrate, a diet containing 11% sunflower seed (SS) substituted for barley, and diets containing SS with15% or 30% wheat dried distillers’ grain with solubles (DDGS). Additions of DDGS were balanced by reductions in RCS and SS to maintain crude fat levels in diets. A total of two pens of eight animals were fed per diet for an average period of 208 days. Relative to the control diet, feeding the SS diet increased (P<0.05) average daily gain, final live weight and proportions of total n-6 FA, non-conjugated 18:2 biohydrogenation products (i.e. atypical dienes) with the first double bond at carbon 8 or 9 from the carboxyl end, conjugated linoleic acid isomers with the first double bond from carbon 7 to 10 from the carboxyl end, t-18:1 isomers, and reduced (P<0.05) the proportions of total n-3 FA, conjugated linolenic acids, branched-chain FA, odd-chain FA and 16:0. Feeding DDGS-15 and DDGS-30 diets v. the SS diet further increased (P<0.05) average daily gains, final live weight, carcass weight, hot dressing percentage, fat thickness, rib-eye muscle area, and improved instrumental and sensory panel meat tenderness. However, in general feeding DGGS-15 or DDGS-30 diets did not change FA proportions relative to feeding the SS diet. Overall, adding SS to a RCS-based diet enhanced muscle proportions of 18:2n-6 biohydrogenation products, and further substitutions of DDGS in the diet improved beef production, and quality while maintaining proportions of potentially functional bioactive FA including vaccenic and rumenic acids.     

Effects of supplementation with corn distillers’ dried grains on animal performance,nitrogen balance,and enteric CH4 emissions of young Nellore bulls fed a high-tropical forage diet

The inclusion of corn-dried distillers’ grains (DDG) could be an alternative supplement to increase animal performance, nitrogen efficiency usage (NEU), and decrease enteric methane (CH₄) emissions. Our goal was to determine whether DDG could replace a traditional supplement (cottonseed meal) without affecting animal performance, N balance, and CH₄ emissions. The experiment was conducted during the forage growing season (December to April), with 15 d adaptation, and a 112 d experimental period. The experimental design was completely randomized with four treatments: a mineral supplement (MS), cottonseed meal supplement (CS), 50% replacement of CS by DDG (50DDG), and 100% replacement of CS by DDG (100DDG). Cottonseed meal and DDG were used as protein supplement. A total of 12 paddocks, 3 per treatment, were used to measure forage mass: morphological and chemical composition of forage, forage allowance, and animal performance. Six animals per treatment were used to evaluate DM intake, digestibility, CH₄ emissions, microbial protein production (MCP), and NEU of each treatment. Eighty-one Young Nellore bulls (48 testers, 12 per treatments and 33 adjusters) with initial BW of 255 ± 5 kg (10–12 months old) were supplemented with each supplement type at a level of 0.3% of BW. Pasture management was continuous stocking with a variable stocking rate (put-and-take). Enteric CH₄ was measured using the gas tracer technique. The MCP was quantified using purine derivatives and the NEU mass balance. No differences were found in nutrient intake (P > 0.228). Individual animal performance and gain per area were higher in the treatments with concentrates compared with that of MS; however, there was no difference among treatments CS, 50DDG, and 100DDG. The ADG was 0.83 for MS and 1.08 kg/animal/d when supplemented (P < 0.05). Gain per hectare was 709 kg/ha for MS and 915 kg/ha when supplemented with concentrates (P < 0.05). There was no difference in CH₄ production among treatments that average 180 g/animal/d; however, CH₄ per kg of gain was reduced with CS. The CH₄ conversion factor averaged 5.91%. There was no difference in the synthesis of MCP and NEU. Corn DDG can replace 100% of cottonseed meal as a protein source for supplementation of young Nellore bulls grazing in tropical pastures without affecting animal performance, NEU, MCP, and CH₄ emissions.     

Variations in chemical composition and in vitro and in situ ruminal degradation characteristics of dried distillers’ grains with solubles from European ethanol plants

The objective of this study was to characterise variations in the composition and nutritive value of dried distillers’ grains with solubles (DDGS) for ruminants, and to estimate the undegradable crude protein (UDP) in DDGS. Thirteen samples originating from wheat, corn, barley and blends of different substrates were studied. The rumen degradation of crude protein (CP) was determined using the nylon bag technique. Samples were incubated for 0, 1, 2, 4, 8, 16, 32 and 72 h, and in situ degradation kinetics were determined. The UDP was estimated using a passage rate of 8%/h. In vitro gas production was measured to estimate the metabolisable energy (ME), net energy for lactation (NE_L) and in vitro digestibility of organic matter (IVDOM). Chemical profiles varied among samples [in g/kg dry matter (DM) ± standard deviation]; the values were 310 ± 33 CP, 86 ± 37 ether extract, 89 ± 18 crude fibre, 408 ± 39 neutral detergent fibre, 151 ± 39 acid detergent fibre and 62 ± 31 acid detergent lignin, as well as in protein fractions according to the Cornell Net Carbohydrate and Protein System [in g/kg CP]; the values were for fractions A, 161 ± 82; B1, 24 ± 11; B2, 404 ± 105; B3, 242 ± 61; and C, 170 ± 87. The ME, NE_L [MJ/kg DM] and IVDOM [%] also varied among samples: 12.1 ± 0.59, 7.3 ± 0.39 and 72.5 ± 4.30, respectively. The in situ rapidly degradable CP fraction (a) varied from 10.2% to 30.6%, and the potentially degradable fraction (b) averaged to 66.8%. The UDP varied from 8.6% to 62.6% of CP. The present study suggests significant variations in composition and nutritive value among different sources of DDGS. The UDP could be predicted on the basis of analysed CP fractions, but the accuracy of UDP prediction improved upon the inclusion of neutral-detergent insoluble nitrogen, explaining 94% of the variation in the UDP values. We conclude that chemical protein fractions may be used to predict the UDP values of DDGS and that the variability in the protein fractions of DDGS should be considered when formulating diets for dairy cows.     

In situ ruminal degradation of amino acids and in vitro protein digestibility of undegraded CP of dried distillers’ grains with solubles from European ethanol plants

The objectives of this study were to compare the in situ ruminal degradation of CP and amino acids (AAs) of dried distillers’ grains with solubles (DDGS), and to estimate intestinal digestibility (ID) of undegradable crude protein (UDP) with the in vitro pepsin–pancreatin solubility of CP (PPS), using either DDGS samples (DDGS-s) or DDGS residues (DDGS-r) obtained after 16 h ruminal incubation. Thirteen samples originating from wheat, corn, barley and blends were studied. Lysine and methionine content of DDGS-s varied from 1.4 to 4.0 and 1.3 to 2.0 g/16 g N, respectively. The milk protein score (MPS) of DDGS-s was low and ranged from 0.36 to 0.51, and lysine and isoleucine were estimated to be the most limiting AAs in DDGS-s and DDGS-r. DDGS-r contained slightly more essential AAs (EAAs) than did the DDGS-s. Rumen degradation after 16 h varied from 44% to 94% for CP, from 39% to 90% for lysine and from 35% to 92% for methionine. Linear regressions showed that the ruminal degradation of individual AAs can be predicted from CP degradation. The PPS of DDGS-s was higher than that of DDGS-r and it varied from 70% to 89% and from 47% to 81%, respectively. There was no significant correlation between the PPS of DDGS-s and PPS of DDGS-r (R²=0.31). The estimated intestinally absorbable dietary protein (IADP) averaged 21%. Moderate correlation was found between the crude fibre (CF) content and PPS of DDGS-r (R²=0.43). This study suggests an overestimation of the contribution of UDP of DDGS to digestible protein supply in the duodenum in some currently used protein evaluation systems. More research is required and recommended to assess the intestinal digestibility of AAs from DDGS.     

Bacterial communities in the rumen and feces of lactating Holstein dairy cows are not affected when fed reduced-fat dried distillers’ grains with solubles

Reduced-fat dried distillers’ grains with solubles (RF-DDGSs) are co-products of ethanol production and contain less fat than traditional distillers’ grains. The fat in corn is ~91% unsaturated, and it is toxic to rumen microorganisms so it could influence the composition of the rumen microbiome. It has been demonstrated that RF-DDGS is a suitable ration ingredient to support the high-producing dairy cow, and this feedstuff is a promising alternative protein source for lactating dairy cows. The current study aims to better understand the effect of RF-DDGS on the rumen and fecal bacterial composition in lactating dairy cows. Thirty-six multiparous (two or three), mid-lactation Holstein cows (BW = 680 ± 11 kg; 106 ± 27 DIM) were randomly assigned to two groups which were fed a control diet made up of corn, corn silage, and alfalfa hay supplemented with expeller soybean meal or with added RF-DDGS (20% of the DM) containing approximately 6.0% fat. Whole rumen contents (rumen fluid and digesta; esophageal tubing method) and feces (free-catch method) were collected on day 35 of the experimental period, after the 14-d acclimation period. Rumen contents and feces from each cow were used for DNA extraction. The bacterial community composition in rumen and fecal samples was assessed via the 16S rRNA gene by using the Illumina MiSeq sequencing platform. Bacteroidetes, Actinobacteria, and Firmicutes were the most abundant phyla in rumen contents. The fecal microbiota was dominated by the phyla Firmicutes and Bacteroidetes, as well as Actinobacteria and Chloroflexi. RF-DGGS increased bacterial richness, evenness, and Shannon diversity in both rumen and fecal samples and was associated with several taxa that had different abundance in treatment versus control comparisons. The RF-DGGS, however, did not significantly alter the bacterial community in the rumen or feces. In general, these findings demonstrated that dietary inclusion of RF-DDGS did not impose any serious short-term (within 30 days) health or production consequences, as would be expected. With this study, we present further evidence that inclusion of 20% (DM basis) RF-DDGS in the diet of lactating dairy cows can be done without consequence on the microbiome of the rumen.     

Nutrient availability of different batches of wheat distiller’s dried grains with solubles for turkeys

Effects of five different batches of wheat distiller’s dried grains with solubles (DDGS) were used to investigate bioavailability of energy and nutrients for turkeys. The laboratory analysis of the DDGS showed the largest variations for soluble non-starch polysaccharides, oil and ash. In total, 96 birds were fed one of six mash diets. The basal diet contained per kilogram 535 g wheat and 300 g soya bean meal, corresponding to 247 g crude protein and 12.6 MJ N-corrected apparent metabolisable energy (AMEn). Another five diets contained per kilogram 200 g of each DDGS samples in replacement for basal diet. Each diet was fed to eight pens with two female Premium turkeys following randomisation. The AMEn and the nutrient retention coefficients of the pure DDGS samples were obtained using the substitution method. The AMEn of the DDGS from batch A was higher (p = 0.048) compared to those from batches B and C, but did not differ from DDGS samples D and E. There were no differences in dry matter retention, nitrogen retention and fat digestibility between the DDGS samples tested. The AMEn of the DDGS samples correlated positively (p < 0.05) to the starch (r = 0.895) and the non-soluble non-starch polysaccharides contents (r = 0.940), and the red index of lighting (a) (r = 0.916), respectively. In general, findings from this study indicate bioavailability of energy and most nutrients to be in the range of published data with turkeys, and to vary between batches.     

Effect of Filgrastim on adult male rats’ fertility and reproductive performance

Filgrastim is a recombinant protein used in treatment neutropenia caused by myelosuppressive medications for patients with non-myeloid cancer. However, its effect in male fertility is not clear. So, the current work aims to clarify the effect of Filgrastim on the reproductive state in Wistar rats. Eighteen (18) male Wistar rats were divided into three groups (6/each). Group (I) where the rats were injected with 0.5 ml/kg/day of distilled water and served as Control Group. The Group (II) animals received intraperitoneal injection of therapeutic dose of 30.83 mcg/kg/day of Filgrastim for one week. The Group (III) rats received the same dose by the same route of Filgrastim for two weeks. Sera of blood samples were processed for serum follicle stimulating hormone (FSH), luteinizing hormone (LH), testosterone (TS). Semen analysis and resazurine reduction test (RRT) were performed. Assaying for malondialdehyde (MDA), glutathione (GSH), superoxide dismutase (SOD), catalase (CAT) was done. The testes were retrieved for histopathological and immunohistochemical studies for caspase-3 detection. Our results revealed that filgrastim affects sperm morphology, significantly decreased the RRT and the reproductive hormones level, elevated the oxidative stress status and induced several histopathological changes in testes with an increased in immunoexpression of caspase-3 in testes tissues. The results of this work demonstrated that Filgrastim may had a deleterious effect on male fertility.     

Low temperature pre-treatment of new cultivar of corn for ethanol production and nutrient value of its distiller’s dried grains with soluble

The objective of this work was to evaluate the production of bioethanol from a new Korean variety of corn (Gangdaok) and to assess low temperature pre-treatment of corn mashes before simultaneous saccharification and fermentation. Corn mashes containing 178 g/L of total sugar were fermented with Saccharomyces cerevisiae CHY 1011(KCTC 11250BP) at 35°C. Fermentation of mash supplemented with solid glucoamylase was completed within 48 h, and the ethanol produced was 474.0 and 473.1 L/ton as dry base with low temperature pre-treatment and pressure pretreatment, respectively. Furthermore, the DDGS of Gangdaok cultivar contained more essential amino acids (21.1 mg/g) than did Ambrosia cultivar (USA corn), which is a widely used feedstock. In addition, there were no significant differences in ethanol yield or amino acid concentration in DDGS between low temperature pre-treatment and pressure pretreatment. The results show that Gangdaok holds potential economic advantages if applied to the bioethanol and feed industries.     

Effect of γ irradiation on the fatty acid composition of soybean and soybean oil

Food irradiation is a form of food processing to extend the shelf life and reduce spoilage of food. We examined the effects of γ radiation on the fatty acid composition, lipid peroxidation level, and antioxidative activity of soybean and soybean oil which both contain a large amount of unsaturated fatty acids. Irradiation at 10 to 80 kGy under aerobic conditions did not markedly change the fatty acid composition of soybean. While 10-kGy irradiation did not markedly affect the fatty acid composition of soybean oil under either aerobic or anaerobic conditions, 40-kGy irradiation considerably altered the fatty acid composition of soybean oil under aerobic conditions, but not under anaerobic conditions. Moreover, 40-kGy irradiation produced a significant amount of trans fatty acids under aerobic conditions, but not under anaerobic conditions. Irradiating soybean oil induced lipid peroxidation and reduced the radical scavenging activity under aerobic conditions, but had no effect under anaerobic conditions. These results indicate that the fatty acid composition of soybean was not markedly affected by radiation at 10 kGy, and that anaerobic conditions reduced the degradation of soybean oil that occurred with high doses of γ radiation.     

Effect of early postpartum PGF2α treatment on reproductive performance in dairy cows with calving and puerperal traits

The objective of this study was to evaluate the effects of early postpartum PGF two alpha treatment on reproductive performance in dairy cows with calving and puerperal traits. A total of 363 Holstein cows (128 primiparous and 235 multiparous) were selected based on the presence of at least one of calving and puerperal traits (dystocia, retained placenta, twin, abortion, and postpartum uterine infections) and were assigned to two groups (treatment and control) irrespective of presence or absence of luteal tissue. Cows in the treatment group were treated twice with 25 mg dinoprost 8 h apart on day 20 postpartum, and for the control group saline placebo was administered. As it was speculated that the timing of a second dose would mimic the release of endogenous PGF2α from the uterus, our hypothesis was that two doses of PGF2α 8 h apart may increase the duration of elevated plasma prostaglandin F2α metabolite concentration in these cows. Recorded reproductive variables included days to first estrus, days to first AI, first service conception rate, pregnancy by 150 days in milk, service per conception, open days, and the percentage of repeat breeder animals. The data were analyzed using SPSS (Version 15) (IBM North America, New York, NY, USA) and Minitab (Version 14) (Minitab, State College, PA, USA). Although early postpartum PGF2α treatment had no effect on days to first estrus (36.7 days vs. 34.9 days, P = 0.056) and days to first AI (70.5 days vs. 72.2 days, P = 0.537), it increased first service conception rate (47.1% vs. 27.6%, P < 0.001); and this was more remarkable in primiparous cows (64.7% vs. 25%, P < 0.001). PGF2α treatment reduced the mean service per conception (1.92 vs. 2.72, P < 0.001) and the mean open days (112 days vs. 144 days, P < 0.001), and increased pregnancy by 150 days in milk (DIM) (80% vs. 66%, P = 0.004). The prevalence of repeat breeder syndrome in cows with calving and puerperal traits was reduced by PGF2α treatment (10% vs. 29.8%, P < 0.001). In conclusion, treatment of cows with calving and puerperal traits twice with a luteolytic dose of PGF2α 8 h apart on Day 20 postpartum improved reproductive performance and reduced the prevalence of repeat breeder syndrome.     

Effects of Trypanosoma congolense and nutritional supplements on establishment and outcome of pregnancy in trypanotolerant Djallonké ewes

Interactions between Trypanosoma congolense and nutritional status were studied in 42 ewes, bred at the peak of parasitaemia after synchronisation of oestrus. As experimental design a randomised block design was used with four treatment combinations (2×2 factors), of which two were on a restricted diet (L), the remainder on an unrestricted diet (H) and half of each nutritional group infected with T. congolense (LI, HI), the remainder serving as controls (LC, HC). Severity of parasitaemia was not influenced by supplementation and mortality rates were higher in the HI and LC groups, but these differences were found not significant. Progesterone levels during the synchronised cycle were significantly lower in the infected groups. Levels of pregnant specific protein B (PSPB) in pregnant sheep at days 21 and 26 were not significantly affected by nutrition or infection, despite the tendency of a decrease in infected groups. T. congolense clearly affected establishment of pregnancy, as shown by lower rates of pregnancy and extended intervals between breeding and confirmation of pregnancy, nor was there any benefit of nutritional supplementation. Mean progesterone concentration during pregnancy, in those ewes which lambed, was not different between groups. The effect of the T. congolense infection on the outcome of pregnancy was not clear with the LI and HC performing well and poor pregnancy outcomes in groups HI and LC, although differences in litter size might explain these anomalies. It is concluded that the most pronounced effect of T. congolense was a negative influence on establishment of pregnancy, with nutritional supplementation unable to overcome this effect but having a beneficial influence on maintenance and successful outcome of pregnancy. However, individual exceptions indicate that some ewes cope better with the negative effects of infection and poor nutrition.     

Effect of 1-methylcyclopropene on postharvest physiological changes of ‘Zaohong’ plum

Plum is a highly perishable fruit and postharvest fruit softening limits its shelf life. The aim of this work was to study the specific effects of 1-methylcyclopropene (1-MCP) treatment on physiological changes in ‘Zaohong’ plums. Plums were treated with 500 nL L⁻¹ 1-MCP at 20°C for 18 h followed by 20°C storage. The results showed that 1-MCP treatment significantly reduced endogenous ethylene production and the activities of ethylene biosynthetic enzymes’ (1-aminocyclopropane-1-carboxylic acid synthase, ACS and 1-aminocyclopropane-1-carboxylic acid oxidase, ACO) in plum fruit during storage when compared with untreated fruit. Although 1-MCP treatment inhibited ethylene production and 1-aminocyclopropane-1-carboxylic acid (ACC) accumulation, it did not inhibit the accumulation of N-malonyl-ACC (MACC). Higher firmness was also found in 1-MCP-treated plums than in controls. During storage, superoxide anion (O₂^−·) and hydrogen peroxide (H₂O₂) levels decreased in 1-MCP-treated fruit. 1-MCP treatment also regulated superoxide dismutase (SOD) and catalase (CAT) activities during storage. Xylanase activity was upregulated while activities of polygalacturonase (PG), pectin methyl esterase (PME) and cellulase enzymes in the fruit were downregulated by 1-MCP treatment. In conclusion, 1-MCP might be a potent compound for extending both storage period and shelf life of ‘Zaohong’ plums by suppressing ethylene biosynthesis, regulating cell wall degradation enzymes and reducing fruit softening.     

A two-step fermentation of distillers’ grains using Trichoderma viride and Rhodopseudomonas palustris for fish feed

It is important to provide added value or to make full use of the co-product of grains from ethanol production. In order to convert distillers’ grains into a high-quality feed, the Trichoderma viride and Rhodopseudomonas palustris fermentation were combined and investigated in this study. The T. viride fermentation was carried out in an aerobic fermentation installation in favoring of the growth of the fungi and the degradation of the cellulose, and then the fermentation of R. palustris was performed to increase the content of protein with an anaerobic installation. After the two step fermentations, the true protein content of dried distiller’ grains increased from 11.4 to 33.6 % (w/w) (the content of crude protein from 14.5 to 39.7 %), the crude fiber content decreased from 21.3 to 7.6 % (w/w), the crude fat content increased from 5.5 to 7.9 % (w/w), the crude ash decreased from 14.6 to 10.2 % (w/w), the total phosphorus content increased from 0.4 to 1.2 % (w/w), and the water content was 11.8 % (w/w). The dried and fermented grains contain the R. palustris viable count of 5.3 × 10¹¹ CFU/g dry matter. The results may support a new application of an active photosynthetic bacteria fish feed in fisheries industry and offer a reference for the further study of lignocellulosic materials as raw materials converting into high-quality feed.     

Effect of feed restriction on the performance and behaviour of pigs immunologically castrated with Improvac®

For centuries, entire male pigs have been castrated to reduce the risk of boar taint. However, physical castration of pig is increasingly being questioned with regard to animal welfare considerations. Immunization against gonadotrophin releasing hormone (GnRH) provides an alternative to physical castration. Using the currently available commercial product (Improvac®; Pfizer Animal Health), a two-dose regimen of a GnRH vaccine is administered. After the second vaccination, a substantial increase in feed consumption has been reported, which may be associated with increased body fatness and decreased feed efficiency when compared with unvaccinated entire male pigs. The aim of the present study was to investigate the effect of a feed restriction on these traits and on the behaviour of 120 group-housed entire males (five pigs/pen) vaccinated against GnRH. The first vaccination was performed at 62 days of age and the second (V2) at 130 days of age. Pigs were slaughtered in two batches 4 to 5 weeks after V2. They were either offered feed ad libitum over the 22 to 114 kg BW range (AL treatment) or ad libitum up to a maximum of 2.50 (R2.50 treatment) or 2.75 kg/day per pig (R2.75 treatment). Behavioural observations and skin lesion scoring were conducted 1 week before V2, and 1 and 3 weeks after V2. At slaughter, the volumetric lean meat content was measured using an X-ray computed tomography scanner. Between V2 and slaughter, the average feed intakes for the R2.75 and R2.50 treatments were 15% and 22% lower than the average AL feed intake (3.20 kg/day), respectively. Feed restriction was associated with a reduced average daily gain after V2 (846, 932 and 1061 g/day in the R2.50, R2.75 and AL groups, P < 0.01) but had no effect on the feed conversion ratio (3.00 kg feed/kg BW gain on average, P = 0.62). No difference was observed in the lean meat content (71.8%, 70.7% and 70.4% in the R2.50, R2.75 and AL groups, P = 0.14), despite a reduced backfat thickness measured in restrictively fed pigs (12.0, 13.0 and 13.6 mm in the R2.50, R2.75 and AL groups, P < 0.01). Higher skin lesion scores were observed 3 weeks after V2 in R2.50 and R2.75 pigs than in the AL ones (scores 33.4, 27.7 and 25.5, respectively, P = 0.04). These results, combined with an unimproved feed efficiency and no marked change in carcass characteristics, suggest that immunologically castrated pigs should not be restrictively fed during the late finishing period.     

Effect of cadmium on physiological parameters of cereal and millet plants—A comparative study

Metal load is an abiotic stress that becomes stronger by continual industrial production, wastage, and long-range transport of contaminants. It deteriorates the conditions of agricultural soil that leads to lower growth of cereals as well as decreasing nutritional value of harvested grains. Cadmium (Cd) entry by food chain also affects the health of population. The present study is focused on finding out the superior cereal variety under increasing Cd regime. The plants were grown in increasing Cd levels (0–1000 µM) in the medium and were investigated on 15th day of the exposure. Various parameters like antioxidative enzymes and osmoprotectant levels were studied in both roots and shoots. Cd accumulation in plant organs was determined by atomic absorption spectrophotometry (AAS). Analysis of stress tolerance mechanisms through reactive oxygen species (ROS) scavenging and better partitioning of Cd in roots indicated kodo millet to be more stress tolerant than wheat.     

Effect of γ-irradiation on F-2 and T-2 toxin production in corn and rice

Fusarium graminearum andF. tricinctum were grown on moistened corn and rice. After inoculation the substrates were exposed to γ-irradiation and growth rate together with mycotoxin production were measured. A delay in mycelium growth and an increase in F-2 and T-2 toxin production occurred after irradiation with 1 and 3 kGy. The maximum F-2 production was 10.7 mg/kg on rice at 3 kGy, whereas T-2 was 735 μg/kg on rice at 3 kGy. At 9 kGy neither growth nor toxin production could be detected in any inoculated corn and rice substrate.