Production of teicoplanin by a mutant of Actinoplanes teicomyceticus

Teicoplanin, a glucopeptide antibiotic, was produced by a mutant of Actinoplanes teicomyceticus at 300 mg l^–1 using mannose and yeast extract as carbon and nitrogen sources in flask culture and at 500 mg l^–1 in 5-l jar fermenter. Teicoplanin production was 25-fold higher than in the parent strain.     

Germination of Rhizopus oligosporus Sporangiospores

The morphology of Rhizopus oligosporus (NRRL 2710) sporangiospores and their physiological requirements for germination were studied. Germination proceeded in two separable phases: phase I (swelling) and phase II (germ tube protrusion). The optimal conditions for germination were 42 degrees C and pH 4.0. Sporangiospores contained insufficient endogenous carbon for swelling or germination to occur in distilled water. Initial swelling during phase I occurred only in the presence of a suitable carbohydrate. Subsequent production of germ tubes during phase II required exogenous sources of both carbon and nitrogen. Spores germinated most rapidly in mixtures of amino acids; l-proline and l-alanine were the most effective. These amino acids, at concentrations as low as 10 M, supported germination when combined with glucose and McIlvaine (citric acid-phosphate) buffer. d-Glucose, d-xylose, and d-mannose were the most effective carbohydrates tested for promotion of germination.     

Bacteriophage Release in a Lysogenic Strain of Agrobacterium tumefaciens

Bacteriophage release in a lysogenic strain of Agrobacterium tumefaciens V-1 is temperature-sensitive. At 25 C and 30 C, phage was released in a ratio of 1 plaque-forming unit per 100 bacteria; at 35 C, although bacterial growth was not inhibited, phage release was suppressed. Phage synthesis was induced by heat shock, 42 C for 30 min, ultraviolet irradiation, and mitomycin C. Induction by ultraviolet light was unusual-an immediate rise in phage titer followed irradiation. A large increase occurred after a 90-min latent period. The lysogenic strain was cured of the phage by incubation at 37 C, and the cured strain produced plant tumors.     

Actinoplanes capillaceus sp. nov., a new species of the genus Actinoplanes

Two motile actinomycete strains, K95–5561^T and K95–5562, were isolated from a soil sample collected at Sayama City, Saitama Prefecture, Japan. They produced bell shaped spore vesicles (sporangia) with hairy surfaces on substrate hyphae. When released into water, the sporangiospores became motile by a tuft of polar flagella. The chemotaxonomic and morphological characteristics together with 16S rRNA gene sequence data indicated that the two isolates belonged to the genus Actinoplanes. The two strains were assigned to a single species on the basis of phenotypic, notably cultural, morphological and physiological characteristics, and DNA-DNA pairing data. The two strains were distinguished from representatives of all validly described species of Actinoplanes using a combination of genotypic and phenotypic properties. It is, therefore, proposed that strains K95–5561 and K95–5562 be recognized as a new species of the genus Actinoplanes with the name Actinoplanes capillaceus sp. nov. The type strain of the species is strain K95–5561^T (=JCM 10268^T =IFO 16408^T). The invalidly proposed species `Ampullariella cylindrica', `Ampullariella pekinensis' and `Ampullariella pilifera' were assigned to Actinoplanes capillaceus on the basis of genotypic and phenotypic data.     

Role of Cations in Accumulation and Release of Phosphate by Acinetobacter Strain 210A

Cells of the strictly aerobic Acinetobacter strain 210A, containing aerobically large amounts of polyphosphate (100 mg of phosphorus per g [dry weight] of biomass), released in the absence of oxygen 1.49 mmol of P_i, 0.77 meq of Mg²⁺, 0.48 meq of K⁺, 0.02 meq of Ca²⁺, and 0.14 meq of NH₄⁺ per g (dry weight) of biomass. The drop in pH during this anaerobic phase was caused by the release of 1.8 protons per PO₄³⁻ molecule. Cells of Acinetobacter strain 132, which do not accumulate polyphosphate aerobically, released only 0.33 mmol of P_i and 0.13 meq of Mg²⁺ per g (dry weight) of biomass but released K⁺ in amounts comparable to those released by strain 210A. Stationary-phase cultures of Acinetobacter strain 210A, in which polyphosphate could not be detected by Neisser staining, aerobically took up phosphate simultaneously with Mg²⁺, the most important counterion in polyphosphate. In the absence of dissolved phosphate in the medium, no Mg²⁺ was taken up. Cells containing polyphosphate granules were able to grow in a Mg-free medium, whereas cells without these granules were not. Mg²⁺ was not essential as a counterion because it could be replaced by Ca²⁺. The presence of small amounts of K⁺ was essential for polyphosphate formation in cells of strain 210A. During continuous cultivation under K⁺ limitation, cells of Acinetobacter strain 210A contained only 14 mg of phosphorus per g (dry weight) of biomass, whereas this element was accumulated in amounts of 59 mg/g under substrate limitation and 41 mg/g under Mg²⁺ limitation. For phosphate uptake in activated sludge, the presence of K⁺ seemed to be crucial.     

Release of Arsenic from Soil by a Novel Dissimilatory Arsenate-Reducing Bacterium,Anaeromyxobacter sp. Strain PSR-1

A novel arsenate-reducing bacterium, designated strain PSR-1, was isolated from arsenic-contaminated soil. Strain PSR-1 was phylogenetically closely related to Anaeromyxobacter dehalogenans 2CP-1^T with 16S rRNA gene similarity of 99.7% and coupled the oxidation of acetate with the reduction of arsenate. Arsenate reduction was inhibited almost completely by respiratory inhibitors such as dicumarol and 2-heptyl-4-hydroxyquinoline N-oxide. Strain PSR-1 also utilized soluble Fe(III), ferrihydrite, nitrate, oxygen, and fumarate as electron acceptors. Strain PSR-1 catalyzed the release of arsenic from arsenate-adsorbed ferrihydrite. In addition, inoculation of washed cells of strain PSR-1 into sterilized soil successfully reproduced arsenic release. Arsenic K-edge X-ray absorption near-edge structure (XANES) analysis revealed that the proportion of arsenite in the soil solid phase actually increased from 20% to 50% during incubation with washed cells of strain PSR-1. These results suggest that strain PSR-1 is capable of reducing not only dissolved arsenate but also arsenate adsorbed on the soil mineral phase. Arsenate reduction by strain PSR-1 expands the metabolic versatility of Anaeromyxobacter dehalogenans. Considering its distribution throughout diverse soils and anoxic sediments, Anaeromyxobacter dehalogenans may play a role in arsenic release from these environments.     

Genetic recombination in Actinoplanes brasiliensis by protoplast fusion.

Protoplast formation, fusion, and cell regeneration have been achieved with mutant strains of Actinoplanes brasiliensis. Three-, four-, and five-factor crosses have shown genetic recombination among the markers, and a five-factor cross is analyzed and discussed. Possibilities of using protoplast fusion for gene mapping and strain improvement are suggested.     

Cyclic Strain Alters the Expression and Release of Angiogenic Factors by Human Tendon Cells

Angiogenesis is associated with the tissue changes underlying chronic overuse tendinopathy. We hypothesized that repetitive, cyclic loading of human tendon cells would lead to increased expression and activity of angiogenic factors. We subjected isolated human tendon cells to overuse tensile loading using an in vitro model (1 Hz, 10% equibiaxial strain). We found that mechanically stimulated human tendon cells released factors that promoted in vitro proliferation and tube formation by human umbilical vein endothelial cells (HUVEC). In response to cyclic strain, there was a transient increase in the expression of several angiogenic genes including ANGPTL4, FGF-2, COX-2, SPHK1, TGF-alpha, VEGF-A and VEGF-C, with no change in anti-angiogenic genes (BAI1, SERPINF1, THBS1 and 2, TIMP1-3). Cyclic strain also resulted in the extracellular release of ANGPTL4 protein by tendon cells. Our study is the first report demonstrating the induction of ANGPTL4 mRNA and release of ANGPTL4 protein in response to cyclic strain. Tenocytes may contribute to the upregulation of angiogenesis during the development of overuse tendinopathy.     

Regulation of Thrombomodulin Expression and Release in Human Aortic Endothelial Cells by Cyclic Strain

Background and Objectives

Thrombomodulin (TM), an integral membrane glycoprotein expressed on the lumenal surface of vascular endothelial cells, promotes anti-coagulant and anti-inflammatory properties. Release of functional TM from the endothelium surface into plasma has also been reported. Much is still unknown however about how endothelial TM is regulated by physiologic hemodynamic forces (and particularly cyclic strain) intrinsic to endothelial-mediated vascular homeostasis.

Methods

This study employed human aortic endothelial cells (HAECs) to investigate the effects of equibiaxial cyclic strain (7.5%, 60 cycles/min, 24 hrs), and to a lesser extent, laminar shear stress (10 dynes/cm², 24 hrs), on TM expression and release. Time-, dose- and frequency-dependency studies were performed.

Results

Our initial studies demonstrated that cyclic strain strongly downregulated TM expression in a p38- and receptor tyrosine kinase-dependent manner. This was in contrast to the upregulatory effect of shear stress. Moreover, both forces significantly upregulated TM release over a 48 hr period. With continuing focus on the cyclic strain-induced TM release, we noted both dose (0–7.5%) and frequency (0.5–2.0 Hz) dependency, with no attenuation of strain-induced TM release observed following inhibition of MAP kinases (p38, ERK-1/2), receptor tyrosine kinase, or eNOS. The concerted impact of cyclic strain and inflammatory mediators on TM release from HAECs was also investigated. In this respect, both TNFα (100 ng/ml) and ox-LDL (10–50 µg/ml) appeared to potentiate strain-induced TM release. Finally, inhibition of neither MMPs (GM6001) nor rhomboids (3,4-dichloroisocoumarin) had any effect on strain-induced TM release. However, significantly elevated levels (2.1 fold) of TM were observed in isolated microparticle fractions following 7.5% strain for 24 hrs.

Conclusions

A preliminary in vitro investigation into the effects of cyclic strain on TM in HAECs is presented. Physiologic cyclic strain was observed to downregulate TM expression, whilst upregulating in a time-, dose- and frequency-dependent manner the release of TM.     

Nonanoic Acid, a Fungal Self-Inhibitor, Prevents Germination of Rhizopus oligosporus Sporangiospores by Dissipation of the pH Gradient

Germination of Rhizopus oligosporus sporangiospores is characterized by swelling of the spores and subsequent emergence of germ tubes. Changes in spore morphology and alterations in intracellular pH (pH(infin)) of the sporangiospores were assessed during the germination process by flow cytometry. Sporangiospores were stained with carboxyfluorescein by incubation with carboxyfluorescein diacetate. The nonfluorescent carboxyfluorescein diacetate is passively transported into intact cells and subsequently cleaved by esterases, which results in intracellular accumulation of the fluorescent carboxyfluorescein. Given that the fluorescence of carboxyfluorescein is pH dependent, the pH(infin) of the individual spores could be assessed simultaneously with spore size. For R. oligosporus, swelling of the sporangiospores was accompanied by an increase of pH(infin). In the presence of nonanoic acid, a self-inhibitor produced by various fungi, increase of the pH(infin) was prevented and swelling was inhibited at concentrations of less than 1 mM. Octanoic acid and decanoic acid were equally effective. Acetic acid also inhibited germination but at much higher concentrations (>8 mM). The mechanism of action of these fatty acids is most likely dissipation of the pH gradient. A model is proposed in which the pH(infin) plays a crucial role in the germination of R. oligosporus sporangiospores.     

Production of teicoplanin by Actinoplanes teichomyceticus in continuous fermentation.

Production of the potent antibiotic teicoplanin by Actinoplanes teichomyceticus was studied in batch and in chemostat cultures. It is found that the producing strain deactivates to a non-producing strain named NP-12. This strain is used to find the growth kinetics of the A. teichomyceticus without interference from the product teicoplanin. In batch experiments with NP-12 grown on glucose at different initial concentrations and with different added amounts of teicoplanin, the strong inhibitory effect of teicoplanin was determined. These results obtained on NP-12 were validated in a series of chemostat experiments with the processing strain. All experiments in batch and in chemostat cultures were well represented by Monod kinetics with respect to the carbon and energy source (glucose) and with a substantial inhibitory effect of teicoplanin. Further experiments were made with the producing strain in a continuous reactor coupled to a microfilter that delivers a cell-free permeate. It was found that the derived kinetics almost exactly simulated the behavior of the cell recirculation reactor in addition to when the cell concentration in the reactor was more than four times higher than in the chemostat. For industrial production of teicoplanin, a continuous reactor with cell recirculation and working with a low effluent glucose concentration was by far the best mode of operation. Finally, the deactivation of the producing strain to NP-12 was modeled by a two-step deactivation mechanism. Deactivation was independent of dilution rate but dependent on the inoculum preparation and on the previous history of the inoculum.     

Production of Pectolytic Enzymes by Rhizopus stolonifer Sporangiospores After "Lethal" Gamma Irradiation

Irradiated sporangiospores of Rhizopus stolonifer excreted pectolytic enzymes, which hydrolyzed pectin and macerated potato tuber discs, into the suspending medium. Pectin glycosidase, but not pectin methylesterase, activity developed regardless of the amount of radiation the spores had received, unless the dose exceeded about 1 megarad. The ability to produce pectolytic enzymes was found to be more radiation-resistant than the potential for colony formation or the ability to germinate. Spores made incapable, through irradiation, of forming colonies continued to produce pectolytic enzymes after a 6-day period following irradiation treatment.     

Production of ramoplanin analogues by genetic engineering of Actinoplanes sp.

Ramoplanins are lipopeptides effective against a wide range of Gram-positive pathogens. Ramoplanin A2 is in Phase III clinical trials. The structure–activity relationship of the unique 2Z,4E-fatty acid side-chain of ramoplanins indicates a significant contribution to the antimicrobial activities but ramoplanin derivatives with longer 2Z,4E-fatty acid side-chains are not easy to obtain by semi-synthetic approaches. To construct a strain that produces such analogues, an acyl-CoA ligase gene in a ramoplanin-producing Actinoplanes was inactivated and a heterologous gene from an enduracidin producer (Streptomyces fungicidicus) was introduced into the mutant. The resulting strain produced three ramoplanin analogues with longer alkyl chains, in which X1 was purified. The MIC value of X1 was ~0.12 μg/ml against Entrococcus sp. and was also active against vancomycin-resistant Staphylococcus aureus (MIC = 2 μg/ml).     

Production of teicoplanin by valine analogue-resistant mutant strains of Actinoplanes teichomyceticus

Teicoplanin is a glycopeptide antibiotic produced by Actinoplanes teichomyceticus. A strain improvement to increase the productivity of the major component, teicoplanin A2-2, was carried out. As the fatty moiety of teicoplanin A2-2 is derived from L-valine, L-valine analogue (valine hydroxamate)-resistant mutants were derived. One of the mutants, 98-1-227, overproduced valine and produced a higher titer of total teicoplanin with higher A2-2 content. In a pilot fermentor (7 m3), the total productivity of teicoplanin was 1,800 units/ml and the A2-2 content was 58%.     

Production of teicoplanin from Actinoplanes teichomyceticus ID9303 by adding proline

We evaluated the influence of amino acids in improving teicoplanin productivity. Arginine, lysine, and proline were selected for better productivity among 20 amino acids in Erlenmeyer flasks. Proline was finally chosen as the additive for maximum teicoplanin productivity in a 5-liter fermenter. We obtained the highest teicoplanin productivity, 3.12 g/l, on the eighth d in a 75-liter pilot fermenter.     

Cloning of a DNA region of Actinoplanes teichomyceticus conferring teicoplanin resistance

Teicoplanin is a glycopeptide antibiotic, produced by Actinoplanes teichomyceticus, active against Gram positive bacteria and recently introduced into clinical practice. It blocks cell wall biosynthesis by inhibiting peptidoglycan polymerization. The mechanism(s) of resistance of the producer strains of this class of antibiotics have not yet been characterized. We have constructed a genomic bank of A. teichomyceticus in Streptomyces lividans. A clone from this bank, PTR168, was able to confer resistance to teicoplanin on its sensitive host. The restriction map of plasmid pTR168 and the hybridization pattern to A. teichomyceticus DNA were determined; we have also studied the mechanism of this resistance which seems correlated with a reduced binding of the antibiotic to the cell wall.     

Characterization of Actinoplanes missouriensis spore flagella

Actinoplanes missouriensis spores swim with a tuft of flagella. Flagella of newborn spores are wrapped with a membranous sheath. When the sheath is unwrapped, spores start swimming. Flagellar length is kept short, at around 1.9 μm, which covers half the circumference of the spore.     

高产雷帕霉素的游动放线菌菌种的选育

以游动放线菌(Actinoplanes)BCLP-016为出发菌株,采用常压室温等离子体(ARTP)诱变技术对其孢子进行处理,并将三个不同时间处理的孢子悬液混合。稀释涂布后,根据菌株菌落形态挑取部分单菌落进行初筛,经发酵复筛后,筛选得到了一株雷帕霉素高产菌株ARTP-039,其雷帕霉素的产量可达到369.39mg/L,较出发菌株BCLP-016的产量256.86 mg/L,提高了43.81%。以筛选出的ARTP-039高产菌为出发菌株,进行传统的紫外诱变,选取高、中、低三个致死率相对应的时间对其孢子悬液进行处理,并基于核糖体工程的理论选取了链霉素、庆大霉素、利福平、氯霉素和红霉素五种抗性物质,进行抗性初筛。发酵复筛后,最终筛选得到了一株雷帕霉素高产菌株St8+Gen6+Rif9+Chl3+Er4-015,该菌株同时具有五种抗性。该菌株的摇瓶实验结果表明,发酵7d后,其雷帕霉素的产量可达到589.79mg/L,较出发菌株BCLP-016的产量,提高了129.61%,且其遗传稳定性良好。