Purification and properties of esterase from Bacillus stearothermophilus

An enzyme, which hydrolyzes p-nitrophenyl and m-carboxyphenyl esters of n-fatty acids, is purified from Bacillus stearothermophilus. The enzyme reaction obeys the Michaelis-Menten theory. The Michaelis constant (K_m) decreases with increasing the length of carbon number of the acids, but the maximum velocity (V) is maximum for n-caproate. The enzyme is inhibited by diisopropyl fluorophosphate (DFP),² and 1 mole of DFP reacts with 1 mole of the enzyme of the molecular weight of 42,000–47,000. The enzyme is considered to be carboxylic ester hydrolase (EC 3.1.1.1). The effects of temperature on K_m or V for p-nitrophenyl n-caproate and on the inhibitor constant (K_i) for n-laurate suggest a thermal transition in the conformation of the enzyme protein at 55 °C. The enzyme is strongly inhibited by sulfhydryl reagents such as p-chloromercuribenzoate and 5,5′-dithiobis (2-nitrobenzoic acid) at 65 °C, but less at 30 °C. The relationship between the inhibition of the activity by p-chloromercuribenzoate and temperature may suggest that a thermal transition of the enzyme protein accompanies some structural change around sulfhydryl group.     

Purification and partial characterisation of a 1.57 kDa thermostable esterase from Bacillus stearothermophilus

The molecular mass of esterases usually falls in the range of 20–160 kDa, although an esterase of 5.7 kDa from Candida lipolytica has been described. Three other enzymes smaller than 10 kDa have been reported, all of which were more thermostable than their higher molecular mass counterparts. This paper describes the purification of an extracellular esterase hydrolysing fluorescein dibutyrate from Bacillus stearothermophilus NCIMB 13335. The esterase had a molecular mass of 1.57 kDa when analysed by SDS-PAGE, gel filtration and MALDI-TOF spectrometry. This enzyme retained more than 90% of its activity after incubation at 90°C for 2 h.     

Phospholipids from Bacillus stearothermophilus

The lipids of Bacillus stearothermophilus strain 2184 were extracted with chloroform-methanol and separated into neutral lipid and three phospholipid fractions by chromatography on silicic acid columns. The phospholipids were identified by specific staining reactions on silicic acid-impregnated paper, by chromatography of alkaline and acid hydrolysis products, and by determination of acyl ester:glycerol:nitrogen:phosphorus molar ratios. The total extractable lipid was 8% of the dry weight of whole cells and consisted of 30 to 40% neutral lipid and 60 to 70% phospholipid. The phospholipid consisted of diphosphatidyl glycerol (23 to 42%), phosphatidyl glycerol (22 to 39%), and phosphatidyl ethanolamine (21 to 32%). The concentrations of diphosphatidyl glycerol and phosphatidyl glycerol were lower in 2-hr cells than in 4- and 8-hr cells. Whole cells were fractionated by sonic treatment and differential centrifugation. The total lipid content, expressed in per cent of dry weight of each fraction was: whole protoplasts, 10%; membrane fraction, 18%; 30,000 x g particulate fraction, 22%; and 105,000 x g particulate fraction, 26%. The relative phospholipid concentrations in each fraction were about the same. As had been previously reported, none of the phospholipid was stable to alkaline hydrolysis.     

嗜热脂肪芽孢杆菌HY－69耐热中性蛋白酶的性质研究

嗜热脂肪芽孢杆菌ＨＹ－６９的耐热中性蛋白酶已纯化。研究了纯酶的性质;该酶分子量为２４ｋｄ,由６个单体构成一个六聚体。酶的等电点９．１５．最适作用ｐＨ为７．５,最适作用温度为８５℃：该酶具有很好的耐热性,９０℃时酶活半寿期为２２ｍｉｎ,８０℃保温３小时,酶活仍保持６３％;酶的ｐＨ稳定性也很好。该酶是金属蛋白酶,活性中心含锌离子,酶的热稳定性依赖于钙离子。测定了酶的氨基酸组成和Ｎ末端氨基酸序列。     

Thermostable peroxidase from Bacillus stearothermophilus

A peroxidase from Bacillus stearothermophilus was purified to homogeneity. The enzyme (Mr 175,000) was composed of two subunits of equal size, and showed a Soret band at 406 nm. On reduction with sodium dithionite, absorption at 434 nm and 558 nm was observed. The spectrum of reduced pyridine haemochrome showed peaks at 418, 526 and 557 nm; the reduced minus oxidized spectrum of pyridine haemochrome showed peaks of 418, 524 and 556 nm with a trough at 452 nm. These results indicate that the enzyme contained protohaem IX as a prosthetic group. The optimum pH was about 6 and the apparent optimum temperature was 70 degrees C. The enzyme was relatively stable up to 70 degrees C; at 30 degrees C it was stable for a month. The enzyme had peroxidase activity toward a mixture of 2,4-dichlorophenol and 4-aminoantipyrine with a Km for H2O2 of 1.3 mM. It also acted as a catalase with a Km for H2O2 of 7.5 mM.     

beta-Galactosidase from Bacillus stearothermophilus.

Several strains of thermophilic aerobic spore-forming bacilli synthesize beta-galactosidase (EC 3.2.1.23) constitutively. The constitutivity is apparently not the result of a temperature-sensitive repressor. The beta-galactosidase from one strain, investigated in cell-free extracts, has a pH optimum between 6.0 and 6.4 and a very sharp pH dependence on the acid side of its optimum. The optimum temperature for this enzyme is 65 degrees C and the Arrhenius activation energy is about 24 kcal/mol below 47 degrees C and 16 kcal/mol above that temperature. At 55 degrees C the Km is 0.11 M for lactose and 9.8 X 10(-3) M for 9-nitrophenyl-beta-D-galactopyranoside. The enzyme is strongly product-inhibited by galactose (Ki equals 2.5 X 10(-3) M). It is relatively stable at 50 degrees C, losing only half of its activity after 20 days at this temperature. At 60 degrees C more than 60% of the activity is lost in 10 min. However, the enzyme is protected somewhat against thermal inactivation by protein, and in the presence of 4 mg/ml of bovine serum albumin the enzyme is only 18% inactivated in 10 min at 60 degrees C. Its molecular weight, estimated by disc gel electrophoresis, is 215 000.     

Cloning and Expression of Thermostable alpha-Amylase Gene from Bacillus stearothermophilus in Bacillus stearothermophilus and Bacillus subtilis

The structural gene for a thermostable alpha-amylase from Bacillus stearothermophilus was cloned in plasmids pTB90 and pTB53. It was expressed in both B. stearothermophilus and Bacillus subtilis. B. stearothermophilus carrying the recombinant plasmid produced about fivefold more alpha-amylase (20.9 U/mg of dry cells) than did the wild-type strain of B. stearothermophilus. Some properties of the alpha-amylases that were purified from the transformants of B. stearothermophilus and B. subtilis were examined. No significant differences were observed among the enzyme properties despite the difference in host cells. It was found that the alpha-amylase, with a molecular weight of 53,000, retained about 60% of its activity even after treatment at 80 degrees C for 60 min.     

Effective extracellular production of Bacillus stearothermophilus esterase by pH-stat modal fed-batch culture of recombinant Bacillus brevis

An automated two-component substrate feeding strategy with a pH-stat modal fed-batch culture using a high pH limit was developed to effectively porduce esterase from a hyperprotein exreting Bacillus brevis HPD31 harboring a plasmid pHSC131 which carries a Bacillus stearothermo philus esterase gene. First, the effect of single- and multi-substrate feedings on the growth and activity of the excreted esterase was investigated. Then a two-component (polypepton + glucose) feeding using different feed rates was studied. Highest activity of the excreted esterase (34 U/mL) was obtained when the concentrations of poly-pepton and glucose in the nutrient feed solution were 250 and 41.60 g/L respectively. The absence and excessive amount of glucose in the nutrient feed solution was ineffective for the exracellular esterase formation because without glucose the increase in cell concentration was minimum while excessive amount of glucose favored cell growth at the expense of the esterase production. It is believed that the mechanism of enzyme excretion is growth dependent and that a higher cell growth of the host is in effect unfavorable for the enzyme production. The feed rate, automatically controlled by the direct signal of the pH change, at 0.30 mL/pulse was found optimum for the esterase production while lower (0.15 mL/pulse) and higher (0.67 mL/pulse) feed rates did not produce good results. The activity of the excreted esterase was increased more than eight times from 4 U/mL obtained in the conventional batch culture to 34 U/mL obtained in this study. The esterase productivity was likewise increased more than threefold. (c) 1992 John Wiley & Sons, Inc.     

Isozymes of alpha-galactosidase from Bacillus stearothermophilus

Two molecular forms of alpha-galactosidase (EC 3.2.1.22) synthesized constitutively by Bacillus stearothermophilus, strain AT-7, have been purified. alpha-Galactosidase I (with the substrate p-nitrophenyl alpha-D-galactopyranoside (PNPG)) has a pH optimum of 6 and half-life at 65 degrees C of > 2 h at low protein concentration. alpha-Galactosidase II has a pH optimum of 7 with PNPG and a half-life at 65 degrees C of about 3 min. The isozymes also differ with respect to their Km with PNPG and melibiose. Both enzymes are inhibited competitively by D-galactose, melibiose, and Tris. With the beta-glycosides cellobiose and lactose either noncompetitive or mixed-type inhibition is observed, with the pattern dependent on both the pH and the isozyme. The two isozymes have similar Arrhenius activation energies (about 20 kcal/mol, 1 kcal = 4.184 kJ). Their molecular weights, estimated by disc gel electrophoresis, are alpha-galactosidase I, 280 000 +/- 30 000 and alpha-galactosidase II, 325 000 +/- 15 000. Dodecyl sulfate gel electrophoresis gave a single band for each enzyme. The respective molecular weights, 81 000 +/- 500 for alpha-galactosidase I and 84 000 +/- 500 for alpha-galactosidase II, suggest that both enzymes consist of four subunits.     

Role of cysteine residues in esterase from Bacillus stearothermophilus and increasing its thermostability by the replacement of cysteines

Bacillus stearothermophilus esterase contains two free cysteine residues at positions of 45 and 115, which react with sulfhydryl reagents resulting in a significant decrease in the enzymatic activity. To understand the role of the cysteine residues in catalytic regions of the esterase, the residues were replaced with serine or alanine by site-directed mutagenesis to construct four single-mutated enzymes (C45A, C45S, C115A, C115S) and two double-mutated ones (C45/115A and C45/115S). Wild-type and mutant enzymes were produced in Escherichia coli cells and purified to homogeneity to examine their chemical and kinetic properties. These mutant enzymes had esterase activity, which suggested that none of the cysteines were required for its activity. Moreover, replacement of both two-cysteine residues made the enzyme insensitive to p-chloromercuribenzoic acid and extensively stabilized it at high temperatures of around 70°C. These results demonstrate that replacement of free cysteine residues by site-directed mutagenesis can improve the thermostability of thermophilic enzymes. Correspondence to: T. Yamane     

Thermostable, Raw-Starch-Digesting Amylase from Bacillus stearothermophilus

An endospore-forming thermophilic bacterium, which produced amylase and was identified as Bacillus stearothermophilus, was isolated from soil. The amylase had an optimum temperature of 70°C and strongly degraded wheat starch granules (93%) and potato starch granules (80%) at 60°C.     

Highly thermostable neutral protease from Bacillus stearothermophilus

Bacillus stearothermophilus MK232, which produced a highly thermostable neutral protease, was isolated from a natural environment. By several steps of mutagenesis, a hyper-producing mutant strain, YG185, was obtained. The enzyme productivity was twice as much as that of the original strain. This extracellular neutral protease was purified and crystallized. The molecular weight of the enzyme was 34,000 by SDS-polyacrylamide gel electrophoresis and gel filtration. The optimum pH and temperature for the enzyme activity were 7.5 and 70°C, respectively, and the enzyme was stable at pH 5–10 and below 70°C. The thermostability and specific activity of the new protease are around 10% and 40% higher than those of thermolysin (the neutral protease from Bacillus thermoproteolyticus), respectively. The enzyme was inactivated by EDTA, but not by phenylmethylsulfonyl fluoride. These results indicate that the enzyme is a highly thermostable neutral-(metallo)protease.     

Crystallization of lactate dehydrogenase from Bacillus stearothermophilus

Crystals of lactate dehydrogenase from Bacillus stearothermophilus have been obtained in five different crystal morphologies belonging to at least two different space groups. Apo-lactate dehydrogenase can crystallize in space group P6₁22 or P6₅22 ($\text{a = 87}\text{A}\text{?}\text{and}\text{c = 358}\text{A}\text{?}$). A complex of lactate dehydrogenase with NADH and the effector fructose 1,6-diphosphate can crystallize in the same space group as the apoenzyme and in P6₃22 ($\text{a = 290}\text{A}\text{?}\text{, c = 146}\text{A}\text{?}$). Both forms are suitable for high resolution X-ray diffraction studies.     

Thermophilic NAD-dependent glutamate dehydrogenase from Bacillus stearothermophilus

A rapid purification procedure for glutamate dehydrogenase (GDH) from Bacillus stearothermophilus var calidolactis was developed. The homogeneous enzyme with a total molecular weight of approximately 240,000 daltons, contained 6 identical subunits. No high molecular weight form of GDH present in crude extracts was found after elution of the enzyme from a 5'AMP-Sepharose column with 4 M urea. The purified enzyme functions in both directions i.e. amination and deamination and is strictly specific for NAD. 2-Oxo glutarate, glutamate or 2-mercaptoethanol protects against heat inactivation. NADH or ammonia, on the other hand, makes GDH more sensitive to heat. The purified enzyme undergoes thermal inactivation process.