糠醛和5-羟甲基糠醛对大肠杆菌产丁二酸的影响

利用可再生生物质特别是木质纤维素水解液来生产平台化合物丁二酸,是目前研究的热点。虽然许多研究者相继报道了木质纤维素水解液对菌株生长和丁二酸生产存在一定抑制作用,但并没有水解液中各种抑制物对菌株影响的相关动力学研究及机理研究。我们选择了两种代表性木质纤维素水解液抑制物,即糠醛和5-羟甲基糠醛,系统研究了它们对大肠杆菌的生长和丁二酸生产的影响。结果表明：糠醛和5-羟甲基糠醛的初始抑制浓度均为0.8 g/L。当糠醛浓度大于6.4 g/L,5-羟甲基糠醛浓度大于12.8 g/L时,菌株生长完全受到抑制。在最高耐受浓度下,糠醛的存在使菌株生物量比对照菌株下降77.8%,丁二酸产量下降36.1%。5-羟甲基糠醛的存在使菌株生物量比对照菌株降低13.6%,丁二酸产量降低18.3%。糠醛和5-羟甲基糠醛具有明显的协同作用。体外酶活测定表明丁二酸生产途径中关键酶磷酸烯醇式丙酮酸羧化酶、苹果酸脱氢酶、富马酸还原酶均受糠醛和5-羟甲基糠醛抑制。研究结果对丁二酸生产用纤维素水解液的预处理和脱毒工艺开发具有指导作用,有利于实现丁二酸发酵生产的工业化。     

碱预处理玉米芯米根霉同步糖化发酵产富马酸

以碱预处理玉米芯渣为原料,采用单因素优化方法优化米根霉同步糖化发酵产富马酸。在此基础上,研究米根霉利用碱预处理玉米芯渣的同步糖化发酵,并与纯糖发酵进行对比。结果表明:在50 g/L底物、(NH4)2SO4质量浓度0.71 g/L、纤维素酶用量20 FPIU(以1 g纤维素计)、Ca CO3加入量30 g/L、接种量10%(体积分数)和装液量50 m L的条件下,米根霉同步糖化发酵过程产富马酸13.78 g/L,而纯糖发酵富马酸生成量仅6.21 g/L。     

响应面法优化稀酸水解处理麸皮的条件

麸皮是一种产量大的食品工业副产品。本文研究酸处理麸皮生成糖液,为麸皮再利用提供可行性。首先,通过单因素实验确定酸处理麸皮过程中温度、处理时间和麸皮浓度为主效应因素,进而通过响应面方法优化了酸处理麸皮的条件。采用Box-Behnken设计的3因素3水平的响应面实验得到回归模型。产糖率最高时的条件:112.37℃、处理时间50 min、麸皮质量浓度60 g/L。同时分析了酸水解液中糠醛和5-羟甲基糠醛的浓度。在最优酸水解条件下,糠醛和5-羟甲基糠醛的质量浓度分别为14.40 mg/L和73.59 mg/L。以猛烈度代表酸处理过程中温度和处理时间,建立了猛烈度与糠醛和5-羟甲基糠醛产生量之间的关系。     

纤维素降解产物对Kluyveromyces marxianus 1727共发酵葡萄糖和木糖的影响

研究纤维素酸水解产生的4种副产物乙酸、甲酸、糠醛、5-羟甲基糠醛及发酵产物乙醇对Kluyveromyces marxianus 1727共发酵葡萄糖和木糖的影响。结果表明:5.0 g/L乙酸和1.0 g/L甲酸对葡萄糖和木糖共发酵具有明显的抑制作用;1.0 g/L糠醛和5-羟甲基糠醛基本不影响K.marxianus 1727发酵葡萄糖,且能够被K.marxianus1727转化为毒性相对较低的物质。由于5-羟甲基糠醛的转化速率慢,对K.marxianus 1727发酵木糖的抑制程度大于糠醛。乙醇对K.marxianus 1727发酵木糖具有抑制作用,当乙醇质量浓度大于20 g/L时,生物量及木糖利用率约是对照的44%和70%。     

乙酸、糠醛和5-羟甲基糠醛对产酸克雷伯氏菌发酵生产2,3-丁二醇的影响

为了解产酸克雷伯氏菌对木质纤维素水解液中主要抑制物的耐受和代谢,考察了产酸克雷伯氏菌发酵生产2,3-丁二醇(2,3-butanediol,2,3-BDO)过程中对3种发酵抑制物乙酸、糠醛和5-羟甲基糠醛(5-hydroxymethylfurfural HMF)的耐受以及抑制物浓度的变化,检测了糠醛和HMF的代谢产物.结果表明:产酸克雷伯氏菌对乙酸、糠醛和HMF的耐受浓度分别为30 g/L、4 g/L和5 g/L.并且部分乙酸可作为生产2,3-丁二醇的底物,在0～30 g/L浓度范围内可提高2,3-丁二醇的产量.发酵过程中产酸克雷伯氏菌可将HMF和糠醛全部转化,其中约70％HMF被转化为2,5-呋喃二甲醇,30％HMF和全部糠醛被菌体代谢.研究表明在木质纤维素水解液生产2,3-丁二醇的脱毒过程中可优先考虑脱除糠醛,一定浓度的乙酸可以不用脱除.     

预处理沙柳酶解液脱毒及其丁醇发酵

为了提高沙柳原料的丁醇发酵效果,考察沙柳原料经过蒸爆、超微粉碎+稀酸和超微粉碎+稀碱预处理后补料酶解的效果,优化了沙柳酶解液活性炭脱毒工艺参数,并对经过脱毒处理的酶解液进行了丁醇发酵研究,结果表明:预处理沙柳原料酶解底物质量浓度为200 g/m L时,3种预处理方法中蒸爆处理法水解效果最好,每克底物的滤纸酶酶加量15 U,酶解96 h后,酶解液总糖质量浓度达到57 g/L。活性炭脱毒处理的最优条件:p H 4.8,碳加量4%(质量分数)、温度70℃、1 h,该条件下的沙柳水解液脱色率达到97.4%、糖损失率3.1%。3种预处理沙柳原料的酶解液经活性炭脱毒后都可以被丁醇梭菌正常利用发酵产丁醇,发酵液总溶剂(ABE)质量浓度约为14 g/L。     

采用玉米秸秆水解糖和玉米浆发酵生产丁二酸

研究了以玉米秸秆水解糖为碳源,不同氮源条件下琥珀酸放线杆菌Actinobacillus succinogenesSF-9的丁二酸发酵产酸能力。结果表明玉米浆可以替代酵母膏作为丁二酸发酵的廉价氮源。厌氧摇瓶丁二酸发酵单因素试验,得到在初糖浓度50 g/L时,玉米浆的较佳用量为20 g/L。在5 L搅拌罐上,考察了不同初始玉米秸秆水解糖浓度对A.succinogenes SF-9发酵生产丁二酸的影响,结果显示高初始秸秆糖浓度对琥珀酸放线杆菌的生长有抑制作用。采用补料分批发酵,发酵60 h丁二酸的产量达到42.7g/L,丁二酸产率82.7%,生产强度0.81 g/(L·h)。丁二酸的产量和生产强度较分批发酵有明显提高。     

发酵产丁二酸过程中废弃细胞的循环利用

对厌氧发酵产丁二酸后的废弃细胞进行破壁处理,考察了以细胞水解液作为有机氮源重新用于丁二酸发酵的可行性。比较了超声破碎、盐溶、酶解3种方法破碎细胞获得的水解液作为氮源发酵产丁二酸的效果,结果表明酶解制得的细胞水解液效果最佳。以总氮含量为1.11g/L的酶解液(相当于10g/L酵母膏)作为氮源发酵,丁二酸产量可达42.0g/L,继续增大酶解液用量对耗糖、产酸能力没有显著提高。将细胞酶解液与5g/L酵母膏联用发酵36h后,丁二酸产量达75.5g/L,且丁二酸生产强度为2.10g/(L·h),比使用10g/L酵母膏时提高了66.7%。因此,厌氧发酵产丁二酸结束后的废弃细胞酶解液可以替代原培养基中50%的酵母膏用于发酵。     

木质纤维素酸解副产物对D-乳酸生产菌Sporolactobacillus sp.Y2-8生长及发酵的影响

选择乙酸根、糠醛、5-羟甲基糠醛、苯酚、香草酸和丁香醛等6种典型木质纤维素酸解副产物,考察它们对D-乳酸生产菌Sporolactobacillus sp.Y2-8生长及发酵的影响。实验结果表明:酚类物质抑制作用最强烈,0.25 g/L丁香醛已经完全抑制了菌体的生长和D-乳酸的发酵;苯酚和香草酸在低浓度(≤1.0 g/L)时抑制作用较小,但质量浓度达到3 g/L时对D-乳酸产量的抑制率分别为99%和70%;3 g/L糠醛和5-羟甲基糠醛对产物的抑制率分别为60%与20%,抑制作用小于酚类;乙酸根的影响最小,10 g/L的乙酸钠对菌体的生长和发酵几乎无抑制作用;当抑制物混合时,存在着相互促进作用,抑制作用更强烈。     

沙柳原料高浓度底物酶解发酵乙醇工艺

为了提高沙柳生物转化过程的经济可行性,考察了沙柳原料经过蒸爆、超微粉碎+稀酸、超微粉碎+稀碱预处理后高浓度底物补料酶解的效果,并对其高浓度水解糖液进行了乙醇发酵。结果表明:蒸爆处理法水解效果最好,通过补料酶解,底物质量分数可以达到30%,酶解液中总糖质量浓度达到132 g/L,葡萄糖质量浓度105 g/L;超微粉碎+稀酸预处理原料底物质量分数可以达到22%,酶解液中总糖质量浓度达到123 g/L,葡萄糖质量浓度73 g/L;超微粉碎+稀碱预处理原料底物质量分数可以达到22%,酶解液中总糖质量浓度133 g/L,葡萄糖质量浓度77 g/L。3种预处理使沙柳原料的酶解糖液都可以较好地被酿酒酵母利用发酵产乙醇,蒸爆处理原料的酶解糖液乙醇发酵效果最好,乙醇质量浓度达到47 g/L。     

Ultrasonic pretreatment and acid hydrolysis of sugarcane bagasse for succinic acid production using Actinobacillus succinogenes

Immense interest has been devoted to the production of bulk chemicals from lignocellulose biomass. Diluted sulfuric acid treatment is currently one of the main pretreatment methods. However, the low total sugar concentration obtained via such pretreatment limits industrial fermentation systems that use lignocellulosic hydrolysate. Sugarcane bagasse hemicellulose hydrolysate is used as the carbon and nitrogen sources to achieve a green and economical production of succinic acid in this study. Sugarcane bagasse was ultrasonically pretreated for 40 min, with 43.9 g/L total sugar obtained after dilute acid hydrolysis. The total sugar concentration increased by 29.5 %. In a 3-L fermentor, using 30 g/L non-detoxified total sugar as the carbon source, succinic acid production increased to 23.7 g/L with a succinic acid yield of 79.0 % and a productivity of 0.99 g/L/h, and 60 % yeast extract in the medium could be reduced. Compared with the detoxified sugar preparation method, succinic acid production and yield were improved by 20.9 and 20.2 %, respectively.     

Simultaneous saccharification and fermentation of acid-pretreated rapeseed meal for succinic acid production using Actinobacillus succinogenes

Rapeseed meal was evaluated for succinic acid production by simultaneous saccharification and fermentation using Actinobacillus succinogenes ATCC 55618. Diluted sulfuric acid pretreatment and subsequent hydrolysis with pectinase was used to release sugars from rapeseed meal. The effects of culture pH, pectinase loading and yeast extract concentration on succinic acid production were investigated. When simultaneous saccharification and fermentation of diluted acid pretreated rapeseed meal with a dry matter content of 12.5% (w/v) was performed at pH 6.4 and a pectinase loading of 2% (w/w, on dry matter) without supplementation of yeast extract, a succinic acid concentration of 15.5 g/L was obtained at a yield of 12.4 g/100g dry matter. Fed-batch simultaneous saccharification and fermentation was carried out with supplementation of concentrated pretreated rapeseed meal and pectinase at 18 and 28 h to yield a final dry matter content of 20.5% and pectinase loading of 2%, with the succinic acid concentration enhanced to 23.4 g/L at a yield of 11.5 g/100g dry matter and a productivity of 0.33 g/(Lh). This study suggests that rapeseed meal may be an alternative substrate for the efficient production of succinic acid by A. succinogenes without requiring nitrogen source supplementation.     

Hydrolysis of sorghum straw using phosphoric acid: evaluation of furfural production

Sorghum straw is a waste that has been studied scarcely. The main application is its use as raw material for xylose production. Xylose is a hemicellulosic sugar mainly used for its bioconversion toward xylitol. An alternative use could be its conversion toward furfural. The objective of this work was to study the furfural production by hydrolysis of sorghum straw with phosphoric acid at 134 degrees C. Several concentrations of H(3)PO(4) in the range 2-6% and reaction time (range 0-300 min) were evaluated. Kinetic parameters of mathematical models for predicting the concentration of xylose, glucose, arabinose, acetic acid and furfural in the hydrolysates were found. Optimal conditions for furfural production by acid hydrolysis were 6% H(3)PO(4) at 134 degrees C for 300 min, which yielded a solution with 13.7 g furfural/L, 4.0 g xylose/L, 2.9 g glucose/L, 1.1g arabinose/L and 1.2g acetic acid/L. The furfural yield of the process was 0.1336 g furfural/g initial dry matter was obtained. The results confirmed that sorghum straw can be used for furfural production when it is hydrolyzed using phosphoric acid.     

木薯粉同步糖化发酵(SSF)产丁二酸

【目的】通过优化产琥珀酸放线杆菌GXAS137同步糖化发酵木薯粉产丁二酸的发酵培养基,提高丁二酸产量,降低生产成本。【方法】在单因素试验的基础上,先利用Plackett-Burman试验设计筛选出影响丁二酸发酵的重要参数,再采用正交试验确定重要参数的最佳水平。【结果】价格低廉玉米浆可用作氮源,影响丁二酸产量的重要参数是木薯粉、玉米浆、碱式碳酸镁和糖化酶浓度。最佳条件为(g/L):木薯粉100,玉米浆14,糖化酶2.0 AGU/g底物,碱式碳酸镁75。优化后丁二酸产量达到69.31 g/L,丁二酸得率为90.01%,生产强度为1.44 g/(L·h)。与初始条件(52.34 g/L)相比,丁二酸浓度提高了32.42%。并利用1.3 L发酵罐对SSF与SHF两种发酵工艺进行了比较,SSF丁二酸产量(72.21 g/L)远高于SHF(56.86 g/L)。【结论】产琥珀酸放线杆菌同步糖化发酵木薯粉丁二酸产量高,生产成本低,具有较好的工业化应用前景。     

酵母发酵蔗渣半纤维素水解物生产木糖酶

采用二次正交旋转组合设计研究了蔗渣半纤维素水解过程中硫酸浓度与液 固比对木糖收率的影响。回归分析表明 ,这两个因素与木糖的收率之间存在显著的回归关系。通过回归方程优化水解条件 ,当硫酸浓度 2 .4g L ,液 固 =6 .2 ,在蒸汽压力 2 .5× 10 4Pa的条件下水解 2 .5h ,10 0g蔗渣可水解生成木糖约 2 4g。大孔树脂吸附层析处理蔗渣半纤维素水解物 ,能有效地减少其中的酵母生长抑制物含量 ,显著改善水解物的发酵性能。用大孔树脂在pH 2条件下处理过的蔗渣半纤维素水解物作基质 ,含木糖 2 0 0g L ,产木糖醇酵母菌株CandidatropicalisAS2 .1776发酵 110h耗完基质中的木糖 ,生成木糖醇 12 7g L ,产物转化率 0 .6 4(木糖醇g 木糖g) ,产物生成速率 1.15g L·h .     

Sequential Thermochemical Hydrolysis of Corncobs and Enzymatic Saccharification of the Whole Slurry Followed by Fermentation of Solubilized Sugars to Ethanol with the Ethanologenic Strain <Emphasis Type="Italic">Escherichia coli</Emphasis> MS04

Interest in the use of corncobs as feedstock for bioethanol production is growing. This study assesses the feasibility of sequential thermochemical diluted sulfuric acid pretreatment of corncobs at moderate temperature to hydrolyze the hemicellulosic fraction, followed by enzymatic hydrolysis of the whole slurry, and fermentation of the obtained syrup. The total sugar concentration after enzymatic hydrolysis was 85.21 g/l, i.e., 86 % of the sugars were liberated from the polymeric fractions, together with a low amount of furfural (0.26 g/l) and 4.01 g/l of acetic acid. The syrups, which contained 36.3, 40.9, 4.47, and 1.84 g/l of xylose, glucose, arabinose, and mannose, respectively, were fermented (pH 7, 37 °C, 150 rpm) to ethanol with the metabolically engineered acetate-tolerant Escherichia coli strain MS04 under non-aerated conditions, producing 35 g/l of ethanol in 18 h (1.94 g_EtOH/l/h), i.e., a conversion yield greater than 80 % of the theoretical value based on total sugars was obtained. Hence, using the procedures developed in this study, 288 l of ethanol can be produced per metric ton of dry corncobs. Strain MS04 can ferment sugars in the presence of acetate, and the amount of furans generated during the sequential thermochemical and enzymatic hydrolysis was low; hence, the detoxification step was avoided. The residual salts, acetic acid, and solubilized lignin present in the syrup did not interfere with the production of ethanol by E. coli MS04 and the results show that this strain can metabolize mixtures of glucose and xylose simultaneously.     

玉米芯稀酸水解及L-乳酸发酵研究

对玉米芯稀硫酸水解条件及糖化液发酵L-乳酸进行了初步研究。结果表明,玉米芯木聚糖最适水解条件为2%H2SO_4、120℃、30 min、固液比1:10,糖化液还原糖含量可达40.8 g/L,主要成分为木塘。细菌A-19可以利用水解液中的葡萄糖和木糖产酸,最适发酵条件为45℃、pH 6.5,从45℃～51℃、pH 5.5～pH 6.5产量均较高。用未浓缩的水解液发酵24 h,L-乳酸产量为30.6g/L,残糖为1.6 g/L,糖酸转化率为82.6%;用浓缩1倍的水解液发酵48 h,L-乳酸产量为41.4 g/L,残糖4.1g/L,糖酸转化率为68.2%,在发酵48 h后继续补料发酵至72 h(补料液为浓缩3倍的水解液),L-乳酸产量为50.9 g/L,残糖6.3 g/L,糖酸转化率为71.8%。该研究为利用木质纤维素生产L-乳酸奠定了一定基础。     

Production of fuel ethanol from bamboo by concentrated sulfuric acid hydrolysis followed by continuous ethanol fermentation

An efficient process for the production of fuel ethanol from bamboo that consisted of hydrolysis with concentrated sulfuric acid, removal of color compounds, separation of acid and sugar, hydrolysis of oligosaccharides and subsequent continuous ethanol fermentation was developed. The highest sugar recovery efficiency was 81.6% when concentrated sulfuric acid hydrolysis was carried out under the optimum conditions. Continuous separation of acid from the saccharified liquid after removal of color compounds with activated carbon was conducted using an improved simulated moving bed (ISMB) system, and 98.4% of sugar and 90.5% of acid were recovered. After oligosaccharide hydrolysis and pH adjustment, the unsterilized saccharified liquid was subjected to continuous ethanol fermentation using Saccharomycescerevisiae strain KF-7. The ethanol concentration, the fermentation yield based on glucose and the ethanol productivity were approximately 27.2 g/l, 92.0% and 8.2 g/l/h, respectively. These results suggest that the process is effective for production of fuel ethanol from bamboo.     

The effect of sugar decomposed on the ethanol fermentation and decomposition reactions of sugars

A batch reactor was used to investigate the dilute acid hydrolysis reaction of alpha-cellulose and sugar decomposition reactions. Varying the sulfuric acid concentration from 0.07 to 5.0% for reaction temperatures between 180 and 220°C significantly affected glucose yields, which ranged from about 70% to below 10%. Increasing the reaction temperature enhanced this effect. Similar experimental results were obtained for the decomposition of xylose. For sugar decomposition reactions, less than 0.3 g/L of furfural and 5-hydroxymethylfurfural (5-HMF) were produced from glucose and xylose in the absence of sulfuric acid at 190°C and 15 min of reaction time, but adding a small amount of sulfuric acid (0.5%) dramatically increased the decomposition rate and led to the formation of four undesireable products: formic acid, 5-HMF, acetic acid, and furfural. In both hydrolysis and fermentation reactions formic acid, acetic acid, and 5-HMF severely inhibited ethanol fermentation, while furfural had less of an inhibition effect.