Pretreatment of lignocellulosic biomass using ultrasound aiming at obtaining fermentable sugar

This study aims to evaluate the activity of the cellulase enzyme forward the use of ultrasound technology in different conditions of temperature, pH and exposure time, as well, to match the steps of pretreatment and enzymatic hydrolysis in one step. A central composite design (CCRD) and response surface analysis were used to evaluate the effect of ultrasound power, temperature and pH on enzyme activity. Optimum condition in the studied range was 30% for ultrasound power, pH 4.6 and 50?°C, yielding an enzyme activity of 15.5 UPF/mL. From this, we carried out kinetics of enzymatic hydrolysis on filter paper and bagasse malt, in optimized conditions. Total reducing sugars (TRS) were 3.85 and 0.46?mg/mL when the filter paper and bagasse malt were used as substrate, respectively. Ultrasound showed to be a good technology to increase the enzyme activity aiming to intensify enzymatic processes.     

蒸汽爆破处理沙柳原料酶解条件优化

研究蒸汽爆破预处理对沙柳原料酶解效果的影响,通过响应曲面实验设计法优化蒸汽爆破处理沙柳原料的酶解工艺。结果表明,蒸汽爆破预处理沙柳原料的最佳蒸汽爆破处理条件：压力3.5 MPa、维压时间300 s; 蒸汽爆破最佳酶解条件：pH 4.8、温度53.5 ℃、 每克底物酶加量29.8 FPU。在最优条件下,蒸汽爆破处理沙柳原料的酶解率可以达到最大值87.92%,并验证了数学模型的有效性,试验结果表明蒸汽爆破预处理可以有效提高沙柳原料的水解率。     

The potential of enzyme recycling during the hydrolysis of a mixed softwood feedstock

Despite recent improvement in cellulase enzymes properties, the high cost associated with the hydrolysis step remains a major impediment to the commercialization of full-scale lignocellulose-to-ethanol bioconversion process. As part of a research effort to develop a commercial process for bioconversion of softwood residues, we have examined the potential for recycling enzymes during the hydrolysis of mixed softwood substrate pretreated by organosolv process. We have used response surface methodology to determine the optimal temperature, pH, ionic strength, and surfactant (Tween 80) concentration for maximizing the recovery of bound protein and enzyme activity from the residual substrates after hydrolysis. Data analysis showed that the temperature, pH and surfactant concentration were the major factors governing enzyme desorption from residual substrate. The optimized conditions were temperature 44.4 °C, pH 5.3 and 0.5% Tween 80. The optimal conditions significantly increased the hydrolysis yield by 25% after three rounds of hydrolysis. This bound enzyme desorption combining with free enzyme re-adsorption is a potential method to recover cellulase enzymes and reduce the cost of enzymatic hydrolysis.     

An approach to cellulase recovery from enzymatic hydrolysis of pretreated sugarcane bagasse with high lignin content

The possibility of recovering the cellulases used for enzymatic hydrolysis of sugarcane bagasse was evaluated. A strategy was adopted to maximize the enzyme recovery: desorption of the enzymes adsorbed in the solid residue after hydrolysis, and re-adsorption of the enzymes from the liquid medium onto a fresh substrate. The use of surfactant during the enzymatic hydrolysis was important to improve the glucose release from the material structure and also to facilitate the enzyme desorption from the solid residue after hydrolysis. The temperature and pH used during desorption influenced the enzymes recovery, with the best results (90% adsorbed cellulase) being achieved at 45?°C and pH 5.5. The enzymes present in the liquid medium after enzymatic hydrolysis were partially recovered (77%) by adsorption onto the fresh substrate and used in new enzymatic hydrolysis batches. It was concluded that it is possible to recycle cellulases from an enzymatic medium for use in subsequent hydrolysis processes.     

产海因酶的菌种筛选和产酶条件的研究

利用5-苄海因作为唯一氮源法筛选高产海因酶的菌种,从本实验室保存的221株菌种中筛选出12株具有不对称水解5-苄海因生成N-氨甲酰基-苯丙氨酸的菌株,其中假单胞菌（Pseudomonassp.)X4-49具有较高的产酶活力,对此菌的产酶条件的研究表明,产酶的最佳碳源为甘油,最佳氮源为蛋白胨,最佳诱导物为苄海因,尿嘧啶,苄海因作为诱导物的有效浓度为0.2%,产酶的最适培养基的初始pH为7.0。培养条件为33℃,13h。     

Identification of cytosolic leucyl aminopeptidase (EC 3.4.11.1) as the major cysteinylglycine-hydrolysing activity in rat liver

Cysteinylglycine hydrolysis is a step in the metabolism of glutathione and glutathione S-conjugates. We had previously observed that in rat liver the enzymatic activity is predominantly located in the cytosol. Here we demonstrate that cytosolic leucyl aminopeptidase (EC 3.4.11.1) is the major cysteinylglycine hydrolysing activity in rat liver. Evidence was obtained from the use of peptidase inhibitors and from immunoprecipitation studies using Pansorbin-coupled antibodies raised against hog kidney cytosolic leucyl aminopeptidase. Both isolated cytosolic leucyl aminopeptidase and the cysteinylglycine-hydrolysing activity in rat liver cytosol are bound with equal efficiency to the affinity matrix. We demonstrate that cytosolic leucyl aminopeptidase exhibits leucinamidase and cysteinylglycinase activity. Cysteinylglycine, cystinyl-bis-glycine, S-nitrosocysteinylglycine, and bimane-S-cysteinylglycine are hydrolysed at high rates; low activity is seen with leukotriene D4. Our findings establish a previously unrecognised physiological function of cytosolic leucyl aminopeptidase, participating in glutathione metabolism and in the degradation of glutathione S-conjugates via the mercapturic acid pathway.     

鲜鹿茸酶降解过程的研究

研究了胰蛋白酶、Alcalase 碱性蛋白酶、木瓜蛋白酶对鲜鹿茸的降解过程,确定了优化降解工艺条件,具有一定的理论意义和实践价值。确定了Alcalase 碱性蛋白酶的降解效率最高,通过单因素实验确定了降解过程中底物浓度、酶解温度、pH值和酶解时间为影响鲜鹿茸降解率的主要因素。正交试验确定最佳的酶解条件为:底物浓度0.08 g/ml、酶解温度65 ℃、pH 9.0、酶解时间6.0 h。在此条件下,鲜鹿茸降解率高达92.6%,氨基酸产品收率达12.1%。     

Preliminary Studies of Some Physiological Properties of Torula jeanselmei

The morphological characteristics of pathogenic and saprophytic strains of Torula jeanselmei (Fungi Imperfecti) are indistinguishable. Some basic physiological properties of T. jeanselmei were investigated in the hope of separating the human pathogenic strain from common saprophytes in a clinical laboratory. Nitrogen and carbon assimilation tests were not useful for distinguishing the pathogen, since all strains, pathogenic and saprophytic, were able to assimilate nitrogen from ammonium, nitrate, and nitrite sources, and all were able to utilize glucose, fructose, galactose, cellobiose, lactose, glycerol, and starch. It appeared that temperature range for growth might be useful in the identification of the pathogen. All pathogenic strains grew well at 37 C but poorly at 10 C; in contrast, all saprophytes could grow at 10 C but were unable to grow at 37 C (with two exceptions).     

蒸汽爆破玉米秸秆酶解动力学

为了掌握蒸汽爆破玉米秸秆的酶解特性,研究了不同底物浓度、酶浓度、温度对反应速率的影响。运用米氏方程对酶解动力学过程进行拟合,结果表明,纤维素酶对该玉米秸秆的水解反应在反应前3 h符合一级反应,可用米氏方程对其进行拟合。在转速为120 r/min、酶浓度为1.2 FPU/mL、pH 5.0、温度为45 ℃时米氏常数Km为11.71 g/L,最大反应速率Vm为1.5 g/(L·h)。确立了包括底物浓度、酶浓度、温度在内的酶解动力学模型,该模型适合温度为30 ℃~50 ℃。     

Enzymatic hydrolysis of willow treated with a steam burst without preliminary water extraction with a high concentration of substrate

A laboratory reactor equipped with a screw press was used for hydrolysis of steam-SO2 exploded willow Salix caprea by a composition of Trichoderma reesei and Aspergillus foetidus enzyme preparations at high substrate concentrations. Optimal conditions providing the maximal volume of hydrolysis syrup with maximal sugar concentrations were determined. Two different hydrolysis procedures were developed in order to exclude initial washing of steam-pretreated plant raw material by large volumes of water, which is necessary to eliminate the inhibitory effect of explosion by-products on enzymatic hydrolysis. The first procedure included a one-hour-long enzymatic prehydrolysis of the substrate, then separation of sugar syrup containing 40-60 g/l of glucose, 20-25 g/l of xylose, and up to 10% of disaccharides, as well as up to 35% of the initial enzymatic activity, then addition of a diluted acetate buffer (pH 4.5), and subsequent hydrolysis of the substrate by the adsorbed enzymes leading to the final accumulation of up to 140 g/l glucose and up to 15 g/l xylose. In the second scenario, the exploded willow was initially adjusted by alkali to pH 4.5 and then hydrolyzed directly by added enzymes for 24 hours. This procedure resulted in a nearly total polysaccharide hydrolysis and accumulation of up to 170 g/l glucose and 20 g/l xylose. The reasons of inhibition of enzymatic hydrolysis are discussed.     

Enzymatic characteristics of ligninperoxidases from Penicillium citrinum, Fusarium oxysporum and Aspergillus terreus using n-propanol as substrate

The activities of ligninperoxidases from Penicillium citrinum MTCC 3565, Fusarium oxysporum MTCC 3379 and Aspergillus terreus MTCC 3374 have been assayed and the enzymatic characteristics like Km, pH and temperature optima using n-propanol as the substrate have been reported. The results suggest that n-propanol can substitute veratryl alcohol as substrate for assaying ligninperoxidase activities from different fungal strains, without affecting the enzymatic characteristics. The above strains were selected, as they were known to secrete ligninperoxidase in the liquid culture medium.     

Kinetic characterization of gyroxin,a serine protease from Crotalus durissus terrificus venom

This work describes for the first time the characterization of the enzymatic features of gyroxin, a serine protease from Crotalus durissus terrificus venom, capable to induce barrel rotation syndrome in rodents. Measuring the hydrolysis of the substrate ZFR-MCA, the optimal pH for proteolytic cleavage of gyroxin was found to be at pH 8.4. Increases in the hydrolytic activity were observed at temperatures from 25 °C to 45 °C, and increases of NaCl concentration up to 1 M led to activity decreases. The preference of gyroxin for Arg residues at the substrate P1 position was also demonstrated. Taken together, this work describes the characterization of substrate specificity of gyroxin, as well as the effects of salt and pH on its enzymatic activity.     

Detection and characterization of protease secreted by the plant pathogen Xylella fastidiosa

Xylella fastidiosa is a pathogenic bacterium found in several plants. These bacteria secrete extracellular proteases into the culture broth as visualized in sodium-dodecyl-sulfate polyacrylamide activity gels containing gelatin as a copolymerized substrate. Three major protein bands were produced by the citrus strain with molar masses (MM) of 122, 84 and 65 kDa. Grape strain 9,713 produced two bands of approximately 84 and 64 kDa. These organisms produced zones of hydrolysis in agar plates amended with gelatin, casein and hemoglobin. Gelatin was the best substrate for these proteases. Sodium dodecyl sulfate-polyacrylamide electrophoresis (SDS-PAGE) activity gel indicated that the protease of Xylella fastidiosa from citrus and grape were completely inhibited by PMSF and partially inhibited by EDTA. The optimal temperature for protease activity was 30 degrees C with an optimal pH of 7.0. Among the proteolytic enzymes secreted by the phytopathogen, chitinase and beta-1,3-glucanase activities were also detected in cultures of Xylella fastidiosa (citrus). From these results, it is suggested that proteases produced by strains of Xylella fastidiosa from citrus and grape, belong to the serine- and metallo-protease group, respectively.     

Enzymatic hydrolysis of microcrystalline cellulose in reverse micelles

The activities of cellulases from Trichoderma reesei entrapped in three types of reverse micelles have been investigated using microcrystalline cellulose as the substrate. The reverse micellar systems are formed by nonionic surfactant Triton X-100, anionic surfactant Aerosol OT (AOT), and cationic surfactant cetyltrimethyl ammonium bromide (CTAB) in organic solvent media, respectively. The influences of the molar ratio of water to surfactant omega0, one of characteristic parameters of reverse micelles, and other environmental conditions including pH and temperature, on the enzymatic activity have been studied in these reverse micellar systems. The results obtained indicate that these three reverse micelles are more effective than aqueous systems for microcrystalline cellulose hydrolysis, and cellulases show "superactivity" in these reverse micelles compared with that in aqueous systems under the same pH and temperature conditions. The enzymatic activity decreases with the increase of omega0 in both AOT and Triton X-100 reverse micellar systems, but reaches a maximum at omega0 of 16.7 for CTAB reverse micelles. Temperature and pH also influence the cellulose hydrolysis process. The structural changes of cellulases in AOT reverse micelles have been measured by intrinsic fluorescence method and a possible explanation for the activity changes of cellulases has been proposed.     

Fatty acid composition of Leptospira lipids as a taxonomic criterion

The fatty-acid composition of microbial cells in 17 pathogenic and saprophytic Leptospira strains, comprising 14 serovars and 10 serogroups, has been studied. The strains under investigation have proved to fall into 3 groups differing by this characteristic. The group of saprophytic strains is characterized by a comparatively high level of myristic acid and, consequently, by the ratio of saturated and unsaturated fatty acids with 14 carbon atoms approaching 1:1; besides, it is also characterized by a lower, in comparison with the pathogenic Leptospira strains belonging to the serogroups Icterohaemorrhagiae, Canicola, Ballum has a higher level of unsaturated fatty acids. The second group of pathogenic Leptospira strains including the serogroups Grippotyphosa, Hebdomadis, Pomona, Tarassovi, Pyrogenes, Australia has been found to occupy an intermediate position between the first group of pathogenic Leptospira strains and the group of saprophytic ones. As the difference in the content of myristic acid in pathogenic and saprophytic Leptospira strains is a stable characteristic, it can be used for the differentiation of these strains. The present investigation has revealed that the distribution of the main fatty acids in Leptospira phospholipids is similar to their distribution in Leptospira neutral lipids with the exception of unsaturated fatty acid with 14 carbon atoms, occurring mainly in phospholipids.     

Kinetic modeling of enzymatic hydrolysis of cellulose in differently pretreated fibers from dairy manure

A kinetic model incorporating dynamic adsorption, enzymatic hydrolysis, and product inhibition was developed for enzymatic hydrolysis of differently pretreated fibers from a nitrogen-rich lignocellulosic material-dairy manure. The effects of manure proteins on the enzyme adsorption profile during hydrolysis have been discussed. Enzyme activity, instead of protein concentration, was used to describe the enzymatic hydrolysis in order to avoid the effect of manure protein on enzyme protein analysis. Dynamic enzyme adsorption was modeled based on a Langmiur-type isotherm. A first-order reaction was applied to model the hydrolysis with consideration being given for the product inhibition. The model satisfactorily predicted the behaviors of enzyme adsorption, hydrolysis, and product inhibition for all five sample manure fibers. The reaction conditions were the substrate concentrations of 10-50 g/L, enzyme loadings of 7-150 FPU/g total substrate, and the reaction temperature of 50 degrees C.     

Electrophoretic study of the outer membrane proteins of leptospirae

The outer membranes of pathogenic and saprophytic leptospires have been isolated. The spectrum of outer membrane proteins in three saprophytic and one pathogenic Leptospira strains has been studied by means of electrophoresis in polyacrylamide gel. In Leptospira strains VGNKI-6 (pathogenic) and G-80 (saprophytic) identical proteins, as well as proteins similar in their Rf value, have been detected. The possibility of using strain G-80 for the development of leptospiral vaccine against serovars having common surface antigens with this strain has been suggested.     

High-solids enzymatic hydrolysis of steam-exploded willow without prior water washing

A laboratory reactor equipped with a screw press was used for the hydrolysis of steam-SO₂-exploded willowSalix caprea by a composition ofTrichoderma reesei andAspergillus foetidus enzyme preparations at high substrate concentration. Optimal conditions providing the maximal volume of hydrolysis syrup with maximal sugar concentrations were determined. Two different hydrolysis procedures were developed in order to exclude the initial washing of steam-pretreated plant raw material by large volumes of water, which was necessary to eliminate the inhibitory effect of explosion byproducts on enzymatic hydrolysis. The first procedure included enzymatic prehydrolysis of the substrate for 1 h; separation of sugar syrup containing 40–60 g/l glucose, 20–25 g/l xylose, and up to 10 g/l disaccharides, as well as up to 35% of the initial enzymatic activity; then addition of a diluted acetate buffer (pH 4.5); and subsequent hydrolysis of the substrate by the adsorbed enzymes leading to the final accumulation of up to 140 g/l glucose and up to 15 g/l of xylose. In the second scenario, the exploded willow was initially adjusted by alkali to pH 4.5 and then hydrolyzed directly by the added enzymes over 24 h. This procedure resulted in a nearly total polysaccharide hydrolysis and accumulation of up to 170 g/l glucose and 20 g/l xylose. The reasons for inhibition of enzymatic hydrolysis are discussed. Deceased.     

Screening of microbes for novel acidic cutinases and cloning and expression of an acidic cutinase from Aspergillus niger CBS 513.88

Isolates from gardening waste compost and 38 culture collection microbes were grown on agar plates at pH 4.0 with the cutinase model substrate polycaprolactone as a carbon source. The strains showing polycaprolactone hydrolysis were cultivated in liquid at acidic pH and the cultivations were monitored by assaying the p-nitrophenyl butyrate esterase activities. Culture supernatants of four strains were analyzed for the hydrolysis of tritiated apple cutin at different pHs. Highest amounts of radioactive hydrolysis products were detected at pHs below 5. The hydrolysis of apple cutin by the culture supernatants at acidic pH was further confirmed by GC–MS analysis of the hydrolysis products. On the basis of screening, the acidic cutinase from Aspergillus niger CBS 513.88 was chosen for heterogeneous production in Pichia pastoris and for analysis of the effects of pH on activity and stability. The recombinant enzyme showed activity over a broad range of pHs with maximal activity between pH 5.0 and 6.5. Activity could be detected still at pH 3.5.     

Characterisation and application of glycanases secreted by Aspergillus terreus CCMI 498 and Trichoderma viride CCMI 84 for enzymatic deinking of mixed office wastepaper

Two enzymatic extracts obtained from xylan-grown Aspergillus terreus CCMI 498 and cellulose-grown Trichoderma viride CCMI 84 were characterised for different glycanase activities. Both strains produce extracellular endoxylanase and endoglucanase enzymes. The enzymes optimal activity was found in the temperature range of 45–60 °C. Endoglucanase systems show identical activity profiles towards temperature, regardless of the strain and inducing substrate. Conversely, the endoxylanases produced by both strains showed maximal activity at different pH values (from 4.5 to 5.5), being the more acidic xylanase produced by T. viride grown on cellulose. The endoglucanase activities have an optimum pH at 4.5–5.0. The endoxylanase and endoglucanase activities exhibited high stability at 50 °C and pH 5.0. Mannanase, β-xylosidase, and amylase activities were also found, being the first two activities only present for T. viride extract. These two enzymatic extracts were used for mixed office wastepaper (MOW) deinking. When the enzymatic extract from T. viride was used, a further increase of 24% in ink removal was obtained by comparison with the control. Both enzymes contributed to the improvement of the paper strength properties and the obtained results clearly indicate that the effective use of enzymes for deinking can also contribute to the pulp and paper properties improvement.