Visualization of Trichoderma reesei Cellobiohydrolase I and Endoglucanase I on Aspen Cellulose by Using Monoclonal Antibody-Colloidal Gold Conjugates

Monoclonal antibodies (MAbs) specific for cellobiohydrolase I (CBH I) and endoglucanase I (EG I) were conjugated to 10- and 15-nm colloidal gold particles, respectively. The binding of CBH I and EG I was visualized by utilizing the MAb-colloidal gold probes. The visualization procedure involved immobilization of cellulose microfibrils on copper electron microscopy grids, incubation of the cellulose-coated grids with cellulase(s), binding of MAb-colloidal gold conjugates to cellulase(s), and visualization via transmission electron microscopy. CBH I was seen bound to apparent crystalline cellulose as well as apparent amorphous cellulose. EG I was seen bound extensively to apparent amorphous cellulose with minimal binding to crystalline cellulose.     

Synergism of Trichoderma reesei cellulases while degrading different celluloses

Summary The synergistic action of purified cellulases from Trichoderma reesei in hydrolysis of cellulose decreased with increasing substrate concentration, depended strongly on the the type of cellulose used, and was maximal on crystalline cellulose. Contrarily, the activity of the individual cellulases was highest on amorphous cellulose. The binary combinations CBH I/EG III and CBH I/CBH II exhibited the greatest degree of synergism on crystalline cellulose.     

Acid hydrolysis of bacterial cellulose reveals different modes of synergistic action between cellobiohydrolase I and endoglucanase I.

Intact and partially acid hydrolyzed cellulose from Acetobacter xylinum were used as model substrates for cellulose hydrolysis by 1,4-beta-D-glucan-cellobiohydrolase I (CBH I) and 1,4-beta-D-endoglucanase I (EG I) from Trichoderma reesei. A high synergy between CBH I and EG I in simultaneous action was observed with intact bacterial cellulose (BC), but this synergistic effect was rapidly reduced by acid pretreatment of the cellulose. Moreover, a distinct synergistic effect was observed upon sequential endo-exo action on BC, but not on bacterial microcrystalline cellulose (BMCC). A mechanism for endo-exo synergism on crystalline cellulose is proposed where the simultaneous action of the enzymes counteract the decrease of activity caused by undesirable changes in the cellulose surface microstructure.     

Dissecting and Reconstructing Synergism: IN SITU VISUALIZATION OF COOPERATIVITY AMONG CELLULASES*

Cellulose is the most abundant biopolymer and a major reservoir of fixed carbon on earth. Comprehension of the elusive mechanism of its enzymatic degradation represents a fundamental problem at the interface of biology, biotechnology, and materials science. The interdependence of cellulose disintegration and hydrolysis and the synergistic interplay among cellulases is yet poorly understood. Here we report evidence from in situ atomic force microscopy (AFM) that delineates degradation of a polymorphic cellulose substrate as a dynamic cycle of alternating exposure and removal of crystalline fibers. Direct observation shows that chain-end-cleaving cellobiohydrolases (CBH I, CBH II) and an internally chain-cleaving endoglucanase (EG), the major components of cellulase systems, take on distinct roles: EG and CBH II make the cellulose surface accessible for CBH I by removing amorphous-unordered substrate areas, thus exposing otherwise embedded crystalline-ordered nanofibrils of the cellulose. Subsequently, these fibrils are degraded efficiently by CBH I, thereby uncovering new amorphous areas. Without prior action of EG and CBH II, CBH I was poorly active on the cellulosic substrate. This leads to the conclusion that synergism among cellulases is morphology-dependent and governed by the cooperativity between enzymes degrading amorphous regions and those targeting primarily crystalline regions. The surface-disrupting activity of cellulases therefore strongly depends on mesoscopic structural features of the substrate: size and packing of crystalline fibers are key determinants of the overall efficiency of cellulose degradation.     

Mode of action of cellulases on dyed cotton with a reactive dye

Cotton woven fabrics which were previously dyed with a reactive dye were treated with a commercial cellulase preparation. Dyeing with a reactive dye for cotton apparently inhibited the weight loss activity and saccharification activity of cellulase. In addition, dyed cotton was treated with highly purified cellulases which were exo-type cellulases (Cellobiohydrolase I (CBH I) and Cellobiohydrolase II (CBH II)) and endo-type cellulase (Endoglucanase II (EG II)). Exo-type cellulases were inhibited more than endo-type cellulase by dyeing in the case of saccharification activity. CBH I was severely inhibited by dyeing as compared with CBH II or EG II from the viewpoint of morphological changes in the fiber surface. Dyes on the cellulose substrates severely influenced CBH I in spite of the rare modification, because CBH I hydrolyzed cellulose with true-processive action. The change in the activity of each cellulase component on dyed cotton can affect the synergistic action of cellulases.     

The Effect of Xyloglucans on the Degradation of Cell-Wall-Embedded Cellulose by the Combined Action of Cellobiohydrolase and Endoglucanases from Trichoderma viride

Two endoglucanases of Trichoderma viride, endoI and endoIV, were assayed for their activity toward alkali-extracted apple xyloglucans. EndoIV was shown to have a 60-fold higher activity toward xyloglucan than endoI, whereas carboxymethyl cellulose and crystalline cellulose were better substrates for the latter. The enzymic degradation of cellulose embedded in the complex cell-wall matrix of apple fruit tissue has been studied using cellobiohydrolase (CBH) and these two different endoglucanases. A high-performance liquid chromatographic method (Aminex HPX-22H) was used to monitor the release of cellobiose and oligomeric xyloglucan fragments. Synergistic action between CBH and endoglucanases on cell-wall-embedded cellulose was, with respect to their optimal ratio, slightly different from that reported for crystalline cellulose. The combination of endoIV and CBH solubilized twice as much cellobiose compared to a combination of endoI and CBH. Apparently, the concomitant removal of the xyloglucan coating from cellulose microfibrils by endoIV is essential for an efficient degradation of cellulose in a complex matrix. Cellulose degradation slightly enhanced the solubilization of xyloglucans. These results indicate optimal degradation of cell-wall-embedded cellulose by a three-enzyme system consisting of an endoglucanase with high affinity toward cellulose (endoI), a xyloglucanase (endoIV), and CBH.     

Synergism among three purified cellulolytic components of Clostridium thermocellum

Abstract Three clostridial cellulases viz. a hydrophilic cellobiohydrolase (CBH3), a hydrophobic endoglucanase (EG1), and an aggregate-forming hydrophilic endoglucanase (EG5), all purified from recombinant strains of Escherichia coli , were used in different combinations to reconstitute the synergistic effect during cellulose hydrolysis. EG1 and EG5 were weakly active on crystalline cellulose, if added separately or together in the reaction mixture. However, when CBH3 was added to the reaction mixture, its hydrolytic activity was increased to 1.8-fold in the presence of EG1 and EG5. A further increase in the activity from 1.8 to 2.2-fold was observed when calcium and dithiothreitol were added to the reaction mixture containing all three enzymes and filter paper as substrate. The synergistic effect remained unaffected even when EG1 was replaced by its 33-amino acid C-terminal deleted variant BL35. BL35 was less active compared to EG1, but was equally hydrophobic as EG1. These results suggest that the hydrophobic interaction between cellulolytic components and/or with the crystalline substrate is important for positive synergistic effect.     

Identification and purification of the main components of cellulases from a mutant strain of Trichoderma viride T 100-14

A new mutant strain of fungus Trichoderma viride T 100-14 was cultivated on 1% microcrystalline cellulose (Avicel) for 120h and the resulting culture filtrate was prepared for protein identification and purification. To identify the predominant catalytic components, cellulases were separated by an adapted two-dimensional electrophoresis technique. The apparent major spots were identified by high performance liquid chromatography electrospray ionization mass (HPLC-ESI-MS). Seven of the components were previously known, i.e., the endoglucanases Cel7B (EG I), Cel12A (EG III), Cel61A (EG IV), the cellobiohydrolases Cel7A (CBH I), Cel6A (CBH II), Cel6B (CBH IIb) and the beta-glucosidase. The seven major components in the fermentation broth of T. viride T 100-14 probably constitute the essential enzymes for crystalline cellulose hydrolysis and they were further purified to electrophoretic homogeneity by a series of chromatography column. Hydrolysis studies of the purified elements revealed that three of the cellulases were classified as cellobiohydrolases due to their main activities on p-nitrophenyl-beta-d-cellobioside (pNPC). Three of the cellulases, with the abilities of hydrolyzing both carboxymethyl-cellulose (CMC) and Avicel indicate their endoglucanase activities. It deserved noting that the beta-glucosidase from the T 100-14 displayed an extremely high activity on p-nitrophenyl-beta-D-glycopyranoside (pNPG), which suggested it was a good candidate for the conversion of cellobiose to glucose.     

Colloidal Gold Cytochemistry of Endo-1,4-beta-Glucanase, 1,4-beta-D-Glucan Cellobiohydrolase, and Endo-1,4-beta-Xylanase: Ultrastructure of Sound and Decayed Birch Wood

Colloidal gold coupled to endo-1,4-beta-glucanase II (EG II) and 1,4-beta-D-glucan cellobiohydrolase I (CBH I), isolated from Trichoderma reesei (QM9414), and endo-1,4-beta-xylanase from Aureobasium pullulans (NRRLY-2311-1) was used successfully to determine the ultrastructural localization of cellulose and xylan in sound birch wood. In addition, these enzyme-gold complexes demonstrated the distribution of cellulose and xylan after decay by three white rot fungi, Phanerochaete chrysosporium, Phellinus pini, and Trametes versicolor, and one brown rot fungus, Fomitopis pinicola. Transverse sections of sound wood showed that EG II was localized primarily on the S(1) layer of the secondary wall, whereas CBH I labeled all layers of the secondary wall. Oblique sections showed a high concentration of gold labeling, using EG II or CBH I. Preference for the sides of the microfibrillar structure was observed for both EG II and CBH I, whereas only CBH I had a specificity for the cut ends of microfibrils. Labeling with the xylanase-gold complex occurred primarily in the inner regions of the S(2) layer, S(1), and the middle lamella. In contrast, little labeling occurred in the middle lamella with EG II or CBH I. Intercellular regions within the cell corners of the middle lamella were less electron dense and labeled positively when EG II- and xylanase-gold were used. Wood decayed by P. chrysosporium or P. pini was delignified, and extensive degradation of the middle lamella was evident. The remaining secondary walls labeled with EG II and CBH I, but little labeling was found with the xylanase-gold complex. Wood decayed by T. versicolor was nonselective, and erosion of all cell wall layers was apparent. Remaining wall layers near sites of erosion labeled with both EG II and CBH I. Erosion troughs that reached the S(1) layer or the middle lamella had less xylanase-gold labeling in the adjacent cell wall that remained. Brown-rotted wood had very low levels of gold particles present in sections treated with EG II or xylanase. Labeling with CBH I had the lowest concentrations in the S(2) layer near cell lumina and corresponded to sites with the most extensive degradation.     

Cellulase Complex of the Fungus Chrysosporium lucknowense: Isolation and Characterization of Endoglucanases and Cellobiohydrolases

Using different chromatographic techniques, eight cellulolytic enzymes were isolated from the culture broth of a mutant strain of Chrysosporium lucknowense: six endoglucanases (EG: 25 kD, pI 4.0; 28 kD, pI 5.7; 44 kD, pI 6.0; 47 kD, pI 5.7; 51 kD, pI 4.8; 60 kD, pI 3.7) and two cellobiohydrolases (CBH I, 65 kD, pI 4.5; CBH II, 42 kD, pI 4.2). Some of the isolated cellulases were classified into known families of glycoside hydrolases: Cel6A (CBH II), Cel7A (CBH I), Cel12A (EG28), Cel45A (EG25). It was shown that EG44 and EG51 are two different forms of one enzyme. EG44 seems to be a catalytic module of an intact EG51 without a cellulose-binding module. All the enzymes had pH optimum of activity in the acidic range (at pH 4.5-6.0), whereas EG25 and EG47 retained 55-60% of the maximum activity at pH 8.5. Substrate specificity of the purified cellulases against carboxymethylcellulose (CMC), beta-glucan, Avicel, xylan, xyloglucan, laminarin, and p-nitrophenyl-beta-D-cellobioside was studied. EG44 and EG51 were characterized by the highest CMCase activity (59 and 52 U/mg protein). EG28 had the lowest CMCase activity (11 U/mg) amongst the endoglucanases; however, this enzyme displayed the highest activity against beta-glucan (125 U/mg). Only EG51 and CBH I were characterized by high adsorption ability on Avicel cellulose (98-99%). Kinetics of Avicel hydrolysis by the isolated cellulases in the presence of purified beta-glucosidase from Aspergillus japonicus was studied. The hydrolytic efficiency of cellulases (estimated as glucose yield after a 7-day reaction) decreased in the following order: CBH I, EG60, CBH II, EG51, EG47, EG25, EG28, EG44.     

微紫青霉CBHⅠ酶纤维素结合结构域在大肠杆菌中的分泌型表达及性质研究

为研究纤维素酶纤维素结合结构域的结构与功能 ,进而深入了解天然纤维素的生物降解机制和提高纤维素酶的生物工艺学价值 ,采用 PCR技术体外扩增了携带微紫青霉外切葡聚糖纤维二糖水解酶 ( CBH ) CBD编码区的 DNA片段 ,将 CBD编码区 DNA片段插入带有 Erwiniacarotovora pe1 B前导肽序列的大肠杆菌质粒 p KK- tac- new上进行了表达 .携带微紫青霉 CBDCBH 编码区的大肠杆菌重组菌株 DH5α( p KK- tac- new- 8)产生有活性的分泌型 CBDCBH 蛋白 .SDS-PAGE检测显示所产生的 CBDCBH 蛋白分子量约 1 0 .8k D.在 IPTG诱导下 ,该菌株所产生的CBDCBH 蛋白含量达 45.2 mg/L,且 90 %以上的 CBD蛋白分泌到培养物上清液中 .结晶纤维素 CF-1 1溶液经 CBDCBH 处理后 ,浊度比对照提高了 1 2 8.9% ,天然棉花纤维结构经 CBDCBH 处理后产生一定程度的非水解性降解作用 ,表明微紫青霉 CBDCBH 具有解聚天然结晶纤维素的作用 .     

Adsorption of Trichoderma reesei CBH I and EG II and their catalytic domains on steam pretreated softwood and isolated lignin

The presence of lignin has shown to play an important role in the enzymatic degradation of softwood. The adsorption of enzymes, and their constituent functional domains on the lignocellulosic material is of key importance to fundamental knowledge of enzymatic hydrolysis. In this study, we compared the adsorption of two purified cellulases from Trichoderma reesei, CBH I (Cel7A) and EG II (Cel5A) and their catalytic domains on steam pretreated softwood (SPS) and lignin using tritium labeled enzymes. Both CBH I and its catalytic domain exhibited a higher affinity to SPS than EG II or its catalytic domain. Removal of cellulose binding domain decreased markedly the binding efficiency. Significant amounts of CBH I and EG II also bound to isolated lignin. Surprisingly, the catalytic domains of the two enzymes of T. reesei differed essentially in the adsorption to isolated lignin. The catalytic domain of EG II was able to adsorb to alkaline isolated lignin with a high affinity, whereas the catalytic domain of CBH I did not adsorb to any of the lignins tested. The results indicate that the cellulose binding domain has a significant role in the unspecific binding of cellulases to lignin.     

Ethanol production from cellulosic materials using cellulase-expressing yeast

We demonstrate direct ethanol fermentation from amorphous cellulose using cellulase-co-expressing yeast. Endoglucanases (EG) and cellobiohydrolases (CBH) from Trichoderma reesei, and β-glucosidases (BGL) from Aspergillus aculeatus were integrated into genomes of the yeast strain Saccharomyces cerevisiae MT8-1. BGL was displayed on the yeast cell surface and both EG and CBH were secreted or displayed on the cell surface. All enzymes were successfully expressed on the cell surface or in culture supernatants in their active forms, and cellulose degradation was increased 3- to 5-fold by co-expressing EG and CBH. Direct ethanol fermentation from 10 g/L phosphoric acid swollen cellulose (PASC) was also carried out using EG-, CBH-, and BGL-co-expressing yeast. The ethanol yield was 2.1 g/L for EG-, CBH-, and BGL-displaying yeast, which was higher than that of EG- and CBH-secreting yeast (1.6 g/L ethanol). Our results show that cell surface display is more suitable for direct ethanol fermentation from cellulose.     

Synergistic cooperation of cellulases of trichoderma reesei as distinguished by a new filter-paper destruction assay

WHATMAN 1 CHR filter paper manufactured from macerated cotton fibers was shown to be a soft substrate when broken down by purified cellulases of Trichoderma reesei (CELLUCLAST). Destruction of filter-paper disks was induced by CBH I/1, CBH I/2, CBH II/1, CBH II/2, and EG I in a macroscopic assay. Attack on disks by mixtures of these cellulases (CBH I/1 or CBH I/2 mixed with CBH II/1, CBH II/2, or with EGJ) were followed by synergistically enhanced destructions. SCHLEICHER &SCHUELL filter paper No 595 was shown to be a harder substrate of enzymatical decomposition when induced by cellulases of CELLUCLAST. None of the cellulases could induce macroscopic destruction of filter-paper disks when acting in isolation. However, mixtures of isolated exo and endo-glucanases (CBH I/1 or CBH I/2 mixed with CBH II/1, CBH II/2, or EG I) caused powerful destruction of filter-paper disks. SCHLEICHER &SCHUELL filter paper No 595 incubated first with an endo-glucanase (CBH II/1, CBH II/2, EG I) and treated in a secondary incubation with an exo-glucanase (CBH I/1, CBH I/2) were destroyed to a greater extent than with incubations executed in the reverse order. Results confirm the endo exo concept of explaining cellulose decomposition. The filter-paper destruction assay was performed with filter-paper disks prepared with an office punch. Disks were incubated in 1 ml EPPENDORF reaction tubes filled up beforehand with 0.4 or 0.5 ml of enzyme solution. The degree of synergism of cellulases resulted from the assay in the range of 300 to 1 300 p.c.     

Studies of the cellulolytic system of Trichoderma reesei QM 9414. Analysis of domain function in two cellobiohydrolases by limited proteolysis

Limited action of papain on the native forms of two cellobiohydrolases (CBH) from Trichoderma reesei (CBH I, 65 kDa, and CBH II, 58 kDa) leads to the isolation of the respective core fragments (56 kDa and 45 kDa) which are fully active on small, soluble substrates, but have a strongly reduced activity (respectively 10% and 50% of the initial value) on microcrystalline cellulose (Avicel). By partial sequencing at the C terminus of the CBH I core and at the N terminus of the CBH II core the papain cleavage sites have been assigned in the primary structures (at about residue 431 and 82 respectively). This limited action of papain on the native enzymes indicates the presence of hinge regions linking the core to these terminal glycopeptides. The latter conserved sequences appear either at the C or N terminus of several cellulolytic enzymes from Trichoderma reesei [Teeri et al. (1987) Gene 51, 43-52]. The specific activities of the intact enzymes and their cores on two forms of insoluble cellulose (crystalline, amorphous) differentiate the CBH I and CBH II in terms of adsorption and catalytic properties. Distinct functions can be attributed to the terminal peptides: for intact CBH II the N-terminal region contributes in the binding onto both cellulose types; the homologous C-terminal peptide in CBH I, however, only affects the interaction with microcrystalline cellulose. It could be inferred that CBH I and its core bind preferentially to crystalline regions. This seems to be corroborated by the results of CBH I/CBH II synergism experiments.     

A mitogen-activated protein kinase pathway modulates the expression of two cellulase genes in Cochliobolus heterostrophus during plant infection

Conserved eukaryotic signaling elements play an important role in the development of fungal pathogens on their hosts. Chk1, a mitogen-activated protein kinase (MAPK), functions in virulence, mating, and sporulation of the maize leaf pathogen Cochliobolus heterostrophus. Suppression subtractive hybridization was used to identify fungal genes whose expression on the host plant is affected in chk1 deletion mutants. Two of the genes isolated in this screen were predicted to encode cellulolytic enzymes: a cellobiohydrolase, CBH7, and an endoglucanase, EG6. Expression of EG6 and CBH7 was followed by the fusion of their upstream regulatory regions to the coding sequence of the green fluorescent protein. Induction of both genes began at the onset of invasive growth and reached its maximal extent during leaf necrosis. Furthermore, EG6 was induced preferentially within necrotic lesions. Disruption of MAPK CHK1 resulted in a delay in the penetration of hyphae into the leaf and a concomitant delay in the induction of expression of both cellulase genes. In saprophytic culture, the absence of Chk1 resulted in a marked delay in the induction of CBH7 expression by crystalline cellulose. EG6 was expressed at a basal level in culture, and this expression was found to depend strictly on Chk1. Thus, the Chk1 MAPK signaling pathway is involved in the regulation of two cellulase-encoding genes and is necessary for their timely induction by environmental signals.     

纤维二糖脱氢酶的纤维素降解中的作用研究

裂褶菌纤维二糖脱氢酶（ｃｅｌｌｏｂｉｏｓｅ ｄｅｈｙｄｒｏｇｅｎａｓｅ,ＣＤＨ）可以提高纤维素酶对纤维素的降解。以纤维二糖为电子供体,ＣＤＨ作用于羧甲基纤维可降低其溶液的粘度,作用纤维素ＣＦ１１和磷酸膨胀纤维素,分别使其悬浊液的浊度提高７％和１４．４％。ＣＤＨ与纤维二糖水解酶或切纤维素酶在降解棉花纤维素时没有表现出协同作用。但若棉花事先在纤维二糖存在下用ＣＤＨ预处理,则变得易于被水解。     

A synergistic kinetics model for enzymatic cellulose hydrolysis compared to degree-of-synergism experimental results

It is demonstrated that a two-enzyme component synergistic model can account for the observation that the degree of synergism goes through a maximum as the total enzyme concentration is increased. The degree of synergism is low at low enzyme concentration because the extent of conversion is low and therefore the cellulose chain ends, present originally, are not exhausted; thus the action of the cellobiohydrolase (CBH) is not dependent on the chain ends generated by the endoglucanase (EG). The degree of synergism declines at high enzyme concentration due to saturation of adsorption sites with CBH, thus decreasing the generation of chain ends by EG. (c) 1993 John Wiley & Sons, Inc.