Characteristics of protease synthesis in Bacteroides splanchnicus NCTC 10825

Studies to determine the physiological and nutritional characteristics of protease synthesis by Bacteroides splanchnicus NCTC 10825 showed that the proteases were constitutive and cell-associated during exponential growth in batch culture. As growth slowed and the bacteria entered the stationary phase, proteases that had accumulated intracellularly were released into the culture media. In continuous cultures, [dilution rate (D)=0.03 h^–1 to D=0.29 h^–1], protease activity was completely cell-bound and maximal during nitrogen-limited growth at high dilution rates. The proteases hydrolysed a relatively restricted range of protein substrates including casein, azocasein and gelatine (comparative maximum rates of hydrolysis were 1.0, 4.1 and 2.7 units mg^–1 protein respectively). B. splanchnicus proteases exhibited arylamidase activities against leucine p-nitroanilide, valylalanine p-nitroanilide and glycylproline p-nitroanilide. Inhibition experiments indicated that the bacterium produced a mixture of serine, thiol and, possibly, metalloproteases. Protease activities were affected by reducing agents and divalent metal ions. Mercaptoethanol at 1 mm was slightly stimulatory; however, dithiortheitol and dithioerythritol (each 10 mm) respectively inhibited protease activities by 91% and 100%. Calcium ions (5 mm) stimulated protease activity by 30%, whereas Mn²⁺ and Mg²⁺ had little or no effect. Protease and arylamidase activities had neutral to alkaline pH optima. Together, these results show that with respect to the types of protease formed and the physiology of the process, B. splanchnicus proteolysis is similar in many respects to that occurring in species belonging to the B. fragilis group. Correspondence to: G. T. Macfarlane     

Aerobic nitrate and nitrite reduction in continuous cultures of Escherichia coli E4

Nitrate and nitrite was reduced by Escherichia coli E4 in a l-lactate (5 mM) limited culture in a chemostat operated at dissolved oxygen concentrations corresponding to 90–100% air saturation. Nitrate reductase and nitrite reductase activity was regulated by the growth rate, and oxygen and nitrate concentrations. At a low growth rate (0.11 h^–1) nitrate and nitrite reductase activities of 200 nmol · mg^–1 protein · min^–1 and 250 nmol · mg^–1 protein · min^–1 were measured, respectively. At a high growth rate (0.55 h^–1) both enzyme activities were considerably lower (25 and 12 nmol mg^–1 · protein · min^–1). The steady state nitrite concentration in the chemostat was controlled by the combined action of the nitrate and nitrite reductase. Both nitrate and nitrite reductase activity were inversely proportional to the growth rate. The nitrite reductase activity decreased faster with growth rate than the nitrate reductase. The chemostat biomass concentration of E. coli E4, with ammonium either solely or combined with nitrate as a source of nitrogen, remained constant throughout all growth rates and was not affected by nitrite concentrations. Contrary to batch, E. coli E4 was able to grow in continuous cultures on nitrate as the sole source of nitrogen. When cultivated with nitrate as the sole source of nitrogen the chemostat biomass concentration is related to the activity of nitrate and nitrite reductase and hence, inversely proportional to growth rate.     

Effect of culture conditions on astaxanthin production by a mutant of Phaffia rhodozyma in batch and chemostat culture

Temperature and pH had only a slight effect on the astaxanthin content of a Phaffia rhodozyma mutant, but influenced the maximum specific growth rate and cell yield profoundly. The optimum conditions for astaxanthin production were 22°C at pH 5.0 with a low concentration of carbon source. Astaxanthin production was growth-associated, and the volumetric astaxanthin concentration gradually decreased after depletion of the carbon source. The biomass concentration decreased rapidly during the stationary growth phase with a concomitant increase in the cellular content of astaxanthin. Sucrose hydrolysis exceeded the assimilation rates of D-glucose and D-fructose and these sugars accumulated during batch cultivation. D-Glucose initially delayed D-fructose uptake, but D-fructose utilization commenced before glucose depletion. In continuous culture, the highest astaxanthin content was obtained at the lowest dilution rate of 0.043 h^–1. The cell yield reached a maximum of 0.48 g cells·g^–1 glucose utilized between dilution rates of 0.05 h^–1 and 0.07 h^–1 and decreased markedly at higher dilution rates. Correspondence to: J. C. Du Preez     

Invertase and phosphatase of yeast in a phosphate-limited continuous culture

Summary Deficiency of inorganic phosphate caused the hyper production of invertase and the derepression of acid phosphatase in a continuous culture ofSaccharomyces carlsbergensis. The specific invertase activity was 40,000 enzyme units per g dry cell weight at a dilution rate lower than 0.05 h^–1 with a synthetic glucose medium of which the molecular ratio of KH₂PO₄ to glucose was less than 0.006. This activity is eight fold higher than in a batch growth and 1.5 fold as much as the highest enzyme activity observed so far in a glucose-limited continuous culture.For the hyper production of invertase, it is necessary to culture the yeast continuously by keeping the Nyholm's conservative inorganic phosphate concentration at less than 0.2 m mole per g dry weight cell. The derepression of acid phosphatase brought about by phosphate deficiency, was similar in both batch and continuous cultures.Nomenclature D dilution rate of continuous culture (h^–1) - E_i invertase concentration in culture (enzyme unit l^–1) - E_p acid phosphatase concentration in culture (enzyme unit l^–1) - P inorganic phosphate concentration in culture (mM) - S glucose concentration in culture (mM) - X cell concentration in culture (g dry weight cell l^–1) Greek Letter specific rate of growth (h^–1) Suffix f feed - 0 initial value     

Anaerobic degradation of p-cresol in batch and continuous cultures by a denitrifying bacterial consortium

Summary The anaerobic degradation of p-cresol under denitrifying conditions by a bacterial consortium was studied in batch and continuous cultures. Concentrations up to 3 mm were degraded within 5–6 days with 4-hydroxybenzyl alcohol, 4-hydroxybenzaldehyde and 4-hydroxybenzoate as intermediates. Steady states could be maintained at only one dilution rate, D=0.04 h^–1. A further increase in the dilution rate to 0.0 8 h^–1 resulted in culture wash-out. An estimation of the Saturation constant was made (<1 mg/l), taking the maximum specific growth rate as 0.045 h^–1, thus yielding a value of 0.125 mg p-cresol/l. Correspondence to: N. Khoury     

Effect of pH and acetic acid on growth and 2,3-butanediol production of Enterobacter aerogenes in continuous culture

Summary The effect of pH and acetic acid on growth and 2,3-butanediol production of Enterobacter aerogenes from glucose was investigated in a microaerobic continuous culture. At a dilution rate of 0.20 h^–1 and a fixed oxygen uptake rate (OUR) of 31.5 mmol l^–1 h^–1 the biomass concentration increased with pH ranging from 5.0 to 7.0, while the specific ATP requirement of the cells decreased. In the pH range 5.5–6.5 the product concentration (butanediol + acetoin) was maximal and nearly constant. However, the specific production continuously declined with increasing pH. Experiments with addition of acetic acid showed that the various effects of pH are due to inhibition of the by-product acetic acid on cell growth. The strength of the acetic and inhibition depended only on the concentration of its undissociated form [HAc]. The biomass concentration and the specific OUR were also only functions of [HAc], irrespective of the pH. Although the specific ATP requirement (q ATP) strongly depended on the pH, [HAc] at constant pH. Offprint requests to: W.-D. Deckwer     

Anaerobic degradation of phenol in batch and continuous cultures by a denitrifying bacterial consortium

Summary The anaerobic degradation of phenol under denitrifying conditions by a bacterial consortium was studied both in batch and continuous cultures. Anaerobic degradation was dependent on NO_f3 ^p– and concentrations up to 4 mm phenol were degraded within 2–5 days. During continuous growth in a fermenter, steady states could be maintained at eight dilution rates (D) corresponding to residence times between 12.5 and 50 h. Culture wash-out occurred at D=0.084 h^–1. The kinetic parameters obtained for anaerobic degradation of phenol under denitrifying conditions by the consortium were: maximam specific growth rate = 0.091 h^–1; saturation constant = 4.91 mg phenol/l; true growth yield = 0.57 mg dry wt/mg phenol; maintenance coefficient = 0.013 mg phenol/mg dry wt per hour. The Haldane model inhibition constant was estimated from batch culture data giving a value of 101 mg/l. The requirement of CO₂ for the anaerobic degradation of phenol with NO_f3 ^p– indicates that phenol carboxylation to 4-hydroxybenzoate was the first step of phenol degradation by this culture. 4-Hydroxybenzoate, proposed as an intermediate of phenol carboxylation under these conditions, was detected only in continuous cultures at very low growth rates (D=0.02 h^–1), but was never detected as a free intermediary metabolite either in batch or in continuous cultures. Correspondence to: N. Khoury     

Limitation of growth and lactic acid production in batch and continuous cultures of Lactobacillus helveticus

Summary Continuous and batch cultures of Lactobacillus helveticus operated under different conditions were studied with respect to the limitation of growth and lactic acid production by increasing undissociated lactic acid and hydrogen ion concentrations, respectively. In a single-stage continuous culture without pH control a final pH of 3.8 and 65 mm undissociated lactic acid was obtained. In two-stage continuous cultures provided with different growth media and run at different pH values, 65–70 mm free acid was obtained in the second stage. Further batch-culture experiments showed growth limitation at 60–70 mm lactic acid. After growth ceased, production of lactate continued until a lactic acid concentration of about 100 mm was reached; obviously an uncoupling of growth and acid production had occurred. Examining the effect of different concentrations of either lactic acid or hydrochloric acid, added to growing batch cultures of L. helveticus, it was shown that the undissociated lactic acid concentration was responsible for growth limitation and lactic acid production in this organism, whereas the pH value had only an indirect effect.     

Inhibition of yeast by lactic acid bacteria in continuous culture: nutrient depletion and/or acid toxicity?

Lactic acid was added to batch very high gravity (VHG) fermentations and to continuous VHG fermentations equilibrated to steady state with Saccharomyces cerevisiae. A 53% reduction in colony-forming units (CFU) ml^–1 of S. cerevisiae was observed in continuous fermentation at an undissociated lactic acid concentration of 3.44% w/v; and greater than 99.9% reduction was evident at 5.35% w/v lactic acid. The differences in yeast cell number in these fermentations were not due to pH, since batch fermentations over a pH range of 2.5–5.0 did not lead to changes in growth rate. Similar fermentations performed in batch showed that growth inhibition with added lactic acid was nearly identical. This indicates that the apparent high resistance of S. cerevisiae to lactic acid in continuous VHG fermentations is not a function of culture mode. Although the total amount of ethanol decreased from 48.7 g l^–1 to 14.5 g l^–1 when 4.74% w/v undissociated lactic acid was added, the specific ethanol productivity increased ca. 3.2-fold (from 7.42×10^–7 g to 24.0×10^–7 g ethanol CFU^–1 h^–1), which indicated that lactic acid stress improved the ethanol production of each surviving cell. In multistage continuous fermentations, lactic acid was not responsible for the 83% (CFU ml^–1) reduction in viable S. cerevisiae yeasts when Lactobacillus paracasei was introduced to the system at a controlled pH of 6.0. The competition for trace nutrients in those fermentations and not lactic acid produced by L. paracasei likely caused the yeast inhibition.     

The isolation and characterisation of a salicylate-hydroxylase-producing strain of Pseudomonas putida

Summary A salicylate-hydroxylase-producing strain of Pseudomonas putida with an unusual capability to grow at toxic levels of salicylate up to 10 g l^–1 has been isolated. It grew well under continuous culture conditions, with optimum growth at pH 6.5 and a temperature of 25° C. The use of an ammonium salt as a nitrogen source, instead of nitrate, resulted in a 30–40% increase in its biomass yield coefficient. Optimum growth under continuous culture conditions was achieved using 4 g l^–1 salicylate at 25° C, pH 6.5 and 0.2 h^–1 dilution rate. High salicylate hydroxylase enzyme activity [236 units (U) l^–1] and productivity (424.8 U h^–1) were obtained at a dilution rate of 0.45 h^–1 using a mineral medium containing 4 g l^–1 of salicylate. Operating under continuous culture conditions with oxygen limitation and a slight accumulation of residual salicylate (0.2 g l^–1) resulted in a decrease in culture performance and enzyme productivity. Correspondence to: R. Marchant     

Physiological aspects of l-lysine production: effect of nutritional limitations on a producing strain of Corynebacterium glutamicum

The effect of nutritional limitations, such as phosphorus and carbon, on the production of l-lysine by Corynebacterium glutamicum was studied in continuous culture. We observed that phosphate-limited cultures at low growth rates were favourable to l-lysine production. l-Lysine was produced when a culture at low dilution rate (0.03 h^–1) was established. A dilution rate of about 0.04 h^–1 should be maintained in order to assure good productivity and an l-lysine yield of 0.53 g/g. Under carbon-limiting conditions the maintenance energy and growth yield of 0.03 g/g·g^–1·h^–1 and 0.41 g/g, respectively, have been obtained. Under these limiting conditions the l-lysine production was not favoured even at lower dilution rates.Correspondence to: N. Coello     

A repeated batch process for cultivation of <Emphasis Type="Italic">Bifidobacterium longum</Emphasis>

A repeated batch process was performed to culture Bifidobacterium longum CCRC 14634. An on-line device, oxidation-reduction potential (ORP), was used to monitor cell growth and uptake of nutrients in the culture. The ORP of the culture medium decreased substantially during fermentation until nutrients were depleted. Six cycles of batch fermentation using ORP as a control parameter were successfully carried out. As soon as ORP remained constant or increased, three-quarters of the broth was removed, and the same volume of fresh medium was fed to the fermenter for a new cycle of cultivation. Average cell concentrations of 1.9×10⁹ and 3.4×10⁹ cfu ml^–1 for repeated batch fermentation in MRS (Lactobacilli MRS broth) and WY (containing whey hydrolyzates, yeast extract, l-cysteine) medium, respectively, were achieved. Cell mass productivities for batch, fed-batch and repeated batch fermentation using MRS medium were 0.51, 0.41, and 0.64 g l^–1 h^–1, respectively, and those for batch and repeated batch using WY medium were 0.76, 0.99 g l^–1 h^–1, respectively. The results indicate a possible industrial process to culture Bifidobacteria sp.     

Regulation of a mixed culture of Streptococcus lactis and Saccharomycopsis fibuliger

Summary In a mixed culture of Saccharomycopsis fibuliger Y76 and Streptococcus lactis 65.1 on starch the main interactions are commensalism and competition. Oxygen-limited batch and continuous cultures of S. fibuliger showed accumulation of sugars. When oxygen was used as an external regulatory parameter in the mixed culture lactic acid, acetic acid and formic acid were formed. Ethanol produced by S. lactis was most likely assimilated by S. fibuliger. Continuous mixed cultures were stable under conditions of oxygen limitation at the dilution rates tested (0.10 h^–1 and 0.15 h^–1). Conversion yields of 35 to 40% were obtained but may be improved.     

The production of lactic acid from whey permeate byLactobacillus helveticus

Summary The effect of pH on growth and lactic acid production ofLactobacillus helveticus was investigated in a continuous culture using supplemented whey ultrafiltrate. Maximum lactate productivity of 5 gl^–1h^–1 occurred at pH 5.5. Whey permeates concentrated up to four times were fermented using batch cultures. Maximum lactic acid concentration of 95 gl^–1 was attained, but residual sugars indicated a possible limitation in growth factors.Nomenclature D Dilution rate [h^–1] - X Biomass [gl^–1] - Glu Glucose consentration [gl^–1] - Gal Galactose consentration [gl^–1] - S Substrate, Lactose consentration [gl^–1] - P Product, Lactate consentration [gl^–1] - Y_p/s Yield, defined as P/S [gg^–1] - r_i Rate of synthesis or consumption of i [gl^–1h^–1]     

High cell density cultivation of Brevibacterium linens and formation of proteinases and lipase

Brevibacterium linens forms hydrolytic enzymes which can be used to accelerate the ripening of cheese without causing bitterness. B. linens ATCC 9172 was grown to a high cell density (50 g dry wt l^–1 after 60 h) in a mineral medium containing lactic acid, soy-peptone and ammonium sulphate by applying a continuous feed of nutrients. The maximal activities of l-leucine aminopeptidase and cell-associated proteinase were 286 U l^–1 and 202 U l^–1, respectively. The cell-associated lipolytic activity exhibited a strong and sudden increase at 46 h, resulting in a maximum of 9.5 U g^–1 dry wt; thus the volumetric productivity of proteolytic and lipolytic activity was 4220 U l^–1 h^–1 and 7.3 U l^–1 h^–1, respectively.     

Interactions in a mixed culture composed of Cellulomonas flavigena and Xanthomonas sp. growing in continuous culture on sugar cane bagasse

A mixed culture formed by Cellulomonas flavigen and Xanthomonas sp. was able to grow in continuous culture in a medium with sugar cane bagasses as carbon source without additional growth factors. The effect of temperature, pH and dilution rate (D) upon the microbial population ratio and biomass composition was studied. Both microorganisms co-existed between 30 and 40° C, at pH 5.8–7.0 and D = 0.04–0.11 h^–1. Correspondence to: T. Ponce-Noyola     

d(−)lactic acid production by suspended and aggregated continuous cultures of Bacillus laevolacticus

Summary A new method of d(–)lactic acid production based on the aggregated form of growth of Bacillus laevolacticus in continuous culture in an anaerobic gaslift reactor is presented. With glucose as the substrate a bacterial dry weight of 25 g·1^–1 and a lactic acid production rate of 13 g·1^–1·h^–1 was attained. In conventional glucose-limited chemostat cultures elevated levels of lactic acid stimulated specific lactic acid production while the formation rates of other end-products remained unaffected. In glucose-limited aggregated cultures lactic acid positively influenced the aggregation of cells, improving the volumetric production rate. It is concluded that lactic acid itself is a positive effector in the optimisation of lactic acid production with aggregated cultures of B. laevolacticus.Offprint requests to: J. P. de Boer     

Growth characteristics and oxidative capacity of<Emphasis Type="Italic"> Acetobacter aceti</Emphasis> IFO 3281: implications for <Emphasis Type="SmallCaps">l</Emphasis>-ribulose production

We studied the growth characteristics and oxidative capacities of Acetobacter aceti IFO 3281 in batch and chemostat cultures. In batch culture, glycerol was the best growth substrate and growth on ethanol occurred only after 6 days delay, although ethanol was rapidly oxidized to acetic acid. In continuous culture, both glycerol and ethanol were good growth substrates with similar characteristics. Resting cells in a bioreactor oxidized ribitol to l-ribulose with a maximal specific rate of 1.2 g g^–1 h^–1). The oxidation of ribitol was inhibited by ethanol but not by glycerol. Biomass yield (Y_SX; C-mmol/C-mmol) on ethanol and glycerol was low (0.21 and 0.17, respectively). In the presence of ribitol the yield was somewhat higher (0.25) with ethanol but lower (0.13) with glycerol, with respectively lower and higher CO₂ production. In chemostat cultures the oxidation rate of ribitol was unaffected by ethanol or glycerol. Cell-free extract oxidized ethanol very slowly but not ribitol; the oxidative activity was located in the cell membrane fraction. Enzymatic activities of some key metabolic enzymes were determined from steady-state chemostat with ethanol, glycerol, or ethanol/glycerol mixture as a growth limiting substrate. Based on the measured enzyme activities, metabolic pathways are proposed for ethanol and glycerol metabolism.     

Fermentation of glycerol to 1,3-propanediol in continuous cultures of Citrobacter freundii

The conversion of glycerol to 1,3-propanediol by Citrobacter freundii DSM 30040 was optimized in single- and two-stage continuous cultures. The productivity of 1,3-propanediol formation was highest under glycerol limitation and increased with the dilution rate (D) to a maximum of 3.7 g·l^–1·h^–1. Glycerol dehydratase seemed to be the rate-limiting step in 1,3-propanediol formation. Conditions for the two-stage fermentation process were as follows: first stage, glycerol limitation (250mM), pH 7.2, D=0.1 h^–, 31° C; second stage, additional glycerol, pH 6.6, D=0.05 h^–1, 28° C. Under these conditions 875mM glycerol were consumed, the final 1,3-propanediol concentration was 545mM, and the overall productivity 1.38 g·1^–1·h^–1. Correspondence to: G. Gottschalk     

Phosphatase activity ofPenicillium citrinum submerged batch cultures and its relationship to fungal activity

Acid and alkaline phosphatase activities were evaluated using batch fermenter cultues ofPenicillium citrinum, an organism used in studies of fungal functioning in soil. Fungal activity was assessed by monitoring rates of O₂ utilization, glucose utilization, dry weight changes over time, and lengths of FDA-stained hyphae. At low growth rates (7 g dry wt increases·h^–1·ml^–1) and low culture activity, phosphatase activity at both pH 8.5 and 5.5 tended to decrease with culture age, with the exception that phosphatase activity at pH 8.5 peaked during early stationary phase. At higher growth rates (25 g dry wt increase·h^–1·ml^–1) and high culture activity, phosphatase activity tended to remain constant throughout the course of the experiment. The relationship between phosphatase activity and other measures of fungal activity was consistent only at low growth rates for acid phosphatase. These results suggest that phosphatase measurements will be of limited utility in assessing activity, except at low growth rates.