Coupling of glucose oxidase and Fenton's reaction for a simple and inexpensive assay of β-glucosidase

A simple and inexpensive assay for β-glucosidase, based on the coupling of glucose oxidase and Fenton's reagent has been described. Hydrogen peroxide formed as a result of the action of glucose oxidase on glucose (derived from the action of β-glucosidase on cellobiose) oxidizes ferrous sulphate, resulting in an increase in absorbance. The oxidation products produced a peak of maximum absorbance at 340 nm. Using this assay system, a linear relationship between glucose concentration in the range 5.55–27.78 mmol l^?1(100–500 mg dl^?1) and absorbance was obtained, indicating conformity to Beer's law. The preciseness of the glucose oxidase/Fenton's reagent for the assay of glucose was shown to be satisfactory. β-Glucosidase was assayed using the hexokinase assay reagent and the glucose oxidase/ferrous sulphate reagent. The values obtained using both reagents did not differ significantly. Although 2.6 times less sensitive than the hexokinase reagent when absorbance is measured at 340 nm, the glucose oxidase/Fenton's reagent is 10 times cheaper and could be used satisfactorily for routine assays of β-glucosidase and other carbohydrases including cellulase and amylase. In this respect, fructose, mannose, xylose, sucrose and cellobiose did not affect the sensitivity of the reagent. Of several metals tested, only aluminium interfered with the reagent, decreasing its sensitivity.     

Products of enzymatic hydrolysis of cellulose and its derivatives

Cellobiose and glucose were determined in a mixture of the two carbohydrates by methods involving the use of glucose oxidase and of β-glucosidase.Paper-partition chromatography is used as a confirmatory method in the identification of the hydrolysis products and in the detection of the various constituents.The cellulolytic organisms studied produce large amounts of the enzyme Cx, which diffuses into the medium. Only small amounts of β-glucosidase are found outside the cell. Cellobiose resulting from Cx activity can enter the cells as rapidly as can glucose.The role of cellobiose as a principal product in the hydrolysis of cellulose is confirmed. It is hypothesized that the principal final product of Cx activity is cellobiose, and that the presence of cellobiase in the medium is not a prerequisite to utilization of cellobiose by the organism. This is a correction of the hypothesis previously published stating that glucose appeared to be the final product of Cx activity.     

Cellobiose metabolism and cellobiohydrolase I biosynthesis by Trichoderma reesei

The relationship between β-linked disaccharide (cellobiose, sophorose) utilization and cellulase, particularly cellobiohydrolase I (CBH I) synthesis by Trichoderma reesei, was investigated. During growth on cellobiose and sophorose as carbon sources in batch as well as resting-cell culture, only sophorose induced cellulase formation. In the latter experiments, sophorose was utilized at a much lower rate than cellobiose, and the more cellulase produced, the lower its rate of utilization. Cellobiose and sophorose were utilized by the fungus mainly via hydrolysis by the cell wall- and cell membrane-bound β-glucosidase. Addition of sophorose to T. reesei growing on cellulose did not further stimulate cellulase synthesis, and addition of cellobiose was inhibitory. Cellobiose, however, promoted cellulase formation in both batch and resting cell cultures, when its hydrolysis by β-glucosidase was inhibited by nojirimycin. No cellulase formation was observed when the uptake of glucose (produced from cellobiose by β-glucosidase) was inhibited by 3-O-methylglucoside. Cellodextrins (C₂ to C₆) promoted formation of low levels of cellobiohydrolase I in indirect proportion to their rate of hydrolysis by β-glucosidase. Studies on the uptake of [³H]cellobiose, [³H]sophorose, and [¹⁴C]glucose in the presence of inhibitors of β-glucosidase (nojirimycin) and glucose transport (3-O-methylglucoside) show that glucose transport occurs at a much higher rate than disaccharide hydrolysis. Extracellular disaccharide hydrolysis accounts for at least 95% of their metabolism. The presence of an uptake system for cellobiose was established by demonstrating the presence of intracellular labeled [³H]cellobiose in T. reesei after its extracellular supply. The data are consistent with induction of cellulase and particularly CBH I formation in T. reesei by β-linked disaccharides under conditions where their uptake is favored at the expense of extracellular hydrolysis.     

L(+) Lactate production from carbohydrates and lignocellulosic materials by Rhizopus oryzae UMIP 4.77

The lactate excretion by Rhizopus oryzae on various carbohydrates was studied in order to assess the potential of lactate production from raw materials. Six collection strains were tested on ten commercial carbohydrates i.e. glucose, xylose, glycerol, sucrose, lactose, cellobiose, inulin, starch, cellulose and fructose in flask or stirred-tank bioreactor. On glucose and xylose, lactate was produced by R. oryzae UMIP 4.77 at 73 and 8 gL^?1 respectively, indicating that lignocellulosic materials could be used as possible raw substrates. Two lignocellulosic substrates were therefore experimented in stirred-tank bioreactor with R. oryzae UMIP 4.77. The first one was hemicellulosic material, which is a concentrated C6 and C5 sugar solution resulting from washing of a steamed wheat straw sample. The second was cellulosic material, which is a partially-hydrolyzed unbleached pulp paper. In a simultaneous saccharification fermentation process, a final production of 24.1 gL^?1 of lactate was obtained from cellulosic material.     

Characterization of a novel β-glucosidase from a Stachybotrys strain

An improved mutant was isolated from the cellulolytic fungus Stachybotrys sp. after nitrous acid mutagenesis. It was fed-batch cultivated on cellulose and its extracellular cellulases (mainly the endoglucanases and β-glucosidases) were analyzed. One β-glucosidase was purified to homogeneity after two steps, MonoQ and gel filtration and shown to be a dimeric protein. The molecular weight of each monomer is 85 kDa. Besides its aryl β-glucosidase activity towards salicin, methyl-umbellypheryl-β-d-glucoside (MUG) and p-nitrophenyl-β-d-glucoside (pNPG), it showed a true β-glucosidase activity since it splits cellobiose into two glucose monomers. The V_max and the K_m kinetics parameters with pNPG as substrate were 78 U/mg and 0.27 mM, respectively. The enzyme shows more affinity to pNPG than cellobiose and salicin whose apparent values of K_m were, respectively, 2.22 and 37.14 mM. This enzyme exhibits its optimal activity at pH 5 and at 50 °C. Interestingly, this activity is not affected by denaturing gel conditions (SDS and β-mercaptoethanol) as long as it is not pre-heated. The N-terminal sequence of the purified enzyme showed a significant homology with the family 1 β-glucosidases of Trichoderma reesei and Humicola isolens even though these two enzymes are much smaller in size.     

Characterization of a recombinant cellobiose 2-epimerase from Dictyoglomus turgidum that epimerizes and isomerizes β-1,4- and α-1,4-gluco-oligosaccharides

A recombinant putative N-acyl-d-glucosamine 2-epimerase from Dictyoglomus turgidum was identified as a cellobiose 2-epimerase by evaluating its substrate specificity. The purified enzyme was a 46?kDa monomer with a specific activity of 16.8?μmol?min^?1?mg^?1 for cellobiose. The epimerization activity was maximal at pH 7.0 and 70?°C with a half-life of 55?h. The isomerization of the glucose at the reducing end of β-1,4- and α-1,4-linked gluco-oligosaccharides to a fructose moiety by the enzyme took place after the epimerization of the glucose to a mannose moiety. The enzyme converted cellobiose to 12.8?% 4-O-β-d-glucopyranosyl-d-mannose and 54.6?% 4-O-β-d-glucopyranosyl-d-fructose as an equilibrium and converted lactose to 12.8?% epilactose and 54.3?% lactulose.     

Isolation and some properties of two extracellular β-glucosidases from Trichosporon adeninovorans

The yeast Trichosporon adeninovorans secretes two multiple forms of β-glucosidase at a high rate if grown in a medium containing cellobiose. Following mutagenesis a mutant strain resistant to 2-deoxy-D-glucose was selected. This strain produced more β-glucosidase activity and had acquired a strong resistance against repression by glucose. The β-glucosidases were separated one from each other by chromatography on hydroxylapatite and by gel filtration. Both enzymes have similar properties. The optimal temperature for their activity was 60 to 63°C and the enzymes displayed highest activity at pH of 4.5. The molecular weight of β-glucosidase I was found to be 570,000 and that for β-glucosidase II was 525,000. The K_m value for cellobiose was determined to be 4.1 mM for β-glucosidase I and 3.0 mM for β-glucosidase II.     

Purification and Characterization of two Extracellular β-Glucosidases from Trichoderma viride ITCC 1433

T. viride ITCC 1433 synthesizes a two component system for the hydrolysis of cellobiose and cellooligodextrins. 80% of the total activity are solubilized during growth. The large protein (A), mol. weight 98 000 d, is glycosylated and slightly acidic (pH = 6.1). The smaller protein (B), mol. weight 70 000 d, is unglycosylated and neutral (pH = 7.2). Both proteins form a two-step system where β-glucosidase A is active at low substrate concentrations (K_M = 2.3 × 10^?4 M cellobiose) while β-glucosidase B covers the range of 10-fold higher cellobiose concentrations (K_M = 1.8 × 10^?3 M). The enzymes are fairly stable with a residual activity of 70% at 50°C after 24 h.     

Purification, characterization, and properties of beta-glucosidase enzymes from Sclerotium rolfsii

Four β-glucosidase enzymes were extensively purified from the culture filtrates of Sclerotium rolfsii and some of their physicochemical properties studied. All the enzymes showed a single protein band in sodium dodecyl sulfate-gel electrophoresis and in disc gel electrophoresis at pH 8.9 and 4.3. The purified β-glucosidases were free of endoglucanase (carboxymethyl cellulose viscosity-lowering activity). All the enzymes are glycoproteins and are composed of one polypeptide chain. The molecular weight of the four β-glucosidases varies between 90,000 and 107,000. The pH and temperature optima of the four β-glucosidases are 4.2 and 68 °C with p-nitrophenyl-β-d-glucoside and 4.5 and 65 °C with cellobiose as substrate. The isoelectric points for the enzymes are 4.10, 4.55, 5.10, and 5.55, respectively. The specific activities of the enzymes with cellobiose as substrate are 55, 78, 175, and 51 μmol glucose released per minute per milligram protein, respectively. The enzymes are inhibited by the reaction product glucose, and by glucono-δ-lactone and nojirimycin. A carboxylate group is implicated in the catalysis of β-glucosidase.     

An enzymic fluorometric micro method for determination of glycoen

A sensitive and rapid micro determination of glycogen in biological samples has been described. The method is fluoro-enzymic and is based on the conversion of glycogen to 6-phosphogluconate with the enzymes amylo-α-1,4-α-1,6-glucosidase, hexokinase, and glucose-6-phosphate dehydrogenase. The increase in NADPH is measured fluorometrically. As little as 200 ng of glycogen can be determined.     

Purification and biochemical characterization of a mycelial glucose- and xylose-stimulated β-glucosidase from the thermophilic fungus Humicola insolens

A mycelial β-glucosidase from the thermophilic mold Humicola insolens was purified and biochemically characterized. The enzyme showed carbohydrate content of 21% and apparent molecular mass of 94 kDa, as estimated by gel filtration. Sodium dodecyl sulfate polyacrylamide gel electrophoresis analysis showed a single polypeptide band of 55 kDa, suggesting that the native enzyme was a homodimer. Mass spectrometry analysis showed amino acid sequence similarity with a β-glucosidase from Humicola grisea var. thermoidea, with about 22% coverage. Optima of temperature and pH were 60 °C and 6.0–6.5, respectively. The enzyme was stable up to 1 h at 50 °C and showed a half-life of approximately 44 min at 55 °C. The β-glucosidase hydrolyzed cellobiose, lactose, p-nitrophenyl-β-d-glucopyranoside, p-nitrophenyl-β-d-fucopyranoside, p-nitrophenyl-β-d-xylopyranoside, p-nitrophenyl-β-d-galactopyranoside, o-nitrophenyl-β-d-galactopyranoside, and salicin. Kinetic studies showed that p-nitrophenyl-β-d-fucopyranoside and cellobiose were the best enzyme substrates. Enzyme activity was stimulated by glucose or xylose at concentrations up to 400 mM, with maximal stimulatory effect (about 2-fold) around 40 mM. The high catalytic efficiency for the natural substrate, good thermal stability, strong stimulation by glucose or xylose, and tolerance to elevated concentrations of these monosaccharides qualify this enzyme for application in the hydrolysis of cellulosic materials.     

The inhibition of β-glucosidase activity in Trichoderma reesei C30 cellulase by derivatives and isomers of glucose

The inhibition of β-glucosidase in Trichoderma reesei C30 cellulase by D -glucose, its isomers, and derivatives was studied using cellobiose and ρ-nitrophenyl-β-glucoside (PNPG) as substrates for determining enzyme activity. The enzymatic hydrolysis of both substrates was inhibited competitively by glucose with approximate K_i values of 0.5mM and 8.7mM for cellobiose and PNPG as substrate, respectively. This inhibition by glucose was maximal at pH 4.8, and no inhibition was observed at pH 6.5 and above. The α anomer of glucose inhibited β-glucosidase to a greater extent than did the β form. Compared with D -glucose, L -glucose, D -glucose-6-phosphate, and D -glucose-1-phosphate inhibited the enzyme to a much lesser extent, unlike D -glucose-L -cysteine which was almost as inhibitory as glucose itself when cellobiose was used as substrate. Fructose (2?100mM) was found to be a poor inhibitor of the enzyme. It is suggested that high rates of cellobiose hydrolysis catalyzed by β-glucosidase may be prolonged by converting the reaction product glucose to fructose using a suitable preparation of glucose isomerase.     

Components of cellulase from the higher termite,Nasutitermes walkeri

The cellulase from the termite Nasutitermes walkeri consists of two enzymes. Each has broad specificity with predominantly one activity. One enzyme is an endo-gb-1,4-glucanase (EC 3.2.1.4) which predominantly cleaves cellulose randomly to glucose, cellobiose and cellotriose. It hydrolyses cellotetraose to cellobiose but will not hydrolyse cellobiose or cellotriose. The second enzyme component is a β-1,4-glucosidase (EC 3.2.1.21) as its major activity is to hydrolyse cellobiose, cellotriose and cellotetraose to glucose; it has some exoglucosidase activity as glucose is the only product produced from cellulose. Its cellobiase activity is inhibited by glucono-δ-lactone.     

Concomitant production of cellulase and xylanase by thermophilic mould <Emphasis Type="Italic">Sporotrichum thermophile</Emphasis> in solid state fermentation and their applicability in bread making

Sporotrichum thermophile BJAMDU5 secreted high titres of xylanolytic and cellulolytic enzymes in solid state fermentation using mixture of wheat straw and cotton oil cake (ratio 1:1) at 45?°C, pH 5.0 after 72 h inoculated with 2.9?×?10⁷ CFU/mL conidiospores. Supplementation of solid medium with lactose and ammonium sulphate further enhanced the production of hydrolytic enzymes. Among different surfactants studied, Tween 80 enhanced the production of all enzymes [3455 U/g DMR (dry mouldy residue), 879.26 U/g DMR, 976.28 U/g DMR and 35.10 U/g DMR for xylanase, CMCase (Carboxymethylcellulase), FPase (Filter paper activity) and β-glucosidase, respectively] as compared to other surfactants. Recycling of solid substrate reduced the production of all these enzymes after second cycle. End products analysis by TLC showed the ability of hydrolytic enzymes of S. thermophile to liberate monomeric (xylose and glucose) as well as oligomeric (xylobiose, cellobiose and higher ones) sugars. Supplementation of enzyme resulted in improved nutritional properties of the bread. Formation of oligomeric sugars by xylanase enzyme of S. thermophile BJAMDU5 make it a good candidate in food industry.     

Effects of galactose and glucose on the hydrolysis reaction of a thermostable β-galactosidase from Caldicellulosiruptor saccharolyticus

A recombinant β-galactosidase from Caldicellulosiruptor saccharolyticus was purified with a specific activity of 211 U mg^?1 by using heat treatment and His-trap affinity chromatography. The native enzyme was an 80-kDa trimer with a molecular mass of 240 kDa. Maximum activity was observed at pH 6.0 and 80ºC, and the half-life at 70ºC was 48 h. The enzyme exhibited hydrolytic activity for p-nitrophenyl-β-d-galactopyranoside (pNPGal), oNPGal, or lactose, whereas no activity for p-nitrophenyl-β-d-glucopyranoside (pNPGlu), oNPGlu, or cellobiose. The catalytic residues E150 and E311 of β-galactosidase from C. saccharolyticus were completely conserved in all aligned glycoside hydrolase family 42 β-galactosidases. The results indicated that the enzyme was a β-galactosidase. Galactose uncompetitively inhibited the enzyme. Glucose inhibition of the enzyme was the lowest among β-galactosidases. When 50 g l^?1 galactose was added, the enzyme activity for pNPGal was reduced to 26%. When 400 g l^?1 glucose instead of galactose was added, the activity was reduced to 82%. When adding galactose (200 g l^?1), only 14% of the lactose was hydrolyzed after 180 min. In contrast, the addition of glucose (400 g l^?1) did not affect lactose hydrolysis, and more than 99% of the lactose was hydrolyzed after 120 min.     

Cellulases: Biosynthesis and applications

Strains of Trichoderma, particularly T. reesei and its mutants, are good sources of extracellular cellulase suitable for practical saccharification. They secrete a complete cellulase complex containing endo- and exo-glucanases plus β-glucosidase (cellobiase) which act syngergistically to degrade totally even highly resistant crystalline cellulose to soluble sugars. All strains investigated to date are inducible by cellulose, lactose, or sophorose, and all are repressible by glucose. Induction, synthesis and secretion of the β-glucanase enzymes appear to be closely associated. The composition and properties of the enzyme complex are similar regardless of the strain or inducing substrate although quantities of the enzyme secreted by the mutants are higher. Enzyme yields are proportional to initial cellulose concentration. Up to 15 filter paper cellulase units (20 mg of cellulase protein) per ml and productivities up to 80 cellulase units (130 mg cellulase protein) per litre per hour have been attained on 6% cellulose. The economics of glucose production are not yet competitive due to the low specific activity of cellulase (0.6 filter paper cellulase units/mg protein) and poor efficiency (about 15% of predicted sugar levels in 24 h hydrolyses of 10–25% substrate). As hydrolysis proceeds, the enzyme reaction slows due to increasing resistance of the residue, product inhibition, and enzyme inactivation. These problems are being attacked by use of pretreatments to increase the quantity of amorphous cellulose, addition of β-glucosidase to reduce cellobiose inhibition, and studies of means to overcome instability and increase efficiency of the cellulases. Indications are that carbon compounds derived from enzymatic hydrolysis of cellulose will be used as fermentation and chemical feedstocks as soon as the process economics are favourable for such application.     

Production and secretion of a multifunctional ß-glucosidase by Humicola grisea var. thermoidea: effects of L-sorbose

The effects of L-sorbose on growth, morphology and production of a multifunctional ß-glucosidase by the thermophilic fungus Humicola grisea var. thermoidea were investigated. Sorbose increased the lag phase period 3-fold and drastically altered the morphology of the fungal hyphae. Cellobiose and lactose were good inducers of the enzyme. The addition of 5 % sorbose to cultures containing 1 % cellobiose enhanced the extracellular levels of the ß-glucosidase 3.3-fold with constant cytosolic and cell-wall bound levels, demonstrating stimulation of both enzyme synthesis and secretion. The stimulation of enzyme production by sorbose was dependent on the presence of cellobiose as inducer, since 2- to 3-fold inhibition was observed in lactose and glucose. Production and secretion of phosphatases and endoglucanases was not stimulated by sorbose, which did not affect the subcellular distribution of the ß-glucosidase also. However, it reduced the uptake rates of glucose and cellobiose. Taken together, the results discarded increased non-specific enzyme secretion and/or increased release of the enzyme from the cell-wall as possible molecular mechanisms for the effects of sorbose on the production of the multifunctional ß-glucosidase by H. grisea. An alternative mechanism, based on a prolonged action of cellobiose as inducer associated with a decreased catabolic repression by glucose, was discussed.     

A novel transglycosylating β-galactosidase from Enterobacter cloacae B5

A strain of Enterobacter cloacae B5 producing β-galactosidase with transglycosylation activity was isolated from the soil. Its freeze-thawed cells synthesized galacto-oligosaccharides with a high yield of 55% from 275 g/L lactose at 50 °C for 12 h. A novel β-galactosidase capable of glycosyl transfer was purified from this strain. It was a homotetramer with molecular mass of about 442 kDa. The optimal pH and temperature for hydrolysis activity on o-nitrophenyl-β-d-galactopyranoside (oNPGal) were 6.5–10.5 and 35 °C, respectively. The enzyme showed a wide range of acceptor specificity for transglycosylation and catalyzed glycosyl transfer from oNPGal to various chemicals such as galactose, glucose, fructose, arabinose, mannose, sorbose, rhamnose, xylose, cellobiose, sucrose, trehalose, melibiose, inositol, mannitol, sorbitol and salicin, resulting in novel saccharide yields ranging from 0.8% to 23.5%. A gene encoding the enzyme was cloned and the recombinant enzyme from Escherichia coli had similar transglycosylation activity to the natural enzyme.     

Agricultural wastes as substrates for β-glucosidase production by Talaromyces thermophilus: Role of these enzymes in enhancing waste paper saccharification

In the present study, we investigated a potent extracellular β-glucosidases secreted by the thermophilic fungal strain AX4 of Talaromyces thermophilus, isolated from Tunisian soil samples. This strain was selected referring to the highest thermostability of its β-glucosidases compared to the other fungal isolates. The β-glucosidase production was investigated by submerged fermentation. The optimal temperature and initial pH for maximum β-glucosidase production were 50°C and 7.0, respectively. Several carbon sources were assayed for their effects on β-glucosidase production, significant yields were obtained in media containing lactose 1% (3.0?±?0.36?U/ml) and wheat bran 2% (4.0?±?0.4?U/ml). The combination of wheat bran at 2% and lactose at 0.8% as carbon source enhanced β-glucosidase production, which reached 8.5?±?0.28?U/ml. Furthermore, the β-glucosidase-rich enzymatic juice of T. thermophilus exhibited significant synergism with Trichoderma reesei (Rut C30) cellulases for pretreated waste paper (PWP) hydrolysis. Interestingly, the use of this optimal enzymatic cocktail increased 4.23 fold the glucose yield after saccharification of waste paper. A maximum sugar yield (94%) was reached when using low substrate (2%) and enzyme loading (EC1).     

Production of a highly glucose tolerant β-glucosidase by Paecilomyces variotii MG3: optimization of fermentation conditions using Plackett–Burman and Box–Behnken experimental designs

β-Glucosidases (β-d-glucoside glucohydrolase, 3.2.1.21) are a group of enzymes mainly involved in the hydrolysis of β-glycosidic bonds connecting carbohydrate residues in different classes of β-d glycosides. During cellulose degradation they convert cellobiose and cellooligosaccharides produced by the endo and exoglucanases to glucose. Most of the microbial β-glucosidases are inhibited by glucose. This limits their application in commercial scale cellulose degradation ventures. Solid state fermentation production of a highly glucose tolerant β-glucosidase by a novel isolate of Paecilomyces was optimized using a two step statistical experiment design. In the first step which employed a Plackett–Burman design, the effects of parameters such as moisture, temperature, pH, inoculum concentration, incubation time and different concentrations of (NH₄)₂SO₄, KH₂PO₄, NaCl, peptone and cellobiose were evaluated. The parameters with significant influence on the process were selected and fine tuned in the second step using a Box–Behnken design. The model obtained was validated and a peptone concentration of 2 g/l, inoculum concentration of 1.2 × 10⁶ spores/ml and an incubation period of 96 h were found to be optimum for the maximum production of the enzyme. The optimization resulted in a doubling of the enzyme production by the fungus.