Biodesulfurization of dibenzothiophene by Gordonia sp. AHV-01 and optimization by using of response surface design procedure

A novel desulfurizing bacterium has been isolated from oil-contaminated soils in Khuzestan. The ability for dibenzothiophene desulfurization and its biochemical pathway were investigated. The bacterium was identified as Gordonia sp. AHV-01 (Genbank Accession No HQ607780) by 16S rRNA gene sequencing. HPLC results and Gibb's assay were shown that dibenzothiophene desulfurized via 4S-pathway Maximum growth (0.426 g dry cells/L) and produced 2-hydroxybiphenyl (63.1 microM) were observed at 120 h of cultivation. By using of response surface design procedure the optimization of pH, temperature and rotary shaker round on the desulfurization reaction of isolate AHV-01 were performed. The optimum conditions were determined at pH of 7.0, temperature of 30 degrees C and rotary shaker round of 180 rpm. At these conditions, the dibenzothiophene desulfurization activity was increased and maximum 2-hydroxybiphenyl production was detected 70.29 microM at 96 h. According to these results, Isolate AHV-01 was capable to desulfurize dibenzothiophene via 4S-pathway and likely it can be useful to reduce organic sulfur contents of crude oil.     

一株柴油脱硫菌的分离与鉴定

由最终产物为邻苯基苯酚（2-HBP）的二苯并噻吩（DBT）的4-S代谢途径出发,从被高硫原油污染的土样中分离,纯化得到一株能高效降解DBT的菌株,通过形态学,生理生化试验及16SrDNA基因测序,归类为Mycobacteriumsp．对细菌的培养条件进行研究,初步确定较为适宜的培养条件：温度为40℃,pH值为7．0,转速为200r／min．在此培养条件下,利用该菌株处理含有5mmol／LDBT的正十二烷模拟相,24h以后,DBT减少到3．36mmol／L,平均比脱硫率为8．34mmol DBTh^-1kg^-1 DCW（干细胞重）。     

Biodesulfurization of dibenzothiophene by a newly isolated Rhodococcus erythropolis strain

A new dibenzothiophene (DBT) desulfurizing bacterium was isolated from oil-contaminated soils in Iran. HPLC analysis and PCR-based detection of the presence of the DBT desulfurization genes (dszA, dszB and dszC) indicate that this strain converts DBT to 2-hydroxybiphenyl (2-HBP) via the 4S pathway. The strain, identified as Rhodococcus erythropolis SHT87, can utilize DBT, dibenzothiophene sulfone, thiophene, 2-methylthiophene and dimethylsulfoxide as a sole sulfur source for growth at 30 °C.The maximum specific desulfurization activity of strain SHT87 resting cells in aqueous and biphasic organic–aqueous systems at 30 °C was determined to be 0.36 and 0.47 μmol 2-HBP min⁻¹ (g dry cell)⁻¹, respectively. Three mM DBT was completely metabolized by SHT87 resting cells in the aqueous and biphasic systems within 10 h. The rate and the extent of the desulfurization reaction by strain SHT87 suggest that this strain can be used for the biodesulfurization of diesel oils.     

Biodesulfurization of DBT in tetradecane and crude oil by a facultative thermophilic bacterium Mycobacterium goodii X7B

Mycobacterium goodii X7B, a facultative thermophilic bacterium, cleaving the C-S bond of dibenzothiophene via a sulfur-specific pathway, was investigated for DBT in tetradecane and crude oil desulfurization. The extent of growth was improved by fed-batch culture controlled at a constant pH. The total sulfur level of dibenzothiophene in tetradecane, was reduced by 99%, from 200 to 2 ppm within 24h at 40 degrees C. After 72 h treatment, 59% of the total sulfur content in Liaoning crude oil was removed, from 3600 to 1478 ppm.     

Evidence for the role of zinc on the performance of dibenzothiophene desulfurization by <Emphasis Type="Italic">Gordonia alkanivorans</Emphasis> strain 1B

Gordonia alkanivorans strain 1B is able to desulfurize dibenzothiophene (DBT) to 2-hydroxybiphenyl (2-HBP), the final product of the 4S pathway. However, both the cell growth and the rate of desulfurization can be largely affected by the nutrient composition of the growth medium due to cofactor requirements of many enzymes involved in the biochemical pathways. In this work, the effect of several metal ions on the growth and DBT desulfurization by G. alkanivorans was studied. From all the metal ions tested, only the absence of zinc significantly affected the cell growth and the desulfurization rate. By increasing the concentration of Zn from 1 to 10 mg L⁻¹, 2-HBP productivity was improved by 26%. The absence of Zn²⁺, when sulfate was also used as the only sulfur source, did not cause any difference in the bacterial growth. Resting cells grown in the presence of Zn²⁺ exhibited a 2-HBP specific productivity of 2.29 μmol g⁻¹ (DCW) h⁻¹, 7.6-fold higher than the specific productivity obtained by resting cells grown in the absence of Zn²⁺ (0.30 μmol g⁻¹ (DCW) h⁻¹). These data suggests that zinc might have a key physiological role in the metabolism of DBT desulfurization.     

Demonstration of the carbon-sulfur bond targeted desulfurization of benzothiophene by thermophilic Paenibacillus sp. strain A11-2 capable of desulfurizing dibenzothiophene

Paenibacillus sp. strain A11-2, which had been primarily isolated as a bacterial strain capable of desulfurizing dibenzothiophene to produce 2-hydroxybiphenyl at high temperatures, was found to desulfurize benzothiophene more efficiently than dibenzothiophene. The desulfurized product was identified as o-hydroxystyrene by GC-MS and 1H-NMR analysis. Benzothiophene was assumed to be degraded in a way analogous to the 4S pathway, which has been well-known as a mode of dibenzothiophene degradation. These results suggest that benzothiophene desulfurization may share at least partially the reaction mechanism with dibenzothiophene desulfurization.     

Biodesulfurization of dibenzothiophene by growing cells of Gordonia sp. in batch cultures

A new isolate, identified as Gordonia sp. ZD-7 by 16S rDNA sequence analysis, grew in n-hexadecane containing dibenzothiophene (DBT) which was degraded from 2.8 mM to 0.2 mM within 48 h. Biodesulfurization could be repeatedly performed for more than 190 h, with average desulfurization rates of 5 mmol DBT kg cells (dry wt)⁻¹ h⁻¹.     

Desulfurization of dibenzothiophene by Bacillus subtilis recombinants carrying dszABC and dszD genes

The desulfurization (dsz) genes from Rhodococcus erythropolis DS-3 were successfully integrated into the chromosomes of Bacillus subtilis ATCC 21332 and UV1 using an integration vector pDGSDN, yielding two recombinant strains, B. subtilis M29 and M28 in which the integrated dsz genes were expressed efficiently under the promoter, Pspac. The dibenzothiophene (DBT) desulfurization efficiency of M29 was 16.2 mg DBT l⁻¹ h⁻¹ at 36 h, significantly higher than that of R. erythropolis DS−3 and B. subtilis M28 and also showed no product inhibition. The interfacial tension of the supernatant fermented by M29 varied from 48 mN m⁻¹ to 4.2 mN m⁻¹, lower than that of the recombinant strain, M28, reveals that the biosurfactant secreted from M29 may have an important function in the DBT desulfurization process.     

Deep desulfurization of hydrodesulfurization-treated diesel oil by a facultative thermophilic bacterium Mycobacterium sp. X7B

The dibenzothiophene (DBT) desulfurization pathway of a facultative thermophilic bacterium Mycobacterium sp. X7B was investigated. Metabolites were identified by gas chromatography-mass spectrometry, and the results showed that 2-hydroxybiphenyl, the end product of the previously reported sulfur-specific pathway (also called 4S pathway), was further converted to 2-methoxybiphenyl. This is the first strain to possess this ability and therefore, an extended 4S pathway was determined. In addition, the DBT-desulfurizing bacterium Mycobacterium sp. X7B was able to grow on DBT derivatives such as 4-methylDBT and 4,6-dimethylDBT. Resting cells could desulfurize diesel oil (total sulfur, 535 ppm) after hydrodesulfurization. GC flame ionization detection and GC atomic emission detection analyses were used to qualitatively evaluate the effect of Mycobacterium sp. X7B treatment on the content of the diesel oil. The total sulfur content of the diesel oil was reduced 86% using resting cell biocatalysts for 24 h at 45 degrees C.     

Microtitre plate assay for biofilm formation, production and utilization of hydroxybiphenyl by Rhodococcus sp. isolated from gasoline-contaminated soil

Gasoline-contaminated soil from Isfahan, Iran was selected to isolate a bacterium capable of desulfurizing dibenzothiophene (DBT). The isolated strain was named R1 and identified as Rhodococcus erythropolis through biochemical tests as well as sequencing of 16S rRNA gene. This strain could efficiently produce 2-hydroxybiphenyl (HBP) from DBT via the 4S metabolic pathway. The highest HBP amount was produced at 2 mM DBT with addition of glucose (10 g l(-1)), ethanol (3 g l(-1)), glycerol (2 g l(-1)) or succinate (10 g l(-1)) as carbon sources at pH 7. Highest respiration and growth rates were observed by microplate titration on 0.1 mM HBP, and addition of 0.2 mM HBP to glucose (1 g l(-1)) and DBT (0.3 mM) could inhibite the respiration of the isolate. The isolated strain could grow up to 0.4 mM of HBP when it is used with mineral sulfur as sole sulfur source. To the best of our knowledge this is the first report on a microtiter assay for the production and utilization of HBP by Rhodococcus.     

Desulfurization of alkylated forms of both dibenzothiophene and benzothiophene by a single bacterial strain

Thirty-five bacterial strains capable of converting dibenzothiophene into 2-hydroxybiphenyl were isolated. Among them Rhodococcus erythropolis KA2-5-1 was chosen for further characterization because of its ability to retain high desulfurization activity stably. PCR cloning and DNA sequencing of a KA2-5-1 genomic DNA fragment showed that it was practically identical with dszABC genes from Rhodococcus sp. IGTS8, a representative carbon-sulfur-bond-targeted dibenzothiophene-degrading bacterium. KA2-5-1 desulfurized a variety of alkyl dibenzothiophenes through the specific cleavage of their C-S bonds. In addition, unexpectedly, KA2-5-1 also attacked alkyl benzothiophenes in a C-S-bond-targeted fashion. The purified monooxygenase, encoded by dszC of KA2-5-1, converted benzothiophene and dibenzothiophene into benzothiophene sulfone and dibenzothiophene sulfone, respectively, with the aid of an NADH-dependent oxidoreductase. This result raises the possibility that the same enzymatic step may be involved in desulfurization of alkylated forms of both dibenzothiophene and benzothiophene in KA2-5-1 cells.     

Chromosome doubling in a <Emphasis Type="Italic">Rosa rugosa</Emphasis> Thunb. hybrid by exposure of in vitro nodes to oryzalin: the effects of node length,oryzalin concentration and exposure time

Chromosome doubling was induced in vitro in a diploid hybrid of Rosa rugosa Thunb. using oryzalin as the spindle inhibitor. Nodal sections, 2 mm long, were exposed to 2.5 or 5 μM oryzalin and 10 mm nodal sections were exposed to 5 μM oryzalin for 0 (controls), 6, 12, 24 and 48 h. The ploidy of the emergent shoots was determined by flow cytometry. The frequency of tetraploid and mixoploid leaves that developed from 2 mm nodal sections exposed to 5 μM oryzalin peaked at 12 h exposure, when 35% of the leaves were tetraploid, but fell after longer exposures. Fewer tetraploid and mixoploid leaves were found when 2 mm nodes were exposed to 2.5 μM oryzalin for 6 and 12 h, indicating that it took longer for a spindle inhibiting concentration of oryzalin to build up in the meristem. However, the frequencies of tetraploid and mixoploid leaves continued to rise after 12 h and were highest at 48 h, when 44% were tetraploid. In treatments with 5 μM oryzalin, the frequencies of tetraploid and mixoploid leaves were lower, at equivalent exposure times, in 10 mm nodes than 2 mm nodes. This suggests that oryzalin diffused to the meristem mainly via the cut surfaces and that access via the epidermis and cuticle was impeded.     

Elucidation of 2-hydroxybiphenyl effect on dibenzothiophene desulfurization by Microbacterium sp. strain ZD-M2

The effect of 2-hydroxybiphenyl (2-HBP), the end product of dibenzothiophene (DBT) desulfurization via 4S pathway, on cell growth and desulfurization activity was investigated by Microbacterium sp. The experimental results indicate that 2-HBP would inhibit the desulfurization activity. Providing 2-HBP was added in the reaction media, the DBT degradation rate decreased along with the increase of 2-HBP addition. By contrast, cell growth would be promoted in the addition of 2-HBP at a low concentration (<0.1mM). At high concentration of 2-HBP, the inhibition on the cell growth occurred. Meanwhile, the inhibitory effect of 2-HBP on DBT desulfurization activity was tested both in the oil/aqueous two-phase system and the aqueous system. A mathematical model was developed to explain the product formation kinetics with DBT as the sole sulfur source. The predicted results were close to the experimental data, it elucidated that along with the 2-HBP accumulation, the inhibitory effect of 2-HBP on DBT desulfurization and cell growth was enhanced.     

Biosynthesis of intracellular 5-aminolevulinic acid by a newly identified halotolerant <Emphasis Type="Italic">Rhodobacter sphaeroides</Emphasis>

Of 23 strains of halotolerant (up to 12% w/v NaCl) photosynthetic bacteria isolated from various sources, one isolate, SH5, accumulated intracellular 5-aminolevulinic acid (ALA) at 0.45 μg/g dry cell wt (DCW) growing aerobically in the dark. The strain was identified as Rhodobacter sphaeroides using 16S rDNA sequencing. Biosynthesis of ALA was enhanced to 14 μg/g DCW using modified glutamate/glucose (50 mM) medium with the addition of 10 mM levulinic acid after 24 h cultivation. Addition of 30 μM Fe²⁺ to this medium increased the yield to 226 μg/g DCW.     

Identification and Cloning of Genes Involved in Specific Desulfurization of Dibenzothiophene by Rhodococcus sp. Strain IGTS8

The gram-positive bacterium Rhodococcus sp. strain IGTS8 is able to remove sulfur from certain aromatic compounds without breaking carbon-carbon bonds. In particular, sulfur is removed from dibenzothiophene (DBT) to give the final product, 2-hydroxybiphenyl. A genomic library of IGTS8 was constructed in the cosmid vector pLAFR5, but no desulfurization phenotype was imparted to Escherichia coli. Therefore, IGTS8 was mutagenized, and a new strain (UV1) was selected that had lost the ability to desulfurize DBT. The genomic library was transferred into UV1, and several colonies that had regained the desulfurization phenotype were isolated, though free plasmid could not be isolated. Instead, vector DNA had integrated into either the chromosome or a large resident plasmid. DNA on either side of the inserted vector sequences was cloned and used to probe the original genomic library in E. coli. This procedure identified individual cosmid clones that, when electroporated into strain UV1, restored desulfurization. When the origin of replication from a Rhodococcus plasmid was inserted, the efficiency with which these clones transformed UV1 increased 20- to 50-fold and they could be retrieved as free plasmids. Restriction mapping and subcloning indicated that the desulfurization genes reside on a 4.0-kb DNA fragment. Finally, the phenotype was transferred to Rhodococcus fascians D188-5, a species normally incapable of desulfurizing DBT. The mutant strain, UV1, and R. fascians produced 2-hydroxybiphenyl from DBT when they contained appropriate clones, indicating that the genes for the entire pathway have been isolated.     

Regulation of leucine transport by intracellular pH in Bacillus pasteurii

The kinetics, specificity and mechanism of leucine uptake were studied in the alkaliphilic bacterium Bacillus pasteurii DSM 33 (ATCC 11859). Leucine was accumulated up to 200-fold by a sodium-dependent secondary transport system for branched-chain amino acids. Apparent K_t values of 9.6 μM for leucine, 8.9 μM for isoleucine, 9.3 μM for valine, and 0.71 mM for sodium were determined, and maximum uptake activity was observed at an external pH of 8.5 and at 35°C. The effect of several ionophores indicated that transport was energized by the membrane potential and a sodium gradient; each gradient alone was sufficient to drive the uptake of leucine. The activity of the leucine transport system was regulated by the intracellular pH and was inhibited at an internal pH below 7.0. Received: 26 September 1995 / Accepted: 10 December 1995     

Shoot regeneration from leaf explants of <Emphasis Type="Italic">Brunfelsia calycina</Emphasis>

A protocol for plantlet regeneration through shoot formation was developed for the neotropical shrub Brunfelsia calycina. This shrub is unique in its change in flower color from dark purple to white. Explants from young and mature leaves were incubated on MS medium (pH 5.7, 30 g/l sucrose, 7.5 g/l agar) with various combinations of Indole-3-acetic acid (IAA) and 6-Benzyladenine (BA) under a 16 h photoperiod at a constant temperature of 25°C. Shoot emergence was best at 4.44 μM BA and 2.85 μM IAA for young leaf explants, and at 8.88 μM BA, 2.85 μM IAA for mature leaf explants. When shoots were transferred to MS medium supplemented with 1.23–2.46 μM indole butrytic acid (IBA), they developed roots.     

Desulfurization of Dibenzothiophene and Diesel Oils by a Newly Isolated Gordona Strain, CYKS1

A dibenzothiophene (DBT)-desulfurizing bacterial strain was isolated and identified as Gordona strain CYKS1. Strain CYKS1 was found to transform DBT to 2-hydroxybiphenyl via the 4S pathway and to be able to also use organic sulfur compounds other than DBT as a sole sulfur source. Its desulfurization activity was susceptible to sulfate repression. Active resting cells for desulfurization could be prepared only in the early growth phase. When two types of diesel oils, middle distillate unit feed (MDUF) and light gas oil (LGO) containing various organic sulfur compounds including DBT, were treated with resting cells of strain CYKS1 for 12 h, the total sulfur content significantly decreased, from 0.15% (wt/wt) to 0.06% (wt/wt) for MDUF and from 0.3% (wt/wt) to 0.25% (wt/wt) for LGO. The newly isolated strain CYKS1 is considered to have good potential for application in the biodesulfurization of fossil fuels.     

Isolation and characterization of a moderate thermophile,Mycobacterium phlei GTIS10, capable of dibenzothiophene desulfurization

An organism, identified as Mycobacterium phlei GTIS10, was isolated based on its ability to use dibenzothiophene (DBT) as a sole source of sulfur for growth at 30-52 degrees C. Similar to other biodesulfurization-competent organisms, M. phlei GTIS10 converts DBT to 2-hydroxybiphenyl (2-HBP), as detected by HPLC. The specific desulfurization activity of the 50 degrees C M. phlei GTIS10 culture was determined to be 1.1+/-0.07 micromol 2-HBP min(-1) (g dry cell)(-1). M. phlei GTIS10 can also utilize benzothiophene and thiophene as sulfur sources for growth. The dszABC operon of M. phlei GTIS10 was cloned and sequenced and was found to be identical to that of Rhodococcus erythropolis IGTS8. The presence of the R. erythropolis IGTS8 120-kb plasmid pSOX, which encodes the dszABC operon, has been demonstrated in M. phlei GTIS10. Even though identical dsz genes are contained in both cultures, the temperature at which resting cells of R. erythropolisIGTS8 reach the highest rate of DBT metabolism is near 30 degrees C whereas the temperature that shows the highest activity in resting cell cultures of M. phlei GTIS10 is near 50 degrees C, and activity is detectable at temperatures as high as 57 degrees C. In M. phlei GTIS10, the rate-limiting step in vivo appears to be the conversion of DBT to dibenzothiophene sulfone catalyzed by the product of the dszC gene, DBT monooxygenase. The thermostability of individual desulfurization enzymes was determined and 2-hydroxybiphenyl-2-sulfinate sulfinolyase, encoded by dszB, was found to be the most thermolabile. These results demonstrate that the thermostability of individual enzymes determined in vitro is not necessarily a good predictor of the functional temperature range of enzymes in vivo.     

Identification and Characterization of Novel Lipophilic Antimicrobial Peptides Derived from Naturally Occurring Proteins

Microbes are increasingly developing defensive mechanisms against known drugs via mutations. There are signs of emergence of superbugs immune to most known antibiotics available. The need for a new class of drugs to counteract this problem is of paramount importance for continued general well being of mankind. A new class of drugs, antimicrobial peptides, has not been fully exploited primarily due to high cytotoxicity, poor lipophilicity preventing systemic distribution and stability. We have synthesised 9-amino acid residue cationic peptides RH01 and RH02 lipidated with myristoyl and octyl groups respectively. These peptides exhibited potent antimicrobial activity and low cytotoxicity. The lipopeptide RH01 has antimicrobial activity against a broad range of microorganisms including bacteria, yeast and filamentous fungi with greatest activity toward Gram-positive bacteria, including S. aureus MRSA stain, MIC’s ranging between 2–8 μM. The MIC for Gram-negative bacteria was higher ranging from between 30–250 μM. RH01 also had antimicrobial activity towards fungi showing good activity against the pathogenic yeast Candida albicans but was less active towards the filamentous fungi Aspergillus niger. The antimicrobial activity of RH01 as a measure of Ki₍₅₀₎ for E. coli and S. aureus was 35–60 μM and 3–7 μM, respectively. In-house data showed the compound is bactericidal even at higher bacteria concentration. The octylated lipopeptide RH02 has similar activities towards S. aureus (3.3 μM) and E coli (53.3 μM) as the myristolated RH01. There was no haemolytic activity of the lipopeptide RH01 towards human blood. Acute intravenous toxicity study in mice showed that both RH01 and RH02 induced no macroscopic abnormalities at their highest non-lethal dose of 75 mg/kg and 150 mg/kg bodyweight, respectively.Australian Peptide Conference Issue.