Short communication: insoluble fibres in supplemental pre-weaning diets affect behaviour of suckling piglets

We investigated the effect of offering supplementary dietary fibres to suckling piglets on their behaviour and performance before weaning. From 5 to 22 days of age, suckling piglets were offered a high-fibre diet (HF; 5% cellulose; n=5 litters), or a control low-fibre diet (n=5 litters). Piglets were housed with the sows in individual farrowing pens, and had access to maternal milk until weaning, at 23 days of age. Behaviours of six focal piglets per pen were scored at 6, 16 and 21 days of age. All piglets were individually weighed at 5, 15 and 20 days of age and feed intake was measured daily at the pen level. Piglets on the HF diet were more active than controls (P=0.05), and spent more time suckling or massaging the udder (P=0.01) and interacting with pen mates (P=0.008). Time spent manipulating pen mates, which may reflect re-directed foraging activity in the absence of substrate, accounted for most of the time spent interacting with pen mates (⩾73% of total time spent interacting). Dietary fibres had no effect on BW and feed intake. In conclusion, inclusion of cellulose in the supplemental diet of suckling piglets affects behaviour, with no deleterious effects on performance before weaning.     

Effects of a dietary crude fibre concentrate on growth in weaned piglets

Many fibre sources can help the adaptation of piglets at weaning, improving the growth. In this study, the effects of a dietary crude fibre concentrate (CFC) on piglet’s growth was investigated. From 31 to 51 days of age, 108 weaned piglets (D×(Lw×L)), had access to two isofibrous, isoenergetic and isonitrogenous diets, supplemented with 1% of CFC (CFC group) or not (control (CON) group). From days 52 to 64 all piglets received the same starter diet. During the dietary treatment period the CFC group showed higher average daily gain, average daily feed intake and feed efficiency (P<0.001) than CON group. At 64 days of age, BW was higher in CFC group compared with CON group (P<0.001). Blood samples were collected at days 31, 38, 45 and 52 of age. From days 31 to 52 significant differences in the somatotropic axis between groups were observed. In particular, growth hormone levels were higher only at the end of the 1^st week of dietary treatment (P<0.05) in CFC group animals compared with CON group animals. The IGF-I trend was similar between groups even if the IGF-I levels were higher in the CFC group than CON group 1 week after starting treatment (P<0.01). The IGF-binding protein 3 (IGFBP-3) levels were higher in the first 2 weeks of dietary treatment and lower in the 3^rd week in CON group compared with CFC group (P<0.01). Specifically, the IGFBP-3 profile was consistent with that of IGF-I in CFC group but not in CON group. At the same time, an increase of leptin in CFC compared with CON group was observed (P<0.05). Piglets fed the CFC diet showed a lower diarrhoea incidence (P<0.05) and a lower number of antibiotic interventions (P<0.05) than CON diet from 31 to 51 days of age. Pig-major acute-phase protein plasma level (P<0.01) and interleukin-6 gene expression (P<0.05) were higher in CON group than CFC group at the end of 1^st week of dietary treatment. In conclusion, this study showed that CFC diet influences the hormones related to energy balance enhancing the welfare and growth of piglets. Furthermore, the increase in feed intake during 3 weeks of dietary treatment improved the feed efficiency over the entire post-weaning period.     

Body composition,muscle fibre characteristics and postnatal growth capacity of pigs born from sows supplemented with L-carnitine

Abstract

Recently, it has been shown that supplementation of sows with L-carnitine increases their plasma concentrations of insulin-like growth factor (IGF)-I, and it has been hypothesized that this may stimulate fetal myogenesis. This study was performed to investigate whether piglets of sows supplemented with L-carnitine differ in muscle fibre characteristics, chemical body composition and postnatal growth capability from pigs of control sows. Muscle fibre characteristics and chemical body composition were determined at weaning in 21 piglets of control sows and 21 piglets of sows treated with L-carnitine with similar body weights; postnatal growth capability was determined from weaning until slaughter at a body weight of 118 kg in 80 pigs of control sows and 80 pigs of sows treated with L-carnitine which had also similar body weights at weaning. Piglets of sows supplemented with L-carnitine did not differ in number, area, diameter and type (percentages of slow twitch oxidative + fast twitch oxidative fibres, and fast twitch glycolytic fibres) of muscle fibres in m. longissimus dorsi and m. semitendinosus and in chermical body composition (concentrations of dry matter, crude protein, crude fat) from piglets of control sows. Postnatal growth capability (body weight gains, feed conversion ratio) from weaning to slaughter as well as carcass composition (carcass yield, meat thickness, fat thickness) was also not different between pigs of sows treated with L-carnitine and pigs of control sows. In conclusion, data of this study do not support the hypothesis that L-carnitine supplementation of sows during pregnancy enhances fetal muscle fibre development and increases postnatal growth capability of the offspring.     

Growth performance, digestibility and faecal coliform bacteria in weaned piglets fed a cereal-based diet including either chicory (Cichorium intybus L) or ribwort (Plantago lanceolata L) forage

Twenty-five weaned 35-day-old piglets were used in a 35-day growth experiment to evaluate the effect of inclusion of chicory and ribwort forage in a cereal-based diet on growth performance, feed intake, digestibility and shedding of faecal coliform bacteria. A total of seven experimental diets were formulated, a cereal-based basal diet (B), and six diets with inclusion of 40, 80 and 160 g/kg chicory (C40, C80 and C160) or ribwort (R40, R80 and R160). Piglets had ad libitum access to feed and water throughout the experiment. Three and five weeks post-weaning faeces samples for determination of digestibility were collected once a day for five subsequent days. Additional faeces samples for determination of coliform counts were collected at days 1, 16 and 35 post-weaning. Piglets fed diet R160 had the lowest average daily feed intake (DFI) and daily weight gain (DWG), and differed (P < 0.05) from piglets fed diets B, R40 and R80. There were no differences in DFI and DWG between the chicory diets and diet B. Inclusion of chicory or ribwort had a minor negative impact on the coefficient of total tract apparent digestibility (CTTAD) of dry matter, organic matter and crude protein, whereas inclusion of both chicory and ribwort resulted in higher CTTAD of non-starch polysaccharides and neutral detergent fibre (NDF). The CTTAD of arabinose were higher for diets C160 and R160 than for diet B (P < 0.05), and the CTTAD of uronic acid was higher for diets C40, C80, C160, R80 and R160 than for diet B (P < 0.05). Age affected the CTTAD for all parameters (P < 0.05) except for NDF, with higher values at 5 than at 3 weeks post-weaning. The coliform counts decreased with increasing age (P < 0.05), but was not affected by treatment. The results indicate that inclusion of up to 160 g/kg of chicory do not negatively affect performance, whereas high inclusion of ribwort have a negative impact on feed consumption and consequently on growth rate. Both herbs have a higher digestibility of fibre compared to cereal fibre. Chicory and ribwort are both promising as feedstuffs to weaned piglets, but the low palatability of ribwort limits the inclusion level.     

Postponed sowing does not alter the fibre/wood ratio or fibre extractability of fibre hemp (Cannabis sativa)

Because hemp is a short-day plant, postponing the sowing date might be a suitable strategy to obtain shorter and smaller plants around flowering, when primary fibres are 'ripe' enough to be harvested. Smaller plants can be processed on existing flax scutching and hackling lines and might have fibre characteristics that are desirable for producing high-quality 'long fibres' for yarn spinning.
It was investigated whether sowing beyond the normal sowing period in the Netherlands affects the ratio in which fibres and wood are produced, and what proportion of these fibres are long fibres, suitable for long fibre spinning. About 400 stem samples were fractioned into retting losses, wood, tow, and long fibre, and the ratios between fractions were analysed using multiple linear regression analyses.
A normal sowing date at the end of April was compared with a postponed sowing date at the end of May. The total fibre/wood ratio was not affected. More than 95% of the variance in total fibre was accounted for by the wood weight per stem (55.5%), the variety (+33.3%) and the stem part (+6.5%). The amount of long fibre per stem mainly depended on the amount of the total fibre per stem (95.4% variance was accounted for) and the stem part (+2.0%).
For economic reasons, it could be interesting to grow two successive high-quality hemp crops in one growing season. Therefore, in an additional experiment with one variety, the effect of sowing fibre hemp up to 12 weeks later than normal on the quantity and quality of the fibres was studied. Postponing the sowing date up to 12 weeks had no important effects on retting losses, the total fibre/wood ratio, and the long fibre/total fibre ratio. It is therefore technically possible to grow two successive hemp crops. Whether this fits well in farming systems and a hemp production chain remains to be studied.     

The effects of superoxide dismutase-rich melon pulp concentrate on inflammation,antioxidant status and growth performance of challenged post-weaning piglets

Piglets can often suffer impaired antioxidant status and poor immune response during post-weaning, especially when chronic inflammation takes place, leading to lower growth rates than expected. Oral administration of dietary antioxidant compounds during this period could be a feasible way to balance oxidation processes and increase health and growth performance. The aim of the trial was to study the effects of an antioxidant feed supplement (melon pulp concentrate) that contains high concentration of the antioxidant superoxide dismutase (SOD) on inflammation, antioxidant status and growth performance of lipopolysaccharide (LPS) challenged weaned piglets. In total, 48 weaned piglets were individually allocated to four experimental groups in a 2×2 factorial design for 29 days. Two different dietary treatments were adopted: (a) control (CTR), fed a basal diet, (b) treatment (MPC), fed the basal diet plus 30 g/ton of melon pulp concentrate. On days 19, 21, 23 and 25 half of the animals within CTR and MPC groups were subjected to a challenge with intramuscular injections of an increasing dosage of LPS from Escherichia coli (serotype 0.55:B5) (+) or were injected with an equal amount of PBS solution (−). Blood samples were collected at the beginning of the trial and under the challenge period for interleukin 1β, interleukin 6, tumour necrosis factor α, haptoglobin, plasma SOD activity, total antioxidant capacity, reactive oxygen species, red blood cells and plasma resistance to haemolysis, and 8-oxo-7, 8-dihydro-2’-deoxyguanosine. Growth performance was evaluated weekly. A positive effect of melon pulp concentrate was evidenced on total antioxidant capacity, half-haemolysis time of red blood cells, average daily gain (ADG) and feed intake, while LPS challenge increased pro-inflammatory cytokines and haptoglobin serum concentrations, with a reduced feed intake and gain : feed (G : F). The obtained results show that oral SOD supplementation with melon pulp concentrate ameliorates the total antioxidant capacity and the half-haemolysis time in red blood cell of post-weaning piglets, with positive results on growing performance.     

Effects of l-carnitine supplementation to suckling piglets on carcass and meat quality at market age

In a previous study, carnitine supplementation to piglets during the suckling period resulted in an increased total muscle fibre number at weaning in piglets of low birth weight. The objective of the present study was to investigate whether this effect is maintained until market age and whether this would attenuate the negative consequences of low birth weight on carcass and meat quality. Using a split-plot design with litter as block, sex as whole plot and treatment as subplot, the effects of early-postnatal l-carnitine supplementation on female and castrated male piglets of low birth weight were investigated on a total of 56 German Landrace piglets from 14 litters. From days 7 to 27 of age piglets were orally supplemented once daily with 400 mg of l-carnitine dissolved in 1 ml of water or received an equal volume of water without carnitine. From weaning (day 28) until slaughter (day 166 of age) all pigs were fed standard diets. At weaning, carnitine-supplemented piglets had a twofold increased concentration of free carnitine (P < 0.001) and a lower concentration of non-esterified fatty acids (P < 0.05) in blood plasma indicating that carnitine became bioavailable and increased fatty acid utilization during the period of supplementation. Growth performance was not influenced by treatment in any growth period. Dual-energy X-ray absorptiometry revealed no differences in body composition between groups in weeks 12, 16 and 20 of age. LW at slaughter, carcass weight, measures of meat yield and fat accretion, as well as body composition by chemical analyses and dissection of primal cuts did not differ between treatments. No differences between control and carnitine-treated pigs in total fibre number (P = 0.85) and fibre cross-sectional area (P = 0.68) in m. semitendinosus (ST) measured at slaughter could be observed. The carnitine group tended to exhibit a smaller proportion of slow-twitch oxidative fibres (P = 0.08), a greater proportion of fast-twitch glycolytic fibres (P = 0.11), and increased specific lactate dehydrogenase activity (P = 0.09) in ST indicating a more glycolytic muscle metabolism. Compared with the controls, a lower pH₂₄ value was observed (P = 0.05) in ST muscle of carnitine-supplemented pigs, which – in castrates only – was associated with an increased drip loss (P < 0.01). Meat quality traits in m. longissimus were not influenced by treatment. In conclusion, our hypothesis that early-postnatal carnitine supplementation to piglets of low birth weight permanently increases myofibre number and improves later carcass and meat quality could not be confirmed by this experiment.     

Grape pomace improves performance,antioxidant status,fecal microbiota and meat quality of piglets

In the present study, grape pomace (GP) was used as feed additive in the diet of weaned piglets in order to develop innovative feedstuffs and to investigate their potential beneficial effects on welfare, productivity and meat quality. For examining the antioxidant capacity of the experimental feeds, 24 piglets of 20 days old were assigned to two experimental groups receiving standard or experimental diet for 30 days. Blood and tissues collections were performed at four different time-points, 2, 20, 35 and 50 days post birth. The collected tissues were brain, heart, kidney, liver, lung, quadriceps muscle, pancreas, spleen and stomach. The following oxidative stress markers were assessed: reduced glutathione (GSH), catalase activity, total antioxidant capacity (TAC), thiobarbituric acid reactive substances (TBARS), protein carbonyls (CARB) and H₂O₂ decomposition activity. The effect on bacterial growth was assessed by examining microbial populations in piglets’ fecal microbiota. Furthermore, the average daily gain (ADG) was calculated and the fatty acid profile of quadriceps muscle was assessed. The results showed that piglets fed with the diet supplemented with GP, had significantly increased antioxidants mechanisms in almost all the tissues as shown by increases in GSH, H₂O₂ decomposition activity and TAC compared with control group. Piglets fed with the experimental diet exhibited decreased oxidative stress-induced damage to lipids and proteins as shown by decreases in TBARS and CARB in GP group compared with control. In addition, the experimental diet increased significantly ADG (by 23.65%) (P<0.05) and enhanced the growth of facultative probiotic bacteria (by up to 1.2 log colony forming units (CFU)/g) (P<0.05) and lactic acid bacteria (by up to 2.0 log CFU/g) (P<0.05) in GP group compared with the control group. GP supplementation inhibited the growth of pathogen populations such as Enterobacteriacae (by up to 1.8 log CFU/g) (P<0.05) and Campylobacter jejuni (by up to 1.0 log CFU/g) (P<0.05). Regarding fatty acid composition of meat, GP inclusion in piglets’ diet increased significantly n-3 fatty acids (EPA; C20 : 5n-3, DHA; C22 : 6n-3, α-linolenic acid; C18 : 3n-3) and decreased significantly n-6/n-3 ratio compared with control (P<0.05). The results suggested that dietary GP supplementation may have a beneficial impact on piglets’ welfare and may improve productivity as well as meat quality.     

Effect of an Escherichia coli F4/F18 bivalent oral live vaccine on gut health and performance of healthy weaned pigs

Oral live vaccines stimulate host immunity, but they could also affect intestinal mucosa development and gut microbiota of piglets during the postweaning. The aim of this study was to determine the effect of an oral vaccine against Escherichia coli F4 and F18 (Coliprotec F4/F18®), on gut functionality and integrity, growth performance and health status of postweaning piglets. A total of 96 weaned piglets (23.30 ± 1.85 days of age; 7334 ± 1039 g BW) were divided into two groups (16 replicates/group; three piglets/replicate) as follows: (1) Control (CO), fed a standard diet (prestarter up to 14 days, then starter feed); (2) Treated (TRT): as CO but vaccinated with Coliprotec F4/F18® at weaning (day 0). Piglets were weighed at day 0 and weekly until day 35. Individual faecal score was recorded daily. Piglets were sacrificed at days 10 (1/3 of total) and 35 (2/3). Samples of jejunum mucosa and of cecum content were collected for morphometric, immunohistochemistry analysis and for microbiota profile analysis, respectively. Data were fitted using a linear model including treatment, class of starting BW as fixed factors and litter as random factor. From days 0 to 7, piglets from the TRT group tended to have a higher average daily gain (+22.6%, P = 0.08) and average daily feed intake compared to the CO group (+13.2%, P = 0.022). Gain to feed ratio was lower in the TRT group from days 14 to 35 (?6.6%, P = 0.011). From days 7 to 14, the TRT group had a higher diarrhoea index (?199%, P < 0.001). Crypt depth was higher in the CO group (+10.9%, P = 0.04) at day 10, but not at day 35. Jejunal expression of Claudin-4 (probability of having a score = 3) was higher in the TRT group at day 10 (CO = 1.50% vs TRT = 2.69%, P < 0.0001) and day 35 (CO = 1.29% vs TRT = 1.92%, P = 0.012). Oral vaccine affected beta diversity at day 10 (P = 0.040; R² = 0.05) and increased the abundance of specific taxa and genera in the cecum at day 10, including Prevotella (lg2FC = 23.2, FDR < 0.001). The results showed how an Escherichia coli-based vaccine supplied to weaned pigs can promote gut health by controlling symptoms of the postweaning perturbation in the first 2 weeks postweaning. In addition, the vaccine strains showed a probiotic-like effect by modulating gut microbiota favouring the establishment of beneficial bacteria, and by promoting gut barrier integrity.     

The potential effects of antioxidant feed additives in mitigating the adverse effects of corn naturally contaminated with <Emphasis Type="Italic">Fusarium</Emphasis> mycotoxins on antioxidant systems in the intestinal mucosa,plasma, and liver in weaned pigs

Seventy-two piglets (6.0 kg BW) were randomly distributed within six different dietary treatments to evaluate the effect of deoxynivalenol (DON) and the potential of four antioxidant feed additives in mitigating the adverse effects of DON on growth performances and oxidative status. Dietary treatments were as follows: control diet 0.8 mg/kg DON; contaminated diet (DON-contaminated diet) 3.1 mg/kg DON; and four contaminated diets, each supplemented with a different antioxidant feed additive, DON + vitamins, DON + organic selenium (Se)/glutathione (GSH), DON + quercetin, and DON + COMB (vitamins + Se/GSH + quercetin from the other treatments). Although DON was the main mycotoxin in the contaminated diet, this diet also contained 1.8 mg/kg of zearalenone (ZEN). The “mycotoxin” effects therefore included the combined effect of these two mycotoxins, DON, and ZEN. The DON-ZEN ingestion did not affect growth performances, average daily gain (ADG), average daily feed intake (ADFI), and feed efficiency (G:F ratio), but partially induced oxidative stress in weaned pigs as shown by increased malondialdehyde (MDA) content in the plasma and superoxide dismutase (SOD) activity in liver (P?<?0.05). However, no change in the activity of other antioxidant enzymes or GSH concentrations was observed in plasma and liver of piglets fed the DON-contaminated diet (P?>?0.05). Supplementation with individual antioxidant feed additive had a limited effect in weaned pigs fed DON-ZEN-contaminated diets. Combination of antioxidants (vitamins A, C, and E, quercetin, and organic Se/GSH) reduced plasma and liver MDA content and SOD activity in liver (P?<?0.05) of piglets fed DON-ZEN-contaminated diets. Furthermore, this combination also reduced MDA content in the ileum (P?<?0.05), although activity of glutathione peroxidases (GPx), SOD or catalase (CAT) in the ileum was not affected by DON-ZEN contamination or antioxidant supplements. In conclusion, DON-ZEN contamination induced oxidative stress in weaned pigs and combination of antioxidant feed additives restored partially the oxidative status. Further studies will be necessary to assess whether the effects of antioxidant feed additives on oxidative status are specific when feed is contaminated with DON-ZEN.     

Performance,feeding behaviour and microbial diversity in weaned piglets fed liquid diets based on water or wet wheat-distillers grain

Performance, nutrient digestibility, feeding behaviour, diarrhoea frequency and faecal microbial diversity was studied in weaned piglets allotted to dry feed (diet A), liquid feed with water (diet B) or liquid feed with wet wheat-distillers grain (diet C). There were no differences in digestibility of organic matter and energy, and the performance was similar between piglets fed liquid diets. Piglets fed diet A spent more time on eating/drinking compared with piglets fed liquid diets. The frequency of diarrhoea decreased (p?<?0.05) from from diet A (11 out of 16) to diet B (6 out of 16) and further to diet C (1 out 16). The type of diet did not affect the diversity of coliform bacteria or lactobacilli, but the composition of the Lactobacillus flora was changed. The lower diarrhoea frequency when feeding diet C may be due to a prophylactic effect induced by the inclusion of wet wheat-distillers grain in the diet.     

Improving retting of fibre through genetic modification of flax to express pectinases

Flax (Linum usitatissimum L.) is a raw material used for important industrial products. Linen has very high quality textile properties, such as its strength, water absorption, comfort and feel. However, it occupies less than 1% of the total textile market. The major reason for this is the long and difficult retting process by which linen fibres are obtained. In retting, bast fibre bundles are separated from the core, the epidermis and the cuticle. This is accomplished by the cleavage of pectins and hemicellulose in the flax cell wall, a process mainly carried out by plant pathogens like filamentous fungi. The remaining bast fibres are mainly composed of cellulose and lignin. The aim of this study was to generate plants that could be retted more efficiently. To accomplish this, we employed the novel approach of transgenic flax plant generation with increased polygalacturonase (PGI ) and rhamnogalacturonase (RHA) activities. The constitutive expression of Aspergillus aculeatus genes resulted in a significant reduction in the pectin content in tissue-cultured and field-grown plants. This pectin content reduction was accompanied by a significantly higher (more than 2-fold) retting efficiency of the transgenic plant fibres as measured by a modified Fried’s test. No alteration in the lignin or cellulose content was observed in the transgenic plants relative to the control. This indicates that the over-expression of the two enzymes does not affect flax fibre composition. The growth rate and soluble sugar and starch contents were in the range of the control levels. It is interesting to note that the RHA and PGI plants showed higher resistance to Fusarium culmorum and F. oxysporum attack, which correlates with the increased phenolic acid level. In this report, we demonstrate for the first time that over-expression of the A. aculeatus genes results in flax plants more readily usable for fibre production. The biochemical parameters of the cell wall components indicated that the fibre quality remains similar to that of wild-type plants, which is an important pre-requisite for industrial applications. Magdalena Musialak and Magdalena Wróbel-Kwiatkowska participated equally in the preparation of this paper     

Sowing density and harvest time affect fibre content in hemp (Cannabis sativa) through their effects on stem weight

Sowing density and harvest time are considered important crop management factors influencing fibre quantity and quality in hemp (Cannabis sativa). We investigated whether the effects of these factors are essentially different or that both factors affect stem weight and thereby total and long‐fibre content. The effects of all combinations of three sowing densities and three harvest times were studied for six different stem parts. Almost 500 samples consisting of stem parts from 50 plants and with a length of 50 cm were tested. Fibres were extracted by a controlled warm‐water retting procedure, followed by breaking and scutching. The initial sample weight was fractionated into retting losses, wood, tow and long fibre. In both Italy and the Netherlands, crops were successfully established with different stem densities (99–283 m^?2), plant heights (146–211 cm) and stem diameters (4.5–8.4 mm) at harvest. Stem dry matter yields (6.8–11.7 Mg ha^?1) increased with a delay in harvest time but were not affected by sowing density. Retting loss percentages were lower in lower stem parts and decreased with later harvest because maturation was associated with increasing amounts of fibre and wood. Within a certain stem part, however, the absolute retting losses were constant with harvest time. Multiple linear regression analyses showed that the amount of fibre in a hemp stem is almost completely determined by the weight and the position of that stem part. When the plant grows, the increase in dry matter is split up into fibres and wood in a fixed way. This total fibre/wood ratio was highest in the middle part of the stem and lower towards both bottom and top. Sowing density and harvest time effects were indirect through stem weight. The long‐fibre weight per stem increased with the total fibre weight and hence with stem weight. Stem weight increased with harvest time; as harvest time did not affect plant density, the highest long‐fibre yields were obtained at the last harvest time. The long fibre/total fibre ratio was lowest in the bottom 5 cm of the stems but similar for all other parts. Sowing density and harvest time effects again were indirect. Fibre percentages in retted hemp decreased with increasing stem weights towards a level that is presumably a variety characteristic. The dry matter increase between harvests, however, is much more important with respect to total and long‐fibre yield.     

Lignin deficiency in transgenic flax resulted in plants with improved mechanical properties

Flax (Linum usitatissimum L.) is a very important source of natural fibres used by the textile industry. Flax fibres are called lignocellulosic, because they contain mainly cellulose (about 70%), with hemicellulose, pectin and lignin. Lignin is a three-dimensional polymer with a high molecular weight, and it gives rigidity and mechanical resistance to the fibre and plant. Its presence means the fibres have worse elastic properties than non-lignocellulosic fibres, e.g. cotton fibres, which contain no lignin. The main aim of this study was to produce low-lignin flax plants with fibres with modified elastic properties. An improvement in the mechanical properties was expected. The used strategy for CAD down-regulation was based on gene silencing RNAi technology. Manipulation of the CAD gene caused changes in enzyme activity, lignin content and in the composition of the cell wall in the transgenic plants. The detected reduction in the lignin level in the CAD-deficient plants resulted in improved mechanical properties. Young's modulus was up to 75% higher in the generated transgenic plants (CAD33) relative to the control plants. A significant increase in the lignin precursor contents and a reduction in the pectin and hemicellulose constituents was also detected. A decrease in pectin and hemicellulose, as well as a lower lignin content, might lead to improved extractability of the fibres. However, the resistance of the transgenic lines to Fusarium oxysporum was over two-fold lower than for the non-transformed plants. Since Fusarium species are used as retting organisms and had been isolated from retted flax, the increased sensitivity of the CAD-deficient plant to F. oxysporum infection might lead to improved flax retting.     

In vitro fermentability and physicochemical properties of fibre substrates and their effect on bacteriological and morphological characteristics of the gastrointestinal tract of newly weaned piglets

Abstract

Fermentability of fibre has a great impact on the bacterial flora along the gastrointestinal tract of newly weaned piglets. Therefore, this parameter was determined by incubating in vitro different fibre substrates (chicory roots, sugar beet pulp, wheat bran and corn cobs) with contents of jejunum or caecum sampled from slaughtered pigs. Incubating with small intestinal contents, lactic acid was the only fermentation product. Fermentability was highest for chicory roots, followed by wheat bran and sugar beet pulp, while corn cobs were not fermented. Based on SCFA formed in the incubations with caecal contents, ranking of the fermentability of the fibre substrates was in the same order. The effect of adding different fibre substrates to diets of newly weaned piglets on bacteriological and morphological aspects of the gastrointestinal tract was also investigated. In Experiment 1 three groups of five piglets, weaned at four weeks of age, received a control feed (C), C supplemented with corn cobs (50 g/kg) or with chicory roots (20 g/kg). In Experiment 2, diet C was supplemented with sugar beet pulp (120 g/kg) or with wheat bran (75 g/kg). After three weeks animals were euthanized and digesta were sampled from stomach, proximal and distal jejunum, caecum and colon. Furthermore, mucosal scrapings were prepared and tissue samples were taken from jejunum, caecum and colon. Viscosity was determined for jejunal, caecal and colon contents. Corn cobs in the feed increased the number of total bacteria, lactobacilli and bifidobacteria in the stomach and proximal duodenum, while a decreased count of streptococci in distal jejunum contents was noted. Chicory roots increased the counts of Escherichia coli in the distal jejunum and on the mucosa, while sugar beet pulp decreased the number of lactobacilli on the mucosa only. Wheat bran seemed to increase the count of E. coli in jejunal digesta and on the mucosa, and also the number of lactobacilli in the stomach and jejunum. Bifidobacterial numbers were increased but only in the proximal part of the jejunum. Fibre substrates affected the concentration of lactate and SCFA in different parts of the intestinal tract. Feeding corn cobs increased villus length in the proximal jejunum by 13%. The number of intra-epithelial lymphocytes in the villous epithelium of proximal and distal jejunum was decreased by corn cobs and chicory roots supplementation while beet pulp and wheat bran had the opposite effect. In Experiment 1, apoptotic index of the mucosa of the distal jejunum was very low and decreased when corn cobs were fed. Mitotic index in the crypts was only affected by the wheat bran diet and a small decrease was noted. It was concluded that the fermentability of fibre was not an ideal criterion for predicting its effects on the flora. The effect of fibres on viscosity of digesta was negligible probably explaining the lack of clear and consistent influences on the intestinal mucosa.     

Determining the physical properties of flax fibre for industrial applications: the influence of agronomic practice

Field trials of fibre flax were sown in 2002 and 2003 comprising 29 and 26 flax varieties, respectively. In 2002, two nitrogen treatments of 40 and 80 kg ha^?1 were imposed. The trials were sprayed with a desiccating herbicide prior to retting at 35 and 15 days after midpoint of flowering in 2002 and 2003, respectively, and were harvested once retting had completed. Fibre was extracted from the flax stems using a laboratory‐scale scutcher and hackling pins, and long and total fibre yields were determined. The breaking load of flax technical fibres was assessed using a novel technique employing ‘zero twist’ yarns. Fineness was assessed using the Wool Industries Research Association airflow method. The tenacity of a single technical fibre was then derived from the average breaking load of the yarn and knowledge of its fineness. Both flax variety and season were found to contribute to variations in fibre fineness and strength, with the dry season in 2003 leading to less variation across the varieties and much finer fibres. Few of the varieties were found to be stable across seasons, and environmental variation accounted for 96% of the variation in fibre fineness between years, and 69% of the variation in tensile strength and breaking load. Fibre yield was found to be related to fibre fineness, with the coarser fibres corresponding to higher yields. The new yarn test presented herein has been shown to be a valid and useful method for determining the tensile properties of technical flax. The varieties and the sample sizes required to adequately measure variation in fibre properties are discussed.     

Effects of dietary addition of heat-killed Mycobacterium phlei on growth performance,immune status and anti-oxidative capacity in early weaned piglets

The contradiction between high susceptibility of early weaned piglets to enteric pathogens and rigid restriction of antibiotic use in the diet is still prominent in the livestock production industry. To address this issue, the study was designed to replace dietary antibiotics partly or completely by an immunostimulant, namely heat-killed Mycobacterium phlei (M. phlei). Piglets (n = 192) were randomly assigned to one of the four groups: (1) basal diet (Group A), (2) basal diet + a mixture of antibiotics (80 mg/kg diet, Group B), (3) basal diet + a mixture of antibiotics (same as in Group B, but 40 mg/kg diet) + heat-killed M. phlei (1.5 g/kg diet) (Group C) and (4) basal diet + heat-killed M. phlei (3 g/kg diet) (Group D). All piglets received the respective diets from days 21 to 51 of age and were weaned at the age of 28 d. Compared with the Control (Group A), in all other groups the average daily gain, average daily feed intake, small intestinal villus height:crypt depth ratio and protein levels of occludin and ZO-1 in the jejunal mucosa were increased. A decreased incidence of diarrhoea in conjunction with an increased sIgA concentration in the intestinal mucosa and serum IL-12 and IFN-γ concentrations was found in groups supplemented with heat-killed M. phlei (Groups C and D), but not in Group B. Groups C and D also showed decreased IL-2 concentrations in the intestinal mucosa with lower TLR4 and phosphor-IκB protein levels. The antioxidant capacity was reinforced in Groups C and D, as evidenced by the reduction in malondialdehyde and enhanced activities of antioxidant enzymes in serum. These data indicate that heat-killed M. phlei is a promising alternative to antibiotic use for early weaned piglets via induction of protective immune responses.     

Effects of soybean hulls and lignocellulose on performance,nutrient digestibility,microbial metabolites and immune response in piglets

ABSTRACT

A feeding trial with 96 piglets was performed to investigate the effect of added soluble (SDF) and insoluble dietary fibre (IDF) sources on performance, apparent total tract digestibility (ATTD), concentration of microbial metabolites and pro-inflammatory marker genes as indicators for immune response. Piglets were allotted to four treatments (T): T1 control, T2 with soybean hulls (IDF/SDF: 8.35) and T3 and T4 with two different kinds of lignocellulose (IDF/SDF: >70). Diets were isofibrous for their value of total dietary fibre to underline the particular physicochemical properties of fibre sources. No differences were observed regarding average daily feed intake, average daily gain (ADG), feed conversion ratio and body weight, while T2 expressed higher ADG in the grower phase (day 14-54) vs. T3. Soybean hulls (T2) resulted in higher ATTD of dry matter and organic matter vs. T4; ether extract vs. T1 and neutral detergent fibre vs. T1, T2 and T3. The concentration of short chain fatty acids did not differ among treatments. Ileal digesta in T2 generated higher amounts of cadaverine vs. T3 and T4, likewise T1 vs. T4. Finally, no impact on immune response was detected. In conclusion, soybean hulls affected ATTD positively and lignocellulose prevented the formation of cadaverine, no overall direct response of SDF nor of IDF for the inclusion level were observed.     

Body composition, muscle fibre characteristics and postnatal growth capacity of pigs born from sows supplemented with L-carnitine

Recently, it has been shown that supplementation of sows with L-carnitine increases their plasma concentrations of insulin-like growth factor (IGF)-I, and it has been hypothesized that this may stimulate fetal myogenesis. This study was performed to investigate whether piglets of sows supplemented with L-carnitine differ in muscle fibre characteristics, chemical body composition and postnatal growth capability from pigs of control sows. Muscle fibre characteristics and chemical body composition were determined at weaning in 21 piglets of control sows and 21 piglets of sows treated with L-carnitine with similar body weights; postnatal growth capability was determined from weaning until slaughter at a body weight of 118 kg in 80 pigs of control sows and 80 pigs of sows treated with L-camitine which had also similar body weights at weaning. Piglets of sows supplemented with L-carnitine did not differ in number, area, diameter and type (percentages of slow twitch oxidative + fast twitch oxidative fibres, and fast twitch glycolytic fibres) of muscle fibres in m. longissimus dorsi and m. semitendinosus and in chermical body composition (concentrations of dry matter, crude protein, crude fat) from piglets of control sows. Postnatal growth capability (body weight gains, feed conversion ratio) from weaning to slaughter as well as carcass composition (carcass yield, meat thickness, fat thickness) was also not different between pigs of sows treated with L-carnitine and pigs of control sows. In conclusion, data of this study do not support the hypothesis that L-carnitine supplementation of sows during pregnancy enhances fetal muscle fibre development and increases postnatal growth capability of the offspring.