The Effect of Sodium Chloride on Radiation Resistance and Recovery of Irradiated Anaerobic Spores

Sodium chloride (3% and 6% w/v) were without effect on the radiation resistance of spores of Clostridium sporogenes and Cl. oedematiens type C. Increasing doses of gamma radiation rendered spores increasingly sensitive to post radiation inhibition by sodium chloride in the plating medium.     

Role of Curing Agents in the Preservation of Shelf-stable Canned Meat Products

Experiments were conducted to gain a better understanding of the mechanism by which sodium chloride, sodium nitrate, and sodium nitrite supplement the action of heat in preserving canned cured meat products. Heated spores of putrefactive anaerobe 3679h were less tolerant of all three curing agents in the outgrowth medium than were unheated spores. When the curing agents were added to the heating menstruum, but not to the outgrowth medium, sodium chloride and sodium nitrate tended to protect the spores against heat injury, but sodium nitrite did not. When the spores were both heated and cultured in the presence of the curing agents: (i) nitrate and salt increased the apparent heat resistance at low concentrations (0.5 to 1%) but decreased it at concentrations of 2 to 4%; (ii) nitrite was markedly inhibitory, especially at pH 6.0. At the normal pH of canned luncheon meats (approximately 6.0), nitrite appears to be the chief preservative agent against spoilage by putrefactive anaerobes.     

The Effect of Sodium Chloride on Heat Resistance and Recovery of Heated Spores of Clostridium sporogenes (PA 3679/S2)

S ummary . In 3% and 6% (w/v) sodium chloride solutions the heat resistances of spores of Clostridium sporogenes were the same as in water. Heating to give a 0.1% survival rendered the surviving spores more sensitive to inhibition by sodium chloride in the recovery medium.     

Properties of Hg- and Cd-spores of Bacillus megaterium QM B1551

Hg- and Cd-spores of Bacillus megaterium QM B1551 were produced in Schaeffer's medium containing mercuric chloride and cadmium chloride respectively. Metals were added to the medium at 9 hr of incubation (Stage V) to give a final concentration of 50 microM. It was found by electron microscopic and biochemical studies that the coats of both Hg- and Cd-spores were thinner than those of control spores. Of the total Hg and Cd in the spores, 77% of the Hg and 63% of the Cd were detected in the spore coats. Hg- and Cd-spores were less resistant to heat and more sensitive to germinants than control spores. Other properties of Hg- and Cd-spores were similar to those of control spores. These results suggest that the spore coat has some relationship to the heat resistance and germinability of spores.     

Conditions Affecting Germination of Clostridium botulinum 62A Spores in a Chemically Defined Medium

Spores of Clostridium botulinum type 62A were germinated in a chemically defined medium (8 mm l-cysteine, 11.9 mm sodium bicarbonate, 4.4 mm sodium thioglycolate; buffered with 100 mm TES, pH 7.0). The rate and extent of germination were increased when an aqueous spore suspension was heated sublethally (80 C, 60 min) before addition to the germination medium. Neither sublethal nor lethal doses of gamma radiation had any marked effect on subsequent germination. Maximum germination (>90% in 2 hr) in the defined medium occurred in the pH range of 6.5 to 7.5, at 30 to 37 C, with an l-cysteine level of 8 mm. Increasing l-cysteine to 32 mm increased the rate (over that with 8 mm l-cysteine) but not the extent of germination. The rate and extent of germination increased with NaHCO(3) addition to 8.3 mm, but increasing levels to 11.9 mm had no further effect. For maximum germination, 2.2 mm sodium thioglycolate was required and higher levels (to 8.8 mm) had no further enhancing or inhibitory effect. Under optimal conditions for germination, 97% of the spores had become heat sensitive; 98% had become sensitive to radiation; 88 and 91% had become phase dark and stainable, respectively, and the spore suspension had lost 46% of its initial optical density by 2 hr. Loss of heat resistance preceded loss of radiation resistance, acquisition of stainability, and phase darkening by about 12 min.     

Inhibition of Clostridium perfringens by heated combinations of nitrite, sulfur, and ferrous or ferric ions.

Heating mixtures of sodium nitrite, cysteine, and either ferrous sulfate or ferric chloride at 121 C for 20 min at pH 6.5 or 6.3 produced a potent inhibitor of Clostridium perfringens vegetative cells and spores when added to previously heat-sterilized fluid thioglycolate medium. When the mixtures containing FeSO4 at pH 5.2 or FeCl3 at pH 2.7 were heated, the inhibitory effect was not produced. These responses seem to eliminate the possibility that cysteine nitrosothiol is the agent responsible for the heated-nitrite inhibition known as the Perigo effect. The variable pH responses also cast doubt upon the role of the black Roussin salt as the agent of the Perigo effect.     

Inhibition of Clostridium perfringens by heated combinations of nitrite, sulfur, and ferrous or ferric ions.

Heating mixtures of sodium nitrite, cysteine, and either ferrous sulfate or ferric chloride at 121 C for 20 min at pH 6.5 or 6.3 produced a potent inhibitor of Clostridium perfringens vegetative cells and spores when added to previously heat-sterilized fluid thioglycolate medium. When the mixtures containing FeSO4 at pH 5.2 or FeCl3 at pH 2.7 were heated, the inhibitory effect was not produced. These responses seem to eliminate the possibility that cysteine nitrosothiol is the agent responsible for the heated-nitrite inhibition known as the Perigo effect. The variable pH responses also cast doubt upon the role of the black Roussin salt as the agent of the Perigo effect.     

Improved Medium for Sporulation of Clostridium perfringens

An improved sporulation medium has been developed in which all five strains of Clostridium perfringens tested exhibited a 100- to 10,000-fold increase in numbers of spores when compared with spore yields in SEC medium under comparable conditions. In addition, three of five strains produced a 100- to 1,000-fold increase, with the remaining two strains yielding approximately the same numbers of spores, when compared with strains cultured in Ellner medium. At the 40-hr sampling time, 18 of 27 strains produced a 10- to 100-fold increase in numbers of spores in our medium, when compared to spore production obtained in a medium recently reported by Kim et al. The new medium contained yeast extract, 0.4%; proteose peptone, 1.5%; soluble starch, 0.4%; sodium thioglycolate, 0.1%; and Na(2)HPO(4). 7H(2)O, 1.0%. In some cases, the spore yield could be increased by the addition of activated carbon to the new medium. The inclusion of activated carbon in the medium resulted in spores with slightly greater heat resistance than spores produced in the new medium without added carbon or in SEC or in Ellner medium. The major differences in heat resistance of the various strains appeared to be genetically determined rather than reflections of a particular sporulation medium. A definite heat-shock requirement was shown for four of four strains, with the optimal temperature ranging from 60 C for a heat-sensitive strain to 80 C for a heat-resistant strain. Heating for 20 min at the optimal temperature resulted in a 100-fold increase over the viable count obtained after heating for 20 min at 50 C.     

Sporulation of Clostridium perfringens in a Modified Medium and Selected Foods

A modified sporulation medium for Clostridium perfringens was formulated in which a larger number of spores were produced than in SEC broth and in which spores of greater heat resistance were produced than in Ellner's medium when it was also used as the suspending medium. This modified medium consisted of 1.5% peptone; 3.0% Trypticase; 0.4% starch; 0.5% NaCl; and 0.02% MgSO(4). The addition of 0.1% sodium thioglycolate and 0.0001% thiamine hydrochloride was optional. The optimal temperature for sporulation of five strains was 37 C in comparison with 5, 22, and 46 C. Sporulation had occurred by 6 hr and was essentially complete after 20 hr at 37 C. Noyes veal broth without glucose also supported the formation of heat-resistant spores but in smaller numbers than did the modified medium. Very low numbers of spores, or none, were produced under the same conditions in pea or tuna slurries.     

Dry Heat or Gaseous Chemical Resistance of Bacillus subtilis var. niger Spores Included Within Water-soluble Crystals

Inclusion of spores of Bacillus subtilis var. niger in water-soluble crystals increased the resistance of the spores to dry heat and to a gaseous mixture of methyl bromide and ethylene oxide. Resistance of spores in glycine crystals to dry heat at 125 C was increased 5 to 24 times compared to unprotected spores. There appeared to be a positive correlation between the size of the crystal and the degree of resistance. The resistance to dry heat of spores included in sodium chloride crystals was about six times greater than unprotected spores. A gaseous mixture of methyl bromide (964 mg/liter) and ethylene oxide (642 mg/liter) at 37% relative humidity was ineffective in sterilizing spores enclosed within these water-soluble crystals, as was ethylene oxide alone. However, if the relative humidity was sufficiently high to dissolve the crystals during exposure to the vapor, viable-spore counts were drastically reduced or were negative. The surfaces of crystals grossly contaminated with dry spores were sterilized by exposure to gaseous ethylene oxide. Sterilization of heat-labile or moisture-labile materials with a critical requirement for sterility, as in planetary probes or drugs, may be complicated by the presence of spores in naturally occurring water-soluble crystals. This phenomenon is similar to the protection afforded spores entrapped in solid plastics.     

Murein components rescue developmental sporulation of Myxococcus xanthus

Murein (peptidoglycan) components are able to rescue sporulation in certain sporulation-defective mutants of Myxococcus xanthus. N-Acetylglucosamine, N-acetylmuramic acid, diaminopimelic acid, and D-alanine each increase the number of spores produced by SpoC mutants. When all four components are included they have a synergistic effect, raising the number of spores produced by SpoC mutants to the wild-type level. Murein-rescued spores are resistant to heat and sonic oscillation and germinate when plated on a nutrient-rich medium. They appear to be identical to fruiting body spores in their ultrastructure, in their protein composition, and in their resistance to boiling sodium dodecyl sulfate. Murein rescue of sporulation, like fruiting body sporulation, requires high cell density, a low nutrient level, and a solid surface.     

Sporulation of Clostridium perfringens (welchii) in Four Laboratory Media

S ummary . Sporulation of 7 strains of Clostridium perfringens ( welchii ) was investigated in 4 laboratory media. A method to induce rapid and simultaneous sporulation was attempted which involved obtaining a purely vegetative culture to inoculate the test media. Heat resistance of spores produced in the individual media by each of 4 selected strains was investigated. The clean spores for the heating tests were obtained by a special procedure which included chilling to 6° for a minimum of 1 week immediately following the usual incubation period, then centrifuging, resuspending to volume in 0.85% NaCl solution and pasteurizing at 75° for 20 min before subjecting to the heating tests. Morphology of each strain was studied using stained microscopic preparations from the 24 h sporulating cultures.
In the Ellner medium spore counts approaching 10⁷/ml were recorded and this medium appeared to be the most efficient when judged in terms of numbers of spores produced. In other media the counts were in the range 10⁴-10⁵ spores/ml. Cooked meat medium yielded slightly higher spore counts than did either SEC broth or modified Wagenaar & Dack medium, the latter contained in a dialysis sac apparatus. A period of chilling to 6° for a minimum of 1 week following incubation enhanced maturation in all cultures except those grown in SEC broth for 24 h or 15 days and those grown 15 days in the modified Wagenaar & Dack medium.
Considerable heat resistance, expressed as percentage spore survival, was recorded for spores of 4 strains when heated at 80°, and heat resistance generally increased with lengthening of incubation time for the culture. Survival of spores heated at 100° for 10 min was usually less than 0.01% but spores in SEC broth after 15 days showed a somewhat greater heat resistance than the others. In no instance did total destruction of spores occur at 100°.     

Heat Injury of Bacillus subtilis Spores at Ultrahigh Temperatures

The following three criteria indicated that Bacillus subtilis A spores were injured, but not completely inactivated, by ultrahigh temperature treatment. (i) Significant reductions in survivors were observed when spores were enumerated with a standard medium but not when the medium contained added CaCl(2) and sodium dipicolinate. (ii) After a damaging heat treatment, more survivors were enumerated with the standard medium after incubation at 32 C than at 45 C, which was opposite to the result with untreated or slightly heated spores. (iii) Apparent numbers of survivors increased during the initial period of 3 C storage when enumerated with the standard medium at 45 C. No injury was evident when survivors were enumerated at either incubation temperature with the medium containing added CaCl(2) and sodium dipicolinate. Heat activation of the spores did not significantly influence the appearance of heat injury. The data suggested that the heat injury occurred in a germination system which was required in the absence of CaCl(2) and sodium dipicolinate.     

The effect of acid shock on sporulating Bacillus subtilis cells

AIMS: To study the effect of acid shock in sporulation on the production of acid-shock proteins, and on the heat resistance and germination characteristics of the spores formed subsequently. METHODS AND RESULTS: Bacillus subtilis wild-type (SASP-alpha+beta+) and mutant (SASP-alpha-beta-) cells in 2 x SG medium at 30 degrees C were acid-shocked with HCl (pH 4, 4.3, 5 and 6 against a control pH of 6.2) for 30 min, 1 h into sporulation. The D85-value of B. subtilis wild-type (but not mutant) spores formed from sporulating cells acid-shocked at pH 5 increased from 46.5 min to 78.8 min, and there was also an increase in the resistance of wild-type acid-shocked spores at both 90 degrees C and 95 degrees C. ALA- or AGFK-initiated germination of pH 5-shocked spores was the same as that of non-acid-shocked spores. Two-dimensional gel electrophoresis showed only one novel acid-shock protein, identified as a vegetative catalase 1 (KatA), which appeared 30 min after acid shock but was lost later in sporulation. CONCLUSIONS: Acid shock at pH 5 increased the heat resistance of spores subsequently formed in B. subtilis wild type. The catalase, KatA, was induced by acid shock early in sporulation, but since it was degraded later in sporulation, it appears to act to increase heat resistance by altering spore structure. SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first proteomic study of acid shock in sporulating B. subtilis cells. The increasing spore heat resistance produced by acid shock may have significance for the heat resistance of spores formed in the food industry.     

Heat resistance of Paenibacillus polymyxa in relation to pH and acidulants

The efficacy of different organic acids in decreasing the heat resistance of Paenibacillus polymyxa spores was assessed. The relationship between concentration of the undissociated form of different organic acids and decrease in heat resistance was also investigated. The heat resistance of P. polymyxa spores was tested in distilled water at 85, 90 and 95 degrees C, at pH4 and in the presence of 50, 100 and 200 mmol l(-1) of the undissociated form of lactic, citric or acetic acid and sodium citrate or acetate. The undissociated form of organic acids was responsible for increasing the heat sensitivity of spores. The most effective acid was lactic acid. The D values of the spores decreased rapidly (between 74 and 43%) in the presence of 50 mmol l(-1) of the undissociated form of organic acid, and increasing concentrations of these forms affected the heat resistance of spores less than proportionally. The heat resistance of the spores in milk was approximately threefold lower than in distilled water. This work has shown that the undissociated fraction of organic acids increases, albeit non-linearly, the sensitivity of spores to heat, even in complex substrates such as milk. By knowing the amount of organic acids added to a given substrate, their dissociation constants and the final pH, it could be possible to estimate the concentration of undissociated forms and the corresponding increase in lethality of heat treatments. This would help the food industry to maximize the lethality achieved by heat processes and/or safely reduce the heat treatments already in use.     

Resistance of Bacillus Spores to Combined Sporicidal Treatments

S ummary . Moist heat at 82° (100° for Bacillus stearothermophilus ) and solutions of 0.2% w/v chlorocresol or 0.01% w/v benzalkonium chloride at 24° separately showed no sporicidal activity against B. pumilis, B. stearothermophilus, B. subtilis and B. subtilis var. niger . Spores of the last organism were the most sensitive to γ radiation, the D value being 0.16 Mrad. Prior irradiation with a dose of 0.16 Mrad brought about only a slight increase in the sensitivity of the spores to moist heat. The presence of bactericide during irradiation did not affect radiation resistance. Inactivation rates were greater when the spores were heated in the presence of a bactericide than in aqueous suspension and benzalkonium chloride was more active than chlorocresol. Chlorocresol enhanced the heat activation of B. stearothermophilus at 100°. Irradiation in the presence of 0.2% w/v chlorocresol or 0.01% w/v benzalkonium chloride had no effect on the subsequent resistance of the spores when heated in the presence of these bactericides. It is concluded that it is unlikely that combinations of moist heat, radiation and bactericides, each less severe than when used in an accepted sterilization process, will lead to an alternative process which, while less damaging to the materials being sterilized, would still maintain the accepted standards of freedom from contamination.     

The effect of recovery conditions on the apparent heat resistance of Bacillus cereus spores

The effect of recovery media and incubation temperature on the apparent heat resistance of three ATCC strains (4342, 7004 and 9818) of Bacillus cereus spores were studied. Nutrient Agar (NA), Tryptic Soy Agar (TSA), Plate Count Agar (PCA) and Milk Agar (MA) as the media and temperatures in the range of 15–40°C were used to recover heated spores. Higher counts of heat injured spores were obtained on PCA and NA. The optimum subculture temperature was about 5°C below the optimum temperature for unheated spores. No significant differences in heat resistance were observed with the different recovery conditions except for strains 4342 and 9818 when MA was used as plating medium.
Large differences in D -values were found among the strains ( D ₁₀₀=0·28 min for 7004; D ₁₀₀=0·99 min for 4342; D ₁₀₀= 4·57 min for 9818). The 7004 strain showed a sub-population with a greater heat resistance. The z values obtained for the three strains studied under the different recovery conditions were similar (7·64°C 0·25).     

Studies on halotolerance in a moderately halophilic bacterium. Effect of betaine on salt resistance of the respiratory system

The role of betaine as a factor influencing the salt resistance of the respiratory system in resting cells of the moderately halophilic halotolerant bacterium Ba(1) was studied. Betaine accelerated succinate oxidation in cells obtained from low-salt medium, and stimulation of the respiratory rate was stronger the higher the sodium chloride concentration in the assay medium. The stimulatory effect also depended on the ratio of betaine concentration to the amount of bacteria present. Accumulation of labelled betaine by the bacterial cells was demonstrated; like the respiratory stimulation, it was favourably influenced by an increase in the sodium chloride concentration of the medium. In cells harvested from a high-salt medium and washed with 2.0m-sodium chloride, betaine caused no increase in the respiratory rate, nor was the already high salt resistance of the respiratory system further improved by the addition of betaine. When, however, these cells lost their salt resistance as a result of washing in the absence of sodium chloride, betaine was able to restore it to its original level. In contrast with respiration in low-salt-grown bacteria, that in high-salt-grown cells was not affected by betaine, even after they were washed in the absence of sodium chloride, when the sodium chloride concentration was optimum.     

Inactivation of Clostridium perfringens Type A Spores at Ultrahigh Temperatures

The inactivation of Clostridium perfringens type A spores (three strains of different heat resistances) at ultrahigh temperatures was studied. Aqueous spore suspensions were heated at 85 to 135 C by the capillary tube method. When survivors were enumerated on the standard plating medium, the spores appeared to have been rapidly inactivated at temperatures above 100 C. The addition of lysozyme to the plating medium did not affect the recovery of spores surviving the early stages of heating, but lysozyme was required for maximal recovery of spores surviving extended heat treatments. The percentage of survivors requiring lysozyme for colony formation increased greatly with longer exposure times or increasing treatment temperature. Time-survivor curves indicated that each spore suspension was heterogeneous with respect to the heat resistance of spore outgrowth system or in the sensitivity of the spores to lysozyme. Recovery of survivors on the lysozyme containing medium revealed greater heat resistance for one strain than has been reported for spores of many mesophilic aerobes and anaerobes. The spores of all three strains were more resistant to heat inactivation when suspended in phosphate buffer, but a greater percentage of the survivors required lysozyme for colony formation.