Patulin accumulation in apples by Penicillium expansum during postharvest stages

AIMS: The aim of this study was to assess the opportunities of Penicillium expansum to develop and produce patulin in apples during cold storage and in the steps prior to processing of apple products. METHODS AND RESULTS: Two lots of apples var. Golden with different ripeness degree were used. Half of each lot was fungicide treated. Apples were inoculated with P. expansum and stored at 1 degrees C for 6 weeks. The extent of lesions and patulin accumulation both at the end of cold storage and after 3 days at 20 degrees C were assessed. Short storage at 20 degrees C aimed to simulate the transport and storage steps at room temperature before processing. Lesion size significantly increased during the storage at 20 degrees C. An interaction between fungicide treatment and ripeness degree was found; efficiency of fungicide treatment was higher for ripe apples. Although lesions were evident after cold storage, no patulin was detected. Patulin was detected only when fruits were further stored at 20 degrees C. Neither ripeness degree nor fungicide treatment affected patulin accumulation. CONCLUSIONS: Cold storage periods of 6 weeks do not lead to patulin accumulation. SIGNIFICANCE AND IMPACT OF THE STUDY: Shortening preprocessing times at warm temperatures would result into a reduction in patulin content at initial steps of fruits entering the processing plants.     

Patulin is a cultivar‐dependent aggressiveness factor favouring the colonization of apples by Penicillium expansum

The blue mould decay of apples is caused by Penicillium expansum and is associated with contamination by patulin, a worldwide regulated mycotoxin. Recently, a cluster of 15 genes (patA–patO) involved in patulin biosynthesis was identified in P. expansum. blast analysis revealed that patL encodes a Cys₆ zinc finger regulatory factor. The deletion of patL caused a drastic decrease in the expression of all pat genes, leading to an absence of patulin production. Pathogenicity studies performed on 13 apple varieties indicated that the PeΔpatL strain could still infect apples, but the intensity of symptoms was weaker compared with the wild‐type strain. A lower growth rate was observed in the PeΔpatL strain when this strain was grown on nine of the 13 apple varieties tested. In the complemented PeΔpatL:patL strain, the ability to grow normally in apple and the production of patulin were restored. Our results clearly demonstrate that patulin is not indispensable in the initiation of the disease, but acts as a cultivar‐dependent aggressiveness factor for P. expansum. This conclusion was strengthened by the fact that the addition of patulin to apple infected by the PeΔpatL mutant restored the normal fungal colonization in apple.     

Activity of trans-2-hexenal against Penicillium expansum in 'Conference' pears

AIMS: To investigate the effects of trans-2-hexenal on blue mould disease, patulin content and fruit quality in 'Conference' pears. METHODS AND RESULTS: Fruits, wounded and inoculated with Penicillium expansum or non-inoculated, were exposed to trans-2-hexenal vapour treatment (12.5 microl l(-1)) at 20 degrees C. A greater reduction of decay was obtained by treatment application 24 or 48 h after inoculation, in contrast trans-2-hexenal application 2 h after inoculation was ineffective. Fruit storage temperature (-1 degrees C) after treatment did not affect the antifungal activity. Although 2-h exposure to trans-2-hexenal was effective in reducing blue mould, an exposure of at least 8 h was required to reduce fruit patulin content. Treatments did not affect fruit physical-chemical characteristics. After 6 days at 20 degrees C following exposure, trans-2-hexenal residue in treated fruits was less than the natural content of the compound in unripe fruits. CONCLUSIONS: trans-2-Hexenal treatment is effective in the reduction of blue mould infections and patulin content in Conference pears when applied 24-48 h after pathogen inoculation. SIGNIFICANCE AND IMPACT OF THE STUDY: trans-2-Hexenal could be a natural alternative to fungicides in the control of P. expansum infections. Further work is needed to study the methods and conditions avoiding the persistence of off-odours and off-flavours in pears after their exposure to trans-2-hexenal vapours.     

Thiabendazole resistance and mutations in the β-tubulin gene of Penicillium expansum strains isolated from apples and pears with blue mold decay

Penicillium expansum is the causal agent of blue mold rot, a postharvest decay of stored fruits. This fungus also produces the mycotoxins patulin and citrinin. Control of P. expansum still relies mainly on the use of fungicides such as thiabendazole. Since its introduction, resistant strains have been reported. The aim of this work was to investigate the thiabendazole resistance and mutations in the β-tubulin gene of P. expansum strains isolated from apples and pears with blue mold decay from Spain. A total of 71 strains of P. expansum were scored for resistance to thiabendazole and the β-tubulin gene was sequenced. Out of 71 strains, 37 were sensitive and 34 were resistant to thiabendazole. Regarding the β-tubulin gene sequence, 10 different genetic types were determined, with a 99.7–100% similarity. When the amino acid sequence was deduced, five different amino acid sequences were found. All except one of the sensitive strains lacked mutations in the region sequenced. Of the 34 resistant strains, only eight had mutations that involved the residues 198 and 240. All the strains with mutations at position 198 always corresponded to resistant isolates. However, a high percentage of resistant strains had no mutations in the region of the β-tubulin gene sequenced, and so other mechanisms may be involved in thiabendazole resistance.     

扩展青霉碱性脂肪酶基因在毕赤酵母中的高效表达

将编码扩展青霉碱性脂肪酶 (PEL)的cDNA克隆到酵母整合型质粒pPIC3.5K ,电转化His4缺陷型巴斯德毕赤酵母 (Pichiapastoris)GS115 ,通过橄榄油 MM平板及PCR方法筛选和鉴定重组子。重组子发酵液经SDS PAGE分析、橄榄油检验板鉴定 ,表明扩展青霉碱性脂肪酶基因在巴斯德毕赤酵母中获得了高效表达。表达蛋白分泌至培养基中 ,分子量约 2 8kD ,与扩展青霉碱性脂肪酶大小一致 ,占分泌蛋白的 95 %。橄榄油检验板检验表明该表达蛋白可分解橄榄油 ,通过优化该表达菌的发酵条件 ,以橄榄油为底物进行酶活测定 ,其发酵液酶活可达 2 6 0u mL。     

Comparison of methods to detect resistance of Penicillium expansum to thiabendazole

Aims:  Because of the lack of a standard method, the aim of this work is to evaluate the suitability of the broth microdilution method CLSI M38-A in determining the resistance level of some Penicillium expansum isolates to thiabendazole (TBZ). The ability of the isolates to produce patulin (PAT) and citrinin (CIT) has been also assessed.
Methods and Results:  Penicillium expansum isolates (128) were assayed (apples, pears, grapes and five reference strains). It was observed that 69·4% of the strains isolated from apples and pears were resistant to TBZ. Sensitive isolates were inhibited at 0·25–0·5 μg ml⁻¹ whilst resistant isolates still grew at 512 μg ml⁻¹. PAT was produced by all P. expansum isolates. CIT was detected in 98·8% of TBZ-resistant isolates and in 89·1% of the TBZ-sensitive isolates.
Conclusions:  The preliminary screening method combined with the adaptation of the method CLSI M38-A, can be a good strategy to be used in assessing the in vitro activity of TBZ against a large number of isolates.
Significance and Impact of the Study:  The proposed methodology can be a contribution to the standardization of susceptibility tests to fungicides against P. expansum.     

由扩展青霉(Penicillium expansum)PF868产生脂肪酶催化油脂水解的研究

研究了由扩展青霉（Ｐｅｎｉｃｉｌｉｕｍｅｘｐａｎｓｕｍ）ＰＦ８６８产生脂肪酶催化水解三种油脂（橄榄油、豆油、鱼油）的影响因素与工艺条件,其中包括：水解时间、温度、ｐＨ、酶量、油水比及添加剂,并用气相色谱对产品脂肪酸进行了分析鉴定,初步分析其催化水解的脂肪酸的特异性     

D92P点突变对扩展青霉碱性脂肪酶最适作用温度的改善

利用重叠延伸PCR法对扩展青霉碱性脂肪酶(PEL)基因进行体外定点突变,并构建了含突变基因的重组质粒pPIC3．5K—lip-D92P。将该质粒在毕赤酵母GS115菌株中表达。与野生型表达产物PEL-GS相比较,突变体表达产物PELD92P—GS最适作用温度为45℃,比野生型提高了5℃;其热稳定性与野生型相当;突变体在40℃下的表达量为109U／mL,约为野生型的29％。结果分析表明,Pro替代Asp^92后,可能是由于Pro一级结构的特点,使酶结构更加稳定,在高温下更适于与底物结合。     

LaeA regulation of secondary metabolism modulates virulence in Penicillium expansum and is mediated by sucrose

Penicillium expansum, the causal agent of blue mould rot, is a critical health concern because of the production of the mycotoxin patulin in colonized apple fruit tissue. Although patulin is produced by many Penicillium species, the factor(s) activating its biosynthesis are not clear. Sucrose, a key sugar component of apple fruit, was found to modulate patulin accumulation in a dose‐responsive pattern. An increase in sucrose culture amendment from 15 to 175 mm decreased both patulin accumulation and expression of the global regulator laeA by 175‐ and five‐fold, respectively, whilst increasing expression of the carbon catabolite repressor creA. LaeA was found to regulate several secondary metabolite genes, including the patulin gene cluster and concomitant patulin synthesis in vitro. Virulence studies of ΔlaeA mutants of two geographically distant P. expansum isolates (Pe‐21 from Israel and Pe‐T01 from China) showed differential reduction in disease severity in freshly harvested fruit, ranging from no reduction for Ch‐Pe‐T01 strains to 15%–25% reduction for both strains in mature fruit, with the ΔlaeA strains of Is‐Pe‐21 always showing a greater loss in virulence. The results suggest the importance of abiotic factors in LaeA regulation of patulin and other secondary metabolites that contribute to pathogenicity.     

三种拮抗酵母菌对苹果采后青霉病的抑制效果

从苹果果实上分离获得的50余种酵母菌中筛选出了能够有效地抑制苹果青霉病（Peniclium expansum Link)的丝孢酵母（Trichosporon pullulans(Lindner.)Diddens and Lodder)。罗伦隐球酵母（Cryptococcus laurentii(Kuffer.)skin-ner)和粘红酵母（Rhodotorula glutinis(Fresen.)F.C.Harrison)。其中,抑病效果最好的T.pullulans是一种用于采后果实生物防治的新型拮抗菌,研究了这三种拮抗菌不同浓度处理和外加营养物质以及与钙配合使用对苹果青霉病的抑病效果。实验结果表明;酵母菌浓度越高,抑病作用越强;外源营养物质的加入削弱了酵母菌的拮抗效果;在C.laurentii的细胞悬浮液中加入0.18mol/L的CaCl2能显著提高其抑病能力。但增加CaCl2对T.pullulans和R.glutinis的抑病效果却没有明显作用。     

扩展青霉碱性脂肪酶基因5'端侧翼区域的克隆与鉴定

应用衔接头PCR技术,扩增得到约2000 bp的扩展青霉碱性脂肪酶基因5’端侧翼区域的单一产物。对该产物测序并提交GenBank数据库(GenBank accession DQ677520),经序列比对分析,发现该序列具有真核启动子序列的基本结构特征,含有TATA盒、CAAT盒、GC盒等元件。将扩增得到的脂肪酶基因5’端侧翼序列,连接到含有绿色荧光蛋白(GFP)报告基因的质粒中,构建了一个重组表达质粒,转化大肠杆菌细胞。荧光显微观察大肠杆菌阳性转化子发出荧光,侧翼序列含有启动子功能得到确认。     

Modelling the inhibitory effect of copper sulfate on the growth of Penicillium expansum and Botrytis cinerea

Aims: This study aimed to investigate the effect of copper sulfate (from 0 to 8 mmol kg^?1) on radial growth rate and lag time of two moulds responsible for vine grapes spoilage: Penicillium expansum strain 25·03 and Botrytis cinerea, strains BC1 and BC2. Methods and results: A new model was developed to describe tailing and shoulders in the inhibition curves. Because of tailing, the minimum inhibitory concentration (MIC), was not defined as the concentration at which no growth was observed, but as the concentration at which the lag time was infinite. The concentrations at which μ = μ_opt/2, (Cu₅₀), were in the range of 2·2–2·6 mmol kg^?1. Radial growth rate of P. expansum and the reciprocal of the lag time were linearly correlated (r = 0·84). In contrast, in the range 0–4 mmol kg^?1, an inhibition of growth of B. cinerea was observed whereas germination remained unaffected (i.e. the lag time was constant). In the range 4–8 mmol kg^?1, the radial growth rate of B. cinerea was almost constant (c. 1 mm day^?1), but germination was inhibited (i.e. the lag time was increased). Conclusions: The MIC values were 4·7 mmol kg^?1 for P. expansum, 8·2 and 7·3 mmol kg^?1 for B. cinerea strain BC1 and BC2, respectively, demonstrating that some isolates of these moulds are resistant to copper. Significance and Impact of the Study: Copper concentrations at 4 mmol kg^?1 would be sufficient to control the development of these isolates, but the toxicity of copper should be extended to other isolates and evaluated in vineyards.     

中温碱性脂肪酶的研究：Ⅰ.高产菌株—扩展青霉PF868的选育

以扩展青霉(Penicillium expansum)uN-503作为出发菌株,经UV,DES和NTG多代诱变,选育成功产酶水平高达1200u/ml的优良变株——扩展青霉PF868,其酶活力较出发菌株提高了111%;连续传代10次PF868变株的产酶性能并没有衰退,是一个稳定的变株;PF868变株产酶的最适碳氮源和pH与出发菌株有显著的差异;其酶学特性与出发菌株相比也得到显著改善,最适作用温度由42℃降至32℃,更加适合于洗涤剂和工业脱脂用酶的要求.     

Low occurrence of patulin‐ and citrinin‐producing species isolated from grapes

Aims: To assess the ability of fungi isolated from grapes to produce patulin and citrinin. Methods and Results: A total of 446 Aspergillus isolates belonging to 20 species and 101 Penicillium isolates were inoculated in Czapek yeast extract agar and yeast extract sucrose agar and incubated for 7 days at 25°C. Extracts were analysed for patulin and citrinin by thin‐layer chromatography. None of the isolates of Aspergillus spp. produced either patulin or citrinin. Patulin was produced by three isolates of Penicillium expansum and two of Penicillium griseofulvum. Citrinin was produced by five isolates of P. expansum, two of Penicillium citrinum and one of Penicillium verrucosum. Conclusions: Our results show that the Aspergillus and Penicillium species commonly isolated from grapes are not a source of the mycotoxins, patulin and citrinin. Significance and Impact of the Study: The possibility of co‐occurrence of patulin and citrinin with ochratoxin A in grapes and grape products remain low, owing to the low frequency of isolation of potentially producing species.     

Partial purification and properties of pectin lyase from Penicillium expansum

A pectin lyase, poly(methoxygalacturonide) lyase, EC 4.2.2.10, from a culture filtrate of Penicillium expansum was partially purified 33-fold with 7.3% yield. The enzyme was monomeric with a molecular mass of 36.5 kDa. The enzyme did not contain pectate lyase activity and degraded citrus and apple pectin best at pH 7.0 and 40 to 45°C. The K _m for citrus pectin was 9 mg ml^-1.     

Experimental dissociation of food intake and plasma beta-endorphin following 2-deoxy-D-glucose in rats

The present studies were undertaken to further assess the role of plasma beta-endorphin (beta-EP) in the hyperphagia induced by the glucose antimetabolite, 2-deoxy-D-glucose (2-DG). Plasma concentrations of immunoreactive beta-EP (ir-beta-EP) were measured at the end of the first hour of feeding in all animals treated with 400 mg/kg 2-DG. Previous studies had shown a consistent, positive association between 2-DG hyperphagia and plasma ir-beta-EP concentrations, but the present data revealed dissociations between hyperphagia and plasma ir-beta-EP. Dexamethasone administration blocked the 2-DG-induced rise in plasma ir-beta-EP, but had no effect on the 2-DG hyperphagia measured at 1 hour. Forced drinking of a 2% NaCl solution decreased 2-DG hyperphagia, but not the 2-DG induced rise in plasma ir-beta-EP. Thus, elevations in plasma ir-beta-EP are not necessary for the full expression of 2-DG-induced hyperphagia in dexamethasone-treated rats. Furthermore, decreased feeding responses to 2-DG could coexist with increased levels of plasma ir-beta-EP in NaCl-treated normal rats. Elevations in plasma ir-beta-EP do not appear to be the critical opiate link in 2-DG induced hyperphagia.