Response surface methodology to supercritical carbon dioxide extraction of astaxanthin from Haematococcus pluvialis

Experimental design was used to investigate the effect of operating temperature (40-80 degrees C), operating pressure (30-50 MPa), and extraction time (1-4h) of supercritical carbon dioxide (SC-CO2) extraction on astaxanthin yields and the extract antioxidant activity (IC50). The ranges of the factors investigated were 40-80 degrees C for the operating temperature (X1), 30-50 MPa for the operating pressure (X2), and 1-4h for the extraction time (X3). The statistical analysis of the experiment indicated that pressure, extraction time, and the interaction between temperature and pressure (X1X2) had significant effect on astaxanthin yields. The central composite design showed that polynomial regression models were in good agreement with the experimental results with the coefficients of determination of 0.924 and 0.846 for astaxanthin yield and antioxidant activity, respectively. The optimal condition for astaxanthin yield within the experimental range of the variables studied was at 70 degrees C, 50 MPa, and 4h. At this condition, the predicted amount of astaxanthin extracted was 23.04 mg/g (2.3 wt% or 83.78% recovery). For the effect of experimental extraction conditions on antioxidant activity, IC50 was used as an index, which is the concentration that gives a 50% reduction in the absorbance of the ABTS free radical. The analysis of the results showed that the interaction between the operating temperature and operating pressure (X1X2) was the only significant factor affecting the extract antioxidant activity. The statistical model gave the minimum point for antioxidant activity at 67 degrees C, 40.3 MPa, and 1.86 h of extraction, at which the value for 1/IC50 was 0.39 l/mg (or IC50 was 2.57 mg/l).     

响应面法优化超临界CO2萃取茉莉花蕾精油及抗氧化活性的研究

为研究超临界CO2萃取茉莉花蕾获得精油的最佳工艺及抗氧化活性,实现资源的综合利用。实验考察了夹带剂用量、原料颗粒大小、萃取压力、萃取温度和动态萃取时间对茉莉精油产率的影响,进一步以响应面实验设计优化挥发油的提取工艺参数,以GC-MS分析挥发油组成及相对含量,并测定精油清除DPPH自由基及还原铁离子能力。结果表明,最佳工艺参数为:夹带剂乙醇用量为0.2mL/g,花粉颗粒为40目,萃取压力20MPa,萃取温度46℃,动态萃取时间1.6h。在此条件下茉莉精油的产率为13.67%,远高于同时蒸馏萃取法(2.87%)和超声辅助提取(2.45%)。超临界萃取精油的主要香气成分与茉莉鲜花基本一致,并且具有较好的清除自由基和还原铁离子能力。实验证明超临界萃取技术提取茉莉花蕾得到茉莉精油品质高,可为其资源综合利用提供参考。     

秋橄榄果实中番茄红素的超临界萃取技术研究

秋橄榄果实中番茄红素含量丰富。利用超临界二氧化碳技术萃取秋橄榄中的番茄红素,对影响萃取的诸因素,如萃取压力、萃取温度、萃取时间、夹带剂等进行研究,并进一步用响应曲面法优化萃取工艺条件。结果表明：丙酮作为夹带剂效果最佳,优化后的最佳萃取工艺条件是萃取压力37MPa,萃取温度52℃,萃取时间3．8h。     

代代花挥发油的超临界萃取及其在烟草中的应用

为了开发新的天然烟用香料,采用超临界流体萃取技术萃取代代花并优化了萃取工艺,GC-MS对挥发油成分进行了分离鉴定,并对其进行了卷烟加香试验.结果表明:①超临界萃取代代花的最佳工艺为:萃取压力40 MPa、萃取温度50℃萃取时间15 min、改性剂为20%乙醇;②代代花挥发油中共鉴定出45种挥发性成分,主要成分为柠檬烯、...     

Separation of cashew (Anacardium occidentale L.) nut shell liquid with supercritical carbon dioxide

Cashew nut shell liquid (CNSL) represents the largest readily available bioresource of alkenyl phenolic compounds. In this work, separation of CNSL from the pericarp of the cashew nut with supercritical carbon dioxide was studied. In the initial extractions with CO(2) at 40-60 degrees C and at pressures from 14.7 to 29.4 MPa, low yields were obtained. However, when the extractions were performed with one or more intermediate depressurization steps, the yield of CNSL increased to as high as 94%. Most of the oil did not separate from the shell during the depressurization step, but was obtained during the subsequent repressurization. The CNSL extract had a clear light brownish pink color and exhibited no evidence of polymerization or degradation. The pressure profile extraction method proposed in this work increases the possible CNSL extraction yields and greatly reduces the amount of CO(2) required for CNSL separation.     

Activity and stability of a neutral protease from Vibrio sp. (vimelysin) in a pressure-temperature gradient.

The apparent second-order rate constant of hydrolysis of Fua-Gly-LeuNH2 by vimelysin, a neutral protease from Vibrio sp. T1800, was measured in a variable pressure-temperature gradient (0. 1-400 MPa and 5-40 degrees C). The apparent maximum rate was observed at approximately 15 degrees C and 150-200 MPa; the pressure-activation ratio (kcat/Km(max)/kcat/Km(0.1 MPa)) was reached about sevenfold. The pressure dependence of the kcat and Km parameters at constant temperature (25 degrees C) revealed that the pressure-activation below 200 MPa was mainly caused by a change in the kcat parameter. The change in the intrinsic fluorescence intensity of vimelysin was also measured in a pressure-temperature plane (0.1-400 MPa and -20 to +60 degrees C). The fluorescence intensity was found to decrease by increasing pressure and temperature, and the isointensity contours were more or less circular. The tangential lines to the contours at high temperatures and low to medium pressures seem to have slightly positive slopes, which was reflected by the higher residual activities left after incubations at higher temperatures and medium pressure (200 MPa and 50 degrees C) and by the almost intact secondary structure left after 1 h of incubation at 200 MPa and 40 degrees C, as studied by circular dichroism. These results were compared with the corresponding results for thermolysin, a moderately thermostable protease from Bacillus thermoproteolyticus. Apparent differences that might be related to the temperature adaptations of the respective source microbes are also discussed.     

Extraction conditions affecting supercritical fluid extraction (SFE) of lycopene from watermelon

Lycopene, a carotenoid linked to protection against certain forms of cancer, is found in produce such as papaya, red-fleshed tomatoes, grapefruit and watermelon. The preparation of a supercritical CO2 (SC-CO2) watermelon-lycopene extract could serve as a food grade source of this carotenoid. This study established preliminary conditions for enhancing SC-CO2 extraction of lycopene from watermelon. Freeze-dried watermelon was extracted with SC-CO2 and ethanol as an organic co-solvent. The lycopene concentration was determined by HPLC, with absorbance measured at 503 nm. In an initial set of experiments, the effects of extraction temperature (70-90 degrees C), pressure (20.7-41.4 MPa) and co-solvent ethanol addition (10-15%) were evaluated. A lycopene yield of 38 microg per gram of wet weight was obtained at 70 degrees C, 20.7 MPa, and 15% by volume ethanol. The extraction of fresh (non-freeze-dried) watermelon yielded 103+/-6 microg lycopene per gram fresh fruit weight. Of the parameters tested, temperature had the most effect on lycopene yield. Thus, in another set of experiments, the temperature was varied from 60-75 degrees C at an extraction pressure of 20.7 MPa in the presence of 15% ethanol. Studies showed that freeze-dried watermelon flesh loses lycopene in storage. In accounting for lycopene storage losses, lycopene yields at 60 degrees C extraction temperature were 14% greater than those obtained at 70 degrees C.     

猴头菌子实体超临界流体技术萃取活性物质初探

以猴头菌子实体为原料,萃取物得率作为指标,采用CO₂超临界流体萃取技术,以萃取压力和CO₂流量等参数为考察因素,结合正交试验获得优化的萃取工艺：萃取压力为30MPa,温度为45℃,时间为1.5h,CO₂流量为20g/min,夹带剂（乙醇）与猴头菌子实体的物料比为5:1（mL:g）,在此条件下,萃取物得率为2.78%。与猴头菌子实体的醇提物相比,猴头菌子实体超临界萃取物具有更好的体外抗氧化能力和抗肿瘤活性,本研究结果为合理地开发和利用猴头菌子实体超临界萃取物产品提供科学的数据。     

The effect of osmotic pressure on the membrane fluidity of Saccharomyces cerevisiae at different physiological temperatures

Membrane fluidity in whole cells of Saccharomyces cerevisiae W303-1A was estimated from fluorescence polarization measurements using the membrane probe, 1,6-diphenyl-1,3,5-hexatriene, over a wide range of temperatures (6-35 degrees C) and at seven levels of osmotic pressure between 1.38 MPa and 133.1 MPa. An increase in phase transition temperatures was observed with increasing osmotic pressure. At 1.38 MPa, a phase transition temperature of 12 +/- 2 degrees C was observed, which increased to 17 +/- 4 degrees C at 43.7 MPa, 21+/- 7 degrees C at 61.8 MPa, and 24 +/- 9 degrees C at an osmotic pressure of 133.1 MPa. From these results we infer that, with increases in osmotic pressure, the change in phospholipid conformation occurs over a larger temperature range. These results allow the representation of membrane fluidity as a function of temperature and osmotic pressure. Osmotic shocks were applied at two levels of osmotic pressure and at nine temperatures, in order to relate membrane conformation to cell viability.     

Synergistic and antagonistic effects of combined subzero temperature and high pressure on inactivation of Escherichia coli

The combined effects of subzero temperature and high pressure on the inactivation of Escherichia coli K12TG1 were investigated. Cells of this bacterial strain were exposed to high pressure (50 to 450 MPa, 10-min holding time) at two temperatures (-20 degrees C without freezing and 25 degrees C) and three water activity levels (a(w)) (0.850, 0.992, and ca. 1.000) achieved with the addition of glycerol. There was a synergistic interaction between subzero temperature and high pressure in their effects on microbial inactivation. Indeed, to achieve the same inactivation rate, the pressures required at -20 degrees C (in the liquid state) were more than 100 MPa less than those required at 25 degrees C, at pressures in the range of 100 to 300 MPa with an a(w) of 0.992. However, at pressures greater than 300 MPa, this trend was reversed, and subzero temperature counteracted the inactivation effect of pressure. When the amount of water in the bacterial suspension was increased, the synergistic effect was enhanced. Conversely, when the a(w) was decreased by the addition of solute to the bacterial suspension, the baroprotective effect of subzero temperature increased sharply. These results support the argument that water compression is involved in the antimicrobial effect of high pressure. From a thermodynamic point of view, the mechanical energy transferred to the cell during the pressure treatment can be characterized by the change in volume of the system. The amount of mechanical energy transferred to the cell system is strongly related to cell compressibility, which depends on the water quantity in the cytoplasm.     

Supercritical carbon dioxide extraction of chamomile flowers: extraction efficiency, stability, and in-line inclusion of chamomile-carbon dioxide extract in beta-cyclodextrin

The extraction of chamomile flowers using supercritical carbon dioxide was investigated with respect to extraction efficiency and compared with solvent extraction. The stability of matricine, a sensitive constituent of the essential oil of chamomile, in these extracts was studied during storage at different temperatures over 6 months. Matricine was stable at -30 degrees C. A slight decrease (80-90% recovery) occurred at +5 degrees C, whereas complete decomposition of matricine took place within 3-4 months at room temperature and at +30 degrees C, respectively. An in-line inclusion of chamomile constituents in beta-cyclodextrin (beta-CD) during the extraction process was assessed and inclusion rates between 40 and 95% were obtained depending on the amount of beta-CD and the type of chamomile constituent. No further stabilization of matricine in the carbon dioxide extract/beta-CD complexes was achieved. High residual water contents in the complexes even after freeze-drying were identified as accelerating the decomposition. In addition, the extractability of flavonoids, such as apigenin and apigenin-7-glucoside, was determined. Apigenin-7-glucoside, the more hydrophilic substance, was not extractable with pure carbon dioxide and showed a recovery of 11% using methanol modified carbon dioxide (18%, w/w) at 60 degrees C and 380 bar. Extraction conditions in the two-phase region of the binary mixture carbon dioxide-methanol (70 degrees C, 100 bar) led to a drastic change in fluid polarity and hence extractability increased to 92-95%.     

Efficiency of high pressure treatment for destruction of Listeria monocytogenes in fruit juices

The objective of this study was to compare high pressure resistance of Listeria monocytogenes strains at 25 degrees C and 50 degrees C at 350 MPa and to use high pressure (250 MPa and 350 MPa) at 30 degrees C and 40 degrees C for the inactivation of the relatively most pressure resistant strain inoculated in pasteurized apple, apricot, cherry and orange juices. L. monocytogenes CA was found to be the relatively most pressure resistant strain and increasing pressurization from 250 MPa to 350 MPa at 30 degrees C had an additional three to four log cycle reduction in viability, still leaving viable cells after 5 min. When 350 MPa at 40 degrees C for 5 min was applied more than eight log cycle reduction in cell population of all fruit juices was achieved. This study demonstrated that low temperature (40 degrees C) high pressure (350 MPa) treatment has the potential to inactivate relatively pressure resistant L. monocytogenes strains inoculated in different fruit juices within 5 min.     

An ecofriendly approach to process rice bran for high quality rice bran oil using supercritical carbon dioxide for nutraceutical applications

An integrated approach to extraction and refining of RBO using supercritical carbon dioxide (SC-CO2) in order to preserve the nutritionally important phytochemicals is reported here. Process variables such as pressure, temperature, time, solvent flow rate and packing material on extraction yield and quality of RBO were investigated using a pilot model SC-CO2 extraction system. Three isobaric (350, 425 and 500 bar), three isothermal temperatures (50, 60 and 70 degrees C), three extraction times (0.5, 1 and 1.5h), at 40/min CO2 flow rate and three packing materials (pebbles, glass beads and structured SS rings) were employed. The RBO yield with SC-CO2 extraction increased with temperature and time under isobaric conditions. At the 60 degrees C isotherm, an increase in the RBO yield was obtained with an increase in the pressure and time. The RBO yield increased significantly with structured SS rings used as packing material. The RBO extracted with SC-CO2 had negligible phosphatides, wax and prooxidant metals (Fe and Cu) and was far superior in color quality when compared with RBO extracted with hexane. At the optimum condition of extraction at 500 bar, 60 degrees C for 1.5h, with structured SS rings used as packing material, the yield of RBO was comparable with that of hexane extraction (22.5%). The phytochemical contents of the RBO under the optimum conditions were in the range of tocols, 1500-1800 ppm; sterols, 15,350-19,120 ppm and oryzanol 5800-11,110 ppm.     

Escherichia coli mutants resistant to inactivation by high hydrostatic pressure.

Alternating cycles of exposure to high pressure and outgrowth of surviving populations were used to select for highly pressure-resistant mutants of Escherichia coli MG1655. Three barotolerant mutants (LMM1010, LMM1020, and LMM1030) were isolated independently by using outgrowth temperatures of 30, 37, and 42 degrees C, respectively. Survival of these mutants after pressure treatment for 15 min at ambient temperature was 40 to 85% at 220 MPa and 0.5 to 1.5% at 800 MPa, while survival of the parent strain, MG1655, decreased from 15% at 220 MPa to 2 x 10(-8)% at 700 MPa. Heat resistance of mutants LMM1020 and LMM1030 was also altered, as evident by higher D values at 58 and 60 degrees C and reduced z values compared to those for the parent strain. D and z values for mutant LMM1010 were not significantly different from those for the parent strain. Pressure sensitivity of the mutants increased from 10 to 50 degrees C, as opposed to the parent strain, which showed a minimum around 40 degrees C. The ability of the mutants to grow at moderately elevated pressure (50 MPa) was reduced at temperatures above 37 degrees C, indicating that resistance to pressure inactivation is unrelated to barotolerant growth. The development of high levels of barotolerance as demonstrated in this work should cause concern about the safety of high-pressure food processing.     

微孔草籽油的超临界CO2流体萃取及HPLC—MS分析

利用超临界CO2萃取微孔草籽油,并对籽油进行了HPLC／MS分析。实验确定的最佳超临界CO2流体萃取条件是：萃取温度45℃,萃取压力20MPa,CO2流量为35-40kg／h,萃取时间120min,在此条件下白刺籽油的萃取率为16．12％。利用HPLC／MS对微孔草籽油分析,发现其不饱和脂肪酸的相对含量高达73．19％。比较了超临界CO2萃取微孔草籽油油样和石油醚萃取微孔草籽油油样的理化性质,发现超临界CO2流体萃取的籽油质量优于传统溶剂萃取的籽油。     

肾叶天胡荽精油的超临界CO2萃取、成分分析及杀虫活性初探

采用正交实验设计,对肾叶天胡荽（Hydrocotyle wigordi Maxim．）精油超临界CO2萃取条件进行了优化,并用GC—MS分析技术对精油的化学成分进行了鉴定,初步探讨了肾叶天胡荽精油对小菜蛾2龄幼虫的触杀活性。结果表明,肾叶天胡荽精油超临界CO2萃取的最佳条件为萃取压力35MPa、萃取温度50℃、解析压力5MPa、解析温度40℃、萃取时间75min、CO2流量34—36L·h^-1,精油得率最高可达5．32％。从精油中共鉴定出19种成分,总相对含量达到89．266％,主要成分为邻苯二甲酸二辛酯（64．302％）。用超临界CO2萃取技术提取的肾叶天胡荽精油对小菜蛾2龄幼虫有一定的触杀作用,20g·L^-1精油对小菜蛾2龄幼虫的24h校正死亡率高达90．00％。     

Supercritical carbon dioxide extraction of hydrocarbons from the microalgaBotryococcus braunii

Samples of the microalgaBotryococcus braunii were submitted to supercritical fluid extraction with carbon dioxide at 40 °C and pressures of 12.5, 20.0 and 30.0 MPa. The extraction yield and the fraction of the hydrocarbons in the extracts both increased with pressure and at 30 MPa these compounds were obtained rapidly. This behaviour is associated with the localization of the hydrocarbons outside the cell wall. In the extracts, which are fluid, golden and limpid, chlorophyll and phospholipids were not detected.Author for correspondence     

Pressure- vs. heat-induced bacterial stress in cooked poultry sausages: a preliminary study

Vacuum-packaged poultry cooked sausages were pressure-treated at 500 MPa by combinations of time (5-45 min) and temperature (2-80 degrees C) and later stored at 6-8 degrees C for 12 we. Mesophile and psychrotrophe counts were determined 1 d, 3, 6, 9 and 12 we after treatment and compared with those of cooked sausages pasteurized at 80-85 degrees C for 40 min. Both pressure and heat treatments offer great possibilities for preservation. Sausages pressurized at 65 degrees C for 15 min showed mesophile numbers below 2 log cfu g(-1) throughout the chill storage. Pressurization, unlike heat treatment, causes a reversible bacterial stress. Thus, injured cells recovered during storage and, at 6 and 12 we, after a temperature abuse (room temperature for approx. 24 h), counts increased up to 6.5 - 7.5 log units. Psychrotrophes were more sensitive to both treatments; no growth was detected the day after (a lethality of more than 4 log units).     

Novel conjugated linseed oil-styrene-divinylbenzene copolymers prepared by thermal polymerization. 1. Effect of monomer concentration on the structure and properties

A variety of novel opaque, white polymers ranging from rubbery materials to tough and rigid plastics have been prepared by the thermal polymerization at 85-160 degrees C of varying amounts of 87% conjugated linseed oil, styrene, and divinylbenzene. Gelation of the reactants typically occurs at temperatures higher than 120 degrees C, and fully cured thermosets are obtained after postcuring at 160 degrees C. The fully cured thermosets have been determined by Soxhlet extraction to contain approximately 35-85% cross-linked materials. The microcomposition of these polymers, as determined by 1H NMR spectroscopy, indicates that the cross-linked materials are composed of both soft oily and hard aromatic phases. After solvent extraction, the insoluble materials exhibit nanopores well distributed throughout the polymer matrixes. Dynamic mechanical analysis of these polymers indicates that they are phase separated with a soft rubbery phase having a sharp glass transition temperature of -50 degrees C and a hard brittle plastic phase with a broadened glass transition temperature of 70-120 degrees C. These polymers possess cross-link densities of 0.15-2.41 x 10(4) mol/m3, compressive Young's moduli of 12-438 MPa, and compressive strengths of 2-27 MPa. These materials are thermally stable below 350 degrees C and exhibit a major thermal degradation of 72-90% at 493-500 degrees C.     

Freezing preservation of the mammalian cardiac explant. V. Cryoprotection by ethanol.

We studied the colligative cryoprotective effect of ethanol (EtOH) in preserving the isolated rat heart frozen at -3.4 degrees C or unfrozen at -1.4 degrees C. Addition of 4.7% (v/v) EtOH to a cardioplegic solution, CP-14, raised the osmolality from 280 to 1100 mOsm/kg H2O and lowered the melting point from -0.52 to -2.1 degrees C. Freezing of the cardiac explant at -3.4 degrees C for 6 h resulted in 34.3 +/- 1.9% of the tissue water as ice; recovery of cardiac output (CO) was 50%. Polyethylene glycol, which at 5% (w/v) has been shown to cryoprotect the hearts during freezing at -1.4 degrees C, did not improve the protective effect of 4.7% EtOH. CP-14 + 4.7% EtOH did not freeze at -1.4 degrees C. After 6 h storage, CO in hearts flushed with CP-14 + 4.7% EtOH oxygenated with 95% O2/5%CO2 returned to almost control level and was much higher than that in hearts flushed with 100% O2 saturated-CP-14 + 4.7% EtOH. Storage of 8 and 12 h reduced CO to 87 +/- 9 and 60 +/- 5% of control. By employing EtOH as a colligative cryoprotectant, we preserved the adult mammalian heart frozen at -3.4 degrees C or unfrozen at -1.4 degrees C, suggesting that this small molecular weight, penetrating substance may be a suitable cryoprotectant for long-term storage of the cardiac explant at high subzero temperatures.