The role of visible faecal material as a vehicle for generic Escherichia coli,coliform, and other enterobacteria contaminating poultry carcasses during slaughtering

AIMS: A comparison of Enterobacteriaceae, coliform and Escherichia coli counts in chicken carcasses with and without visible faecal contamination was conducted to evaluate the role of contamination as a vehicle for generic E. coli, coliform and other enterobacteria contaminating broiler chicken carcasses when processed under routine commercial operations. METHODS AND RESULTS: Samples were removed from the processing line immediately after evisceration, inside-outside shower and chilling for microbiological analysis. After evisceration, mean counts were significantly different only for E. coli (P < or = 0.05) in chicken carcasses with and without visible faecal contamination. While the spray wash practice was not efficient enough for complete removal of the visible contamination from carcasses, leading to microbiological reduction percentages lower than expected, 25 ppm chlorinated water chilling did reduce the contamination level considerably in all samples. CONCLUSIONS: Carcasses with and without visible faecal contamination harboured E. coli and other potentially hazardous enterobacteria. E. coli was the predominant strain isolated in all samples, Enterobacter cloacae being next most frequent. SIGNIFICANCE AND IMPACT OF THE STUDY: The zero tolerance of visible faecal contamination requirement alone is not sufficient to assure safety and to improve the microbial quality of carcasses.     

The potential use of chilling to control the growth of Enterobacteriaceae on porcine carcasses and the incidence of E. coli O157:H7 in pigs

Aims:  To (i) monitor the presence of Enterobacteriaceae as indicators of faecal contamination on pig carcasses, (ii) examine the potential use of chilling as a critical control point (CCP) and establish its influence on pig carcass categorization by Decision 471/EC and (iii) determine the incidence of E. coli O157:H7 in pigs.
Methods and Results:  Porcine faecal samples and carcass swabs were collected before and after chilling at four Irish pig abattoirs and examined for Enterobacteriaceae and E. coli O157:H7. Chilling generally reduced Enterobacteriaceae counts on carcasses, but increases were also observed, particularly in one abattoir. E. coli O157:H7 was absent from carcasses before chilling, present on 0·21% after chilling and was recovered from 0·63% of faecal samples. All of the isolates were found to contain virulence genes associated with clinical illness in humans.
Conclusions:  The data show that overall chilling had the capacity to reduce the numbers of carcasses positive for the presence of Enterobacteriaceae .
Significance and Impact of Study:  The influence of chilling on the categorization of pig carcasses suggests that it has the potential to improve the numbers of acceptable carcasses and the process could be used as a CCP within a HACCP plan.     

Contamination of Pig Carcasses at Two Abattoirs by Escherichia coli with Special Reference to O-serotypes and Antibiotic Resistance

Evidence of the source of carcass contamination of pigs at slaughter was obtained by determining presumptive coliform counts on faeces and on carcass surfaces, and comparing the O-serotypes and antibiotic sensitivity patterns of Escherichia coli from both sites. All of the 16 pig carcasses from the slaughter line of a commercial abattoir were contaminated with presumptive coliform bacilli on most sites examined; the carcasses of six out of eight pigs slaughtered at the Meat Research Institute (MRI) abattoir were also contaminated, but only small numbers of coliforms could be detected on a few of the sites. The proportion of O-serotypes of E. coli present in faeces which were also detected on carcass surfaces, indicating faecal contamination, varied between 0 and 8.6% in MRI slaughtered pigs but reached 66.6% in one group of commercially slaughtered pigs. O-serotypes found on carcass surfaces but not in the faeces of the pigs, were used as an indication of environmental contamination and this was very evident in the commercially slaughtered pigs. A high proportion of E. coli O-serotypes in the gut were resistant to antibiotics and these were also often found on the carcass surface and, since the range of O-serotypes in the pig is similar to that reported in man, the pig must be considered to be a potential reservoir of antibiotic resistant E. coli for man.     

Bifidobacteria as indicators of faecal contamination along a sheep meat production chain

Aims:  The potential use of bifidobacteria as indicators for faecal contamination was studied along a sheep meat production and processing chain. The levels of bifidobacteria were compared with those of Escherichia coli . Total viable counts were followed along the chain (244 samples).
Methods and Results:  Forty-three per cent of the samples contained bifidobacteria, of which 15% were solely detected using a PCR method based on the hsp60 gene and not by a culture-based method. Bifidobacteria were detected in only three of nine sheep faeces samples using one or the other method. However, carcasses (types C and E) were highly contaminated. These sample types (30% and 28%, respectively) were positive for bifidobacteria and negative for E. coli . The species Bifidobacterium pseudolongum and Bif. thermophilum , isolated from faecal samples, were predominant. Bifidobacterium choerinum were found in C, D, E and F sample types.
Conclusions:  Bifidobacteria were shown more efficient than E. coli in carcasses samples. The presence of Bif. choerinum suggested a faecal pork contamination.
Significance and Impact of the Study:  Detection and identification of bifidobacteria, in correlation with E. coli counting, should improve hygiene quality of mutton processing chains.     

Impact of dried skim milk in production diets on Lactobacillus and pathogenic bacterial shedding in growing-finishing swine

AIMS: To determine the possible effects of inclusion of dried skim milk (DSM) in swine diets on indigenous Lactobacillus spp. and Escherichia coli, and its potential for controlling pathogen shedding and affect animal growth in growing-finishing swine. METHODS AND RESULTS: Animals were fed over three dietary phases to match production needs from age 10-14 weeks, 14-18 weeks and 18-22 weeks. For each feeding phase, diets were formulated to contain 0 or 10% DSM (balanced for metabolizable energy and true ileal digestible amino acids). Animals were weighed every 2 weeks and faecal samples were collected from 40 animals (20 with DSM and 20 without DSM) at week 10 (d 0 on diets), 14, 18 and 22 of age, and were analysed for Lactobacillus spp., Enterobacteriaceae, coliforms, E. coli, Salmonella, Campylobacter and E. coli O157:H7. At the start of the study (week 10), faecal bacterial counts (log10 CFU g(-1) faeces) were 9.55, 7.26, 7.01 and 6.93 for Lactobacillus, Enterobacteriaceae, coliforms and E. coli populations respectively. The Enterobacteriaceae, coliform and E. coli populations decreased through week 14 and 18, but were higher in animals fed with the DSM diet compared with the basal diet without DSM. The Lactobacillus populations at weeks 14 and 18 were lower in the animals fed the diet without DSM, whereas feeding DSM maintained the Lactobacillus counts from week 10. At week 22, populations of Enterobacteriaceae, coliforms and E. coli were >week 18 for the animals fed the diet without DSM, less change was observed with the feeding of DSM, and no differences between the diets were observed at week 22. However, in week 22 the animal gain was positively correlated with Lactobacillus numbers and negatively correlated with E. coli numbers. Subtraction of the E. coli population (log10) from the Lactobacillus population (log10) yielded a positive value termed 'effective'Lactobacillus that correlated well with animal gain and may better define a beneficial function in the intestine. Salmonella were detected in over 60% of the animals at week 10 and 14, and <20% at week 18 and 22. Campylobacter were detected rarely at weeks 10, 14 and 18, but were found in 25% of the animals at week 22. The DSM did not affect Salmonella or Campylobacter shedding, but examination of individual animals over the entire experiment indicated that fewer recurring incidences of Salmonella shedding occurred in animals that maintained higher Lactobacillus. In addition, at week 22, Salmonella and Campylobacter shedding was associated with lower levels of effective Lactobacillus and lower animal weight gains. CONCLUSIONS: The DSM did not directly affect the animal performance or pathogen shedding via the Lactobacillus spp. population at any phase of production. However, analysis of data from all animals revealed that faecal Lactobacillus affected Salmonella shedding and in the finishing phase, animal growth and pathogen shedding also were affected, as reflected by the 'effective'Lactobacillus-associated observations. SIGNIFICANCE AND IMPACT OF THE STUDY: In the swine intestine, any benefits from gastrointestinal Lactobacillus may be compromized by the E. coli population, and this antagonism may explain responses observed with prebiotics or probiotics in some swine.     

The prevalence and spread of Escherichia coli O157:H7 at a commercial beef abattoir

AIMS: To investigate the prevalence and virulence characteristics of Escherichia coli O157:H7 after a number of beef process operations at a commercial Irish abattoir. METHODS AND RESULTS: Two 12-month studies were carried out. The first study (study 1) examined the prevalence of E. coli O157:H7 at up to six sites on carcasses at eight stages of the dressing, washing, chilling and boning process. The second study (study 2) examined the prevalence of E. coli O157:H7 in bovine faeces and rumen contents post-slaughter and on dressed, washed carcasses. Isolates from both studies were phage-typed and the presence of genes encoding verocytotoxin, enterohaemolysin and intimin production was determined. E. coli O157:H7 was isolated from four of 36 carcasses in study 1. E. coli O157:H7 was detected during hide removal and was detected at multiple carcass sites and multiple process stages, including boning. On two carcasses, contamination was first detected at the bung following its freeing and tying. All isolates from study 1 were phage type (PT) 2, eaeAO157 and ehlyA positive, but were verocytotoxin 1 (VT1) and verocytotoxin 2 (VT2) negative. In study 2, E. coli O157:H7 was isolated from 2.4% of faecal, 0.8% of rumen and 3.2% of carcass samples. In some cases, isolates recovered from the faeces of a particular animal, the resulting carcass and adjacent carcasses on the line had the same phage typing and virulence characteristic profile patterns. All isolates from study 2 were eaeAO157 and ehlyA positive and only one isolate was VT1 and VT2 negative. Most isolates were PT 32. A higher frequency of positive isolations was noted from samples taken during spring and late summer. CONCLUSION: These studies show that in a typical Irish beef abattoir, carcass contamination with E. coli O157:H7 can occur during hide removal and bung tying and this contamination can remain on the carcass during subsequent processing. SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides data that is necessary for the understanding of how E. coli O157:H7 contamination of beef occurs.     

Cross-contamination of carcasses and equipment during pork processing

AIMS: The cross-contamination events within a commercial pork processing line were examined by a combination of ERIC-PCR DNA fingerprinting of Escherichia coli and plate counts. METHODS AND RESULTS: Sponge sampling of environmental surfaces and carcasses was performed over an 8-h processing period. Prior to the start of processing the scraper and dry polisher blades were found to harbour substantial Enterobacteriaceae and Escherichia coli populations. From plate count data the key cross-contamination site for the transfer of bacteria between carcasses occurred during evisceration. However, DNA fingerprints of representative E. coli isolates identified that genotypes initially present on the scraper/dry polisher became distributed on wet polisher blades, band-saw and butcher's hands despite a singeing step being performed post dry polishing. A high proportion of E. coli on post-eviscerated carcasses could be traced to down-stream (pre-singe) environmental contact surfaces. CONCLUSIONS: DNA fingerprinting has demonstrated that E. coli and potential enteric pathogens can be transferred between pork carcasses throughout the processing line. In this respect scalding and singeing cannot be relied upon to control cross-contamination of enteric bacteria between carcasses. SIGNIFICANCE AND IMPACT OF THE STUDY: Sole reliance on indicator organism counts to identify cross-contamination events as currently advocated is limited.     

Occurrence of Escherichia coli O157:H7 in faeces, skin and carcasses from sheep and goats in Ethiopia

Aims:  To determine the occurrence and proportion of Escherichia coli O157:H7 in faeces, skin swabs and carcasses before and after washing, from sheep and goats in Ethiopia.
Method and Results:  Individual samples were enriched in modified tryptic soy broth with novobiocin, concentrated using immunomagnetic separation (IMS) and plated onto cefixime-tellurite containing sorbitol MacConkey agar. Presumptive colonies were confirmed by biochemical tests and subjected to latex agglutination tests. A PCR was performed on isolates for the detection of stx ₁, stx ₂ and eae genes. Escherichia coli O157:H7 was isolated from faeces (4·7%), skin swabs (8·7%) and carcasses before washing (8·1%) and after washing (8·7%) and on water samples (4·2%). The proportion of carcasses contaminated with E. coli O157:H7 was strongly associated with those recovered from faecal and skin samples. Both stx ₁ and stx ₂ genes were identified from one E. coli O157:H7 isolate from a goat carcass.
Conclusions:  Even though the numbers of samples examined in this study were limited to one abattoir, sheep and goats can be potential sources of E. coli O157:H7 for human infection in the country. Control measures to reduce the public health risks arising from E.   coli O157:H7 in reservoir animals need to be addressed at abattoir levels by reducing skin and faecal sources and carcass contaminations at different stages of slaughter operations.
Significance and Impact of the Study:  Escherichia coli O157:H7 was detected from carcasses before and after washing during slaughtering operations, and one O157 isolate was positive for verotoxins.     

The prevalence of Salmonella spp. in bovine faecal,rumen and carcass samples at a commercial abattoir

AIMS: To determine the prevalence, serotype and antibiotic resistance profile of Salmonella isolates in cattle and on carcasses at a commercial Irish abattoir. METHODS AND RESULTS: Faecal, rumen and carcass samples were collected from a beef abattoir over a 12-month period and examined for the presence of Salmonella spp. Isolates were serotyped, phage typed (when serotype was found to be S. Typhimurium) and tested for susceptibility to a panel of antibiotics. Salmonella was isolated from 2% of faecal, 2% of rumen and 7.6% of carcass samples. Salmonella was most frequently isolated from samples taken during the period August to October. S. Dublin was isolated from 72% of positive samples. S. Agona and S. Typhimurium definitive type (DT)104 were each isolated from 14% of positive samples. All S. Typhimurium DT104 isolates were resistant to ampicillin, chloramphenicol, streptomycin, sulphafurazole and tetracycline (ACSSuT). On occasion, from a single animal, the same serotype was isolated from more than one sample (i.e. faeces and rumen; faeces and carcass; rumen and carcass; faeces, rumen and carcass). CONCLUSIONS: Salmonella is present in cattle at slaughter and on beef carcasses at an Irish abattoir, with a higher frequency of occurrence during the period August to October. Most isolates from the study are not commonly associated with human clinical infection, with the exception of S. Typhimurium DT104 (R-type ACSSuT). SIGNIFICANCE AND IMPACT OF THE STUDY: This study provides epidemiological data that is necessary for the understanding of beef as a source of human Salmonella infection.     

Impact of the slaughter line contamination on the presence of Salmonella on broiler carcasses

AIMS: The aim of the study was to assess the impact of Salmonella present on the slaughter line before processing on broiler carcass contamination during processing. METHODS AND RESULTS: Three Belgian broiler slaughterhouses were each visited twice. Samples were taken from the slaughter line after the cleaning and the disinfection process and before slaughter of the first flock. During the slaughter of the first flock, feathers and neck skins were collected at various points of the slaughter process. Swab samples were also taken from the crates in which the birds were transported. In two slaughterhouses, the slaughter line was contaminated with Salmonella before the onset of slaughter, especially the shackles, conveyer belt and the plucking machine in the dirty zone. During slaughter, the carcasses of the first Salmonella-free flock became contaminated with the same strains as isolated previously from the slaughter line. CONCLUSION: Contamination of the slaughter line with Salmonella leads to carcass contamination. SIGNIFICANCE AND IMPACT OF THE STUDY: Implementation of logistic slaughter is only successful when the cleaning and disinfection process completely eliminates the Salmonella contamination of the slaughter line. Only if this is achieved, will the slaughter of Salmonella-free flocks result in the absence of Salmonella on the carcasses after slaughter.     

An adapted ImmunoMagnetic cell separation method for use in quantification of Escherichia coli O157:H7 from bovine faeces

Detection of Escherichia coli O157:H7 organisms in food, clinical or environmental samples is necessary for diagnosis of infection and epidemiological investigations. However, this pathogen may be present in low numbers and difficult to identify among high numbers of other background bacteria. In order to increase the sensitivity of culture- and PCR detection, pre-enrichment of E. coli O157:H7 in broth culture combined with ImmunoMagnetic cell Separation (IMS) is routinely employed. These methods, although able to detect levels as low as 2 cfu/g (from 10 to 25 g samples), are qualitative detection strategies only. If the actual numbers of E. coli O157:H7 are to be quantified, growth enrichment must be excluded and the organisms isolated directly from the sample of interest. Such quantification is necessary, for example, to determinate contamination levels on beef carcasses and for determination of bacterial numbers in in vivo gene expression studies. In the present study, it was not possible to recover organisms from bovine faecal suspensions using the customary IMS system and so a range of alternative buffers and other paramagnetic beads was tested. Combination of a 6.2-microm diameter bead with a detergent-based buffer gave optimal recovery of E. coli O157:H7 organisms from faecal suspensions. This system was validated for recovery of E. coli O157:H7 by comparing it with that obtained with the standard Dynabeads IMS protocol, using both the traditional broth enrichment method and a quantitative detection approach. We conclude that a 6.2-microm diameter Aureon bead can be used for quantitative isolation of E. coli O157:H7 directly from bovine faeces and, for this purpose, is preferred to the 2.8-microm diameter Dynal bead.     

Prevalence and serotypes of Salmonella associated with goats at two Australian abattoirs

Aims:  This study was carried out to determine the prevalence and serotype of Salmonella in goats presented for slaughter.
Methods and Results:  A total of 121 goats were examined for the presence of Salmonella in matching rumen, faecal and carcass samples. Samples were analysed for the presence of Salmonella following the Australian Standard AS 1766.2.5-1991. Salmonella was isolated from 56 (46·3%) faecal samples, 55 (45·5%) rumen samples and 35 (28·9%) carcass samples. The dominant serotypes isolated were Salmonella serotype Saintpaul (31%), Salmonella serotype Typhimurium (13%) and Salmonella serotype Chester (11%).
Conclusions:  Salmonella was isolated from at least one of the three sample sites in 68% of animals. Carcase contamination with faeces, compared with rumen liquor, is a greater hazard for Salmonella contamination of goat carcases. Goat meat is a potential source of Salmonella serovars associated with human disease.
Significance and Impact of the Study:  Goat carcases contaminated with Salmonella during slaughter could be a source of food-borne disease if consumed raw or inadequately cooked, or may be a source of cross-contamination to other foods.     

Prevalence, enumeration, serotypes, and antimicrobial resistance phenotypes of salmonella enterica isolates from carcasses at two large United States pork processing plants

The objective of this study was to characterize Salmonella enterica contamination on carcasses in two large U.S. commercial pork processing plants. The carcasses were sampled at three points, before scalding (prescald), after dehairing/polishing but before evisceration (preevisceration), and after chilling (chilled final). The overall prevalences of Salmonella on carcasses at these three sampling points, prescald, preevisceration, and after chilling, were 91.2%, 19.1%, and 3.7%, respectively. At one of the two plants, the prevalence of Salmonella was significantly higher (P < 0.01) for each of the carcass sampling points. The prevalences of carcasses with enumerable Salmonella at prescald, preevisceration, and after chilling were 37.7%, 4.8%, and 0.6%, respectively. A total of 294 prescald carcasses had Salmonella loads of >1.9 log CFU/100 cm(2), but these carcasses were not equally distributed between the two plants, as 234 occurred at the plant with higher Salmonella prevalences. Forty-one serotypes were identified on prescald carcasses with Salmonella enterica serotypes Derby, Typhimurium, and Anatum predominating. S. enterica serotypes Typhimurium and London were the most common of the 24 serotypes isolated from preevisceration carcasses. The Salmonella serotypes Johannesburg and Typhimurium were the most frequently isolated serotypes of the 9 serotypes identified from chilled final carcasses. Antimicrobial susceptibility was determined for selected isolates from each carcass sampling point. Multiple drug resistance (MDR), defined as resistance to three or more classes of antimicrobial agents, was identified for 71.2%, 47.8%, and 77.5% of the tested isolates from prescald, preevisceration, and chilled final carcasses, respectively. The results of this study indicate that the interventions used by pork processing plants greatly reduce the prevalence of Salmonella on carcasses, but MDR Salmonella was isolated from 3.2% of the final carcasses sampled.     

Sources of Salmonella on broiler carcasses during transportation and processing: modes of contamination and methods of control

AIMS: The prevalence and types of salmonella in broiler chickens during transportation and during slaughter and dressing were studied. This was part of a comprehensive investigation of salmonellas in two UK poultry companies, which aimed to find the origins and mechanisms of salmonella contamination. METHODS AND RESULTS: Salmonellas were isolated using cultural methods. Serovars of Salmonella detected during rearing were usually also found in a small proportion of birds on the day of slaughter and on the carcasses at various points during processing. There was little evidence of salmonellas spreading to large numbers of carcasses during processing. Many serovars found in the feedmills or hatcheries were also detected in the birds during rearing and/or slaughter. Transport crates were contaminated with salmonellas after washing and disinfection. CONCLUSIONS: Prevalence of salmonellas fell in the two companies during this survey. A small number of serovars predominated in the processing plants of each company. These serovars originated from the feed mills. Reasons for transport crate contamination were: (1) inadequate cleaning, resulting in residual faecal soiling; (2) disinfectant concentration and temperature of disinfectant too low; (3) contaminated recycled flume water used to soak the crates. SIGNIFICANCE AND IMPACT OF THE STUDY: Efforts to control salmonella infection in broilers need to concentrate on crate cleaning and disinfection and hygiene in the feed mills.     

Salmonella on pig carcasses: positive pigs and cross contamination in the slaughterhouse

AIMS: The purpose of this study was to investigate the prevalence of Salmonella in pigs at the moment of slaughter and in the slaughterhouse environment. METHODS AND RESULTS: In total, five different commercial slaughterhouses were sampled during eight slaughterhouse visits. Carcass swabs, colon content and mesenteric lymph nodes were taken to reflect the animal status and from the slaughterhouse environmental samples were taken. Salmonella was isolated from 37% of the carcass samples as a mean value. High variations were noticed between different slaughterhouses (between 0 and 70%) and sampling days in the same abattoir (between 3 and 52%). A correlation was found between the carcass contamination and the status of the delivered animals (P=0.01675). Cross contamination was estimated to account for 29% of the positive carcasses. The slaughterhouse environment was highly contaminated; before starting the slaughtering activities 25% of the samples were positive on average. The most prevalent serotypes isolated at the slaughterhouse environment and from the colon content were S. Typhimurium, S. Livingstone and S. Derby. On carcasses S. Typhimurium was predominately isolated (71%). The biggest variability of serotypes was found in the mesenteric lymph nodes. Serologically 56.3% of the pigs were found positive for Salmonella using a cut-off level of the optical density percentage higher than 10 (O.D.% > or = 10). While on individual pig level the correlation between the bacteriological and serological data was poor, because of recent Salmonella infections, a better correlation was found at the herd level on the moment of slaughtering. CONCLUSION: A high degree of carcass contamination is noticed after slaughtering. This contamination resulted from the delivery of Salmonella-positive pigs and cross-contamination from the slaughterhouse environment. SIGNIFICANCE AND IMPACT OF THE STUDY: In pigs, Salmonella carriage is high, but it is obvious that slaughterhouse hygiene is a determinative factor for managing carcass contamination.     

THE VALUE OF THE ASSOCIATION ESCHERICHIEAE-GROUP D STREPTOCOCCI IN THE DIAGNOSIS OF CONTAMINATION IN FOODS

SUMMARY: The tests for faecal contamination in foods, based on 'indicator species', should be reconsidered for the following reasons. First, in Europe, Escherichia coli is regarded as a specific index of such contamination; but, apparently through the use of antibiotics, the proportion of human faeces containing Klebsiella has risen from 5.2% in 1947 to 48.4% in 1956–7. Moreover, E. coli and other coli-aerogenes organisms may be absent from the gut of certain animals, notably the pig. Second, while the usual methods of counting coli-aerogenes bacteria do not permit the isolation of strains which ferment lactose slowly or not at all (i.e. paracolons), these occur in 35.6% of samples of human faeces. Further, the recommended methods of detecting such strains are not wholly satisfactory. Third, the origin of the coli-aerogenes bacteria is uncertain.
It is thus necessary to consider other organisms which normally inhabit the intestinal tract of humans and other animals. As to Clostridium perfringens , its source is doubtful, for it may come from faeces or from soil, and many foods contain only soil strains. The group D streptococci, on the other hand, are excellent indicators of faecal contamination. They are constant or frequent in the intestines of man and animals, and often more numerous there than coli-aerogenes bacteria. Their specificity as an index of faecal contamination is high and their investigation is easy with the selective media now available. Associated with the coli-aerogenes bacteria, they justify the diagnosis of faecal contamination in a foodstuff.     

Enumeration of Salmonella and Escherichia coli O157:H7 in ground beef, cattle carcass, hide and faecal samples using direct plating methods

AIM: To develop and validate high throughput methods for the direct enumeration of viable and culturable Salmonella and Escherichia coli O157:H7 in ground beef, carcass, hide and faecal (GCHF) samples from cattle. METHODS AND RESULTS: The hydrophobic grid membrane filtration (HGMF) method and the spiral plate count method (SPCM) were evaluated as rapid tools for the estimation of pathogen load using GCHF samples spiked with known levels of Salmonella serotype Typhimurium. Validation studies showed that for a single determination of each sample type the low end of the detection limits were approx. 2.0 x 10(0) CFU g(-1) for ground beef, 5.0 x 10(-1) CFU (100 cm(2))(-1) for Salmonella and 8.0 x 10(-1) CFU (100 cm(2))(-1) for E. coli O157:H7 on carcasses, 4.0 x 10(1) CFU (100 cm(2))(-1) for hide and 2.0 x 10(2) CFU g(-1) for faecal samples. In addition, ground beef (n = 609), carcass (n = 1520) and hide (n = 3038) samples were collected from beef-processing plants and faecal samples (n = 3190) were collected from feed-lot cattle, and these samples were tested for the presence of Salmonella and E. coli O157:H7 by enrichment and enumeration methods. CONCLUSIONS: The direct enumeration methods described here are amenable to high throughput sample processing and were found to be cost-effective alternatives to other enumeration methods for the estimation of Salmonella and E. coli O157:H7, in samples collected during cattle production and beef processing. SIGNIFICANCE AND IMPACT OF THE STUDY: Use of the methods described here would allow for more routine testing and quantification data collection, providing useful information about the effectiveness of beef processing intervention strategies.     

Distribution and sources of microbial contamination on beef carcasses

Three beef dressing lines of different capacity (160, 440 and 800 head d(-1)) were investigated with respect to contamination associated with carcass/hide and carcass/faeces contacts, the distribution of microbial contamination on carcasses and the antimicrobial efficacy of cold water carcass washes. Swab samples were taken from up to 17 sites for determination of Aerobic Plate Counts at 37 degrees C (APC 37 degrees C) and Escherichia coli enumeration using the Petrifilm procedure. The three beef dressing systems produced virtually identical patterns of microbial contamination. High contamination was found at those sites associated with opening cuts and/or subject to hide contact during hide removal. Where contamination is intermittent, the use of mean microbial data tended to obscure evidence of faecal or hide contact. Consequently, worst-case results, as represented by the 95th percentile value, were used to identify probable instances and sources of contact contamination. Sites not subject to faecal contamination or hide contact typically had swab sample APC (37 degrees C) values of less than log 2.00 cfu cm(-2) accompanied by the occasional detection of E. coli at levels below log 1.00 cfu cm(-2). Sites contacted by 'clean' hide typically had APC (37 degrees C) counts of log 3.00 cfu cm(-2) or greater accompanied by occasional E. coli counts not exceeding log 2.00 cfu cm(-2). Sites contaminated by direct faecal contact or contact with faecally contaminated hides typically had APC (37 degrees C) counts equal to, or greater than, log 4.00 cfu cm(-2) accompanied by E. coli counts exceeding log 2.00 cfu cm(-2). Cold water carcass washing was ineffective in removing microbial contamination and tended to bring about a posterior to anterior redistribution, resulting in increased counts at forequarter sites.     

Relationships between the density of different indicator organisms on sheep and beef carcasses and in frozen beef and sheep meat

AIM: To describe the relationship between the concentration of different indicator bacteria in red meat. METHODS AND RESULTS: Enumeration data for aerobic plate count (APC), Enterobacteriaceae, coliforms and Escherichia coli biotype I were analysed from an Australia-wide survey of beef carcasses, sheep carcasses, frozen beef and frozen sheep meat. In all commodities, there was only low-to-moderate rank correlation (0.16-0.47) between concentration of APC and concentration of each Gram-negative indicator. Rank correlations between counts of Gram-negative indicators were much higher (0.47-0.92) especially when nondetections were excluded from analysis (0.78-0.94). Receiver-operator characteristics analysis showed that detection of coliforms can predict the presence of E. coli biotype I with almost 100% sensitivity but fails to predict absence in 2.7-8.5% of samples not containing E. coli biotype I. CONCLUSIONS: Enumeration of coliforms is a useful adjunct to enumeration of E. coli biotype I or Enterobacteriaceae in red meat. The density of coliforms or Enterobacteriaceae can be used to predict the presence or absence of E. coli biotype I, although when the latter is at low prevalence errors in positive test prediction can be large. SIGNIFICANCE AND IMPACT OF THE STUDY: A quantitative basis is provided for comparing the concentration of different indicator bacteria measured in the production, regulation and trade of red meat.     

Phenotypic and molecular typing of Salmonella strains reveals different contamination sources in two commercial pig slaughterhouses

This study aimed to define the origin of Salmonella contamination on swine carcasses and the distribution of Salmonella serotypes in two commercial slaughterhouses during normal activity. Salmonellae were isolated from carcasses, from colons and mesenteric lymph nodes of individual pigs, and from the slaughterhouse environment. All strains were serotyped; Salmonella enterica serotype Typhimurium and Salmonella enterica serotype Derby isolates were additionally typed beyond the serotype level by pulsed-field gel electrophoresis (PFGE) and antibiotic resistance profiling (ARP); and a subset of 31 serotype Typhimurium strains were additionally phage typed. PFGE and ARP had the same discriminative possibility. Phage typing in combination with PFGE could give extra information for some strains. In one slaughterhouse, 21% of the carcasses were contaminated, reflecting a correlation with the delivery of infected pigs. Carcass contamination did not result only from infection of the corresponding pig; only 25% of the positive carcasses were contaminated with the same serotype or genotype found in the corresponding feces or mesenteric lymph nodes. In the other slaughterhouse, 70% of the carcasses were contaminated, and only in 4% was the same genotype or serotype detected as in the feces of the corresponding pigs. The other positive carcasses in both slaughterhouses were contaminated by genotypes present in the feces or lymph nodes of pigs slaughtered earlier that day or from dispersed sources in the environment. In slaughterhouses, complex contamination cycles may be present, resulting in the isolation of many different genotypes circulating in the environment due to the supply of positive animals and in the contamination of carcasses, probably through aerosols.