Simultaneous occurrence of mycotoxins in human food commodities from Cameroon

Eighty-two samples of dried food commodities from Cameroon were screened and quantified for different mycotoxins, including fumonisin B₁ (FB₁), zearalenone (ZEA), deoxynivalenol (DON), aflatoxin (AF) and ochratoxin A (OTA), by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC), respectively. The percentage of positive samples was as follows: FB₁ 41%, AF 51%, ZEA 57%, DON 65% and OTA 3%. High FB₁ contents were found in maize, averaging 3,684 μg/kg (range: 37-24,225 μg/kg), whereas the highest average ZEA level was found in peanuts (70 μg/kg), followed by maize (69 μg/kg), rice (67 μg/kg) and beans (48 μg/kg) with no ZEA was detected in soybeans. DON contents were low, ranging from 13 to 273 μg/kg, and for AF the average content was 2.6 μg/kg with peanuts and maize as principal substrates. The incidence of OTA was low, with a mean level of 6.4 μg/kg recorded. The majority (79%) of samples contained more than one mycotoxin and the most frequent co-occurrence found was FB₁ + ZEA + DON, detected in 21% of samples (mainly maize) analysed. Co-contamination with FB₁ + ZEA + DON + AF was found in 11% of the samples. Although a large proportion of samples had fairly low levels of individual mycotoxins, this should be of concern as the co-occurrence of mycotoxins may generate additive or synergistic effect in humans, especially if the respective commodities are consumed almost on a daily basis.     

Co-occurrence of mycotoxins in swine feed produced in Portugal

A total of 404 samples of commercial swine feed from Portugal feed mills were analysed by HPLC methods for the presence of mycotoxins: 277 samples of feed for fattening pigs were analysed for ochratoxin A (OTA), zearalenone (ZEA), and deoxynivalenol (DON), and 127 samples of feed for sows were analysed for ZEA and fumonisins (FB₁ + FB₂). Concerning feed for fattening pigs, 21 (7.6%) samples were positive for OTA, (2–6.8 μg/kg), 69 (24.9%) were positive for ZEA (5–73 μg/kg), and 47 (16.9%) were positive for DON (100–864 μg/kg). In feed for sows, the results showed 29.9% of positive samples for ZEA (5–57.7 μg/kg) and 8.7% positive samples for FB₁ and FB₂ (50–391.4 μg/kg). Co-occurrence of DON/ZEA was found most frequently, but simultaneous contamination with OTA/ZEA and OTA/DON was also found.     

Natural multi-occurrence of mycotoxins in rice from Niger State,Nigeria

Twenty-one rice samples from field (ten), store (six) and market (five) from the traditional rice-growing areas of Niger State, Nigeria were analysed for aflatoxins (AFs), ochratoxin A (OTA), zearalenone (ZEA), deoxynivalenol (DON), fumonisin B₁ (FB₁) and B₂ (FB₂), and patulin (PAT) by thin-layer chromatography (TLC) and high-performance liquid chromatography (HPLC) respectively. T-2 toxin was determined using TLC only. AFs were detected in all samples, at total AF concentrations of 28–372 μg/kg. OTA was found in 66.7% of the samples, also at high concentrations (134–341 μg/kg) that have to be considered as critical levels in aspects of nephrotoxicity. ZEA (53.4%), DON (23.8), FB₁ (14.3%) and FB₂ (4.8%) were also found in rice, although at relatively low levels. T-2 toxin was qualitatively detected by TLC in only one sample. Co-contamination with AFs, OTA, and ZEA was very common, and up to five mycotoxins were detected in a single sample. The high AF and OTA levels as found in rice in this study are regarded as unsafe, and multi-occurrences of mycotoxins in the rice samples with possible additive or synergistic toxic effects in consumers raise concern with respect to public health.     

Mycotoxins in horse feed

A total of 62 samples of commercial horse feed preparations (complementary feeds) containing cereal mixtures (“muesli” or mash, n = 39; pelleted feeds, n = 12), and plain horse feed grains (maize, n = 5; oats, n = 4; barley, n = 2) were purchased from 21 different producers/distributors from the German market. All samples were analysed by competitive enzyme immunoassays (EIA) for six different mycotoxins (mycotoxin groups). Analytes (detection limit, mean recovery) were: deoxynivalenol (DON, 10 μg/kg, 84%), zearalenone (ZEA, 5 μg/kg, 93%), fumonisin B₁ (FB₁, 2 μg/kg, 113%), T-2 toxin (T-2, 0.1 μg/kg, 71%), sum of T-2 + HT-2 toxin (T-2/HT2, 0.2 μg/kg, 97%), ochratoxin A (OTA, 0.2 μg/kg, 67%), and total ergot alkaloids (Generic Ergot Alkaloids “GEA”, 30 μg/kg, 132%). All samples contained DON (16–4,900 μg/kg, median 220 μg/kg), T-2/HT-2 (0.8–230 μg/kg, median 24 μg/kg), and T-2 (0.3–91 μg/kg, median 7 μg/kg). ZEA was detected in 98% of the samples (7–310 μg/kg, median 61 μg/kg). Most samples (94%) were positive for FB₁ (2–2,200 μg/kg, median 27 μg/kg). Ergot alkaloids were detected in 61% of samples (28–1,200 μg/kg, median 97 μg/kg), OTA was found in 42% of samples (0.2–4 μg/kg, median 0.35 μg/kg). The results demonstrate that a co-contamination with several mycotoxins is very common in commercial horse feed from the German market. The toxin concentrations were in most cases well below the levels which are usually considered as critical or even toxic. The highest mycotoxin concentrations were mostly found in single-grain cereal feed: the maximum values for DON and FB₁ were found in maize, the highest T-2/HT-2 toxin concentrations were found in oats, and the highest concentration of ergot alkaloids was found in barley. In composed feeds, no correlation between cereal composition and mycotoxin levels could be found.     

Untersuchungen zur Tiergesundheit,Leistung und zum Rückstandsverhalten beim Schwein bei gleichzeitiger Aufnahme der Mykotoxine Ochratoxin A,Deoxynivalenol, Zearalenon über das Futter im 90-Tage-Test

The effect of the administration of the mycotoxins OTA, ZEA and DON alone resp. in combination on animal health and the residue behavior of pigs from 50 – 60 kg living weight over 90 days was investigated in 4 separate studies. Due to its fast metabolisation the administration of 1000 µg DON resp. 250 µg ZEA per kg feed alone or in combination with other mycotoxins does not lead to detectable residues of these mycotoxins in organs and tissues. Therefore these mycotoxins should not be relevant to the consumer.There is an effect of the simultaneous administration of ZEA resp. DON on the metabolisation resp. secretion of OTA. OTA is of relevance from the point of view of residue toxicology.     

Mould and mycotoxin contamination of pig feed in northwest Croatia

The aim of this study was to investigate the contamination of pig feed with moulds and the occurrence of mycotoxins. A total of 30 feed samples were collected at different animal feed factories in the north-western part of Croatia. Mycological analysis showed that the total number of moulds ranged from 1?×?10³ to 1?×?10⁵?cfu/g with samples contaminated with Aspergillus spp. (63?%), Penicillium spp. (80?%), and Fusarium spp. (77?%). A determination of aflatoxin B1 (AFB₁), ochratoxin A (OTA), zearalenone (ZEA), deoxynivalenol (DON), T-2 toxin (T-2) and fumonisin (FUM) concentration was done using the validated ELISA method. The mean concentrations of AFB₁ (0.5?±?0.6???g/kg), OTA (1.53?±?0.42???g/kg) and FUM (405?±?298???g/kg) were below the maximum levels or recommended values in the EU in all the investigated samples. The observed results indicated an increased contamination of pig feed with Fusarium mycotoxins DON and ZEA with mean concentrations of 817?±?447 and 184?±?214???g/kg, higher than recommended in 40 and 17?% of the analysed samples, respectively.     

Preliminary exposure assessment of deoxynivalenol and patulin in South Africa

Deoxynivalenol (DON) and patulin (PAT) are mycotoxins widely regulated internationally. DON is frequently found in cereals, whereas PAT is commonly found in apple juices. A survey of South African commercial products was conducted on DON levels in maize meal and wheat flours, and on PAT levels in apple juices. DON levels in 23 wheat flour samples (mean of 16 positives, 29 μg/kg) were equal to or below 100 μg/kg and in wheat consumers contributed 6–13% of the provisional maximum tolerable daily intake (PMTDI; 1 μg/kg body weight per day) for DON set by the Joint FAO/WHO Expert Committee on Food Additives (JECFA). Sixteen of 18 maize meal samples were contaminated, with a mean for positive samples of 294 μg/kg, and the probable daily intakes ranged from 3.67 μg/kg body weight per day in rural infants to 1.39 μg/kg body weight per day in urban adults. PAT levels in 20 of 30 apple-juice samples were below the detection level of 10 μg/l. Mean of positive samples was 210 μg/l, with three samples exceeding the South African legal limit of 50 μg/l and the highest level (1,650 μg/l) showing the possibility of a brief but high exposure of 37 μg/kg body weight per day (or 9,250% of the JECFA PMTDI of 0.4 μg/kg body weight per day) in young children.     

Occurrence of deoxynivalenol (DON) and ochratoxin A (OTA) in dog foods

The commercially available dog food samples (29 dry foods and 11 wet foods) were analysed for deoxynivalenol (DON) and ochratoxin A (OTA) using ELISA. All (100%) dry foods were contaminated with DON with various amount of the toxin (22-1837 μg/kg). In wet food 3 samples were found to be positive for DON in the range of 95-170 μg/kg. There were a few samples contaminated with OTA: 3 samples in dry foods (7-40 μg/kg) and 2 samples in wet foods (45 and 115 μg/kg).     

<Emphasis Type="Italic">Fusarium</Emphasis> toxins in cereals of integrated and organic cultivation from the Federal State of Brandenburg (Germany) harvested in the years 2000–2007

Over a period of 8 years (2000–2007), wheat (n = 407) and rye (n = 510) samples of integrated and organic cultivation in the Federal State of Brandenburg were analyzed by HPLC for the Fusarium toxins deoxynivalenol (DON) and zearalenone (ZEA). In the years 2002 and 2007, the overall contamination level was higher than in the other years. The percentage of DON-positives (>50 μg/kg) varied from 5 to 86%, the median and maximum levels varied from 50 to 380 μg/kg and from 50  to 10,400 μg/kg, respectively. The percentage of ZEA-positives (>3 μg/kg) varied from 2 to 41%, the median and maximum levels varied from 8 to 84 μg/kg and from 10 to 451 μg/kg. In the 8 years of testing, frequency and levels of DON and ZEA were significantly lower in cereals of organic cultivation compared with cereals of integrated cultivation.     

A review on comparative data concerning <Emphasis Type="Italic">Fusarium</Emphasis> mycotoxins in Bt maize and non-Bt isogenic maize

The European corn borer reportedly promotes the infection of maize by Fusarium spp. Stalk and ear rots caused by Fusarium spp. are often related to mycotoxin accumulation in maize kernels. As a result, food and animal feed from maize are more severely contaminated with Fusarium mycotoxins: e.g. fumonisins (FUM), deoxynivalenol (DON) and zearalenone (ZEA). Bt maize is primarily an important potential tool for insect pest protection, both in the European Union and in other countries. Bt maize carrying the Bt genes is highly resistant to European corn borer larval feeding due to Bt toxin (δ toxin) production. Effective measures to combat pests therefore often have a positive side-effect in that they also reduce mycotoxin levels. Comparative analysis was used to the evaluation of the studies dealing with the reduction of Fusarium mycotoxins in Bt maize. Nineteen out of 23 studies on Bt maize came to the conclusion that Bt maize is less contaminated with mycotoxins (FUM, DON, ZEA) than the conventional control variety in each case.     

Mycotoxins in several Polish food products in 2004–2005

In 2004–2005, samples of several selected Polish foods such as cereal products, nuts, dried fruits, coffee and culinary spices collected from Warsaw market and taken from food producers were analyzed on presence of aflatoxin B₁, B₂, G₁, G₂ (AF), ochratoxin A (OTA), zearalenone (ZEA) and deoxynivalenol (DON). After extraction and clean-up of extracts on immunoaffinity columns (IAC), mycotoxin analyses were carried out by HPLC using fluorescence and UV detectors. The concentrations of aflatoxins and ochratoxin A depending on the kind of sample ranged from 0.02 to 7.8 (one sample, of peanuts) and 0.02–11.9 μg/kg (one coffee sample), respectively. The levels of ZEA and DON were found to be below 50 °g/kg.     

Airborne mycotoxins in dust from grain elevators

Workers in grain elevators are exposed to grain dust and may therefore have an increased risk of inhalatory contact with mycotoxins. To study the mycotoxin burden of such environments, settled grain dust samples (n=35) were collected from several locations of a total of 13 grain elevators in Germany, and analysed for ochratoxin A (OTA, detection limit 0.01 ng/g), deoxynivalenol (DON, detection limit 15 ng/g), and zearalenone (ZEA, detection limit 6 ng/g), respectively. Cytotoxicity of these samples was assessed by a MTT bioassay with a swine kidney target cell line. Additionally, the airborne dust concentration of these locations was determined. Nearly all settled dust samples contained OTA (96%), DON (100%), and ZEA (100%) with median concentrations of 0.4 ng/g, 416 ng/g, and 126 ng/g, respectively. Cytotoxic effects in varying degrees from weakly to highly toxic were caused by crude extracts of 86% of the dust samples. However, cytotoxicity did not correlate with mycotoxin levels in these samples and thus indicated the presence of cytotoxic compounds of unknown origin. Based on the mycotoxin findings in settled dust samples and the airborne dust concentrations, the average airborne mycotoxin concentrations were estimated to be 0.002 ng/m³ (OTA), 2 ng/m³ (DON), and 1 ng/m³ (ZEA), respectively. The relevance of these findings for occupational health was assessed by comparison with WHO recommendations for the maximum tolerable daily (oral) intake (TDI). Even in a worst case scenario, the calculated inhalatory intake was far below the TDI values. However, considering the uncertainties resulting from different exposure pathways, namely oral ingestion versus inhalation, further research should primarily address the problem of how adequate assessment criteria for airborne exposure to mycotoxins could be established. Presented at the 28^th Mykotoxin-Workshop, Bydgoszcz, Poland, May 29–31, 2006     

Use of enzyme-linked immunosorbent assay to screen for aflatoxins,ochratoxin A,and deoxynivalenol in dry pet foods

The objective of this study was to perform a market survey on dry pet foods using enzyme-linked immunosorbent assay (ELISA) to detect total aflatoxins (AFs), ochratoxin A (OTA), and deoxynivalenol (DON). Pet food products (n?=?58) marketed for dogs, cats, birds, and rabbits were tested in duplicate with ELISA, and results above the limit of quantitation were confirmed using liquid chromatography tandem mass spectrometry (LC-MS/MS). OTA was detected in one product (rabbit food) and AFs were detected in two products (one dog treat and one bird treat). In contrast, DON was detected in the majority (74%) of products tested. Bird and rabbit products were the most affected by DON, with levels above 0.5 μg/g in 50 and 80% of samples, respectively. One rabbit sample tested positive for both OTA and DON. Overall, the findings of this study revealed a low incidence of AFs and OTA in commercial pet food. Although DON was detected in numerous products, the levels were well below those associated with acute toxic effects.     

Zearalenone,deoxynivalenol and aflatoxin B<Subscript>1</Subscript> and their metabolites in pig urine as biomarkers for mycotoxin exposure

Methods to determine zearalenone (ZEA), deoxynivalenol (DON), aflatoxins (AF) and their metabolites in pig urine were developed as biomarkers for pig exposure to the mycotoxins in feed. Urine samples were incubated with β-glucuronidase to cleave conjugates, extracted and cleaned-up with solid phase and immunoaffinity columns, followed by HPLC with UV and fluorescence detection. Good recoveries (83–130%), low variation (2–10%), and low detection limits (0.3–9.9 ng/ml) were obtained. The results of controlled AFB₁ feeding trials found no difference in urine concentrations of AFB₁ or AFM₁ from pigs fed three different levels (127, 227, 327 μg/kg) of AFB₁ in diets. The excretion of AFB₁ and AFM₁ in urine was on average 30% of the oral dose and the ratio AFB₁ to AFM₁ was around 23%. The analysis of 15 Vietnamese pig urine samples indicate a relatively high exposure of ZEA, DON and AF, which were found as toxin or metabolites in 47, 73, and 80% of the urine samples, respectively.     

Single laboratory evaluation of a planar waveguide-based system for a simple simultaneous analysis of four mycotoxins in wheat

The accuracy and precision of a commercially available system based on an indirect competitive immunoassay and planar waveguide technology was evaluated for the analysis of deoxynivalenol (DON), ochratoxin A (OTA), zearalenone (ZEAR), and T-2 toxin in wheat. The system generally performed well at the tested concentrations that were close to the regulatory limits of DON and OTA in wheat. The mean percent recovery of OTA from certified and in-house reference materials ranged from 90 to 111 %, with a relative standard deviation of 8–16 % (at 4.2, 4.9, and 7.0 μg/kg). Mean percent recoveries of DON ranged from 75 to 103 %, with a relative standard deviation of 14–20 % (at 610, 940, and 1300 μg/kg). As analyte concentrations approached the lower limits of the working range of 3 μg/kg OTA and 400 μg/kg DON, the mean percent recoveries and relative standard deviation increased for both DON and OTA. A lack of reference materials precluded a thorough evaluation of the method for the analysis of ZEAR and T-2. The particular strength of the technology was that multiple mycotoxins were analyzed simultaneously.     

Deoxynivalenol (DON) in hartweizen

Deoxynivalenol (DON) in Durum Wheat High contamination levels of deoxynivalenol (DON) were found during an investigation of noodles in 2001 and initiated an additional survey of Durum wheat used as raw material for these products. Analyses of 53 samples of Durum wheat by HPLC revealed 89% positives and a median concentration of 790 ug/kg, which clearly exceeded the EU action level of 500 μg/kg. Based on these findings, producers increased quality controls on Durum wheat. In 2002 a total of 60 samples were analysed and 85% positives found. The median, however, lay at 215 μg/kg, below a probable maximum level of 500 μg/kg and demonstrated the positive efforts of food producers to decrease the contamination levels of DON in pasta products.     

Mycotoxins in foods in Lower Saxony (Germany): results of official control analyses performed in 2009

In this presentation, the mycotoxin levels—as analysed by the analytical centre for mycotoxin surveillance of the state food laboratory (LAVES Braunschweig)—for approximately 500 food samples are reported. The samples were collected in the year 2009 at retail in the German federal state of Lower Saxony. Aflatoxin and ochratoxin A were analysed in dried fruits, spices, cereals and tree nuts. Ochratoxin A was detected in all samples of dried vine fruits, at levels up to 8.1 μg/kg. Aflatoxins and ochratoxin A were also found in nutmeg and curry powder: the maximum regulatory levels for aflatoxins were exceeded in 25% of the nutmeg samples. Nearly all samples of basmati rice contained aflatoxins, although at levels below the maximum regulatory level in all but one sample. Aflatoxins were also detected in about 50% of hazelnut samples, in 20% of the samples the maximum levels was exceeded (maximum 23.2 μg/kg). In contrast, aflatoxin contents in pistachios were surprisingly low. Fusarium toxins were analysed in cereals and cereal products such as flour, bread, and pasta. Deoxynivalenol (DON) was the predominant toxin found in these samples: DON was found in about 40% of the samples, although the maximum levels were not exceeded (max. 418 μg/kg). Fumonisins (FBs) and zearalenone (ZEA) were specifically analysed in maize products (snacks, flour and oil). Most of these samples (80%) were positive, but at levels not exceeding the maximum levels. Maximum levels were 98 μg/kg (ZEA) and 577 μg/kg (sum of FB₁ and FB₂). Ergot alkaloids (six major alkaloids) were analysed in rye flour, and approximately 50% were positive. The highest concentration of ergot alkaloids was 1,063 μg/kg; the predominant alkaloids were ergotamine and ergocristine. In conclusion, the results indicate that continuous and efficient control measures for mycotoxins in a wide range of critical foods are necessary to ensure compliance with maximum levels. Although the mycotoxin levels in the vast majority of samples were below maximum levels, year-to-year variation and changes in the production of relevant commodities may result in a different picture in the future.     

Determinatıon of ochratoxin A and total aflatoxin levels in corn samples from Turkey by enzyme-linked immunosorbent assay

Forty-seven samples of corn were collected from various street bazaars and market outlets in different regions of Turkey and total aflatoxin (AF) and ochratoxin A (OTA) levels were determined by enzyme-linked immunosorbent assay (ELISA) following sample preparation. Levels of AF and OTA in corn samples ranged between 1.75–120.3 μg/kg and 1.08–8.57 μg/kg, respectively. Although 53% of the samples analysed had no detectable levels of AF, 4% of similar samples were found to contain AFs above the acceptable limit of 10 μg/kg in Turkey. For OTA, 4% of the corn samples had levels above the acceptable limit (3 μg/kg) in Turkey, with over 43% samples not found to contain this mycotoxin. Although the levels of mycotoxins analysed in this study were not found to be high and the percentage of samples contaminated above permitted limits were low, the importance of overall daily dietary intake should not be underestimated and control of these fungal metabolites in corn must be explored to minimise the hazards they may cause in humans.     

Ochratoxin A in brewer’s yeast used as food supplement

Brewer’s yeasts are rich in vitamins of the B-group and contain other nutritive factors; therefore, they are recommended as valuable food supplements for people with special dietary requirements like pregnant women, children, and adolescents, or for people with high physical activity. Additionally, certain strains of brewer’s yeast are known to be capable of adsorbing xenobiotics such as mycotoxins. Because of that, these yeasts are regarded as having positive effects in food, beverage, and feed technology. Their potential to bind mycotoxins such as ochratoxin A (OTA), however, can subsequently lead to a contamination of such brewer’s yeasts used as food supplements. In the present study, we analyzed 46 samples of brewer’s yeasts for the occurrence of OTA by HPLC with fluorescence detector (HPLC-FLD) and for confirmatory measurements by liquid chromatography-tandem mass spectrometry (LC-MS/MS). Nearly 90 % of the samples were contaminated with OTA, the levels ranging from the limit of detection (LOD, 0.01 μg/kg) to 4.2 μg/kg. The mean and median levels of contamination were 0.49 and 0.27 μg/kg, respectively. Based on these results, the additional weekly OTA exposure by regularly consuming such supplements was assessed. Depending on different subpopulations (adults, children) and levels of contamination used for calculation, the additional OTA intake via brewer’s yeast products ranged from 9.3 % (mean case) to 114 % (worst case) of the published mean weekly OTA intake in Germany (adults 279.3 ng, children 195.3 ng). At present, maximum levels for OTA in nutritional supplements like brewer’s yeast do not exist. Based on our results, however, it is recommended that producers of these dietary supplements should include mycotoxin analyses in ongoing and future self-monitoring programs and in product quality checks.     

A survey of aflatoxins in sesame seeds imported into Khorasan Province, Iran

Sesame seed is one of the main nutrient substances which is used in the food industries of Khorasan Razavi, Iran. Because it is likely that stored sesame seeds are contaminated with mycotoxins, the levels of aflatoxins (AF) in five lots of imported sesame seeds before their distribution to the market were studied during one year. A total of 269 sub-samples were obtained from a total of 9,321 tons of sesame seeds from five importing companies. Aflatoxins at >1 μg/kg were found in 50 % of all samples, but at low levels in most cases, which is illustrated by mean AFB₁ and total AF levels of 1.25?±?3.70 and 1.43?±?4.38 μg/kg, respectively. A few (1.9 %) samples exceeded the National Iranian Standard maximum accepted level for AFB₁ (5 μg/kg) or total AF (15 μg/kg); the maximum total AF level found in one sample was 48 μg/kg. The results indicate that the risk of a violative AF contamination in imported sesame seeds is not negligible but is currently relatively low.