Monitoring pH and dissolved oxygen in mammalian cell culture using optical sensors

Here, we have studied two parameters critical to process control in mammalian cell culture; dissolved oxygen (dO₂) and pH, measured with fluorescent sensors thus allowing the study of the metabolic state of cells in culture without removing or damaging cells during cultivation. Two cell lines, namely, NS0 and CHO were batch-grown in 24-well plates at different serum concentrations with the sensors implemented in the bottom of each well. The data showed a good relationship between the dO₂ and pH data obtained from fluorescent probes and the growth and death characteristics of cells. The method has provided a high throughput on-line multi-parametric analysis of mammalian cell cellular activity.     

Modulation of dissolved oxygen levels in a hypertidal estuary by sediment resuspension

Hyperconcentrated benthic layers, which form during neap tides, recruit much of the fine sediment population of the turbidity maximum of a hypertidal estuary. Measurements of tidal amplitude and suspended solids concentration reveal that resuspension of the hyperconcentrated layers occurs between three and eight tides after neap tides rather than during spring tides (12 to 15 tides after neaps). During these resuspension events, dissolved oxygen levels are reduced but recover by spring tides. Peak solids concentrations and critically depressed dissolved oxygen levels are out of phase with tidal current amplitude. Thus observations close to neap and spring tides do not necessaraly capture the extremes of the envelope of water quality conditions.     

Modulation of fibroblast proliferation by oxygen free radicals.

The major unexplained phenomenon in fibrotic conditions is an increase in replicating fibroblasts. In this report we present evidence that oxygen free radicals can both stimulate and inhibit proliferation of cultured human fibroblasts, and that fibroblasts themselves release superoxide (O2.-) free radicals. Fibroblasts released O2.- in concentrations which stimulated proliferation, a finding confirmed by a dose-dependent inhibition of proliferation by free radical scavengers. Oxygen free radicals released by a host of agents may thus provide a very fast, specific and sensitive trigger for fibroblast proliferation. Prolonged stimulation may result in fibrosis, and agents which inhibit free radical release may have a role in the prevention of fibrosis.     

Serum-independent modulation of hemicyst formation by dissolved oxygen in postconfluent epithelial monolayers

Summary Hemicyst formation is considered a manifestation of either transepithelial solute and fluid movement or secretory activity in culture. This study shows that hemicyst formation in postconfluent monolayers of rhesus monkey kidney (LLC-MK₂) cells is modulated by the dissolved oxygen concentration (P_O2) of the culture medium. Either daily replacement of serum-free medium or displacement of the gas phase with 18% vol/vol O₂ (initial medium P_O2=125 to 135 mm Hg) enhances formation of hemicysts. Use of 30% O₂ (medium P_O2≊175 mm Hg) does not further increase the incidence, but neither 10% O₂ (medium P_O2=90 to 95 mm Hg) nor 1% O₂ (medium P_O2=35 to 50 mm Hg), the approximate range of dissolved oxygen values in blood, supports hemicyst formation unless cultures are gently rocked to disrupt diffusion gradients. Phase photomicrography of living cultures shows that the surface of a turgid hemicyst is furrowed, and cinephoto-micrography reveals that the walls vibrate subtly. When hypoxic conditions (0 to 1% O₂) are introduced this vibration ceases within 2 to 3 h, whereas collapse and disappearance of turgid hemicysts requires 18 to 20 h, seems virtually synchronous, and is reversible. Hemicysts form in a broad osmotic range, and increased electrolyte concentration increases the incidence. Hemicysts persist in localyy dense areas when cell-free strips are etched in the postconfluent monolayer; no DNA synthesis is detected under these conditions, but two-dimensional cell spreading into the denuded area is seen along the edge of the wound. We conclude that the dissolved oxygen supply in the cellular microenvironment modulates functional expression by differentiated kidney epithelial cells in culture and that increased electrolyte concentration also enhances expression of this phenotypic marker.     

The effect of dissolved oxygen tension and the utility of oxygen uptake rate in insect cell culture

Dissolved oxygen tension and oxygen uptake rate are critical parameters in animal cell culture. However, only scarce information of such variables is available for insect cell culture. In this work, the effect of dissolved oxygen tension (DOT) and the utility of on-line oxygen uptake rate (OUR) measurements in monitoring Spodoptera frugiperda (Sf9) cultures were determined. Sf9 cells were grown at constant dissolved oxygen tensions in the range of 0 to 30%. Sf9 metabolism was affected only at DOT below 10%, as no significant differences on specific growth rate, cell concentration, amino acid consumption/production nor carbohydrates consumption rates were found at DOT between 10 and 30%. The specific growth rate and specific oxygen uptake rate followed typical Monod kinetics with respect to DOT. The calculated _max and max were 0.033 h^-1 and 3.82×10^-10 mole cell^-1h^-1, respectively, and the corresponding saturation constants were 1.91 and 1.57%, respectively. In all aerated cultures, lactate was consumed only after glucose and fructose had been exhausted. The yield of lactate increased with decreasing DOT. It is proposed, that an apparent DOT in non-instrumented cultures can be inferred from the lactate yield of bioreactors as a function of DOT. Such a concept, can be a useful and important tool for determining the average dissolved oxygen tension in non-instrumented cultures. It was shown that the dynamic behavior of OUR can be correlated with monosaccharide (fructose and glucose) depletion and viable cell concentration. Accordingly, OUR can have two important applications in insect cell culture: for on-line estimation of viable cells, and as a possible feed-back control variable in automatic strategies of nutrient addition.Abbreviations DOT Dissolved oxygen tension - OUR Oxygen uptake rate - specific oxygen uptake rate - specific growth rate - X_v viable cell concentration - C_L, C^*, and oxygen concentrations in liquid phase, in equilibrium with gas phase, and medium molar concentration, respectively - H Henry's constant - K_La volumetric oxygen transfer coefficient - P_T total pressure - oxygen partial pressure - oxygen molar fraction - i discrete element     

Long-term continuous monitoring of dissolved oxygen in cell culture medium for perfused bioreactors using optical oxygen sensors

For long-term growth of mammalian cells in perfused bioreactors, it is essential to monitor the concentration of dissolved oxygen (DO) present in the culture medium to ascertain the health of the cells. An optical oxygen sensor based on dynamic fluorescent quenching was developed for long-term continuous measurement of DO for NASA-designed rotating perfused bioreactors. Tris(4,7-diphenyl-1,10-phenanthroline) ruthenium(II) chloride is employed as the fluorescent dye indicator. A pulsed, blue LED was chosen as the excitation light source. The sensor can be sterilized using an autoclave. The sensors were tested in a perfused rotating bioreactor supporting a BHK-21 (baby hamster kidney) cell culture over one 28-day, one 43-day, and one 180-day cell runs. The sensors were initially calibrated in sterile phosphate-buffered saline (PBS) against a blood-gas analyzer (BGA), and then used continuously during the entire cell culture without recalibration. In the 180-day cell run, two oxygen sensors were employed; one interfaced at the outlet of the bioreactor and the other at the inlet of the bioreactor. The DO concentrations determined by both sensors were compared with those sampled and measured regularly with the BGA reference. The sensor outputs were found to correlate well with the BGA data throughout the experiment using a single calibration, where the DO of the culture medium varied between 25 and 60 mm Hg at the bioreactor outlet and 80-116 mm Hg at the bioreactor inlet. During all 180 days of culture, the precision and the bias were +/-5.1 mm Hg and -3.8 mm Hg at the bioreactor outlet, and +/- 19 mm Hg and -18 mm Hg at inlet. The sensor dynamic range is between 0 and 200 mm Hg and the response time is less than 1 minute. The resolution of the sensor is 0.1 mm Hg at 50 mm Hg, and 0.25 mm Hg at 130 mm Hg.     

Modulation of proliferation in epidermal keratinocyte cultures by lowered oxygen tension

The modulation of proliferation and differentiation in primary epidermal keratinocyte cultures by lowered gas phase oxygen tensions was studied. Neonatal mouse epidermal keratinocyte cultures were grown in an Heraeus type B 5060 EK/O2 incubator in oxygen tensions between 5% and 15% (within the physiologic range); the oxygen tension of ambient air being 21%. Cell morphology was studied using histochemical stains and electron microscopy. Differentiation was assessed using autoradiography of SDS PAGE gels of six serially extracted cell protein fractions with [3H]leucine as a marker. Autoradiographs using [14C]glucosamine and 32Pi as markers were also assessed as a measure of other cell functions. Proliferation was studied using autoradiography of [3H]thymidine ([3H]TdR) pulse-labeled cultures and [3H]TdR incorporation into isolated DNA fractions. The results of these studies showed that lowering the oxygen tension in the gas phase reversibly inhibited cell proliferation. There was a direct arithmetic relationship between the proliferative rate of the cultures and the oxygen tension. No change in differentiation as defined by [3H]leucine indexing of protein synthesis was seen. Other markers of cell function, such as [14C]glucosamine glycosylation and [32P] phosphorylation of proteins were also unchanged. These results suggest that oxygen tension regulates only proliferation in epidermal keratinocytes. This epidermal response is well adapted to its role in the healing wound, and is an example of a tissue-specific modification of a regulatory function.     

Identification and control of dissolved oxygen in hybridoma cell culture in a shear sensitive environment

The productivity of mammalian cells can be enhanced by facilitating adequate oxygen transfer into the cultivation medium. However, current methods of controlling dissolved oxygen (DO) fail to account for alterations in medium composition during the course of the fermentation. These changes, which directly affect gas solubility and overall mass transfer coefficient, may be significant and deteriorate controller's performance in the long run. In this paper, the applications of Generalized Predictive Controllers (GPC) to DO control were investigated in a shear sensitive environment and compared to PID and Model Predictive Controllers (MPC). Input and output data for system identification were initially generated by varying the composition of oxygen fed into the bioreactor from 0 to 0.21 mol % while keeping the total inlet gas flow rate at 8.75 vvm. The process was identified using an AutoRegressive model with eXogeneous inputs (ARX) model and tested on different data sets. The model parameters were then correlated with the overall mass transfer coefficients. In simulation tests, the output of the PID controller switched from minimum to maximum values while more continuous control signals were obtained with the MPC and GPC controllers. When tested in a cell-free medium, all three controllers were able to track setpoint changes with some chattering observed in the control signals. The GPC outperformed the MPC and PID controllers when applied to the cultivation of hybridoma cells.     

Control of dissolved oxygen concentration in mammalian cell culture using a computer-coupled mass flow controller

Summary A simple proportional control system for dissolved oxygen (DO) concentration in cell culture medium was developed by using a computer-coupled mass flow controller. The DO levels were very stable during the cultivation of Vero-6, while flow rates of air and/or oxygen enriched air were gradually changed depending on the DO concentration and the preset DO level. Vero-6 cells could grow normally to the confluence in the range of 30% and 50% of DO. Growth of Vero-6 at 10% of DO was markedly retarded.     

Modulation of sodium transport in fetal alveolar epithelial cells by oxygen and corticosterone

The involvement of P2Y receptors, which are activated by extracellular nucleotides, in proliferative regulation of human lung epithelial cells is unclear. Here we show that extracellular ATP and UTP stimulate bromodeoxyuridine (BrdU) incorporation into epithelial cell lines. The nucleotide efficacy profile [ATP = ADP > UDP >or= UTP > adenosine >or= 2-methylthioadenosine-5'-diphosphate, with alpha,beta-methylene adenosine 5'-triphosphate, 2',3'-O-(4-benzoylbenzoyl)adenosine 5'-triphosphate, AMP, UMP, and ATPalphaS inactive] and PCR analysis indicate involvement of P2Y2 and P2Y6 receptors. The signal transduction pathway, which, via the P2Y2 receptor, transmits the proliferative activity of ATP or UTP in A549 cells downstream of phospholipase C, depends on Ca2+/calmodulin-dependent protein kinase II and nuclear factor-kappaB, but not on protein kinase C. Signaling does not involve the mitogen-activated protein kinases extracellular signal-regulated kinases-1 and -2, the phosphatidylinositol 3-kinase pathway, or Src kinases. Thus nucleotides regulate proliferation of human lung epithelial cells by a novel pathway. The stimulatory effect of UTP, but not ATP, in A549 cells is attenuated by preincubation with interleukin-1beta and interleukin-6, but not tumor necrosis factor-alpha. This indicates an important role for the pyrimidine-activated P2Y receptor in the inflammatory response of lung epithelia. ATP antagonizes the antiproliferative effect of the anticancer drugs paclitaxel and etoposide, whereas it enhances the activity of cisplatin about fourfold. Thus pathways activated by extracellular nucleotides differentially control proliferation of lung epithelial tumor cells.     

Modulation of trophoblast cell death by oxygen and EGF

BACKGROUND: Preeclampsia, a maternal hypertensive disease, is characterized by shallow invasion of the maternal spiral arterioles resulting in hypoxia/reperfusion type insult; however, the molecular mechanism is unknown. The aim of this study was to determine the mechanism of altered oxygen tension or inhibition of phosphatidyl-inositol-3-kinase (PI3K) on trophoblast survival and to investigate the effect of epidermal growth factor (EGF) on maintaining cellular integrity. MATERIALS AND METHOD: We have used flow cytometry, immunoblotting, and fluoroimmunocytochemistry to study apoptosis in a characterized, spontaneously transformed first trimester extravillous-like trophoblast cell line that exhibits many characteristics of in vivo trophoblast. RESULTS: Time-dependent exposure of first trimester extravillous-like trophoblast to all oxygen tensions tested promoted dissipation of the mitochondrial membrane potential (psi(m)) and resulted in a significant increase in celldeath by 48 hr as determined by dual staining flow cytometry. Western blot analysis revealed expression ofcleaved caspase-3 and caspase-9 increased with time with hypoxia and hyperoxia promoting the greatest elevation indicating that longer duration of exposure to a change inoxygen tension causes increased apoptosis via a mitochondrial-mediated pathway. Disruption of the anti-apoptotic PI3K pathway by LY294002 (40 microM), its specific inhibitor, caused further significant dissipation of the psi(m) (p< 0.01) and cleavage of caspase-3. EGF was able to maintain the psi(m) and to prevent cleavage of caspase-3 even in the presence of LY294002, indicating that its survival effects were independent of the PI3K pathway. CONCLUSIONS: These results suggest that inhibition of the PI3K/Akt pathway can sensitize first-trimester trophoblast-like cells into oxygen-induced cell death and that EGF exerts its anti-apoptotic effect independently of PI3K/Akt.     

Uterine epithelial cells in primary culture: a model system to study cell proliferation

Guinea-pig uterine glandular epithelial cells were grown in primary culture. During the 4-day initial culture period, a 6.7 fold increase in DNA synthesis and a doubling time of approximately 30 hours were observed. Then the cells were submitted to serum depletion (60 hours) and the quiescent cells were stimulated with 15% fetal calf serum (FCS). The control cells were submitted to 1% heated and dextran-coated charcoal stripped FCS. In stimulated cells, the DNA synthesis increased and peaked between the 12th and 24th hour. In these cells, c-fos mRNAs increased rapidly, within 30 min., peaked at 75 min. (ratio to the control = 2.5), and returned to basal level within 90 min. These results prove that uterine epithelial cells in primary culture are able to respond to unspecific mitogen by both rapid expression of c-fos gene and DNA synthesis, suggesting that this cell culture system will be useful in studying the growth regulation in endometrium.     

Regulation of cell proliferation in a stratified culture system of epithelial cells from prostate tissue

Mechanisms controlling epithelial proliferation and differentiation in the prostate have been primarily investigated in mouse models. The regulation of proliferation and differentiation is poorly understood in human prostate epithelial cells. In vivo, the glandular prostate epithelium consists of a p63-positive proliferating basal cell layer and a post-mitotic p27-positive secretory cell layer. We have established an organized stratified culture system of human primary prostate epithelial cells to gain insight into mechanisms regulating proliferation and differentiation. In this system, expression of p63 is observed in the bottom layer. In addition, BrdU incorporation persists even though cells are confluent. In contrast, in the upper layer, p63 expression is greatly diminished, p27 is expressed, and the cells are growth arrested. Overexpression of cyclin D1 or knockdown of p27 does not increase proliferation. After inactivation of the nuclear phosphoprotein Rb, the cell layers remain organized and cell proliferation increases only in the bottom layer. Furthermore, the expression of p63 remains confined to the bottom layer after Rb inactivation. Altogether, this in vitro model recapitulates certain aspects of in vivo growth regulation and differentiation and suggests that the loss of Rb family proteins in human cells trigger hyperplasia but is not sufficient for transformation.This work was supported by the Departments of Pathology and Urology at Weill Medial College, by grants DAMD-17-02-1-0159, MEDC-GR-355, and P30 CA015704-30, and by grant RO1CA84069 to B.E.C.     

Long-term proliferation of mouse thymic epithelial cells in culture

Summary Epithelial cells from the normal mouse thymus were successfully cultivated on tissue culture plastic when plated with lethally irradiated support cells of the LA7 rat mammary tumor line. As the irradiated LA7 cells slowly decreased in number the thymus cells proliferated concomitantly to form a confluent monolayer. The cells now in culture have been subcultured 8 times, have doubled in number at least 30 times, and are still proliferating vigorously. The culture technique also supported clonal growth from a single cell, and nine clones have been isolated. The colony-forming efficiency of thymic cells plated at low concentrations was about 8%. These cultures were never overgrown by fibroblasts. The thymus cells were characterized as epithelial by the presence of cytoplasmic keratin and numerous desmosomes and tonofilaments. They were shown to be mouse cells by immunocytochemistry with species specific antibodies, by isoenzyme analysis, and by karyology. The cells stained when reacted with antibodies to tubulin, vimentin, and actin, but not with antibodies to Thy-1.2, Lyt-1, Lyt-2, Ia, or H-2 proteins. More than 85% of the cells had a normal mouse diploid chromosome number of 40. This culture technique opens the way for future studies of T-cell education with homogeneous thymic epithelial cell populations both in vitro and after reimplantation into genetically defined strains of mice. This work was supported by the Veterans Administration, Washington, D.C.     

Prostate epithelial stem cell culture

The prostate gland is the site of the second most common cancer in men in the UK, with 9,280 deaths recorded in 2000. Another common disease of the prostate is benign prostatic hyperplasia and both conditions are believed to arise as a result of changes in the balance between cell proliferation and differentiation. There are three types of prostatic epithelial cell, proliferative basal, secretory luminal, and neuroendocrine. All three are believed to be derived from a common stem cell through differentiation along different pathways but the mechanisms behind these processes is poorly understood. In particular, there has until recently been very little information about prostate stem cell growth and differentiation. This review will discuss ways of distinguishing these prostate cell types using markers, such as keratins. Methods available for the culture of prostate epithelial cells and for the characterisation of stem cells both in monolayer and three-dimensional models are examined. This revised version was published online in July 2006 with corrections to the Cover Date.     

Redox regulation of proliferation of lens epithelial cells in culture

Both oxidants and antioxidants have been shown to modulate cell proliferation. We studied the effects of hydrogen peroxide and two antioxidants on the rate of proliferation of lens epithelial cells in culture. Hydrogen peroxide at concentrations higher than 32 microM caused a significant inhibition of proliferation. However, in the concentration range of 0.01-0.5 microM, hydrogen peroxide stimulated the rate of proliferation. The effect of hydrogen peroxide was dependent on the amount of cells in an individual culture well, indicating decomposition of hydrogen peroxide by cellular enzymes. In order to eliminate the possibility of decomposition of the dose of hydrogen peroxide given as a bolus, we induced continual production of hydrogen peroxide by adding glucose oxidase to the incubation medium. We found that hydrogen peroxide, generated by 1-50 microU x ml(-1) of glucose oxidase significantly increased the rate of cell proliferation. This effect was most apparent at the beginning of the exponential phase of cellular growth. Glucose oxidase alone (100-500 microU x ml(-1)) did not produce any effect. The effects of pro-oxidative hydrogen peroxide were compared with the effects of two biologically important antioxidants, alpha-tocopherol and retinol. Both antioxidants completely inhibited proliferation at concentrations of 30 microM and higher. In contrast to retinol, the effect of alpha-tocopherol was dependent on the amount of cells, indicating cellular decomposition of alpha-tocopherol. The results document the possibility of redox regulation of cellular proliferation at physiologically relevant reactant concentrations.